2001 Ford F-250 Super Duty

What owners should know

Covers 1999–2004 · 7.3L and 6.0L Power Stroke diesel, 5.4L V8 and 6.8L V10 gas · Updated 2026-10-01

Researched from owner forums and NHTSA complaints and written by Know Your Truck. These are patterns in what owners report, not a guarantee about any particular truck.

Common failures & how to fix them

Parts and video buttons search for your 2001 Ford F-250 Super Duty. Always confirm a part fits using your VIN. Brakes, steering, fuel and airbag work affects your safety, so if you're not sure, have a qualified mechanic do it.

• 7.3L stalling (cam position sensor)

  Easy DIY

  Signs: Engine cuts out or won't start, the tachometer drops to zero, and power steering and brakes go stiff when it dies.

  Fix: Replace the camshaft position sensor. Owners recommend a genuine Motorcraft sensor. It's a small part on the front of the engine.

  May be covered free by recall 07V553000. Check the VIN at nhtsa.gov/recalls.

  Shop: 7.3 Powerstroke camshaft position sensor▶ How-to videos

• 7.3L rough cold starts or misfire (valve cover harness)

  Moderate DIY

  Signs: Rough running when cold, a miss on one or more cylinders, or glow plug codes.

  Fix: Inspect and replace the under-valve-cover harness (UVCH) and its gaskets, and check glow plugs and connectors.

  Shop: 7.3 Powerstroke under valve cover harness▶ How-to videos

• Spark plug blowout (5.4L / 6.8L gas)

  Hard DIY

  Signs: A loud pop, then a ticking or puffing noise and a misfire. The plug may be sitting loose in the coil.

  Fix: Repair the stripped threads with a thread insert kit made for these heads, often without removing the head. Many owners have a shop do it.

  Shop: Ford Triton spark plug thread repair kit▶ How-to videos

• Cruise control switch fire risk

  Dealer (recall)

  Signs: Often no warning. The switch on the brake master cylinder can overheat and burn.

  Fix: Covered by Ford recalls. A dealer replaces or disconnects the switch for free.

  May be covered free by recall 06V286000 / 09V399000. Check the VIN at nhtsa.gov/recalls.

• Rusted brake lines

  Hard DIY

  Signs: Heavy scale or swelling on the steel lines along the frame, a soft pedal, or a fluid leak.

  Fix: Replace rusted lines with pre-bent lines or copper-nickel line, then bleed the brakes. Do the whole run, not just the bad spot.

  Shop: brake line kit▶ How-to videos

• Worn ball joints and tie rods

  Hard DIY

  Signs: Clunks over bumps, wandering steering, uneven tire wear, or play when you rock a lifted front wheel.

  Fix: Replace worn ball joints and tie rod ends, then get an alignment. Ball joints need a press tool, which many parts stores lend out.

  Shop: ball jointsShop: tie rod end▶ How-to videos

Recalls

A recall doesn't mean a truck still has the problem. Enter the truck's VIN at nhtsa.gov/recalls or ask a dealer to see whether the repair was done.

• Vehicle Speed Control

  Oct 2009 · #09V399000

  FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

  Risk and fix

  Risk: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.

  Fix: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.

• Exterior Lighting:Headlights

  May 2009 · #09E025000

  DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

  Risk and fix

  Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

  Fix: DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.

• Exterior Lighting

  Apr 2009 · #09E012000

  SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

  Risk and fix

  Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

  Fix: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

• Wheels:Hub

  Dec 2007 · #07E106000

  CERTAIN FEDERAL-MOGUL REPLACEMENT WHEEL HUB ASSEMBLIES WITH THE BRAND NAMES: NATIONAL, CARQUEST P/NOS. 515020, 515021, 515025, 515053, 515054, 515059, AND 515060, SHIPPED BETWEEN JANUARY 23, 2006, AND DECEMBER 20, 2007, SOLD FOR LIGHT DUTY AND MEDIUM DUTY TRUCKS. THE INBOARD RETENTION NUT USED TO MAINTAIN HUB BEARING ASSEMBLY CAN LOOSEN RESULTING IN AN ABS LIGHT INDICATION, NOISE, AND/OR WHEEL SEPARATION.

  Risk and fix

  Risk: WHEEL SEPARATION CAN RESULT IN A VEHICLE CRASH.

  Fix: FEDERAL-MOGUL WILL NOTIFY CUSTOMERS AND WILL REPLACE THE HUB ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 7, 2008. OWNERS CAN CONTACT FEDERAL-MOGUL TOLL-FREE AT 877-489-6659.

• Engine And Engine Cooling:Engine:Diesel

  Dec 2007 · #07V553000

  ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH 7.3L DIESEL ENGINES, THE CAMSHAFT POSITION SENSOR LOCATED ON THE ENGINE OF THE VEHICLE MAY FUNCTION INTERMITTENTLY, POSSIBLY RESULTING IN AN ENGINE STALL.

  Risk and fix

  Risk: IN THE EVENT OF AN ENGINE STALL, A CRASH COULD RESULT WITHOUT WARNING.

  Fix: DEALERS WILL INSPECT THE SENSOR AND REPLACE IT WITH AN IMPROVED CAMSHAFT POSITION SENSOR FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 29, 2007. OWNERS MAY CONTACT FORD AT 1-866-436-7332.

• Equipment:Electrical

  Aug 2007 · #07E066000

  CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.

  Risk and fix

  Risk: IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.

  Fix: ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.

• Vehicle Speed Control

  Aug 2006 · #06V286000

  ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.

  Risk and fix

  Risk: OVERHEATING COULD RESULT IN SMOKE OR BURN AND AN UNDERHOOD FIRE.

  Fix: DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 7, 2006. OWNERS MAY CONTACT FORD AT 1-866-436-7332. (NOTE: ALSO SEE RECALLS 05V017 AND 05V388)

• Exterior Lighting:Headlights

  Jun 2006 · #06E052000

  CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

  Risk and fix

  Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

  Fix: SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.

• Exterior Lighting

  May 2006 · #06E049000

  CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

  Risk and fix

  Risk: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

  Fix: CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.

• Exterior Lighting

  Mar 2006 · #06E026000

  CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

  Risk and fix

  Risk: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

  Fix: PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

• Visibility:Windshield Wiper/Washer:Motor

  Aug 2001 · #01V258000

  VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.

  Risk and fix

  Risk: LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.

  Fix: DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.

• Seat Belts:Front:Buckle Assembly

  Jul 2001 · #01V227001

  VEHICLE DESCRIPTION: PASSENGER AND SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND MINIVANS. EQUIPPED WITH SEAT BELTS SUPPLIED BY TRW. IT IS POSSIBLE THAT THE DRIVER'S AND/OR FRONT PASSENGER'S OUTBOARD SEAT BELT BUCKLE MAY NOT FULLY LATCH. FORD CROWN VICTORIA BUILT AT ST. THOMAS ASSEMBLY PLANT FROM 4/17/00 - 5/29/01 MERCURY GRAND MARQUIS BUILT AT ST. THOMAS ASSEMBLY PLANT FROM 4/17/00 - 5/29/01. LINCOLN TOWN CARS BUILT AT WIXOM ASSEMBLY PLANT FROM 3/27/00 - 5/30/01. LINCOLN NAVIGATORS BUILT AT MICHIGAN TRUCK PLANT FROM 4/11/00 - 5/31/01. FORD WINDSTARS BUILT AT OAKVILLE ASSEMBLY PLANT FROM 3/23/00 - 5/30/01. FORD RANGERS BUILT AT TWIN CITIES PLANT FROM 3/28/00 - 5/30/01, AND ALSO AT THE EDISON PLANT FROM 3/13/00 - 5/25/01. FORD F-150 TRUCK BUILT AT NORFOLK PLANT FROM 4/18/00 - 5/25/00; AT ONTARIO PLANT FROM 5/10/00 - 5/28/01; AT KANSAS CITY PLANT FROM 9/11/99 - 5/25/01; AND AT CUAUTITLAN PLANT FROM 5/16/00 - 6/9/01. FORD SUPER DUTY F-250, F-350, F-450, AND F-550 TRUCKS BUILT AT KENTUCKY PLANT FROM 4/17/00 - 5/27/01; AND AT CUAUTITLAN PLANT FROM 5/16/00 - 6/19/01. FORD EXCURSIONS BUILT AT KENTUCKY PLANT FROM 4/17/00 - 10/2/00. FORD EXPEDITIONS BUILT AT MICHIGAN TRUCK PLANT FROM 4/11/00 - 5/31/01.

  Risk and fix

  Risk: IN THE EVENT OF A CRASH, THE RESTRAINT SYSTEM MAY NOT PROVIDE ADEQUATE OCCUPANT PROTECTION, INCREASING THE RISK OF PERSONAL INJURY TO THE SEAT OCCUPANT.

  Fix: DEALERS WILL INSPECT THE FRONT OUTBOARD SEAT BELT BUCKLES AND IF THE BUCKLE FAILS THE INSPECTION PROCESS, IT WILL BE REPLACED. OWNER NOTIFICATION BEGAN JULY 25, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.

• Air Bags:Frontal

  Mar 2001 · #01V082000

  VEHICLE DESCRIPTION: PASSENGER AND SPORT UTILITY VEHICLES. THE INFLATOR CANISTER IN THE DRIVER AIR BAG MODULE MAY HAVE AN INADEQUATE WELD NEAR THE IGNITER.

  Risk and fix

  Risk: IN THE EVENT OF A VEHICLE CRASH, THE DRIVER AIR BAG MAY NOT DEPLOY AS INTENDED, POTENTIALLY RESULTING IN REDUCED OCCUPANT PROTECTION, OR A BURN INJURY.

  Fix: DEALERS WILL INSTALL A DRIVER AIR BAG MODULE. OWNER NOTIFICATION BEGAN MARCH 19, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.

Owner complaints by area

Reports owners filed with NHTSA. They aren't verified, and one complaint can mention more than one area. Tap an area to read the most recent ones.

• Engine And Engine Cooling112

  1 involved a crash · 11 involved a fire

  • Filed Apr 2012

    TL* THE CONTACT OWNS A 2001 FORD F-250 SD. THE CONTACT STATED THAT WHILE ACCELERATING FROM A STOP, SMOKE WAS SEEN COMING FROM UNDER THE FRONT HOOD OF THE VEHICLE. THE DEALER DIAGNOSED THAT THE SPARK PLUG HAD SEPARATED FROM THE ENGINE. THE DEALER REPLACED THE ENGINE NUMEROUS TIMES, BUT THE FAILURE CONTINUOUSLY RECURRED. THE MANUFACTURER WAS NOTIFIED, BUT DENIED ANY ASSISTANCE WITH REPAIRS TO THE VEHICLE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 98,000 AND THE CURRENT MILEAGE WAS 103,000. UPDATED 05/08/12*LJ UPDATED 05/14/12

  • Filed Mar 2012

    SPARK PLUG SPIT FROM MOTOR SMASHING COIL PACK. 5.4 LITER TRITON MOTOR. THIS HAS HAPPENED THREE MORE TIMES. I HAVE LOST FOUR PLUGS TO THIS ENGINEERING DISASTER. AT A COST OF ONE DEALER REPAIR, AND TIME OFF WORK TO REPAIR THE OTHER THREE. ONCE I HAD TO BE TOWED OVER FIFTY MILES. AFTER WHAT I HAVE READ, THEIR SHOULD BE A REMEDY TO THIS PROBLEM. WHY NOT! *TR

  • Filed Feb 2012

    WHILE DRIVING 55 MPH, HEARD A LOAD BANG AND THEN A STEADY POPPING SOUND. AFTER PULLING OFF ROAD TO CHECK PROBLEM OPEN THE HOOD TO SEE THE COIL EXPLODED AND ARCHING AGAINST FUEL RAIL, AND SPARK PLUG ON THE VALVE COVER. GOT THE TRUCK HOME STARTED RESEARCHING THIS ISSUE AND I SEE THIS IS A COMMON PROBLEM YET FORD SAYS IT ISN'T. MY BEST EDUCATED REPAIR SOLUTION IS CAL VAN 38900 FORD 5.4L SPARK PLUG PORT REPAIR KIT AT A COST OF 250 . IT TOOK A DAY AND A HALF TO DO A COMPLETE REPAIR. SEEMS TO BE WORKING BUT FORD HAS A PROBLEM AND SHOULD DO SOMETHING FOR THE OWNERS SHOULD IT HAPPEN. THEY CANT SAY THIS IS A TORQUE ISSUE THIS ARE THE FACTORY PLUGS AND COIL. SO IF THEY TORQUE THEM WRONG AT THE FACTORY. *TR

  • Filed Aug 2011

    WHEN DRIVING AT NORMAL SPEEDS IN A 2001 F-250 SD 5.4 LITER, SLOWED TO MAKE A STOP AND THEN PROCEEDED ON AND THERE WAS A LOUD POP AND THE TRUCK STARTED RUNNING ROUGH AND MAKING A LOT OF NOISE FROM UNDER THE HOOD. IT TURNED OUT THAT A SPARK PLUG HAD BLOWN OUT OF THE CYLINDER WALL CAUSING THE NOISE AND ROUGH RUNNING. THESE PLUGS HAD JUST BEE REPLACED ABOUT 1 YEAR AGO. THE TRUCK HAD TO BE TOWED TO A REPAIR SHOP ALMOST 100 MILES TO BE REPAIRED. FROM WHAT I UNDERSTAND FROM MY MECHANIC THIS IS AN ONGOING PROBLEM WITH THIS ENGINE. *TR

