2005 Ford F-350 Super Duty

What owners should know

Covers 2005–2007 · 6.0L Power Stroke diesel, 5.4L V8 and 6.8L V10 gas · Updated 2026-10-01

Researched from owner forums and NHTSA complaints and written by Know Your Truck. These are patterns in what owners report, not a guarantee about any particular truck.

Common failures & how to fix them

Parts and video buttons search for your 2005 Ford F-350 Super Duty. Always confirm a part fits using your VIN. Brakes, steering, fuel and airbag work affects your safety, so if you're not sure, have a qualified mechanic do it.

• Front-end shake (death wobble)

  Moderate DIY

  Signs: Violent shaking of the steering wheel and front end after hitting a bump, usually at 45+ mph. Slowing down hard is often the only way to stop it.

  Fix: Find and replace the worn parts, most often the track bar or its bushings, then check ball joints, tie rod ends, the drag link and alignment. A new steering stabilizer alone usually only hides the problem.

  Shop: track barShop: steering stabilizer▶ How-to videos

• 6.0L oil cooler and EGR cooler failure

  Best left to a shop

  Signs: Coolant loss with no visible leak, white smoke, and engine oil running much hotter than coolant on a scan tool.

  Fix: Replace the oil cooler and EGR cooler, usually with upgraded parts, and flush the cooling system. It's a big job.

  Shop: 6.0 Powerstroke oil coolerShop: 6.0 Powerstroke EGR cooler▶ How-to videos

• 6.0L blown head gaskets

  Best left to a shop

  Signs: Coolant pushed out of the coolant bottle under load, bubbles in the coolant, overheating when towing.

  Fix: Replace head gaskets and install head studs in place of the factory bolts (part of 'bulletproofing'). Fix the oil and EGR coolers at the same time.

  Shop: 6.0 Powerstroke head studs▶ How-to videos

• 6.0L FICM failure

  Moderate DIY

  Signs: Hard starts (especially cold), rough running and misfires.

  Fix: Test the fuel injection control module's voltage. Repair or replace the FICM, and check the batteries, since weak batteries are hard on it.

  Shop: 6.0 Powerstroke FICM▶ How-to videos

• Broken spark plugs (5.4L / 6.8L 3-valve gas)

  Hard DIY

  Signs: Plugs snap off in the head during a tune-up.

  Fix: Use the plug removal procedure for these engines and a broken-plug extractor tool if one snaps. Many owners leave this job to a shop.

  Shop: Ford 3V broken spark plug extractor▶ How-to videos

• Worn ball joints and tie rods

  Hard DIY

  Signs: Clunks over bumps, wandering steering, uneven tire wear, or play when you rock a lifted front wheel.

  Fix: Replace worn ball joints and tie rod ends, then get an alignment. Ball joints need a press tool, which many parts stores lend out.

  Shop: ball jointsShop: tie rod end▶ How-to videos

Recalls

A recall doesn't mean a truck still has the problem. Enter the truck's VIN at nhtsa.gov/recalls or ask a dealer to see whether the repair was done.

• Steering

  Dec 2020 · #20E090000

  Icon Vehicle Dynamics, LLC (Icon) is recalling all 05-UP FSD 2.5 Centerline Stabilizer Kits with part number 65050. The kits were sold as an accessory for certain 2005-2021 Ford F-250 4X4 and F-350 4X4 pickup trucks. The foam ring inside the stabilizer "through shaft" may block the piston ports, possibly causing the steering to lock up.

  Risk and fix

  Risk: If the steering locks, it can increase the risk of a crash.

  Fix: Icon will notify owners, and dealers will install a new shock assembly with a revised foam ring and steel support disc, free of charge. The recall began December 21, 2020. Owners may contact Icon customer service at 1-951-689-4266.

• Exterior Lighting:Tail Lights

  Jul 2011 · #11V352000

  FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.

  Risk and fix

  Risk: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.

  Fix: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.

• Equipment:Electrical

  Aug 2007 · #07E066000

  CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.

  Risk and fix

  Risk: IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.

  Fix: ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.

• Service Brakes, Air

  Oct 2006 · #06E087000

  CERTAIN HARSCO WHEEL MODIFICATION GROUPS CONTAINING ACCURIDE STEEL RIMS, P/NOS. 203237 AND 203738; ACCURIDE ALUMINUM RIMS, P/N 203712; AND GKN STEEL RIMS, P/N 203688, SOLD AS MODIFICATION EQUIPMENT FOR CERTAIN 2005-2007 FORD F-250/F-350 4X4 PICKUP TRUCKS TO MODIFY TRACK WIDTH OF FRONT AND REAR AXLES. THE RIMS PROVIDED IN THESE WHEEL MODIFICATION GROUPS WEAR THROUGH THE OEM BRAKE LINES.

  Risk and fix

  Risk: BRAKE FAILURE CAN OCCUR, POSSIBLY RESULTING IN A VEHICLE CRASH.

  Fix: HARSCO WILL NOTIFY OWNERS AND PROVIDE A REPAIR KIT ALONG WITH REPAIR INSTRUCTIONS FREE OF CHARGE. THE RECALL BEGAN IN SEPTEMBER 2006. OWNERS MAY CONTACT HARSCO AT 507-235-7112.

• Electrical System:Wiring

  Jun 2005 · #05V270000

  CERTAIN PICKUP TRUCKS, SPORT UTILITY VEHICLES AND VANS EQUIPPED WITH 6.0L DIESEL ENGINES MAY EXPERIENCE STALLING WITHOUT WARNING WHILE DRIVING AND MAY OR MAY NOT RESTART.

  Risk and fix

  Risk: SHOULD THE ENGINE STALL, A VEHICLE CRASH COULD OCCUR.

  Fix: DEALERS WILL UPGRADE THE FUEL INJECTION CONTROL MODULE (FICM) WIRE HARNESS OR REPLACED, AND/OR HAVE A NEW INJECTION CONTROL PRESSURE (ICP)) SENSOR CONNECTOR INSTALLED FREE OF CHARGE. THE RECALL BEGAN ON JULY 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

• Fuel System, Gasoline:Delivery:Hoses, Lines/Piping, And Fittings

  Jun 2005 · #05V266000

  ON CERTAIN PICKUP TRUCKS AND CHASSIS CAB VEHICLES EQUIPPED WITH 5.4L OR 6.8L GASOLINE ENGINES, THE FUEL JUMPER LINE MAY HAVE AN INCORRECT END FORM.

  Risk and fix

  Risk: THE FUEL LINE MAY SEPARATE AT THE CONNECTION TO THE MAIN FUEL BUNDLE. IF THE FUEL LINE SEPARATES, AN OPERATOR MAY NOTICE A GASOLINE ODOR AND/OR FUEL ON THE GROUND, LOSS OF POWER, AND THE ENGINE WILL EVENTUALLY STALL. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

  Fix: DEALERS WILL INSTALL AN EXTERNAL RETENTION CLIP AT THE FUEL JUMPER LINE TO THE MAIN FUEL BUNDLE CONNECTION. THE RECALL BEGAN ON JUNE 20, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

Owner complaints by area

Reports owners filed with NHTSA. They aren't verified, and one complaint can mention more than one area. Tap an area to read the most recent ones.

• Steering66

  2 involved a crash

  • Filed Feb 2024

    Twice today, traveling at 75mph on highway [XXX] (northbound and then several hours later southbound) just north of Ardmore OK, I experienced a violent shaking of the steering wheel/front wheel shimmy. The vehicle was difficult to control due to the violent shaking that did not stop until the vehicle slowed to approximately 20mph. Once the shaking stopped the vehicle was okay to drive. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

  • Filed Jul 2023

    My 2005 F350 Diesel Pick up has suffered from the Ford death wobble on and off for the last 15 years. While navigating a left hand corner at speeds over 40 it begins to shake uncontrollably after hitting a small bump or pot hole until speed is reduced to 30mph or less. I have replaced bearings, uppper & lower ball joints, torque arms and other suspension parts without finding a cure.

  • Filed May 2022

    Multiple times driving the truck at speed limit and hit small bump or a little bumpy part of road triggers the death wobble. Have to almost come to complete stop on highway to stop wobble.

  • Filed May 2022

    The contact owns a 2005 Ford F-350. The contact stated while driving approximately 50 MPH, the vehicle started to shimmy. The contact stated that at the time of failure the steering wheel was very difficult to turn. The contact stated that after slowing down the vehicle operated normally. The contact stated that the brake warning light was illuminated. The vehicle was not repaired. The contact stated that she received notification in the mail of NHTSA Campaign Number: 20E090000 (Steering, Suspension, Equipment) however, her vehicle was not included in the recall. The contact stated that neither the dealer nor the manufacturer was notified of the failure. The failure mileage was unknown.

  • Filed Aug 2021

    When driving 50 mph or above and hitting a bump in the road such as a bridge apron the truck develops an uncontrollable shimmy in the front end. It requires a firm grip from both hands to control the steering and lasts until the truck is slowed to under 20 mph and often until it is completely stopped. Luckily there hasn’t been another vehicle in the lanes next to me when this has occurred. If there had been it may have caused an accident. Tires are relatively new and the alignment is spot on. It feels like the same problem I had as a teenager in my 1959 Ford F100 when the king pins were worn.

  • Showing the 5 most recent of 66.
• Engine And Engine Cooling65

  3 involved a fire

  • Filed Feb 2016

    CPSC: 2005 F-350. CONSUMER STATED THE 6.0 DIESEL MOTOR IS NO LONGER WORKING DUE TO A BUILDUP IN THE GAS TANK, OR OIL SYSTEM. *SS THE CONSUMER STATED AFTER THE VEHICLE WAS FIXED, IT BROKE DOWN AGAIN. *JB

  • Filed Mar 2013

    TL* THE CONTACT OWNS A 2005 FORD F350 SD. THE CONTACT STATED THAT WHILE DRIVING UPHILL, THE VEHICLE OVERHEATED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION WHERE THEY STATED THAT THE TURBO NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THE VEHICLE WAS NOT DRIVEN ENOUGH, WHICH WAS THE CAUSE OF THE FAILURE. THE FAILURE MILEAGE WAS 21,768. UPDATED 5/9/13 *CN

  • Filed Jul 2012

    TL* THE CONTACT OWNS A 2005 FORD F350 SUPER DUTY. THE CONTACT STATED THAT THE VEHICLE STALLED NUMEROUS TIMES WITHOUT WARNING WHILE DRIVING AT ANY SPEED. THE VEHICLE WAS TAKEN TO THE DEALER NUMEROUS TIMES FOR THE FAILURE. THE DEALER REPLACED THE FUEL INJECTORS, THE TURBO CHARGER WAS REPLACED FOUR TIMES, THE HEAD GASKETS, AND THE REAR END RINGS HOWEVER THE FAILURE WAS NOT CORRECTED. THE VEHICLE CONTINUED TO STALL WITHOUT WARNING AND THE ENGINE COULD NO LONGER BE STARTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND ADVISED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 05V270000 (ELECTRICAL SYSTEM: WIRING). THE FAILURE MILEAGE WAS 9,368 AND THE CURRENT MILEAGE WAS 175,000. UPDATED 8/21/12 *CN THE CONSUMER STATED THE HIGH PRESSURE OIL PUMP, FRONT END SEALS, END RINGS, FUEL INJECTORS, TURBO CHARGER, HEAD GASKETS AND EGR VALVE WERE REPALCED. THE TRANSMISSION WAS SLIPPIING WHEN THE VEHICLE WAS PUT IN REVERSE. THE ABS LIGHT ILLUMINATED.

  • Filed Jul 2012

    WHITE HEAVY SPOKE, LOSS OF POWER, PERFORMANCE, ENGINE STALLED ON MAJOR HIGHWAY AN EXTREMELY DANGEROUS SITUATION. DEALER STATED NOT FORD OR THEIR PROBLEM. CHARGES CLOSE TO $1,500 TO REPAIR. DEALER CLAIMS FAILED EGR VALVE.

  • Filed Mar 2012

    WHILE PULLING A 30 FOOT TRAVEL TRAILER TUCK SUDDENLY DIED CAUSING IMMEDIATE LOSS OF STEERING AND BRAKING POWER ON A VERY BUSY HIGHWAY NEARLY CAUSING AN ACCIDENT. HAD IT TOWED TO A DIESEL SHOP WHO SCANNED TO FIND IT TO BE THE HIGH PRESSURE OIL AND FUEL PUMPS. THEY SAID THEY HAVE DONE REPEATED REPAIRS ON THE SAME ENGINE WITH THE SAME PROBLEMS IN THE PAST. VERY COSTLY REPAIR OVER $3000 AND 5 DAYS TO DO. *TR

  • Showing the 5 most recent of 65.
• Suspension63

  3 involved a crash · 1 involved a fire

  • Filed Feb 2024

    Twice today, traveling at 75mph on highway [XXX] (northbound and then several hours later southbound) just north of Ardmore OK, I experienced a violent shaking of the steering wheel/front wheel shimmy. The vehicle was difficult to control due to the violent shaking that did not stop until the vehicle slowed to approximately 20mph. Once the shaking stopped the vehicle was okay to drive. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

  • Filed Jul 2023

    My 2005 F350 Diesel Pick up has suffered from the Ford death wobble on and off for the last 15 years. While navigating a left hand corner at speeds over 40 it begins to shake uncontrollably after hitting a small bump or pot hole until speed is reduced to 30mph or less. I have replaced bearings, uppper & lower ball joints, torque arms and other suspension parts without finding a cure.

