2006 Ford F-250 Super Duty

What owners should know

Covers 2005–2007 · 6.0L Power Stroke diesel, 5.4L V8 and 6.8L V10 gas · Updated 2026-10-01

Researched from owner forums and NHTSA complaints and written by Know Your Truck. These are patterns in what owners report, not a guarantee about any particular truck.

Common failures & how to fix them

Parts and video buttons search for your 2006 Ford F-250 Super Duty. Always confirm a part fits using your VIN. Brakes, steering, fuel and airbag work affects your safety, so if you're not sure, have a qualified mechanic do it.

• Front-end shake (death wobble)

  Moderate DIY

  Signs: Violent shaking of the steering wheel and front end after hitting a bump, usually at 45+ mph. Slowing down hard is often the only way to stop it.

  Fix: Find and replace the worn parts, most often the track bar or its bushings, then check ball joints, tie rod ends, the drag link and alignment. A new steering stabilizer alone usually only hides the problem.

  Shop: track barShop: steering stabilizer▶ How-to videos

• 6.0L oil cooler and EGR cooler failure

  Best left to a shop

  Signs: Coolant loss with no visible leak, white smoke, and engine oil running much hotter than coolant on a scan tool.

  Fix: Replace the oil cooler and EGR cooler, usually with upgraded parts, and flush the cooling system. It's a big job.

  Shop: 6.0 Powerstroke oil coolerShop: 6.0 Powerstroke EGR cooler▶ How-to videos

• 6.0L blown head gaskets

  Best left to a shop

  Signs: Coolant pushed out of the coolant bottle under load, bubbles in the coolant, overheating when towing.

  Fix: Replace head gaskets and install head studs in place of the factory bolts (part of 'bulletproofing'). Fix the oil and EGR coolers at the same time.

  Shop: 6.0 Powerstroke head studs▶ How-to videos

• 6.0L FICM failure

  Moderate DIY

  Signs: Hard starts (especially cold), rough running and misfires.

  Fix: Test the fuel injection control module's voltage. Repair or replace the FICM, and check the batteries, since weak batteries are hard on it.

  Shop: 6.0 Powerstroke FICM▶ How-to videos

• Broken spark plugs (5.4L / 6.8L 3-valve gas)

  Hard DIY

  Signs: Plugs snap off in the head during a tune-up.

  Fix: Use the plug removal procedure for these engines and a broken-plug extractor tool if one snaps. Many owners leave this job to a shop.

  Shop: Ford 3V broken spark plug extractor▶ How-to videos

• Worn ball joints and tie rods

  Hard DIY

  Signs: Clunks over bumps, wandering steering, uneven tire wear, or play when you rock a lifted front wheel.

  Fix: Replace worn ball joints and tie rod ends, then get an alignment. Ball joints need a press tool, which many parts stores lend out.

  Shop: ball jointsShop: tie rod end▶ How-to videos

Recalls

A recall doesn't mean a truck still has the problem. Enter the truck's VIN at nhtsa.gov/recalls or ask a dealer to see whether the repair was done.

• Steering

  Dec 2020 · #20E090000

  Icon Vehicle Dynamics, LLC (Icon) is recalling all 05-UP FSD 2.5 Centerline Stabilizer Kits with part number 65050. The kits were sold as an accessory for certain 2005-2021 Ford F-250 4X4 and F-350 4X4 pickup trucks. The foam ring inside the stabilizer "through shaft" may block the piston ports, possibly causing the steering to lock up.

  Risk and fix

  Risk: If the steering locks, it can increase the risk of a crash.

  Fix: Icon will notify owners, and dealers will install a new shock assembly with a revised foam ring and steel support disc, free of charge. The recall began December 21, 2020. Owners may contact Icon customer service at 1-951-689-4266.

• Exterior Lighting:Tail Lights

  Jul 2011 · #11V352000

  FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.

  Risk and fix

  Risk: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.

  Fix: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.

• Trailer Hitches

  Jul 2008 · #08V344000

  KNAPHEIDE IS RECALLING 108 MY 2006-2008 PRO SERIES TRUCK BEDS EQUIPPED WITH AN ICC BUMPER WHICH INCLUDED A PROVISION FOR A BALL HITCH. THERE MAY BE AN INSUFFICIENT WELD ATTACHING THE HITCH CHANNEL TO THE SUPPORTING STRUCTURE.

  Risk and fix

  Risk: THIS COULD RESULT IN BENDING OF THE HITCH CHANNEL OR THE HITCH COULD BE PULLED OFF THE VEHICLE, INCREASING THE RISK OF A CRASH.

  Fix: KNAPHEIDE WILL OFFER TWO REMEDIES TO ITS CUSTOMERS: (1) FOR THOSE CUSTOMERS WHO DO NOT USE THE HITCH, THE HITCH WILL BE REMOVED FROM THE TRUCK BED AND REPLACED WITH AN ICC BUMPER; OR (2) FOR THOSE CUSTOMERS WHO NEED A HITCH, A RECEIVER HITCH ASSEMBLY WILL BE ADDED TO THE EXISTING HITCH ASSEMBLY AND ALL SUSPECT WELD JOINTS WILL BE RE WELDED. THE RECALL BEGAN ON AUGUST 15, 2008. OWNERS MAY CONTACT KNAPHEIDE AT 1-877-473-5763.

• Equipment

  Mar 2008 · #08E026000

  TRUXXX IS RECALLING 338 AFTERMARKET REPLACEMENT WELDED 3" LIFT BLOCKS FOR REAR SUSPENSIONS, PART NO. 206073, INCLUDED IN SUSPENSION KIT NOS. 108035 AND 108036, SOLD BETWEEN JULY 26, 2007 AND MARCH 4, 2008, FOR USE ON FORD MY 2005-2008 F-250 SUPERDUTY 4X4 LIGHT TRUCKS. COMPRESSIVE FORCES OF THE WELDED LIFT BLOCKS RESULTING FROM FORESEEABLE AND EXCESS VEHICLE PAYLOADS AS WELL AS OVER-TIGHTENING OF THE U-BOLTS DURING INSTALLATION MAY DISTORT THE BLOCKS, REDUCING THE INTENDED CLAMPING FORCE OF THE U-BOLTS.

  Risk and fix

  Risk: THIS COULD ALLOW POSSIBLE SHIFTING AND DAMAGE TO THE REAR DRIVE SHAFT AND AXLE.

  Fix: TRUXXX WILL NOTIFY CUSTOMERS/INSTALLERS AND WILL REPLACE AFFECTED WELDED LIFT BLOCKS WITH EITHER NON-WELDED ALUMINUM OR CAST IRON BLOCKS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT APRIL 16, 2008. OWNERS MAY CONTACT TRUXXX AT 1-800-381-8320.

• Service Brakes, Air

  Oct 2006 · #06E087000

  CERTAIN HARSCO WHEEL MODIFICATION GROUPS CONTAINING ACCURIDE STEEL RIMS, P/NOS. 203237 AND 203738; ACCURIDE ALUMINUM RIMS, P/N 203712; AND GKN STEEL RIMS, P/N 203688, SOLD AS MODIFICATION EQUIPMENT FOR CERTAIN 2005-2007 FORD F-250/F-350 4X4 PICKUP TRUCKS TO MODIFY TRACK WIDTH OF FRONT AND REAR AXLES. THE RIMS PROVIDED IN THESE WHEEL MODIFICATION GROUPS WEAR THROUGH THE OEM BRAKE LINES.

  Risk and fix

  Risk: BRAKE FAILURE CAN OCCUR, POSSIBLY RESULTING IN A VEHICLE CRASH.

  Fix: HARSCO WILL NOTIFY OWNERS AND PROVIDE A REPAIR KIT ALONG WITH REPAIR INSTRUCTIONS FREE OF CHARGE. THE RECALL BEGAN IN SEPTEMBER 2006. OWNERS MAY CONTACT HARSCO AT 507-235-7112.

• Tires:Tread/Belt

  Nov 2005 · #05T022000

  CERTAIN CONTINENTAL CONTITRAC TR OWL, CONTITRAC TR BSW, GENERAL GRABBER TR BSW, AND CONTITRAC BSW TIRES MANUFACTURED BETWEEN MAY 29 AND JUNE 11, 2005, AND SOLD AS ORIGINAL EQUIPMENT ON CERTAIN FORD TRUCKS AND SOLD AS REPLACEMENT TIRES. THESE TIRES CAN WEAR PREMATURELY WHICH FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 119, NEW PNEUMATIC TIRES FOR VEHICLES OTHER THAN PASSENGER CARS.

  Risk and fix

  Risk: AFFECTED TIRES MAY NOT MEET THE ENDURANCE TEST REQUIREMENTS OF THE STANDARD. CONTINUED USE OF THE AFFECTED TIRES CAN RESULT IN TIRE FAILURE WHICH COULD LEAD TO VEHICLE DAMAGE OR MOTOR VEHICLE CRASH.

  Fix: CONTINENTAL WILL NOTIFY OWNERS AND REPLACE THE TIRES FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 7, 2005. OWNERS MAY CONTACT CONTINENTAL AT 704-588-5895.

Owner complaints by area

Reports owners filed with NHTSA. They aren't verified, and one complaint can mention more than one area. Tap an area to read the most recent ones.

• Suspension229

  2 involved a crash

  • Filed Nov 2023

    Purchased my truck last year and was unaware of problems with this truck.whikr traveling couple miles from my home on a paved two lane road I ran over a small gravel or walnut which immediately sent my truck into uncontrollably shaking in the front end my speed was between 30 and 35 mph it was all I could do to get it to the side of the road and stopped.Shaking I got out and looked underneath the front thinking I had a wheel or something about to come off.I couldn't see anything noticeable loose.So I got back in and very slowly continued to my destination.Since then it has happened more times than I can count small hump or raised pavement or even a hole in the road will send it into a shaking fit all I can do is try and get to the side of the road and come to a stop.Im in a fix as this is the only vehicle I own and I can't afford to buy another and no one knows what to do to fix it.I feel like I'm riding in a death trap Everytime I have to run out I try and stay on the back roads where I don't have as much traffic and don't have to go as fast having this happen on the interstate is extremely scary not to mention trying to get to the side of the road and not get ran over by tractor trailers.When I purchased this truck it only had around 53,000 miles on it and is still under 60,000.Ive seen read about the problem Ford is having and that they are doing nothing about it.I think this is a disgrace for a company my own father worked for them for 15 years and it's ashame they don't care about their reputation or their company or the safety of their customers and families.I want my truck added to the list of the ticking time bombs they have out on the road.

  • Filed Nov 2022

    The front end wanders and grabs any road deformities severely enough to put you in another lane

  • Filed Jun 2022

    On 6/25/2022 I experienced violent shaking at freeway speed in southern California. The vehicle was difficult to control - the steering wheel shook violently, and it could be felt throughout the vehicle. The ride was completely smooth when I began the freeway drive; the problem came on all of a sudden, then continued at all speeds, but was particularly violent over 50 MPH. I have not had it inspected yet, but research revealed this is most likely the Ford "Death Wobble" affecting F250 and F350 trucks years 2005 to 2021. I haven't discerned all the information yet as to how to make repairs. My understanding is the cause is inadequate front end suspension parts, a Ford manufacturing safety issue. Mine is a 2006 model, and some articles report that year was notably the worse. There was no traffic accident, no police report was filed, and we made it home safely. There were no warning lights or messages. The truck is not under warranty.

  • Filed Sep 2020

    DEATH WOBBLE WHILE ON FREEWAY GOING 45 + MPH

  • Filed Aug 2020

    WHILE TRAVELING ON PENNSYLVANIA TURNPIKE AT APPROX. 75 MPH I HIT BUMP AND THE FRONT END OF MY TRUCK STARTED BOUNCING AND STEERING WHEEL WAS SHAKING SO BAD I COULD HARDLY CONTROL MY TRUCK. ONCE I SLOWED DOWN ENOUGH X THE SHAKING STOPPED.

  • Showing the 5 most recent of 229.
• Steering180

  5 involved a crash

  • Filed Jul 2024

    Our truck has been doing the "death wobble" several times over the last 2 years. The truck will suddenly shake violently at high speeds and go into limp mode. We have to pull over pumping the brakes slowly. It is EXTREMELY TERRIFYING to have happen and we have spent THOUSANDS trying to get it repaired but it continues.

  • Filed Jul 2024

    While driving on the freeway the vehicle started to shake violently. I had to pump the breaks slowly and pull to the side of the road. After checking everything we took it to the shop and they did 2k in repairs and said it was fixed. It did it again. They said they don't know what it is.

  • Filed Nov 2023

    Purchased my truck last year and was unaware of problems with this truck.whikr traveling couple miles from my home on a paved two lane road I ran over a small gravel or walnut which immediately sent my truck into uncontrollably shaking in the front end my speed was between 30 and 35 mph it was all I could do to get it to the side of the road and stopped.Shaking I got out and looked underneath the front thinking I had a wheel or something about to come off.I couldn't see anything noticeable loose.So I got back in and very slowly continued to my destination.Since then it has happened more times than I can count small hump or raised pavement or even a hole in the road will send it into a shaking fit all I can do is try and get to the side of the road and come to a stop.Im in a fix as this is the only vehicle I own and I can't afford to buy another and no one knows what to do to fix it.I feel like I'm riding in a death trap Everytime I have to run out I try and stay on the back roads where I don't have as much traffic and don't have to go as fast having this happen on the interstate is extremely scary not to mention trying to get to the side of the road and not get ran over by tractor trailers.When I purchased this truck it only had around 53,000 miles on it and is still under 60,000.Ive seen read about the problem Ford is having and that they are doing nothing about it.I think this is a disgrace for a company my own father worked for them for 15 years and it's ashame they don't care about their reputation or their company or the safety of their customers and families.I want my truck added to the list of the ticking time bombs they have out on the road.

