2016 Ford F-350 Super Duty

What owners should know

Covers 2011–2016 · 6.7L Power Stroke diesel and 6.2L V8 gas · Updated 2026-10-01

Researched from owner forums and NHTSA complaints and written by Know Your Truck. These are patterns in what owners report, not a guarantee about any particular truck.

Common failures & how to fix them

Parts and video buttons search for your 2016 Ford F-350 Super Duty. Always confirm a part fits using your VIN. Brakes, steering, fuel and airbag work affects your safety, so if you're not sure, have a qualified mechanic do it.

• Front-end shake (death wobble)

  Moderate DIY

  Signs: Violent shaking of the steering wheel and front end after hitting a bump, usually at 45+ mph. Slowing down hard is often the only way to stop it.

  Fix: Find and replace the worn parts, most often the track bar or its bushings, then check ball joints, tie rod ends, the drag link and alignment. A new steering stabilizer alone usually only hides the problem.

  Shop: track barShop: steering stabilizer▶ How-to videos

• High-pressure fuel pump (CP4) failure

  Easy DIY

  Signs: Sudden stalling or no-start, low fuel pressure codes, metal in the fuel filter. Often there's little warning.

  Fix: Prevention is the fix you can do: change both fuel filters on schedule, drain the water separator, and buy fuel from busy stations. Some owners add a kit that keeps pump debris away from the injectors. A failed pump usually means a full fuel system replacement at a diesel shop.

  Shop: fuel filter kitShop: CP4 disaster prevention kit▶ How-to videos

• 6.7L exhaust temperature (EGT) sensor failure

  Moderate DIY

  Signs: Check engine light, reduced power, or the engine shutting down. Most common on 2011–2012 trucks.

  Fix: Scan for codes to find which sensor failed and replace it. There are four on the exhaust.

  Shop: 6.7 Powerstroke EGT sensor▶ How-to videos

• 6.7L coolant leaks

  Moderate DIY

  Signs: Low coolant, a sweet smell, dried coolant crust on the upper radiator hose fitting, radiator or coolant bottle.

  Fix: Find the source. The upper radiator hose O-ring is a common and simple fix. Radiators and coolant bottles are bigger jobs.

  Shop: 6.7 Powerstroke upper radiator hoseShop: 6.7 Powerstroke degas bottle▶ How-to videos

• 6.7L DEF heater and NOx sensors

  Moderate DIY

  Signs: DEF or exhaust fluid warnings, reduced power, check engine light.

  Fix: Scan for codes. Common fixes are a NOx sensor or the DEF heater and pump assembly.

  Shop: 6.7 Powerstroke NOx sensor▶ How-to videos

Recalls

A recall doesn't mean a truck still has the problem. Enter the truck's VIN at nhtsa.gov/recalls or ask a dealer to see whether the repair was done.

• Back Over Prevention: Sensing System: Camera

  Sep 2025 · #25V572000

  Ford Motor Company (Ford) is recalling certain 2015-2019 Lincoln MKC, Mustang, F-350 SD, F-250 SD, F-450 SD, 2015-2017 Lincoln Navigator, Expedition, 2015-2018 Edge, Transit Connect, 2016-2019 F-550 SD, Transit, 2017-2019 Econoline, and 2019 Ranger vehicles. The rearview camera may display a distorted, inverted, or blank image when the vehicle is in reverse.

  Risk and fix

  Risk: A rearview camera that displays an inverted, distorted, or blank image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.

  Fix: Dealers will inspect and replace the rearview camera as necessary, free of charge. Owner notification letters were mailed January 13, 2026. Ford owners will receive letters in phases, beginning January 2026 and June 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S89. This recall expands previous NHTSA recall number 25V270. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 8, 2025.

• Air Bags:Frontal:Driver Clockspring/Spiral Cassette

  May 2022 · #22V337000

  Ford Motor Company (Ford) is recalling certain 2016 Super Duty F-250, F-350, F-450, and F-550 vehicles. Dust may accumulate in the steering wheel clock spring, causing a disconnection in the electrical connection resulting in the driver's air bag not deploying as intended.

  Risk and fix

  Risk: A disconnected driver's air bag can result in it not deploying, as intended, during a crash, increasing the risk of injury.

  Fix: Dealers will replace the steering wheel clock spring, free of charge. Remedy parts are expected to become available in the 3rd Quarter of 2023. An interim notification letter informing owners of the safety risk was mailed on July 6, 2022. Owner notification letters were mailed July 10, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S35.

• Steering

  Dec 2020 · #20E090000

  Icon Vehicle Dynamics, LLC (Icon) is recalling all 05-UP FSD 2.5 Centerline Stabilizer Kits with part number 65050. The kits were sold as an accessory for certain 2005-2021 Ford F-250 4X4 and F-350 4X4 pickup trucks. The foam ring inside the stabilizer "through shaft" may block the piston ports, possibly causing the steering to lock up.

  Risk and fix

  Risk: If the steering locks, it can increase the risk of a crash.

