2022 Ford F-350 Super Duty

What owners should know

Covers 2020–2022 · 6.7L Power Stroke diesel, 7.3L V8 and 6.2L V8 gas · Updated 2026-10-01

Researched from owner forums and NHTSA complaints and written by Know Your Truck. These are patterns in what owners report, not a guarantee about any particular truck.

Common failures & how to fix them

Parts and video buttons search for your 2022 Ford F-350 Super Duty. Always confirm a part fits using your VIN. Brakes, steering, fuel and airbag work affects your safety, so if you're not sure, have a qualified mechanic do it.

• 10-speed transmission harsh or delayed shifts

  Best left to a shop

  Signs: Clunky or harsh shifts, a long delay going into Drive or Reverse after the truck sits, trouble holding Park.

  Fix: Have a dealer check for open recalls and software updates and run the transmission's adaptive relearn. Some trucks have needed internal repairs or replacement under warranty.

  May be covered free by recall 22V256000 / 20V365000. Check the VIN at nhtsa.gov/recalls.

  ▶ How-to videos

• 6.7L fuel pump (CP4) recall

  Dealer (recall)

  Signs: Power loss or stalling. Ford found deposits from aged biodiesel can cause the pump to fail.

  Fix: Covered by Ford recall 24S78 (a software update), plus a follow-up for trucks repaired incorrectly. Keep up with fuel filter changes too.

  May be covered free by recall 24V957000 / 26V158000. Check the VIN at nhtsa.gov/recalls.

  Shop: fuel filter kit▶ How-to videos

• Steering column upper shaft

  Dealer (recall)

  Signs: Loose or clunky steering. In rare cases the shaft can separate.

  Fix: Covered by a Ford recall on 2020–2021 trucks.

  May be covered free by recall 25V626000. Check the VIN at nhtsa.gov/recalls.

• 7.3L gas ticking (lifters)

  Best left to a shop

  Signs: A ticking noise that gets louder with engine speed, sometimes a misfire.

  Fix: Have a shop diagnose it. Some owners report lifter or camshaft failures, which are warranty repairs on newer trucks.

  ▶ How-to videos

Recalls

A recall doesn't mean a truck still has the problem. Enter the truck's VIN at nhtsa.gov/recalls or ask a dealer to see whether the repair was done.

• Visibility:Windshield Wiper/Washer:Linkages

  Mar 2026 · #26V204000

  Ford Motor Company (Ford) is recalling certain 2021-2023 Lincoln Navigator, Expedition, and 2022-2023 F-250 SD, F-350 SD, F-450 SD, F-550 SD, and F-600 SD vehicles. The windshield wiper arms may break, causing the wipers to fail.

  Risk and fix

  Risk: Windshield wiper failure can reduce visibility, increasing the risk of a crash.

  Fix: Dealers will inspect and replace the wiper arms, as necessary, free of charge. Owner notification letters were mailed August 5, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S24.Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on April 1, 2026.

• Fuel System, Diesel:Delivery:Fuel Pump

  Mar 2026 · #26V158000

  Ford Motor Company (Ford) is recalling certain 2020-2022 F-Super Duty F250, F350, F450, F550, 2021-2022 F600, and 2022 F750 vehicles previously repaired incorrectly under recall number 24V957. Biodiesel deposits may form on the pump drivetrain roller components, which could lead to failure of the high pressure fuel pump.

  Risk and fix

  Risk: High pressure fuel pump failure can cause a loss of drive power, increasing the risk of a crash.

  Fix: Dealers will update the powertrain control module (PCM) software, free of charge. Owner notification letters were mailed mailed April 7, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S17. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 18, 2026.

• Electrical System: Integrated Trailer Brake Control

  Feb 2026 · #26V104000

  Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."

  Risk and fix

  Risk: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.

  Fix: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.

• Visibility:Sun/Moon Roof Assembly

  Oct 2025 · #25V729000

  Ford Motor Company (Ford) is recalling certain 2021-2022 Expedition, Lincoln Navigator, 2021-2023 F-150, 2022 F-250 SD, F-350 SD, and F-450 SD vehicles. The moonroof wind deflector clips may be inadequately attached to the moonroof frame, which can result in the wind deflector detaching from the vehicle.

  Risk and fix

  Risk: A detached wind deflector can become a road hazard and increase the risk of a crash.

  Fix: Dealers will inspect and repair the moonroof wind deflector as necessary, free of charge. Owner notification letters were mailed November 10, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SB7. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning October 30, 2025.

• Back Over Prevention:Software

  Oct 2025 · #25V686000

  Ford Motor Company (Ford) is recalling certain 2020-2022 F-250 SD, F-350 SD, and F-450 SD vehicles. The 360-degree view camera system may not display a rearview image properly in certain lighting conditions.

  Risk and fix

  Risk: A rearview camera image that does not display properly can reduce the driver’s view behind the vehicle, increasing the risk of a crash.

  Fix: Dealers will update the image processing module software, free of charge.This will be a phased campaign, with the remedy becoming available in different phases based on model years. Interim letters notifying owners of the safety risk were mailed on October 30, 2025. Additional letters will be mailed once the remedy is available on each phase. Owner notification letters were mailed May 19, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA8. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 13, 2025.

• Fuel System, Gasoline:Delivery:Fuel Pump

  Jul 2025 · #25V455000

  Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco, Explorer, Lincoln Aviator, F-250 SD, F-350 SD, F-450 SD, F-550 SD, 2021-2022 Lincoln Navigator, Mustang, F-150, and 2022 Expedition vehicles. The low-pressure fuel pump may fail, which can result in an engine stall while driving.

  Risk and fix

  Risk: An engine stall increases the risk of a crash.

  Fix: Dealers will replace the low pressure fuel pump on super duty vehicles and update the powertrain control module (PCM) software on all other affected vehicles, free of charge. Owner notification letters were mailed July 27, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S75.

• Electrical System: Integrated Trailer Brake Control

  Feb 2025 · #25V132000

  Ford Motor Company (Ford) is recalling certain 2021-2022 F-150, 2022 Maverick, Expedition, Lincoln Navigator, F-250, F-350, F-450, and F-550 vehicles previously repaired incorrectly under recall number 22V-193. Due to a software error, a towed trailer equipped with an electric or electric-over hydraulic brake system may not brake.

  Risk and fix

  Risk: Loss of trailer brake functionality can extend the distance required to stop, increasing the risk of a crash.

  Fix: Dealers will update the integrated trailer brake control module software, free of charge. Owner notification letters were mailed April 11, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S18.

• Back Over Prevention: Sensing System: Camera

  Jan 2025 · #25V048000

  Ford Motor Company (Ford) is recalling certain 2021 Expedition, 2021-2022 Super Duty F-250, F-350, F-450, F-550, F-600, and 2020-2022 Lincoln Corsair vehicles. The rearview camera may display a blank or distorted image.

  Risk and fix

  Risk: Rearview camera failure can reduce the driver's view of what is behind the vehicle, increasing the risk of a crash.

  Fix: Dealers will replace the rearview camera as necessary, free of charge. Owner notification letters were mailed September 18, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S05.

• Fuel System, Diesel:Delivery:Fuel Pump

  Dec 2024 · #24V957000

  Ford Motor Company (Ford) is recalling certain 2020-2022 F-Super Duty F250, F350, F450, F550, F600, and 2021-2022 F-650, F750 vehicles. Biodiesel deposits may form on the pump drivetrain roller components, which could lead to failure of the high pressure fuel pump.

  Risk and fix

  Risk: High pressure fuel pump failure can cause a loss of drive power, increasing the risk of a crash.

  Fix: Dealers will update the powertrain control module (PCM) and Transmission Control Module (TCM) software, free of charge. Owner notification letters were mailed January 23, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S78.

• Power Train:Axle Hubs

  Nov 2023 · #23V758000

  NHTSA warning: do not drive until this recall is fixed.

  Ford Motor Company is recalling certain 2022-2023 Ford Super Duty F-350, F-450, F-550, and F-600 vehicles. The fasteners for the front wheel hub extender may be insufficiently tightened, which can result in the wheel and wheel extender detaching from the vehicle.

  Risk and fix

  Risk: Wheel detachment can result in a loss of vehicle control and create a road hazard, increasing the risk of a crash.

  Fix: Owners are advised not to drive their vehicle until the repair has been performed. Dealers will inspect the front wheel hub extender retaining nuts. If the retaining nuts are loose, dealers will replace the wheel hub extender, retaining nuts, and hub assembly. Repairs will be performed free of charge. Owner notification letters were mailed December 7, 2023. Owners may contact Ford customer service at -866-436-7332. Ford's number for this recall is 23S59.