  • Filed Aug 2011

    ON VACATION IN MAINE WITH MY 2001 FORD F250 SUPER DUTY I WAS DRIVING DOWN A VERY NARROW, HEAVILY WOODED TWO LANE ROAD AT ABOUT 20 MPH, SUDDENLY AND WITHOUT WARNING A LOUD BANG UNDER THE HOOD OCCURRED. DIFFICULT TO PULL OVER SAFELY AND INVESTIGATE. I HAD TO DRIVE SEVERAL HUNDRED FEET TO TRY TO GET ON A STRAIGHT AWAY FOR SAFETY. THERE WERE SEVERAL LOG TRUCKS THAT HAD TO PASS AS WELL AS OTHER TRAFFIC. I DISCOVERED THAT THE #6 SPARK PLUG HAD "BLOWN OUT" OF ITS HOLE AND DESTROYED THE THREADS, COIL PACK, AND SPARK PLUG. AFTER GETTING THE TRUCK TO A REPAIR FACILITY THE OWNER/MECHANIC INFORMED ME THAT THIS 5.4L TRITON ENGINE DOES THIS ALL THE TIME. HE INFORMED ME THAT HE REPAIRS TWO OR THREE OF THESE A WEEK, IN FACT THERE IS A "REPAIR KIT" AVAILABLE FROM MOST AUTO PART STORES. DOING SOME RESEARCH AFTER GETTING HOME I DISCOVERED THAT THIS IS A CHRONIC FORD PROBLEM THAT THEY REFUSE TO ADDRESS. I WILL BE SELLING THIS TRUCK BECAUSE IT IS A HUGE SAFETY ISSUE FOR ME. I DON'T NEED TO BE STRANDED ON BACK COUNTRY ROADS OR INTERSTATES WITH ANY OF THE OTHER 7 SPARK PLUGS READY TO LAUNCH FROM MY ENGINE WITHOUT WARNING OR CAUSE. *TR

  • Showing the 5 most recent of 112.
• Tires89

  4 involved a crash

  • Filed Apr 2022

    The contact owns a 2001 Ford F-250 equipped with Toyo tires, Tire Line: HT Open Country, Tire Size: LT265/75/R16, DOT Number: CXLTCAK4815. The contact stated that while driving at an undisclosed speed, the vehicle was shaking and felt like the front tires were bouncing. The contact veered to the side of the road, where he noticed that the tires were deformed. The contact continued to drive. The vehicle was taken to the local dealer where it was diagnosed that the tread belt was separating. The front tires were replaced; however, the failure reoccurred with the rear tires. The vehicle was taken to an independent tire mechanic where the rear tires were replaced under an unknown recall. The contact stated that the failure reoccurred on the front tires. The dealer was notified of the failure. The manufacturer was notified of the failure but did not provide any assistance. The tires were not replaced. The tires were replacement equipment. The tire failure mileage was 30,000. The vehicle failure mileage was approximately 230,000.

  • Filed Jun 2015

    ON SEPTEMBER 12, 2011, A KUMHO ROAD VENTURE AT TIRE, SIZE LT235/85R16, DOT K2ORYD4A3508 (MANUFACTURED AT KUMHO?S BINH DUONG PLANT IN VIETNAM IN THE 35TH WEEK OF 2008) SUFFERED A CATASTROPHIC TREAD SEPARATION, RESULTING IN SEVERE INJURIES TO THE FRONT SEAT PASSENGER OF THE FORD F-250 AND THE DEATH OF HER SON, WHO WAS 32 WEEKS OLD AND STILL IN UTERO. A LAWSUIT HAS BEEN FILED AGAINST KUMHO TIRE CO., INC. AND KUMHO TIRE U.S.A., INC. IN THE UNITED STATES DISTRICT COURT FOR THE DISTRICT OF KANSAS (CASE NO. 2:13-CV-02393-JTM-TJJ). DURING THE DISCOVERY STAGE OF THE CASE, THE PASSENGER RETAINED TROY COTTLES, A RENOWNED TIRE FAILURE EXPERT. AFTER INSPECTING THE SUBJECT TIRE, MR. COTTLES FOUND THE FOLLOWING DEFECTS IN THE SUBJECT TIRE: (1) INADEQUATE BONDING BETWEEN BELTS (TRAPPED AIR/STEAM BLISTER IMPRESSIONS); (2) PREMATURE OXIDATION OF THE BELT SKIMS; (3) BELTING DEFECTS (COINCIDENTAL BELT ENDINGS, IRREGULAR BELT WIRE SPACING, GAPPED BELT SPLICES, DOG-EARED SPLICES, SNAKING, AND SPREAD CABLES); (4) CORD SHADOWS ON THE INNERLINER; (5) LOW TOP BELT WIDTH TO TREAD WIDTH RATIO; AND (6) INADEQUATE APPLICATION OF NYLON CAP PLIES. AS PART OF HIS WORK ON THE CASE, MR. COTTLES TESTED TWO EXEMPLAR KUMHO ROAD VENTURE AT TIRES OF THE SAME SIZE AS THE SUBJECT TIRE THAT WERE ALSO MANUFACTURED AT KUMHO?S VIETNAM PLANT. BOTH OF THOSE TIRES FAILED IN SIDEWALL FAILURE MODE IN APPROXIMATELY 10,000 MILES OR LESS UNDER PROPER LOADS, INFLATIONS, AND SPEEDS THAT WERE MONITORED DAILY. SEE ATTACHED TEST REPORTS AND PHOTOGRAPHS. THIS INFORMATION IS BEING SUBMITTED BY THE ATTORNEYS FOR THE INJURED PASSENGER, AND WITH HER PERMISSION, IN HOPES THAT THIS TIRE (AND THOSE SIMILAR TO IT) WILL BE INVESTIGATED AND RECALLED TO ENSURE NO ONE ELSE IS NEEDLESSLY INJURED OR KILLED AS A RESULT OF THESE DANGEROUS AND DEFECTIVE TIRES....UPDATED 07/30/15 *BF UPDATED 10/23/2017*CN

  • Filed Jun 2014

    TIRE BLOWOUT WITH COMPLETE TREAD SEPARATION WHILE TRAVELING ON INTERSTATE PULLING A HORSE TRAILER. WAS ABLE TO SAFELY PULL TO SHOULDER & CHANGE TIRE FOR SPARE. TREAD DAMAGED TRUCK PANEL, TAILPIPE & BENT FRONT AXLE OF TRAILER. TIRES WERE WELL MAINTAINED AND HAD BEEN CHECKED BEFORE DEPARTURE. TIRES WERE NITTO TERRA GRAPPLER LT 285/75R16 126/123Q LOAD RANGE E. *TR

  • Filed Oct 2012

    TL* THE CONTACT OWNS A 2001 FORD F-250 EQUIPPED WITH MICKEY THOMPSON/BAJA ATZ TIRES, TIRE SIZES 35 * 12.50 R20. THE CONTACT STATED THAT WHILE TRAVELING 70 MPH, THE RIGHT FRONT PASSENGER TIRE BLEW OUT AND CAUSED THE CONTACT TO RUN OFF THE SIDE OF THE ROAD. THE CONTACT WAS NOT INJURED. THE CONTACT STATED THE BELT SEPARATED FROM THE TIRE. THE VEHICLE WAS TOWED TO A REPAIR SHOP. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN NHTSA RECALL CAMPAIGN ID NUMBER:06T024000(TIRES:TREAD/BELT) THE FAILURE AND CURRENT MILEAGE WAS 2360,000. UPDATED 11/19/12 *BF THE CONSUMER STATED THE DISCOUNT TIRE MANAGER REFUSED TO REPLACE THE TIRE OR GIVE A DOCUMENT STATING THERE WAS NO FAILURE WITH THE TIRE. THE MANAGER DID BALANCE THE TIRE BUT WOULD NOT PRINT A RECEIPT FOR THE CUSTOMER. ON 10/15/2012 THE CONSUMER FILED A REPORT WITH COOPER TIRE OVER THE PHONE AND WAS TOLD A PACKAGE WOULD BE SENT OUT. ON 10/30/2012 3 TIRES WERE BALANCED VIBRATING RECURRED. UPDATED 11/20/2012 *JS

  • Filed Sep 2011

    MY THIRD UNIROYAL LIBERATOR TIRE HAS FAILED IN THE SAME MANNER AS THE TWO BEFORE. THIS IS MY THIRD COMPLAINT CONCERNING THESE DEFECTIVE TIRES. THESE TIRES ALL FAILED IN THE SAME EXACT MANNER (TREAD/TIRE SEPARATION) AND ALL WITHIN WEEKS OR MONTHS OF EACH OTHER. THE TREAD PULLED LOOSE FROM THE CARCASS,CAUSING A BUMP-IMBALANCE. I RECOGNIZED THE FAILURE AND WAS ABLE TO DRIVE HOME WHERE I CHANGED TO A SPARE. I LATER REPLACED THIS TIRE. THIS TIRE ONLY HAVE ABOUT 37,000 MILES. WALMART,WHERE I PURCHASED THE TIRES,REFUSES TO GIVE ANY TYPE OF WARRANTY OR TIRE CREDIT AND NO LONGER CARRY THIS TIRE. THIS TIRE HAD PLENTY OF TREAD AND WAS WELL WITHIN ITS LIFE SPAN. THIS LIBERATOR TIRE SHOULD BE RECALLED AND PULLED OFF THE MARKET BECAUSE OF ITS CONSISTENT FAILURE RATE. I HAVE SENT COMPLAINTS TO UNIROYAL WITH NO RESPONSE. PLEASE HAVE A RECALL BEFORE SOMEONE GETS KILLED OR INJURED. THESE THINGS ARE JUNK. *TR

  • Showing the 5 most recent of 89.
• Power Train72

  1 involved a crash · 5 involved a fire

  • Filed Mar 2025

    When im in traffic, starting out driving or merging between intersections my truck decides to either hard shift or not shift at all. Several times ive had to lay on my horn in an attempt to warn oncoming vehicles that i have no power and cannot accelerate and several times it has nearly caused an accident. I purchased the truck used and have yet to take it into the dealership to have them inspect the issue though from what i’ve read thus far is that ford calls this problem “normal operation” and has been less than understanding when people attempt to have this obvious defect resolved. There are no warning lights that come on when this happens. I can have my truck inspected by whomever, whenever need be. I will also be returning to the dealer to use my warranty to help deal with this issue. The date this most recently happened causing a near miss was today, though there has been an occasional but recurring situation almost weekly.

  • Filed May 2018

    PARKED VEHICLE AT MAIN POST OFFICE , REMOVED KEYS, I KNOW THIS BECAUSE IT HAS MY POBOX KEY ON KEY RING. I HOPPED OUT AND STATED TO WALK OFF, THEN I GLANCED A VIEW TO THE RIGHT, AND NOTICED OR THOUGHT I NOTICED, MY TRUCK ROLLING BACKWARDS. IT WAS !!! I CHASED MY TRUCK AND CAUGHT UP TO IT, AND ATTEMPTED HOP IN AND ENGAGE FOOT BRAKE. I AM TO FAT AND SLOW TO DO THAT, SO I THOUGHT QUICKLY, , AH HA, THE EMERGENCY BRAKE . I REACHED DOWN AND LET THE TRUCK ROLL THE ER BRAKE TO MY HAND, AND ENGAGE IT I CALLED THE FORD DEALER, NO KNOW ISSUES LIKE THIS HAS HAPPENED, SO I WAS TOLD. SO MAYBE THIS WAS AN 1 OFF EVENT,,,, RIGHT WRONG SEVERAL MONTH LATER, SAME THING HAPPEN, DIFFERENT LOCATION. ALTHOUGH I CATCH BEFORE I GOT OUT. THIS TIME I TOOK A VIDEO OF THE ROLL BACK, AND THE SNIFTER IN PARK, AND THE KEYS OUT

  • Filed Oct 2017

    PARKED MY TRUCK AT THE POST OFFICE TO RETRIEVE MAIL, GOT OUT AND SHUT DOOR, AND OUT OF THE CORNER OF MY EYE I SAW WHAT I THOUGHT AS MOVEMENT OF MY TRUCK, SO I TURNED AROUND TO SEE MY TRUCK STARTING TO ROLL BACKWARDS , I YELLED WTF, AND STARTED TO CHASE MY TRUCK THROUGH THE PARKING AREA, TRIED TO JUMP IN WHEN I OPENED THE DOOR AND I WAS TO OLD AND FAT TO DO THAT, TRIED PUSH BACK , BUT TRUCK WAS TO HEAVY TO DO THAT, SO I WENT FOR THE PARKING BRAKE PRESSED IT HARD AND FAST AS I COULD, AND THAT WORKED MY TRUCK WAS IN PARK, AS I HAD MY KEYS IN MY HAND. THE PARK LOCK ON THE TRANSMISSION FAILED IN SOME WAY ,ALLOWING TO ROLL LIKE IT WAS IN NEUTRAL

  • Filed Aug 2017

    FOR THE R4100 TRANSMISSION. THE EXTERNAL TRANSMISSION FILTER CAME APART AND DESTROYED MY TRANSMISSION (FORD PART # XC3Z-7B155-BA) DEFINITELY NOT A 30,000 MILE FILTER. NOT MANY PEOPLE KNOW ANYTHING ABOUT THIS,OF WHAT I HAVE FOUND. THERE WAS A EASY 80,000 LEFT IN THE TRANS IF LINES AND OIL PORTS WEREN'T PLUGGED FROM FILTER FIBERS. #2 THE PAINT CANCER (WHITE) IS THERE ANY RECALLS OR HELP WITH THAT?