  • Filed May 2023

    My son was driving on the freeway, traveling approximately 83 mph, when the vehicle lost power, the engine stalled and he lost the ability to steer the vehicle properly. The vehicle was parked at nearest gas station until i could get to it. After inspecting engine, I noticed some wires that had the insulation coming off. I replaced wiring harness, and when doing so, found the main harness to be severely chafed from rubbing the under side of air filter ducts. When looking around engine bay I noticed other wires with insulation coming off too.

  • Filed Nov 2022

    The front end wanders and grabs any road deformities severely enough to put you in another lane

  • Showing the 5 most recent of 180.
• Engine And Engine Cooling35

  1 involved a crash · 2 involved a fire

  • Filed Jan 2015

    TL*THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING AT 3 MPH, THE ACCELERATOR PEDAL WAS DEPRESSED BUT IT FAILED TO RESPOND. IN ADDITION, THE CONTACT NOTICED SMOKE COMING FROM THE EXHAUST PIPE. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN STATED THAT THE OIL COOLER, THE EXHAUST BACK PRESSURE SENSOR, THE TURBO AND THE EGR VALVE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 160,000.

  • Filed Jan 2015

    THE TRUCK WAS ON A MAJOR INTERSTATE (I-81 NEAR BLACKSBURG EXIT 118A,B,C) DRIVING UPHILL. WHILE TRYING TO MERGE INTO THE RIGHT LANE FROM THE MIDDLE LANE, WHILE LETTING OF THE ACCELERATOR THE ENGINE DIES. AT THIS POINT LOST ALL POWER INCLUDING BRAKES AND STEERING CONTROL. SINCE THERE WAS NO TRAFFIC IMMEDIATELY BEHIND THE TRUCK THEN WAS ABLE TO PULL OVER TO THE FIRST LANE AND GET OFF THE SHOULDER. THE TRUCK DIED AND FORTUNATELY DUE TO LOW TRAFFIC ABLE TO MANEUVER TO THE SHOULDER. AT THAT POINT, TRIED TO START THE TRUCK AND IT WOULD NOT START SO HAD TO REMAIN ON THE SIDE OF INTERSTATE UNTIL HELP COULD ARRIVE. STRANDED ON THE SIDE OF THE INTERSTATE. TRUCK WAS TOWED TO DEALERSHIP. FORD BLOGS INDICATE THERE IS A KNOWN PROBLEM THAT HAS GONE UNADDRESSED. *TR

  • Filed Nov 2014

    TL* THE CONTACT OWNS A 2006 FORD F-250 SD. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE DECELERATED AND THE SERVICE ENGINE SOON AND THE ENGINE WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS DIAGNOSED THAT THE OIL COOLER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 85,000.

  • Filed May 2012

    UPON ACCELERATION, FROM STOP AT A RED LIGHT, VEHICLE HESITATED (STALLED) TO ACCELERATE. UPON ACCELERATION, AFTER SEVERAL SECONDS, THICK CLOUD OF BLACK SMOKE APPEARED FROM EXHAUST PIPE, AND WHITE SMOKE DISCHARGED FROM ENGINE OIL (FILL) TUBE. VEHICLE CONTINUED WITH DESCRIBED PROBLEM(S) FOR THE REST OF THE TRIP, WHICH WAS APPROXIMATELY TEN (10) MINUTES, AND HAS CONTINUED WITH DESCRIBED PERFORMANCE PROBLEMS FOR MANY DAYS SINCE. THIS PROBLEM AROSE AFTER SPENDING OVER $2000 TO HAVE SIMILAR ENGINE PROBLEMS FIXED, AT FORD AUTHORIZED DEALERSHIP. UPON CONTACTING FORD MOTOR COMPANY, DIRECTLY (FOR FINANCIAL ASSISTANCE ON FIXING THE PROBLEM FOR THE SECOND TIME), I WAS INFORMED THAT THERE WOULD BE NO SUCH ASSISTANCE GRANTED. PERIOD. *JS

  • Filed Apr 2012

    2006 FORD F-250. CONSUMER STATES PROBLEM WITH EGR COOLER/EGR VALVE *TGW THE CONSUMER STATED THE PURPOSE OF THE EGR COOLER WAS TO COOL THE EXHAUST. AFTER MAKING SOME INQUIRIES, IT WAS BROUGHT TO HER ATTENTION THAT IT WAS A VERY COMMON PROBLEM. THE CONSUMER WAS INFORMED SINCE THE EGR VALVE WAS NOT MANUFACTURED PROPERLY, IT WAS GETTING PLUGGED UP WITH WET CARBON. THE CONSUMER WAS INFORMED IT WOULD COST $3,000 TO FIX THE PROBLEM. *JB

  • Showing the 5 most recent of 35.
• Engine28

  3 involved a fire

  • Filed Jul 2024

    Our truck has been doing the "death wobble" several times over the last 2 years. The truck will suddenly shake violently at high speeds and go into limp mode. We have to pull over pumping the brakes slowly. It is EXTREMELY TERRIFYING to have happen and we have spent THOUSANDS trying to get it repaired but it continues.

  • Filed Jul 2024

    While driving on the freeway the vehicle started to shake violently. I had to pump the breaks slowly and pull to the side of the road. After checking everything we took it to the shop and they did 2k in repairs and said it was fixed. It did it again. They said they don't know what it is.

  • Filed May 2023

    My son was driving on the freeway, traveling approximately 83 mph, when the vehicle lost power, the engine stalled and he lost the ability to steer the vehicle properly. The vehicle was parked at nearest gas station until i could get to it. After inspecting engine, I noticed some wires that had the insulation coming off. I replaced wiring harness, and when doing so, found the main harness to be severely chafed from rubbing the under side of air filter ducts. When looking around engine bay I noticed other wires with insulation coming off too.

  • Filed Mar 2019

    TL* THE CONTACT OWNS A 2006 FORD F-250. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT MENTIONED THAT THE VEHICLE WAS ABLE TO RESTART ON SOME OCCASIONS. THE FAILURE RECURRED NUMEROUS TIMES. IN ADDITION, THE VEHICLE WAS ACCELERATING INDEPENDENTLY. WHEN THE BRAKE PEDAL WAS DEPRESSED, THE VEHICLE HESITATED TO ACCELERATE. THE VEHICLE WAS TAKEN TO WEST HILLS FORD (1100 OYSTER BAY AVE S, BREMERTON, WA 98312) WHERE IT WAS DIAGNOSED THAT THE THROTTLE BODY NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 52,500.

  • Filed Aug 2018

    EXHAUST MANIFOLD IS SEPARATING FROM THE HEADS (BOTH SIDES); CAB CORNERS AND REAR OUTSIDE FENDERS RUSTED THROUGH NECESSITATING REPLACEMENT; BACK OF MUFFLER BLEW OUT REQUIRING REPLACEMENT.

  • Showing the 5 most recent of 28.
• Electrical System27

  2 involved a crash · 3 involved a fire

  • Filed Jun 2023

    The check engine light continues to stay on no matter what Ford tries to do. We can not get the truck smogged for registration due to this problem.

  • Filed Oct 2018

    WHILE DRIVING VEHICLE DASH CONTROLS, WINDOWS, RADIO ALL SHUT OFF AND TURN BACK ON OCCASIONALLY. IF THE VEHICLE STARTS AND THE CONTROLS ARE NOT CURRENTLY WORKING THE TRUCK IDLES HIGH AND CHUGS. WHEN GAGES ARE NOT WORKING THE BATTERY DOES NOT CHANGE EITHER. THE GAGES SHUT OFF WHILE MOVING, NOT MOVING AND AT TIME S ARE OFF RIGHT WHEN THE TRUCK STARTS. DOES IT WHILE DRIVING STRAIGHT, TURNING, BACK ROADS HIGHWAY AND ALSO DRIVEWAY. WHILE LOOKING ON GOOGLE THERE HAVE BEEN AT LEAST 30 OTHER COMPLAINTS OF THE SAME EXACT ISSUE WITHOUT A 100% FIX FOR THE PROBLEM. FORD NEEDS TO INSPECT AND FIND A WAY TO FIX THIS PROBLEM.

  • Filed Jan 2018

    CHECK ENGINE LIGHT THAT FORD DEALERSHIP COULDN'T FIX, COULDN'T FIND THE PROBLEM EVEN AFTER FULL INSPECTION. CODES APPEARED: P0299, P0401, P0404, P1335.

  • Filed Feb 2017

    STALLING 2006 FORD F-250 6.0 DIESEL, I WAS DRIVING ON THE FREEWAY WITH MY 2 BOYS DOING PROBLAY 60 MPH IN A 65MPH ZONE WHEN I NOTICED THAT THE TRUCK STARTED FIRST SEEMED TO LOOSE POWER THEN SPURTED, THEN 20SECONDS LATER THE RPMS DROPPED FINDING MY SELF WITHOUT NO CONTROL OF THE TRUCK WHAT SO EVER, MEANING IT HAD NO POWER BRAKES NO STEERING AND THE ENGINE COMPLETLY SHUT OFF ! , COASTING TO THE SIDE OF THE FREEWAY BARELY MAKING IT WITHOUT GETTING REAR ENDED ! I COULDNT BELIEVE THIS. I GOT TO THE SIDE OF THE FREEWAY AND TRIED FOR A GOOD 5 TO 7 MINUTES BEFORE CALLING TRIPLE A FOR A TOW, THEN WHILE WAITING FOR THEM TO ARRIVE I TRIED IT ONCE AGAIN TO START THE TRUCK AND GIVE IT GAS WHILE DOING SO IT FIRED UP BUT FOR ABOUT 15 SECONDS IT SOUNDED LIKE IT WAS FIRING ON 4 CYLINDERS OR MISFIRING THEN IT WENT BACK TO NORMAL AND MADE IT HOME. I THEN TOOK THE VEHILE TO THE LOCAL FORD DEALERSHIP, I DON'T KNOW AS OF YET WHATS WRONG WITH IT BUT I CAN TELL YOU I WAS SCARED OVER THIS HAPPENING!

  • Filed Aug 2015

    TL* THE CONTACT OWNS A 2006 FORD F-250. WHILE THE VEHICLE WAS BEING INSPECTED, THE TAIL LIGHTS FAILED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE REAR LIGHTS NEEDED TO BE REPLACED AND THAT THERE WAS AN ELECTRICAL FAILURE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

  • Showing the 5 most recent of 27.
• Service Brakes25

  3 involved a crash · 1 involved a fire

  • Filed Sep 2019

    BOUGHT TRUCK CASH HAD IT 3 WEEKS BRAKE LINES WE CORRODED NEVER LOOKED AT GOT TOLD GARAGE WON'T FIND TRANNY COOLER FITTING AND THE GAS STRAP BROKE OFF AND I HAVE ONLY HAD TRUCK 3 MONTHS NOW AND DEALERSHIP WON'T HELP AND GARAGE WON'T FIX TRUCK AND GOT TURNED AWAY FROM FORD DEALERSHIP..AND I HAVE A 6 MONTH UNLIMITED MILEAGE WARRANTY ON TRUCK..THE TRUCK WAS IN MOTION COMING FROM CHURCH WHEN BRAKE LINES BY ENGINE BLOCK SPRAYED ALL OVER ENGINE..WE WE DRIVING ON A STREET BEHIND OTHER CHURCH GOERS.. I NEEDED THIS TRUCK FOR HAULING AND SUCH AND HAD STRAP BREAKING AND MAY CAUSE FIRE IF TO DRIVE DOWN MAIN HIGHWAY AND IT FALL OUT..

  • Filed Apr 2017

    EMERGENCY BRAKES DO NOT HOLD. HAVE HAD THEM CHECKED FOR ADJUSTMENT SEVERAL TIMES. IS A MAJOR PROBLEM WITH A MANUAL TRANSMISSION AS IT HAS NO PARK PINS. ALTHOUGH MY INSURANCE COVERED IT, IT ACTUALLY ROLLED INTO ANOTHER BUILDING ON MY PROPERTY. I HAVE TO US A WOOD BLOCK AGAINST THE WHEEL TO STOP IT FROM ROLLING ON ALL BUT THE SLIGHTEST INCLINE. THERE HAVE BEEN SEVERAL OCCURRENCES WHEN THIS HAS HAPPENED.