  • Filed May 2022

    Multiple times driving the truck at speed limit and hit small bump or a little bumpy part of road triggers the death wobble. Have to almost come to complete stop on highway to stop wobble.

  • Filed May 2022

    The contact owns a 2005 Ford F-350. The contact stated while driving approximately 50 MPH, the vehicle started to shimmy. The contact stated that at the time of failure the steering wheel was very difficult to turn. The contact stated that after slowing down the vehicle operated normally. The contact stated that the brake warning light was illuminated. The vehicle was not repaired. The contact stated that she received notification in the mail of NHTSA Campaign Number: 20E090000 (Steering, Suspension, Equipment) however, her vehicle was not included in the recall. The contact stated that neither the dealer nor the manufacturer was notified of the failure. The failure mileage was unknown.

  • Filed Oct 2021

    [XXX] who performs automotive work out of his residence [XXX] and [XXX] of [XXX] have worked on this vehicle to spite the customer and to gouge the customer in unnecessary fraudulent repairs. They have deliberately set this vehicle up to fail with the braking system, the 6.0 engine being rebuilt to no avail, and constant driving problems such as pulling to the right and the left when brakes applied, constant overheating, constant oil temperature overheating, shuttering at highway speed, transmission failure, air conditioning failure, coolant system failure, electrical system failure, and every system that they have repaired, continues to fail. They specifically performed work on the electrical wiring and truck keeps blowing fuses. They performed work on the transmission and the transmission failed shortly after. They performed work on the engine and deleted illegally all the emissions EGR pollutant controls. They installed faulty wiring for the electric trailer brake controls and the electronic speed controls. They tampered with the air conditioning system causing the compressor to blow out, send metal through the a/c lines, and the belt stopped turning causing the serpentine belt to break, tear the fan shroud apart and shred. They also installed a trailer brake controller that was aftermarket and it caused brake loss and intermittent failure with the service brake system and speed control. Domingo also tuned the computer to make the truck output 550 horsepower which caused the new engine to fail prematurely and the transmission to fail as well. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

  • Showing the 5 most recent of 63.
• Fuel System52

  3 involved a fire

  • Filed Feb 2016

    CPSC: 2005 F-350. CONSUMER STATED THE 6.0 DIESEL MOTOR IS NO LONGER WORKING DUE TO A BUILDUP IN THE GAS TANK, OR OIL SYSTEM. *SS THE CONSUMER STATED AFTER THE VEHICLE WAS FIXED, IT BROKE DOWN AGAIN. *JB

  • Filed Jan 2015

    I HAVE A 2005 FORD F350 DIESEL POWERSTROKE THAT HAS THE FUEL TANK LINING FALLING OFF AND ITS GOTTEN TO MY FUEL LINES AND FUEL PUMP CAUSING THE TRUCK TO COME TO A COMPLETE STOP WHILE I WAS DRIVING DOWN THE FREEWAY HAULING A 12FT TRAILER WITH A 10000 LBS TRACTOR ON IT. I HAD TO GET IT TOWED TO A SHOP WHERE THEY REPLACED THE FUEL PUMP AND FILTERS. ONE MONTH LATER IT DID THE SAME THING WHILE ON THE HIGHWAY AGAIN IT JUST DIED THE MECHANIC SAYS MY FUEL TANK IS THE PROBLEM THE LINING INSIDE THE FUEL TANK IS CHIPPING AWAY AND IT HAS GOTTEN TO THE FUEL SYSTEM AGAIN THIS IS A FREQUENT PROBLEM WITH FORD DIESEL TANKS AND THEY WONT TAKE RESPONSIBILITY. THIS SECOND TIME AROUND I AM HAVING TO REPLACE FUEL INJECTORS AND THE FILTERS AGAIN.

  • Filed Oct 2014

    TL* THE CONTACT OWNS A 2005 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING AT 30 MPH, THE ENGINE STALLED WITHOUT WARNING. THE FAILURE OCCURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER ON SEVERAL OCCASIONS WHERE IT WAS DIAGNOSED THAT THE MOTOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. ON ANOTHER OCCASION THE VEHICLE WAS TAKEN TO THE DEALER, WHERE IT WAS DIAGNOSED THAT THE PRESSURE UNIT FOR THE DIESEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 92,000.

  • Filed Oct 2014

    TL* THE CONTACT OWNS A 2005 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING AT 30 MPH, THE ENGINE STALLED WITHOUT WARNING. THE FAILURE OCCURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER ON SEVERAL OCCASIONS WHERE IT WAS DIAGNOSED THAT THE MOTOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. ON ANOTHER OCCASION THE VEHICLE WAS TAKEN TO THE DEALER, WHERE IT WAS DIAGNOSED THAT THE PRESSURE UNIT FOR THE DIESEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 92,000.

  • Filed Dec 2013

    TL* THE CONTACT OWNS A 2005 FORD F350. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION WHERE THEY STATED THAT THE FUEL FILTER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 55,000. *TR

  • Showing the 5 most recent of 52.
• Electrical System43

  1 involved a crash · 3 involved a fire

  • Filed Jun 2024

    Vehicle stalls while driving and wont start again suddenly while operating. Fuel injectors won’t feed fuel line to restart or operate. Occasional start but then stalls continuously until battery dies from trying. Will start when priming the carburetor however will not stay running and stalls out.

  • Filed Apr 2022

    The all very common issues with the year f350 and the 6.0 l. Engines, are as such. The malfunctioning FICM. THE high and low oil coolers, the inter coolers and head studs. Also leaking break fluid .

  • Filed Oct 2021

    [XXX], [XXX] approx age 40 lives and works at [XXX].[XXX] can also control the computers to cancel out and delete the use of catalytic converters, delete the use of DEF intake, delete the use of DPF particulate filters, and not react to controls such as manual braking or acceleration because the computer is controlling when and not the driver. [XXX] strictly states that he cannot have any emissions controls such as EGR, DEF, DPF, catalyst, or any pollutant controls. [XXX] intentionally set it up to have flaws and be dangerous for one reason: to get the customer to keep returning again and again with vehicle problems, wiring electrical problems, performance problems, overheating problems, and never ending engine problems not to mention transmission problems because the transmission could not handle the increased output of the engine. The hydroboost and ABS module and master cylinder that controls the brakes can be easily rigged so that when the driver stomps on the brakes, there is no braking action whatsoever for a 3-5 second delay before skidding the tires and locking the brakes. [XXX] altered the hydroboost and ABS module and master cylinder and the electronic controls to the braking system. [XXX] [XXX] partner admitted the hydrobooster and master cylinder was the problem because he admitted what [XXX] did as sabotage to the customer’s truck. [XXX] deletes the DPF and DEF and the electronics rewiring the truck. [XXX] has a pattern of keeping customers vehicles for excessively long periods of time: 42 days to change batteries, change fuel pump change PCM fusebox and rewire truck. [XXX] has removed the all the catalytic converters and he has removed all the EGR and emissions pollutant controls on [XXX]. [XXX] has sabotaged this truck’s braking system, electrical systems, fuse box wiring, electronic braking wiring, accelerator electronic control. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

  • Filed Jul 2019

    WHILE DRIVING DOWN THE HIGHWAY(45-55MPH) VEHICLE DASH LIGHTS, RADIO, WINDOWS ALL STOP WORKING. THEY COME BACK ON RANDOMLY. NO CHANGE TO LITTLE CHANGE WHEN RE-STARTING. VEHICLE ALSO LOSES POWER AND THE ENGINE SEEMS TO PAUSE AND GO, OVER AND OVER LIKE IT'S STRUGGLING. I'VE TAKEN IT TO SEVERAL FORD CERTIFIED MECHANICS WHO ARE BAFFLED.

  • Filed Aug 2018

    TL* THE CONTACT OWNS A 2005 FORD F-350. WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE SUDDENLY STALLED. AFTER, RESTARTING THE ENGINE, THE VEHICLE OPERATED NORMALLY; HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER (MATTHEWS FORD, 1101 WEST SW. EXPRESS DR., BROKEN ARROW, OK) WHERE IT WAS DIAGNOSED THAT THE ELECTRICAL WIRE HARNESS WAS FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, BUT NO ASSISTANCE WAS OFFERED. THE CONTACT WAS INFORMED BY THE MANUFACTURER THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM), ALTHOUGH IT EXPERIENCED THE SAME FAILURE LISTED IN THE RECALL. THE FAILURE MILEAGE WAS 45,000. *TT *JS

  • Showing the 5 most recent of 43.
• Diesel37

  2 involved a fire

  • Filed Feb 2016

    CPSC: 2005 F-350. CONSUMER STATED THE 6.0 DIESEL MOTOR IS NO LONGER WORKING DUE TO A BUILDUP IN THE GAS TANK, OR OIL SYSTEM. *SS THE CONSUMER STATED AFTER THE VEHICLE WAS FIXED, IT BROKE DOWN AGAIN. *JB

  • Filed Jan 2015

    I HAVE A 2005 FORD F350 DIESEL POWERSTROKE THAT HAS THE FUEL TANK LINING FALLING OFF AND ITS GOTTEN TO MY FUEL LINES AND FUEL PUMP CAUSING THE TRUCK TO COME TO A COMPLETE STOP WHILE I WAS DRIVING DOWN THE FREEWAY HAULING A 12FT TRAILER WITH A 10000 LBS TRACTOR ON IT. I HAD TO GET IT TOWED TO A SHOP WHERE THEY REPLACED THE FUEL PUMP AND FILTERS. ONE MONTH LATER IT DID THE SAME THING WHILE ON THE HIGHWAY AGAIN IT JUST DIED THE MECHANIC SAYS MY FUEL TANK IS THE PROBLEM THE LINING INSIDE THE FUEL TANK IS CHIPPING AWAY AND IT HAS GOTTEN TO THE FUEL SYSTEM AGAIN THIS IS A FREQUENT PROBLEM WITH FORD DIESEL TANKS AND THEY WONT TAKE RESPONSIBILITY. THIS SECOND TIME AROUND I AM HAVING TO REPLACE FUEL INJECTORS AND THE FILTERS AGAIN.

  • Filed Oct 2014

    TL* THE CONTACT OWNS A 2005 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING AT 30 MPH, THE ENGINE STALLED WITHOUT WARNING. THE FAILURE OCCURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER ON SEVERAL OCCASIONS WHERE IT WAS DIAGNOSED THAT THE MOTOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. ON ANOTHER OCCASION THE VEHICLE WAS TAKEN TO THE DEALER, WHERE IT WAS DIAGNOSED THAT THE PRESSURE UNIT FOR THE DIESEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 92,000.

  • Filed Dec 2013

    TL* THE CONTACT OWNS A 2005 FORD F350. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION WHERE THEY STATED THAT THE FUEL FILTER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 55,000. *TR

  • Filed Aug 2013

    MERGED ON TO MCFARLAND BLVD. WITH SOUTH BOUND TRAFFIC TRUCK LOST POWER COULD NOT CONTROL VEHICLE OTHER TRAFFIC ALMOST RAN INTO THE TRUCK.HAD TRUCK TOWED TO DIESEL SHOP.COLUMBUS DIESEL SERVICE FOUND PAINT CHIPS IN FILTER REMOVED FUEL TANK ,COATING OF THE TANK WAS COMING OFF AND ENTERING THE FUEL SYSTEM THIS IS THE FACTORY TANK THAT CAME WITH THE TRUCK.. *TR

  • Showing the 5 most recent of 37.
• Service Brakes27

  4 involved a crash · 3 involved a fire

  • Filed Oct 2021

    [XXX] who performs automotive work out of his residence [XXX] and [XXX] of [XXX] have worked on this vehicle to spite the customer and to gouge the customer in unnecessary fraudulent repairs. They have deliberately set this vehicle up to fail with the braking system, the 6.0 engine being rebuilt to no avail, and constant driving problems such as pulling to the right and the left when brakes applied, constant overheating, constant oil temperature overheating, shuttering at highway speed, transmission failure, air conditioning failure, coolant system failure, electrical system failure, and every system that they have repaired, continues to fail. They specifically performed work on the electrical wiring and truck keeps blowing fuses. They performed work on the transmission and the transmission failed shortly after. They performed work on the engine and deleted illegally all the emissions EGR pollutant controls. They installed faulty wiring for the electric trailer brake controls and the electronic speed controls. They tampered with the air conditioning system causing the compressor to blow out, send metal through the a/c lines, and the belt stopped turning causing the serpentine belt to break, tear the fan shroud apart and shred. They also installed a trailer brake controller that was aftermarket and it caused brake loss and intermittent failure with the service brake system and speed control. Domingo also tuned the computer to make the truck output 550 horsepower which caused the new engine to fail prematurely and the transmission to fail as well. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

  • Filed Oct 2021

    [XXX], [XXX] approx age 40 lives and works at [XXX].[XXX] can also control the computers to cancel out and delete the use of catalytic converters, delete the use of DEF intake, delete the use of DPF particulate filters, and not react to controls such as manual braking or acceleration because the computer is controlling when and not the driver. [XXX] strictly states that he cannot have any emissions controls such as EGR, DEF, DPF, catalyst, or any pollutant controls. [XXX] intentionally set it up to have flaws and be dangerous for one reason: to get the customer to keep returning again and again with vehicle problems, wiring electrical problems, performance problems, overheating problems, and never ending engine problems not to mention transmission problems because the transmission could not handle the increased output of the engine. The hydroboost and ABS module and master cylinder that controls the brakes can be easily rigged so that when the driver stomps on the brakes, there is no braking action whatsoever for a 3-5 second delay before skidding the tires and locking the brakes. [XXX] altered the hydroboost and ABS module and master cylinder and the electronic controls to the braking system. [XXX] [XXX] partner admitted the hydrobooster and master cylinder was the problem because he admitted what [XXX] did as sabotage to the customer’s truck. [XXX] deletes the DPF and DEF and the electronics rewiring the truck. [XXX] has a pattern of keeping customers vehicles for excessively long periods of time: 42 days to change batteries, change fuel pump change PCM fusebox and rewire truck. [XXX] has removed the all the catalytic converters and he has removed all the EGR and emissions pollutant controls on [XXX]. [XXX] has sabotaged this truck’s braking system, electrical systems, fuse box wiring, electronic braking wiring, accelerator electronic control. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

  • Filed Jul 2014

    TL* THE CONTACT OWNS A 2005 FORD F-350. THE CONTACT STATED WHILE DRIVING AT 15 MPH, THE BRAKE LIGHT FAILED TO ILLUMINATE WHENEVER THE BRAKES WERE ENGAGED. ALSO, THE TBC WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE CONNECTOR TO THE BREAK LIGHT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNAVAILABLE AND THE CURRENT MILEAGE WAS 140,000.

