2023 Ford F-250 Super Duty

What owners should know

Covers 2023–2026 · 6.7L Power Stroke diesel (standard and high output), 7.3L V8 and 6.8L V8 gas · Updated 2026-10-01

Researched from owner forums and NHTSA complaints and written by Know Your Truck. These are patterns in what owners report, not a guarantee about any particular truck.

Common failures & how to fix them

Parts and video buttons search for your 2023 Ford F-250 Super Duty. Always confirm a part fits using your VIN. Brakes, steering, fuel and airbag work affects your safety, so if you're not sure, have a qualified mechanic do it.

• Rear axle shaft or driveshaft failure

  Dealer (recall)

  Signs: Loss of drive power, or the truck rolling while in Park.

  Fix: Covered by Ford recalls on certain 2023, 2025 and 2026 trucks. Use the parking brake until it's fixed.

  May be covered free by recall 23V595000 / 25V866000 / 26V119000. Check the VIN at nhtsa.gov/recalls.

• Camera, screen and software problems

  Dealer (recall)

  Signs: Blank or frozen backup camera, screen glitches, warning messages.

  Fix: Several Ford recalls fix these with software updates. Ask a dealer to check for all open recalls and updates.

  May be covered free by recall several (check VIN). Check the VIN at nhtsa.gov/recalls.

• Diesel fuel system care

  Easy DIY

  Signs: These trucks still use the CP4-type high-pressure fuel pump.

  Fix: Change both fuel filters on schedule, drain the water separator, and buy fuel from busy stations.

  Shop: fuel filter kit▶ How-to videos

Recalls

A recall doesn't mean a truck still has the problem. Enter the truck's VIN at nhtsa.gov/recalls or ask a dealer to see whether the repair was done.

• Back Over Prevention:Display Function

  Jul 2026 · #26V489000

  Ford Motor Company (Ford) is recalling certain 2021-2023 F-150 and 2023-2026 F-250 SD vehicles equipped with 8-inch SYNC infotainment screens. A software error may cause the rearview camera image to be obstructed by the infotainment home screen menu when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."

  Risk and fix

  Risk: An obstructed rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.

  Fix: The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Interim letters, notifying owners of the safety risk, were mailed August 7, 2026. Additional letters will be sent once the remedy is available, anticipated in September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C37. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 31, 2026.

• Visibility:Windshield Wiper/Washer:Linkages

  Mar 2026 · #26V204000

  Ford Motor Company (Ford) is recalling certain 2021-2023 Lincoln Navigator, Expedition, and 2022-2023 F-250 SD, F-350 SD, F-450 SD, F-550 SD, and F-600 SD vehicles. The windshield wiper arms may break, causing the wipers to fail.

  Risk and fix

  Risk: Windshield wiper failure can reduce visibility, increasing the risk of a crash.

  Fix: Dealers will inspect and replace the wiper arms, as necessary, free of charge. Owner notification letters were mailed August 5, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S24.Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on April 1, 2026.

• Electrical System: Integrated Trailer Brake Control

  Feb 2026 · #26V104000

  Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."

  Risk and fix

  Risk: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.

  Fix: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.

• Fuel System, Gasoline:Delivery:Fuel Pump

  Jul 2025 · #25V455000

  Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco, Explorer, Lincoln Aviator, F-250 SD, F-350 SD, F-450 SD, F-550 SD, 2021-2022 Lincoln Navigator, Mustang, F-150, and 2022 Expedition vehicles. The low-pressure fuel pump may fail, which can result in an engine stall while driving.

  Risk and fix

  Risk: An engine stall increases the risk of a crash.

  Fix: Dealers will replace the low pressure fuel pump on super duty vehicles and update the powertrain control module (PCM) software on all other affected vehicles, free of charge. Owner notification letters were mailed July 27, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S75.

• Back Over Prevention:Software

  May 2025 · #25V315000

  Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco, F-150, 2021-2024 Edge, 2022-2025 Escape, F-250, F-350, F-450, F-550, F-600, 2022-2024 Expedition, 2022-2025 Transit, 2021-2023 Mach-E, 2024 Ranger, Mustang, 2021-2023 Lincoln Nautilus, 2022-2024 Navigator, and 2023-2024 Corsair vehicles. A software error may cause the rearview camera image to delay, freeze, or not display when the vehicle is in reverse.

  Risk and fix

  Risk: A frozen or missing rearview camera image can reduce the driver's view behind the vehicle, increasing the risk of a crash.

  Fix: The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air update, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model and model years. Interim letters notifying owners of the safety risk were mailed on June 26, 2025. Additional letters will be mailed once the final remedy is available on each phase. Owner notification letters were sent on October 8, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S49.

• Visibility:Power Window Devices And Controls

  Mar 2025 · #25V157000

  Ford Motor Company (Ford) is recalling certain 2023 Super Duty F-250 and F-350 vehicles previously repaired incorrectly under recall number 23V-507. The driver and front passenger windows may fail to detect an obstacle while closing and not reverse direction as intended.

  Risk and fix

  Risk: A window that does not automatically reverse when an obstruction is encountered increases the risk of injury.

  Fix: Dealers will update the software, free of charge. Owner notification letters were mailed April 18, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S25.

• Back Over Prevention:Software

  Feb 2025 · #25V134000

  Ford Motor Company (Ford) is recalling certain 2023 F-Super Duty F-250, F-350, and F-450 vehicles previously repaired incorrectly under recall number 23V-573. The default rearview camera image may not be displayed when using the Pro Trailer Hitch Assist feature.

  Risk and fix

  Risk: An incorrect rearview camera image can reduce the driver's view of what is behind the vehicle, increasing the risk of a crash or injury.

  Fix: Dealers will update the Advanced Drive Assistance System (ADAS) module software, free of charge. Owner notification letters were mailed April 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S17.