  • Filed Jul 2015

    IN LATE 2011, WHILE DRIVING MY TRUCK DOWN HIGHWAY 90 EAST IN PASCAGOULA, MS, THE TRUCK BEGAN SLOW DOWN AND PULL DRAMATICALLY TO THE RIGHT AFTER APPLYING THE BRAKES. I MANAGED TO WRESTLE WITH THE STEERING WHEEL AND, IN COMBINATION WITH THE SLOWING SPEED, BROUGHT THE TRUCK SAFELY TO A STOP IN A WALMART PARKING LOT IN ABOUT 1 MILE. I INSPECTED THE TRUCK AND THE FRONT RIGHT ROTOR WAS SMOKING AND GLOWING RED HOT. APPARENTLY THE BRAKE CALIPER HAD SEIZED AFTER APPLICATION. I WENT INSIDE WALMART TO KILL TIME AND LET THE BRAKES COOL OFF, HOPING THAT WHEN COOLED, THE CALIPER WOULD RELEASE AND THE TRUCK WOULD BE DRIVABLE. AFTER APPROXIMATELY 1-1/2 HOURS, I RETURNED TO THE TRUCK AND NOTED THAT THE WHEEL WAS NOT SMOKING, BUT WAS STILL RADIATING HEAT. I BEGAN TO DRIVE THE TRUCK AND IT DROVE WITHOUT ANY NOTICEABLE ISSUES UNTIL I APPLIED THE BRAKES AGAIN TO STOP AT A TRAFFIC LIGHT. AFTER RELEASING THE BRAKE, THE TRUCK WAS NOW PULLING TO THE LEFT. EXPECTING A SIMILAR ISSUE, I DECIDED TO DRIVE DIRECTLY TO THE FORD DEALERSHIP IN PASCAGOULA. HOWEVER, UPON NEEDING TO APPLY THE BRAKES AGAIN, THEY DID NOT WORK AT ALL. I HAD TO USE THE PARKING BRAKE TO BRING THE TRUCK TO A STOP AS THE REGULAR BRAKES HAD COMPLETELY FAILED. I CONTINUED TO EXPERIENCE SIMILAR BRAKE ISSUES (PULLING AND HEATING FROM SEIZED CALIPERS) AND IN JUNE 2015 HAD A SIMILAR EXPERIENCE TO THE ONE IN 2011. LOOKING AT BLOGS AND COMPLAINT SITES, FORD'S SUPER DUTY SERIES OF TRUCKS, AS WELL AS F-150S, ARE KNOWN TO HAVE BRAKE ISSUES. THIS IS A SERIOUS PROBLEM THAT FORD NEEDS TO BE HELD ACCOUNTABLE TO FIX. PLEASE HELP. I'M TIRED OF SHELLING OUT $2,000+ WHEN ALL I SHOULD HAVE TO DO IS REPLACE THE BRAKE PADS DUE TO NORMAL WEAR AND TEAR. DUE TO THE SUDDEN AND SEVERE "PULL" AND SUBSEQUENT LOSS OF STOPPING ABILITY, THIS HAS THE POTENTIAL TO BE A VERY SERIOUS SAFETY PROBLEM.

  • Filed Sep 2014

    WHILE DRIVING I NOTICED THAT THE VEHICLE WAS SLUGGISH AND WHEN ENGAGING THE CLUTCH IN ORDER TO SHIFT THERE WAS A NOTICEABLE BRAKING FEELING EVEN THOUGH I WAS NOT TOUCHING THE BRAKE PEDAL. UPON REACHING HOME I SAW MY FRONT WHEELS/ROTORS/CALIPERS SMOKING AND THE HEAT FROM THE WHEELS COULD BE FELT ALMOST 3 FEET FROM THE VEHICLE. I TOOK MY PICK-UP TO THE DEALER AND WAS TOLD THAT MY FRONT CALIPERS HAD FROZEN AS WELL AS THE RIGHT REAR AND THE LEFT REAR WAS JUST AS BAD BUT HAD NOT FROZEN YET AND PROBABLY WOULD. THIS REPAIR REQUIRED FOUR (4) NEW CALIPERS, BRAKE PADS AND REQUIRED THE ROTORS TO BE RESURFACED. THE DEALER SAID THAT NO RECALL HAD BEEN MADE FOR THIS ITEM. *TR

  • Filed May 2014

    TL* THE CONTACT OWNS A 2006 FORD F-250 SUPER DUTY. THE CONTACT STATED THAT THE BRAKES SEIZED AND OVERHEATED. THE VEHICLE WAS TAKEN TO A INDEPENDENT MECHANIC WHO STATED THAT THE CALIPER HOUSING AND BRAKE PADS NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE CURRENT AND FAILURE MILEAGE WAS 125,000.

  • Showing the 5 most recent of 25.
• Tires25

  • Filed Jul 2016

    I HAVE BF GOODRICH RUGGED TRAIL T/A 275 70 R18 TIRES ON MY 2006 FORD F250 WHICH WERE PURCHASED 25 MONTHS AGO AND HAVE 22000 MILES ON THEM. WHILE TOWING MY TRAVEL TRAILER I EXPERIENCED A SLIGHT VIBRATION WHILE DRIVING. I IMMEDIATELY PULLED OVER AND CHECKED THE VEHICLE AND CAMPER FOR NY VISIBLE SIGNS OF A PROBLEM. EVERYTHING A APPEARED TO BE IN GOOD WORKING ORDER SO I CONTINUED ON DRIVING SLOWER. AFTER ABOUT 10 MILES THE TIRE COMPLETELY BLEW UP DAMAGING MY VEHICLE AND SENDING THE TREAD OF THE TIRE ACROSS THE OTHER LANES TRAFFIC WHICH ALMOST CAUSED A MAJOR VEHICULAR ACCIDENT. I THOUGHT IT WAS BAD LUCK. I CHANGED THE TIRE AND CONTINUED DOWN THE ROAD. AFTER APPROXIMATELY ANOTHER 200 MILES I STARTED GETTING THE SAME VIBRATION FROM THE REAR DRIVERS SIDE TIRE. FEARING ANOTHER BLOW OUT AND HAVING NO SPARE TIRE I PULLED OVER AND SPENT THE NIGHT IN A CAMPGROUND. THE NEXT MORNING I WENT OUT TO GET TIRES AND UPON THE TIRE PERSONAL INSPECTING THE TIRE THEY SAID THAT IT HAD A AIR BUBBLE UNDER THE TREAD AND THAT IT TOO WOULD HAVE MORE THAN LIKELY BLOWN OUT ON ME. I DIDN'T THINK THAT THIS WAS COINCIDENCE ANYMORE. SO UPON GETTING HOME I CALLED BF GOODRICH AND MADE A COMPLAINT. THEN I RESEARCHED THE TIRES AND SAW THAT A BUNCH OF THEM WERE RECALLED. JUST THAT MINE WAS NOT WITHIN THE THE MANUFACTURE'S DATE CODE WITH IN A FEW WEEKS. I FEEL THAT IF I HADN'T HAD THAT CAMPER BEHIND ME THAT I PROBABLY COULD HAVE LOST CONTROL OF MY TRUCK WITH POSSIBLE CATASTROPHIC CONSEQUENCES.

  • Filed Jan 2015

    I PURCHASED THIS VEHICLE WITH A FULL SET OF THE EXACT SAME TIRE BRAND, TYPE, SIZE, AND LOAD RANGE. THE NEW TIRES WERE TO REPLACE THE DEFECTIVE TIRES WHICH HAD THE EXACT SAME PROBLEM AS THESE: BELT FAILURE. TIRE FAILURE: BELTS BEGAN TO SEPARATE LEADING TO UNEVEN WEAR AND EVENTUALLY FAILURE OF THE SIDEWALL. *TR

  • Filed Jan 2015

    I PURCHASED THIS VEHICLE WITH A FULL SET OF THE EXACT SAME TIRE BRAND, TYPE, SIZE, AND LOAD RANGE. THE NEW TIRES WERE TO REPLACE THE DEFECTIVE TIRES WHICH HAD THE EXACT SAME PROBLEM AS THESE: BELT FAILURE. TIRE FAILURE: BELTS BEGAN TO SEPARATE LEADING TO UNEVEN WEAR AND EVENTUALLY FAILURE OF THE SIDEWALL. *TR

  • Filed Jan 2015

    I PURCHASED THIS VEHICLE WITH A FULL SET OF THE EXACT SAME TIRE BRAND, TYPE, SIZE, AND LOAD RANGE. THE NEW TIRES WERE TO REPLACE THE DEFECTIVE TIRES WHICH HAD THE EXACT SAME PROBLEM AS THESE: BELT FAILURE. TIRE FAILURE: BELTS BEGAN TO SEPARATE LEADING TO UNEVEN WEAR AND EVENTUALLY FAILURE OF THE SIDEWALL. *TR

  • Filed Jan 2015

    I PURCHASED THIS VEHICLE WITH A FULL SET OF THE EXACT SAME TIRE BRAND, TYPE, SIZE, AND LOAD RANGE. THE NEW TIRES WERE TO REPLACE THE DEFECTIVE TIRES WHICH HAD THE EXACT SAME PROBLEM AS THESE: BELT FAILURE. TIRE FAILURE: BELTS BEGAN TO SEPARATE LEADING TO UNEVEN WEAR AND EVENTUALLY FAILURE OF THE SIDEWALL. *TR

  • Showing the 5 most recent of 25.
• Wheels24

  1 involved a crash

  • Filed Nov 2023

    Purchased my truck last year and was unaware of problems with this truck.whikr traveling couple miles from my home on a paved two lane road I ran over a small gravel or walnut which immediately sent my truck into uncontrollably shaking in the front end my speed was between 30 and 35 mph it was all I could do to get it to the side of the road and stopped.Shaking I got out and looked underneath the front thinking I had a wheel or something about to come off.I couldn't see anything noticeable loose.So I got back in and very slowly continued to my destination.Since then it has happened more times than I can count small hump or raised pavement or even a hole in the road will send it into a shaking fit all I can do is try and get to the side of the road and come to a stop.Im in a fix as this is the only vehicle I own and I can't afford to buy another and no one knows what to do to fix it.I feel like I'm riding in a death trap Everytime I have to run out I try and stay on the back roads where I don't have as much traffic and don't have to go as fast having this happen on the interstate is extremely scary not to mention trying to get to the side of the road and not get ran over by tractor trailers.When I purchased this truck it only had around 53,000 miles on it and is still under 60,000.Ive seen read about the problem Ford is having and that they are doing nothing about it.I think this is a disgrace for a company my own father worked for them for 15 years and it's ashame they don't care about their reputation or their company or the safety of their customers and families.I want my truck added to the list of the ticking time bombs they have out on the road.

  • Filed Mar 2021

    I WAS TRAVELING STRAIGHT ON THE INTERSTATE JUST BELOW THE SPEED LIMIT. I HEARD AN ODD NOISE FELT THE TRUCK FEEL UNSTABLE. I SLOWLY COASTED TO A HALT TO FIND THAT MY REAR PASSENGER TIRE HAD BLOWN OUT. THE ENTIRE SIDEWALL WAS DISINTEGRATED AND THE TIRE WAS DETACHED FROM THE RIM. IT BENT IN MY THE REAR QUARTER PANEL OF MY BED CAUSING AN ESTIMATED $1200 IN DAMAGE.

  • Filed Sep 2020

    DEATH WOBBLE WHILE ON FREEWAY GOING 45 + MPH

  • Filed Aug 2019

    I WAS TRAVELING SOUTH ON I-85 IN MEBANE, NC ON THE NIGHT OF 07/29/19 WHEN THE RIGHT REAR TIRE BEGAN TO VIBRATE EXCESSIVELY. I BEGAN TO SLOW DOWN WHEN THE RIGHT REAR TIRE EXPLODED. APPROXIMATELY ONE-HALF OF THE TREAD DETACHED FROM THE TIRE CAUSING DAMAGE TO THE RIGHT SIDE OF THE TRUCK BED. MICHELIN LT 265 70 R 17 LTX AT/2, 10 PLY TIRES WERE ON THE TRUCK. I REPLACED ALL FOUR TIRES WITH A DIFFERENT BRAND OF TIRE. I CONTACTED MICHELIN ON 08/02/19 TO FILE A CLAIM AND WAS TOLD THAT WITHOUT THE TIRE THAT EXPLODED, A CLAIM COULDN'T BE FILED. I CONTACTED THE TIRE SHOP AND THE TIRES THAT WERE REMOVED FROM MY TRUCK HAVE ALREADY BEEN DISPOSED OF. I HAVE PROOF OF PURCHASE AND PHOTOS OF THE DEFECTIVE TIRE AND DAMAGE DONE TO MY TRUCK. MICHELIN STATED THAT PROOF OF PURCHASE AND PHOTOS WERE NOT ACCEPTABLE. I'M BEING OVERLOOKED FOR MICHELIN'S DEFECTIVE PRODUCTS AND THIS IS NOT GOOD CUSTOMER SERVICE. I GOT A AUTO BODY REPAIR ESTIMATE FOR THE TRUCK ON 08/02/19.

  • Filed Apr 2019

    WHEN DRIVING ABOUT 55 AND IT STARTED SHAKING AND WOBBLING LIKE THOUGHT WE WERE GOING TO FLIP OR SOMETHING. IVE READ A LOT OF OTHER PEOPLE HAVING THIS ISSUE.

  • Showing the 5 most recent of 24.
• Structure14

  • Filed Mar 2021

    I WAS TRAVELING STRAIGHT ON THE INTERSTATE JUST BELOW THE SPEED LIMIT. I HEARD AN ODD NOISE FELT THE TRUCK FEEL UNSTABLE. I SLOWLY COASTED TO A HALT TO FIND THAT MY REAR PASSENGER TIRE HAD BLOWN OUT. THE ENTIRE SIDEWALL WAS DISINTEGRATED AND THE TIRE WAS DETACHED FROM THE RIM. IT BENT IN MY THE REAR QUARTER PANEL OF MY BED CAUSING AN ESTIMATED $1200 IN DAMAGE.

  • Filed Aug 2019

    I WAS TRAVELING SOUTH ON I-85 IN MEBANE, NC ON THE NIGHT OF 07/29/19 WHEN THE RIGHT REAR TIRE BEGAN TO VIBRATE EXCESSIVELY. I BEGAN TO SLOW DOWN WHEN THE RIGHT REAR TIRE EXPLODED. APPROXIMATELY ONE-HALF OF THE TREAD DETACHED FROM THE TIRE CAUSING DAMAGE TO THE RIGHT SIDE OF THE TRUCK BED. MICHELIN LT 265 70 R 17 LTX AT/2, 10 PLY TIRES WERE ON THE TRUCK. I REPLACED ALL FOUR TIRES WITH A DIFFERENT BRAND OF TIRE. I CONTACTED MICHELIN ON 08/02/19 TO FILE A CLAIM AND WAS TOLD THAT WITHOUT THE TIRE THAT EXPLODED, A CLAIM COULDN'T BE FILED. I CONTACTED THE TIRE SHOP AND THE TIRES THAT WERE REMOVED FROM MY TRUCK HAVE ALREADY BEEN DISPOSED OF. I HAVE PROOF OF PURCHASE AND PHOTOS OF THE DEFECTIVE TIRE AND DAMAGE DONE TO MY TRUCK. MICHELIN STATED THAT PROOF OF PURCHASE AND PHOTOS WERE NOT ACCEPTABLE. I'M BEING OVERLOOKED FOR MICHELIN'S DEFECTIVE PRODUCTS AND THIS IS NOT GOOD CUSTOMER SERVICE. I GOT A AUTO BODY REPAIR ESTIMATE FOR THE TRUCK ON 08/02/19.