  • Filed Oct 2012

    THIS VEHICLE HAS HAD NUMEROUS ENGINE FAILURES WHICH I WILL LIST BELOW. I SPEND ALOT OF TIME IN RURAL LOCATIONS BETWEEN 50 AND 100 MILES FROM ANY SERVICE FACILITIES IN ALL KINDS OF WEATHER. USUALLY THERE IS NOT ANY CELL SERVICE AVAILABLE. IT IS ONLY A MATTER OF TIME BEFORE I OR SOMEONE IS STRANDED IN BAD WEATHER BECAUSE OF THE POOR ENGINEERING ON THE 6.0 LITER DIESEL THAT FORD INSTALLED IN MY VEHICLE. THIS COULD WELL BE LIFE THREATENING AND LEAD TO DEATH IN THE FUTURE. 6/12/06 TURBO FAILURE-COVERED BY WARRANTY BY FORD - 20000 MILES 7/15/06 RECALL ON COMPUTER-COVERED BY WARRANTY BY FORD- 21000 MILES 4/8/11 EGR COOLER BLEW OUT- OUT OF POCKET COST $1703.46- 90619 MILES 8/28/12 INJECTORS FAILED- OUT OF POCKET COST $2178.09- 110732 MILES 8/30/12 REAR WHEEL SEAL AND EMERGENCY BRAKE FAILURE- OUT OF POCKET COST- $703.06- 111423 MILES 10/12/12 TURBO FAILURE AGAIN- OUT OF POCKET COST $2577.75- 113473 MILES YOU CAN SEE THE ONGOING THEME HERE AND WHEN I TALK TO FORD THEY SAY "SORRY BUT WE HAVE NO RECALLS AND NO CUSTOMER SERVICE HELP AT THIS TIME." THEY NEED TO TAKE RESPOSIBILITY BEFORE SOMETHING HAPPENS AND IT PUTS PEOPLES LIVES AT RISK. AS THE OWNER OF THIS VEHICLE I WOULD LIKE TO BE INCLUDED IN ANY CLASS ACTION LAWSUITS AGAINST FORD FOR NOT TAKING RESPONSIBILITY FOR THE 6.0 LITER ENGINEERING DISASTER THAT THEY CREATED. HOPEFULLY SOMEONE WILL MAKE THEM STEP UP AND PROVIDE THE BUYERS OF THESE ENGINES THE HELP THEY NEED AND DESERVE. *TR

  • Filed Jul 2012

    TL* THE CONTACT OWNS A 2005 FORD F350 SUPER DUTY. THE CONTACT STATED THAT THE VEHICLE STALLED NUMEROUS TIMES WITHOUT WARNING WHILE DRIVING AT ANY SPEED. THE VEHICLE WAS TAKEN TO THE DEALER NUMEROUS TIMES FOR THE FAILURE. THE DEALER REPLACED THE FUEL INJECTORS, THE TURBO CHARGER WAS REPLACED FOUR TIMES, THE HEAD GASKETS, AND THE REAR END RINGS HOWEVER THE FAILURE WAS NOT CORRECTED. THE VEHICLE CONTINUED TO STALL WITHOUT WARNING AND THE ENGINE COULD NO LONGER BE STARTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND ADVISED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 05V270000 (ELECTRICAL SYSTEM: WIRING). THE FAILURE MILEAGE WAS 9,368 AND THE CURRENT MILEAGE WAS 175,000. UPDATED 8/21/12 *CN THE CONSUMER STATED THE HIGH PRESSURE OIL PUMP, FRONT END SEALS, END RINGS, FUEL INJECTORS, TURBO CHARGER, HEAD GASKETS AND EGR VALVE WERE REPALCED. THE TRANSMISSION WAS SLIPPIING WHEN THE VEHICLE WAS PUT IN REVERSE. THE ABS LIGHT ILLUMINATED.

  • Showing the 5 most recent of 27.
• Engine26

  1 involved a crash · 2 involved a fire

  • Filed Apr 2022

    The all very common issues with the year f350 and the 6.0 l. Engines, are as such. The malfunctioning FICM. THE high and low oil coolers, the inter coolers and head studs. Also leaking break fluid .

  • Filed Oct 2021

    [XXX], [XXX] approx age 40 lives and works at [XXX].[XXX] can also control the computers to cancel out and delete the use of catalytic converters, delete the use of DEF intake, delete the use of DPF particulate filters, and not react to controls such as manual braking or acceleration because the computer is controlling when and not the driver. [XXX] strictly states that he cannot have any emissions controls such as EGR, DEF, DPF, catalyst, or any pollutant controls. [XXX] intentionally set it up to have flaws and be dangerous for one reason: to get the customer to keep returning again and again with vehicle problems, wiring electrical problems, performance problems, overheating problems, and never ending engine problems not to mention transmission problems because the transmission could not handle the increased output of the engine. The hydroboost and ABS module and master cylinder that controls the brakes can be easily rigged so that when the driver stomps on the brakes, there is no braking action whatsoever for a 3-5 second delay before skidding the tires and locking the brakes. [XXX] altered the hydroboost and ABS module and master cylinder and the electronic controls to the braking system. [XXX] [XXX] partner admitted the hydrobooster and master cylinder was the problem because he admitted what [XXX] did as sabotage to the customer’s truck. [XXX] deletes the DPF and DEF and the electronics rewiring the truck. [XXX] has a pattern of keeping customers vehicles for excessively long periods of time: 42 days to change batteries, change fuel pump change PCM fusebox and rewire truck. [XXX] has removed the all the catalytic converters and he has removed all the EGR and emissions pollutant controls on [XXX]. [XXX] has sabotaged this truck’s braking system, electrical systems, fuse box wiring, electronic braking wiring, accelerator electronic control. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

  • Filed Nov 2019

    TL* THE CONTACT OWNS A 2005 FORD F-350. THE CONTACT STATED THAT THE VEHICLE MISFIRED AND CAUSED THE STEERING WHEEL TO SEIZE. ALSO, WHILE DRIVING VARIOUS SPEEDS, THE BRAKE PEDAL WAS DEPRESSED, BUT THE VEHICLE FAILED TO IMMEDIATELY STOP. THE VEHICLE WAS TAKEN TO FORMULA FORD LINCOLN (4318 MIDDLE RD, RUTLAND, VT 05701, (802) 773-9168) WHERE THE CAM PHASERS WERE REPLACED; HOWEVER, THE FAILURE RECURRED AFTER 176 MILES. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 63,000.

  • Filed Apr 2019

    TL* THE CONTACT OWNS A 2005 FORD F-350. WHILE DRIVING 65 MPH, THE VEHICLE STALLED AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD AND POWERED OFF THE ENGINE. THE VEHICLE WAS RESTARTED AND WAS ABLE TO DRIVE NORMALLY. LATER, THE VEHICLE STALLED AND FAILED TO RESTART. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED, BUT A FAILURE CODE COULD NOT BE FOUND. THE VEHICLE WAS NOT TAKEN TO A DEALER AND WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN A RECALL. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.

  • Filed Sep 2018

    TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING 35 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT ATTEMPTED TO RESTART THE VEHICLE, BUT WAS UNSUCCESSFUL. THE CONTACT HAD THE VEHICLE TOWED TO HIS HOME. A DIAGNOSTIC APPOINTMENT WAS SCHEDULED WITH GUESS FORD (457 STEUBENVILLE RD SE, CARROLLTON, OH 44615, (330)-627-7666). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THERE WERE NO RECALLS; THEREFORE, THE CONTACT WOULD HAVE TO PAY IN FULL FOR THE REPAIRS. THE FAILURE MILEAGE WAS 76,000. *TT CONSUMER STATED THIS WAS THE SECOND TIME IT STALLED. UPDATED 12/03/18*JB

  • Showing the 5 most recent of 26.
• Hydraulic19

  1 involved a crash · 1 involved a fire

  • Filed Oct 2012

    THIS VEHICLE HAS HAD NUMEROUS ENGINE FAILURES WHICH I WILL LIST BELOW. I SPEND ALOT OF TIME IN RURAL LOCATIONS BETWEEN 50 AND 100 MILES FROM ANY SERVICE FACILITIES IN ALL KINDS OF WEATHER. USUALLY THERE IS NOT ANY CELL SERVICE AVAILABLE. IT IS ONLY A MATTER OF TIME BEFORE I OR SOMEONE IS STRANDED IN BAD WEATHER BECAUSE OF THE POOR ENGINEERING ON THE 6.0 LITER DIESEL THAT FORD INSTALLED IN MY VEHICLE. THIS COULD WELL BE LIFE THREATENING AND LEAD TO DEATH IN THE FUTURE. 6/12/06 TURBO FAILURE-COVERED BY WARRANTY BY FORD - 20000 MILES 7/15/06 RECALL ON COMPUTER-COVERED BY WARRANTY BY FORD- 21000 MILES 4/8/11 EGR COOLER BLEW OUT- OUT OF POCKET COST $1703.46- 90619 MILES 8/28/12 INJECTORS FAILED- OUT OF POCKET COST $2178.09- 110732 MILES 8/30/12 REAR WHEEL SEAL AND EMERGENCY BRAKE FAILURE- OUT OF POCKET COST- $703.06- 111423 MILES 10/12/12 TURBO FAILURE AGAIN- OUT OF POCKET COST $2577.75- 113473 MILES YOU CAN SEE THE ONGOING THEME HERE AND WHEN I TALK TO FORD THEY SAY "SORRY BUT WE HAVE NO RECALLS AND NO CUSTOMER SERVICE HELP AT THIS TIME." THEY NEED TO TAKE RESPOSIBILITY BEFORE SOMETHING HAPPENS AND IT PUTS PEOPLES LIVES AT RISK. AS THE OWNER OF THIS VEHICLE I WOULD LIKE TO BE INCLUDED IN ANY CLASS ACTION LAWSUITS AGAINST FORD FOR NOT TAKING RESPONSIBILITY FOR THE 6.0 LITER ENGINEERING DISASTER THAT THEY CREATED. HOPEFULLY SOMEONE WILL MAKE THEM STEP UP AND PROVIDE THE BUYERS OF THESE ENGINES THE HELP THEY NEED AND DESERVE. *TR

  • Filed Jul 2012

    TL* THE CONTACT OWNS A 2005 FORD F350 SUPER DUTY. THE CONTACT STATED THAT THE VEHICLE STALLED NUMEROUS TIMES WITHOUT WARNING WHILE DRIVING AT ANY SPEED. THE VEHICLE WAS TAKEN TO THE DEALER NUMEROUS TIMES FOR THE FAILURE. THE DEALER REPLACED THE FUEL INJECTORS, THE TURBO CHARGER WAS REPLACED FOUR TIMES, THE HEAD GASKETS, AND THE REAR END RINGS HOWEVER THE FAILURE WAS NOT CORRECTED. THE VEHICLE CONTINUED TO STALL WITHOUT WARNING AND THE ENGINE COULD NO LONGER BE STARTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND ADVISED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 05V270000 (ELECTRICAL SYSTEM: WIRING). THE FAILURE MILEAGE WAS 9,368 AND THE CURRENT MILEAGE WAS 175,000. UPDATED 8/21/12 *CN THE CONSUMER STATED THE HIGH PRESSURE OIL PUMP, FRONT END SEALS, END RINGS, FUEL INJECTORS, TURBO CHARGER, HEAD GASKETS AND EGR VALVE WERE REPALCED. THE TRANSMISSION WAS SLIPPIING WHEN THE VEHICLE WAS PUT IN REVERSE. THE ABS LIGHT ILLUMINATED.