• Equipment:Other:Owners/Service/Other Manual

  Jun 2023 · #23V420000

  Ford Motor Company (Ford) is recalling certain 2018-2023 Expedition and Lincoln Navigator vehicles equipped with third-row seating; and 2019-2023 F-Super Duty F-250, F-350, F-450, and F-550 SuperCab vehicles. The owner's manual does not include instructions for adjusting or removing certain head restraints. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 202, "Head Restraints."

  Risk and fix

  Risk: Without instructions, the head restraints may be improperly adjusted, increasing the risk of injury in the event of a crash.

  Fix: Ford will mail the Owner's Manual addendums that describe how to adjust and remove the head restraints for the center seating positions, free of charge. Owner notification letters were mailed July 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C20.

• Equipment:Other:Labels

  May 2022 · #22V384000

  Ford Motor Company (Ford) is recalling certain 2022 F-Super Duty F-250, F-350, F-450, F-550, F600, and 2023 E-Series vehicles. In addition, certain 2016 E-Series, 2017 and 2019 F-450, 2021 F-350, and 2021 Transit vehicles that received a reprinted label are also included in this recall. The Safety Certification Labels are missing the tire size, rim type, and tire pressure values for both the front and rear axles. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 110, "Tire Selection and Rim", and 120, "Wheels and Rims-Other Than Passenger Cars."

  Risk and fix

  Risk: Missing tire information could lead to an incorrect tire or rim being installed, or incorrect tire pressure, increasing the risk of a crash.

  Fix: Dealers will replace the Safety Certification Label, free of charge. Owner notification letters were mailed July 6, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22C09.

• Visibility:Windshield Wiper/Washer:Linkages

  Apr 2022 · #22V250000

  Ford Motor Company (Ford) is recalling certain 2020-2021 F-150, Expedition, 2020-2022 Super Duty F-250, F-350, F-450, F-550, and 2020-2021 Lincoln Navigator vehicles. The windshield wiper arms may break, causing the windshield wipers to fail.

  Risk and fix

  Risk: Inoperative windshield wipers can reduce visibility in certain driving conditions, increasing the risk of a crash.

  Fix: Dealers will replace both front windshield wiper arms, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed on May 24, 2022. Remedy parts are expected to be available 3rd Quarter 2022. Owner notification letters were mailed on October 21, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S26.

• Electrical System: Integrated Trailer Brake Control

  Mar 2022 · #22V193000

  Ford Motor Company (Ford) is recalling certain 2021-2022 F-150, 2022 Maverick, Expedition, Lincoln Navigator, F-250, F-350, F-450, and F-550 vehicles. Due to a software error, a towed trailer equipped with an electric or electric-over hydraulic brake system may not brake.

  Risk and fix

  Risk: Loss of trailer brake functionality could result in extended stopping distance, increasing the risk of a crash.

  Fix: Dealers will update the integrated trailer brake control module software, free of charge. Owner notification letters were mailed April 22, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S17.

• Structure:Frame And Members:Underbody Shields

  Feb 2022 · #22V087000

  Ford Motor Company (Ford) is recalling certain 2017-2022 F-250 and F-350 Super Duty vehicles equipped with gasoline engines and aluminum driveshafts. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.

  Risk and fix

  Risk: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.

  Fix: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed on April 7, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S09.

• Air Bags

  Nov 2021 · #21V923000

  Ford Motor Company (Ford) is recalling certain 2022 Super Duty F-250 and F-350 vehicles. The strength of the driver-side air bag cover may be insufficient.

  Risk and fix

  Risk: During a crash, the air bag cover may break apart and project fragments towards occupants, increasing the risk of injury.

  Fix: Dealers will replace the driver-side air bag module, free of charge. Owner notification letters were mailed December 16, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S49.

• Air Bags:Sensor:Side Impact

  Oct 2021 · #21V805000

  Ford Motor Company (Ford) is recalling certain 2022 Super Duty F-250, F-350, 2021 F-150, Expedition, and Lincoln Navigator vehicles. The front-door side impact pressure sensor modules may have been damaged during supplier assembly, which can cause the side impact air bags to not deploy properly in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 214, "Side Impact Protection."

  Risk and fix

  Risk: An air bag that does not deploy properly during a crash increases the risk of injury.

  Fix: Dealers will replace the driver and passenger front door side impact sensors, free of charge. Owner notification letters were mailed November 3, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C26.

Owner complaints by area

Reports owners filed with NHTSA. They aren't verified, and one complaint can mention more than one area. Tap an area to read the most recent ones.

• Electrical System30

  1 involved a crash

  • Filed Sep 2026

    The contact owns a 2022 Ford F-350 SD. The contact stated that while driving 45 MPH, the vehicle lost automotive power. Upon further investigation, the contact became aware that there was water accumulated in the battery junction box. The vehicle was towed to a local dealer to be diagnosed, and the failure was confirmed as water accumulation in the battery junction box. An appointment for the repair was scheduled with the local dealer. The failure mileage was approximately 56,000.

  • Filed Sep 2026

    Vehicle lost complete power unexpectedly.

  • Filed Jul 2026

    fuse box is allowing moisture in causing horn to not stop and truck to remain running. Ford has updates in their manual that this is a problem but no recall issued.

  • Filed Jul 2026

    While traveling with my fifth-wheel camper attached, my 2022 Ford F-350 Super Duty (6.7L Power Stroke) suddenly developed a complete no-crank condition. Prior to the failure, the vehicle displayed multiple electrical warnings, including U0100 (Lost Communication with PCM), High Engine Temperature, AdvanceTrac, Blind Spot System Fault, Hill Start Assist, and Pre-Collision Assist warnings. The vehicle ultimately became disabled and would not crank or start, leaving me stranded away from home while towing a trailer. Repair Description After troubleshooting the vehicle, I discovered severe internal corrosion inside the under-hood Battery Junction Box (BJB). The corrosion appeared consistent with Ford Technical Service Bulletin 23-2133 regarding moisture intrusion into the Battery Junction Box on certain 2020–2022 Super Duty trucks. I purchased a genuine Ford replacement Battery Junction Box from a Ford dealership and installed it. Immediately after replacement, the vehicle started normally and all warning messages disappeared. I retained the failed Battery Junction Box and have photographs documenting the internal corrosion. Safety Concern My concern is not simply the repair cost but the safety implications of this failure. The vehicle became completely disabled while towing a fifth-wheel trailer during travel. A sudden electrical failure affecting the Battery Junction Box can leave occupants stranded and may create hazardous situations if it occurs in remote locations or during travel. Because Ford has issued a Technical Service Bulletin addressing moisture intrusion into the Battery Junction Box, I believe this condition should be evaluated to determine whether additional action is warranted.

  • Filed May 2026

    The contact owns a 2022 Ford F-350. The contact stated while driving at an undisclosed speed, the trailor lights and the brake lights failed to function as intended. No warning lights were ullimunated. The vehicle was taken to the dealer where it was diagnosed with a malfunction with the trailor brakes and service brakes. The contact was informed that the parts were unavailable. The vehicle was not repaired. The contact received a recall notification, NHTSA Campaign Number 22V193000 Electrical System) however the parts were unavailable.

  • Showing the 5 most recent of 30.
• Steering16

  • Filed Apr 2026

    2022 F350 SRW, King Ranch, Tremor Steering column began making clunking sound when hitting rough patches on highway. I then noticed that I was able to lift the steering wheel an inch or two up and also pull it towards me two to three inches and freely push it back in. I could wobble the steering wheel side to side as well. Felt very unsafe as I was on a 7 hour trip home. No warning lights or incident that contributed to problem

  • Filed Sep 2025

    The contact owns a 2022 Ford F-350. The contact stated that while driving at 35 MPH, the steering became inoperable. The contact stated that the steering wheel had separated, but the driver was able to reattach the steering wheel and regain control of the vehicle. The contact was able to depress the brake pedal and pull over to the side of the road. There were no warning lights illuminated. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 25V626000 (Steering). A Ford technician inspected the vehicle. The vehicle was towed to the local dealer, where it was diagnosed that the steering column needed to be replaced. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was approximately 63,019.

  • Filed Jul 2025

    The contact owns a 2022 Ford F-350 SD. The contact stated that while driving over bumps in the roadway, there was a clanking sound coming from the steering column. The contact stated that the failure became progressively worse over time. The vehicle was taken to the local dealer, who was unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 5,000.

  • Filed Jul 2025

    The fan clutch assembly failed and as a result the drive mode would not change from tow/haul mode to any of the other 4 drive modes. Accelerations and decelerations were negatively affected as a result creating safety hazards when driving. The engine was always responding as if a trailer were attached and subsequently accelerations were difficult and decelerations consistently utilized the trailer engine braking system, similar to semi-trucks utilizing the Jake-Braking systems, This is a significant safety issue and needs to have a recall issued for the replacement of these fan clutch assemblies.