  • Filed Aug 2018

    EXHAUST MANIFOLD IS SEPARATING FROM THE HEADS (BOTH SIDES); CAB CORNERS AND REAR OUTSIDE FENDERS RUSTED THROUGH NECESSITATING REPLACEMENT; BACK OF MUFFLER BLEW OUT REQUIRING REPLACEMENT.

  • Filed Mar 2018

    2006 FORD F-259. CONSUMER WRITES IN REGARDS TO VEHICLE SHAKING WHILE DRIVING AT SPEEDS OVER 70 MPH. *LD THE CONSUMER STATED THE SHAKING BECAME SO VIOLENT IT FELT AS IF THE FRONT END WAS GOING TO RIP OFF. *JS

  • Filed May 2017

    TL* THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT STATED THAT THE FRAME OF THE VEHICLE RUSTED AND ROTTED AWAY. THE DEALER STATED THAT THE VEHICLE WAS OUT OF WARRANTY AND NOTHING WAS DONE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VEHICLE WAS OUT OF WARRANTY. THE FAILURE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 12,000. THE VIN WAS NOT PROVIDED.

  • Showing the 5 most recent of 14.
• Fuel/Propulsion System13

  1 involved a fire

  • Filed May 2023

    My son was driving on the freeway, traveling approximately 83 mph, when the vehicle lost power, the engine stalled and he lost the ability to steer the vehicle properly. The vehicle was parked at nearest gas station until i could get to it. After inspecting engine, I noticed some wires that had the insulation coming off. I replaced wiring harness, and when doing so, found the main harness to be severely chafed from rubbing the under side of air filter ducts. When looking around engine bay I noticed other wires with insulation coming off too.

  • Filed Aug 2020

    I OWN A 2006 FORD F 250, ON SATURDAY WHILE DRIVING THE VEHICLE ON THE HIGHWAY I NOTICED A WET STREAK BEHIND ME SO I PULLED OVER AND NOTICED GAS GUSHING OUT OF A HOLE IN THE TANK. FORTUNATELY I WAS IN A RURAL AREA CLOSE TO HOME, SO I DROVE IT THE REST OF THE WAY HOME AND PARKED IT IN A FIELD, AWAY FROM ANY BUILDINGS TO ALLOW THE 30+ GALLONS OF GAS TO DRAIN OUT. THE CAUSE OF THE LEAK WAS ONE OF THE STRAPS THAT SECURES THE FUEL TANK BROKE (RUSTED IN HALF) AND THE GAS TANK DROPPED DOWN AND WAS DRAGGING AGAINST THE HIGHWAY. I ATTACHED A PHOTO OF THE STRAP THAT BROKE

  • Filed Dec 2019

    WAS TRAVELING DOWN INTERSTATE 24 AFTER JUST FUELING UP WHEN HIT A ROUGH SPOT ON THE HIGHWAY AND THE FUEL TANK DROPPED OUT OF THE TRUCK LEAVING ME AND MY STEPSON STRANDED ON THE SIDE OF THE INTERSTATE COST ME 1200 DOLLARS TO BE TOWED HOME NOT TO MENTION WHAT THE REPAIR COST ARE GOING TO COST ME

  • Filed Sep 2019

    BOUGHT TRUCK CASH HAD IT 3 WEEKS BRAKE LINES WE CORRODED NEVER LOOKED AT GOT TOLD GARAGE WON'T FIND TRANNY COOLER FITTING AND THE GAS STRAP BROKE OFF AND I HAVE ONLY HAD TRUCK 3 MONTHS NOW AND DEALERSHIP WON'T HELP AND GARAGE WON'T FIX TRUCK AND GOT TURNED AWAY FROM FORD DEALERSHIP..AND I HAVE A 6 MONTH UNLIMITED MILEAGE WARRANTY ON TRUCK..THE TRUCK WAS IN MOTION COMING FROM CHURCH WHEN BRAKE LINES BY ENGINE BLOCK SPRAYED ALL OVER ENGINE..WE WE DRIVING ON A STREET BEHIND OTHER CHURCH GOERS.. I NEEDED THIS TRUCK FOR HAULING AND SUCH AND HAD STRAP BREAKING AND MAY CAUSE FIRE IF TO DRIVE DOWN MAIN HIGHWAY AND IT FALL OUT..

  • Filed Aug 2018

    EXHAUST MANIFOLD IS SEPARATING FROM THE HEADS (BOTH SIDES); CAB CORNERS AND REAR OUTSIDE FENDERS RUSTED THROUGH NECESSITATING REPLACEMENT; BACK OF MUFFLER BLEW OUT REQUIRING REPLACEMENT.

  • Showing the 5 most recent of 13.
• Hydraulic13

  2 involved a crash · 1 involved a fire

  • Filed Sep 2011

    SHIMMY- THE SHIMMY PROBLEM THAT OCCURS IN THE 4X4 F250 SHOULD STILL BE A SIGNIFICANT ISSUE FOR THOSE OF US THAT STILL OWN THESE TRUCKS. THE DEALER TRIED THE TIRE INFLATION STORY WITH ME, BUT THAT DID NOT CORRECT THE PROBLEM. ROAD RACING SPORT CARS FOR MANY YEARS I KNOW THAT ONE POUND CAN MAKE A DIFFERENCE IN HANDLING AND I MADE SURE THAT THE TIRES WERE INFLATED CORRECTLY. THEN THEY TOLD ME THAT FORD SENT THEM A NEW SET OF ALIGNMENT SPECS. WELL AS WE ALL KNOW NOW THAT DID NOT FIX IT EITHER. THEN THEY TOLD ME THAT THE TIRES BEING CUPPED WAS CAUSING THE SHIMMY, MY RESPONSE TO THAT WAS THAT IT WAS THE SHIMMY CAUSING THE TIRES TO CUP NOT THE TIRES BEING CUPPED CAUSING THE SHIMMY, ALTHOUGH THE WORSE THE CUPPING, THE WORSE THE SHIMMY. AFTER INSISTING ON NEW TIRES AND THEN THE NEW LINE UP SPECS, WE TRIED IT AGAIN. THEN 960 MILES LATER AND ONLY ROAD DRIVING THE SAME CUPPING WAS HAPPENING AGAIN. THEN IT WAS THE DAMPENER AND ATTACH POINT THAT WAS THE PROBLEM. THEN 2 YEARS LATER CAME THE LETTER ABOUT DECELERATING AND APPLYING THE BRAKES AND THEN ABOUT 45 MPH IT SHOULD FIX IT. I GUESS THAT WOULD BE OK UNTIL YOUR GOING DOWN THE INTERSTATE AT 70 MPH WITH AN 18 WHEELER BEHIND YOU GOING 70 MPH. WOULD IT BE OK AFTER WHAT COULD BE A SERIOUS AND POSSIBLY FATAL ACCIDENT THAT I COULD PULL OUT MY LETTER THAT I GOT FROM FORD AND TELL EVERYONE, SORRY BUT I DRIVE A FORD. *KB

  • Filed Mar 2011

    TL*THE CONTACT OWNS A 2006 FORD F-250 SUPER DUTY. WHILE HAVING THE BRAKES SERVICED BY AN INDEPENDENT MECHANIC, THE CONTACT WAS INFORMED THAT THE BACKING PLATES FOR THE REAR BRAKES WERE SEVERELY CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 40,000.

  • Filed Mar 2011

    TL*THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT STATED THAT WHEN TRYING TO DECELERATE HE SMELLED A STRONG ODOR. WHEN HE INSPECTED THE VEHICLE, THE CALIPERS ON THE BRAKE LINE HAD DISINTEGRATED. THE MANUFACTURER WAS NOTIFIED AND OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 108,400. UPDATED 04/12/11*LJ THE CONSUMER STATED WHEN HE PULLED THE BRAKE APART, HE NOTICED ONE OF THE TWO CALIPER PISTONS HAD DISINTEGRATED. UPDATED 04/13/11

  • Filed Nov 2010

    TL* THE CONTACT OWNS A 2006 FORD F-250 SUPER DUTY. THE CONTACT STATED THAT THE REAR BRAKES WOULD MALFUNCTION WHEN DRIVING IN REVERSE. THE CONTACT STATED THAT THE BRAKE LINE COLLAPSED CAUSING THE CALIPERS TO CLOSE IN ON THE BRAKE PADS. THIS CAUSED THE CALIPER SEAL TO BURST AND BRAKE FLUID BEGAN LEAKING FROM THE VEHICLE. THE VEHICLE WAS TOWED TO A DEALER WHERE THE ENTIRE REAR BRAKING SYSTEM WAS REPLACED. THE MANUFACTURER ADVISED THE CONTACT THAT REPAIRS WOULD BE AT THE CONTACTS EXPENSE AND THEY WOULD NOT ASSIST. THE CONTACT STATED IF THE VEHICLE WAS TRAVELING AT A HIGHER RATE OF SPEED, A CRASH COULD HAVE POTENTIALLY OCCURRED. THE FAILURE MILEAGE WAS 51,500.

  • Filed Aug 2010

    2006 FORD-250 SD. S10 APPROPRIATE HANDLING-LETTER FROM REGARDING FORD PROBLEMS *TGW THE CONSUMER STATED THE RIGHT REAR CALIPER SEIZED WHICH CAUSED HEAVY SMOKE. THE DEALER INFORMED THE CONSUMER THE CALIPERS WERE DEFECTIVE. THE CONSUMER STATED THE BRAKES STILL HAVE NOT BEEN REPAIRED TO HIS SATISFACTION. THERE WAS A MUSHY FEEL WHEN THE BRAKE PEDAL WAS APPLIED. *JB

  • Showing the 5 most recent of 13.
• Vehicle Speed Control11

  1 involved a fire

  • Filed Jul 2024

    Our truck has been doing the "death wobble" several times over the last 2 years. The truck will suddenly shake violently at high speeds and go into limp mode. We have to pull over pumping the brakes slowly. It is EXTREMELY TERRIFYING to have happen and we have spent THOUSANDS trying to get it repaired but it continues.

  • Filed Jul 2024

    While driving on the freeway the vehicle started to shake violently. I had to pump the breaks slowly and pull to the side of the road. After checking everything we took it to the shop and they did 2k in repairs and said it was fixed. It did it again. They said they don't know what it is.

  • Filed Mar 2019

    TL* THE CONTACT OWNS A 2006 FORD F-250. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT MENTIONED THAT THE VEHICLE WAS ABLE TO RESTART ON SOME OCCASIONS. THE FAILURE RECURRED NUMEROUS TIMES. IN ADDITION, THE VEHICLE WAS ACCELERATING INDEPENDENTLY. WHEN THE BRAKE PEDAL WAS DEPRESSED, THE VEHICLE HESITATED TO ACCELERATE. THE VEHICLE WAS TAKEN TO WEST HILLS FORD (1100 OYSTER BAY AVE S, BREMERTON, WA 98312) WHERE IT WAS DIAGNOSED THAT THE THROTTLE BODY NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 52,500.

  • Filed Sep 2016

    FIKM, INJECTORS, GLO PLUGS, IPR, HARMONIC BALANCER, PRV LOW OIL PUMP, HIGH OIL PUMP, FUEL FILTERS ALL REPLACED BETWEEN 277,000 AND 290,000 MILES ( 1ST TIME ON INJECTORS AND GLO PLUGS AT 277,000 MILES ON A 6.0L 2006 SUPER DUTY DIESEL)DUE TO LACK OF POWER DURING ACCELERATION BETWEEN 65 AND 75 MPH MORE THAN ONCE! SPENT MORE THAN $3,000.00 TO DATE TO CORRECT THIS ISSUE AND NOTHING HAS WORKED! FORD HAS SOME EXPLAINING TO DO, AND IT HAS BAFFLED EVEN ONE OR MORE OF THEIR BEST MECHANICS, AS WELL AS THE TOW TRUCK PERSON THAT HAD TO TOW IT AT 10:00 PM THIS PAST WEEK! NOW WHO IS RESPONSIBLE????? WE HAVE OWNED THIS TRUCK FROM NEW STATUS TO PRESENT AND YES 290,000 MILES ON A 6.0L DIESEL 2006..SURPRISE! THE VEHICLE WAS IN MOTION WHEN THIS ISSUE HAPPENED.... ON BOTH CITY STREETS AND INTERSTATES, AND IN THE DRIVEWAY WITH EMER. BRAKE ON AND ACCELERATION UP TO 2000 RPM'S AND IT CHUGS AND SPITS AND SPUTTERS AND THEN DIES AND WON'T RESTART UNTIL THE NEXT DAY! I CAN PROVIDE YOU SEVERAL RECEIPTS, BUT I AM NOT PUTTING THEM ONLINE FOR ALL TO VIEW VIN NUMBERS, ETC. ANY INFORMATION WILL BE GREATLY APPRECIATED! ALL THIS TROUBLE HAS GONE ON SINCE APRIL OF 2016 TO PRESENT. MY TRUCK IS A WORK VEHICLE AND HAS BEEN A GOOD ONE UNTIL NOW AND HAS TRAVELLED WELL FOR 10 YEARS OLD AND 290,000 MILES. I AM CURRENTLY STUCK IN GEORGIA TRYING TO FIX THIS ISSUE.