  Fix: Icon will notify owners, and dealers will install a new shock assembly with a revised foam ring and steel support disc, free of charge. The recall began December 21, 2020. Owners may contact Icon customer service at 1-951-689-4266.

• Tires:Sidewall

  Apr 2016 · #16V246000

  Ford Motor Company (Ford) is recalling certain model year 2016 Ford F-250, F-350, F-450, and F-550 trucks manufactured April 5, 2016, to April 11, 2016. The tires installed during assembly of the affected vehicles may have sustained damage to the inner sidewall, possibly resulting in a loss of air or a tire rupture.

  Risk and fix

  Risk: A rapid loss of air or a tire rupture while the vehicle is being driven may cause a loss of vehicle control, increasing the risk of a crash.

  Fix: Ford will notify owners, and dealers will inspect the tires for damage and replace them as necessary, free of charge. The recall began on May 23, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S17.

Owner complaints by area

Reports owners filed with NHTSA. They aren't verified, and one complaint can mention more than one area. Tap an area to read the most recent ones.

• Suspension81

  • Filed Jul 2025

    I was driving as normal and truck started shaking vigorously until I came to a stop. From I can tell, they call this a death wobble. I almost hit another car and have some video of it.

  • Filed Feb 2025

    When reaching high speeds, my truck experiences the death wobble.

  • Filed Dec 2024

    The contact owns a 2016 Ford F-350. The contact stated while driving approximately 75 MPH, the vehicle drove over a depression in the roadway and the vehicle started vibrating abnormally and then started drifting to the left and to the right in the lane. The contact slowed down to regain control of the vehicle. There was no warning light illuminated. The contact stated that the failure was a recurring failure. The contact had taken the vehicle to a local dealer who was unable to duplicate the failure. The contact stated that the vehicle was not repaired. The contact stated that the failure had reoccurred, and the vehicle was taken back to the same dealer and the contact was informed that the tires and the brakes needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The vehicle was not taken to be diagnosed or repaired. The manufacturer was informed of the failure. The failure mileage was approximately 148,000.

  • Filed Oct 2024

    The truck has started a violent wabble on the front end making it hard to control and causing me to cone to a total stop. I have been driving the vehicle locally and at slow speeds. I have taken the vehicle to a shop for inspection at a tire and alignment shop and they recommend replacing tires and shocks. I have contacted Ford and they say I need to make an appointment to discuss. It apers, per internet research, that this is a common problem with the Super Duties. One of the times it happened I was in traffic but able to control during the stop using median. This vehicle displays the symptoms that indicate the Ford Death Wabble I have read about on the internet. No warnings.

  • Filed Sep 2024

    Death wobble happened 5 times driving on the interstate. Couldn’t control steering and everything was violently shaking.

  • Showing the 5 most recent of 81.
• Steering76

  2 involved a crash

  • Filed Jul 2025

    I was driving as normal and truck started shaking vigorously until I came to a stop. From I can tell, they call this a death wobble. I almost hit another car and have some video of it.

  • Filed Feb 2025

    When reaching high speeds, my truck experiences the death wobble.

  • Filed Sep 2024

    Death wobble happened 5 times driving on the interstate. Couldn’t control steering and everything was violently shaking.

  • Filed Jul 2024

    We purchased this truck as a certified used vehicle in January of 2019. In September of 2023 we started experiencing a death wobble every time we try and take the truck over 55 mph. We have taken the truck to the ford dealership six different times to try and fix the issue, and ford can not figure out the cause of the wobble. Currently the truck has been in the shop at ford for almost 2 months continuously with them trying to figure out what is causing the issue.

  • Filed Jul 2024

    For years my truck starts vibrating excessively, shaking the entire vehicle when driving over certain sections of roadway or bumps. Sometimes, my steering is difficult to maintain when this happens. This occurs at speeds around 50 mph+. I always assumed it was just a bad road section and never pursued any repair as I didn't think it was a truck issue. Recently, I have come across some articles, that described my exact situation/condition when driving my truck. It makes me have to slow way down below the speed limit for the violent shaking to stop. Sometimes, I though it was just my stiff suspension on bad roads. It is being called the Ford Death Wobble and affects many Ford Super Duty Trucks. Who knows what other components of my truck have been unduly affected due to this manufacturer's safety issue with my truck and that appears to be a situation that occurs often with other Ford Super Duty trucks. I'm concerned one day it will cause me to lose control and crash or crash into another vehicle. To my knowledge Ford has not issued any recall's regarding these safety problems. My truck has been to the Ford shops many times but nothing addressed regarding this condition. It has occurred so many times, I can not even count, well over hundreds of times over 8 years. The most recent time it occurred was about two weeks ago on [XXX] in Colorado Springs. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

  • Showing the 5 most recent of 76.
• Engine22

  1 involved a crash · 4 involved a fire

  • Filed May 2025

    P207F dtc Nox sensor issue

  • Filed Dec 2023

    The contact owns a 2016 Ford F-350. The contact stated while driving approximately 70 MPH, the "Engine Power Reduced" message was displayed and the vehicle downshifted while running very rough before the vehicle stalled. The contact coasted to the side of the road and had the vehicle towed to the dealer. The dealer diagnosed the vehicle and determined that the high-pressure fuel pump had failed and caused metal fragments to enter the fuel system. The contact was informed that the high-pressure fuel system needed to be replaced. The vehicle had not been repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The approximate failure mileage was 112,000.