  • Filed Jan 2015

    THE 2001 F250 I OWN HAS ALWAYS STALLED AT ANY GIVEN TIME. FORD RECALLED THE CAM POSITION SENSOR, I HAD ALREADY CHANGED IT JUST BEFORE RECALL THEN THEY DID AGAIN. THAT NEVER STOPPED IT FROM STALLING, IT ALSO DOESN'T READ WHEN YOU SOMETIMES GO TO TAKE OFF. I'VE CHANGED (THROTTLE SWITCH) THAT DID NOTHING. ALL OF ITS MISHAPS HAS CASED THOUSANDS OF DOLLARS IN REPAIR. ALWAYS BROKE DOWN AND CAN'T MAKE MONEY WHEN IT'S IMPOSSIBLE TO DRIVE TRUCK TIME AFTER TIME. I HAVE BEEN IN SEVERAL CLOSE CALL ACCIDENTS, WHEN I LOSE POWERSTEERING AND ALMOST HAVE CRASHED INTO CARS. I FIGURED OUT THE FUEL TANK FLAKING OFF INSIDE THE TANK COULD BE THE CAUSE. THE TRUCK GETS TERRIBLE FUEL MILEAGE WHEN THIS HAPPENS COSTING A FORTUNE IN WASTED DIESEL FUMES. THAT HAVE BEEN KNOW TO CAUSE BRAIN CANCER, ALSO THE AMOUNT OF POLLUTION FROM NOT RUNNING PROPER. I AM NO FAN OF FORD'S REPAIR SHOP WHEN THEY TELL YOU IN 1983 TO MY FATHER THAT HIS ALMOST BRAND NEW DIESEL NEEDS NEW (SPARK PLUGS) WHEN DIESEL DO NOT EVEN HAVE THEM. I OWN THIS 2001 DIESEL FOR A LONG TIME NOW FOR A LANDSCAPING AND SNOWPLOWING THAT IS OUT OF BUSINESS. IT IS EMBARRASSING FOR IT TO STALL, REV UP SLIPPING TRANSMISSION, HARMING WHOLE DRIVE TRAIN. NEVER KNOWING WHEN I'M COULD BE STRANDED IN NORTHERN MICHIGAN. I HAVE HAD ONE THING AFTER ANOTHER WITH THE FORD I OWN. I HAVE SEEN A LOT OF SAME PROBLEMS PEOPLE ARE COMPLAINING ABOUT. SOUNDS LIKE FORD HAS DONE GOOD AT COVERING UP PROBLEM BY NOT TELLING US IF THEY KNEW. I THOUGHT THE FUEL PROBLEM CAME FROM GAS STATIONS. ONLY THING HELPED ME WAS MOSTLY SAME NEWER STATION, AND TRIED TO KEEP IT FULL HELPED. CAN ANYONE HELP, THESE ARE DANGEROUS SITUATIONS WHEN LIVES DEPEND ON THEM. I'M NOT SURE WHAT TO DO WITH THE TRUCK, I'D LIKE TO SEE IT GO TO SCRAP AT THIS TIME. WITH 277,000 NOT EVEN RUSTED OUT MUCH. IT NEEDS WHOLE DRIVE TRAIN AGAIN, I DON'T WANT THE OILY LEAKING, POLLUTING JUNK ON THE ROAD. *TR

  • Showing the 5 most recent of 72.
• Electrical System51

  1 involved a crash · 18 involved a fire

  • Filed Jul 2020

    WHILE SHOPPING MY F250 TRYED TO BURN DOWN IN PARKING LOT 2ND TIME AT A SCHOOL SOCCER GAME AND 4 THE THIRD TIME RIGHT IN FRONT OF MY HOUSE AND STILL AFTER THOUSANDS IN REPAIRS STILL SAME ISSUE FORD NEEDS TO MAN UP AN ADDRESS THIS SITUATION..... [XXXX] KEY NEVER IN TRUCK ALL THREE TIMES THIS HAS OCCURED REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

  • Filed Sep 2019

    TL* THE CONTACT OWNS A 2001 FORD F-250. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 05V017000 (VEHICLE SPEED CONTROL). WHILE THE VEHICLE WAS PARKED, SMOKE SPONTANEOUSLY EMERGED FROM UNDER THE HOOD AND THE VEHICLE CAUGHT FIRE WITHOUT WARNING. THE CONTACT EXTINGUISHED THE FIRE. THE VEHICLE WAS TAKEN TO BATTLEFIELD FORD COMMERCIAL TRUCK CENTER (8980 MATHIS AVE, MANASSAS, VA 20110, (703) 368-3231) WHO STATED THAT THEY WERE WAITING ON AUTHORIZATION. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. A FIRE REPORT WAS NOT FILED AND THERE WERE NO INJURIES. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 144,840.

  • Filed May 2018

    DRIVING AT NIGHT, TRIED TO USE CRUISE CONTROL (DIDN'T COME ON) THEN OVERDRIVE "ON" BUTTON STARTED FLASHING, THEN SPEEDOMETER BEGAN BOUNCING. LATER TRUCK WOULD NOT GO OFF WHEN KEY WAS TURNED TO OFF POSITION. NEXT DAY A LOW BEEP WAS NOTED. REPAIR SHOP WITH SCANNER SAID IT WAS AN AIRBAG WARNING BEEP. THE FOLLOWING DAY THE HEADLIGHTS CAME ON AT NIGHT ALTHOUGH THE KEY WAS TO THE OFF POSITION AND OUT OF THE TRUCK. SUBSEQUENTLY ALL SYMPTOMS STOPPED AND NORMAL OPERATION RETURNED UNTIL A RAINY DAY. SAME SYMPTOMS. DAY FOLLOWING THAT, NORMAL OPERATION. MECHANIC STATES THAT SYMPTOMS NEED TO BE OCCURRING TO MAKE PROPER DIAGNOSIS.

  • Filed Apr 2016

    THE TRUCK BURST INTO FLAMES WHILE PARKED. IT HAD BEEN SITTING FOR OVER 13 HOURS AT THE TIME OF THE FIRE. IT DESTROYED ONE CAR ON EITHER SIDE OF IT. THE FIRE INVESTIGATOR COULD NOT SAY EXACTLY WHAT CAUSED THE FIRE AT THE TIME, BUT MADE ME AWARE OF A RECALL ON THAT YEAR OF FORD VEHICLES INVOLVING THE SPEED CONTROL SAFETY DEACTIVATION SWITCH. INFORMATION ON THE RECALL SAYS THAT THE WIRE COULD HEAT UP AND CAUSE A FIRE. THE TRUCK ALONG WITH TWO OTHER VEHICLES WERE COMPLETELY DESTROYED IN THE FIRE.

  • Filed Jul 2014

    WHILE I WAS DRIVING ALONG A HILLY, WINDING ROAD THE ENGINE OF MY 2001 F-250 DIESEL 4X4 TRUCK UNEXPECTEDLY SHUT OFF. I LOST STEERING AND BRAKING. THERE WERE NO LIGHTS ON THE DASH. THERE WAS NO PRIOR INDICATION OF ANY PROBLEM WITH THE ENGINE OR ELECTRICAL SYSTEM. I'VE HAD THE TRUCK FOR 12 YEARS AT THE TIME AND NEVER EXPERIENCED ANY PROBLEM LIKE THIS. I WAS VERY FORTUNATE TO HAVE BEEN ABLE TO GET THE TRUCK TO THE ROAD'S SHOULDER. AFTER THE TRUCK STOPPED I PUT THE SHIFT INTO PARK. THE KEY WAS STILL IN THE RUN POSITION. I SIMPLY TURNED IT TO THE START POSITION AND THE ENGINE STARTED RIGHT UP. I TOOK IT IMMEDIATELY TO THE LOCAL FORD DEALER WHO RAN DIAGNOSTICS ON THE TRUCK. THEY FOUND NO INDICATION OF A PROBLEM OTHER THAN ONE BATTERY'S VOLTAGE WAS SLIGHTLY LOW, BUT NOT OUT OF ACCEPTABLE RANGE. I REPLACED BOTH BATTERIES AS THEY WERE ALMOST 3 YEARS OLD. SO FAR, I'VE NOT EXPERIENCED THIS PROBLEM AGAIN. *JS

  • Showing the 5 most recent of 51.
• Steering43

  2 involved a crash · 1 involved a fire

  • Filed Apr 2020

    SPARK PLUGS KEEP BLOWING OUT OF THE ENGINE, WHILE ACCELERATING, HAS DONE FIVE TIMES,, WHEN IT DOES VEHICLE STALLED POSSIBLY CARE CAUSE AN ACCIDENT, ALMOST GOT HIT BY A TRUCK TRYING TO TURN,

  • Filed Jan 2019

    TWICE IN THE LAST 5 YEARS I HAVE EXPERIENCED TOTAL STEERING LOSS WHILE DRIVING FORD F-250 V10 TRITON PICKUP TRUCK, I AM FORTUNATE TO BE ALIVE, BOTH TIMES THE CONNECTION TO THE STEERING BOX BROKE. THERE HAVE BEEN NO AFTERMARKET MODIFICATIONS DONE TO THIS TRUCK. VERY SERIOUS ISSUE! TRUCK IS IN THE SHOP NOW FOLLOWING MOST RECENT FAILURE. I FEAR THINKING ABOUT THE CONSEQUENCES HAD EITHER OF THESE TWO FAILURES OCCURRED AT HIGH SPEED

  • Filed Nov 2018

    TL* THE CONTACT OWNS A 2001 FORD F-250 SD. WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE LOST POWER AND THE STEERING WHEEL SEIZED. IN ADDITION, THE CHECK ENGINE INDICATOR ILLUMINATED. THE DEALER (TOMBALL FORD, 22702 TOMBALL PKWY, TOMBALL, TX 77375, (281) 378-3160) WAS CONTACTED, BUT DID NOT RECEIVE AUTHORIZATION FROM THE CONTACT TO DIAGNOSE THE VEHICLE. AN INDEPENDENT MECHANIC DIAGNOSED THAT THE HIGH VOLUME OIL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 157,000.

  • Filed Jul 2016

    WHILE DRIVING BACK HOME FROM SHOPPING MY BRAKES (ANTI-LOCK STYLE) LOCKED UP AND VIOLENTLY SHOOK MY VEHICLE ALL OVER THE ROAD I WAS DRIVING ON. I HAD LIMITED OR NO CONTROL AT ALL OF THIS INCIDENT. WAS DOING ABOUT 40 MPH. TRUCK ACTED AS IF BRAKES WERE APPLIED ON AND OFF 50/60 TIMES SO FAST THAT THERE WAS NOTHING TO DO BUT HANG ON TO THE STEERING WHEEL. AT ONE POINT I THOUGHT I WAS GOING TO FLIP OVER AS THE TRUCK WENT SIDEWAYS. STEERING WENT FROM SIDE TO SIDE AT FIRST, THEN A CONSTANT PULL TO THE RIGHT. I THOUGHT ONE OF MY FRONT TIRES WAS BLOWN OUT. SLOWED DOWN ENOUGH TO GAIN SOME CONTROL BUT IT TOOK MY TRUCK OVER A CURB AND STOPPED ON A SIDEWALK AND SOME GRASS. WHEN I DID APPLY THE BRAKES NOTHING HAPPENED UNTIL I WAS ON THE SIDEWALK AND GOING VERY SLOW BY THIS TIME. GOT OUT AND INSPECTED MY TRUCK FOR DAMAGE BUT SAW NOTHING. WAS ONLY ABOUT .3 MILES FROM HOME SO I STARTED MY VEHICLE AND LIMED IT HOME AT WALKING SPEED. WHEN I TRIED TO GO A LITTLE FASTER IT WOULD START JUMPING AND SHAKING AGAIN. GOT IT HOME AND THAT IS WHEN I NOTICED THE ABS LIGHT WAS ON. IT WAS NOT ON WHEN I STARTED HOME FROM THE STORE. THIS HAPPENED SO FAST THAT I AM GLAD NO ONE WAS IN ANOTHER LANE. THIS HAPPENED ON A 3 LANE EACH DIRECTION ROAD. ALL THIS OCCURRED ON JULY 4TH AT ABOUT 10:47 A.M.