  • Filed Jul 2014

    AS I PULLED AWAY FROM A STOP SIGN I THROTTLED UP TO REACH THE APPROPRIATE SPEED LIMIT AND MY 2006 FORD F250 6.0 WENT WIDE OPEN THROTTLE OUT OF NOWHERE. I MASHED ON MY BRAKES TO TRY TO SLOW THE TRUCK DOWN, TO NO SUCCESS. I FLASHED MY LIGHTS AND STROBE LIGHTS AT ON COMING TRAFFIC AS WELL AS BLEW THE HORN TO MAKE OTHER DRIVERS AWARE THAT I COULD NOT STOP. LUCK BEING AGAINST ME THIS DAY THE FIRST VEHICLE I APPROACHED WAS A NC STATE TROOPER. I HAD TO TURN OFF MY IGNITION TO STOP THE TRUCK BUT THE ENGINE KEPT RUNNING AT 4500 RPM SO I SLAMMED IT IN PARK. THE STATE TROOPER GAVE ME A TICKET FOR PASSING HIM AT 80MPH IN A 45. KEEP IN MIND THAT MY TRUCK IS EQUIPPED WITH AN SCT LIVEWIRE TUNER, SO WHEN IT OPENED UP IT LAUNCHED LIKE A ROCKET. THIS IS THE SECOND TIME I'VE HAD THE THROTTLE ISSUE, THE FIRST TIME WAS THE SAME CASE EXCEPT I DID NOT HAD A TUNE ON THE VEHICLE. THERE HAS BEEN SEVERAL REPORTED CASES OF THIS HAPPENING, WITH AND WITHOUT TUNERS ON THE VEHICLE. PLEASE SHARE YOUR INSIGHT IF ANY ONE KNOWS THE CAUSE OF THIS ISSUE. *TR

  • Showing the 5 most recent of 11.
• Power Train10

  • Filed Jan 2016

    TL* THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS AND GOING OVER A BUMP ON THE ROAD, THE FRONT OF THE VEHICLE WOBBLED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE A STABILIZATION BAR WAS INSTALLED HOWEVER, THE FAILURE PERSISTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 15,000.

  • Filed Mar 2012

    F250SD DIESEL ABOUT 65 MI.S.OF ELI,NV. THE CK ENGINE SYMBOL CAME ON,SO I PULLED OVER AND LOOKED UNDER THE HOOD. THERE WAS OIL ALL OVER THE TOP OF THE ENGINE,[MAYBE 1 GAL.]. OIL WAS COMING OUT OF PLASTIC COOLANT OVERFLOW BOX. NO OIL SHOWED ON CHECK STICK. I GOT 2 GAL OF OIL FROM SOMEONE PASSING BY AND LIMPED INTO ELI NV. THE PICKUP SEEMED TO RUN OK AND NO OTHER WARNINGS SHOWED. [I WATCHED TEMPS CLOSELY]. TURNED OUT THE OIL COOLER INTERNAL [UNDER THE INTAKE MANIFOLD] SPRUNG A LEAK AND FORCED OIL INTO THE COOLANT SYSTEM. MY TRUCK WAS BARELY OVER THE 5 YR. WARRANTY SO NO HELP THERE FROM FORD. I ALWAYS WANTED A FORD DIESEL BUT NOT ANYMORE. COST $2200. FOR REPAIRS, AND LOST 3 WEEKS WITH THE TRUCK. HAD TO HIRE A U-HAUL TO GET HOME TO BOISE AND COME BACK FOR MY PICKUP. MY QUESTION IS WHY NO HELP FROM FORD? I STILL HAVE THE BAD COOLER. *TR

  • Filed Sep 2011

    POWER TRAIN HAD REAR MAIN SEAL FAILURE AROUND THIS DATE. POWER TRAIN HAS ANOTHER FAILURE AND LEAK IN SEPTEMBER OF THE SAME YEAR WHICH FORD WILL NO LONGER FIX. VEHICLE HAS LESS THAN 100,000 MILES AND ONLY APPROX 81,000 WHEN THE POWER TRAIN BEGAN TO HAVE PROBLEMS. THIS VEHICLE HAS SEVERAL OTHER ISSUES WHICH FORD WILL NOT ADDRESS. THE CUSTOMER ASSISTANCE CENTER AND THE COMPANY REP WILL ONLY OFFER HALF OFF ON REPAIRS WHICH THEY CLAIM THEY ARE NOT RESPONSIBLE FOR AND WILL NOT ACKNOWLEDGE THE PAST OR OTHER CURRENT PROBLEMS THE VEHICLE IS HAVING. *TR

  • Filed Jun 2010

    TL* THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT STATED WHEN DRIVING OVER AN UNEVEN ROAD SURFACE AT SPEEDS LESS THAN 70 MPH, THE FRONT END WOULD WOBBLE ABNORMALLY. THE DEALER REPLACED THE TRANSMISSION SHIFT AND INSTALLED A DAMPER ON THE FRONT END OF THE VEHICLE. THE FAILURE RECURRED WITHIN FOUR MONTHS. THE VEHICLE WAS NOT DIAGNOSED OR FURTHER REPAIRED. THE FAILURE MILEAGE WAS 17,000 AND THE CURRENT MILEAGE WAS 47,000.

  • Filed Apr 2008

    TL*THE CONTACT OWNS A 2006 FORD F-250 SD. WHILE DRIVING BETWEEN 45-70 MPH, THE ENTIRE VEHICLE SHAKES VIOLENTLY. THE VEHICLE WAS TAKEN TO THE DEALER FOUR DIFFERENT TIMES FOR THIS FAILURE, BUT IT WAS UNABLE TO BE REPAIRED. THE CONTACT TRADED THE VEHICLE IN AT A LOSS. THE FAILURE MILEAGE WAS 4,806.

  • Showing the 5 most recent of 10.
• Unknown or Other9

  • Filed Jun 2023

    The check engine light continues to stay on no matter what Ford tries to do. We can not get the truck smogged for registration due to this problem.

  • Filed Nov 2022

    The front end wanders and grabs any road deformities severely enough to put you in another lane

  • Filed Jun 2019

    I HAVE A 2006 FORD F250 SUPER DUTY 4X4 PICK UP W/ 61.00 MILES , THAT HAS A DEATH WOBBLE WHEN DRIVING OVER 45 MPH. I HAVE REPLACED BOTH HUBS AND SEALS, SHOCKS, STEERING DAMPER, STABILIZER BAR LINKS AND INNER & OUTER TIE RODS. HAVE HAD THE TIRES BALANCED TWICE AND A FRONT END ALIGNMENT. DOES THIS FALL UNDER A RECALL? I HAVE SEEN SERVICE BULLETINS ON THIS. THEY SEEM TO HAVE REPLACED THE SAME PARTS THAT I DID. IS THERE A FIX, AS THIS IS VERY DANGEROUS? THIS DEATH WOBBLE HAPPENS EVERY DAY, SMOOTH OR ROUGH ROADS.

  • Filed Oct 2018

    WHILE DRIVING VEHICLE DASH CONTROLS, WINDOWS, RADIO ALL SHUT OFF AND TURN BACK ON OCCASIONALLY. IF THE VEHICLE STARTS AND THE CONTROLS ARE NOT CURRENTLY WORKING THE TRUCK IDLES HIGH AND CHUGS. WHEN GAGES ARE NOT WORKING THE BATTERY DOES NOT CHANGE EITHER. THE GAGES SHUT OFF WHILE MOVING, NOT MOVING AND AT TIME S ARE OFF RIGHT WHEN THE TRUCK STARTS. DOES IT WHILE DRIVING STRAIGHT, TURNING, BACK ROADS HIGHWAY AND ALSO DRIVEWAY. WHILE LOOKING ON GOOGLE THERE HAVE BEEN AT LEAST 30 OTHER COMPLAINTS OF THE SAME EXACT ISSUE WITHOUT A 100% FIX FOR THE PROBLEM. FORD NEEDS TO INSPECT AND FIND A WAY TO FIX THIS PROBLEM.

  • Filed Jun 2017

    CPSC: THE RIGHT FRONT TIRE DEVELOPED A TERRIBLE BOUNCE ATSPEEDS LESS THAN 30 MPH. I RETURNED THE TRUCK TO RICK'S TIRES AND HE CONTACTED FREESERVICE TIRES. *BF THE CONSUMER WAS ADVISED THE BELTS SEPARATED ON THE LEFT. THE TIRE WAS REPLACED. THE RIGHT REAR TIRE EXPLODED WHILE TOWING A BOAT. THE TIRED HAD A LARGE HOLE AND PART OF THE TREAD SEPARATED FROM THE INNER TIRE. THIS CAUSED DAMAGE TO THE RIGHT PICK UP BED OUTER WALL AND BRACING SUPPORTS. UPDATED 06/28/2017*JS

  • Showing the 5 most recent of 9.
• Fuel System9

  • Filed May 2013

    TL* THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE CONTACT WAS ADVISED THAT THE FUEL PUMP, CIRCUIT AND THE FUEL INJECTORS WOULD HAVE TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT TO NO AVAIL. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 106,000. *TR

  • Filed Jan 2012

    THE FICM (FUEL INJECTOR CONTROL MODULE) ON THE 6.0L POWERSTROKES ARE A KNOWN ITEM TO FAIL. THEY LOSE VOLTAGE AND MAKE INJECTORS NOT WORK, WHICH SHUTS OFF THE VEHICLE. THIS CAN HAPPEN AT ANY TIME WHILE AT AN IDLE OR GOING DOWN THE HIGHWAY. ONCE THIS HAPPENS, THE TRUCK SHUTS OFF AND YOU LOSE POWER STEERING AND BRAKING ABILITY. MINE SHUT OFF WHILE GOING DOWN THE ROAD SEVERAL TIMES NOW, BUT FORD DOES NOT WANT TO WARRANTY IT. MY SMALL TOWN FORD DEALERSHIP REPLACES SEVERAL OF THESE PARTS A WEEK. DOES SOMEONE HAVE TO DIE FOR THEM TO ISSUE A RECALL ON THESE? *TR

  • Filed Jan 2012

    I HAVE A 2006 FORD F250 6.0 IT HAS BEEN TOWED 8 TIMES, I VE HAD TURBO,INJECTOR,ELECTRICAL,WHEEL,TRANS PROBLEMS SINCE DAY ONE OF PURCHASE. THERES OVER 16 PAGES OF MECHANICAL PROBLEMS THAT HAS BEEN PERFORMED AND COUNTING. I KNOW I AM NOT THE ONLY ONE THATS HAVING THESE PROBLEMS AND I CAN'T GET MUCH ASSISTANCE FROM FORD. IT GOING TO TAKE SOMEONE LIKE THIS AGENCY TO HELP US. THIS IS ALOT WHEN YOU PAY $51000.00 PLUS ADDITION REPAIRS FOR A VEHICLE WITH A EXTENTED WARR. *TT

  • Filed Oct 2011

    2006 F-250 SD 6.0 DIESEL ENGINE. A FUEL LEAK ONTO THE ENGINE DEVELOPED DUE TO A DEGRADED O-RING WHERE THE FUEL PRESSURE REGULATOR ASSEMBLY ATTACHES TO THE ENGINE MOUNTED FUEL FILTER. THE LEAKAGE WAS ESTIMATED AT 6 DROPS PER MINUTE WHEN THE ENGINE WAS RUNNING. THE HOUSING AND O-RING ARE SUBJECT TO APPROXIMATELY 45 PSIG AND ARE ON THE UPPER SECTION OF THE ENGINE. THE LEAK WAS DETECTED DUE TO STRONG ODOR OF UNBURNED DIESEL FUMES COMING IN THE HVAC SYSTEM WHEN STOPPED AT A LIGHT AND AT THE FRONT EXTERIOR OF THE TRUCK JUST AFTER SHUTTING THE ENGINE OFF. THE DEALER STATED AND MY OWN RESEARCH ON INTERNET FORUMNS INDICATED THIS IS A COMMON ISSUE. UNDER THE WRONG CIRCUMSTANCES THIS COULD BE A FIRE HAZARD AND AT BEST IS AN ISSUE WITH ENVIRONMENTAL IMPACT TO SOME DEGREE. THE DEALER IS MAKING THIS REPAIR AT MY EXPENSE. *KB

  • Filed May 2011

    2/15/10 ~ FUEL REGULATOR CHANGED. 2/16/10 ~ SENSOR AND CONNECTOR CHANGED. 3/1/2010~ FUEL INJECTORS REPLACED, EGR COLLOR CONNECTOR, HIGH PRESSURE OIL PUMP PRELACED. NOW 1 YEAR LATER ALL INJECTORS NEED TO BE REPLACED AGAIN.

  • Showing the 5 most recent of 9.
• Visibility8

  • Filed Jan 2015

    TL*THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT STATED THAT THE SUN ROOF WINDOW WAS DETACHING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN MADE THE CONTACT AWARE THAT THERE WAS A MANUFACTURER RECALL RELATED TO THE SUN ROOF FAILURE. THE SUN ROOF WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 21,000.