  • Filed Apr 2023

    My vehicle was purchased from Shottenkirk Ford new in 2016. They perform my maintenance regularly. Recently, I experienced a leak and took it in; I had it towed to them. Shottenkirk wanted $1200 because they stated that the water pump needed to be replaced. After replacing the water pump, the leak was worse. Shottenkirk wanted $1200 to replace parts they said needed replacing in the transmission cooling portion. They tried to get me to trade in my vehicle for a new one. I could not afford that. After they did that repair, they said there was still a small leak. I tried to head straight home, but the vehicle would not shift into third gear, stranding me in highway traffic. I had to have the vehicle towed back to them. Now, they state that the transmission needs repair and they want $9000. I stated I could not do this and they said I could trade my 2016 Ford Diesel F350 with 4WD with numerous upgrades for a base-model 2008 Honda Ridgeline 2WD with over 100,000 miles. After researching, I believe Ford and Shottenkirk are well aware of the problems with the manufacturing of this truck, and I believe it needs to be addressed at a national level.

  • Filed Mar 2023

    My wife and I were pulling a 40’ fifth wheel from AZ to Idaho. On the Montana side of 4th of July pass I suddenly get a trouble code. The exhaust filter is full. My wife and I are both handicapped so in the mountains pulling our rv scared us both. I pulled over when I could and called Ford. The guy tells me to just drive it at a constant speed over 45 and it should clean itself. My question was I’ve been traveling over 45 for miles so why is it full? No explanation, however, he tells me if it doesn’t clean out then the trk will go into limp mode and that’s not good. But also says we should be ok for the 200 remaining miles until we get to Idaho. Well here’s the problem. My understanding is that this component is part of the emission system and is not something that is life nor death if it isn’t working. Well we get part way up the mountain not fifty miles in the middle of no where and the trk suddenly starts loosing power on a two lane mountain pass with two handicapped people, one 70 and one 62. This trk slows to 5 mph in first gear and that’s it…. That as far as I’m concerned put our lives in danger! We could have died over a stupid part of the emissions system that Ford decided was important enough to put a vehicle into a not even a limp mode but actually create a dangerous situation. Why so they can charge me $200 to clean it. Which is done by hooking a code machine to the trk and telling it to clean the exhaust filter and it all automatic. I understand this limp mode and other computer controlled systems Ford and other manufacturers built into their vehicles allows them a way to get you into their shop but taking my wife and my life into their hands is not only dangerous but should not be allowed on such a level. If we would have been hit or injured because of this there would have been a law suit for sure. So now what????

  • Filed Sep 2022

    The contact owns a 2016 Ford F-350. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer where it was diagnosed that the diesel particulate filter needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was advised to call the NHTSA Hotline. The failure mileage was approximately 44,000.

  • Showing the 5 most recent of 22.
• Air Bags21

  3 involved a crash · 1 involved a fire

  • Filed Jun 2025

    The contact owned a 2016 Ford F-350. The contact stated that while driving at 45 MPH, the vehicle was involved in a head-on crash. The air bags did not deploy. No warning lights illuminated. The vehicle was towed to a local tow yard. The vehicle was condemned as a total loss by the insurance company. The contact's wife, who is a certified RN took the contact to the local medical center. The contact sustained injuries to the back and neck. The contact sustained whiplash. In addition, the contact sustained inoperable disk injuries to his back. A Police report was filed. The manufacturer was not made aware of the failure. The failure mileage was approximately 124,000.

  • Filed Mar 2024

    Airbags are not faulty if you look at sticker they have warning due to old age the plastic becomes brittle and can cause fragments to impale driver only way to prevent this is not replace the airbag but to cover with duct tape, this recall needs to be updated Takata is not responsible, they operate as designed as I said the air bag fill with high pressure air and in older cars will crack plastic cover. Please update this recall this is not a manufacturer error.

  • Filed Oct 2023

    The contact owns a 2016 Ford F-350. The contact received notification of NHTSA Campaign Number: 22V337000 (Air Bags), and the vehicle was repaired under recall. Upon retrieving the vehicle, the contact became aware that none of the buttons on the steering wheel were functioning, including the horn. The vehicle was taken to the dealer, who determined that the failure was unrelated to the recall but was unable to provide a diagnosis. The vehicle was not repaired. After investigating the failure, the contact related it to NHTSA Campaign Number: 22V337000 (Air Bags), and the VIN was included. The manufacturer was not notified of the failure. The failure mileage was 45,000.