  • Filed Jun 2015

    WE HAD TRAVELED APROXIMATELY 450 MILES AND ON THE LAST LEG OF A TRIP IN THE MOUNTAINS. THE DRIVER NOTICED ON THE LAST 150 MILES OF THE TRIP THE STEERING WHEEL HAD CHANGED POSITION WHERE THE CENTER OF THE WHEEL NORMALLY WAS HORIZONTAL, WAS NOW 45 DEGREES OFF AND VERTICAL. THE VEHICLE WAS PARKED ON ARRIVAL TO DESTINATION. THE NEXT DAY THE VEHICLE NEEDED TO BE MOVED AND UNLOADED WHEN THIS WAS ATTEMPTED THE STEERING WHEEL JUST TURNED WITH NOT CONTROL OF THE WHEELS. SO WE WERE UNABLE TO MOVE THE VEHICLE. AFTER AN INITIAL INSPECTION OF THE VEHICLE AND IT WAS PLACED ON A FLOOR JACK TO RAISE THE FRONT END TO LOOK FOR PROBLEMS UNDER THE VEHICLE. AFTER TURNING THE WHEELS MANUALLY IT WAS NOTICED THE ARM THAT COMES FROM THE STEERING BOX WAS LOOSE AT THE ELBOW. AFTER CLOSER INSPECTION IT WAS FOUND THAT THE ENTIRE SHAFT WAS SHEERED OFF AT THE STEERING BOX. WE WERE LUCK IT FAILED WHEN WE WERE NOT ON THE ROAD. IT MUST DID THE FINAL FAILURE WHEN WE DROVE INTO OUR DRIVE WAY AND PARKED. THIS MIGHT HAVE BEEN A DISASTEROUS ACCIDENT IF THIS HAD FAILED WHILE WE WERE DRIVING ON THE MOUNTAIN ROADS WE HAD JUST DRIVEN ON OUR TRIP.

  • Showing the 5 most recent of 43.
• Service Brakes37

  2 involved a crash

  • Filed Apr 2020

    SPARK PLUGS KEEP BLOWING OUT OF THE ENGINE, WHILE ACCELERATING, HAS DONE FIVE TIMES,, WHEN IT DOES VEHICLE STALLED POSSIBLY CARE CAUSE AN ACCIDENT, ALMOST GOT HIT BY A TRUCK TRYING TO TURN,

  • Filed Feb 2020

    LOCATION MASTER CYLINDER CRUISE CONTROL DEACTIVATION SENSOR LEAKING BRAKE FLUID NON FUNCTIONAL BRAKES AND CRUISE CONTROL.

  • Filed Oct 2017

    PARKED MY TRUCK AT THE POST OFFICE TO RETRIEVE MAIL, GOT OUT AND SHUT DOOR, AND OUT OF THE CORNER OF MY EYE I SAW WHAT I THOUGHT AS MOVEMENT OF MY TRUCK, SO I TURNED AROUND TO SEE MY TRUCK STARTING TO ROLL BACKWARDS , I YELLED WTF, AND STARTED TO CHASE MY TRUCK THROUGH THE PARKING AREA, TRIED TO JUMP IN WHEN I OPENED THE DOOR AND I WAS TO OLD AND FAT TO DO THAT, TRIED PUSH BACK , BUT TRUCK WAS TO HEAVY TO DO THAT, SO I WENT FOR THE PARKING BRAKE PRESSED IT HARD AND FAST AS I COULD, AND THAT WORKED MY TRUCK WAS IN PARK, AS I HAD MY KEYS IN MY HAND. THE PARK LOCK ON THE TRANSMISSION FAILED IN SOME WAY ,ALLOWING TO ROLL LIKE IT WAS IN NEUTRAL

  • Filed Feb 2017

    TL* THE CONTACT OWNS A 2001 FORD F-250. WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE CRASHED INTO A PEDESTRIAN BRIDGE. THE DRIVER WAS FATALLY INJURED. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE BRAKE PEDAL WAS BENT AND OVERLAPPED THE ACCELERATOR PEDAL. THIS ISSUE MAY HAVE CAUSED THE CRASH. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS APPROXIMATELY 109,000. UPDATED 04/04/17 LJ *CN

  • Filed Jul 2016

    WHILE DRIVING BACK HOME FROM SHOPPING MY BRAKES (ANTI-LOCK STYLE) LOCKED UP AND VIOLENTLY SHOOK MY VEHICLE ALL OVER THE ROAD I WAS DRIVING ON. I HAD LIMITED OR NO CONTROL AT ALL OF THIS INCIDENT. WAS DOING ABOUT 40 MPH. TRUCK ACTED AS IF BRAKES WERE APPLIED ON AND OFF 50/60 TIMES SO FAST THAT THERE WAS NOTHING TO DO BUT HANG ON TO THE STEERING WHEEL. AT ONE POINT I THOUGHT I WAS GOING TO FLIP OVER AS THE TRUCK WENT SIDEWAYS. STEERING WENT FROM SIDE TO SIDE AT FIRST, THEN A CONSTANT PULL TO THE RIGHT. I THOUGHT ONE OF MY FRONT TIRES WAS BLOWN OUT. SLOWED DOWN ENOUGH TO GAIN SOME CONTROL BUT IT TOOK MY TRUCK OVER A CURB AND STOPPED ON A SIDEWALK AND SOME GRASS. WHEN I DID APPLY THE BRAKES NOTHING HAPPENED UNTIL I WAS ON THE SIDEWALK AND GOING VERY SLOW BY THIS TIME. GOT OUT AND INSPECTED MY TRUCK FOR DAMAGE BUT SAW NOTHING. WAS ONLY ABOUT .3 MILES FROM HOME SO I STARTED MY VEHICLE AND LIMED IT HOME AT WALKING SPEED. WHEN I TRIED TO GO A LITTLE FASTER IT WOULD START JUMPING AND SHAKING AGAIN. GOT IT HOME AND THAT IS WHEN I NOTICED THE ABS LIGHT WAS ON. IT WAS NOT ON WHEN I STARTED HOME FROM THE STORE. THIS HAPPENED SO FAST THAT I AM GLAD NO ONE WAS IN ANOTHER LANE. THIS HAPPENED ON A 3 LANE EACH DIRECTION ROAD. ALL THIS OCCURRED ON JULY 4TH AT ABOUT 10:47 A.M.

  • Showing the 5 most recent of 37.
• Vehicle Speed Control34

  2 involved a crash · 18 involved a fire

  • Filed Feb 2020

    LOCATION MASTER CYLINDER CRUISE CONTROL DEACTIVATION SENSOR LEAKING BRAKE FLUID NON FUNCTIONAL BRAKES AND CRUISE CONTROL.

  • Filed Oct 2019

    TL* THE CONTACT OWNS A 2001 FORD F-250. WHILE THE VEHICLE WAS STATIONARY IN A PARKING LOT, THE CONTACT NOTICED SMOKE UNDERNEATH THE HOOD. THE CONTACT EXITED THE VEHICLE, OPENED THE HOOD, AND NOTICED FLAMES. THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE WITH WATER AND NOTICED THAT AN UNKNOWN PLUG RELATED TO THE CRUISE CONTROL WAS MELTED. NO POLICE OR FIRE REPORTS WERE FILED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS ABLE TO BE DRIVEN. THE CONTACT'S VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V017000 (VEHICLE SPEED CONTROL). THE VEHICLE WAS TAKEN TO EL CAJON FORD (LOCATED AT 1595 E MAIN ST, EL CAJON, CA 92021, (619) 312-4107) WHERE IT WAS DIAGNOSED THAT THE UNKNOWN PLUG RELATED TO THE CRUISE CONTROL NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS UNKNOWN.

  • Filed Aug 2018

    TL* THE CONTACT OWNS A 2001 FORD F-250. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED, A FIRE WAS DETECTED COMING FROM UNDERNEATH THE DRIVER'S SIDE WHEEL. THE CONTACT ALSO MENTIONED THAT THE DRIVER SIDE OF THE VEHICLE EXPLODED. A POLICE REPORT WAS FILED. THE FIRE WAS EXTINGUISHED BY THE LOCAL FIRE DEPARTMENT. THERE WERE NO INJURIES REPORTED. THE VEHICLE WAS NOT TAKEN OR TOWED TO A DEALER OR INDEPENDENT MECHANIC FOR A DIAGNOSTIC TEST OR REPAIRS. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS INCLUDED IN THE NHTSA CAMPAIGN NUMBER: 05V170000 (VEHICLE SPEED CONTROL). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

  • Filed Feb 2017

    TL* THE CONTACT OWNS A 2001 FORD F-250. WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE CRASHED INTO A PEDESTRIAN BRIDGE. THE DRIVER WAS FATALLY INJURED. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE BRAKE PEDAL WAS BENT AND OVERLAPPED THE ACCELERATOR PEDAL. THIS ISSUE MAY HAVE CAUSED THE CRASH. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS APPROXIMATELY 109,000. UPDATED 04/04/17 LJ *CN

  • Filed Dec 2012

    TL* THE CONTACT OWNS A 2001 FORD F-250 SD. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, HE ATTEMPTED TO ACTIVATE THE CRUISE CONTROL BUT IT WOULD NOT ENGAGE. THE CONTACT TOOK THE VEHICLE TO THE DEALER FOR INSPECTION WHERE THEY ADVISED THE CONTACT THAT BRAKE FLUID WAS LEAKING FROM THE CRUISE CONTROL SWITCH AND THE SWITCH WOULD NEED TO BE REPLACED. THE DEALER ALSO STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 09V399000 (VEHICLE SPEED CONTROL). THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 70,000. UPDATED 1/15/13 *CN UPDATED 1/25/13 *JS

  • Showing the 5 most recent of 34.
• Hydraulic29

  2 involved a crash

  • Filed Feb 2017

    TL* THE CONTACT OWNS A 2001 FORD F-250. WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE CRASHED INTO A PEDESTRIAN BRIDGE. THE DRIVER WAS FATALLY INJURED. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE BRAKE PEDAL WAS BENT AND OVERLAPPED THE ACCELERATOR PEDAL. THIS ISSUE MAY HAVE CAUSED THE CRASH. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS APPROXIMATELY 109,000. UPDATED 04/04/17 LJ *CN

  • Filed Jul 2010

    BRAKE LINE TO THE REAR BRAKES RUPTURED DUE TO EXTREME CORROSION INSIDE THE FRAME THIS FAILURE RESULTED IN THE LOSS OF BRAKING/STOPPING POWER WITHOUT ANY WARNING. THE LINE WAS REPLACED. *TR

  • Filed Jul 2010

    A REAR BRAKE LINE ON MY 2001 FORD F-250 SUPER DUTY TRUCK RUSTED THROUGH, CAUSING A LOSS OF BRAKE FLUID AND BRAKING ABILITY. I REPLACED THE BRAKE LINE WITH A PART FROM FORD, BUT FORD SEEMED UNINTERESTED IN ADDRESSING THIS FAILURE, WHICH I HAD NEVER HEARD OF HAPPENING BEFORE. I STILL HAVE THE OLD PART. *TR

  • Filed Apr 2008

    THERE IS A BRAKE LINE TO THE REAR WHEELS LOCATED ROUGHLY ABOVE THE DIFFERENTIAL. THAT LINE IS IN CLOSE PROXIMITY TO ANOTHER CABLE (MAYBE THE EMERGENCY BRAKE CABLE) AND THE BRAKE LINE AND CABLE ARE RUBBING TOGETHER. THE BRAKE LINE IS VERY WORN IN THAT AREA FROM CONTACT WITH THE CABLE. IT LOOKS TO BE WORN TO A POINT THAT WOULD BE VERY CLOSE TO THE "CORE"OF THE BRAKE LINE. OF COURSE EXCESS PRESSURE OR FURTHER WEAR COULD CAUSE A FAILURE OF THAT LINE AND THEREFORE LOSS OF REAR BRAKING. *TR

  • Filed Dec 2006

    WHEN APPLYING BRAKES, THE PEDAL WENT SLOWLY TO FLOOR. PUMPING BRAKES HELPED IN STOPPING FAILURE WAS IN ANTI-LOCK BRAKES CONTROL PART # 5C7Z-2C286-A. *JB

  • Showing the 5 most recent of 29.
• Seat Belts26

  1 involved a crash

  • Filed Apr 2019

    FRONT PASSENGER SEAT BELT WILL DISENGAGE WITH OUT TOUCHING THE RELEASE BUTTON. I HAVE TRIED USING HIGH PRESSURE AIR THINKING IT WOULD DISLODGE SOMETHING. EVEN TRIED A LITTLE WD-40 TO NO AVAIL. REALLY FRUSTRATING TO HEAR ITS NOT ON THE RECALL LIST FOR THIS MODEL YEAR. DEALERSHIPS SURE DON'T ACT LIKE THEY WANT TO FIX IT. HAS HAPPENED NUMEROUS TIMES.

  • Filed May 2017

    THE DRIVER'S SIDE SEAT BELT COMES UNBUCKLED WITHOUT THE LATCH BEING TOUCHED WHILE DRIVING. THIS RESULTS IN AN UNSAFE SITUATION WHERE THE SEAT BELT ISN'T PROVIDING ANY SAFETY AND IT ALSO REQUIRES TWO HANDS TO RE-BUCKLE IT TAKING MY HANDS OFF THE STEERING WHEEL. THIS HAPPENS WHILE DRIVING IN MY DRIVEWAY, ON CITY STREETS AND HIGHWAYS. THE PROBLEM HAS BEEN HAPPENING SOON AFTER I BOUGHT THE TRUCK USED ON NOVEMBER 10, 2004.

  • Filed Aug 2016

    TL* THE CONTACT OWNS A 2001 FORD F-250. WHILE THE VEHICLE WAS BEING OPERATED, THE FRONT DRIVER AND PASSENGER SEAT BELTS UNLATCHED INDEPENDENTLY. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 135,000.