  • Filed Jan 2025

    violent shaking , wobbling of the steering wheel

  • Showing the 5 most recent of 16.
• Power Train14

  • Filed Sep 2026

    I have contacted my dealer several times over the past year, and filed a complaint with Ford Motor Company's, Office of General Counsel. To date, NO response from Ford. The dealer relies on Ford for the fix. This is an alarming issue, in that the failure will be mostly unexpected and perhaps catastrophic. I find it unusual and negligent for Ford to take this long for the remedy. My dealer tells me no parts are available. I drive sometimes out of state. I may get stranded and still no one can fix the issue. Ford needs "jacking up" to get this done. Fourteen months have lapsed and its way overdue.

  • Filed May 2026

    While flat towing my 2022 Ford F‑350 behind a motorhome using Ford’s Neutral Tow Mode procedure, the vehicle suffered a catastrophic transmission failure. The Ford dealer documented this clearly on the service invoice: “HAPPENED WHILE THE VEHICLE WAS FLAT TOWED.” After the tow, the truck had severe slipping, delayed engagement, high RPM with no movement, and a wrench light. The dealer confirmed fault codes P0741, P1744, and P27B4. The dealer found catastrophic internal damage: “fluid is burnt with metal debris… filter is packed with metal debris… torque converter has came apart and filled transmission with metal debris… it is catastrophic failure.” These components are available for inspection. The dealer also documented a low battery condition: “batteries. low state of charge.” Ford’s Neutral Tow Mode relies on electronic control modules that require stable voltage, but Ford provides no warning that low voltage can cause the transfer case to exit Neutral Tow Mode. This creates a safety risk because the transmission can be rotated internally without lubrication while being towed, which can lead to sudden drivetrain lockup or loss of control. The problem was confirmed by the Ford dealer, and the vehicle was fully inspected by them. The only warning symptom occurred after towing: wrench light, slipping, and no movement. There were no warnings during the tow itself. This failure mode is not disclosed by Ford and cannot be detected or prevented by the owner.

  • Filed Jul 2025

    The fan clutch assembly failed and as a result the drive mode would not change from tow/haul mode to any of the other 4 drive modes. Accelerations and decelerations were negatively affected as a result creating safety hazards when driving. The engine was always responding as if a trailer were attached and subsequently accelerations were difficult and decelerations consistently utilized the trailer engine braking system, similar to semi-trucks utilizing the Jake-Braking systems, This is a significant safety issue and needs to have a recall issued for the replacement of these fan clutch assemblies.

  • Filed Jul 2025

    Driverside rear axle snapped.There is a recall right now for the 2023 with similar issue. The truck is sitting at Murray ford in kingsland,ga waiting parts to completely replace a new axle. It does go into park or anything

  • Filed May 2025

    1.Spark Plug Wire Failures: oIncident 1: On December 15, 2024, a spark plug wire failure on cylinder #1 caused a misfire and check engine light (code P0301), reducing engine power while towing a 10,000-pound trailer on I-90. Wendle Ford Spokane repaired it under warranty. oIncident 2: On April 10, 2025, another failure on a different cylinder triggered a misfire and check engine light, requiring a $766 repair (invoice attached). These failures are a known defect in 2020–2022 Super Duty trucks, per owner forums and a 7.3L motorhome Technical Service Bulletin. oSafety Risk: Misfires reduce power and control, endangering occupants and other drivers, especially during heavy towing in winter conditions. 2.Front Differential Failure: oOn April 5, 2025, the front differential failed, disabling 4x4 throughout the 2024–2025 winter. Discovered during a snowstorm on a rural job site, the loss of 4x4 compromised traction and stability, requiring a one-week repair. oSafety Risk: Loss of 4x4 in adverse conditions increases the risk of skidding or stranding, particularly for a heavy-duty truck used in construction.

  • Showing the 5 most recent of 14.
• Unknown or Other13

  • Filed Jun 2026

    When the vehicle is moving forward, and rear camera is selected to visibly confirm the status of anything behind the vehicle, there is a giant black bar/box that states "full view not available" Clearly this is a safety hazard in the sense that I am unable to rapidly assess and determine the status of anything behind my vehicle, be it a trailer, a hitch mounted bike rack, or another vehicle. Ford should be required to remove all of these distractions from their software immediately.

  • Filed May 2026

    While flat towing my 2022 Ford F‑350 behind a motorhome using Ford’s Neutral Tow Mode procedure, the vehicle suffered a catastrophic transmission failure. The Ford dealer documented this clearly on the service invoice: “HAPPENED WHILE THE VEHICLE WAS FLAT TOWED.” After the tow, the truck had severe slipping, delayed engagement, high RPM with no movement, and a wrench light. The dealer confirmed fault codes P0741, P1744, and P27B4. The dealer found catastrophic internal damage: “fluid is burnt with metal debris… filter is packed with metal debris… torque converter has came apart and filled transmission with metal debris… it is catastrophic failure.” These components are available for inspection. The dealer also documented a low battery condition: “batteries. low state of charge.” Ford’s Neutral Tow Mode relies on electronic control modules that require stable voltage, but Ford provides no warning that low voltage can cause the transfer case to exit Neutral Tow Mode. This creates a safety risk because the transmission can be rotated internally without lubrication while being towed, which can lead to sudden drivetrain lockup or loss of control. The problem was confirmed by the Ford dealer, and the vehicle was fully inspected by them. The only warning symptom occurred after towing: wrench light, slipping, and no movement. There were no warnings during the tow itself. This failure mode is not disclosed by Ford and cannot be detected or prevented by the owner.

  • Filed Apr 2026

    Front facing camera, located in front grill, has inadequate water proofing, which eventually shorts out the camera and causing it to become inoperable. This creates a blind spot when backing up or driving in tight spaces with such a large truck. When the front camera blacks out, you lose visibility in front of the vehicle. This is a safety issue, because the size of the truck, how high it sits from the factory, and no visibility over the hood could cause a collision with low height persons or kids or property. Yes, this issue has been reproduced by the dealer. And there are numerous reports of people on message forums and social media complaining of this issue. There were no warnings of this prior to failure. One day the front facing camera simply stopped working, leaving a black screen for any camera views that include the front camera.

  • Filed Apr 2026

    Glass roof panel behind sunroof (over rear seats of crew cab) shattered while driving on the highway at 5:30am with no other vehicles within several hundred yards. No sign of impact, remaining glass seems to be pushed outward.

  • Filed Jun 2025

    As a Ford owner, I can vividly recall the 1980’s Ford acronym ‘fix or repair daily’. That comes to mind as my 2022 F350 Platinum Dually has been in the shop for one thing or another more times in 3 years than my 2015 Chevy Impala LTZ has in 10 years. But I digress. The reason for this complaint is my latest malfunction on my Ford vehicle. As mentioned previously, it hasn’t been 3 years and yet another issue with my vehicle has come to light. My passenger roof trim has broken at the connection point, which of all things, was connected via rivet…beneath the rear glass. Apparently, this an extremely common issue among 2017 and up Ford Super Duty. There has been no recall issued. And Ford wants the vehicle owners to pay for the repair. It is an absolute horrible design. The plastic breaks often. And to make matters worse, the rear glass had to be removed to replace the trim. Most of the trim snaps in place but the very end, the end that is cheaply made and connected to a metal rivet, is so fragile and thin that after a few months of driving over American bumpy roads and being beating up the Sun, it cracks, breaks lose, sticks up like a sore thumb, and otherwise detracts from the reputation of the Ford Brand. My vehicle is still under the original warranty as I have only 22,240 miles, and I purchased and extended warranty with adds 4 more years. This needs to be remedied and Ford owners need to be compensated for monies spent to repair these manufacturing defects. MY LOCAL FORD DEALERSHIP STATES THAT IF THEY BREAK THE GLASS DURING THE REPAIR THAT THE COST OF THE NEW GLASS IS MY RESPONSIBILITY, EVEN UNDER WARRANTY. That is so very wrong and alarming. The repair is $125, to be completed by an outside vendor. The dealer will not even tackle this repair. THE CONNECTION POINT OF THE ROOF TRIM IS A RIVET. Why? THE CONNECTION POINT OF THE ROOF TRIM IS BENEATH THE REAR GLASS, WHICH HAS TO BE REMOVED INORDER TO REPAIR THE DEFECTIVE ROOF TRIM. Why? Why make

  • Showing the 5 most recent of 13.
• Service Brakes12

  • Filed May 2026

    Trailer Brake Module Failure message at start up. I no longer have any trailer brake function. I was towing when this happened.