  • Filed Sep 2023

    The contact owns a 2016 Ford F-350. The contact received notification of NHTSA Campaign Number: 22V337000 (Air Bags), and the vehicle was taken to the dealer for the recall repair; however, the dealer later called the contact back and advised him to pick up the vehicle because they had received the wrong part and was unable to complete the recall repair. The contact stated that he had contacted the dealer several times, and the dealer informed him that the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and informed the contact that the dealer had already marked the recall as complete. The contact had not experienced a failure. VIN tool showed no open recall.

  • Filed Jul 2023

    The contact owns a 2016 Ford F-350. The contact received notification of NHTSA Campaign Number: 22V337000 (Air Bags) however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

  • Showing the 5 most recent of 21.
• Unknown or Other19

  • Filed Jul 2026

    The issue with truck is the rear window has a large mirror tint reflection. Causing a safety hazard when driving as the reflection leaves other drivers light blinded. Leaving a flash blindness.

  • Filed Feb 2026

    My 2016 Ford F-350 is included in NHTSA recall [campaign number 25S89/25V572] for rearview camera failure. I received notice probably a year ago and it stopped working 2 days ago. The camera is currently malfunctioning and I can not see behind me when I back up. Dealers state no parts available and no timeline for repair, only willing to help if I pay a $200 diagnostic fee. Vehicle remains unrepaired.

  • Filed Sep 2024

    Death wobble happened 5 times driving on the interstate. Couldn’t control steering and everything was violently shaking.

  • Filed Jul 2024

    We purchased this truck as a certified used vehicle in January of 2019. In September of 2023 we started experiencing a death wobble every time we try and take the truck over 55 mph. We have taken the truck to the ford dealership six different times to try and fix the issue, and ford can not figure out the cause of the wobble. Currently the truck has been in the shop at ford for almost 2 months continuously with them trying to figure out what is causing the issue.

  • Filed Jul 2024

    For years my truck starts vibrating excessively, shaking the entire vehicle when driving over certain sections of roadway or bumps. Sometimes, my steering is difficult to maintain when this happens. This occurs at speeds around 50 mph+. I always assumed it was just a bad road section and never pursued any repair as I didn't think it was a truck issue. Recently, I have come across some articles, that described my exact situation/condition when driving my truck. It makes me have to slow way down below the speed limit for the violent shaking to stop. Sometimes, I though it was just my stiff suspension on bad roads. It is being called the Ford Death Wobble and affects many Ford Super Duty Trucks. Who knows what other components of my truck have been unduly affected due to this manufacturer's safety issue with my truck and that appears to be a situation that occurs often with other Ford Super Duty trucks. I'm concerned one day it will cause me to lose control and crash or crash into another vehicle. To my knowledge Ford has not issued any recall's regarding these safety problems. My truck has been to the Ford shops many times but nothing addressed regarding this condition. It has occurred so many times, I can not even count, well over hundreds of times over 8 years. The most recent time it occurred was about two weeks ago on [XXX] in Colorado Springs. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

  • Showing the 5 most recent of 19.
• Fuel/Propulsion System17

  • Filed Sep 2026

    On 09-25-2026 I was changing the fuel filters on my truck when i noticed metal shavings in the bottom of the fuel filter. Immediatey contacted Norman's Auto & Diesel Repair and i had the truck towed to Norman's. The CP4 fuel pump was failing, they converted to the DCR fuel pump. The truck only has 71,234 miles on it and this problem cost me over 4,000.00 dollars. All Ford 6.7 diesel from 2011 to 2026 should be recalled. This is a problem that Ford has been knowing about since 2011. INVOICE #018016

  • Filed Apr 2026

    The CP4 is failing, this has been a know problem on these F- series trucks for sometime now. This needs to be remedied on these vehicles. This has been known for years.

  • Filed May 2025

    P207F dtc Nox sensor issue

  • Filed Apr 2024

    THERE ARE TWO INCIDENTS ONE FORD DIESEL HIGH PRESSURE FUEL PUMP DISINTERGRATES WHILE DRIVING VEHICLE AND THE INTERCOOLER HOSE WHICH IS PLASTIC BLOWS UP WHICH IN BOTH CASES CAUSES THE VEHICLE TO LOSE POWER AND STOP RUNNING. THIS OCCURED TO ME WHILE PULLING RV ON INTERSTATE .

  • Filed May 2022

    The diesel exhaust fluid system, reductant heater and sender assembly. The truck went into a -idell reduced power mode ( 5 miles an hour) 25 miles from service at 2:00 AM 300 miles from home. The dealer has the truck. They towed it in September, 2021. they have had it for seven months. I need a TRUCK !!!!!!!! What is going on, this is unacceptable.I have been renting a car since Oct, 2021. Ford didn't offer me anything. The truck has 21,000 miles on it. Sell it and get me a new truck, I need a TRUCK.

  • Showing the 5 most recent of 17.
• Power Train17

  • Filed Apr 2026

    The contact owns a 2016 Ford F-350. The contact stated that while driving at undisclosed speeds, the transmission unexpectedly downshifted to a lower gear. The check engine warning light was occasionally illuminated. The vehicle was taken to a local dealer to be diagnosed; however, the failure could not be duplicated. The contact related the failure to NHTSA Campaign: 26V237000 (Power Train); however, the VIN was not included in the recall. The manufacturer was made aware of the failure. The failure mileage was approximately 50,000.