  • Filed Oct 2011

    TL* THE CONTACT OWNS A 2005 FORD F-350 SD. THE CONTACT STATED THE BOLT ON THE MASTER CYLINDER FOR THE BRAKES SHEARED OFF. WHILE DRIVING 5 MPH WHILE THE BRAKE WAS BEING DEPRESSED THE BRAKE EXTENDED TO THE FLOOR CAUSING THE VEHICLE TO BE STOPPED WITH THE EMERGENCY BRAKE. THE CONTACT INSPECTED THE BRAKE AND NOTICED THE BOLT FROM THE MASTER CYLINDER BROKE. THE DEALER WAS NOTIFIED AND STATED THEY WERE AWARE OF THE FAILURE. THE MANUFACTURER WAS NOTIFIED AND STATED THEY WERE NOT AWARE OF THE FAILURE AND OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 190,000.

  • Filed Oct 2011

    LOST FAN BELT TRAVELING 65/MPH THEREBY LOST ALL STEERING AND BRAKES .WAS ON SECONDARY HIGHWAY COASTED INTO A SMALL TOWN AND USED MY EMERGENCY BRAKE TO STOP. MY WIFE PANICKED JUST LUCKY I WAS DRIVING ,HAVING BEEN A MECHANIC FOR 35 YEARS HAD ENOUGH SENSE TO NOT PANIC AND USE EMERGENCY BRAKE TO STOP. *TR

  • Filed Jun 2011

    TL* THE CONTACT OWNS A FORD 2005 F-350 SD. THE CONTACT STATED THAT THE VEHICLE WOULD MAKE A LOUD SQUEAKING NOISE WHENEVER THE BRAKES WERE APPLIED, AND SHE WOULD ALSO SMELL A BURNING ODOR. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT A BRAKE CALIPER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTUER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGES WERE 18,413 AND THE CURRENT MILEAGE WAS 38,156.

  • Showing the 5 most recent of 19.
• Power Train18

  1 involved a crash · 1 involved a fire

  • Filed Oct 2021

    [XXX] who performs automotive work out of his residence [XXX] and [XXX] of [XXX] have worked on this vehicle to spite the customer and to gouge the customer in unnecessary fraudulent repairs. They have deliberately set this vehicle up to fail with the braking system, the 6.0 engine being rebuilt to no avail, and constant driving problems such as pulling to the right and the left when brakes applied, constant overheating, constant oil temperature overheating, shuttering at highway speed, transmission failure, air conditioning failure, coolant system failure, electrical system failure, and every system that they have repaired, continues to fail. They specifically performed work on the electrical wiring and truck keeps blowing fuses. They performed work on the transmission and the transmission failed shortly after. They performed work on the engine and deleted illegally all the emissions EGR pollutant controls. They installed faulty wiring for the electric trailer brake controls and the electronic speed controls. They tampered with the air conditioning system causing the compressor to blow out, send metal through the a/c lines, and the belt stopped turning causing the serpentine belt to break, tear the fan shroud apart and shred. They also installed a trailer brake controller that was aftermarket and it caused brake loss and intermittent failure with the service brake system and speed control. Domingo also tuned the computer to make the truck output 550 horsepower which caused the new engine to fail prematurely and the transmission to fail as well. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

  • Filed Jan 2015

    I HAVE A 2005 FORD F350 DIESEL POWERSTROKE THAT HAS THE FUEL TANK LINING FALLING OFF AND ITS GOTTEN TO MY FUEL LINES AND FUEL PUMP CAUSING THE TRUCK TO COME TO A COMPLETE STOP WHILE I WAS DRIVING DOWN THE FREEWAY HAULING A 12FT TRAILER WITH A 10000 LBS TRACTOR ON IT. I HAD TO GET IT TOWED TO A SHOP WHERE THEY REPLACED THE FUEL PUMP AND FILTERS. ONE MONTH LATER IT DID THE SAME THING WHILE ON THE HIGHWAY AGAIN IT JUST DIED THE MECHANIC SAYS MY FUEL TANK IS THE PROBLEM THE LINING INSIDE THE FUEL TANK IS CHIPPING AWAY AND IT HAS GOTTEN TO THE FUEL SYSTEM AGAIN THIS IS A FREQUENT PROBLEM WITH FORD DIESEL TANKS AND THEY WONT TAKE RESPONSIBILITY. THIS SECOND TIME AROUND I AM HAVING TO REPLACE FUEL INJECTORS AND THE FILTERS AGAIN.

  • Filed Dec 2012

    TL* THE CONTACT OWNS A 2005 FORD F-350. THE CONTACT STATED THAT THE VEHICLE WAS LEAKING TRANSMISSION FLUID FROM A SEAL IN THE TORQUE CONVERTER. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN ADVISED THE CONTACT THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 150,000 AND THE CURRENT MILEAGE WAS 168,000.

  • Filed Jul 2012

    TL* THE CONTACT OWNS A 2005 FORD F350 SUPER DUTY. THE CONTACT STATED THAT THE VEHICLE STALLED NUMEROUS TIMES WITHOUT WARNING WHILE DRIVING AT ANY SPEED. THE VEHICLE WAS TAKEN TO THE DEALER NUMEROUS TIMES FOR THE FAILURE. THE DEALER REPLACED THE FUEL INJECTORS, THE TURBO CHARGER WAS REPLACED FOUR TIMES, THE HEAD GASKETS, AND THE REAR END RINGS HOWEVER THE FAILURE WAS NOT CORRECTED. THE VEHICLE CONTINUED TO STALL WITHOUT WARNING AND THE ENGINE COULD NO LONGER BE STARTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND ADVISED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 05V270000 (ELECTRICAL SYSTEM: WIRING). THE FAILURE MILEAGE WAS 9,368 AND THE CURRENT MILEAGE WAS 175,000. UPDATED 8/21/12 *CN THE CONSUMER STATED THE HIGH PRESSURE OIL PUMP, FRONT END SEALS, END RINGS, FUEL INJECTORS, TURBO CHARGER, HEAD GASKETS AND EGR VALVE WERE REPALCED. THE TRANSMISSION WAS SLIPPIING WHEN THE VEHICLE WAS PUT IN REVERSE. THE ABS LIGHT ILLUMINATED.

  • Filed Dec 2011

    TRANSMISSION FLUID WAS LEAKING OUT FROM UNDER TRUCK AFTER I STARTED IT TO LET WARM UP. HAD IT TOWED TO THE GARAGE ONLY TO FIND OUT THAT A SNAP RING INSIDE THE TRANSMISSION HAD WORN A HOLE IN THE TRANSMISSION CASING. THIS COULD HAVE BEEN REAL BAD IF I HAD NOT LET THE TRUCK WARM UP AS I LIVE ON A HILL AND THE TRANSMISSION FLUID WAS COMING OUT SO FAST I AM SURE THE ROAD WOULD HAVE BEEN COVERED. I CHECK TO SEE IF FORD HAD RECALLED THIS PROBLEM BUT THEY DID NOT, EVEN AS THERE ARE MANY COMPLAINTS ON THE FORD FORUM WEBSITE. ALL I CAN SAY IS THERE WILL NOT BE ANOTHER FORD IN MY LIFE AFTER I REPLACE THIS TRUCK. *TR

  • Showing the 5 most recent of 18.
• Tires18

  1 involved a crash

  • Filed Feb 2019

    DRIVING ON INTERSTATE I-85 IN NORTH GA ON SUNDAY, FEBRUARY 24TH TRAVELING 65MPH. REAR DRIVER SIDE TIRE TREAD FLIES OFF. TRUCK ROCKS AND MAKES A LOT OF NOISE. ABLE TO MAINTAIN CONTROL OF VEHICLE AND MOVE TO EMERGENCY LANE. TIRE APPEARS TO HAVE PEELED APART LIKE A BANANA. *DT*JB

  • Filed Sep 2015

    TIRE FAILURE CAUSING ACCIDENT WITH PROPERTY DAMAGE AND MINOR INJURIES. TIRE WAS THE FRONT LEFT TIRE ON A 2005 FORD F350 4X4 SRW. TIRE HAD APPROXIMATELY 25,000 MILES. ACCIDENT OCCURRED WHILE TOWING A FIFTH WHEEL TOY HAULER TRAILER. TRAILER IS 25' LONG WITH AN APPROXIMATE EMPTY WEIGHT OF 5500 LBS. ALSO IN THE TRAILER WERE PERSONAL EFFECTS INCLUDING ONE MOTORCYCLE WITH AN APPROXIMATE WEIGHT OF 550 LBS. TIRE PRESSURE WAS CHECKED AT 76 PSI COLD 3 DAYS PRIOR TO INCIDENT. ACCIDENT OCCURRED WHILE ON AN INTERSTATE HIGHWAY. THE WEATHER WAS SUNNY WITH TEMPERATURES IN THE 70S TO LOW 80S. SPEED OF VEHICLE AT TIME OF INCIDENT WAS 60-65 MPH. APPROXIMATELY 30 MILES PRIOR TO INCIDENT, A STOP WAS MADE FOR FUEL WITH DRIVER DOING A WALK AROUND VISUAL INSPECTION WITH NO DEFECTS NOTED. LEFT FRONT TIRE BLEW WITH NO ADVANCED WARNING. THIS CAUSED THE VEHICLE TO PULL HARD TO THE LEFT. VEHICLE LEFT THE ROADWAY INTO THE MEDIAN. VEHICLE JACK-KNIFED AND OVERTURNED TO ITS RIGHT SIDE. GUARD RAIL STOPPED VEHICLE FROM ENTERING ONCOMING TRAFFIC. FIFTH WHEEL TRAILER OVERTURNED ONTO ITS RIGHT SIDE. OCCUPANTS OF VEHICLE, ONE ADULT MALE DRIVER AND ONE ADULT FEMALE PASSENGER SELF EXTRICATED VIA THE BACK WINDOW. DRIVER UNINJURED. PASSENGER NOTED MINOR CUTS, 'ROAD RASH', BRUISES AND PAIN TO LEFT WRIST. BOTH OCCUPANTS REFUSED TREATMENT AND TRANSPORT BY EMERGENCY RESPONDING UNITS. UPON INSPECTION, IT APPEARS, TO THE OPINION OF THE DRIVER, THAT THE TIRE FAILED AT THE SIDEWALL NEAR THE BEAD CAUSING A RAPID LOSS OF AIR AND SUBSEQUENT DELAMINATION OF TIRE STRUCTURE. THE TRUCK AND FIFTH WHEEL WAS TOTALLY DAMAGED BEYOND REPAIR. THE FEMALE PASSENGER CONTINUES TO MONITOR INJURIES WITH NO MEDICAL ATTENTION SOUGHT AT THIS TIME. TRUCK AND TRAILER WAS TOWED BY A LOCAL SALVAGE AND RECOVERY COMPANY TO THEIR YARD. TRUCK AND TRAILER WERE RELEASED BY THE DRIVER/OWNER TO THE INSURANCE COMPANY FOR INSPECTION, ALTHOUGH HE MAINTAINS OWNERSHIP OF VEHICLES.

  • Filed May 2013

    TL* THE CONTACT OWNS A 2005 FORD F-350 SD EQUIPPED WITH MICHELIN TIRES, SIZE: LT245/75/R17 TIRES(N/A). THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH, THE HOOD ON THE TRUCK, BEGAN TO VIBRATE IN A VIOLENT MANNER. WITHIN 2-3 SECONDS, THE FRONT PASSENGER'S SIDE TIRE EXPLODED WHICH CAUSED THE VEHICLE TO PULL TOWARD THE RIGHT AND SWAY UNCONTROLLABLY OFF ROAD, THROUGH SAND, BRUSH ROCKS, ACROSS A CULVERT, WHICH CAUSED THE FRONT END OF THE VEHICLE, TO BECOME BURIED DEEP IN THE SAND. THERE WAS DAMAGE TO THE VEHICLE. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE WHERE THE DEFECTIVE TIRE WAS REPLACED WITH A SPARE. THE VEHICLE WAS THEN TAKEN TO A TIRE CENTER WHERE THE FRONT PASSENGER AND DRIVER'S SIDE TIRES WERE REPLACED. THE TIRE CENTER REPLACED THE DEFECTIVE TIRE FREE OF CHARGE. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 82,462. UPDATED 6/17/13 *CN THE CONSUMER STATED THE RETAIL ESTABLISHMENT REFUNDED THE COST OF THE BLOWN TIRE, STATING IT WAS DEFECTIVE. MICHELIN DISAGREED WITH THE RETAIL ESTABLISHMENTS FINDINGS AND STATED THE TIRE WAS NOT DEFECTIVE. MICHELIN STATED THEIR INSPECTION REVEALED A RADIAL BREAK THROUGH THE CASING IN THE CROWN AREA FROM BEAD TO BEAD. A PORTION OF THE TREAD AND BOTH STEEL BELTS WERE DETACHED AND MISSING IN THAT AREA EXPOSING THE RADIAL CASING PILED. MICHELIN, WENT ON TO STATED, THAT INDICATED THE INNER LINER ALLOWING AIR TO INFILTRATE INTO THE CASING. AS THE TIRE REMAINED IN SERVICE, THE AIR INFILTRATION PROGRESSED, ULTIMATELY CAUSING THE TREAD TO DETACH. UPDATED 06/25/13

  • Filed Oct 2012

    TIRE BELT INSIDE FELL APART AND CAUSED FLAT TIRE. TIRES BOUNCE EVEN AFTER BEING BALANCED OVER AND OVER SHOWS TIRES ARE BALANCED BUT TIRES BOUNCE ON ROAD. *TR

  • Filed Jul 2011

    TL* THE CONTACT OWNS A 2005 FORD F-350 WITH CONTINENTAL TIRES, TIRE LINE SIZE 275/70/18. THE CONTACT STATED THAT WHILE DRIVING 50 MPH, HE HEARD A LOUD NOISE AND THE VEHICLE STARTED JERKING VIOLENTLY. THE CONTACT NOTICED THAT THE PASSENGER SIDE REAR TIRE SIDEWALL WAS PEELING OFF. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO DIAGNOSED THAT ALL FOUR TIRES NEEDED TO BE REPLACED BECAUSE THE SIDEWALL WAS CRACKED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE TIRES WERE REPLACED. THE DOT NUMBER WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 24,000 AND THE CURRENT MILEAGE WAS 26,000. UPDATED 8/30/11 *CN THE CONSUMER STATED THE TIRES WERE INSPECTED AND IT WAS DETERMINED THEY WERE FAULTY. UPDATED 09/26/11

  • Showing the 5 most recent of 18.
• Fuel/Propulsion System14

  • Filed Apr 2022

    The all very common issues with the year f350 and the 6.0 l. Engines, are as such. The malfunctioning FICM. THE high and low oil coolers, the inter coolers and head studs. Also leaking break fluid .