  • Filed Apr 2026

    This is not a failed component, the issue is a design interaction issue. This truck when it gets stuck as it unfortunately very easily does even on wet grass goes into a traction control mode where the throttle is VERY damped but the issue is not only is the opening very dampened the closing is also VERY damped. This is made significantly worse by the fact that traction control cannot actually be disabled. There is a switch and it indicates it is disabled but the functionality remains the same. This combination means whenever you're working to get the truck unstuck, like yesterday when it was on wet grass you have to expect that the vehicle will suddenly accelerate as soon as it finds traction. normally you can counteract this by expecting to apply significant brakes as soon as it finds traction but if the front wheels are still on a slippery surface the ABS system will lose it's mind and essentially disable brakes as the vehicle accelerates violently backwards with the new found traction. This combination of software decisions makes it so you can very easily replicate an unintended acceleration scenario where the vehicle jumps back a solid 20' when this happens, not respecting any brake input given by the driver and certainly not respecting that the throttle was released long ago. The throttle closing should not be damped when traction control is running and the ABS system should not be behaving the way it does. I understand getting the vehicle unstuck from wet grass is not normal operation but that's what the traction control disable button should be for and Ford makes that button useless also. When taken together, all these engineering decisions make for a very unsafe situation that has zero reason to exist. I've attached pictures that show the overview of the situation as well as the characteristic ABS marks showing that it was disabling brakes.

  • Filed Sep 2025

    Integrated trailer brake controller failing. Surging and randomly releasing trailer brakes. I tow a 16k lb. Trailer.

  • Filed Jul 2024

    The contact owns a 2022 Ford F-350 SD. The contact stated that while hauling a trailer, the brakes failed to operate as needed. The vehicle was taken to the local dealer, who updated and replaced the Auxiliary Power Interface Module (APIM) several times. The vehicle was repaired, but the failure recurred. Additionally, the radio turned on without driver interaction. The contact stated that the Forward Collision Avoidance system and the mirrors were turning on and off, the crash alert was engaged, and the brake was applied without driver input. The steering wheel was vibrating. The manufacturer was contacted and declined a buyback of the vehicle. The failure mileage was approximately 100.

  • Filed Oct 2023

    Trailer brakes continuously go out on multiple trailers with an associated right turn lamp fault. There was a related recall but did not cover all of the vehicles this is happening to. Manufacturer Recall Number: 22S17 NHTSA Recall Number: 22v193

  • Showing the 5 most recent of 12.
• Fuel System12

  1 involved a crash

  • Filed Apr 2026

    The contact owns a 2022 Ford F-350 SD. The contact stated that while attempting to accelerate from a complete stop, the vehicle lost power. There was no warning light illuminated. The vehicle was able to restart. The contact received notification of NHTSA Campaign Numbers: 25V455000 (Fuel System, Gasoline), 25V686000 (Back Over Prevention), 26V104000 (Electrical System, Exterior Lighting), and 26V204000 (Visibility); however, the parts to do the recall repairs were not yet available. The vehicle was taken to the dealer but was not diagnosed or repaired. The dealer stated that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 30,000.

  • Filed Dec 2025

    The contact owns a 2022 Ford F-350 SD. The contact received the recall notice for NHTSA Campaign Numbers: 25V455000 (Fuel System, Gasoline) and 25V686000 (Back Over Prevention). The contact expressed safety concerns about driving the recalled vehicle. The local dealer was contacted and confirmed that the parts to do the recall repairs were not available. The manufacturer was contacted by mail regarding vehicle rental and buyback assistance, which was denied. The contact had not experienced a failure.

  • Filed Nov 2025

    The contact owns a 2022 Ford F-350 SD. The contact received notification of NHTSA Campaign Number: 25V455000(Fuel System, Gasoline). The contact was concerned about driving the vehicle. The local dealer was contacted and informed the contact that there was no related recall information from the manufacturer. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The contact had not experienced a failure.

  • Filed Oct 2025

    The contact owns a 2022 Ford F-350 SD. The contact received notifications of NHTSA Campaign Numbers: 25V455000 (Fuel System, Gasoline) and 25V686000 (Back Over Prevention); however, the parts to do the recall repairs were unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repairs. The contact stated that while attempting to accelerate from a stop, the vehicle hesitated before accelerating. There were no warning lights illuminated. The dealer was contacted, and it was confirmed that parts were not yet available. The manufacturer was made aware of the issue. The failure mileage was unknown.

  • Filed Oct 2025

    The contact owns a 2022 Ford F-350 SD. The contact received notifications of NHTSA Campaign Numbers: 22V250000 (VISIBILITY), 24V957000 (FUEL SYSTEM, DIESEL), and 25V686000 (Back Over Prevention). However, the parts to do two of the recall repairs were not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

  • Showing the 5 most recent of 12.
• Engine11

  • Filed Sep 2026

    Vehicle lost complete power unexpectedly.

  • Filed Sep 2026

    I have contacted my dealer several times over the past year, and filed a complaint with Ford Motor Company's, Office of General Counsel. To date, NO response from Ford. The dealer relies on Ford for the fix. This is an alarming issue, in that the failure will be mostly unexpected and perhaps catastrophic. I find it unusual and negligent for Ford to take this long for the remedy. My dealer tells me no parts are available. I drive sometimes out of state. I may get stranded and still no one can fix the issue. Ford needs "jacking up" to get this done. Fourteen months have lapsed and its way overdue.

  • Filed Sep 2025

    NHTSA Complaint Draft Vehicle Information: Year/Make/Model: 2022 Ford F-350 VIN: [XXX] Recall Campaign: 25S75 / 25V455 Mileage: 38606 Problem Description: My 2022 Ford F-350 is subject to recall 25S75/25V455 (low-pressure fuel pump failure). Ford notified me on July 8, 2025, that no remedy is currently available. The recall states the fuel pump can fail, resulting in a loss of fuel pressure and engine stall while driving. This creates a serious safety risk of crash or injury. Despite acknowledging the defect, Ford has not provided a remedy, a timeline for repair, or safe alternative transportation. I feel unsafe driving this vehicle, and I am still financially responsible for it. Safety Concern: The risk of the engine stalling while driving, especially at highway speeds, creates an immediate danger to myself, passengers, and other motorists. Resolution Sought: Require Ford to provide a safe loaner or rental vehicle until a remedy is available, OR Require Ford to buy back or pay off the balance of this unsafe vehicle until the defect is resolved. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

  • Filed Jul 2025

    Sudden loss of acceleration at highway speed. Engine sputtered and died as I coasted to a stop on a two lane bridge. Very dangerous location. Was able to restart engine. Ford dealer at next exit. Checked out and no codes thrown. Advised to keep driving until recurrence. Took to hometown Ford dealership and after three days reported no codes, no recurrence, and no problems detected. Advised to keep driving until recurrence.

  • Filed Jul 2025

    1 month ago my vehicle intermittently would not shut off. You could hit the Start/Stop button and from all dash board appearances the truck was off, but the truck was still running. I resorted to pulling a circuit breaker to get the truck off. I found NHTSA 10226938 and replaced the Battery Junction Box as prescribed. This fixed the vehicle for a few weeks, but now the issue is back. There is no water intrusion in the BSB junction box.

  • Showing the 5 most recent of 11.
• Back Over Prevention10

  • Filed Aug 2026

    The contact owns a 2022 Ford F-350 SD. The contact received notification of NHTSA Campaign Number: 25V686000 (Back Over Prevention). The contact stated that while in reverse(R) on several occasions, the rear-view camera was black. The contact stated that on one occasion while his wife was driving the vehicle and shifted into reverse(R), the camera went black, and the vehicle reversed into a cement pole. The vehicle was taken to a dealer where the vehicle was not diagnosed; however, the contact was informed that the part to repair the vehicle was not yet available. The manufacturer was not notified of the failure. The failure mileage was approximately 1,500.

  • Filed Jul 2026

    While traveling with my fifth-wheel camper attached, my 2022 Ford F-350 Super Duty (6.7L Power Stroke) suddenly developed a complete no-crank condition. Prior to the failure, the vehicle displayed multiple electrical warnings, including U0100 (Lost Communication with PCM), High Engine Temperature, AdvanceTrac, Blind Spot System Fault, Hill Start Assist, and Pre-Collision Assist warnings. The vehicle ultimately became disabled and would not crank or start, leaving me stranded away from home while towing a trailer. Repair Description After troubleshooting the vehicle, I discovered severe internal corrosion inside the under-hood Battery Junction Box (BJB). The corrosion appeared consistent with Ford Technical Service Bulletin 23-2133 regarding moisture intrusion into the Battery Junction Box on certain 2020–2022 Super Duty trucks. I purchased a genuine Ford replacement Battery Junction Box from a Ford dealership and installed it. Immediately after replacement, the vehicle started normally and all warning messages disappeared. I retained the failed Battery Junction Box and have photographs documenting the internal corrosion. Safety Concern My concern is not simply the repair cost but the safety implications of this failure. The vehicle became completely disabled while towing a fifth-wheel trailer during travel. A sudden electrical failure affecting the Battery Junction Box can leave occupants stranded and may create hazardous situations if it occurs in remote locations or during travel. Because Ford has issued a Technical Service Bulletin addressing moisture intrusion into the Battery Junction Box, I believe this condition should be evaluated to determine whether additional action is warranted.