  • Filed Aug 2025

    The contact owns a 2016 Ford F-350. The contact stated that while driving at an undisclosed speed, there was an abnormal rattling sound coming from the rear of the vehicle. The vehicle was later taken for routine maintenance, and the mechanic discovered that the rear axle bolts had sheared off and were inside the wheel hub caps. The vehicle was taken to the local dealer, who diagnosed that the rear driver’s side differential axle bolts had failed, and the axle needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 155,000.

  • Filed Apr 2024

    THERE ARE TWO INCIDENTS ONE FORD DIESEL HIGH PRESSURE FUEL PUMP DISINTERGRATES WHILE DRIVING VEHICLE AND THE INTERCOOLER HOSE WHICH IS PLASTIC BLOWS UP WHICH IN BOTH CASES CAUSES THE VEHICLE TO LOSE POWER AND STOP RUNNING. THIS OCCURED TO ME WHILE PULLING RV ON INTERSTATE .

  • Filed Dec 2023

    The contact owns a 2016 Ford F-350. The contact stated while driving at various speeds, the transmission was shifting hard and was slipping. Additionally, the vehicle was shuddering while the transmission was shifting. An unknown warning light was illuminated. The vehicle was taken to the dealer; however, the cause of the failure could not be determined. The contact stated that the failure persisted. The vehicle was taken to a transmission specialist, where it was diagnosed that the transmission had failed and needed to be replaced. The vehicle was being repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 50,000. The VIN was unavailable.

  • Filed Dec 2023

    At 55,000 miles torque converter locked up. Very difficult to stop vehicle due to excessive rpm’s. Ford has had problems with this and due to being out of year warranty..will not repair

  • Showing the 5 most recent of 17.
• Wheels12

  • Filed Jul 2023

    We have consistently had issues with severe wheel oscillation, which I’ve seen referred to as the death wobble, that causes the entire cab of the truck to shake violently and feels like the front tires are bouncing back and forth laterally on the road, when driving over 55mph and hitting any sort of uneven road or bump, especially after bridges. We have spent thousands on replacing different parts which sometimes alleviate the issue for a short period of time, but it always comes back when you least expect it. We have come incredibly close to being rear ended on the interstate several times because the only way to stop it is to slam on the breaks to decelerate quickly and get the truck below 30 miles per hour. It is more common when not hauling anything but still occurs wether hauling a light load or very heavy one as well. We have PTSD now when driving and can’t function in our business with out using a heavy duty truck. It is absolutely terrifying. This started approximately 6 months after purchasing the truck. We just had it into a Ford repair shop and put $2000 into repairs less than a month ago.

  • Filed Jan 2023

    While driving at approximately 62mph, my truck hit a small bump in the road and began shaking so violently that I could barely hold onto the wheel. I immediately braked which caused the truck to shake even more until I finally slowed to about 20th and pulled off the 2 lane highway. Luckily there was very minimal traffic and I was able to keep from losing control. I have only had this truck that I bought from a Ford dealership approximately 5 weeks. This is extremely alarming that a truck like this has no safety recall for something that after some research is named the death wobble across the web. There is no warning, and I do not believe the dealership will do anything to fix this issue without compensation.

  • Filed Oct 2022

    While traveling at Interstate speed (55-75 MPH), when you hit a certain bump or pothole or road irregularity, the front passenger wheel will begin vibrating which quickly grows in magnitude until the entire engine compartment and cab starts to violently shudder, to the point where all 4 tires begin losing contact with the road surface. The only way to regain control and reduce the harmonics is to apply maximum braking. However, as the truck starts to slow, the shudders will become more violent until finally dampening out appx. 100 yards later at around 40 MPH. Once damped out, the truck will drive smoothly and predictably again at speed until the next bump. As it stands now, I am afraid to drive the truck and my wife refuses to drive it. The big fear is having this happen while in a turn or in heavy traffic where the sudden maximum braking can cause an accident.

  • Filed Oct 2022

    Any time I hit a bump going over 50 mph the front end of my truck starts shaking violently. So much that it feels like the front end is about to break apart. The only way to stop is to slam on the brakes and slow down as fast as possible. It’s ways on the highway so it’s a danger to myself and the people behind me. I have to hold the steering wheel as tight I can to keep from losing control. Dealer told me it happens but they don’t know why. This has been happening on a daily basis since I drive on highways to get to work. And only a matter of time before I get into an accident.