  • Filed May 2008

    THE TRUCK SHOWED NO SIGNS OF TROUBLE LEADING UP TO THE EVENT. WHILE DRIVING APPROXIMATELY 50-55 MILES AN HOUR AND HEADING AROUND A RIGHT HAND CORNER IN THE ROAD THE TRUCK HIT AN INDENTATION IN THE ROAD SURFACE WHICH CAUSED THE TRUCK TO SHAKE UNCONTROLLABLY AND DRIFT INTO THE ONCOMING LANE CAUSING THE TRUCKS MIRROR TO HIT A BOX TRUCK AND SMASH INTO THE INTERIOR OF MY TRUCK. WHEN THE TRUCK SLOWED DOWN TO BELOW 35, I REGAINED CONTROL OF THE VEHICLE AND PULLED OFF TO THE RIGHT SHOULDER. THE BOX TRUCK, APPARENTLY NOT REALIZING WHAT HAD HAPPENED, CONTINUED ON WITHOUT STOPPING. THE MIRROR WAS DESTROYED, GLASS WAS COVERING THE INTERIOR OF MY TRUCK, AND I SUFFERED MINOR CUTS ON MY FACE AND ARM. I RETURNED HOME WITH MY TRUCK AT SPEEDS UNDER 40 MPH, BUT STILL COULD FEEL A SHUDDER WHEN THE TRUCK HIT EITHER A RAISED BUMP OR AN INDENTATION IN THE ROAD. THE DEALER REPLACED SEVERAL PARTS IN THE FRONT END OF THE TRUCK, BUT NOT THE MIRROR. I WAS TOLD THAT THE MIRROR WOULD NOT BE COVERED UNDER WARRANTY. THE TRUCK HAS NOT HAD THE PROBLEM SINCE. I AM NOT AWARE IF THE OLD PARTS ARE STILL AVAILABLE. *TR

  • Filed Apr 2007

    SPEEDOMETER WOULD NO LONGER GO BELOW 26 MPH, EVEN WITH VEHICLE STOPPED AND IGNITION TURNED OFF. DRIVING VEHICLE WOULD INDICATE A SPEED CONSTANTLY 26 MPH FASTER THAN ACTUAL SPEED. BROUGHT TO DEALER WHERE DEALER ORDERED AND LATER REPLACED ENTIRE INSTRUMENT PANEL. SECOND PROBLEM INVOLVED PASSENGER SIDE WIPER ARM FELL OFF WHILE IN OPERATION DRIVING DURING RAIN. DEALER REPLACED WIPER ARM. *JB

  • Filed Mar 2007

    TL*- THE CONTACT STATED THAT WHILE DRIVING THE 2006 FORD F250 WITH N8700 FAILURE MILES AT 30 MPH ON A MODERATELY SNOWY DAY BOTH WINDSHIELD WIPERS FELL OFF WITHOUT ANY WARNING. THE VEHICLE WAS TAKEN TO A DEALER. THE WINDSHIELD WIPERS WERE REPLACED, BUT THE CONTACT WAS CONCERNED THAT THE PROBLEM MIGHT REPEAT ITSELF. THE CURRENT MILEAGE WAS 9000.*AK UPDATED 04/05/07. *JB

  • Filed Jan 2007

    2006 FORD F250 PICKUP. ON 1/14/07, I NOTICED THAT THE RUBBER SEAL AROUND THE WINDSHIELD WAS BEGINNING TO LIFT FROM THE VEHICLE BODY (NEAR THE TOP OF THE WINDSHIELD). I TOOK THE VEHICLE TO MY DEALER WHO HAD A WINDSHIELD PROFESSIONAL INSPECT THE RUBBER. ON 1/23/07, I WAS NOTIFIED BY MY DEALER THAT THE WINDSHIELD PROFESSIONAL GLUED DOWN THE LIFTED PORTION AND THAT IF THERE WERE ANY ADDITIONAL PROBLEMS, IT WOULD NOT BE COVERED BY THE MANUFACTURER'S WARRANTY. NOTHING HAS BEEN ALTERED ON THE VEHICLE TO CAUSE THIS. IT IS A MANUFACTURER DEFECT AND FORD IS CLAIMING THAT IT WAS DAMAGED DURING USAGE. THROUGH FURTHER RESEARCH, I LEARNED THAT FORD CROWN VICTORIA'S HAVE A SIMILAR PROBLEM THAT RESULTED IN A SERVICE BULLETIN. I AM DEMANDING THAT THE ENTIRE WINDSHIELD ASSEMBLY (AND SEAL) BE REPLACED UNDER WARRANTY. *JB

  • Showing the 5 most recent of 8.
• Air Bags7

  5 involved a crash

  • Filed Feb 2012

    I WAS DRIVING DOWN A STREET IN MY 2006 F250 SD, WHEN ALL OF A SUDDEN THE HORN HONKED AND STAYED ON (NOT LIKE HONK HONK BUT LIKE HHHHOOONNNKK) I HAD TO STOP AND PULL THE FUSE TO GET THE HORN TO TURN OFF. IT IS A SAFETY RISK DUE THE WAY OTHER DRIVERS GET STARTLED BUY THIS SUDDEN NOISE. AND MAY VERY WELL CAUSES AND ACCIDENT OR KILL SOME ONE IF IT HAPPENS AT THE WRONG TIME. I HAVE READ ONLINE THAT IS HAPPENS ALOT IN THE 03-06 F250, AND WHEN FORD FIXED MY TRUCK THEY REPLACED THE FUSE BOX, DRIVER SIDE AIR BAG AND HORN ASSEMBLY(AT A COST OF 1486.80). STATING THAT IF I HAD BEEN IN AN ACCIDENT THE AIR BAG MIGHT NOT HAVE DEPLOYED. SO MY LIFE COULD HAVE VERY MUCH BEEN IN DANGER......... THANKS FORD... *TR

  • Filed Oct 2011

    TL* THE CONTACT OWNS A 2006 FORD F-250 SD. THE CONTACT WAS DRIVING 20 -30 MPH ON A WET SURFACE. THE BRAKES WERE APPLIED LIGHTLY AND THE VEHICLE HYDRO-PLANED AND CRASHED INTO A TREE. THE AIR BAGS DID NOT DEPLOY AND THE CONTACTED WAS THROWN INTO THE REAR OF THE VEHICLE WITH THE SEAT BELT RESTRAINED ACROSS HIM. HE SUFFERED INJURIES TO HIS ENTIRE BODY AND WAS TAKEN TO THE HOSPITAL. THE POLICE WERE CALLED AND A REPORT WAS FILED. THE VEHICLE WAS DESTROYED AND THE INSURANCE COMPANY WAS NOTIFIED. THE MANUFACTURER WAS NOTIFIED AND A CLAIM WAS FILED. THE FAILURE MILEAGE WAS 115,000.

  • Filed Apr 2010

    THIS WAS A SINGLE VEHICLE CRASH INVOLVING A 2006 FORD F-250 EXTENDED CAB 4X4 PICKUP ON A COUNTY MAINTAINED GRAVEL SURFACED ROAD. UPON LEAVING THE ROADWAY THE FRONT OF THE VEHICLE STRUCK A TREE HEAD ON, JUST TO THE RIGHT SIDE OF CENTER. THERE WERE NO PASSENGERS, JUST THE OPERATOR IN THE VEHICLE. THE ESTIMATED SPEED WAS 30-35 MPH. THE AIRBAG DID NOT DEPLOY. THE DRIVER WAS TREATED AT A MEDICAL FACILITY AND RELEASED. *TR

  • Filed Apr 2009

    TL*THE CONTACT OWNS A 2006 FORD F-250. WHILE DRIVING BETWEEN 40-45 MPH IN RAINY CONDITIONS, THE CONTACT'S VEHICLE STRUCK AN OPPOSING VEHICLE ON THE DRIVER'S SIDE. THE FRONTAL AIR BAGS FAILED TO DEPLOY, BUT THE CONTACT WAS UNINJURED. THE POLICE WAS CALLED TO THE SCENE AND FILED A REPORT. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER AND REPAIRED. ON APRIL 10, 2009, THE MASTER CYLINDER FAILED AND THE CONTACT CRASHED INTO TWO OTHER VEHICLES. THE AIR BAGS FAILED TO DEPLOY AGAIN. THE DRIVER WAS UNINJURED, BUT HIS VEHICLE SUSTAINED SEVERE BODY DAMAGE. THE VEHICLE WAS TOWED TO A COLLISION CENTER AFTER BEING TOWED TO HIS RESIDENCE. HOWEVER, THE OTHER TWO VEHICLES WERE COMPLETELY DESTROYED THE OCCUPANTS WERE INJURED. THE VEHICLE IS IN THE PROCESS OF BEING INSPECTED AND REPAIRED. THE CAUSE OF THE AIR BAG FAILURES HAS NOT BEEN DETERMINED. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 36,000 AND CURRENT MILEAGE WAS 46,000. UPDATED 05/18/09. *LJ UPDATED 05/20/09.*JB

  • Filed Apr 2008

    2006 FORD F-250 AMBULANCE AIRBAGS DID NOT DEPLOY. CONSUMER STATES THAT THE AMBULANCE WAS INVOLVED IN AN ACCIDENT AND THE AIRBAGS FAILED TO DEPLOY. HE STATES THAT THE AMBULANCE WAS GOING AROUND 50-55 MPH. *KB THE DRIVER OF THE AMBULANCE WAS INJURED, BUT NOT SERIOUSLY. THE DRIVER OF THE VEHICLE, THAT THE AMBULANCE HIT WAS KILLED. *JB

  • Showing the 5 most recent of 7.
• Gasoline5

  • Filed Jan 2012

    THE FICM (FUEL INJECTOR CONTROL MODULE) ON THE 6.0L POWERSTROKES ARE A KNOWN ITEM TO FAIL. THEY LOSE VOLTAGE AND MAKE INJECTORS NOT WORK, WHICH SHUTS OFF THE VEHICLE. THIS CAN HAPPEN AT ANY TIME WHILE AT AN IDLE OR GOING DOWN THE HIGHWAY. ONCE THIS HAPPENS, THE TRUCK SHUTS OFF AND YOU LOSE POWER STEERING AND BRAKING ABILITY. MINE SHUT OFF WHILE GOING DOWN THE ROAD SEVERAL TIMES NOW, BUT FORD DOES NOT WANT TO WARRANTY IT. MY SMALL TOWN FORD DEALERSHIP REPLACES SEVERAL OF THESE PARTS A WEEK. DOES SOMEONE HAVE TO DIE FOR THEM TO ISSUE A RECALL ON THESE? *TR

  • Filed Jan 2012

    I HAVE A 2006 FORD F250 6.0 IT HAS BEEN TOWED 8 TIMES, I VE HAD TURBO,INJECTOR,ELECTRICAL,WHEEL,TRANS PROBLEMS SINCE DAY ONE OF PURCHASE. THERES OVER 16 PAGES OF MECHANICAL PROBLEMS THAT HAS BEEN PERFORMED AND COUNTING. I KNOW I AM NOT THE ONLY ONE THATS HAVING THESE PROBLEMS AND I CAN'T GET MUCH ASSISTANCE FROM FORD. IT GOING TO TAKE SOMEONE LIKE THIS AGENCY TO HELP US. THIS IS ALOT WHEN YOU PAY $51000.00 PLUS ADDITION REPAIRS FOR A VEHICLE WITH A EXTENTED WARR. *TT

  • Filed May 2011

    2/15/10 ~ FUEL REGULATOR CHANGED. 2/16/10 ~ SENSOR AND CONNECTOR CHANGED. 3/1/2010~ FUEL INJECTORS REPLACED, EGR COLLOR CONNECTOR, HIGH PRESSURE OIL PUMP PRELACED. NOW 1 YEAR LATER ALL INJECTORS NEED TO BE REPLACED AGAIN.

  • Filed Oct 2010

    TL* THE CONTACT OWNS A 2006 FORD F250. THE CONTACT ATTEMPTED TO ACCELERATE FROM A COMPLETE STOP, BUT THERE WAS NO ENGINE POWER. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE FUEL FILTER WAS REPLACED. THE FAILURE REOCCURRED TWO DAYS AFTER THE REPAIR. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE BACK TO THE DEALER FOR DIAGNOSIS. THE TECHNICIAN INFORMED THE CONTACT THAT THE FAILURE COULD POSSIBLY BE CONTRIBUTED TO THE FUEL INJECTORS. THE VEHICLE WAS IN THE PROCESS OF BEING REPAIRED. THE VEHICLE HAD NOT BEEN DRIVEN FOR ONE YEAR DUE TO THE INTERMITTENT FAILURES AND INSUFFICIENT REPAIRS. THE FAILURE OCCURRED FOUR DIFFERENT TIMES. THE FAILURE MILEAGE WAS APPROXIMATELY 120,000. THE VIN WAS UNAVAILABLE. UPDATED 12/10/10. *LJ

  • Filed Mar 2006

    DT*: THE CONTACT STATED WITHOUT WARNING, WHILE DRIVING AT ANY SPEED, THE ENGINE WOULD CUT OUT AND STALL WHILE THE ACCELERATOR PEDAL WAS BEING RELEASED. THE VEHICLE RESTARTED AFTER 15 MINUTES. THE DEALERSHIP DETERMINED THE INJECTORS WENT OUT, CAUSING DIESEL TO GET INTO THE OIL. THE INJECTORS WERE REPLACED AND THE OIL CHANGED. SINCE THE REPAIRS, THE TRANSMISSION SLIPS WHILE PULLING A HORSE TRAILER OVER A MOUNTAIN. THE VEHICLE HAS NOT BEEN RETURNED TO THE DEALERSHIP.