  • Filed Apr 2026

    The right rear corner parking sensor on the truck has a 3 foot range. I believe these rear back up sensors normally should have a 12-15 foot range. I was backing up at an angle at slow speeds at hit a large brick mailbox. The mailbox is below the height of the closed tailgate. This could have been a adult or child. The sensor triggered but I did not stop in time. At 5mph a 3 foot distance is covered in .4 seconds. I replaced the bumper and the bumper cover as a result of this .

  • Filed Apr 2026

    The contact owns a 2022 Ford F-350 SD. The contact stated that while attempting to accelerate from a complete stop, the vehicle lost power. There was no warning light illuminated. The vehicle was able to restart. The contact received notification of NHTSA Campaign Numbers: 25V455000 (Fuel System, Gasoline), 25V686000 (Back Over Prevention), 26V104000 (Electrical System, Exterior Lighting), and 26V204000 (Visibility); however, the parts to do the recall repairs were not yet available. The vehicle was taken to the dealer but was not diagnosed or repaired. The dealer stated that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 30,000.

  • Filed Dec 2025

    The contact owns a 2022 Ford F-350 SD. The contact received the recall notice for NHTSA Campaign Numbers: 25V455000 (Fuel System, Gasoline) and 25V686000 (Back Over Prevention). The contact expressed safety concerns about driving the recalled vehicle. The local dealer was contacted and confirmed that the parts to do the recall repairs were not available. The manufacturer was contacted by mail regarding vehicle rental and buyback assistance, which was denied. The contact had not experienced a failure.

  • Showing the 5 most recent of 10.
• Fuel/Propulsion System8

  • Filed Sep 2026

    Vehicle lost complete power unexpectedly.

  • Filed Aug 2026

    I find it absolutely absurd that the fuel pump recall is still not resolved! When are you going to hold Ford accountable for this egregious delay? This has been over a year now. Everyday I drive my truck and tow my travel trailer wondering if at anytime it may just die on me on the highway.

  • Filed Jul 2026

    I have been waiting over a year for this low pressure fuel pump recall and it has stopped me from driving long distance to visit my daughter where part of the trip is hoursbthrew the Nevada high desert with extreme heat and NO CELL SERVICE. I AM FED UP AND NEED YHISNISDUE REDOVLED NOW OR A NEW DARN TRUCK. PLEASE ADVISE

  • Filed Sep 2025

    NHTSA Complaint Draft Vehicle Information: Year/Make/Model: 2022 Ford F-350 VIN: [XXX] Recall Campaign: 25S75 / 25V455 Mileage: 38606 Problem Description: My 2022 Ford F-350 is subject to recall 25S75/25V455 (low-pressure fuel pump failure). Ford notified me on July 8, 2025, that no remedy is currently available. The recall states the fuel pump can fail, resulting in a loss of fuel pressure and engine stall while driving. This creates a serious safety risk of crash or injury. Despite acknowledging the defect, Ford has not provided a remedy, a timeline for repair, or safe alternative transportation. I feel unsafe driving this vehicle, and I am still financially responsible for it. Safety Concern: The risk of the engine stalling while driving, especially at highway speeds, creates an immediate danger to myself, passengers, and other motorists. Resolution Sought: Require Ford to provide a safe loaner or rental vehicle until a remedy is available, OR Require Ford to buy back or pay off the balance of this unsafe vehicle until the defect is resolved. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

  • Filed Jul 2025

    Sudden loss of acceleration at highway speed. Engine sputtered and died as I coasted to a stop on a two lane bridge. Very dangerous location. Was able to restart engine. Ford dealer at next exit. Checked out and no codes thrown. Advised to keep driving until recurrence. Took to hometown Ford dealership and after three days reported no codes, no recurrence, and no problems detected. Advised to keep driving until recurrence.

  • Showing the 5 most recent of 8.
• Structure8

  1 involved a crash

  • Filed Jan 2026

    Our truck is currently experiencing issue with the driver side door. In cold temperatures, the door will not open from the outside of the vehicle nor the inside of the vehicle. This is a known Ford recall with the F150 series as well. TSB/SSM 50543: SSM 50543 is a Ford Special Service Message addressing freezing door latches on 2021-2022 F-150 trucks. It addresses issues with doors failing to lock, unlock, or open in freezing temperatures due to water intrusion, instructing dealers to inspect and, if necessary, replace door latch cables and actuators. This is EXACTLY what we are experiencing with our 2022 F350.

  • Filed Jun 2025

    As a Ford owner, I can vividly recall the 1980’s Ford acronym ‘fix or repair daily’. That comes to mind as my 2022 F350 Platinum Dually has been in the shop for one thing or another more times in 3 years than my 2015 Chevy Impala LTZ has in 10 years. But I digress. The reason for this complaint is my latest malfunction on my Ford vehicle. As mentioned previously, it hasn’t been 3 years and yet another issue with my vehicle has come to light. My passenger roof trim has broken at the connection point, which of all things, was connected via rivet…beneath the rear glass. Apparently, this an extremely common issue among 2017 and up Ford Super Duty. There has been no recall issued. And Ford wants the vehicle owners to pay for the repair. It is an absolute horrible design. The plastic breaks often. And to make matters worse, the rear glass had to be removed to replace the trim. Most of the trim snaps in place but the very end, the end that is cheaply made and connected to a metal rivet, is so fragile and thin that after a few months of driving over American bumpy roads and being beating up the Sun, it cracks, breaks lose, sticks up like a sore thumb, and otherwise detracts from the reputation of the Ford Brand. My vehicle is still under the original warranty as I have only 22,240 miles, and I purchased and extended warranty with adds 4 more years. This needs to be remedied and Ford owners need to be compensated for monies spent to repair these manufacturing defects. MY LOCAL FORD DEALERSHIP STATES THAT IF THEY BREAK THE GLASS DURING THE REPAIR THAT THE COST OF THE NEW GLASS IS MY RESPONSIBILITY, EVEN UNDER WARRANTY. That is so very wrong and alarming. The repair is $125, to be completed by an outside vendor. The dealer will not even tackle this repair. THE CONNECTION POINT OF THE ROOF TRIM IS A RIVET. Why? THE CONNECTION POINT OF THE ROOF TRIM IS BENEATH THE REAR GLASS, WHICH HAS TO BE REMOVED INORDER TO REPAIR THE DEFECTIVE ROOF TRIM. Why? Why make

  • Filed Jul 2024

    The contact owns a 2022 Ford F-350 SD. The contact stated that while driving during a rainstorm, rainwater leaked in from the rear window into the rear cabin of the vehicle. The contact stated that the failure was due to a faulty rear window seal. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was provided. The local dealer was not contacted regarding the failure. The failure mileage was 50,000.

  • Filed Jun 2024

    I had a trailer hooked to my truck. while driving down the road the tailgate came down by it's self. not knoing it was down there was damage to the tailgate $4,400.00 worth risk is not being able to turn.ford in baraboo wi looked at as well as my insurance. no warning lamps or message came on

  • Filed May 2024

    The contact owns a 2022 Ford F-350 SD. The contact stated that while hauling a horse trailer and driving approximately 65 MPH, the rear tailgate door erroneously opened. The contact stated that the failure had occurred on several occasions. The cause of the failure was not yet determined. The local dealer and manufacturer were notified of the failure, but no assistance was provided. The failure mileage was 25,000.

  • Showing the 5 most recent of 8.
• Diesel7

  • Filed Oct 2025

    The contact owns a 2022 Ford F-350 SD. The contact received notifications of NHTSA Campaign Numbers: 22V250000 (VISIBILITY), 24V957000 (FUEL SYSTEM, DIESEL), and 25V686000 (Back Over Prevention). However, the parts to do two of the recall repairs were not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

  • Filed Jul 2025

    The contact owns a 2022 Ford F-350SD. The contact stated while driving at 5 MPH, the vehicle shut off with the check engine warning light illuminated. The contact used a diagnostic machine and diagnosed the vehicle and determined that the high-pressure fuel rail and high-pressure fuel rail sensor were defective. The contact replaced the high-pressure rail fuel sensor; however, the error code remained. The contact stated that while driving at an undisclosed speed, there was an abnormal popping sound coming from the vehicle, with the check engine warning light illuminated. The contact self-diagnosed the vehicle and retrieved a code that the low-pressure fuel rail was defective. The contact also discovered oil leaking out of the O-rings where the fuel injectors were located. The dealer was contacted, and the vehicle towed to the dealer. The dealer diagnosed the vehicle with a defective low-pressure fuel pump. Upon investigation, the contact linked the failure to NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the VIN was not included in the recall. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The vehicle was not repaired and remained with the dealer. The failure mileage was approximately 61,000.