  • Filed Jul 2019

    WHILE DRIVING DOWN THE HIGHWAY(45-55MPH) VEHICLE DASH LIGHTS, RADIO, WINDOWS ALL STOP WORKING. THEY COME BACK ON RANDOMLY. NO CHANGE TO LITTLE CHANGE WHEN RE-STARTING. VEHICLE ALSO LOSES POWER AND THE ENGINE SEEMS TO PAUSE AND GO, OVER AND OVER LIKE IT'S STRUGGLING. I'VE TAKEN IT TO SEVERAL FORD CERTIFIED MECHANICS WHO ARE BAFFLED.

  • Filed Aug 2018

    FICM AND ICP SENSOR. I WOULD BE DRIVING DOWN THE ROAD AND MY VEHICLE WOULD CUT OFF ON ME WHILE ON THE STREET. IT WOULD TAKE ABOUT FIFTEEN MINUTES OR MORE TO START BACK UP(HOT START). I'VE ONLY HAD THE VEHICLE FOR A YEAR.

  • Filed Sep 2017

    THE GAS TANK HAS A DEFECT IT EPOXY LINER IN GAS TANK CORRODES AND PLUGS UP THE FILTER EJECTOR AND SHUT TRUCK DOWN AND RUST OUT FILTERS. THE TRUCK WAS BEEN DRIVEN WHEN IT SHUT DOWN , TOOK TRUCK TO FORD DEALER, WAS TOLD GAS TANK IS ERODED AND HAS PLUG UP SYSTEM INCLUDING INJECTORS, WILL BE $8000.00 TO FIX, THAT THERE WASNT A CURRENT RECALL ON ITEM, BUT THAT FOR KNOW PROBLEM EXIST.

  • Filed Sep 2017

    TL* THE CONTACT OWNS A 2005 FORD F-350. WHILE DRIVING APPROXIMATELY 65 MPH, THE ENGINE SEIZED WITHOUT WARNING. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO LEIF JOHNSON FORD (501 E KOENIG LN #1, AUSTIN, TX 78751 (512) 454-3711) WHERE IT WAS DIAGNOSED THAT THE FUEL LINER IN THE FUEL TANK CAUSED THE VEHICLE TO SEIZE. THE FUEL TANK WAS CORRODED AND CLOGGED THE INJECTORS. THE CONTACT STATED THAT THE FUEL TANK, FUEL INJECTORS, AND FUEL FILTERS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER ACKNOWLEDGED THE FAILURE, STATED THAT THE VEHICLE WAS NOT INCLUDED IN A RECALL, AND DID NOT OFFER ANY FURTHER ASSISTANCE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

  • Showing the 5 most recent of 14.
• Gasoline14

  1 involved a fire

  • Filed Mar 2012

    WHILE PULLING A 30 FOOT TRAVEL TRAILER TUCK SUDDENLY DIED CAUSING IMMEDIATE LOSS OF STEERING AND BRAKING POWER ON A VERY BUSY HIGHWAY NEARLY CAUSING AN ACCIDENT. HAD IT TOWED TO A DIESEL SHOP WHO SCANNED TO FIND IT TO BE THE HIGH PRESSURE OIL AND FUEL PUMPS. THEY SAID THEY HAVE DONE REPEATED REPAIRS ON THE SAME ENGINE WITH THE SAME PROBLEMS IN THE PAST. VERY COSTLY REPAIR OVER $3000 AND 5 DAYS TO DO. *TR

  • Filed Mar 2012

    MY 2005 F350 HAS A FUEL FAILURE AND WHEN I TOOK IT TO THE DEALER THEY SAID THAT 5 INJECTORS HAD FAILED AND I NEEDED THEY BLAME IT ON BIOFUEL, I HAVE ONLY USED ON ROAD DIESEL AND I HAVE OWNED THIS TRUCK SINCE IT HAD 25,000 MILES ON IT. AT THIS POINT IT IS $6000 TO REPAIR AND OF COURSE THERE IS NO WARRANTY ON IT. THIS IS A MAJOR CONCERN BECAUSE THIS TRUCK CARRIES EXTREME LOADS AT HIGH SPEEDS AND A FUEL FAILURE AT 65 OR 70 WILL CAUSE YOU TO LOSE POWER STEERING AND BRAKING ABILITY. WHEN YOU ARE CARRYING A BACKHOE AND HAVE A TRAILER THAT WEIGHS 6000LBS THE TOTAL WEIGHT OF THE WHOLE RIG IS RIGHT AT 35,000 POUNDS. THAT IS ENOUGH TO TAKE OUT AT LEAST 6 OR 7 CARS THAT HAVE STOPPED IN FRONT OF YOU. THIS NEEDS TO BE FIXED ASAP. *TR

  • Filed Feb 2012

    TL* THE CONTACT OWNS A 2005 FORD F-350. THE CONTACT STATED THAT THE VEHICLE STALLED WHILE DRIVING 20 MPH. UPON RESTART, THE VEHICLE OPERATED AS NORMAL. THE CONTACT EXAMINED THE VEHICLE AND STATED THAT THE FUEL TANK WAS DELAMINATING AND CLOGGING THE FUEL FILTERS. THE VEHICLE WAS NOT DIAGNOSED, NOR REPAIRED, BY THE DEALER. THE FAILURE MILEAGE WAS 49,500 AND THE CURRENT MILEAGE WAS 50,200.

  • Filed Jan 2012

    TL* THE CONTACT OWNS A 2005 FORD F-350 SD DIESEL. THE CONTACT STATED THAT THE VEHICLE WAS RESISTANT TO ACCELERATION ATTEMPTS. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS ADVISED THAT THE FUEL TANK WAS DELAMINATING AND PREVENTING FUEL FROM GETTING TO THE ENGINE. AS A RESULT, THE ENTIRE FUEL TANK WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE. THE FAILURE AND THE CURRENT MILEAGES WERE APPROXIMATELY 100,000. THE VIN WAS UNAVAILABLE.

  • Filed Jul 2011

    THE INTER LINER OF THE FUEL TANK DISINTEGRATED CAUSING THE FUEL TO CONTAMINATE THE FUEL INJECTORS AND THE FUEL PUMP. THE LOCAL FORD DEALER RECOMMENDED THAT THE FUEL TANK, THE FUEL PUMP AND ALL THE FUEL INJECTORS BE REPLACED. TOTAL COST BETWEEN $5000 AND $6000 DOLLARS. GAVE THE APPROVAL ON MAY 3RD 2011. AS OF JULY 5TH STILL WAITING ON THE NEW FUEL TANK. FORD HAS HAD SO MANY OF THESE FUEL TANKS FAIL THAT THERE IS A NATIONAL WAITING LIST FOR THE REPLACEMENT TANKS. ADDING INSULT TO INJURY, THIS IS A WORK TRUCK. EVERYDAY IT'S UNAVAILABLE COST THE COMPANY $100.00 TO $150.00 A DAY. ADD THAT INTO THE REPAIR AND NOW IT'S COSTING US 10K TO 12K. AT THIS TIME, WE STILL HAVE NO ANSWER FROM OUR FORD DEALER AS TO WHEN WE CAN EXPECT THE NEW TANK. AT THE VERY LEAST, I THINK FORD SHOULD BE RESPONSIBLE FOR THE REPAIR.

  • Showing the 5 most recent of 14.
• Equipment6

  1 involved a fire

  • Filed May 2010

    WE EXPERIENCED A SEVERE STEERING SHIMMY AT 65 MPH. THE VEHICLE WAS UNCONTROLLABLE. THE SHIMMY LASTED UNTIL THE VEHICLE WAS BROUGHT TO A COMPLETE STOP. THE STEERING DAMPER WAS FOUND TO BE DEFECTIVE AND REPLACED. *TR

  • Filed Nov 2008

    ON JULY 4, 2005, I PURCHASED A 2005 FORD F350 SUPER DUTY LARIAT WITH LONG BED AND DUAL WHEELS AND 4WD AT EL CAJON FORD. FROM THE BEGINNING, THE TRUCK EXPERIENCED SEVERE FRONT-END VIBRATION WHEN I REACHED ABOUT 60 MPH. IT CONTINUED UNTIL I GOT TO ABOUT 80 MPH. I COMPLAINED ABOUT THIS PROBLEM FROM THE FIRST VISIT FOR SERVICE AT DOWNEY FORD. AFTER A FEW VISITS FOR DIAGNOSTICS, DOWNEY FORD INSTALLED A "DAMPENER" ON THE FRONT END. IT MADE THE PROBLEM BETTER, BUT IT DID NOT COMPLETELY CURE THE DEFECT. I EVENTUALLY BOUGHT A LANCE CAMPER, WHICH WAS ON THE TRUCK FOR OVER A YEAR. WHILE THE TRUCK HAD THE 3000 LB CAMPER ON IT, THE VIBRATION WENT AWAY ON THE STRAIGHTAWAY, BUT WAS HORRIBLY DANGEROUS ON THE CURVES. FOR EXAMPLE, ONE SUCH CURVE IS THE 605 SB TO THE 405 SB IN LONG BEACH. I ALMOST LOST CONTROL OF THE VEHICLE/CAMPER ON THIS CURVE UNLESS I ALMOST STOPPED. I REMOVED THE CAMPER ABOUT A YEAR AGO AND THE PROBLEM WITH THE TRUCK IS WORSE. IT NOW WILL VIBRATE UNCONTROLLABLY AT 40-50 MPH. I REPORTED THIS VIBRATION PROBLEM EVERY TIME I WENT TO THE DEALER FOR SERVICE. THEY ALWAYS SAID THEY DID ALL THEY COULD WITH THE DAMPENER. I TOOK THE TRUCK TO EL CAJON FORD ABOUT 3-4 WEEKS AGO. NOW THAT IT IS OUT OF WARRANTY, FORD NOW SAYS IT CAN FIX THE PROBLEM, BUT IT HAS DAMAGE THE FRONT STEERING MECHANISM. THE SERVICE WRITER SAID IN A VOICE MAIL THAT DOWNEY PUT ON A DAMPER THAT WAS TOO SMALL FOR MY TRUCK. I DEMANDED THEY FIX IT FREE AND THEY REFUSE. I WANT MY TRUCK FIXED. THIS IS A DESIGN DEFECT, SINCE IT HAS EXISTED FROM DAY 1. I HAVE READ ON SEVERAL WEBSITES THAT THIS IS A COMMON PROBLEM THAT EXISTED WELL BEFORE 2005, BUT FORD HAS IGNORED THE SAFETY ISSUES. A HIGH PROBABILITY OF AN ACCIDENT EXISTS WHEN YOUR TRUCK IS VIBRATING AND BOUNCING ACROSS LANES AND YOU CANNOT STEP ON THE BRAKE OR MAKE IT WORSE! THANK YOU, ANNETTE GILLIAM *TR

  • Filed Mar 2007

    TL* - THE CONTACT HAS A AEVIT BY EMC. THE CONTACT STATED THAT THIS EQUIPMENT WAS USED TO HELP WITH STEERING, BRAKING, AND ACCELERATION. THE CONTACT WAS JUST GOING DOWN THE ROAD WHEN ALL OF A SUDDEN THE AEVIT SYSTEM MADE A HARD LEFT AND SENT THE VEHICLE INTO A DITCH. THE CONTACT HAD TO GET SEVEN STITCHES ON HIS THE RIGHT SIDE OF FOREHEAD. A POLICE REPORT WAS TAKEN. THE WEATHER THAT DAY WAS COLD, BUT CLEAR. HE WAS DRIVING APPROXIMATELY 25 - 30 MPH. THERE WAS APPROXIMATELY $7,000 WORTH OF DAMAGE DONE TO THE VEHICLE. THE VEHICLE HAS BEEN REPAIRED, BUT HE HAS NOT DRIVEN THE VEHICLE SINCE. THE CONTACT NO LONGER HAD THE VEHICLE. *AK