• Back Over Prevention: Sensing System: Camera

  Oct 2024 · #24V806000

  Ford Motor Company (Ford) is recalling certain 2023-2024 F-250, F-350, and F-450 vehicles. Water may enter the Tailgate Park Assist Sensor Interface Module (TPASIM) and cause the rearview camera image to display intermittently or appear blue or black.

  Risk and fix

  Risk: A rearview camera image that does not display can decrease the driver's visibility, increasing the risk of injury or crash.

  Fix: Dealers will replace the tailgate top camera, wire harness, TPASIM module, and update the Image Processing Module A (IPMA) software, free of charge. Owner notification letters were mailed August 6, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S66.

• Steering:Column

  Dec 2023 · #23V847000

  Ford Motor Company (Ford) is recalling certain 2023 F-150 and Ford SD F250, F350, F450, F550, and F600 vehicles. The steering wheel clock spring may have an insufficient weld, causing a loss of electrical connection to the driver's frontal air bag.

  Risk and fix

  Risk: A deactivated air bag will not deploy during a crash, increasing the risk of injury.

  Fix: Dealers will inspect and replace the clock spring as necessary, free of charge. Owner notification letters were mailed on May 3, 2024. Owners may contact Ford customer service at 1-866-436-7332.

• Power Train:Axle Assembly:Axle Shaft

  Aug 2023 · #23V595000

  Ford Motor Company (Ford) is recalling certain 2023 Super Duty F250 and F350 vehicles equipped with single rear wheels and a 10.5-inch rear axle shaft. The left rear axle shaft may have been improperly heat-treated during manufacturing and may break.

  Risk and fix

  Risk: A broken rear axle shaft can result in a loss of drive power or vehicle rollaway when the vehicle is placed in park. Either of these scenarios can increase the risk of a crash.

  Fix: Dealers will inspect the left rear axle shaft date code and replace the axle shaft as necessary, free of charge. Owner notification letters were mailed October 17, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S49.

• Back Over Prevention:Display Function

  Aug 2023 · #23V573000

  Ford Motor Company (Ford) is recalling certain 2023 F-Super Duty F250, F350, and F450 vehicles equipped with the Pro Trailer Hitch Assist feature. The default rearview camera image may not be displayed when using the Pro Trailer Hitch Assist feature.

  Risk and fix

  Risk: An incorrect rearview camera image can reduce the driver's view of what is behind the vehicle, increasing the risk of a crash or injury.

  Fix: Dealers will update the Advanced Drive Assistance System (ADAS) module software, free of charge. Owner notification letters were mailed December 5, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S46.

• Electrical System: Instrument Cluster/Panel

  Jul 2023 · #23V506000

  Ford Motor Company (Ford) is recalling certain 2023 Escape, Super Duty F-250, Super Duty F-350, Super Duty F-450, and Super Duty F-550 vehicles equipped with a digital instrument panel cluster. The module may have been improperly soldered, preventing the instrument panel from illuminating. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Control and Displays."

  Risk and fix

  Risk: An inoperable instrument panel cannot show critical safety information, such as the speedometer or warning lights, which may increase the risk of a crash.

  Fix: Dealers will replace the module or instrument panel as necessary, free of charge. Owner notification letters were mailed on November 4, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C25.

• Structure:Body:Door

  Jul 2023 · #23V507000

  Ford Motor Company (Ford) is recalling certain 2023 Super Duty F250, F350, F450, and F550 vehicles. If the driver and front passenger door module experiences a low power condition and resets while the window is moving, the anti-pinch function may not detect an obstacle near the top edge and may not automatically reverse direction.

  Risk and fix

  Risk: A window that does not automatically reverse when an obstruction is encountered increases the risk of injury.

  Fix: Dealers will update the software, free of charge. Owner notification letters were mailed August 28, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S37.

• Equipment:Other:Owners/Service/Other Manual

  Jun 2023 · #23V420000

  Ford Motor Company (Ford) is recalling certain 2018-2023 Expedition and Lincoln Navigator vehicles equipped with third-row seating; and 2019-2023 F-Super Duty F-250, F-350, F-450, and F-550 SuperCab vehicles. The owner's manual does not include instructions for adjusting or removing certain head restraints. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 202, "Head Restraints."

  Risk and fix

  Risk: Without instructions, the head restraints may be improperly adjusted, increasing the risk of injury in the event of a crash.

  Fix: Ford will mail the Owner's Manual addendums that describe how to adjust and remove the head restraints for the center seating positions, free of charge. Owner notification letters were mailed July 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C20.

• Equipment:Other:Labels

  May 2023 · #23V379000

  Ford Motor Company (Ford) is recalling certain 2022-2023 Bronco, 2023 Super Duty F-250, and 2019-2023 Ranger vehicles. The Tire and Loading Information (TREAD) label states the incorrect load carrying capacity, which can result in an overloaded vehicle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."

  Risk and fix

  Risk: An overloaded vehicle increases the risk of a crash.

  Fix: Ford will mail a new TREAD label to install over the existing label, free of charge. Owners will also have the option to take their vehicle to a Ford or Lincoln dealer to have the new label installed, free of charge. Owner notification letters were mailed July 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C18.

• Steering:Column

  May 2023 · #23V344000

  Ford Motor Company (Ford) is recalling certain 2023 Super Duty F-250, F-350, and F-450 vehicles. The steering column upper shaft bolts may be missing or improperly tightened, resulting in possible separation of the steering column from the adjoining components.

  Risk and fix

  Risk: A disconnected steering column can result in a loss of steering control, increasing the risk of a crash.

  Fix: Dealers will inspect and tighten the steering column upper shaft coupler bolts, or install any missing bolts, as necessary, free of charge. Owner notification letters were mailed June 1, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S22.