  • Filed Jul 2022

    Assuming something in suspension. Uncontrollable vibration in front suspension/steering of vehicle. Not as of yet for my vehicle. Did find many reports online referencing what I/we experienced. Scheduled to take into Dealer and local service facility for further inspection. No warnings of any kind. Around 65 -70 MPH there's VIOLENT vibration/shaking on the wheels making steering uncontrollable. Vibration continues till vehicle's speed is reduced to around 40 MPH. Seams to occur when tires experience bumps/imperfections in road. These bumps/imperfections are minor at that. I have now experienced this situation now 6 times. As previously mentioned, during research I found multiple YouTube videos other online references this situation as "Death Wobble". Multiple News affiliation have done reports on this experance/situation.

  • Showing the 5 most recent of 12.
• Electrical System10

  1 involved a crash · 2 involved a fire

  • Filed Aug 2025

    The junk cab mounts deteriorate so fast the cab settles and crushes the wiring harness causing many electrical issues. There are many forums that talk about bad cab mounts and what components to use to repair them, but in my opinion this is a Ford issue.

  • Filed Feb 2024

    The contact owns a 2016 Ford F-350. The contact stated that while driving on several occasions at various speeds, the A/C unit turned off without being disengaged. The tire pressure warning light flashed on the instrument panel. Additionally, the indicator lights were blinking quickly, and trailer turn light failed to illuminate properly and there was a delay when the trailer was connected. The vehicle was taken to a dealer where it was diagnosed that the brain control module needed to be replaced. The vehicle was repaired but the failure persisted. The manufacturer was notified of the failure and a complaint was filed. The failure mileage was approximately 88,000.

  • Filed Jul 2023

    The control arm for the turnsignals and wiper system fails resulting in the delay wipers constantly running. This is both an annoyance to driving as well as an obstruction to your field of vision. There also a risk of damage to the windshield as well. This is a very, very common part failure with Ford Trucks.

  • Filed Aug 2022

    There is an "advanced" recall on the clockspring contamination on my vehicle. The local ford dealership is stating that they do not have access to the parts to fix this issue, as it's an advanced warning. The issue is that the truck is having the malfunction. The buttons on the steering wheel do not work, which is now causing me to not be able to see the display b/c it's blocked by a warning, the airbag light is on which is an indication that it does not work. Ford won't look at it without charging $200 for diagnostics and then I will be responsible for paying for the repairs, even if it has to do with the recall. They aren't even sure if the truck can be repaired because they don't have the parts for the repair?????? This is a safety issue, and is basically forcing me to find another vehicle to drive since the airbags are showing they won't work. I also can't use the handsfree phone options since the buttons don't work on the steering wheel. Need to know when the parts are going to actually be available.

  • Filed Apr 2022

    vehicle was taken to Seaside Auto Repair, Satellite Beach FL to be looked at for problems it was having on the 24th of March. On 3/31/22 the using federal agency rec'd call to pick up vehicle at the shop as they could not figure out the problem and how to fix it. The agency picked up vehicle from shop. Agency started vehicle and drove to the Pest Mgmt Shop at Patrick AFB, As the vehicle crossed the main gate, the driver heard a strange noise coming from the driver side of the hood near the side mirror, sound got faster. As he approached Anvil Ave, all power to the vehicle went down leaving him with only brake and steering control. At the same time the driver saw flames spew from the driver side panel of the hood. He pulled over, exited vehicle and contacted base fire dept.

  • Showing the 5 most recent of 10.
• Fuel System10

  • Filed Jun 2025

    The contact owns a 2016 Ford F-350. The contact stated while driving 60 MPH, there was an abnormal knocking sound coming from the engine compartment. The vehicle was taken to the local dealer where it was diagnosed and determined that the cylinder was not operating as needed, and there was engine damage. The vehicle was not repaired. The vehicle was previously taken to the local dealer, Summerville Ford (9700 Dorchester Rd, Summerville, SC 29485); where it was diagnosed and determined that there were metal shavings in the fuel system in the high-pressure fuel pump. The vehicle was repaired; however, the failure recurred. There was black smoke while driving and the check engine warning light was illuminated. The contact stated that the turbo charger, body mounts, and coolant pump were replaced; however, the failure persisted. The manufacturer was not yet contacted. The failure mileage was approximately 82,800.

  • Filed Apr 2025

    The contact owns a 2016 Ford F-350. The contact stated that the check engine warning light was illuminated. The contact stated that after adding diesel particulate filter fluid in the vehicle, the message that the vehicle was low on fluid was displayed, and the vehicle would unintendedly decelerate to under 50 MPH. The vehicle was taken to the dealer, who replaced the DPF pump and burner. Approximately 30,000 miles later, the failure recurred, and the vehicle was returned to the dealer. The dealer replaced the DPF pump and burner again. The manufacturer was informed of the failure and opened a case. The manufacturer transferred the contact to the NHTSA Hotline to report the failure. The failure mileage was 52,860.

  • Filed Dec 2024

    The contact owns a 2016 Ford F-350. The contact stated that while driving at 55 MPH, the vehicle inadvertently lost motive power. The contact was able to pull to the shoulder of the roadway, where the vehicle failed to restart. The oil and check engine warning lights were illuminated. The vehicle was towed to the dealer who diagnosed a failure with the fuel pump. The contact was informed that the entire fuel system needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure but did not assist. The failure mileage was 88,000.