• Electronic Stability Control (esc)4

  • Filed Mar 2020

    AT SPEEDS OF OVER 50 MPH, THE VEHICLE SHAKES VIOLENTLY TO THE POINT OF LOSING CONTROL OF STEERING. IN ADDITION, AT SPEEDS OF OVER 15 MPH, THE STEERING WHEEL HAS SO MUCH PLAY THAT ROUGH ROADS CAUSE THE VEHICLE TO TRAVEL LEFT OR RIGHT AND HUGE CORRECTIONS NEED TO BE MADE IN ORDER TO KEEP FROM DRIFTING INTO OTHER LANES. BOTH THESE ISSUES ARE CONSITENT

  • Filed Oct 2018

    WHILE DRIVING VEHICLE DASH CONTROLS, WINDOWS, RADIO ALL SHUT OFF AND TURN BACK ON OCCASIONALLY. IF THE VEHICLE STARTS AND THE CONTROLS ARE NOT CURRENTLY WORKING THE TRUCK IDLES HIGH AND CHUGS. WHEN GAGES ARE NOT WORKING THE BATTERY DOES NOT CHANGE EITHER. THE GAGES SHUT OFF WHILE MOVING, NOT MOVING AND AT TIME S ARE OFF RIGHT WHEN THE TRUCK STARTS. DOES IT WHILE DRIVING STRAIGHT, TURNING, BACK ROADS HIGHWAY AND ALSO DRIVEWAY. WHILE LOOKING ON GOOGLE THERE HAVE BEEN AT LEAST 30 OTHER COMPLAINTS OF THE SAME EXACT ISSUE WITHOUT A 100% FIX FOR THE PROBLEM. FORD NEEDS TO INSPECT AND FIND A WAY TO FIX THIS PROBLEM.

  • Filed Feb 2017

    STALLING 2006 FORD F-250 6.0 DIESEL, I WAS DRIVING ON THE FREEWAY WITH MY 2 BOYS DOING PROBLAY 60 MPH IN A 65MPH ZONE WHEN I NOTICED THAT THE TRUCK STARTED FIRST SEEMED TO LOOSE POWER THEN SPURTED, THEN 20SECONDS LATER THE RPMS DROPPED FINDING MY SELF WITHOUT NO CONTROL OF THE TRUCK WHAT SO EVER, MEANING IT HAD NO POWER BRAKES NO STEERING AND THE ENGINE COMPLETLY SHUT OFF ! , COASTING TO THE SIDE OF THE FREEWAY BARELY MAKING IT WITHOUT GETTING REAR ENDED ! I COULDNT BELIEVE THIS. I GOT TO THE SIDE OF THE FREEWAY AND TRIED FOR A GOOD 5 TO 7 MINUTES BEFORE CALLING TRIPLE A FOR A TOW, THEN WHILE WAITING FOR THEM TO ARRIVE I TRIED IT ONCE AGAIN TO START THE TRUCK AND GIVE IT GAS WHILE DOING SO IT FIRED UP BUT FOR ABOUT 15 SECONDS IT SOUNDED LIKE IT WAS FIRING ON 4 CYLINDERS OR MISFIRING THEN IT WENT BACK TO NORMAL AND MADE IT HOME. I THEN TOOK THE VEHILE TO THE LOCAL FORD DEALERSHIP, I DON'T KNOW AS OF YET WHATS WRONG WITH IT BUT I CAN TELL YOU I WAS SCARED OVER THIS HAPPENING!

  • Filed Aug 2012

    TRUCK HAS HAD THIS PROBLEM SINCE I BOUGHT IT. A SHIMMY AND VIBRATION WHENEVER GOING OVER ANY TYPE OF IMPERFECTION ON THE ROADWAY. FROM A CONSTANT VIBRATION UP TO A SEVERE ALMOST UNCONTROLLABLE SHIMMY. TRUCK WILL EVEN HOP SIDEWAYS WHEN GOING OVER A SMALL PATCH JOB ON THE HWY. I HAVE BOUGHT NEW TIRES, KEEP MY TIRE PRESSURE CONSTANT AND STILL HAVE THE PROBLEM. PLEASE HELP IF A FIX IS KNOWN. THE LAST SET OF TIRES WERE RUINED DUE TO CUPPING. AT $1300.00 A SET, I DO NOT WANT TO HAVE TO REPLACE AGAIN AFTER ONLY 15,000 MILES, BUT MORE THEN THAT, I WOULD HATE TO BE THE ONE CAUSING AN ACCIDENT RESULTING IN INJURY AND EVEN DEATH. PLEASE LET ME KNOW IF FORD HAS COME UP WITH A REMEDY TO THIS PROBLEM. *TR

• Exterior Lighting4

  • Filed Aug 2015

    TL* THE CONTACT OWNS A 2006 FORD F-250. WHILE THE VEHICLE WAS BEING INSPECTED, THE TAIL LIGHTS FAILED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE REAR LIGHTS NEEDED TO BE REPLACED AND THAT THERE WAS AN ELECTRICAL FAILURE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

  • Filed Sep 2014

    DASHBOARD INSTRUMENT PANEL GAUGES AND LIGHTS STOP FUNCTIONING ALSO LOW FUEL LIGHT COMES ON WITH FULL TANK OF FUEL. *TR

  • Filed Jul 2014

    GOING 55MPH THE TRUCK STARTS SHAKING AND SHIMMING. ALL LIGHTS GO IN AND OUT AND BLOWS WHENEVER ANYTHING IS HOOKED UP. *TR

  • Filed Sep 2007

    FORD F-250 WITH NO BRAKE LIGHT OR REAR TURN SIGNALS. CUSTOMER STATES THAT THIS IS A SAFETY DEFECT. HE STATED THAT THE DEALER SAID THEY WOULD BE ABLE TO LOOK AT IT WITHIN 7 DAYS. CONSUMER BELIEVES THAT IS UNACCEPTABLE. *KB

• Seat Belts3

  • Filed Jan 2018

    CHECK ENGINE LIGHT THAT FORD DEALERSHIP COULDN'T FIX, COULDN'T FIND THE PROBLEM EVEN AFTER FULL INSPECTION. CODES APPEARED: P0299, P0401, P0404, P1335.

  • Filed Mar 2015

    TL*THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING AT A VARIOUS SPEEDS, THE FRONT PASSENGER, FRONT MIDDLE AND REAR MIDDLE SEAT BELTS FAILED TO BUCKLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 83,000.

  • Filed Oct 2013

    TL* THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT STATED THAT HE ATTEMPTED TO CONNECT THE SEAT BELT BUT THE BUCKLE WOULD NOT SECURE WITH THE CONNECTOR. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION WHERE THEY STATED THAT THE SEAT BELT BUCKLE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000. UPDATED 12/18/13*CN

• Equipment Adaptive/Mobility3

  • Filed Jul 2013

    I WAS DRIVING ON A TWO LANE BLACKTOP ROAD AT 35 MPH, WHEN THE VEHICLE UNEXPECTLY DIED LOSING ALL POWER, INCLUDING STEERING AND BRAKES. THIS OCCURRED AFTER I HAD JUST EXITED A U.S. HIGHWAY WHERE THE SPEED LIMIT WAS 65 MPH. DUE TO THE FACT THAT I AM A FORMER POLICE DEFENSIVE DRIVING INSTRUCTOR I WAS ABLE TO STEER THE VEHICLE TO A SIDE STREET. I BOUGHT THIS VEHICLE TO TOW A 14,000 LB. FIFTH WHEEL TRAILER AND I AM GLAD IT WAS NOT ATTACHED.. IT TURNED OUT THAT THE PROBLEM WAS THE STC FITTING. FORD TOLD ME THAT THIS PART HAS A COMMON FAILURE PROBLEM AND IT HAS BEEN REPLACED WITH THE REVISED STC FITTING. MY CONCERM IS THAT FAILURE OF THIS PART WITH AN INEXPERIENCED DRIVER ON AN INTERSTATE COULD BE FATAL. THE STC FITTING IS APPARENTLY ATTACHED TO THE HIGH PRESSURE OIL PUMP, AND WHEN IT FAILS YOU LOSE ALL POWER AND THE VEHICLE WILL NOT RESTART. *TR

  • Filed Jan 2012

    I HAVE A 2006 FORD F250 6.0 IT HAS BEEN TOWED 8 TIMES, I VE HAD TURBO,INJECTOR,ELECTRICAL,WHEEL,TRANS PROBLEMS SINCE DAY ONE OF PURCHASE. THERES OVER 16 PAGES OF MECHANICAL PROBLEMS THAT HAS BEEN PERFORMED AND COUNTING. I KNOW I AM NOT THE ONLY ONE THATS HAVING THESE PROBLEMS AND I CAN'T GET MUCH ASSISTANCE FROM FORD. IT GOING TO TAKE SOMEONE LIKE THIS AGENCY TO HELP US. THIS IS ALOT WHEN YOU PAY $51000.00 PLUS ADDITION REPAIRS FOR A VEHICLE WITH A EXTENTED WARR. *TT

  • Filed Jan 2010

    2006 FORD F250 SUPERDUTY TRUCK FLOORMATS ARE CAUSING THE ACCELERATOR PEDAL TO GET STUCK AND THE BRAKES WONT STOP THE TRUCK IF ITS FLOORED. I THOUGHT MY FAMILY WAS GOING TO DIE. WE DIDN'T KNOW WHAT WAS CAUSING THE ACCELERATOR TO STICK. THANK GOD I NOTICED THE MAT OR WE WOULD ALL BE DEAD FOR CERTAIN. PLEASE FOLLOW UP ON THIS ISSUE. MY HUSBAND REVVED THE ENGINE BECAUSE THE TRUCK WAS HAVING OTHER MECHANICAL ISSUES BUT ANYONE WHO MAY FLOOR THEIR VEHICLE COULD KILL THEMSELVES OR OTHERS ON THE ROAD. WE ARE CAUTIOUS OF THIS PROBLEM AND KNOW NOT TO PRESS THE PEDAL TOO FAR DOWN. OTHERS MAY NOT BE AWARE! *TR

• Diesel3

  • Filed May 2013

    TL* THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE CONTACT WAS ADVISED THAT THE FUEL PUMP, CIRCUIT AND THE FUEL INJECTORS WOULD HAVE TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT TO NO AVAIL. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 106,000. *TR

  • Filed Oct 2011

    2006 F-250 SD 6.0 DIESEL ENGINE. A FUEL LEAK ONTO THE ENGINE DEVELOPED DUE TO A DEGRADED O-RING WHERE THE FUEL PRESSURE REGULATOR ASSEMBLY ATTACHES TO THE ENGINE MOUNTED FUEL FILTER. THE LEAKAGE WAS ESTIMATED AT 6 DROPS PER MINUTE WHEN THE ENGINE WAS RUNNING. THE HOUSING AND O-RING ARE SUBJECT TO APPROXIMATELY 45 PSIG AND ARE ON THE UPPER SECTION OF THE ENGINE. THE LEAK WAS DETECTED DUE TO STRONG ODOR OF UNBURNED DIESEL FUMES COMING IN THE HVAC SYSTEM WHEN STOPPED AT A LIGHT AND AT THE FRONT EXTERIOR OF THE TRUCK JUST AFTER SHUTTING THE ENGINE OFF. THE DEALER STATED AND MY OWN RESEARCH ON INTERNET FORUMNS INDICATED THIS IS A COMMON ISSUE. UNDER THE WRONG CIRCUMSTANCES THIS COULD BE A FIRE HAZARD AND AT BEST IS AN ISSUE WITH ENVIRONMENTAL IMPACT TO SOME DEGREE. THE DEALER IS MAKING THIS REPAIR AT MY EXPENSE. *KB

  • Filed May 2008

    AFTER LETTING 2006 F250 DIESEL WARM UP FOR APPROXIMATELY 5MINS, PROCEED TO GET ONTO I-35, ABOUT 5 MILES FROM THE HOUSE WHEN I SET THE CRUISE CONTROL FOR 70MPH EVERYTHING WAS FINE. WITHIN A MILE OF GETTING ON THE HIGHWAY, TRUCK HESITATED AND COMPLETELY STALLED. I MOVE THE VEHICLE ONTO THE SHOULDER OF THE HIGHWAY TO AWAIT A TOW. I TOOK IT TO A FORD DEALERSHIP WHERE THEY FOUND THAT THE FICM WAS BAD. A DAY AFTER I PICKED UP THE TRUCK, AGAIN, THE VEHICLE HESITATED FOR A SECOND BEFORE STALLING IN CITY TRAFFIC. I LOST POWER BRAKES AND POWER STEERING AND WAS VERY DIFFICULT TO GET OFF OF THE CITY STREETS. CURRENTLY TOWED TO THE DEALERSHIP AGAIN, WHERE THE ISSUE IS UNDER INVESTIGATION. CONCERN THAT IF SOMEONE OTHER THAN A 6'4" PERSON WAS DRIVING THIS 7500LB VEHICLE, THEY MAY NOT HAVE BEEN ABLE TO STEER THIS VEHICLE OUT OF THE TRAFFIC. I'VE HEARD OF COMMON COMPLAINTS WITH THE FICM/HPOP/EGR ISSUES WITH THESE TRUCKS AND AM SURPRISED THAT NO RECALL HAS BEEN CREATED BY FORD. *TR

• Equipment3

  1 involved a crash

  • Filed Apr 2011

    AIR CONDITIONING ISSUE: IN TURNING ON THE AIR CONDITIONING IN MY F250 FORD TRUCK THIS YEAR IT DID NOT COOL THE CAB. IN TAKING IT TO A MECHANIC TO SEE WHAT WAS THE PROBLEM, I WAS TOLD THAT 3 TECHNICAL BULLETINS HAD BEEN ISSUED ON THE A/C UNIT. UNLESS THERE WAS A PROBLEM, NO ONE WOULD HAVE CHECKED THE A/C. BULLETINS 06-17-12, 08-13-5 AND 08-13-5 - LACK OF A/C COOLING DUE TO DEFICIENT MATERIAL CLOGGING ORIFICE TUBE. NOW IT IS COSTING OVER $800 FROM MY POCKET TO FIX A PROBLEM THAT FORD ACKNOWLEDGES THAT IT KNOWS ABOUT AND BECAUSE OF THE BAD PART, THE ENTIRE A/C SYSTEM HAS BEEN COMPROMISED. *TR

  • Filed Apr 2010

    THIS WAS A SINGLE VEHICLE CRASH INVOLVING A 2006 FORD F-250 EXTENDED CAB 4X4 PICKUP ON A COUNTY MAINTAINED GRAVEL SURFACED ROAD. UPON LEAVING THE ROADWAY THE FRONT OF THE VEHICLE STRUCK A TREE HEAD ON, JUST TO THE RIGHT SIDE OF CENTER. THERE WERE NO PASSENGERS, JUST THE OPERATOR IN THE VEHICLE. THE ESTIMATED SPEED WAS 30-35 MPH. THE AIRBAG DID NOT DEPLOY. THE DRIVER WAS TREATED AT A MEDICAL FACILITY AND RELEASED. *TR

  • Filed Mar 2010

    TL*THE CONTACT OWNS A 2006 FORD F-250. WHEN THE CONTACT WOULD ATTEMPT TO START HIS VEHICLE HE NOTICED THAT THE KEY WOULD TURN INSIDE THE IGNITION BUT THE ENGINE WOULD NOT START. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC SHOP WHERE THE CONTACT WAS INFORMED THAT THE INJECTOR DRIVING MODULE WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE CURRENT AND FAILURE MILEAGES WERE 160000.