Owner complaints by area

Reports owners filed with NHTSA. They aren't verified, and one complaint can mention more than one area. Tap an area to read the most recent ones.

• Electrical System13

  • Filed Oct 2025

    Speedometer not working correctly analog and digital do no match. Trailer brake and lighting module failure warnings displayed. Both have been looked at by Ford Dealership, twice. You don’t know what is true, you can’t rely on any warning lights as all have proven wrong. I am in the process of 3rd trip in tomorrow to leave the vehicle a few days since it has to be parked on the Ford lot and stored there in order to try to get another speedometer to install to see if it fixes the one problem.

  • Filed Jun 2025

    The contact owns a 2023 Ford F-250 SD. The contact had experienced several electrical failures with the vehicle and the vehicle had been back to the dealer for repairs for more than 70 days. The contact stated that the instrument cluster failed to properly illuminate, and it was difficult to see the information on the instrument cluster. The contact also stated that the front passenger’s side window failed to roll up in one motion. The contact stated that the window would stop halfway up and had to be rolled back down first and then another attempt had to be made to roll the window up for the window to operate as needed. Additionally, the back over prevention and trailer park assists system functions failed to operate as needed. The contact also stated that the back over prevention software failure of the TPASIN module caused the screen to intermittently display a distorted image, a blue screen, or displayed a solid black screen. The contact also stated that the powertrain axle assembly shaft was improperly heat treated during the manufacturing process. Additionally, the vehicle experienced failures with steering column, and the tailgate release function occasionally failed to operate as needed. The vehicle was taken to the local dealer on several occasions and remained with dealer often, for two to three weeks each time. The contact stated that the dealer attempted to assess a diagnostic fee even though the failure was a known failure with the vehicle. The vehicle was not repaired. The manufacturer was notified of the failure on several occasions however, the contact stated that the manufacturer failed to acknowledge the failures or take the vehicle back from when the vehicle was first purchased new. The approximate failure mileage was 500.

  • Filed Jul 2024

    7 Pin Trailer Connector is not transfering power to trailer needs to be repair under warranty vehicle around 17000 miles No rapair was done at Mossy Ford dealer spend 5 days without vehicle Dealership provide me a diagram in order I repleace fuse by myself. no repairs was done problem persist

  • Filed Mar 2024

    there hasn't been an incident per say and these might not be a safety concern. however i would like to list my grievances here just so there's documentation. my radio has some type of glitch where the phone calls get static like its digital, also the mirrors don't fold in all the time when locked with the key fob, the brakes have squeaked since day 1 and the grab handle in the tailgate just slides right out when the steps are pulled out. again i don't think this really qualifies for dangerous

  • Filed Jan 2024

    Air conditioning and heating output on drivers side and passenger side vents swings wildly independent of settings and requires continual manual adjustment or complete airflow/system shutoff. The interior of the cab either bakes or freezes on either side and requires constant operator input to manage. Very unsafe as the driver must continually monitor and adjust looking at the display screen and not the road. Essentially, the same thing as texting continually while navigating all driving situations. Am aware of other 2023 SD Tremor models with the same issue 250-450. No warning lamps no codes present and has been a constant issue since purchased new 6 months ago.

  • Showing the 5 most recent of 13.
• Engine8

  2 involved a fire

  • Filed Feb 2026

    I was on an overpass in the left hand lane doing 40-45mpg getting ready to make a left hand turn on an expressway on ramp. I coasted for just a bit and applied the brakes gently, then a little more. The truck was not slowing down like it should have so I applied alot more brake pedal pressure and it slowed down some then it down shifted several times and the engine was roaring, I'm guessing around 3K rpms or more and pulling me forwards. I put as much pressure as I could on the brake pedal and got it down to 4-5 mph and then as it was almost at a stop, still with the motor roaring, I slammed it into park and turned the key off. The motor turned off thank goodness. I sat there for about 20 seconds or so, luckily no one was behind me, then I turned it on again and it was idling just fine. I crept through the intersection and proceeded down the on ramp at 10mph or so and pulled over. Turned it off again and called the wife and a few friends about it. It ran ok, albeit I was super cautious, to my destination 25 minutes on down the highway. Something freaked out big time in the computer. Had there been traffic or someone in front of me it would have lead to a serious crash.

  • Filed Apr 2025

    As I was driving, the truck stopped running and then under the engine compartment it started on fire and fully engulfed the engine compartment in front half of the truck

  • Filed Apr 2025

    The contact owns a 2023 Ford F-250 SD. The contact stated while driving 78 MPH, the vehicle was not aligned. The contact stated that while the brake pedal was depressed, the vehicle lunged forward and failed to stop intermittently. There were unknown warning lights illuminated, with a smell of smoke coming from the vehicle. On a separate occasion, the vehicle pointed to the left and accelerated independently. The vehicle was then taken to a dealer, but a diagnostic test was pending; however, the contact was informed that the drive line and the engine were rusty. The vehicle was taken to a different dealer, where the contact was informed that the failure was not the same. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 4,500.

  • Filed Oct 2024

    Ford Has yet to update VIN Lists for 24B27 engine update.

  • Filed Sep 2024

    The engine had a life threatening malfunction. Currently, there are arrangements being made to move the truck to my insurance company's property. I'm sure my insurance company would allow and arrange a site visit to inspect the truck. It happened so fast and without warning, we were blessed that we were able to escape the truck without losing our lives or getting severely burned. Anyone who helped or passed by was put at risk due to the fire or possible explosion that could have accrued from the truck fuel tank or trailer propane bottles. The fire inspector and insurance company have conducted there preliminary inspections and are in the process of writing up their reports. There was no warning lamp, message or symptom of a engine problem or failure prior to the engine bursting into flames, but the only warning that accrued after the engine caught fire, was the engine was being shut off.