  • Filed Nov 2024

    I keep on hand a set of fuel filters and other filters for my personal vehicle. The set I just installed (fuel filters), the upper one, made of plastic, exploded while purging the air out of the diesel system. Diesel went all over the motor, the exhaust, the turbo, and all over my garage. While looking into this more, I found more people in the listings showing the same thing to happen to them. I had to go out and spend another $103 to fix this problem, so I could get my vehicle up and running again. Now, imagine if this engine was hot, the exhaust hot, the turbo hot. This would have ignited the fuel and possibly caused a wreck and or loss of life. I use my vehicle to tow a 5.5 ton trailer, so the motor can run warm some days. This could have been extremely dangerous to myself and others around me. I have contacted Amazon about this seller, but when Amazon allows anyone to sell anything on there, there is opportunity for people to sell fake garbage. I have kept the filter that exploded, along with the packaging. Comparing the old with the one that exploded, I can now tell the fakes from the originals. [XXX] # In the uploads, the white writing on the canister is the fake one. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

  • Filed Jun 2024

    The contact owns a 2016 Ford F-350. The contact stated that while driving at an undisclosed speed, the engine seized. The check engine warning light illuminated. The contact stated that the vehicle failed to restart. The vehicle was towed to an independent mechanic where it was diagnosed with a failed fuel pump and metal shavings inside the fuel system. The contact was informed that the fuel system and injectors needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 150,000.

  • Showing the 5 most recent of 10.
• Diesel6

  • Filed Jun 2025

    The contact owns a 2016 Ford F-350. The contact stated while driving 60 MPH, there was an abnormal knocking sound coming from the engine compartment. The vehicle was taken to the local dealer where it was diagnosed and determined that the cylinder was not operating as needed, and there was engine damage. The vehicle was not repaired. The vehicle was previously taken to the local dealer, Summerville Ford (9700 Dorchester Rd, Summerville, SC 29485); where it was diagnosed and determined that there were metal shavings in the fuel system in the high-pressure fuel pump. The vehicle was repaired; however, the failure recurred. There was black smoke while driving and the check engine warning light was illuminated. The contact stated that the turbo charger, body mounts, and coolant pump were replaced; however, the failure persisted. The manufacturer was not yet contacted. The failure mileage was approximately 82,800.

  • Filed Apr 2025

    The contact owns a 2016 Ford F-350. The contact stated that the check engine warning light was illuminated. The contact stated that after adding diesel particulate filter fluid in the vehicle, the message that the vehicle was low on fluid was displayed, and the vehicle would unintendedly decelerate to under 50 MPH. The vehicle was taken to the dealer, who replaced the DPF pump and burner. Approximately 30,000 miles later, the failure recurred, and the vehicle was returned to the dealer. The dealer replaced the DPF pump and burner again. The manufacturer was informed of the failure and opened a case. The manufacturer transferred the contact to the NHTSA Hotline to report the failure. The failure mileage was 52,860.

  • Filed Jun 2024

    The contact owns a 2016 Ford F-350. The contact stated that while driving at an undisclosed speed, the engine seized. The check engine warning light illuminated. The contact stated that the vehicle failed to restart. The vehicle was towed to an independent mechanic where it was diagnosed with a failed fuel pump and metal shavings inside the fuel system. The contact was informed that the fuel system and injectors needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 150,000.

  • Filed Jul 2023

    The contact owns a 2016 Ford F-350. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact was able to reach her destination but had to periodically start the vehicle and let it run to ensure that the vehicle would remain operable. No warning lights were illuminated. The vehicle was taken to the dealer, who determined that the diesel exhaust fluid tank had frozen and needed to be replaced. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was 100,000.

  • Filed Sep 2022

    The contact owns a 2016 Ford F-350. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer where it was diagnosed that the diesel particulate filter needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was advised to call the NHTSA Hotline. The failure mileage was approximately 44,000.

  • Showing the 5 most recent of 6.
• Vehicle Speed Control6

  1 involved a crash

  • Filed Apr 2023

    My vehicle was purchased from Shottenkirk Ford new in 2016. They perform my maintenance regularly. Recently, I experienced a leak and took it in; I had it towed to them. Shottenkirk wanted $1200 because they stated that the water pump needed to be replaced. After replacing the water pump, the leak was worse. Shottenkirk wanted $1200 to replace parts they said needed replacing in the transmission cooling portion. They tried to get me to trade in my vehicle for a new one. I could not afford that. After they did that repair, they said there was still a small leak. I tried to head straight home, but the vehicle would not shift into third gear, stranding me in highway traffic. I had to have the vehicle towed back to them. Now, they state that the transmission needs repair and they want $9000. I stated I could not do this and they said I could trade my 2016 Ford Diesel F350 with 4WD with numerous upgrades for a base-model 2008 Honda Ridgeline 2WD with over 100,000 miles. After researching, I believe Ford and Shottenkirk are well aware of the problems with the manufacturing of this truck, and I believe it needs to be addressed at a national level.