  • Filed Jul 2025

    The contact's husband owns a 2022 Ford F-350 SD. The contact stated that while depressing the accelerator pedal, the vehicle lost motive power with the check engine warning light displayed on the instrument panel. The vehicle was taken to the dealer where a diagnostic test was performed, and the contact was informed that the high-pressure fuel pump (HPFP) needed to be replaced. The contact initially assumed that the vehicle would be covered under warranty; however, the warranty did not cover the repair. The contact was then referred to the manufacturer for assistance. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The vehicle was repaired out of pocket. The failure mileage was approximately 140,000.

  • Filed Apr 2025

    The contact owns a 2022 Ford F-350 SD. The contact stated while driving 15 MPH, the vehicle lost motive power and vehicle stalled. The contact stated there was an abnormal sound coming from the engine. An unknown message was displayed on the instrument panel. The vehicle failed to restart and was pulled into a gas station by another driver. The vehicle was then towed to the residence. A mobile mechanic diagnosed that the CP4 pump had failed. The contact was informed that the CP4 pump needed to be replaced. The vehicle had not been repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 90,000.

  • Filed Apr 2025

    The contact owns a 2022 Ford F-350 SD. The contact received notification of NHTSA Campaign Number: 24V957000 (Fuel System, Diesel); however, the part to do the recall repair was not yet available. The dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

  • Showing the 5 most recent of 7.
• Visibility/Wiper6

  • Filed Feb 2026

    The contact owns a 2022 Ford F-350 SD. The contact stated that while driving approximately 45-50 MPH, in snowy weather, the front driver's side windshield wiper fractured, and the contact pulled over to manually wipe the window. The dealer was notified of the failure and informed the contact that the vehicle could not be repaired under Ford Campaign Number: 22S26 (Both Front Wiper Arm Replacement) because the VIN was not included. The vehicle was not diagnosed or repaired. The manufacturer was contacted and confirmed the dealer's information. The failure mileage was approximately 32,076.

  • Filed Jun 2025

    Rear facing camera/back-up assistant distorted view. Problem confirmed by local dealer. Ford motor company impairing dealer's ability to complete repairs under warranty. Ford Motor Company mandating unrelated maintenance actions at customer expense ($350). More details contained in attachment: NHTSA FORD COMPLAINT

  • Filed Jun 2025

    Was driving at 06:30 in the morning on a multi-lane highway with light rain. Sudden explosion of the forward sunroof panel with glass shattering everywhere. It was a very loud boom that occurred. No other vehicles were close by so this was not a rock thrown. Plus the roof is 7 feet off the ground which makes it very unlikely with no other vehicles close by.

  • Filed Dec 2023

    What component or system failed or malfunctioned, and is it available for inspection upon request? Transfer case shift motor failure, transmission slipping in 3,2,1 gear and when accelerating from 7-8 gear. Electronics on dash have gone out while driving multiple times. Tailgate opened up while driving multiple times. Trailer brake. Drivers side faulty window (glass) fracture across entire window when not moving. Yes, all can be inspected or paper work reviewed for repairs complete. How was your safety or the safety of others put at risk? Could not use 4 wheel drive in icy/snowy conditions to get to destination. Transmission slipping caused my foot to come off brake pedal and immediately had to reengage brake pedal due to the force of the transmission slipping (like the transmission was falling out from under the truck), nearly hitting the car in front of me on both occasions. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. All issues have been confirmed by local Ford dealer and fixed by certified Ford mechanic, but once issue is repaired, the electronics issues and transmission issue continue to arise (exact same issues). Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Yes, by the dealership (Ford representatives). Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No, no warning signs for any of the defects other than a letter for the tailgate recall, brake recall and wiper recall.

  • Filed Jun 2022

    I purchased this vehicle on 6/7/2022. Ford let me know there was a recall 2 days later. Ford tells me that I cannot drive the vehicle off of their lot until the parts have been replaced. Ford has no date available as to when the parts will be available. I would like to be able to drive the new truck I purchased. I have not even picked up the truck from the dealer.

  • Showing the 5 most recent of 6.
• Vehicle Speed Control5

  • Filed May 2026

    Charging System Fault. Caused multiple error messages like Forward camera not available, collision avoidance not available. Then Radio goes black and reboots. Several cycles later the dash board goes DARK. No speed or RPM anything visible for 5-10 secs, and on some reboots this Dark dash lasted 30 seconds. Thankfully while traveling at midnight the head lights and tail lights remain on, just no interior lights during these Reboots. New batteries made no difference.

  • Filed Apr 2026

    This is not a failed component, the issue is a design interaction issue. This truck when it gets stuck as it unfortunately very easily does even on wet grass goes into a traction control mode where the throttle is VERY damped but the issue is not only is the opening very dampened the closing is also VERY damped. This is made significantly worse by the fact that traction control cannot actually be disabled. There is a switch and it indicates it is disabled but the functionality remains the same. This combination means whenever you're working to get the truck unstuck, like yesterday when it was on wet grass you have to expect that the vehicle will suddenly accelerate as soon as it finds traction. normally you can counteract this by expecting to apply significant brakes as soon as it finds traction but if the front wheels are still on a slippery surface the ABS system will lose it's mind and essentially disable brakes as the vehicle accelerates violently backwards with the new found traction. This combination of software decisions makes it so you can very easily replicate an unintended acceleration scenario where the vehicle jumps back a solid 20' when this happens, not respecting any brake input given by the driver and certainly not respecting that the throttle was released long ago. The throttle closing should not be damped when traction control is running and the ABS system should not be behaving the way it does. I understand getting the vehicle unstuck from wet grass is not normal operation but that's what the traction control disable button should be for and Ford makes that button useless also. When taken together, all these engineering decisions make for a very unsafe situation that has zero reason to exist. I've attached pictures that show the overview of the situation as well as the characteristic ABS marks showing that it was disabling brakes.

  • Filed Jul 2025

    The fan clutch assembly failed and as a result the drive mode would not change from tow/haul mode to any of the other 4 drive modes. Accelerations and decelerations were negatively affected as a result creating safety hazards when driving. The engine was always responding as if a trailer were attached and subsequently accelerations were difficult and decelerations consistently utilized the trailer engine braking system, similar to semi-trucks utilizing the Jake-Braking systems, This is a significant safety issue and needs to have a recall issued for the replacement of these fan clutch assemblies.

  • Filed Apr 2025

    While driving with the cruise set I wanted to reduce speed and hit the minus speed button on the cruise control which caused the vehicle to speed up which made me hit it quickly a couple more times to slow it down and it responded by speeding up more and led me to slam on the brakes. Luckily no one was in front of me so I didn’t rear end them when it sped up and no one was behind me that could have rear ended me when I slammed on the brakes.

  • Filed Apr 2022

    The contact owns a 2022 Ford F-350 SD. The contact stated that while driving approximately 75 MPH with the adaptive cruise control activated, while attempting to decrease the speed, the vehicle inadvertently accelerated to 80 MPH. The contact disengaged the adaptive cruise control however, several unknown warning lights illuminated and adaptive cruise control remained activated. The brake pedal was depressed and the adaptive cruise control disengaged. After restarting the vehicle, the adaptive cruise control performed as designed. The vehicle was not taken to be diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 5,000.

• Forward Collision Avoidance5

  • Filed May 2026

    Charging System Fault. Caused multiple error messages like Forward camera not available, collision avoidance not available. Then Radio goes black and reboots. Several cycles later the dash board goes DARK. No speed or RPM anything visible for 5-10 secs, and on some reboots this Dark dash lasted 30 seconds. Thankfully while traveling at midnight the head lights and tail lights remain on, just no interior lights during these Reboots. New batteries made no difference.