  • Showing the 5 most recent of 8.
• Power Train7

  • Filed Feb 2026

    I was on an overpass in the left hand lane doing 40-45mpg getting ready to make a left hand turn on an expressway on ramp. I coasted for just a bit and applied the brakes gently, then a little more. The truck was not slowing down like it should have so I applied alot more brake pedal pressure and it slowed down some then it down shifted several times and the engine was roaring, I'm guessing around 3K rpms or more and pulling me forwards. I put as much pressure as I could on the brake pedal and got it down to 4-5 mph and then as it was almost at a stop, still with the motor roaring, I slammed it into park and turned the key off. The motor turned off thank goodness. I sat there for about 20 seconds or so, luckily no one was behind me, then I turned it on again and it was idling just fine. I crept through the intersection and proceeded down the on ramp at 10mph or so and pulled over. Turned it off again and called the wife and a few friends about it. It ran ok, albeit I was super cautious, to my destination 25 minutes on down the highway. Something freaked out big time in the computer. Had there been traffic or someone in front of me it would have lead to a serious crash.

  • Filed May 2025

    When shifting into drive from reverse it will shift very hard into drive. This happens about 4 times a month and it is very forceful. Suspension is very ruff. Very different from other Ford trucks I driven. Rear suspension makes a noise going over bumps and dips.

  • Filed Oct 2024

    Ford Has yet to update VIN Lists for 24B27 engine update.

  • Filed Sep 2024

    What component or system failed or malfunctioned, and is it available for inspection upon request? The Variable Displacement Oil Pump delivers oil to the engine at low pressure/capacity during idle conditions. Routine occurrences of prolonged idle time may result in excess wear to the engine camshaft lobes and valve tappet surfaces due to reduced lubrication. Overtime, the engine may progressively run rough due to cylinder misfire. Additionally, customers may hear engine tapping noises and the Check Engine Light may illuminate. This causes delamination of the lifters and camshaft which sends metal throughout the engine causing total engine failure and this requires a completely new engine. How was your safety or the safety of others put at risk? Beyond the financial implications, A sudden breakdown on a busy road can lead to dangerous situations, putting both me and other drivers at risk. Additionally, driving a vehicle with a compromised engine can result in further damage and potentially cause accidents. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes there are many forums and videos online about this issue in the 7.3 Godzilla engine produced by ford. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? My vehicle is currently at the dealership for repairs which they said they are unable to do so I will be taking it to another dealership next week. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? In my vehicle there was no CEL but in other customers vehicles the CEL will appear if the problem is not caught soon enough.

  • Filed Mar 2024

    I had my truck inspected for this recall on October 26, 2023 and as of today they are telling me that the parts are on backorder so the recall has not been completed. Manufacturer Recall Number23S49 NHTSA Recall Number23V595 Recall StatusRecall Incomplete

  • Showing the 5 most recent of 7.
• Service Brakes7

  1 involved a crash

  • Filed Oct 2025

    Speedometer not working correctly analog and digital do no match. Trailer brake and lighting module failure warnings displayed. Both have been looked at by Ford Dealership, twice. You don’t know what is true, you can’t rely on any warning lights as all have proven wrong. I am in the process of 3rd trip in tomorrow to leave the vehicle a few days since it has to be parked on the Ford lot and stored there in order to try to get another speedometer to install to see if it fixes the one problem.

  • Filed Sep 2025

    On September 16, 2025, while driving my 2023 Ford F-250 Super Duty at approximately 65 mph with cruise control engaged, I pressed the brake pedal to disengage cruise. The cruise control did not disengage. I pressed the brake pedal harder, but the truck did not slow down and maintained speed. There was no ABS activation sound or sensation, and no skid marks were left on the roadway. I struck the rear of a tractor trailer because the vehicle failed to slow down or cancel cruise control. In addition, the airbags did not deploy during the collision. This appears to be a failure of the brake pedal input/cruise disengagement system, braking system, and potentially the airbag system. This is a severe safety defect that could result in serious injury or death.

  • Filed Mar 2024

    there hasn't been an incident per say and these might not be a safety concern. however i would like to list my grievances here just so there's documentation. my radio has some type of glitch where the phone calls get static like its digital, also the mirrors don't fold in all the time when locked with the key fob, the brakes have squeaked since day 1 and the grab handle in the tailgate just slides right out when the steps are pulled out. again i don't think this really qualifies for dangerous

  • Filed Feb 2024

    During the 1st 20 min or so of operation the truck tries to "high idle" when in gear. This forces the operator use excessive brake pressure to keep the vehicle stopped. There have been several times my leg gets tired of holding the brake pedal down so hard the truck will creep forward unintentionally. The brakes grunt due to excessive force trying to keep the truck stopped. The dealer blows it off as normal, saying the truck is doing what its supposed to. I don't think the truck should be allowed to high idle in gear. I am afraid that I am going to accidently roll forward and hit someone. I have driven other 3/4 ton trucks and the ford 7.3 engine this is the only one that does this. I called ford and they said there is nothing to do if the dealership says the truck is operating properly.

  • Filed Dec 2023

    The first time I drove the truck was in stop-and-go traffic. I was behind a semi-truck that was slow rolling in traffic at four miles an hour with a forty-foot gap. I never felt as if the brakes should need to be applied. My new truck began slamming on the brakes for no reason, bringing me to a complete stop. This continued for several miles this was and is very dangerous the car behind me almost rear-ended me every time this happened. I have turned this option off this should be removed from vehicles until it is perfected.