  • Filed Sep 2015

    TL* THE CONTACT OWNS A 2001 FORD F-250. WHILE DRIVING AT VARIOUS SPEEDS, THE FRONT PASSENGER SIDE SEAT BELT BECAME DETACHED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE VEHICLE HAD ALREADY BEEN THROUGH A RECALL AND THERE WAS NO DEFECT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 300,000....UPDATED 01/07/16 *BF

  • Filed Aug 2015

    TL* THE CONTACT OWNS A 2001 FORD F-250. WHILE DRIVING AT ANY SPEED, THE SEAT BELT WOULD INDEPENDENTLY UNLATCH WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER, WHERE IT WAS CONFIRMED THAT THERE WAS A MALFUNCTION WITH THE SEAT BELTS. THE TECHNICIAN REFUSED TO REPAIR THE VEHICLE. THE VEHICLE WAS TAKEN IN TO BE INSPECTED UNDER NHTSA CAMPAIGN NUMBER: 01V227001 (SEAT BELTS) BUT NO FAILURE WAS FOUND. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 60,000. THE VIN WAS NOT AVAILABLE.

  • Showing the 5 most recent of 26.
• Suspension23

  1 involved a crash

  • Filed Dec 2011

    AFTER TRAVELING OVER SMALL BUMPS, LIKE RAILROAD TRACKS MOST RECENTLY, AT AROUND 30MPH, ONE FRONT WHEEL STARTED BOUNCING VIOLENTLY, MAKING VEHICLE LOOSE CONTROL UNTIL TRUCK COULD BE BROUGHT TO A STOP. HAD EXPERIENCED THIS NUMEROUS TIME IN THE PAST BUT THOUGHT PROBLEM WAS SOLVED BY ADDING A STEERING STABILIZER A FEW YEARS AGO. PROBLEM HAS RETURNED. EACH TIME, THIS HAS NEARLY RESULTED IN A CATASTROPHIC ACCIDENT. *TR

  • Filed Sep 2009

    I HAVE A 2001 FORD F250 SD CREW/4X4 AND THERE IS SOMETHING WRONG WITH THE FRONT END STEERING SYSTEM. TODAY WAS THE SECOND TIME THAT MY TRUCK BEGAN TO SHIMMY AND SHAKE SO HARD THAT AT 55MPH BY THE TIME I GOT THE TRUCK SLOWED TO ABOUT 15MPH I WAS OVER INTO THE LANE OF THE ON COMING TRAFFIC (LUCKLY NO ONE WAS THERE). THE OTHER DAY WITH MY WIFE IN THE TRUCK WE TURNED A CORNER AND THE TRUCK STARTED TO SHIMMY REALLY HARD AND I LOST SOME RESPONSE CONTROL OF THE TRUCK THE STEERING BECAME SOMEWHAT UNRESPONSIVE, AND I WAS FORCED TO ALLOW THE TRUCK TO TRACK INTO THE BAILY POST OFFICE PARKING LOT. SOMETHING IS WRONG WITH MY TRUCK BUT THE MECHANICS TELL ME THAT THERE IS NOTHING WRONG WITH IT THAT THEY CAN FIND. THE TRUCK DOES NOT DO THIS ALL THE TIME, IT COMES AND GOES, SOMETIMES IT HAPPENS ALMOST EVERY TIME I DRIVE IT AND THEN IT CAN GO WEEKS WITHOUT HAPPENING. I WORKED AS A MECHANIC FOR 25 YEARS AND I AM TELLING YOU THIS IS A VERY DANGEROUS PROBLEM WITH THIS TRUCK AND I KNOW THAT YOU HAVE RECEIVED HUNDREDS MAYBE EVEN THOUSANDS OF COMPLAINTS ABOUT THIS SAME PROBLEM WITH THE FORD F-SERIES TRUCKS AND FORD SHOULD BE HELD ACCOUNTABLE FOR SUCH A BAD DESIGN FLAW THAT CAN CAUSES A LIGHT SHIMMY TO TOTAL LOSS OF CONTROL OF THESE TRUCKS AT ANY TIME WHILE DRIVING, WHICH MAY CAUSE SERIOUS HARM OR EVEN DEATH TO THE OWNER. MY WIFE WILL NOT EVEN RIDE IN THE TRUCK ANY MORE BECAUSE SHE IS TOO SCARED TO DO SO. THANK YOU FOR TIME AND CONSIDERATION. GARY *TR

  • Filed May 2008

    NOTHING LEAD UP TO THIS. I JUST SOLD MY 2001 F250 XLT TO A FRIEND. WITHIN DAYS THE TRUCK STARTED SHAKING VIOLENTLY WHEN THEY WOULD REACH A SPEED AROUND 40MPH. THEY HAVE TAKEN IT TO A MECHANIC AND HE SPENT DAYS LOOKING AT IT AND CAN NOT FIND A PROBLEM. ITS BAD ENOUGH THAT IT ALMOST CAUSED THEM TO RUN OFF THE ROAD. TRUCK HAD TO BE PARKED ON THE SIDE OF THE ROAD!! *TR

  • Filed Aug 2006

    2001 FORD F-250 WEAVES ON THE ROAD. UPON INSPECTION MECHANIC DETERMINED THE CONSUMER NEEDED NEW TIRES AND TO HAVE THE FRONT END REALIGNED. PROBLEM RESISTED. *KB THE VEHICLE WAS TAKEN TO ANOTHER DEALER WHO INDICATED THAT THE FRONT END HAD BEEN CHANGED AND THAT'S WHY THE VEHICLE WAS WANDERING. *NM

  • Filed Jul 2006

    DT*: THE CONTACT STATED THAT THE FRONT END OF THE VEHICLE WEAVED WHILE DRIVING AT ANY SPEED, CAUSING INCREASED STEERING EFFORT. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHERE THE TIRES WERE REPLACED, AND A FRONT END ALIGNMENT WAS PERFORMED. THE REPAIR WAS UNSUCCESSFUL IN CORRECTING THE PROBLEM.

  • Showing the 5 most recent of 23.
• Engine21

  1 involved a crash · 2 involved a fire

  • Filed Apr 2020

    SPARK PLUGS KEEP BLOWING OUT OF THE ENGINE, WHILE ACCELERATING, HAS DONE FIVE TIMES,, WHEN IT DOES VEHICLE STALLED POSSIBLY CARE CAUSE AN ACCIDENT, ALMOST GOT HIT BY A TRUCK TRYING TO TURN,

  • Filed Sep 2019

    TL* THE CONTACT OWNS A 2001 FORD F-250. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 05V017000 (VEHICLE SPEED CONTROL). WHILE THE VEHICLE WAS PARKED, SMOKE SPONTANEOUSLY EMERGED FROM UNDER THE HOOD AND THE VEHICLE CAUGHT FIRE WITHOUT WARNING. THE CONTACT EXTINGUISHED THE FIRE. THE VEHICLE WAS TAKEN TO BATTLEFIELD FORD COMMERCIAL TRUCK CENTER (8980 MATHIS AVE, MANASSAS, VA 20110, (703) 368-3231) WHO STATED THAT THEY WERE WAITING ON AUTHORIZATION. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. A FIRE REPORT WAS NOT FILED AND THERE WERE NO INJURIES. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 144,840.

  • Filed Apr 2019

    2001 FORD F250. CONSUMER WRITES IN REGARDS TO ISSUES WITH THE MOTOR. *LD THE CONSUMER STATED THE MOTOR WOULD BACK FIRE AND BLOW OUT. THE CONSUMER STATED THERE WAS A RECALL ON THE MOTOR, BUT THE MANUFACTURER WOULD NOT HONOR THE RECALL. *JS THE CONSUMER STATED THE VEHICLE BLEW IT'S LAST SPARK PLUG. *JS

  • Filed Nov 2018

    TL* THE CONTACT OWNS A 2001 FORD F-250 SD. WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE LOST POWER AND THE STEERING WHEEL SEIZED. IN ADDITION, THE CHECK ENGINE INDICATOR ILLUMINATED. THE DEALER (TOMBALL FORD, 22702 TOMBALL PKWY, TOMBALL, TX 77375, (281) 378-3160) WAS CONTACTED, BUT DID NOT RECEIVE AUTHORIZATION FROM THE CONTACT TO DIAGNOSE THE VEHICLE. AN INDEPENDENT MECHANIC DIAGNOSED THAT THE HIGH VOLUME OIL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 157,000.

  • Filed Aug 2018

    TL* THE CONTACT OWNS A 2001 FORD F-250. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED, A FIRE WAS DETECTED COMING FROM UNDERNEATH THE DRIVER'S SIDE WHEEL. THE CONTACT ALSO MENTIONED THAT THE DRIVER SIDE OF THE VEHICLE EXPLODED. A POLICE REPORT WAS FILED. THE FIRE WAS EXTINGUISHED BY THE LOCAL FIRE DEPARTMENT. THERE WERE NO INJURIES REPORTED. THE VEHICLE WAS NOT TAKEN OR TOWED TO A DEALER OR INDEPENDENT MECHANIC FOR A DIAGNOSTIC TEST OR REPAIRS. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS INCLUDED IN THE NHTSA CAMPAIGN NUMBER: 05V170000 (VEHICLE SPEED CONTROL). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

  • Showing the 5 most recent of 21.
• Air Bags13

  13 involved a crash

  • Filed Jan 2022

    Was T-Boned in the passenger side of the truck which changed my direction of travel resulting in hitting a tree head on. Neither frontal air bags deployed. The frontal impact was hard enough to push the tree 18 to 20 inches into the engine compartment bending the frame where the front bumper was attached. The accident resulted in a fatality. I'm just confused why neither air bag deployed. I have had this truck since it was new so I know it's history. There was not any warnings lights on, No air bag warning lights, No modifications were ever done to the truck. All stock. There was never any indication that the air bags were not operating normal. So Why did they malfunction?

  • Filed Jul 2006

    DT*: THE CONTACT STATED WHILE TRAVELING 30 MPH, THE VEHICLE HIT A CULVERT CAUSING AN ACCIDENT. THERE WAS EXTENSIVE DAMAGE DONE TO THE FRONT PASSENGER SIDE OF THE VEHICLE. THE AIRBAGS DID NOT DEPLOY.

  • Filed Mar 2006

    DT*: THE CONTACT STATED WHILE DRIVING 45 MPH A VEHICLE PULLED OUT IN FRONT OF THE CONTACT CAUSING A CRASH. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED AND THE OTHER DRIVER WAS INJURED.

  • Filed Aug 2005

    DT: ABS BRAKES, AIR BAGS, AND FUEL SYSTEM FAILED. AT 4700 MILES THEY REPLACED THE ENTIRE BRAKE SYSTEM. HAD IT A MECHANIC SHOP AND DISCOVERED IT WAS THE ABS. WHILE GOING 55 MPH AND MAKING A LEFT HAND TURN KEPT PUSHING THE BRAKES AND NOTHING HAPPENED CAUSING A WRECK. KEPT TAKING VEHICLE TO FORD, THEY COULD NOT FIND ANYTHING WRONG. UPON IMPACT, AIR BAGS ALSO DID NOT DEPLOY. ALSO, FUEL LINES SHUT OFF. THIS HAPPENED ON MARCH 15, 2002. *AK *NM

  • Filed Jul 2004

    I WAS TRAVELING AT APPROXIMATELY 50 MPH IN MY FORD F250 WHEN A CHEVROLET MINIVAN CROSSED THE CENTER LINE AND HIT ME HEAD ON. THE VAN'S AIRBAGS DEPLOYED, HOWEVER MINE DID NOT. FORD MOTOR COMPANY'S OPINION ON THIS IS THEY SHOULD NOT HAVE GONE OFF, BUT THEY WILL NOT INSPECT THE VEHICLE. THE VEHICLE IS UNDER FACTORY WARRANTY AND HAS NOT BEEN INVOLVED IN ANY PRIOR COLLISIONS. FORD IS ALSO UNWILLING TO PROVIDE ANY WRITTEN DOCUMENTATION THAT THE AIRBAGS ARE IN PROPER WORKING CONDITION UNLESS I COVER ALL EXPENSES INCURRED IN SUCH AN INSPECTION. THE VEHICLE REPAIR SHOP OWNER EXPERIENCE PROVIDES INDICATION THAT THE AIRBAGS IN MY VEHICLE MOST CERTAINLY SHOULD HAVE DEPLOYED. THIS IS ALSO THE OPINION OF THE INVESTIGATING STATE PATROL OFFICER. *AK

  • Showing the 5 most recent of 13.
• Wheels11

  • Filed Oct 2020

    TAILPIPE IS CLOSE ENOUGH TO SPARE TIRE TO MELT TIRE. TIRE IS UNUSABLE. LATER VEHICLES HAVE A HEAT SHIELD IN PLACE TO PREVENT THIS. FORD SHOULD HAVE RECALLED EARLIER UNITS.