• Seats2

  1 involved a fire

  • Filed Dec 2018

    CAR WAS PARK OVER NIGHT IN FRONT OF MY HOUSE .5 AM NEIGHBOR CAME OUT TO GET NEWSPAPERS AND SAW TRUCK WAS SMOKING FROM INSIDE CAB N SAW FLAME. NEIGHBOR CALL FIRE DEPARTMENT, FIRE DEPARTMENT PUT OUT FIRE FROM INSIDE CAB AND VERIFY IT WAS THE HEATED SEAT MODULE THAT'S CAUSE THE SEAT TO GO UP IN FLAME. HAVE A REPORT FROM THE FIRE DEPARTMENT AND FIRE MARSHAL. WHERE DO I FILE A COMPLAINT FOR WHO IS LIABLE FOR MY REPAIR.? CAUSE THIS IS CLEARLY A MANUFACTURED DEFECT. WHAT IF I WAS IN MY CAR WITH MY KIDS. ? PLEASE HELP DIRECT ME IN THE PATH OR WHOM MAY HELP ME WITH MY SITUATION. THANKS

  • Filed Aug 2006

    BOTH FRONT DRIVER AND PASSENGER ELECTRIC HEATED SEATS SWITCH IS TOO EASILY TO INADVERTENTLY BUMP INTO THE "ON" POSITION BY DRIVER/PASSENGER LEGS. FORD NEEDS TO REDESIGN A RELOCATION OR RETROFIT KIT TO MOVE THE SWITCH OR CHANGE THE MOMENTARY ON/OFF SWITCH TO A DIFFERENT TYPE OF SWITCH. THIS CONDITION HAS MADE ME PULL OFF THE SIDE OF THE ROAD MANY OF TIMES TO LET THE SEAT COOL DOWN WHICH TAKES A WHILE...ESPECIALLY DURING THE SUMMER MONTHS. THIS SITUATION CREATES AN UNEXPECTED SUDDEN HEATING OF THE SEAT AND CAN MAKE THE OPERATOR VERY UNCOMFORTABLE. ADDITIONALLY, I HAD PULL OVER AS FAST AS I COULD LEAVING THE TRUCK AT TIMES IN A VULNERABLE LANE OF TRAFFIC. PLEASE HAVE SOMEONE FROM FORD CALL ME AT [XXX] OR EMAIL ME AT [XXX]FOR ADDITIONAL INFORMATION. *NM INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

• Latches/Locks/Linkages2

  • Filed Mar 2013

    MY HUSBAND DRIVES A 2006 FORD F250 SUPERCAB PICKUP TRUCK WITH APPROXIMATELY 53,000 MILES (LOW MILEAGE FOR THE YEAR OF THE TRUCK). RECENTLY, THE LATCH CABLES ON THE REAR SUICIDE DOORS BOTH BROKE WITHIN 1 MONTH OF EACH OTHER, RENDERING THE REAR DOORS COMPLETELY INOPERABLE. FROM RESEARCHING BLOGS ONLINE, THIS IS CAUSED BY A DEFECTIVE PLASTIC PART IN THE LATCH MECHANISM AND IS QUITE COMMON ON THIS TYPE FORD TRUCK DOOR. THE PARTS AND LABOR ARE QUITE COSTLY ($400 PER DOOR), AS THE WHOLE MECHANISM MUST BE REPLACED, RATHER THAN JUST THE DEFECTIVE PLASTIC PIECE. THIS IS CERTAINLY A SAFETY CONCERN, AS ANYONE IN THE REAR OF THE VEHICLE IS TRAPPED INSIDE, AS THE DOORS WILL NOT UNLATCH AND OPEN. WE WERE TOLD BY FORD CUSTOMER CARE THAT THEY WILL NOT CORRECT THIS PROBLEM AND MUST REPLACE THE LATCH WITH THE SAME TYPE LATCH CABLE THAT HAS ALREADY BROKEN (CASE # [XXX]). THERE IS NO GUARANTEE WITH THE REPLACEMENT THAT IT WILL NOT HAPPEN AGAIN AND IS QUITE A SAFETY CONCERN, ESPECIALLY IF A CHILD IS IN THE REAR SEAT, AS PASSENGERS MAY NOT BE ABLE TO EXIT DURING AN EMERGENCY. WE FEEL THIS SHOULD BE A RECALL ISSUE AND THE DEFECTIVE PIECE SHOULD BE REPLACED AT NO CHARGE. PERHAPS YOUR AGENCY CAN LOOK INTO THIS MATTER TO SEE IF THIS IS AS COMMON A PROBLEM AS IT APPEARS AND IS NOT ISOLATED TO MODEL AND YEAR OF OUR FORD TRUCK. THESE DOORS ARE COMMON ON MANY FORD TRUCKS. FORD WILL NOT PROVIDE A REMEDY OR RELIEF FOR THIS SITUATION. THANKS FOR YOUR TIME. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

  • Filed Dec 2010

    VEHICLE WAS STOLEN OFF LARSON FORDS LOT WITHIN 30 SECONDS. I WAS TOLD BY A DETECTIVE THAT THIS THE F150, 250, 350 ARE VERY EASY TO STEAL BY JABBING A SCREW DRIVER UP AND BEHIND THE DOOR HANDLE WHICH UNLOCKS THE DOOR THEN PUT THE SCREW DRIVER IN THE IGNITION AND START IT UP AND FORD COMPANY KNOWS ALL ABOUT THIS AND DID NOTHING TO FIX THE PROBLEM. *TR

• Traction Control System1

  • Filed May 2010

    I OWN A FORD SUPER DUTY F 250 2006 WAS BOUGHT 03-18-10 .APROX 2 1/2 MONTHS THE TRUCK VIOLENTLY SHAKES AND LOSES CONTROL WHEN HITTING THE SMALLEST BUMP IF EXCEEDING 45 KLM OUR HIGHER. IF YOU APPLY YOUR BRAKES WHILE THIS HAPPENS THE BACK END WILL 360 THIS IS A DEATH TRAP. THIS HAS HAPPENED ABOUT 15 TIMES BUT IT COULD OF BEEN MORE I ONLY DRIVE VERY SLOW AND IN THE SLOW LANE SO IF IT HAPPENS I CAN PULL OVER. I HAVE HAD EVERYTHING REPAIRED ON THIS TRUCK I REPLACED ALL THE HEAVY DUTY SHOCKS THE TIE RODS THE STEERING DAMPER THE ALIGNMENT THE PRESSURE IN MY TIRES AND EVEN THE BRAKES, AT FIRST I THOUGHT THE GARAGE JUST WANTED MY MONEY BUT ONCE SEARCHING ON THE INTERNET I FOUND MANY OTHERS WITH THE EXACT SAME PROBLEMS NO ONE HAS FOUND A SOLUTION TO THE PROBLEMS AND MY OWN MECHANIC SAYS HE HAS EXHAUSTED ALL AVENUES WITH THIS TRUCK. MY BIGGEST FEAR IS SOMEONE WILL HAVE TO DIE TO MAKE FORD UNDERSTAND THERE IS A DEFECT WITH THIS TRUCK AND I DON'T WANT IT TO BE ME. I HAVE NOT DRIVEN THIS TRUCK IN THE WINTER AS OF YET AND CAN TELL YOU WITH EXPERIENCE IF THE TRUCK SHAKES VIOLENTLY AND I HAVE A HAD A TOUGH TIME CONTROLLING IT IN THE SUMMER IMAGINE THE WINTER. SOMEONE NEEDS TO TAKE THIS SERIOUS. JUST TELL ME HOW TO FIX IT AT LEAST I CAN MAKE IT SAFE. *TR

• Electric1

  • Filed Feb 2010

    CRUISE CONTROL WILL NOT DISENGAGE, TRUCK WANTS TO SPEED UP EVEN WITH BRAKE ON, THIS IS AN ONGOING PROBLEM STARTED IN JANUARY OF 2009. *TR

• Electronic Stability Control1

  • Filed Nov 2007

    OWN A 2006 FORD F250 POWERSTROKE DIESEL. WHEN VEHICLE IS DRIVEN AT ABOUT 65-70MPH ON THE HIGHWAY IT TENDS TO START A VIOLENT SHAKE THAT CAN ONLY BE STOPPED BY SLOWING DOWN THE VEHICLE. I ALMOST GOT INTO A FATAL ACCIDENT. THIS HAS NOW OCCURRED ABOUT 7 TIMES. THE VEHICLE HAS ABOUT 24,000 MILES. *TR

• Other1

  • Filed Sep 2007

    BLOWN TURBO - JUNE 07 9/4/07 THE MOTOR RPM RAN UP AS IF A CLUTCH WAS SLIPPING AND THE TRUCK WOULD NOT GO FASTER THAN 35 MPH FOR A MINUTE 3 MILES TO HOME AND TRUCK RAN EXTREMELY ROUGH CALLED FOLSOM LAKE FORD- 14,440 MILES. 9/5/07 BRAD SAYS IT APPEARS TO BE A WIRING HARNESS..SOMETHING TO DO WITH A RUB ON THE EXHAUST BACKPRESSURE HARNESS AND HE WILL CALL ME LATER. QTD, LOOKS LIKE AN INJECTOR, #1 AND THEY WILL ORDER IT AND GET IT PUT IN PROBABLY TOMORROW. 9/6/07 BRAD SAYS INJECTOR REPLACED BUT WANT TO KEEP IT OVERNIGHT. BRAD QTD THAT WE HAVE A LOT OF THESE 6.0'S COME IN AND NO ONE REALLY LIKES DEALING WITH THEM AS THEY CAN BE VERY TROUBLESOME. BRAD QTD THAT TECH WAS GONE BUT WANTED TO KEEP IT FOR A COLD START AND POSS WARM TESTING AND WOULD CALL ME IN THE MORNING. 9/7/07 CALL FROM BRAD 9:21 AM LOOKS GOOD, WILL HOT TEST 11:11AM QTD COMPUTER HAS NOW THROWN A CODE SHOWING #1 AND #5 INJECTORS BAD.. PM 2:24 CALL FROM BRAD, QTD NOT SURE YOU'LL BELIEVE THIS BUT WANT YOU TO KNOW B4 YOU SEE THE PAPERWORK, NOW THE FUEL PUMP HAS GONE BAD. HAVE ALREADY CLEARED IT W/ENTERPRISE FOR YOU TO KEEP THE CAR THROUGH MONDAY..7-8 DAYS. I ASKED IF THE PARTS WOULD BE NEW OR RE-MANUFACTURED AND WAS TOLD THESE WERE NEW. 9/10/07 CALL TO BRAD 11:12AM QTD CHECKED AT 9AM AND THERE WAS NO CHANGE. WOULD CHECK AND CALL ME BACK. CALLED AND SPOKE TO BRAD AT 1:06 PM, BRAD QTD SPOKE WITH TECH AND TECH SPENT 4 HOURS THIS AM ON MY TRUCK DON'T HAVE ANY NEW INFO, GOT PARTS FOR ANOTHER TRUCK IN AND HAVE TO SHELF MATT'S TRUCK AND GO BACK TO THE ONE THAT HAS BEEN IN OUR SHOP LONGER. WE HAVE FOUR IN HERE RIGHT NOW WITH THE SAME PROBLEM. I RQSTD A FORD 250 DIESEL 4X4 WHILE MINE IS BEING FIXED, I QTD ..PAID 45K PLUS TO BE ABLE TO HAUL AND TOW, ALSO I CAN SEAT SIX PASSENGERS. BRAD SAID THAT HE WOULD GET HIS MANAGER TO CALL ME. THEY TELL ME THEY HAVE NO IDEA AND CAN'T GIVE ME ANY TENTATIVE TIME FRAME FOR FIXING MY TRUCK. *TR

Safety ratings

NHTSA 5-Star Safety Ratings from government crash tests. Ratings can differ by cab style and 2WD/4WD.

NHTSA hasn't published star ratings for this truck. Many heavy-duty pickups aren't included in NHTSA's crash-test program, so this doesn't mean the truck is unsafe.