  • Showing the 5 most recent of 7.
• Unknown or Other5

  1 involved a crash

  • Filed Apr 2026

    My Ford brake malfunction when i was applied the brake while towing a UHaul trailer. It locked up and warning light showed up on the dashboard. The trailer got away from my truck, hit the rear of my truck and went on the other side of road and hit an oncoming car

  • Filed Dec 2025

    SCREEN DASHBOARD ( INSTRUMENT CLUSTER) BLANK/BLACK AT STARTUP. OCCURRED DEC 20. DEALER CLOSED AND XMAS HOLIDAY CAUSED INABILTY TO MAKE APPOINTMENT.

  • Filed Oct 2025

    Other because it has to do with the stereo system. The BO Unleashed system. When starting the truck a loud deafening high pitched squeal is produced. My ears ring for 1 hour after this happens. Audio system will not operate at that point until the truck is turned off and restarted.

  • Filed Jul 2024

    7 Pin Trailer Connector is not transfering power to trailer needs to be repair under warranty vehicle around 17000 miles No rapair was done at Mossy Ford dealer spend 5 days without vehicle Dealership provide me a diagram in order I repleace fuse by myself. no repairs was done problem persist

  • Filed Sep 2023

    Front emergency break assistance over sensitive. Have had multiple occasions where the vehicle has locked up in a turn at a busy intersection. It has locked up only while turning left 3 times in intersections and now is doing it in fast food drive through 2 times. I now have it shut off for ky safety. Since the last time I was almost t-boned. Have not been able to bring to dealer yet.

• Forward Collision Avoidance5

  • Filed Dec 2023

    The truck slams to a complete stop with no rhyme or reason. It senses something that doesn't exist. This has happened MANY times... I-76 through Philadelphia during rush hour. Cross Bronx Expressway during rush hour. Route 30 in Magnolia NJ. Has happened in drive-throughs. Driving around town.

  • Filed Dec 2023

    The first time I drove the truck was in stop-and-go traffic. I was behind a semi-truck that was slow rolling in traffic at four miles an hour with a forty-foot gap. I never felt as if the brakes should need to be applied. My new truck began slamming on the brakes for no reason, bringing me to a complete stop. This continued for several miles this was and is very dangerous the car behind me almost rear-ended me every time this happened. I have turned this option off this should be removed from vehicles until it is perfected.

  • Filed Sep 2023

    Front emergency break assistance over sensitive. Have had multiple occasions where the vehicle has locked up in a turn at a busy intersection. It has locked up only while turning left 3 times in intersections and now is doing it in fast food drive through 2 times. I now have it shut off for ky safety. Since the last time I was almost t-boned. Have not been able to bring to dealer yet.

  • Filed Sep 2023

    The instrument panel cluster has failed. You can not see how fast you are going, none of the dash is lit up. You are unable to determine if there are any issues going on with the vehicle. The adaptive cruise control and emergency braking system is not working properly. The battery will also not hold a charge. Our safety is at risk as we don't know what is going on with the fuctions of the truck or if it will start. Yes, ford has confirm this problem and issued a recall. The dealership has inspected the vehicle. There were no warnings of the problem before it occurred. The instrument panel and other functions of the vehicle just stopped working. We are in contact regularly with the dealership and Ford. Initially they placed us in a long term rental since the current Truck is not driveable however, they are wanting to terminate that rental and not provided us with the needed vehicle. Currently, there is not a part to fix this issue. This was a vehicle that was purchased brand new and within 6 weeks we experienced this electronic failure. We need Ford to step up and provide a Ford F250 as we purchased until this is fixed.

  • Filed Sep 2023

    MY NEW 2023 F250 SUPER DUTY HAD APPROXIMATELY 540 MILES WHEN I RECEIVED FOLLOWING MESSAGES: 1) PRE-COLLISION ASSIST NOT AVAILABLE 2) SERVICE ADVANCE TRAC 3) ABC OR ABS NOT WORKING FORD SERVICE DID A DIAGNOSIS AND ORDERED AND PUT IN STEERING CONTROL MODULE. FIXED CODES FOR ABOUT 1000 MILES AND CODES HAVE COME BACK. FORD SERVICE DIAGNOSIS ON TWO MORE SEPARATE OCCASIONS HAS NOT FOUND THE PROBLEM AND CODES STILL EXIST. FORD SERVICE WANTS TO DO HARNESS LAY OVER AND REPLACE TWO MAJOR HARNESS AND DO NOT KNOW IF THIS WILL FIX THE ISSUE. I DO NOT WANT A BRAND NEW TRUCK DISSECTED. MAJOR SAFETY ISSUE IF BRAKES ACTIVATE AT NORMAL AND/OR HIGHWAY SPEEDS!!!!!!

• Steering4

  • Filed Jun 2026

    I bought this truck and its got 50000 miles on it and it has a clunking noise c coming from the steering shaft took it to ford to have trailer module recall fixed and had them inspect the noise and they said the whole steering shaft needs replaced and I have co workers with f250s and they have the same noise... something comes apart in steering shaft could cause a wreck and even death... dealer said its a common issue in the f250s they replace the whole shaft to fix the issue!

  • Filed Apr 2024

    The contact owns a 2023 Ford F-250 SD. The contact stated that when the steering wheel was turned to the left, the steering wheel made popping sounds. The vehicle was taken to the dealer. The contact stated that an unknown repair was completed; however, while driving at undisclosed speeds, the vehicle drove over uneven ground and the vehicle was violently shaking. The contact stated that the shaking had worsened, and the vehicle experienced the death wobble. The vehicle was taken to the dealer. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 40,000.

  • Filed Nov 2023

    The steering will not center itself from a full right turn. You must use both hands spinning the steering wheel as fast as you can to keep from running out of the road or hitting parked cars. The truck will turn a circle if you do not steer frantically to get the turn straightened out. This a 2023 Ford F250 with 1300 miles on it. Ford dealer said this is normal, if so, lots of accidents ready to happen are on the road.