  • Filed Sep 2016

    MY RECENTLY PURCHASED VEE RUBBER A/T TIRE BLEW UP WITH A LOUD BANG SUNDAY MORNING PARKED IN THE DRIVEWAY, THANKFULLY, AND NOT ON THE ROAD. I JUST BOUGHT FOUR TIRES FROM SIMPLE TIRE ON 07/07/2016 AND ONLY PUT 200 MILES ON THEM. IT APPEARS TO ME LIKE AN AIR LEAK DEVELOPED NEAR THE TREAD/SIDEWALL AREA AND DELAMINATED THE SIDEWALL FROM THE INNER LINER AND BLEW OUT NEAR THE BEAD. TIRES: VEE RUBBER TAIGA A/T LT285/75R-16 R 126/123R THE ONLY DATE CODE MARKING I SEE IS 0316?

  • Filed Dec 2015

    WIFE WAS DRIVING EAST BOUND ON 580 COMING DOWN WHAT WE CALL THE ALTAMONT PASS ON A SUNDAY AFTERNOON WITH MODERATE TRAFFIC. THE VEHICLE WAS EMPTY SO THE BOUNCING ON THIS FREEWAY IS PRETTY STANDARD. SHE HEARD A LOAD EXPLOSION AND THE TRUCK BEGAN TO SHAKE. SHE IMMEDIATELY PULLED TO THE SHOULDER AND NOTICED THE DRIVER SIDE REAR TIRE WAS SHREDDED ALONG WITH THE SIDE OF THE TRUCK. PRAISE GOD SHE HAD JUST HAD THE TIRES ROTATED OTHERWISE THIS TIRE WOULD HAVE BEEN IN THE FRONT AND PULLED HER ACROSS TRAFFIC. HER SPEED WAS IN THE RANGE OF 55-65 MPH WHICH IS TYPICAL FOR HER AND ON THE FREEWAY THIS TIME OF DAY. CONDITIONS WERE CLEAR AND DRY.

  • Filed Mar 2015

    WITHOUT WARNING, OUTER TIRE TREAD SEPARATED FROM TIRE WHILE DRIVING AT 65 MPH. UNIROYAL LIBERATOR, TIRE CODE BFOR C62U 2610, PURCHASED NEW ON 08/02/2010 WITH APPROXIMATELY 40,000 MILES. THIS HAPPENED ABOUT 0800, WEATHER WAS CLEAR, SUNNY AND ABOUT 50F DEGREES.

  • Filed Sep 2010

    DRIVING MY TRUCK ON HIGHWAY. THE SPARE TIRE CABLE BROKE THE TIRE WENT UNDER A TRAILER AND BENT TWO RIMS AND THE AXLE. I BOUGHT THE TRUCK NEW HAS 60,900 MILES THE SPARE HAS NEVER BEEN OF THE TRUCK. *TR

  • Showing the 5 most recent of 11.
• Structure8

  1 involved a fire

  • Filed Jun 2019

    REAR PASSENGER DOORS OF EXTENDED CAB(BOTH) WILL NOT RELEASE TO OPEN. CAUSING DANGER IN DIFFICULTY OF PASSENGERS TO EXIT THE VEHICLE.

  • Filed Aug 2017

    FOR THE R4100 TRANSMISSION. THE EXTERNAL TRANSMISSION FILTER CAME APART AND DESTROYED MY TRANSMISSION (FORD PART # XC3Z-7B155-BA) DEFINITELY NOT A 30,000 MILE FILTER. NOT MANY PEOPLE KNOW ANYTHING ABOUT THIS,OF WHAT I HAVE FOUND. THERE WAS A EASY 80,000 LEFT IN THE TRANS IF LINES AND OIL PORTS WEREN'T PLUGGED FROM FILTER FIBERS. #2 THE PAINT CANCER (WHITE) IS THERE ANY RECALLS OR HELP WITH THAT?

  • Filed Sep 2009

    I HAVE A 2001 FORD F250 SD CREW/4X4 AND THERE IS SOMETHING WRONG WITH THE FRONT END STEERING SYSTEM. TODAY WAS THE SECOND TIME THAT MY TRUCK BEGAN TO SHIMMY AND SHAKE SO HARD THAT AT 55MPH BY THE TIME I GOT THE TRUCK SLOWED TO ABOUT 15MPH I WAS OVER INTO THE LANE OF THE ON COMING TRAFFIC (LUCKLY NO ONE WAS THERE). THE OTHER DAY WITH MY WIFE IN THE TRUCK WE TURNED A CORNER AND THE TRUCK STARTED TO SHIMMY REALLY HARD AND I LOST SOME RESPONSE CONTROL OF THE TRUCK THE STEERING BECAME SOMEWHAT UNRESPONSIVE, AND I WAS FORCED TO ALLOW THE TRUCK TO TRACK INTO THE BAILY POST OFFICE PARKING LOT. SOMETHING IS WRONG WITH MY TRUCK BUT THE MECHANICS TELL ME THAT THERE IS NOTHING WRONG WITH IT THAT THEY CAN FIND. THE TRUCK DOES NOT DO THIS ALL THE TIME, IT COMES AND GOES, SOMETIMES IT HAPPENS ALMOST EVERY TIME I DRIVE IT AND THEN IT CAN GO WEEKS WITHOUT HAPPENING. I WORKED AS A MECHANIC FOR 25 YEARS AND I AM TELLING YOU THIS IS A VERY DANGEROUS PROBLEM WITH THIS TRUCK AND I KNOW THAT YOU HAVE RECEIVED HUNDREDS MAYBE EVEN THOUSANDS OF COMPLAINTS ABOUT THIS SAME PROBLEM WITH THE FORD F-SERIES TRUCKS AND FORD SHOULD BE HELD ACCOUNTABLE FOR SUCH A BAD DESIGN FLAW THAT CAN CAUSES A LIGHT SHIMMY TO TOTAL LOSS OF CONTROL OF THESE TRUCKS AT ANY TIME WHILE DRIVING, WHICH MAY CAUSE SERIOUS HARM OR EVEN DEATH TO THE OWNER. MY WIFE WILL NOT EVEN RIDE IN THE TRUCK ANY MORE BECAUSE SHE IS TOO SCARED TO DO SO. THANK YOU FOR TIME AND CONSIDERATION. GARY *TR

  • Filed Sep 2008

    TL*THE CONTACT OWNS A 2001 FORD F-250 SD. WHEN THE GEAR SHIFTER IS USED, IT CAUSES THE ACCELERATOR PEDAL FUSE TO BLOW. SMOKE APPEARED OUT OF THE STEERING COLUMN. THE CONTACT BELIEVES THAT THE FAILURE WAS DUE TO BURNED WIRES AND ALL OF THE ISSUES WERE CONNECTED TO THE STEERING COLUMN ELECTRICAL SYSTEM. HE BELIEVES THAT THE WIRES WERE BURNED IN THE STEERING COLUMN. THE TOW PACKAGE BURNED AND THE RIGHT TURN SIGNAL AND BRAKE LIGHTS NO LONGER WORK. ALL OF THE DOORS APPEARED TO BE SHORT AND DO NOT CLOSE OR OPEN PROPERLY. IN ADDITION, THE OVERDRIVE FAILED ON THE STEERING COLUMN. WHEN THE CONTACT PRESSES THE BUTTON, NOTHING HAPPENS. THE DEALER STATED THAT THE VEHICLE WAS NOT UNDER WARRANTY AND DOES NOT HAVE ANY SAFETY RECALLS THAT APPLY TO THE VIN. THE CONTACT WOULD BE RESPONSIBLE FOR THE REPAIR COSTS. THE FAILURE MILEAGE WAS 142,000.

  • Filed Jul 2007

    TL*THE CONTACT OWNS A 2001 FORD F-250 SD. WHILE DRIVING 70 MPH, THE DRIVER SIDE REAR TIRE SEPARATED, BUT THE TIRE WAS STILL INFLATED. THE LEFT REAR QUARTER PANEL OF THE VEHICLE BUCKLED AND THE INNER FENDER BRACE RIPPED OUT. THE ROAD CONDITIONS WERE NORMAL. THE TIRES WERE FIRESTONE STEEL TEX. THE CURRENT AND FAILURE MILEAGES WERE 71,000. THE CONSUMER STATED BELIEVES THE TIRES ARE UNSAFE AND WOULD LIKE THE SITUATION INVESTIGATED. UPDATED 09/05/07 *TR

  • Showing the 5 most recent of 8.
• Fuel System8

  1 involved a crash

  • Filed Aug 2016

    TL* THE CONTACT OWNS A 2001 FORD F-250. WHILE THE VEHICLE WAS PARKED, THE FUEL TANK PARTIALLY DETACHED FROM THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 125,000. UDATED 09/30/16*LJ *TR

  • Filed Jul 2013

    TURNED CORNER, HEARD A SUDDEN DRAGGING NOISE. CHECKED UNDER TRUCK. FUEL TANK STRAP HAD BROKEN AND FUEL TANK WAS DRAGGING. QUICKLY PULLED INTO DRIVEWAY. HAVING VEHICLE TOWED TO REPAIR SHOP. CALLED DEALER AND FOUND OUT THAT THERE WAS A RECALL ON THE SAME YEAR FORD TRUCK FOR F15 NOT F250. OBVIOUSLY APPEARS TO BE A PROBLEM IN OTHER MODELS.VERY LUCKY NO INJURIES, EXPLOSIONS, LEAKAGE, ETC...COULD HAVE BEEN BAD. FRUSTRATED. *TR

  • Filed Aug 2010

    I OWN A 2001 FORD F 250 SUPER DUTY WITH A 6.8 LITER V10 THIS IS THE SECOND TIME NOW THAT IT HAS BLOWN OUT A SPARKPLUG WHILE DRIVING DOWN THE ROAD AT A HIGH SPEED THEY WERE NOT THE SAME PLUG AND THEY ARE ORIGINAL MOTORCRAFT PLUGS . BOTH TIMES YOU SMELL ALOT OF GAS THAT COULD CAUSE A FIRE. *TR

  • Filed Jul 2010

    WHILE DRIVING HOME FROM WORK TODAY DURING A RAIN STORM IN RUSH HOUR (I'M TRAVELING AT 10MPH TOP), MY ENGINE SUDDENLY LOST POWER AND SOUNDED AS IF IT HAD LOST THE MUFFLER, EXCEPT THE SOUND WAS COMING FROM THE ENGINE COMPARTMENT. BECAUSE OF THE RAIN, IT WASN'T AS LOUD AS THE LAST TIME IT HAPPENED THREE YEARS AGO, BUT I KNEW WHAT HAD HAPPENED THANKS TO MY PRIOR EXPERIENCE. I PULLED OVER IMMEDIATELY AND EXITED THE HIGHWAY. ONCE THE RAIN STOPPED, I WAS SURE WHAT HAD HAPPENED. THERE IS NO REASON FOR THIS OCCURRING AT ALL, BUT TO HAVE IT HAPPEN TWICE! THERE IS SERIOUSLY SOMETHING WRONG WITH THE DESIGN IN FORD'S ENGINES (MINE IS A 5.4 V8, F-250.) I SEE ALL THE REPORTS OF THE SAME PROBLEM ON THE INTERNET AND IT MENTIONS THE FACT THAT THERE IS THE POSSIBILITY OF ENGINE COMPARTMENT FIRES. WHEN IT HAPPENED TO ME THE FIRST TIME, I WAS TOLD BY THE DEALERSHIP I SHOULD BE ABLE TO DRIVE IT IN FOR SERVICE, SO I DID. AND I DID SO AGAIN TODAY, TAKING THE BACKROADS. ONLY LATER THIS EVENING, WHILE RESEARCHING THE PROBLEM, DID I DISCOVER THE DANGER. PLEASE APPLY PRESSURE TO FORD TO CORRECT THIS PROBLEM BEFORE SOMEONE IS SERIOUSLY INJURED. AND SINCE THIS IS A COSTLY REPAIR THAT I FEEL IS CAUSED BY POOR DESIGN, IT SHOULD NOT BE PLACED ON THE BURDEN OF FORD CUSTOMERS WHO PAY THOUSANDS OF DOLLARS FOR THEIR VEHICLES IN THE FIRST PLACE. *TR

  • Filed Jan 2010

    I WAS DRIVING HOME FRIDAY JANUARY8TH AT 7:30 PM WHEN MY SPARK PLUG BLEW OUT OF MOTOR WHILE DRIVING, SHOOTING FUEL OUT OF CYLINDER AS COIL WAS STILL CONNECTED AND ARCING ON MOTOR.I LOST POWER AND HAD TO GET TO SIDE OF ROAD I COULD NOT FIX BECAUSE THREADS OF CYLINDER HEAD WERE DAMAGED WHEN BLOWOUT OCCURRED.FORTUNATLY THIS HAPPENED WITHIN A COUPLE MILE OF MY HOME, IF THIS WERE TO OCCUR ON HIGHWAY WITH TRAFFIC AROUND THE LOSS OF POWER AND POTENTIAL FOR FIRE WOULD HAVE BEEN VERY DANGEROUS! *TR

  • Showing the 5 most recent of 8.
• Visibility8

  • Filed Nov 2013

    THE TWO VENTS BEHIND THE REAR SEAT OF THE CAB LEAK AND CAUSE CARPET/FLOOR DAMAGE. *TR

  • Filed Apr 2011

    TL* THE CONTACT OWNS A 2001 FORD F-250. THE CONTACT STATED THAT DURING RAINY WEATHER, THE GENERAL ELECTRIC MODULE WOULD BECOME WET AND CAUSE THE VEHICLE TO MALFUNCTION. THE CONTACT STATED THAT THE FAILURE WOULD ALSO CAUSE THE VEHICLE TO START INDEPENDENTLY, THE LIGHTS WOULD FLASH AND THE TURN SIGNALS WOULD ILLUMINATE INDEPENDENTLY. IN ADDITION, THE AIR BAG WARNING LIGHT WAS ILLUMINATED. THE DEALER STATED THAT THEY WERE AWARE OF THE FAILURE AND MADE A COVER FOR THE PART. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THERE WAS A LEAK COMING FROM THE WINDSHIELD THAT WAS ALLOWING WATER TO ENTER THE GENERAL ELECTRONIC MODULE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 180,000 AND THE CURRENT MILEAGE WAS 240,000.