  • Filed Mar 2006

    DT*: THE CONTACT STATED THE VEHICLE DID NOT COME EQUIPPED WITH A SPARE TIRE, JACK AND LUG WRENCH. THE CONTACT FEELS THIS IS A SAFETY ISSUE, IF THE VEHICLE HAS A BLOW OUT WHILE DRIVING THERE WOULD BE NO SPARE TO USE. THE MANUFACTURER WAS ALERTED AND STATED IT IS STANDARD FOR THIS EQUIPMENT NOT TO BE PROVIDED ON THE VEHICLE WHEN SOLD. UPDATED 4/6/2006 - *NM

  • Filed Dec 2005

    I HAVE AN F-350 SUPER DUTY DIESEL. THE TRUCK WAS PARKED IN THE DRIVEWAY @ 7:30 PM. AROUND 12:15 AM, MY WIFE HEARD A LOUD POPPING NOISE AND WHAT SOUNDED LIKE A BANGING TYPE CRASH. SHE THOUGHT A CAR HAD CRASHED OUT IN FRONT OF THE HOUSE, SO SHE LOOKED OUT THE WINDOW AND SAW THE TRUCK WITH FLAMES COMING OUT FROM UNDER THE HOOD. WE CALLED THE FIRE DEPT. AND SPRAYED WATER ON OUR EAVES UNTIL THEY ARRIVED. I WILL NEED TO REPLACE THE EAVES ABOVE THE GARAGE, GARAGE DOORS, SEVERAL ITEMS IN THE GARAGE THAT MELTED OR BURNED AS WELL AS WORK TOOLS AND ALL PERSONAL ITEMS FROM THE TRUCK. I WILL ALSO HAVE TO RE-PAINT MY HOUSE DUE TO THE FIRE AND SMOKE FROM THE TRUCK GOING ACROSS THE FRONT OF MY HOUSE ABOVE THE GARAGE. THE FIRE INVESTIGATOR REPORTS THAT THE FIRE STARTED UNDER THE HOOD. I CONTACTED THE FORD DEALER WHERE I HAVE PURCHASED 5 TRUCKS IN THE PAST YEAR! WHEN ASKED ABOUT RECALLS OR IF THIS WAS COVERED UNDER WARRANTY DUE TO THE YEAR OF THE TRUCK AND WHERE THE FIRE STARTED, THEY RESPONDED THAT THERE IS NO RECALL, AND THEY WOULD NOT COVER ANYTHING UNDER WARRANTY???? THIS IS ACTUALLY THE SECOND FORD TRUCK IN ABOUT SIX MONTHS THAT I HAVE HAD CATCH FIRE????? THE FIRST WAS AN F-350 THAT I USED AS ONE OF MY WORK TRUCKS. THAT FIRE ACTUALLY STARED WHILE THE TRUCK WAS BEING DRIVEN BACK TO MY SHOP FROM A JOB. THE FIRE DEPT. STATED THE FIRE HAD ALSO STARTED UNDER THE HOOD IN THE ENGINE COMPARTMENT. I HAD NO IDEA THAT THERE WERE ANY ISSUES WITH FORD TRUCKS AND FIRES. HAD I KNOWN, I WOULD HAVE NEVER TURNED THE FIRST TRUCK INTO MY INSURANCE CARRIER WITHOUT RAISING QUESTIONS REGARDING POSSIBLE FAULTY PARTS AS A CAUSE OF DAMAGE. *NM

  • Showing the 5 most recent of 6.
• Wheels5

  • Filed Sep 2016

    DEATH WOBBLE. 1ST TIME IT HAPPENED WAS ENTERING THE HIGHWAY OFF THE RAMP AND ACCELERATING TO MERGE INTO TRAFFIC AND GOING OVER THE OVERPASS THE BRIDGES IN MASS. ARE A MESS, ANY WAY, WHEN I DROVE THOSE SERIES OF BUMPS AT ABOUT 60-65 MPH IN A TRUCK IT GETS BUMPY ANYWAY BUT ALL OF A SUDDEN THE STEERING WHEEL, AND THE TRUCK STARTED VIOLENTLY SHAKING OUT OF CONTROL SO BAD I LOST COMPLETE VISION IT WAS SHAKING SO BAD WITH NO CAPABILITY OF STEERING THE TRUCK..INSTINCTIVELY I APPLIED THE BRAKES NOT EVEN CHECKING TO SEE WHAT WAS BEHIND ME AS IT WAS SHAKING SO BAD, YOU CANT TURN AROUND, YOU CAN NOT SEE OUT THE MIRRORS. AS I STATED YOU KIND OF LOSE VISION AND EVERYTHING GOES BLURRY BECAUSE YOUR SHAKING IN THE VEHICLE SO BAD. A QUICK GOOGLE AND YOU FIND THIS HAPPENS TO MANY MANY OWNERS OF THIS VERY THE SAME TRUCK. IN FACT FORD SENT ME A LETTER STATING THEY KNEW ABOUT IT AND TO MAKE SURE WE HAVE THE CORRECT AIR PRESSURE. I USE A $50 AIR PRESSURE GAUGE, THE AIR PRESSURES NOT THE PROBLEM. IT WAS STILL HAPPENING ANYTIME YOU GO OVER BIG BUMPS OR A SERIES OF SMALLER BUMPS WILL SET IT OFF WHILE DRIVING ON THE HIGHWAY OR OVER 60 MPH. IT DOESN'T HAPPEN TO US AT SLOWER SPEEDS. THIS IS AN EXTREMELY DANGEROUS DEFECT.

  • Filed Aug 2015

    THIS HAS TO DO WITH 19.5" WHEELS MANUFACTURED BY VISION WHEEL,SPECIFICALLY WHEEL # 81A-9770MBO. ON THE BACK OF THE WHEEL THERE IS A RELIEF MACHINED AROUND EACH LUG HOLE THAT IS ABOUT 1/8"DEEP X 3/4" IN DIA. WHETHER THIS IS A MANUFACTURING DESIGN OR A FLAW I AM NOT SURE,BUT PREVIOUS WHEELS OF THE SAME MODEL NO. DO NOT HAVE THIS AND ARE FLAT ON THE BACK. SHOULD THE LUGS NUTS BE OVER TIGHTENED IT CRACKS THE RIM AROUND THE LUG HOLE AND STARTS TO PULL THROUGH. I FOUND THIS SHORTLY AFTER I GOT MY TRUCK BACK FROM THE TIRE SHOP AND WAS LOOKING AT THE NEW WHEELS.IT IS NOT READILY NOTICEABLE AND WAS JUST LUCK THAT I SAW IT. MY CONCERN IS THAT THIS COULD HAPPEN ANY TIME A WHEEL IS TAKEN OFF FOR SOME SERVICE OR ANOTHER. IF THE WHEEL LUG NUTS GET OVER TORQUED THIS OCCURS. THESE WHEELS ARE USED PRIMARILY BY PEOPLE THAT CARRY HEAVY LOADS AS THE 19.5 TIRES AFFORD BETTER STABILITY. SHOULD SOMEONE NOT BE AWARE OF THIS ISSUE THERE IS THE POSSIBILITY OF LOOSING A TIRE. THIS COULD BE RESOLVED SIMPLY BY NOT MACHINING THE BACK OF THE WHEEL AS WAS NOTED ABOVE. I BELIEVE THIS COULD BE A HAZARD. CONTACT INFO CAN BE OBTAINED HERE: HTTP://WWW.VISIONWHEEL.COM/CONTACT.CFM

  • Filed Jul 2012

    WHILE TRAVELING ON THE HIGHWAY AT 65-70 MPH MY VEHICLE WILL GO INTO A VIOLENT SHIMMY IF IT HITS ANY SORT OF ROAD BUMP (SUCH AS BRIDGE EXPANSION). THIS HAPPENS EVERYDAY IN THIS VEHICLE. IT WILL NOT GO AWAY UNTIL I SLOW THE VEHICLE DOWN TO 45 MPH. *TR

  • Filed Mar 2010

    ALUMINUM ALLOY WHEEL FRACTURING CIRCUMFERENTIALLY AROUND RIM. *TR

  • Filed Mar 2010

    ALUMINUM ALLOY WHEEL FRACTURING CIRCUMFERENTIALLY AROUND RIM. SECOND WHEEL TO FAIL IN THIS FASHION. *TR

• Vehicle Speed Control5

  • Filed Mar 2012

    I PURCHASED THE TRUCK USED FROM A PRIVATE DEALER IN AUG 2011 WITH 66,000MI. ON IT! FROM THE DEALER THIS ISSUE STARTED. IT HAS HAPPENED AT LEAST 2 DZ TIMES NOW AND FORD REFUSES TO ACCEPT THE ISSUE AS A FORD ISSUE! THEY TELL ME ITS THE TIRE PRESSURE AND I HAVE HAD IT TO THEM 3 TIMES TO FIX THIS ISSUE, THEY HAVE RE INFLATED MY TIRE PRESSURE TO " FACTORY RECOMMENDED PRESSURE" AND WITHIN 5 MILES ITS SHAKING SO VIOLENTLY I HAVE TO PULL OVER AND START AGAIN, THIS WILL CAUSE A DEATH EVENTUALLY!! I WILL NOT LET MY WIFE DRIVE THIS TRUCK AND THAT IS WHAT IT WAS BOUGHT FOR, A SAFE FAMILY VEHICLE. *TR

  • Filed Oct 2010

    TL*THE CONTACT OWNS A 2005 FORD F-350. WHILE STOPPED WITH HER FOOT ON THE BRAKE PEDAL THE VEHICLE ATTEMPTED TO SURGE FORWARD. THE RPMS INCREASED EXCESSIVELY AND SHE HAD TO APPLY EXTREME PRESSURE TO THE BRAKE PEDAL IN ORDER TO STOP THE VEHICLE FROM SURGING FORWARD. THE FAILURE ALSO OCCURRED INTERMITTENTLY WHILE DRIVING THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE SHE WAS INFORMED THAT THE EGR COOLER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 39,000.

  • Filed Apr 2009

    1. DRIVING 2. CRUISE CONTROL DOES NOT DISENGAGE WHEN BRAKE IS APPLIED. IN FACT, WHEN BRAKE IS APPLIED, THE TRUCK TRIES TO COMPENSATE FOR REDUCED SPEED BY DOWNSHIFTING AND ACCELERATING. I HAVE HAD IT HAPPEN TWICE WHERE IT NEARLY CAUSED ME TO HIT THE VEHICLE IN FRONT OF ME. THE DEALERSHIP VERIFIED THE PROBLEM BUT COULD NOT FIX IT. THEY SENT ME AWAY WITH THE PROBLEM STILL OCCURRING AND IT IS SO DANGEROUS THAT I DO NOT USE CRUISE CONTROL AT ALL. 3. DEALERSHIP ATTEMPTED TO ADDRESS THE PROBLEM BUT COULDN'T FIX IT. THEY VERIFIED THE PROBLEM AND DOCUMENTED IT IN MY FILE WITH THEM. *TR

  • Filed Mar 2005

    WHEN ACCELERATING IN FULL THROTTLE FROM A DEAD STOP VEHICLE DELAYS FOR A LONG PERIOD OF TIME BEFORE TAKING OFF. CONSUMER IS CONCERNED ABOUT VEHICLE'S ACTION IN AN EMERGENCY SITUATION. *AK

  • Filed Feb 2005

    CONSUMER STATES THE VEHICLE IS FOR PLOWING. HOWEVER, THE COIL SPRINGS ARE NOT STRONG ENOUGH TO HOLD THE PLOW. THE PLOW ACTUALLY DROPS DOWN HITTING THE GROUND; CAUSING THE STEERING TO BECOME ERRATIC OR DIFFICULT. *AK THE TRANSMISSION HAD GONE OUT, THE TIRES WEREN'T SUFFICIENT ENOUGH FOR THIS VEHICLE, THE GAS GAUGE READ EMPTY AT HALF FULL DUE TO THE LOW FRONT END AND THE CONSUMER WAS TOLD THAT THERE WAS NO PROBLEM, THERE WAS NO LIGHT IN THE GLOVE BOX, THERE WERE NOT MUD GUARDS IN THE WHEEL WELL, THE VOLUME WAS INOPERATIVE ON THE RADIO AND THERE WAS A PROBLEM WITH THE THROTTLE CABLE DUE TO A TWO SECOND DELAY WHEN THE GAS PEDAL WAS APPLIED. *SC

• Electric5

  1 involved a crash

  • Filed Jan 2011

    I HAVE A 2005 FORD F350 4 WDR, SUPER DUTY WITH V10, 4 SP. AUTO, VIN NO. [XXX]. I EXPERIENCED SUDDEN VEHICLE ACCELERATION, IE. FROM A STOPPED POSITION WITH VEHICLE IN DRIVE AND FOOT ON BRAKE THE VEHICLE, LUNGED FORWARD, HEAVY BRAKING WOULD NOT STOP VEHICLE IT ONLY CAUSED ACCELERATION. ONLY IMPACT WITH MAIL BOX AND SNOW BANK STOPPED VEHICLE. I COMPARED WHAT HAD JUST HAPPENED WITH PRESSING ON THE ACCELERATOR AND BRAKE AT THE SAME TIME AND THIS WAS DIFFERENT AND DID NOT RESULT IN LOSS OF CONTROL. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).*TR