  • Filed Sep 2023

    MY NEW 2023 F250 SUPER DUTY HAD APPROXIMATELY 540 MILES WHEN I RECEIVED FOLLOWING MESSAGES: 1) PRE-COLLISION ASSIST NOT AVAILABLE 2) SERVICE ADVANCE TRAC 3) ABC OR ABS NOT WORKING FORD SERVICE DID A DIAGNOSIS AND ORDERED AND PUT IN STEERING CONTROL MODULE. FIXED CODES FOR ABOUT 1000 MILES AND CODES HAVE COME BACK. FORD SERVICE DIAGNOSIS ON TWO MORE SEPARATE OCCASIONS HAS NOT FOUND THE PROBLEM AND CODES STILL EXIST. FORD SERVICE WANTS TO DO HARNESS LAY OVER AND REPLACE TWO MAJOR HARNESS AND DO NOT KNOW IF THIS WILL FIX THE ISSUE. I DO NOT WANT A BRAND NEW TRUCK DISSECTED. MAJOR SAFETY ISSUE IF BRAKES ACTIVATE AT NORMAL AND/OR HIGHWAY SPEEDS!!!!!!

• Vehicle Speed Control4

  1 involved a crash

  • Filed Oct 2025

    Speedometer not working correctly analog and digital do no match. Trailer brake and lighting module failure warnings displayed. Both have been looked at by Ford Dealership, twice. You don’t know what is true, you can’t rely on any warning lights as all have proven wrong. I am in the process of 3rd trip in tomorrow to leave the vehicle a few days since it has to be parked on the Ford lot and stored there in order to try to get another speedometer to install to see if it fixes the one problem.

  • Filed Sep 2025

    On September 16, 2025, while driving my 2023 Ford F-250 Super Duty at approximately 65 mph with cruise control engaged, I pressed the brake pedal to disengage cruise. The cruise control did not disengage. I pressed the brake pedal harder, but the truck did not slow down and maintained speed. There was no ABS activation sound or sensation, and no skid marks were left on the roadway. I struck the rear of a tractor trailer because the vehicle failed to slow down or cancel cruise control. In addition, the airbags did not deploy during the collision. This appears to be a failure of the brake pedal input/cruise disengagement system, braking system, and potentially the airbag system. This is a severe safety defect that could result in serious injury or death.

  • Filed Apr 2025

    The contact owns a 2023 Ford F-250 SD. The contact stated while driving 78 MPH, the vehicle was not aligned. The contact stated that while the brake pedal was depressed, the vehicle lunged forward and failed to stop intermittently. There were unknown warning lights illuminated, with a smell of smoke coming from the vehicle. On a separate occasion, the vehicle pointed to the left and accelerated independently. The vehicle was then taken to a dealer, but a diagnostic test was pending; however, the contact was informed that the drive line and the engine were rusty. The vehicle was taken to a different dealer, where the contact was informed that the failure was not the same. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 4,500.

  • Filed Sep 2023

    Instrument pan is completely out and ford has no fix for it.

• Lane Departure3

  • Filed Oct 2025

    Rear back up camera screen is blue and doesn’t function. Was told by Ford it could be a software issue but isn’t part of the current recall of 2023 F250 super duty

  • Filed Jul 2024

    7 Pin Trailer Connector is not transfering power to trailer needs to be repair under warranty vehicle around 17000 miles No rapair was done at Mossy Ford dealer spend 5 days without vehicle Dealership provide me a diagram in order I repleace fuse by myself. no repairs was done problem persist

  • Filed Dec 2023

    The truck slams to a complete stop with no rhyme or reason. It senses something that doesn't exist. This has happened MANY times... I-76 through Philadelphia during rush hour. Cross Bronx Expressway during rush hour. Route 30 in Magnolia NJ. Has happened in drive-throughs. Driving around town.

• Seat Belts2

  • Filed Mar 2026

    Rear passenger seatbelt came UNSECURED from the rear seat mounting bracket. Unknowingly ENDANGERED my child by becoming dislodged therefore leaving her WITHOUT any restraint mechanism in the event of a crash! The incident happened at evening after hours and NOT been reported to manufacturer, dealership, law enforcement, or any other as of present. There were no warning signs or indicators other than the safety belt just freely coming up into her hand when we parked and she unbuckled.

  • Filed Mar 2025

    I have a safety concern on my 2023 Ford 250 SuperDuty Pickup. The front passenger seatbelt indicator does not engage when a person sits in the seat.   The other 4 seats (front driver & 3 back seats) in the vehicle engage as soon as a person sits in the seat showing the seat red in the on the dash until the seatbelt is engaged and then turns green with a check mark on it.   When a person sits in the front passenger seat the seat does not light up on the dashboard like there is no one sitting in the seat.  Once the seatbelt is clicked in, the seat then turns to green with a check mark and then if the seatbelt is unclicked the seat will turn red. I took the vehicle in to be looked at.  The Ford Dealership put in a new part and it reacted the same way.  They then said that they checked and the seat was working as designed and there was no issue.  I asked them to confirm that the airbags would still engage.  They would not confirm that.  I then called Ford's Hotline with my concerns, they said based on what they could see, the airbags would still engage. I feel that all the seats should react the same way and if a person is sitting in that front seat and doesn't use the seatbelt, the vehicle doesn't recognize that a person is in the seat.  And if so, possibly the airbags do not work.