  • Filed May 2025

    I was driving on [XXX] in St Louis County Missouri during rush hours traffic. I experienced a blow out on my drivers front tire. I was surrounded by lots of heavy traffic from passenger cars to tractor trailer going more than 60 mph. I slowly got to the right shoulder. Modot and the state highway patrol blocked the traffic away from us while AAA changed my tire. After I was ready to leave I noticed my traffic early collision warning, and other safety warning systems were not working now. I also noticed my rear view camera was not operating either. This was the first time I noticed any issue with my safety systems. I got. Ew tires and changed them all 6 out. Still my rear view camera is not operating. I did notice Ford was getting ready to put in a recall for rear view camera for F350’s from 2015 to 2025. I do have a 2022 so I feel I am in the recall. Please let me know if I should go to my dealer for repairs under the recall. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

  • Filed Jul 2024

    The contact owns a 2022 Ford F-350 SD. The contact stated that while hauling a trailer, the brakes failed to operate as needed. The vehicle was taken to the local dealer, who updated and replaced the Auxiliary Power Interface Module (APIM) several times. The vehicle was repaired, but the failure recurred. Additionally, the radio turned on without driver interaction. The contact stated that the Forward Collision Avoidance system and the mirrors were turning on and off, the crash alert was engaged, and the brake was applied without driver input. The steering wheel was vibrating. The manufacturer was contacted and declined a buyback of the vehicle. The failure mileage was approximately 100.

  • Filed Mar 2023

    My 2022 Ford F 350 platinum truck came optioned from the factory with the Ford winch, and collision avoidance as well as adaptive cruise control. Ford has included the collision avoidance sensor in the bracket for the winch. Ford is aware that the bracket can be distorted by the winch which disables the collision avoidance, adapative cruise, and abnormal cruise creating a safety issue. Ford refuses to correct the issue

  • Filed Apr 2022

    The contact owns a 2022 Ford F-350 SD. The contact stated that while driving approximately 75 MPH with the adaptive cruise control activated, while attempting to decrease the speed, the vehicle inadvertently accelerated to 80 MPH. The contact disengaged the adaptive cruise control however, several unknown warning lights illuminated and adaptive cruise control remained activated. The brake pedal was depressed and the adaptive cruise control disengaged. After restarting the vehicle, the adaptive cruise control performed as designed. The vehicle was not taken to be diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 5,000.

• Gasoline5

  1 involved a crash

  • Filed Apr 2026

    The contact owns a 2022 Ford F-350 SD. The contact stated that while attempting to accelerate from a complete stop, the vehicle lost power. There was no warning light illuminated. The vehicle was able to restart. The contact received notification of NHTSA Campaign Numbers: 25V455000 (Fuel System, Gasoline), 25V686000 (Back Over Prevention), 26V104000 (Electrical System, Exterior Lighting), and 26V204000 (Visibility); however, the parts to do the recall repairs were not yet available. The vehicle was taken to the dealer but was not diagnosed or repaired. The dealer stated that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 30,000.

  • Filed Dec 2025

    The contact owns a 2022 Ford F-350 SD. The contact received the recall notice for NHTSA Campaign Numbers: 25V455000 (Fuel System, Gasoline) and 25V686000 (Back Over Prevention). The contact expressed safety concerns about driving the recalled vehicle. The local dealer was contacted and confirmed that the parts to do the recall repairs were not available. The manufacturer was contacted by mail regarding vehicle rental and buyback assistance, which was denied. The contact had not experienced a failure.

  • Filed Nov 2025

    The contact owns a 2022 Ford F-350 SD. The contact received notification of NHTSA Campaign Number: 25V455000(Fuel System, Gasoline). The contact was concerned about driving the vehicle. The local dealer was contacted and informed the contact that there was no related recall information from the manufacturer. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The contact had not experienced a failure.

  • Filed Oct 2025

    The contact owns a 2022 Ford F-350 SD. The contact received notifications of NHTSA Campaign Numbers: 25V455000 (Fuel System, Gasoline) and 25V686000 (Back Over Prevention); however, the parts to do the recall repairs were unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repairs. The contact stated that while attempting to accelerate from a stop, the vehicle hesitated before accelerating. There were no warning lights illuminated. The dealer was contacted, and it was confirmed that parts were not yet available. The manufacturer was made aware of the issue. The failure mileage was unknown.

  • Filed Sep 2025

    The contact owns a 2022 Ford F-350. The contact stated that while stopped at a traffic signal with his foot on the brake pedal, the vehicle suddenly accelerated as if he had applied the accelerator. The contact stated that his vehicle front end crashed into the rear end of the vehicle. The contact stated that he turned the vehicle off to stop it from continuing to gain forward momentum. The contact stated that he was able to restart the vehicle and pulled over. The contact stated that his lower front bumper was dented and had scratches. The contact stated that the vehicle he had crashed into had damage to the tail gate and rear bumper. The contact stated that no one was injured and both vehicles were able to drive away. The police were not called. The contact stated that prior to the crash the vehicle was having multiple electrical failures and numerous warning lights had illuminated. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the transmission needed to be rebuilt. The vehicle repaired, however the contact stated that he was still having warning lights and that the vehicle was shifting roughly from park (P) to drive (D) or from park (P) to reverse (R). Additionally, the contact stated that the accelerator pedal was failing to respond when he applied the pedal. The contact had taken the vehicle back to the same dealer who replaced the battery junction box. The contact stated that the dealer had replaced the battery junction box according to a manufacturer technical service bulletin number 23-2133 (Electrical System). The contact stated that prior to the crash, again the accelerator pedal failed to respond when he applied the pedal. The contact stated that he had used a hand held scanner and was getting codes for electrical system failures, ignition cylinder codes, ABS faults, Body Control Module throttle control codes. The vehicle was taken back to the same dealer and was not repaired. The manufacturer was informed of the failure and advised the dealer not continue repairing the vehicle. The failure mileage was approximately 72,000.

• Visibility5

  • Filed Dec 2025

    The contact owns a 2022 Ford F-350 SD. The contact stated that while driving at various speeds, there was an abnormal rattling sound coming from the roof. The vehicle was taken to a local independent mechanic, where it was diagnosed, and determined that the roof rack needed to be replaced. The vehicle was taken to a local dealer, where the failure was replicated. The vehicle was not repaired due to the VIN not being included in NHTSA Campaign: 25V729000 (Visibility). The manufacturer was made aware of the failure. The failure mileage was approximately 40,000.

  • Filed Oct 2025

    The contact owns a 2022 Ford F-350 SD. The contact received notifications of NHTSA Campaign Numbers: 22V250000 (VISIBILITY), 24V957000 (FUEL SYSTEM, DIESEL), and 25V686000 (Back Over Prevention). However, the parts to do two of the recall repairs were not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

  • Filed Jun 2024

    the ac compressor went out and national back order this has been a problem for years

  • Filed Jun 2023

    I was driving off the ramp merging onto another interstate when my sunroof exploded. There was nothing above me or any cars in front or back of me. The cloth sunroof cover shows no damage. I take it to Ted Russell Ford in Knoxville, TN and they deny my warranty. Stating something the size of a basketball hit my sunroof but the cloth barrier shows no sign of damage. I spoke with customer service and they refused to warranty the issue. This is a known issue with Ford and Lincoln and have thousands of complaints concerning this issue.

  • Filed Feb 2022

    02/05/2022: Severe ice storm in Northeast. Windshield adequately thawed and cleared with ice pieces and snow remaining in windshield wiper "bay". Upon energizing windshield wipers in preparation for departure, wipers made several clearing swipes with minor resistance when the driver's side wiper disengaged. After investigation the following theoretical engineering/design flaws were noted: 1) windshield wiper arm hub is larger than splined shaft not allowing 360-degree engagement on spined shaft. Ford has chosen a keyseat in the shaft and a keyway in the hub combined with a key to make the assembly a keyed joint in what appears to be an effort to make a satisfactory drive assembly. 2) The wiper arm is retained on the splined shaft with a spring-loaded lever recessed in a groove. This spring-loaded lever is neither strong nor protected. 3) the wiper arm and blade are heavily spring-loaded on the windshield. My theory is that the ice debris became lodged beneath the wiper arm hub forcing the wiper arm retention lever open (note: lever can be displaced by your thumbnail) popping the wiper arm up with the assistance of the heavily preloaded spring force downward on the windshield. The key fell out when the arm was displaced which left the assembly disengaged from the splined shaft. The key was found in the bay. It is my contention that this assembly poses a serious safety issue for these vehicles. They are purchased to be used in inclement weather (i.e.: snowplowing) and there is not a reliable windshield wiper arm to shaft retention device nor an adequate drive spline. Had this happened while I was driving down the road (especially in inclement weather), it would have been an immediate and severe safety crisis which could have been disastrous.

• Engine And Engine Cooling3

  1 involved a fire

  • Filed Jul 2025

    The contact owns a 2022 Ford F-350. The contact stated the check engine warning would illuminate on cold starts and would remain illuminated while driving. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the Reductant Heater and Sender Assembly on the 6.7L diesel engine needed to be replaced. The mechanic related the failure to Ford Customer Satisfaction Program Number: 18M01(Reductant Heater and Sender Assembly Repair). The vehicle was not repaired. The manufacturer was notified of the failure and advised the contact that the VIN was not included, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 66,000.