  • Filed Aug 2006

    I WAS BACKING LOADED TRAILER DOWN INCLINE TOWARD POND; "TOW COMMAND" TRAILER BRAKE CONTROLLER DID NOT WORK PROPERLY AND THE 2005 F-350 SUPER DUTY TRUCK, WITH WHEELS LOCKED, WAS DRAGGED BACKWARD TOWARD THE EDGE OF THE POND BY WEIGHT OF THE TRAILER AND ITS LOAD; TRAILER AND TRUCK STOPPED BEFORE REACHING EDGE OF POND. THIS HAS OCCURRED AT OTHER TIMES, INDICATING THAT BRAKE CONTROLLER DOES NOT PROVIDE ADEQUATE BRAKING IN REVERSE AT LOW SPEEDS. THE PROBLEM WAS REPORTED TO THE SELLING DEALER, WHO SAID THEIR CHECKS INDICATE THE CONTROLLER IS WORKING ACCORDING TO FORD SPECIFICATIONS AT THE DATE OF MANUFACTURER IN SEPTEMBER, 2004, THOUGH A NEW VERSION OF THE CONTROLLER APPARENTLY HAS BEEN INSTALLED ON LATER MODELS, BEGINNING AROUND MARCH OF 2006. THE DEALER AND FORD CUSTOMER SERVICE REPRESENTATIVES HAVE THUS FAR REFUSED TO REPLACE THE CONTROLLER WITH THE UPDATED VERSION AND MAINTAIN THERE IS NOT ADEQUATE PROOF THAT THE CONTROLLER DOES NOT WORK PROPERLY. *JB

  • Filed May 2006

    TRAILER BRAKE CONTROLLER ONLY ALLOWS MINIMAL ELECTRIC CURRENT TO TRAILER UNDER 15 MPH. I AM TOLD, DOT KNOWS OF THIS PROBLEM IN FORD F 350 TRUCKS MFRD. PRIOR TO 03/05. COVERED BY FORD BULLETIN. FORD REFUSES TO UPDATE OR REPAIR. NOT ENOUGH BRAKES UNDER 15 MPH TO STOP TRAILER OR TO TEST FOR TRAILER BRAKES. *NM

  • Filed Nov 2005

    DT: CONTACT STATED THE BRAKES ON TRAILER FAILED DUE TO THE TOW COMMAND SYSTEM. THE DEALER ATTEMPTED TO REPAIR, BUT THE VEHICLE'S TOW COMMAND SYSTEM DID NOT HAVE PROPER VOLTAGE FOR THE TRAILER BRAKES TO WORK. *AK UPDATED 1/11/2006. *NM

  • Filed Sep 2005

    DT: THE CONSUMER OWNS A 2005 FORD F350 SUPER DUTY DUALLY WITH THE BRAKE CONTROLLER BUILT IN THE DASHBOARD. WHEN APPLYING BRAKES AT 10 MPH OR UNDER, THERE IS NOT ENOUGH VOLTAGE TO ACTIVATE THE BRAKE PUMP ACTUATOR, RESULTING IN NO TRAILER BRAKES AT THIS SPEED. THE BRAKE CONTROLLER OVERRIDE DOES NOT FUNCTION AT THIS LEVEL AS WELL. THE CONSUMER TOOK THE TRUCK TO DEALER, WHO VERIFIED THIS ISSUE, BUT THEY SAID THIS WAS THE WAY IT WAS MADE AND WAS NOT A PROBLEM. NO CORRECTIONS OR REPAIRS WERE DONE AT THIS TIME. THE DEALER CONTACTED FORD, AND THEY CONFIRMED WHAT THE DEALER SAID. *AK *NM

• Air Bags4

  3 involved a crash

  • Filed Apr 2025

    The contact owns a 2005 Ford F-350. The contact stated while driving approximately 60-65 MPH and coming up to a bridge, the contact stated that the roadway was a bit wet from ice and rain, and the contact stated that the vehicle ahead entered the bridge and started skidding, so the contact let up off the accelerator pedal; however, when the vehicle entered the bridge, the vehicle started sliding and the contact lost control of the vehicle and crashed head-on into the concrete barrier surrounding the bridge and broke the two picking eyes that was welded unto the front sub frame of the vehicle. The contact stated that the front bumper was severely damaged, and he was concerned that that the air bags had failed to deploy. The contact stated that his chin struck the steering wheel, and his neck was hyper-extended. The contact sustained neck and shoulder injuries. The contact had not received medical treatment at the scene and was not transported to the local medical center for treatment. The contact stated that a Police report was filed and he received paperwork to request a copy of the Police report. The vehicle was towed to a local tow yard. The vehicle was later towed to the residence. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 228,000.

  • Filed Jan 2014

    FORD F350 PULLING A 31' TRAILER CRASHED INTO REAR OF A COMMERCIAL TRUCK/TRAILER DUE TO ICY ROAD CONDITIONS. AIR BAGS DID NOT ACTIVATE ON IMPACT. PASSENGER IN RIGHT/FRONT SEAT WAS CRUSHED DUE TO IMPACT. *TR

  • Filed Sep 2010

    TL*THE CONTACT OWNED A 2005 FORD F350. THE CONTACT STATED THAT HE CRASHED INTO A TELEPHONE POLE WHILE DRIVING 35 MPH. THE CONTACT HAD AN AIR BAG ON/OFF SWITCH FOR THE PASSENGER SIDE AIR BAG AND IT WAS IN THE OFF POSITION BUT THE AIR BAG DEPLOYED ANYWAY. THE OWNER WAS TAKEN TO THE HOSPITAL BY AMBULANCE AND WAS DISCHARGED. THE POLICE DID RESPOND AND A REPORT WAS FILED. THE VEHICLE WAS DESTROYED. FORD WAS NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 122,000.

  • Filed Mar 2008

    THIS IS A DESIGN ISSUE. THE 2005 FORD F350 HAS A LARGE PART OF ITS REAR BUMPERS' HORIZONTAL SURFACE REMOVED. THE BUMPER IS THEN COVERED IN A HARD PLASTIC. I STEPPED OFF THE DECK OF MY TRUCK ONTO THE BUMPER AND THE PLASTIC SURFACE GAVE WAY. I ALMOST BROKE MY ANKLE AND LOST MY BALANCE , NOT BECAUSE THE PLASTIC BROKE THROUGH , IT JUST HAD WAY TOO MUCH FLEX IN IT. I'VE TRIED TO DEAL WITH FORD CO REGARDING THIS BUT AS YOU PROBABLY KNOW ,THEY WANT ZERO TO DO WITH THE RETAIL / POST WHOLESALE APPARATUS. I WAS TOLD TO TALK TO THE DEALER. I WOULD HAVE MORE COMPETENCE AND HONEST FEEDBACK FROM MY DOG. *TR

• Electronic Stability Control (esc)4

  • Filed Aug 2018

    FICM AND ICP SENSOR. I WOULD BE DRIVING DOWN THE ROAD AND MY VEHICLE WOULD CUT OFF ON ME WHILE ON THE STREET. IT WOULD TAKE ABOUT FIFTEEN MINUTES OR MORE TO START BACK UP(HOT START). I'VE ONLY HAD THE VEHICLE FOR A YEAR.

  • Filed Sep 2017

    THE GAS TANK HAS A DEFECT IT EPOXY LINER IN GAS TANK CORRODES AND PLUGS UP THE FILTER EJECTOR AND SHUT TRUCK DOWN AND RUST OUT FILTERS. THE TRUCK WAS BEEN DRIVEN WHEN IT SHUT DOWN , TOOK TRUCK TO FORD DEALER, WAS TOLD GAS TANK IS ERODED AND HAS PLUG UP SYSTEM INCLUDING INJECTORS, WILL BE $8000.00 TO FIX, THAT THERE WASNT A CURRENT RECALL ON ITEM, BUT THAT FOR KNOW PROBLEM EXIST.

  • Filed May 2016

    TL* THE CONTACT OWNS A 2005 FORD F-350. THE CONTACT STATED WHILE DRIVING AT APPROXIMATELY 65 MPH, THE VEHICLE VIOLENTLY SHOOK. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THE VEHICLE HAD A FRONT END OSCILLATION AND THAT TRACK BAR, STABILIZER LINK, AND UPPER AND LOWER BALL JOINTS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 127,000.

  • Filed Mar 2012

    I PURCHASED THE TRUCK USED FROM A PRIVATE DEALER IN AUG 2011 WITH 66,000MI. ON IT! FROM THE DEALER THIS ISSUE STARTED. IT HAS HAPPENED AT LEAST 2 DZ TIMES NOW AND FORD REFUSES TO ACCEPT THE ISSUE AS A FORD ISSUE! THEY TELL ME ITS THE TIRE PRESSURE AND I HAVE HAD IT TO THEM 3 TIMES TO FIX THIS ISSUE, THEY HAVE RE INFLATED MY TIRE PRESSURE TO " FACTORY RECOMMENDED PRESSURE" AND WITHIN 5 MILES ITS SHAKING SO VIOLENTLY I HAVE TO PULL OVER AND START AGAIN, THIS WILL CAUSE A DEATH EVENTUALLY!! I WILL NOT LET MY WIFE DRIVE THIS TRUCK AND THAT IS WHAT IT WAS BOUGHT FOR, A SAFE FAMILY VEHICLE. *TR

• Parking Brake4

  • Filed Aug 2011

    OCCURRING SINCE VEHICLE PURCHASED NEW ON JULY 9, 2005 WITH SIX YEAR EXTENDED WARRANTY. THE FAILURE IS THAT THE PARKING BRAKE DOES NOT WORK PROPERLY DESPITE REPEATED ATTEMPTS BY TWO DEALERS TO AS THEY SAY "ADJUST" IT. THE BRAKE WORKS AND ACTUATES 1-2 TIMES OUT OF 10 AND DOES NOT WORK IN REVERSE EVER. DEALER TOLD ME IT IS NOT DESIGNED TO WORK IN REVERSE AT ALL AND WILL NOT HOLD IN REVERSE. THE DEALERS SEE NO DEFECT AND HAVE NEVER REPLACED ANY PARTS. THE BRAKE LINING IS IN EXCELLENT CONDITION. DUE TO THIS SITUATION I SUSPECT IT IS SIMPLY A MANUFACTURER DEFECT OR DESIGN FLAW WITH SERIOUS SAFETY IMPLICATIONS IF THE TRANSMISSION PARK PIN FAILED. *TR

  • Filed Jul 2011

    REAR BRAKE BACKING PLATE RUSTED OUT CAUSING THE PARKING BRAKES TO LOCK UP ON LEFT SIDE . VEHICLE VEERED OFF ROAD. *TR

  • Filed Jan 2010

    TL*THE CONTACT OWNS A 2005 FORD F-350. WHILE DRIVING APPROXIMATELY 35 MPH, THE REAR DRIVER SIDE TIRE SUDDENLY LOCKED WHICH CAUSED THE VEHICLES REAR END TO SLIDE; HOWEVER, THE CONTACT WAS ABLE TO CONTROL THE VEHICLE AND AVOID A CRASH. THE DEALER STATED THAT THE PARKING BRAKE ASSEMBLY NEEDED TO BE REPLACED. THE CONTACT PREVIOUSLY NOTICED THAT THE PARKING BRAKE INTERMITTENTLY FAILED TO FUNCTION PROPERLY. THE CURRENT AND FAILURE MILEAGES WERE 59,000.