• Back Over Prevention2

  • Filed Oct 2025

    Rear back up camera screen is blue and doesn’t function. Was told by Ford it could be a software issue but isn’t part of the current recall of 2023 F250 super duty

  • Filed Jun 2025

    The contact owns a 2023 Ford F-250 SD. The contact had experienced several electrical failures with the vehicle and the vehicle had been back to the dealer for repairs for more than 70 days. The contact stated that the instrument cluster failed to properly illuminate, and it was difficult to see the information on the instrument cluster. The contact also stated that the front passenger’s side window failed to roll up in one motion. The contact stated that the window would stop halfway up and had to be rolled back down first and then another attempt had to be made to roll the window up for the window to operate as needed. Additionally, the back over prevention and trailer park assists system functions failed to operate as needed. The contact also stated that the back over prevention software failure of the TPASIN module caused the screen to intermittently display a distorted image, a blue screen, or displayed a solid black screen. The contact also stated that the powertrain axle assembly shaft was improperly heat treated during the manufacturing process. Additionally, the vehicle experienced failures with steering column, and the tailgate release function occasionally failed to operate as needed. The vehicle was taken to the local dealer on several occasions and remained with dealer often, for two to three weeks each time. The contact stated that the dealer attempted to assess a diagnostic fee even though the failure was a known failure with the vehicle. The vehicle was not repaired. The manufacturer was notified of the failure on several occasions however, the contact stated that the manufacturer failed to acknowledge the failures or take the vehicle back from when the vehicle was first purchased new. The approximate failure mileage was 500.

• Air Bags2

  1 involved a crash

  • Filed Sep 2025

    On September 16, 2025, while driving my 2023 Ford F-250 Super Duty at approximately 65 mph with cruise control engaged, I pressed the brake pedal to disengage cruise. The cruise control did not disengage. I pressed the brake pedal harder, but the truck did not slow down and maintained speed. There was no ABS activation sound or sensation, and no skid marks were left on the roadway. I struck the rear of a tractor trailer because the vehicle failed to slow down or cancel cruise control. In addition, the airbags did not deploy during the collision. This appears to be a failure of the brake pedal input/cruise disengagement system, braking system, and potentially the airbag system. This is a severe safety defect that could result in serious injury or death.

  • Filed Mar 2025

    I have a safety concern on my 2023 Ford 250 SuperDuty Pickup. The front passenger seatbelt indicator does not engage when a person sits in the seat.   The other 4 seats (front driver & 3 back seats) in the vehicle engage as soon as a person sits in the seat showing the seat red in the on the dash until the seatbelt is engaged and then turns green with a check mark on it.   When a person sits in the front passenger seat the seat does not light up on the dashboard like there is no one sitting in the seat.  Once the seatbelt is clicked in, the seat then turns to green with a check mark and then if the seatbelt is unclicked the seat will turn red. I took the vehicle in to be looked at.  The Ford Dealership put in a new part and it reacted the same way.  They then said that they checked and the seat was working as designed and there was no issue.  I asked them to confirm that the airbags would still engage.  They would not confirm that.  I then called Ford's Hotline with my concerns, they said based on what they could see, the airbags would still engage. I feel that all the seats should react the same way and if a person is sitting in that front seat and doesn't use the seatbelt, the vehicle doesn't recognize that a person is in the seat.  And if so, possibly the airbags do not work.

• Suspension2

  • Filed May 2025

    When shifting into drive from reverse it will shift very hard into drive. This happens about 4 times a month and it is very forceful. Suspension is very ruff. Very different from other Ford trucks I driven. Rear suspension makes a noise going over bumps and dips.

  • Filed Apr 2024

    The contact owns a 2023 Ford F-250 SD. The contact stated that when the steering wheel was turned to the left, the steering wheel made popping sounds. The vehicle was taken to the dealer. The contact stated that an unknown repair was completed; however, while driving at undisclosed speeds, the vehicle drove over uneven ground and the vehicle was violently shaking. The contact stated that the shaking had worsened, and the vehicle experienced the death wobble. The vehicle was taken to the dealer. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 40,000.

• Fuel/Propulsion System2

  1 involved a fire

  • Filed Apr 2025

    As I was driving, the truck stopped running and then under the engine compartment it started on fire and fully engulfed the engine compartment in front half of the truck

  • Filed Jan 2024

    I’ve been stopped at a stop light and the vehicles starts trying to accelerate on its own. I held the brakes down as hard as a could and the vehicles would start burning rubber on the back tires. This has happened three times.

• Fuel System1

  1 involved a fire

  • Filed Feb 2026

    The contact owned a 2023 Ford F-250 Super Duty. The contact stated that while driving at 35 MPH, the engine seized. The contact was able to coast to the side of the road. The contact exited the vehicle and noticed flames were emitting from under the hood and wheel well. No warning lights were illuminated. The contact did not sustain any injuries. The police and fire department were called to the scene. The fire department extinguished the flames. The contact suspected that the fire started near the fuel pump. The vehicle was towed to a tow yard. The contact attempted to tow the vehicle out of the towing yard, and the towing company refused to release the vehicle to the contact. The manufacturer was notified of the fire and informed the contact that the vehicle was in their possession and was at an unknown location. The insurance company was notified about the fire. The contact stated that it was unclear if the vehicle was insured. The failure mileage was 44,000.

• Diesel1

  1 involved a fire

  • Filed Feb 2026

    The contact owned a 2023 Ford F-250 Super Duty. The contact stated that while driving at 35 MPH, the engine seized. The contact was able to coast to the side of the road. The contact exited the vehicle and noticed flames were emitting from under the hood and wheel well. No warning lights were illuminated. The contact did not sustain any injuries. The police and fire department were called to the scene. The fire department extinguished the flames. The contact suspected that the fire started near the fuel pump. The vehicle was towed to a tow yard. The contact attempted to tow the vehicle out of the towing yard, and the towing company refused to release the vehicle to the contact. The manufacturer was notified of the fire and informed the contact that the vehicle was in their possession and was at an unknown location. The insurance company was notified about the fire. The contact stated that it was unclear if the vehicle was insured. The failure mileage was 44,000.