  • Filed May 2025

    The contact owns a 2022 Ford F-350 SD. The contact stated that while driving approximately 40 MPH and pulling a trailer, the parking warning alert suddenly displayed on the dashboard, and moments later, a flashing check engine light was activated. While driving to the side of the road to park, smoke and flames began to come from under the passenger side of the front hood of the vehicle. The occupants immediately exited the vehicle, and the vehicle was engulfed in flames. The fire department was called to the scene and extinguished the flames. During the incident, the vehicle was completely destroyed, and the trailer had sustained severe fire damage to the front end. A police report was taken at the scene, and both the vehicle and trailer were towed away. No injuries were reported, but both the driver and passenger were severely stressed mentally from the incident. The cause of the failure has not yet been determined. The manufacturer and local dealer were notified of the incident. The failure mileage was 30,051.

  • Filed Sep 2023

    The contact owns a 2022 Ford F-350 SD. The contact stated while driving at approximately 45 MPH, the temperature gauge started rising quickly. The engine overheated message was displayed. The vehicle had been taken to the dealer who diagnosed and determined that there was coolant leaking into the cylinders and might have been caused by a defective head gasket. The dealer was unable to identify the exact location of the leak. The contact was informed that the engine needed to be replaced. The vehicle had not been repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 317.

• Suspension3

  • Filed Aug 2024

    Highway travel at approx 65mph, experienced a sudden violent uncontrollable steering wheel movement known as a death wobble. Uncontrollable steering wheel movement increased resulting in a reactionary driver hard breaking application to try and regain control of the vehicle steering WITHOUT checking rear view mirror for other motorists close behind. Speed dropped to approx 30-35mph before regaining control of steering. Fortunately no vehicles were following close behind or the affected vehicle and other highway occupants may have resulted in a crash caused by the uncontrollable vehicle and sudden breaking. Components/systems involved include front suspension/steering. Dealer #1 stated vehicle was inspected and found no abnormal wear or damage, all specs within limits. Dealer #2 found steering damper depleted requiring replacement (warranty covered), and front end alignment found out of specifications requiring addition parts installed at owner cost ($787), all while under warranty at approx 19000mi at time of occurrence. No prior symptoms or indications. One owner/driver vehicle since new. Incident occurred without warning and immediate unsafe driving conditions occured. Trip continued for approx 1000mi without further incident until inspected by 2 Ford dealerships until some sort of corrective action applied.

  • Filed Oct 2023

    Well, driving truck at speeds of 60 mph developed wobble. After slowing down wobble went away after about a 10th of a mile. Incident does not happen when I travel under 50 mph. Has happened several times. I researched this topic on Internet and Ford claims to fix this problem in the year 2020. They claim vehicles after that year will not have this.

  • Filed Sep 2023

    Today 9/6/23 at 9:20pm I was driving 65mph on the highway and hit a medium sized pot hole. This caused my front end to violently shake back and forth over a prolonged period of time causing me to loose control of my vehicle. I was able to brake and the shaking stopped around 20mph while I was on the highway. This has happened to me once before almost causing an accident. Neither time was I speeding, over loaded, or driving erratically. The pot holes were things I had seen but not avoided as were are not something that has ever caused a problem for me while driving any other vehicle. I have driven daily for over 10 years.

• Lane Departure1

  • Filed Jul 2026

    While traveling with my fifth-wheel camper attached, my 2022 Ford F-350 Super Duty (6.7L Power Stroke) suddenly developed a complete no-crank condition. Prior to the failure, the vehicle displayed multiple electrical warnings, including U0100 (Lost Communication with PCM), High Engine Temperature, AdvanceTrac, Blind Spot System Fault, Hill Start Assist, and Pre-Collision Assist warnings. The vehicle ultimately became disabled and would not crank or start, leaving me stranded away from home while towing a trailer. Repair Description After troubleshooting the vehicle, I discovered severe internal corrosion inside the under-hood Battery Junction Box (BJB). The corrosion appeared consistent with Ford Technical Service Bulletin 23-2133 regarding moisture intrusion into the Battery Junction Box on certain 2020–2022 Super Duty trucks. I purchased a genuine Ford replacement Battery Junction Box from a Ford dealership and installed it. Immediately after replacement, the vehicle started normally and all warning messages disappeared. I retained the failed Battery Junction Box and have photographs documenting the internal corrosion. Safety Concern My concern is not simply the repair cost but the safety implications of this failure. The vehicle became completely disabled while towing a fifth-wheel trailer during travel. A sudden electrical failure affecting the Battery Junction Box can leave occupants stranded and may create hazardous situations if it occurs in remote locations or during travel. Because Ford has issued a Technical Service Bulletin addressing moisture intrusion into the Battery Junction Box, I believe this condition should be evaluated to determine whether additional action is warranted.

• Equipment1

  • Filed Dec 2025

    The contact owns a 2022 Ford F-350 SD. The contact stated that while driving at various speeds, there was an abnormal rattling sound coming from the roof. The vehicle was taken to a local independent mechanic, where it was diagnosed, and determined that the roof rack needed to be replaced. The vehicle was taken to a local dealer, where the failure was replicated. The vehicle was not repaired due to the VIN not being included in NHTSA Campaign: 25V729000 (Visibility). The manufacturer was made aware of the failure. The failure mileage was approximately 40,000.

• Exterior Lighting1

  • Filed Oct 2023

    Trailer brakes continuously go out on multiple trailers with an associated right turn lamp fault. There was a related recall but did not cover all of the vehicles this is happening to. Manufacturer Recall Number: 22S17 NHTSA Recall Number: 22v193

• Tires1

  • Filed Sep 2023

    25X12.00B9 IMP. THE TIRE WENT FLAT WITH NO SIGNS OF DAMAGE. REMOVED TIRE AND TOOK TO BELLE TIRE, BROWNSBURG, IN IN WHICH DAMEON THOMAS, MANAGER STATED THAT THERE WERE CRAKES INSIDE THE TIRE WHICH WAS A MANUFACTURING DEFECT. IN THE LAST 30 DAYS HE HAD SEEN OVER 70 TIRES WITH THIS PROBLEM. HE CONTACTED YOKOHAMA DIRECTLY AND THEY REFUSED TO DO ANYTHING. THESE TIRES HAVE LESS THAN 4000 MILES. WAITED A TOTAL 5 WEEKS FOR THEM TO TELL US THEY WILL DO NOTHING. TOOK VEHICLE TO COSTCO AND HAD 4 NEW FIRESTONE TIRES MOUNTED FOR A COST OF $1815.79. COSTCO STATED THAT ALL OF THE TIRES ARE DEFECTIVE AND COULD HAVE BLOWN WHILE DRIVING. WE HAVE THE 4 TIRES IN OUR POSSION. WE ARE ASKING FOR A REFUND OF THE COST OF NEW TIRES AND LOSS OF USE OF THE VEHICLE.

• Wheels1

  • Filed Sep 2023

    Today 9/6/23 at 9:20pm I was driving 65mph on the highway and hit a medium sized pot hole. This caused my front end to violently shake back and forth over a prolonged period of time causing me to loose control of my vehicle. I was able to brake and the shaking stopped around 20mph while I was on the highway. This has happened to me once before almost causing an accident. Neither time was I speeding, over loaded, or driving erratically. The pot holes were things I had seen but not avoided as were are not something that has ever caused a problem for me while driving any other vehicle. I have driven daily for over 10 years.

• Latches/Locks/Linkages1

  • Filed Aug 2021

    Page 84 of the owners manual states to open locked rear doors to pull the handle twice. The first pull unlocks the door the second pull opens the door. This function does not work. The dealer even tested at least 2 other 2022 F-350's and this did not work on those either. In the event of a crash, car jacking, fire or being just left in the vehicle and the doors are not unlocked the rear passengers doors will not unlock and passengers can not exit the vehicle via the doors using just the handle. The only way to unlock the rear doors if front seats are not accessable/danger to life exists is to pull up on the lock indicator stalk on the rear of the rear doors. The dealer I bought this vehicle from looked over all of this information and confirmed it to not work as described in the manual and even contacted Ford engineering. Ford's response is that this feature my no longer be available and that the owners manual is either not correct or is not available yet for the vehicle. This information was directly to the dealer that inspected the vehicle and confirmed that none of the F-350 crew cabs they have are able to perform this function.

Safety ratings

NHTSA 5-Star Safety Ratings from government crash tests. Ratings can differ by cab style and 2WD/4WD.

NHTSA hasn't published star ratings for this truck. Many heavy-duty pickups aren't included in NHTSA's crash-test program, so this doesn't mean the truck is unsafe.