  • Filed Aug 2008

    REAR BRAKE DRUM FAILURE - BACKER PLATE OF MY FORD F350 HAS CORRODED TO THE EXTENT THAT THE REAR BRAKE SHOE RETAINER PINS FELL INWARDS AND THE BACK BRAKE SHOE TWISTED AROUND GRINDING IN THE REAR DRUM. UPON HEARING A NOISE SLOWED AND THE REAR WHEEL LOCKED AND SPUN THE TRUCK SIDEWAYS ON THE ROAD. THIS IS A LONG WHEEL BASE,K CREWCAB PICKUP WITH AN 8FT BOX. THE DISC ROTOR COVER HAS ALSO RUSTED THROUGH LEAVING A HOLE ALLOWING SMALL STONES TO JAM BETWEEN THE ROTOR AND BRAKES CAUSING THE VEHICLE TO PULL (ECENTUALLY START TO BRAKE ON ONE WHEEL - PROBLEMATIC ESPECIALLY WHEN BRAKING ON WET OR ICY ROADS. *TR

• Structure4

  • Filed Aug 2008

    REAR BRAKE DRUM FAILURE - BACKER PLATE OF MY FORD F350 HAS CORRODED TO THE EXTENT THAT THE REAR BRAKE SHOE RETAINER PINS FELL INWARDS AND THE BACK BRAKE SHOE TWISTED AROUND GRINDING IN THE REAR DRUM. UPON HEARING A NOISE SLOWED AND THE REAR WHEEL LOCKED AND SPUN THE TRUCK SIDEWAYS ON THE ROAD. THIS IS A LONG WHEEL BASE,K CREWCAB PICKUP WITH AN 8FT BOX. THE DISC ROTOR COVER HAS ALSO RUSTED THROUGH LEAVING A HOLE ALLOWING SMALL STONES TO JAM BETWEEN THE ROTOR AND BRAKES CAUSING THE VEHICLE TO PULL (ECENTUALLY START TO BRAKE ON ONE WHEEL - PROBLEMATIC ESPECIALLY WHEN BRAKING ON WET OR ICY ROADS. *TR

  • Filed Mar 2008

    THIS IS A DESIGN ISSUE. THE 2005 FORD F350 HAS A LARGE PART OF ITS REAR BUMPERS' HORIZONTAL SURFACE REMOVED. THE BUMPER IS THEN COVERED IN A HARD PLASTIC. I STEPPED OFF THE DECK OF MY TRUCK ONTO THE BUMPER AND THE PLASTIC SURFACE GAVE WAY. I ALMOST BROKE MY ANKLE AND LOST MY BALANCE , NOT BECAUSE THE PLASTIC BROKE THROUGH , IT JUST HAD WAY TOO MUCH FLEX IN IT. I'VE TRIED TO DEAL WITH FORD CO REGARDING THIS BUT AS YOU PROBABLY KNOW ,THEY WANT ZERO TO DO WITH THE RETAIL / POST WHOLESALE APPARATUS. I WAS TOLD TO TALK TO THE DEALER. I WOULD HAVE MORE COMPETENCE AND HONEST FEEDBACK FROM MY DOG. *TR

  • Filed Jun 2006

    THE VEHICLE IN QUESTION, A FORD F-350 PICK UP, IS NORMALLY USED TO PULL A GOOSENECK TRAILER. TO CONNECT THE TRAILER, THE TAIL GATE OF THE TRUCK MUST BE OPENED, THE TRUCK BACKED UP PART WAY, THE TAIL ATE THEN CLOSED, AND THE TRAILER CONNECTED. THE TAIL GATE IS NOT OPENED AGAIN UNTIL THE TRAILER IS BEING DISCONNECTED. I FOLLOWED THIS PROCEDURE, HAULED THE TRAILER ABOUT 40 MILES ON INTERSTATE HIGHWAY TO ITS DESTINATION AND UNLOADED THE TRAILER. I THEN WAS PROCEEDING TO PARK THE TRAILER BEFORE UNLOADING THE BED OF THE TRUCK. DURING A LOW SPEED U TURN OVER SLIGHTLY ROUGH GROUND, THE TAIL GATE OF THE FORD F-350 (WHICH WAS STILL TOWING THE GOOSE NECK TRAILER) POPPED OPEN AND FELL AGAINST THE TRAILER. BEFORE I COULD GET THE VEHICLE STOPPED, THE TAIL GATE WAS BENT BY THE TRAILER. DAMAGE TO THE TAILGATE AND TRUCK IS COSTING $1750 TO REPAIR. *JB

  • Filed Feb 2005

    CONSUMER STATES THE VEHICLE IS FOR PLOWING. HOWEVER, THE COIL SPRINGS ARE NOT STRONG ENOUGH TO HOLD THE PLOW. THE PLOW ACTUALLY DROPS DOWN HITTING THE GROUND; CAUSING THE STEERING TO BECOME ERRATIC OR DIFFICULT. *AK THE TRANSMISSION HAD GONE OUT, THE TIRES WEREN'T SUFFICIENT ENOUGH FOR THIS VEHICLE, THE GAS GAUGE READ EMPTY AT HALF FULL DUE TO THE LOW FRONT END AND THE CONSUMER WAS TOLD THAT THERE WAS NO PROBLEM, THERE WAS NO LIGHT IN THE GLOVE BOX, THERE WERE NOT MUD GUARDS IN THE WHEEL WELL, THE VOLUME WAS INOPERATIVE ON THE RADIO AND THERE WAS A PROBLEM WITH THE THROTTLE CABLE DUE TO A TWO SECOND DELAY WHEN THE GAS PEDAL WAS APPLIED. *SC

• Unknown or Other3

  • Filed Jan 2022

    Oil leaking from more than 4 parts of the engine and was told it’s normal for this model. Also, when driving over a bump or uneven pavement the trucks steering and suspension drives out of control.

  • Filed Dec 2021

    Once I get up to 55-60 mph it just shakes really bad, I have had ball joints replaced bought new tires and it still shakes

  • Filed Feb 2016

    I WAS DRIVING ON A TWO LANE BACK ROAD AROUND 45 TO 50 MPH, AND MY TRUCK STARTED VIOLENTLY SHAKING AND I LOST ALL CONTROL OF STEERING. I WENT INTO THE ONCOMING LANE, LUCKILY NO ONE WAS COMING, AND HAD TO HIT MY BRAKES HARD TO GET THE SHAKING TO STOP. IT HAS ALSO HAPPENED WHILE DRIVING AT SPEEDS OF 35-40 ON A CITY STREET AND 60 MPH ON A HIGHWAY. THIS IS KNOWN AS DEATH WOBBLE. THE WOBBLE WAS SO BAD THAT IT LOOSENED THE TRACK BAR AND THE BOLT HOLDING THE POWER STEERING HARD LINE. I LOST ALL POWER STEERING FLUID WITHIN SECONDS. I HAVE RESEARCHED IT, TRIED REPLACING SEVERAL PARTS, LIKE TIE-RODS, AND IT HAS LESSENED A LITTLE BIT, BUT IF I HIT A BUMPY ROAD OR EVEN JUST A PATCH OF NEW PAVEMENT, IT STARTS SHAKING. I HAVE READ A LOT OF OTHER FORD OWNERS ARE EXPERIENCING THIS SAME ISSUE WITH THEIR TRUCKS.

• Exterior Lighting3

  • Filed Jul 2019

    WHILE DRIVING DOWN THE HIGHWAY(45-55MPH) VEHICLE DASH LIGHTS, RADIO, WINDOWS ALL STOP WORKING. THEY COME BACK ON RANDOMLY. NO CHANGE TO LITTLE CHANGE WHEN RE-STARTING. VEHICLE ALSO LOSES POWER AND THE ENGINE SEEMS TO PAUSE AND GO, OVER AND OVER LIKE IT'S STRUGGLING. I'VE TAKEN IT TO SEVERAL FORD CERTIFIED MECHANICS WHO ARE BAFFLED.

  • Filed Sep 2016

    WHILE DRIVING ON THE INTERSTATE IN THE EVENING WITH OUR HEADLIGHTS ON, WE HAD TO BE PULLED OVER BY THE STATE POLICE TO INFORM US WE HAD ABSOLUTELY NO REAR RUNNING LIGHTS. UPON TROUBLESHOOTING THE PROBLEM I FOUND IT IS MOST LIKELY THE SAME AS RECALL NO. 11C18 MULTI-FUNCTION SWITCH. OUR MECHANIC ALSO AGREED THIS IS THE PROBLEM. BUT FORD SAYS OUR VIN # IS NOT INCLUDED IN THE RECALL. I HAVE SINCE SEEN TWO OTHER TRUCKS IDENTICAL TO OURS WITH NO REAR LIGHT AT NIGHT WHILE YET THEIR HEAD LIGHTS ARE ON.

  • Filed Aug 2008

    I RENTED A TRUCK FROM U-HAUL IN ELK GROVE, CA AT 4:50PM ON 8/28/08. ONCE THE VEHICLE WAS ABOVE 45MPH IT STARTED TO SHAKE VIOLENTLY AND ONCE IT WAS DARK, THE TAIL LIGHTS ON THE RIGHT SIDE WERE SHOWN TO BE NON-FUNCTIONING. THE REPRESENTATIVE DID NOT DO A VEHICLE INSPECTION WITH ME, IN FACT, HE TOOK OFF BEFORE I EVEN PULLED OUT OF THE DRIVE-WAY. I CALLED THE REPAIR SERVICE BECAUSE I FELT THE VEHICLE WAS UNSAFE AND WAS TOLD BY THE MECHANIC THEY SENT OUT THAT THE REAR END WAS COMING APART AND THAT THE POWER BRAKE SYSTEM HAD NO POWER WHEN I CAME TO A COMPLETE STOP. I INFORMED U-HAUL AND THEY INSISTED THAT I STILL DRIVE THE VEHICLE BACK TO THEIR FACILITY. I REFUSED, CITING THAT IT WAS UNSAFE AND ILLEGAL TO DRIVE A VEHICLE WITHOUT THE WORKING TAIL LIGHTS. THEY THEN CHARGED MY CREDIT CARD FOR THE RENTAL AND MILEAGE EVEN THOUGH THE VEHICLE STILL SAT IN MY DRIVE-WAY WITHOUT THEM KNOWING WHAT THAT MILEAGE WOULD BE. *TR

• Visibility2

  • Filed Sep 2008

    THE A/C CONTROL DOESN'T SWITCH OFF OF THE DEFROST SETTING. COULD CAUSE THE WINDSHIELD TO FOG UP AND POSSIBLY CAUSE AN ACCIDENT. THE A/C CONSTANTLY BLOWS OUT OF THE DEFROST VENTS. *TR

  • Filed Mar 2005

    DRIVER AND PASSENGER WINDOWS ARE GETTING SCRATCHED WHEN WINDOW IS GOING UP AND DOWN. DEALER/SERVICE STATES THAT ROAD DIRT IS COLLECTING IN THE FELT MATERIAL USED TO KEEP WIND NOISE AND WIPE WINDOW CLEAN WHEN WET. WINDOWS ARE GETTING DEEP SCRATCHES. VEHICLE HAS LESS THAN 3000 MILES AND HARDLY USED. WIFE'S TRUCK IS OVER 2 YEARS OLD AND WINDOWS DO NOT LOOK LIKE THIS. DEALER/SERVICE TOOK PHOTOS OF WINDOWS AND SUBMITTED TO FORD AND FORD DENIED CLAIM TO REPLACE OR REPAIR WINDOWS.*AK

• Other1

  • Filed Oct 2014

    TL* THE CONTACT OWNS A 2005 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING AT 30 MPH, THE ENGINE STALLED WITHOUT WARNING. THE FAILURE OCCURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER ON SEVERAL OCCASIONS WHERE IT WAS DIAGNOSED THAT THE MOTOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. ON ANOTHER OCCASION THE VEHICLE WAS TAKEN TO THE DEALER, WHERE IT WAS DIAGNOSED THAT THE PRESSURE UNIT FOR THE DIESEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 92,000.

• Equipment Adaptive/Mobility1

  • Filed Mar 2007

    TL* - THE CONTACT HAS A AEVIT BY EMC. THE CONTACT STATED THAT THIS EQUIPMENT WAS USED TO HELP WITH STEERING, BRAKING, AND ACCELERATION. THE CONTACT WAS JUST GOING DOWN THE ROAD WHEN ALL OF A SUDDEN THE AEVIT SYSTEM MADE A HARD LEFT AND SENT THE VEHICLE INTO A DITCH. THE CONTACT HAD TO GET SEVEN STITCHES ON HIS THE RIGHT SIDE OF FOREHEAD. A POLICE REPORT WAS TAKEN. THE WEATHER THAT DAY WAS COLD, BUT CLEAR. HE WAS DRIVING APPROXIMATELY 25 - 30 MPH. THERE WAS APPROXIMATELY $7,000 WORTH OF DAMAGE DONE TO THE VEHICLE. THE VEHICLE HAS BEEN REPAIRED, BUT HE HAS NOT DRIVEN THE VEHICLE SINCE. THE CONTACT NO LONGER HAD THE VEHICLE. *AK

• Trailer Hitches1

  • Filed Jul 2006

    2005 F-350 TRAILER BECAME UNATTACHED STRIKING THE GUARDRAIL. *TS THE TRAILER TRAVELED OFF THE LEFT SIDE OF THE ROAD AND STRUCK A MEDIAN WALL. THE CONSUMER BELIEVES THE PIN CAME OUT OF THE TRAILER HITCH. THE SAFETY CHAINS WERE ATTACHED BUT ALSO BROKEN OFF. *NM

• Interior Lighting1

  • Filed Feb 2005

    CONSUMER STATES THE VEHICLE IS FOR PLOWING. HOWEVER, THE COIL SPRINGS ARE NOT STRONG ENOUGH TO HOLD THE PLOW. THE PLOW ACTUALLY DROPS DOWN HITTING THE GROUND; CAUSING THE STEERING TO BECOME ERRATIC OR DIFFICULT. *AK THE TRANSMISSION HAD GONE OUT, THE TIRES WEREN'T SUFFICIENT ENOUGH FOR THIS VEHICLE, THE GAS GAUGE READ EMPTY AT HALF FULL DUE TO THE LOW FRONT END AND THE CONSUMER WAS TOLD THAT THERE WAS NO PROBLEM, THERE WAS NO LIGHT IN THE GLOVE BOX, THERE WERE NOT MUD GUARDS IN THE WHEEL WELL, THE VOLUME WAS INOPERATIVE ON THE RADIO AND THERE WAS A PROBLEM WITH THE THROTTLE CABLE DUE TO A TWO SECOND DELAY WHEN THE GAS PEDAL WAS APPLIED. *SC

Safety ratings

NHTSA 5-Star Safety Ratings from government crash tests. Ratings can differ by cab style and 2WD/4WD.

NHTSA hasn't published star ratings for this truck. Many heavy-duty pickups aren't included in NHTSA's crash-test program, so this doesn't mean the truck is unsafe.