  • Filed Feb 2009

    I HAVE A 2001 FORD F250, THE WINDSHIELD LEAKED CAUSING THE GEM MODULE TO MAL-FUNCTION. THIS IS A PROBLEM IN ALOT OF FORD VEHICLES,NOT JUST MINE. THE SHORT CAUSES THE TRUCK TO MISS, STALL, A LOT OF ELECTRICAL PROBLEMS RESULT. *TR

  • Filed Jul 2004

    WINDSHIELD WIPERS FAILED TO OPERATE IN THE SLOW SPEED. WINDSHIELD WIPERS WILL WORK IN FAST SPEED IF THEY FUNCTION WHEN ENGAGED. ALSO, WILL NOT WILL NOT GO BACK TO THE START POSITION WHEN TURNED OFF. RECALL 01V258000 WAS ISSUED, BUT THIS VEHICLE WAS NOT INVOLVED IN THE RECALL DUE TO VIN. *AK

  • Filed Sep 2003

    WHILE DRIVING 65 MPH WINDSHIELD WAS IMPACTED BY A SMALL OBJECT. WHEN THIS OCCURRED WINDSHIELD GLASS SPIRALED OUT, AND SMALL PIECES OF SPARE SHAPE GLASS WENT INTO THE CABIN OF THE VEHICLE AND HIT THE OCCUPANTS.*AK

  • Showing the 5 most recent of 8.
• Unknown or Other6

  1 involved a fire

  • Filed Oct 2020

    TAILPIPE IS CLOSE ENOUGH TO SPARE TIRE TO MELT TIRE. TIRE IS UNUSABLE. LATER VEHICLES HAVE A HEAT SHIELD IN PLACE TO PREVENT THIS. FORD SHOULD HAVE RECALLED EARLIER UNITS.

  • Filed Apr 2016

    THE TRUCK BURST INTO FLAMES WHILE PARKED. IT HAD BEEN SITTING FOR OVER 13 HOURS AT THE TIME OF THE FIRE. IT DESTROYED ONE CAR ON EITHER SIDE OF IT. THE FIRE INVESTIGATOR COULD NOT SAY EXACTLY WHAT CAUSED THE FIRE AT THE TIME, BUT MADE ME AWARE OF A RECALL ON THAT YEAR OF FORD VEHICLES INVOLVING THE SPEED CONTROL SAFETY DEACTIVATION SWITCH. INFORMATION ON THE RECALL SAYS THAT THE WIRE COULD HEAT UP AND CAUSE A FIRE. THE TRUCK ALONG WITH TWO OTHER VEHICLES WERE COMPLETELY DESTROYED IN THE FIRE.

  • Filed Aug 2005

    MY HUSBAND AND I HAVE A FORD F250 TRUCK. IT'S A 2001 WHICH WE PURCHASE IN 3/2002. MY HUSBAND WAS DRIVING THE TRUCK WHEN HE HEARD A BANG THEN THE TRUCK DIED. WE HAD THE TRUCK TOWED TO A LOCAL AUTO REPAIR SHOP. THE REPAIR SHOP STATED THAT THEY WOULD NOT TOUCH THE TRUCK BECAUSE THE SPARK PLUG BLEW OUT CAUSING THE HEAD TO BLOW. THEY STATED THAT THIS IS AN ONGOING THING WITH FORD TRUCKS AND FORD WILL NOT ADMIT THAT THEY HAVE AN ENGINEERING PROBLEM WITH THE MOTOR. I BROUGHT THIS MATTER TO THE DEALERSHIP AND THE FORD CUSTOMER SERVICE DEPARTMENTS ATTENTION. NEITHER ONE OF THEM WOULD ASSIST ME. THEY STATED THAT WE WOULD BE RESPONSIBLE FOR THE REPAIRS. AFTER THESE PHONE CALLS I CALL A FEW OTHER AUTO REPAIR SHOPS. THEY ALSO STATED THAT THAT WAS UNUSUAL THAT A SPARK PLUG WOULD BACK OUT AND EVEN IF THE SPARK PLUG DID BACK OUT THAT IT WAS UNUSUAL THAT IT WOULD BLOW THE HEAD GASKET. AT THIS POINT WE HAVE TO PAY FOR THE REPAIRS WHICH IS 3,500.00. I WOULD LIKE THIS MATTER LOOKED INTO.

  • Filed Jun 2005

    WE HAVE A 2001 FORD F250 THE TRUCK HAS SHUT OFF WHILE DRIVING 6 TIMES. 3 TIMES WERE NEAR FATAL. WE GET THE VEHICLE TOWED TO THE DEALERSHIP THEY SAY THEY FIX IT AND THEN IT HAPPENS AGAIN. WE CALLED FILES FLORIDA LEMON LAW AND THEY SAID BECAUSE WE DID NOT FILE WITHIN THE FIRST TWO YEARS OF OWNING THE CAR THAT IT IS NOT A LEMON.FIRST TIME OCCURED 12/00 NUMBER 6 OCCURED 6/05

  • Filed Apr 2004

    THE SPARE TIRE HOIST ON OUR 2001 FORD F250 IS JAMMED AND WILL NOT PICK UP THE SPARE TIRE. THERE IS NO SAFE, SUITABLE PLACE TO STORE THE SPARE TIRE. LEAVING IT ALONG THE ROAD WAS NOT AN OPTION AND THERE WAS NO ROOM BEHIND THE FRONT SEAT. LEAVING IT IN THE TRUCK BED WHERE IT IS SUBJECT TO THEFT ISN'T A VIABLE OPTION. FORD WAS NOTIFIED, BUT SAID THAT THE WARRANTY HAD EXPIRED AND THAT THEY WILL NOT REPAIR THE HOIST. IN THE MEANTIME WE HAVE AN 80LB. TIRE AND NO SAFE PLACE TO KEEP IT. *JB

  • Showing the 5 most recent of 6.
• Gasoline6

  1 involved a crash

  • Filed Aug 2016

    TL* THE CONTACT OWNS A 2001 FORD F-250. WHILE THE VEHICLE WAS PARKED, THE FUEL TANK PARTIALLY DETACHED FROM THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 125,000. UDATED 09/30/16*LJ *TR

  • Filed Aug 2010

    I OWN A 2001 FORD F 250 SUPER DUTY WITH A 6.8 LITER V10 THIS IS THE SECOND TIME NOW THAT IT HAS BLOWN OUT A SPARKPLUG WHILE DRIVING DOWN THE ROAD AT A HIGH SPEED THEY WERE NOT THE SAME PLUG AND THEY ARE ORIGINAL MOTORCRAFT PLUGS . BOTH TIMES YOU SMELL ALOT OF GAS THAT COULD CAUSE A FIRE. *TR

  • Filed Jul 2010

    WHILE DRIVING HOME FROM WORK TODAY DURING A RAIN STORM IN RUSH HOUR (I'M TRAVELING AT 10MPH TOP), MY ENGINE SUDDENLY LOST POWER AND SOUNDED AS IF IT HAD LOST THE MUFFLER, EXCEPT THE SOUND WAS COMING FROM THE ENGINE COMPARTMENT. BECAUSE OF THE RAIN, IT WASN'T AS LOUD AS THE LAST TIME IT HAPPENED THREE YEARS AGO, BUT I KNEW WHAT HAD HAPPENED THANKS TO MY PRIOR EXPERIENCE. I PULLED OVER IMMEDIATELY AND EXITED THE HIGHWAY. ONCE THE RAIN STOPPED, I WAS SURE WHAT HAD HAPPENED. THERE IS NO REASON FOR THIS OCCURRING AT ALL, BUT TO HAVE IT HAPPEN TWICE! THERE IS SERIOUSLY SOMETHING WRONG WITH THE DESIGN IN FORD'S ENGINES (MINE IS A 5.4 V8, F-250.) I SEE ALL THE REPORTS OF THE SAME PROBLEM ON THE INTERNET AND IT MENTIONS THE FACT THAT THERE IS THE POSSIBILITY OF ENGINE COMPARTMENT FIRES. WHEN IT HAPPENED TO ME THE FIRST TIME, I WAS TOLD BY THE DEALERSHIP I SHOULD BE ABLE TO DRIVE IT IN FOR SERVICE, SO I DID. AND I DID SO AGAIN TODAY, TAKING THE BACKROADS. ONLY LATER THIS EVENING, WHILE RESEARCHING THE PROBLEM, DID I DISCOVER THE DANGER. PLEASE APPLY PRESSURE TO FORD TO CORRECT THIS PROBLEM BEFORE SOMEONE IS SERIOUSLY INJURED. AND SINCE THIS IS A COSTLY REPAIR THAT I FEEL IS CAUSED BY POOR DESIGN, IT SHOULD NOT BE PLACED ON THE BURDEN OF FORD CUSTOMERS WHO PAY THOUSANDS OF DOLLARS FOR THEIR VEHICLES IN THE FIRST PLACE. *TR

  • Filed Jan 2010

    I WAS DRIVING HOME FRIDAY JANUARY8TH AT 7:30 PM WHEN MY SPARK PLUG BLEW OUT OF MOTOR WHILE DRIVING, SHOOTING FUEL OUT OF CYLINDER AS COIL WAS STILL CONNECTED AND ARCING ON MOTOR.I LOST POWER AND HAD TO GET TO SIDE OF ROAD I COULD NOT FIX BECAUSE THREADS OF CYLINDER HEAD WERE DAMAGED WHEN BLOWOUT OCCURRED.FORTUNATLY THIS HAPPENED WITHIN A COUPLE MILE OF MY HOME, IF THIS WERE TO OCCUR ON HIGHWAY WITH TRAFFIC AROUND THE LOSS OF POWER AND POTENTIAL FOR FIRE WOULD HAVE BEEN VERY DANGEROUS! *TR

  • Filed Aug 2005

    DT: ABS BRAKES, AIR BAGS, AND FUEL SYSTEM FAILED. AT 4700 MILES THEY REPLACED THE ENTIRE BRAKE SYSTEM. HAD IT A MECHANIC SHOP AND DISCOVERED IT WAS THE ABS. WHILE GOING 55 MPH AND MAKING A LEFT HAND TURN KEPT PUSHING THE BRAKES AND NOTHING HAPPENED CAUSING A WRECK. KEPT TAKING VEHICLE TO FORD, THEY COULD NOT FIND ANYTHING WRONG. UPON IMPACT, AIR BAGS ALSO DID NOT DEPLOY. ALSO, FUEL LINES SHUT OFF. THIS HAPPENED ON MARCH 15, 2002. *AK *NM

  • Showing the 5 most recent of 6.
• Equipment4

  • Filed Feb 2011

    I AM AN OWNER OF A 2001 F-250 SUPER DUTY, I HAVE HAD THE PROBLEM WITH SPARK PLUG EJECTION FROM THE HEADS OF MY MOTOR. THE FIRST TIME THIS HAPPENED WAS WITH THE OEM PLUGS STILL IN THE MOTOR, THE SECOND TIME I HAD THE BLOW OUT REPAIRED ALREADY AND ALL PLUGS WERE REPLACED BUT YET AGAIN A LITTLE OVER A YEAR LATER THE PLUG IN ANOTHER HOLE BLEW OUT. THIS TIME I HAD ALL HOLES PATCHED WITH A STAINLESS STEEL INSERT. BOTH TIMES I HAD TO PAY WELL OVER $50.00 FOR TOWING AND THE LAST REPAIR BILL WAS IN EXCESS OF $800.00. I AM A FULL TIME STUDENT AND SINGLE FATHER I DO NOT HAVE THE RESOURCES TO PAY FOR CONSTANT REPAIRS BECAUSE OF AN ENGINEERING PROBLEM WITH OEM EQUIPMENT, FROM WHAT I HAVE SEEN ON THE INTERNET AND TOLD BY MY MECHANICS THIS IS HAPPENING TO ALMOST EVERY VEHICLE WITH THESE TYPES OF MOTORS. THANK YOU FOR YOUR TIME AND EFFORT IN LOOKING INTO THIS MATTER. *TR