• Wheels1

  • Filed Nov 2025

    My complaint is with the OEM lug nuts applied on my 2023 Ford F250. I recently tried to check the tightness on my wheels lug nuts only to find out that the lug wrench provided with the vehicle when purchased new will not fit 90 percent of the lug nuts. Dealership has rotated tires at routeen intervals since purchased new in spring 2023. Service manager stated that his mechanics routeenly use the next larger socket to loosen and reapply nuts. They are a carbon steel with chrome cap. Evertime you use the wrong size socket you further distort the chrome cap. The caps are loose and swollen so I can not change out a flat without calling and waiting for roadside assistance. My vehicle is still well within the 36 month 36 thousand mile bumper to bumper warranty. Local service manager states that Ford will not warranty faulty lug nuts. It's a safety issue when the nuts are improperly torqued or over torqued because they are using the wrong size impact socket on an impact wrench. It's a safety issue if I get a flat in an area with no cell service, or stuck on the side of the highway and get rearended. Ford and it's dealerships are aware of the failure of these two piece lugnuts and recommend that I go buy single piece lug nuts from an after market manufacturer like Dorman. This is the second time I have been gooned by Ford on lug nuts, Walmart will refuse service if the required size socket cannot be applied to the lug nuts. Back in 2014 I needed two new tires on my 2010 F150 , local auto zone and they only had 8 nuts in stock but enough to do one flat tire, we were on vacation in Kentucky. Drove home with spare on, we live in Belvidere Illinois. These two piece lug nuts should be outlawed, and using the wrong size sockets should be some kind of code violation, and the correct final torque should be checked with an actual torque wrench, not a best guess setting with your battery impact wrench. My walmarts in Belvidere and Rockford Illinois follow these rules for good reason

• Structure1

  • Filed Jul 2025

    The contact owns a 2023 Ford F-250 SD. The contact stated that while attempting to roll up the front driver's side window, the window partially rolled up. The contact stated that the front passenger's side window had experienced the same failure. There was no warning light illuminated. Additionally, the infotainment system had defaulted to a factory setting independently, causing the Forward Collision Avoidance system and several other safety features to be deactivated. The contact stated that the failures were intermittent. The vehicle was taken to a local dealer however, the failures could not be duplicated. The vehicle was not repaired. The contact related the window failure to NHTSA Campaign Number: 23V507000 (Structure); however, the VIN was not included in the recall. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 1,000.

• Equipment1

  • Filed Jul 2025

    The contact owns a 2023 Ford F-250 SD. The contact stated that while attempting to roll up the front driver's side window, the window partially rolled up. The contact stated that the front passenger's side window had experienced the same failure. There was no warning light illuminated. Additionally, the infotainment system had defaulted to a factory setting independently, causing the Forward Collision Avoidance system and several other safety features to be deactivated. The contact stated that the failures were intermittent. The vehicle was taken to a local dealer however, the failures could not be duplicated. The vehicle was not repaired. The contact related the window failure to NHTSA Campaign Number: 23V507000 (Structure); however, the VIN was not included in the recall. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 1,000.

• Seats1

  • Filed Mar 2025

    I have a safety concern on my 2023 Ford 250 SuperDuty Pickup. The front passenger seatbelt indicator does not engage when a person sits in the seat.   The other 4 seats (front driver & 3 back seats) in the vehicle engage as soon as a person sits in the seat showing the seat red in the on the dash until the seatbelt is engaged and then turns green with a check mark on it.   When a person sits in the front passenger seat the seat does not light up on the dashboard like there is no one sitting in the seat.  Once the seatbelt is clicked in, the seat then turns to green with a check mark and then if the seatbelt is unclicked the seat will turn red. I took the vehicle in to be looked at.  The Ford Dealership put in a new part and it reacted the same way.  They then said that they checked and the seat was working as designed and there was no issue.  I asked them to confirm that the airbags would still engage.  They would not confirm that.  I then called Ford's Hotline with my concerns, they said based on what they could see, the airbags would still engage. I feel that all the seats should react the same way and if a person is sitting in that front seat and doesn't use the seatbelt, the vehicle doesn't recognize that a person is in the seat.  And if so, possibly the airbags do not work.

• Engine And Engine Cooling1

  • Filed Mar 2024

    The contact owns a 2023 Ford F-250. The contact stated that while driving at various speeds, the vehicle hesitated upon depression of the accelerator pedal without warning. The vehicle was taken to the local Ford dealer on numerous occasions where various software updates and maintenance checks were performed on the vehicle; however, the failure persisted after each repair. Recently, the contact stated that while the vehicle was idling, there was an abnormal ticking sound coming from the engine compartment. The contact's friend tested the vehicle by placing the vehicle into park and depressing the accelerator pedal; both the contact and the friend noticed that the vehicle would inch forward despite the vehicle being in park. Both the dealer and the manufacturer were notified of the failure but neither offered any assistance. The manufacturer referred the contact to the NHTSA Hotline. The vehicle was not repaired. The failure mileage was approximately 400.

• Visibility1

  • Filed Jan 2024

    Air conditioning and heating output on drivers side and passenger side vents swings wildly independent of settings and requires continual manual adjustment or complete airflow/system shutoff. The interior of the cab either bakes or freezes on either side and requires constant operator input to manage. Very unsafe as the driver must continually monitor and adjust looking at the display screen and not the road. Essentially, the same thing as texting continually while navigating all driving situations. Am aware of other 2023 SD Tremor models with the same issue 250-450. No warning lamps no codes present and has been a constant issue since purchased new 6 months ago.

Safety ratings

NHTSA 5-Star Safety Ratings from government crash tests. Ratings can differ by cab style and 2WD/4WD.

NHTSA hasn't published star ratings for this truck. Many heavy-duty pickups aren't included in NHTSA's crash-test program, so this doesn't mean the truck is unsafe.