  • Filed Jul 2009

    THERE HAVE BEEN NO INCIDENTS/ACCIDENTS, HOWEVER PROBLEM IS: 2001 FORD F250 SUPER DUTY PICKUP TRUCK - OWNER'S GUIDE / MANUAL STATES ON PAGE117 UNDER THE HEADING "TETHER ANCHORAGE HARDWARE" -- (TETHER ANCHORAGE HARDWARE KITS (PART NUMBER 613D74) INCLUDING INSTRUCTIONS, MAY BE OBTAINED AT NO CHARGE FROM ANY FORD OR LINCOLN/MERCURY DEALER) PER AUTOMOTIVE DEALERSHIP, PART NUMBER IS NOW OBSOLETE; HAVE INVESTIGATED AND FOUND UPDATED PART # F81Z5613D74AA. FORD CUSTOMER SERVICE PHONE TOLD ME TO CALL THE DEALER; DEALER SAID PART IS APPROXIMATELY $80.00; CALLED FORD CUSTOMER SERVICE BACK - THEY TOLD ME TO CALL THE SERVICE MANAGER AT THE DEALER TO SEE IF THEY COULD HELP. FORD DID NOT HAVE RESPONSIBILITY. BASICLY I WAS TOLD TO PAY FOR IT OR WHO CARES? SO FAR INCLUDING THIS LETTER I NOW HAVE 2+ HOURS INVESTED INTO THIS ISSUE. UNFORTURNATELY, MOST PEOPLE WOULD NOT TAKE THE TIME AND THIS IS WHY THESE ISSUES EXIST IN THE FIRST PLACE. THIS SHOULD HAVE BEEN TAKEN CARE OF IN 1-2 PHONE CALLS. CONSEQUENCES COULD MEAN DEATH OF A CHILD DUE TO THE CHILD RESTRAINT SEAT NOT FASTENED INTO VEHICLE PROPERLY. ALSO, IF INFORMATION ONLINE IS ACCURATE, I'M NOT THE ONLY ONE WHO HAS EXPERIENCED PROBLEMS WITH THIS TYPE OF QUESTION / ISSUE. PLEASE LOOK INTO THIS AND HOLD THESE MANUFACTURES ACCOUNTABLE TO KEEP OUR CHILDREN SAFE! *TR

  • Filed Oct 2004

    UPON JACKING THE VEHICLE UP TO CHANGE THE TIRE THE TRUCK FAILED. THE JACK WAS NOT BUILT CORRECTLY. CONSUMER WAS INJURED. CONSUMER CONTACTED DEALER.*AK

  • Filed Jun 2004

    DIESEL EMISSIONS GETTING INTO CABIN AT TOXIC LEVELS. WHILE CLEANING OUT THE INSIDE OF MY DECEASED FATHERS F250 SUPER DUTY DIESEL, I NOTICED A BROWN HAZE COVERING THE THE FRONT SEAT AND NOTICED AT THE BOTTOM OF THE SEATBELTS, THEY WERE COVERED HEAVILY WITH DIESEL SOOT. I SENT OFF TO LAB FOR ANALYSIS AND THE RESULTS OF THE FIRST TEST WERE AS FOLLOWS: DIESEL RANGE ORGANIC GC/CARBON DISTRIBUTION 508MG/L. *AK

• Fuel/Propulsion System3

  1 involved a crash

  • Filed Mar 2015

    I WAS IN FLORIDA HAVING COFFEE AT THE PICNIC TABLE WHEN I NOTICED THE FUEL TANK WAS HANGING LOW. I WAS LUCKY TO CATCH IT BEFORE IT FELL OFF ON THE FREEWAY. I CAN SEND YOU A PICTURE. I UNDERSTAND THERE IS A RECALL ON OTHER FORD PICKUPS 150'S AND 250'S BUT NOT MY MODEL YEAR, MY YEAR TRUCK SHOULD BE INCLUDED. *TR

  • Filed Jan 2015

    THE 2001 F250 I OWN HAS ALWAYS STALLED AT ANY GIVEN TIME. FORD RECALLED THE CAM POSITION SENSOR, I HAD ALREADY CHANGED IT JUST BEFORE RECALL THEN THEY DID AGAIN. THAT NEVER STOPPED IT FROM STALLING, IT ALSO DOESN'T READ WHEN YOU SOMETIMES GO TO TAKE OFF. I'VE CHANGED (THROTTLE SWITCH) THAT DID NOTHING. ALL OF ITS MISHAPS HAS CASED THOUSANDS OF DOLLARS IN REPAIR. ALWAYS BROKE DOWN AND CAN'T MAKE MONEY WHEN IT'S IMPOSSIBLE TO DRIVE TRUCK TIME AFTER TIME. I HAVE BEEN IN SEVERAL CLOSE CALL ACCIDENTS, WHEN I LOSE POWERSTEERING AND ALMOST HAVE CRASHED INTO CARS. I FIGURED OUT THE FUEL TANK FLAKING OFF INSIDE THE TANK COULD BE THE CAUSE. THE TRUCK GETS TERRIBLE FUEL MILEAGE WHEN THIS HAPPENS COSTING A FORTUNE IN WASTED DIESEL FUMES. THAT HAVE BEEN KNOW TO CAUSE BRAIN CANCER, ALSO THE AMOUNT OF POLLUTION FROM NOT RUNNING PROPER. I AM NO FAN OF FORD'S REPAIR SHOP WHEN THEY TELL YOU IN 1983 TO MY FATHER THAT HIS ALMOST BRAND NEW DIESEL NEEDS NEW (SPARK PLUGS) WHEN DIESEL DO NOT EVEN HAVE THEM. I OWN THIS 2001 DIESEL FOR A LONG TIME NOW FOR A LANDSCAPING AND SNOWPLOWING THAT IS OUT OF BUSINESS. IT IS EMBARRASSING FOR IT TO STALL, REV UP SLIPPING TRANSMISSION, HARMING WHOLE DRIVE TRAIN. NEVER KNOWING WHEN I'M COULD BE STRANDED IN NORTHERN MICHIGAN. I HAVE HAD ONE THING AFTER ANOTHER WITH THE FORD I OWN. I HAVE SEEN A LOT OF SAME PROBLEMS PEOPLE ARE COMPLAINING ABOUT. SOUNDS LIKE FORD HAS DONE GOOD AT COVERING UP PROBLEM BY NOT TELLING US IF THEY KNEW. I THOUGHT THE FUEL PROBLEM CAME FROM GAS STATIONS. ONLY THING HELPED ME WAS MOSTLY SAME NEWER STATION, AND TRIED TO KEEP IT FULL HELPED. CAN ANYONE HELP, THESE ARE DANGEROUS SITUATIONS WHEN LIVES DEPEND ON THEM. I'M NOT SURE WHAT TO DO WITH THE TRUCK, I'D LIKE TO SEE IT GO TO SCRAP AT THIS TIME. WITH 277,000 NOT EVEN RUSTED OUT MUCH. IT NEEDS WHOLE DRIVE TRAIN AGAIN, I DON'T WANT THE OILY LEAKING, POLLUTING JUNK ON THE ROAD. *TR

  • Filed Jan 2013

    TL* THE CONTACT OWNS A 2001 FORD F-250 SD. THE CONTACT STATED THAT THE VEHICLE WAS RUNNING VERY ROUGH. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION AND THEY STATED THAT THE SENDING UNIT HAD FAILED. THE DEALER ALSO STATED THAT THE FUEL TANK STRAPS HAD CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED AND THEY STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE). THE FAILURE MILEAGE WAS 252,000. THE VIN WAS UNAVAILABLE.

• Latches/Locks/Linkages3

  • Filed Nov 2008

    2001 FORD F250 SUPER DUTY PICKUP. POWER DOOR LOCKS ARE BOTH FAILING. UNABLE TO OPEN DOORS WITH OUT PULLING UP LOCK MANUALLY INSIDE TRUCK. COULD BE SAFETY HAZARD DURING AN ACCIDENT. FORD WILL ONLY REPLACE FOR $400. THE TRUCK IS ONLY 7 YEARS OLD. THIS SEEMS TO EARLY FOR LOCK ACTUATORS TO FAIL. HAVE READ OF MANY FORD OWNERS COMPLAINING OF SIMILAR FAILURES ON FORD WEBITES. *TR

  • Filed Mar 2006

    DRIVING ALONG BUSY ROAD WAY RUNNING FINE, THEN THE MOTOR JUST SHUT DOWN. LEFT STRANDED RIGHT IN THE MIDDLE OF THE ROAD. COULD NOT BE RESTARTED, TRUCK WAS TOWED TO GARAGE. CAM SHAFT SENOR REPLACED. *JB

  • Filed Jun 2005

    THE CONSUMER STATED AT 27,000 MILES HIS 2001 FORD F250 DEVELOPED AN ENGINE VIBRATION. *JB THE CONSUMER WAS TOLD THERE WAS NO FIX FOR THE PROBLEM. WHEN THE CONSUMER APPLIED THE BRAKES, THERE WAS A VIBRATION. THE DEALER MACHINED THE FRONT ROTORS AND REPLACED THE PADS THAT WERE CRACKED. THERE WAS A RATTLE NOISE COMING FROM UNDER THE VEHICLE. THE EXHAUST SHIELDS WERE LOOSE, THE HOSE CLAMP ON THE RADIATOR WAS REPLACED AND THE POWER DOOR LOCK WAS REPLACED. *JB *NM

• Seats3

  • Filed Apr 2003

    THE FRONT SEAT WAS DESIGNED IMPROPERLY. *JB

  • Filed Jun 2002

    CONSUMER IS CONCERNED ABOUT THE DESIGN OF REAR SEATS, THEY0 DO NOT HAVE HEADRESTS, IN THE EVENT OF A REAR END CRASH THE PASSENGER?S HEAD WOULD GO THROUGH THE WINDOW. *YD

  • Filed Dec 2001

    THE CONSUMER STATED THAT THE PASSENGERS REAR SEAT DOES HAVE HEADREST. IT WILL BE UNSAFE FOR REAR SEAT PASSENGERS IF AN ACCIDENT OCCURS. *YD

• Visibility/Wiper2

  • Filed Sep 2013

    TL* THE CONTACT OWNS A 2001 FORD F-250 SD. THE CONTACT STATED THAT AS HE STARTED THE ENGINE, EVERY LIGHT REMAINED ILLUMINATED OF THE INSTRUMENT PANEL. IN ADDITION, THE CONTACT STATED THAT THERE WAS A BROKEN SEAM IN THE WINDSHIELD THAT WOULD CAUSE WATER TO LEAK INTO THE VEHICLE AND ONTO THE ELECTRONIC CONTROL MODULE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 200,007.

  • Filed Oct 2012

    WHEN I PURCHASED THE TRUCK USED, THE DRIVER'S SIDE WINDOW WAS SLIGHTLY SCRATCHED AND OVER THE YEARS THE WINDOW HAS BEEN SCRATCHED MORE OVER A LARGER AREA MAKING IT NEARLY IMPOSSIBLE TO SEE OUT OF IF THE SUN IS ON THE LEFT SIDE OF THE TRUCK. I KNOW OTHER MODELS AND YEARS HAVE HAD THIS PROBLEM AND DON'T UNDERSTAND WHY MY TRUCK HAS NOT BEEN INCLUDED. *TR

• Diesel1

  • Filed Jul 2013

    TURNED CORNER, HEARD A SUDDEN DRAGGING NOISE. CHECKED UNDER TRUCK. FUEL TANK STRAP HAD BROKEN AND FUEL TANK WAS DRAGGING. QUICKLY PULLED INTO DRIVEWAY. HAVING VEHICLE TOWED TO REPAIR SHOP. CALLED DEALER AND FOUND OUT THAT THERE WAS A RECALL ON THE SAME YEAR FORD TRUCK FOR F15 NOT F250. OBVIOUSLY APPEARS TO BE A PROBLEM IN OTHER MODELS.VERY LUCKY NO INJURIES, EXPLOSIONS, LEAKAGE, ETC...COULD HAVE BEEN BAD. FRUSTRATED. *TR

• Other1

  • Filed Jun 2007

    THE CAM POSITIONING SENSOR IN THE FORD POWER STROKE 7.3L DIESEL HAS GONE OUT AT 60,000 MILES. THIS CAUSED THE VEHICLE TO COMPLETELY SHUT DOWN. THIS WAS NOT THE ONLY TRUCK THIS HAS HAPPENED TO. MANY PEOPLE I KNOW HAD THIS HAPPEN WITHIN THE FIRST 100,000 MILES. FORD REPAIRED THE CPS FOR $400.00 AT MY EXPENSE. ALSO THE O RING IN THE HIGH PRESSURE OIL PUMP WENT OUT AT 71,000 MILES WITH NO WARNING, CAUSING ME TO DUMP ALL OF THE OIL OUT. I DISCOVERED IT BEFORE IT CAUSED MOTOR PROBLEMS. FORD FIXED THIS PROBLEM FOR $500.00. BOTH PROBLEMS A WERE VERY COMMON WITH THE 7.3L AND NEED TO BE ADDRESSED BY FORD. THEY WERE NOT ORDINARY PROBLEMS AND NEED SOME KIND OF ATTENTION FROM FORD. *AK

• Air1

  • Filed Jan 2003

    WHILE APPLYING BRAKES THE VEHICLE'S WHEEL WONT TURN. DEALER NOTIFIED. PLEASE PROVIDE ADDITIONAL INFORMATION. TS

Safety ratings

NHTSA 5-Star Safety Ratings from government crash tests. Ratings can differ by cab style and 2WD/4WD.

NHTSA hasn't published star ratings for this truck. Many heavy-duty pickups aren't included in NHTSA's crash-test program, so this doesn't mean the truck is unsafe.