  • Filed Aug 2022

    There is an "advanced" recall on the clockspring contamination on my vehicle. The local ford dealership is stating that they do not have access to the parts to fix this issue, as it's an advanced warning. The issue is that the truck is having the malfunction. The buttons on the steering wheel do not work, which is now causing me to not be able to see the display b/c it's blocked by a warning, the airbag light is on which is an indication that it does not work. Ford won't look at it without charging $200 for diagnostics and then I will be responsible for paying for the repairs, even if it has to do with the recall. They aren't even sure if the truck can be repaired because they don't have the parts for the repair?????? This is a safety issue, and is basically forcing me to find another vehicle to drive since the airbags are showing they won't work. I also can't use the handsfree phone options since the buttons don't work on the steering wheel. Need to know when the parts are going to actually be available.

  • Filed Dec 2021

    When driving down the road, the entire truck starts violently shaking and making it difficult to control the truck. Slowing down to 5-10mph stops the shaking.

  • Filed May 2021

    I'VE EXPERIENCED 4 EXTREME CASES OF VIOLENT WOBBLING OF THE FRONT END, UTTERLY VIOLENT AND UNCONTROLLABLE. TAP THE BRAKES IT BECOMES WORST. CANT HOLD THE STEERING WHEEL, UTTERLY RANDOM HAPPENED 4 TIMES IN THE LAST TWO WEEKS. I AM SCARED TO DRIVE THE TRUCK NOW AND IT'S MY ONLY MEANS OF TRANSPORT. I AM TERRIFIED IT'S GOING TO HAPPEN AND I WILL CRASH OR KILL MYSELF OR SOMEONE ELSE IN A WRECK WHEN THE TRUCK IS SHAKING OUT OF CONTROL. IT IS TRULY TERRIFYING. IN MOTION TYPICALLY ON A FREEWAY SPEED AROUND 50 TO 60 MPH.

  • Filed Feb 2019

    REFERENCED FORD HAD THE DRIVER'S SIDE AIRBAG DEPLOY WHILE VEHICLE WAS PARKED IN A HEATED GARAGE OVERNIGHT. THERE WAS NO KEY IN THE IGNITION. WE DO NOT HAVE A TIME FRAME FOR HOW LONG IT WAS PARKED BEFORE DEPLOYMENT. AFTER THIS DEPLOYMENT FOUND THAT THE TRUCK NO LONGER HAD POWER TO START THE VEHICLE OR ANY DASHBOARD INDICATORS/GAUGES WORKING. THE HEADLIGHTS WOULD COME ON/OFF RANDOMLY TILL BATTERY IS COMPLETELY DEAD WHILE PARKED AND SWITCH WAS IN THE OFF POSITION. SPOKE WITH THE DEALERSHIP AND THEY SAID IT WOULD TAKE UP TO 6 MONTHS TO REPAIR. I DECIDED TO SEE IF I WAS ABLE TO TRACK DOWN THE PROBLEM MYSELF. WHILE WORKING ON THE TRUCK MY DOG HAPPENED TO JUMP INTO THE TRUCK AND ALL THE LIGHTS CAME BACK ON. I TOLD HIM TO GET OUT AND AS HE WAS GETTING DOWN HE MADE CONTACT WITH THE DRIVER'S SIDE FOOT WELL COVER AND ALL THE LIGHTS WENT BACK OUT. UPON REMOVING THE FOOT WELL COVER I IMMEDIATELY FOUND BROKEN AND CHARRED WIRING TO INCLUDE THE AIRBAG WIRES BEING COMPROMISED. THE AREA OF CONCERN IS WHERE THE FOOT WELL COVER AND THE DRIVER'S SIDE KICK WELL PANEL COME TOGETHER JUST BELOW AND TO THE LEFT OF THE PARKING BRAKE. THEY USE THE OPEN SPACE BELOW THE FOOT WELL COVER TO RUN THE WIRES TO VARIOUS DIFFERENT PARTS OF THE VEHICLE. SPEAKING WITH KENDALL FORD DEALERSHIP IN WASILLA ALASKA, HE INFORMED ME THAT THE WIRE BEING CHAFFED/BROKEN AND CHARRED WAS A NORMAL WEAR AND TEAR PART AND THAT FORD WOULD NOT REPAIR IT OR REPLACE THE AIRBAG. REALLY FELT LIKE THEY DID NOT WANT TO EVEN TALK TO ME.

  • Showing the 5 most recent of 6.
• Service Brakes5

  1 involved a fire

  • Filed May 2022

    the emergency brake pads came off of the steel brake backing causing my rear tire to lock up. 1 of the 4 pads came off, broke and locked up the tire. After the repair I checked the other pads and noticed all 4 pads are coming off of the bonded steel emergency brakes. This is a very dangerous situation for anyone who experiences this situation while driving down the road.

  • Filed Aug 2020

    MICHAEL WAS CHANGE ODOMETER ENGINE TOTAL MILES TO HAVE WARRANTY FROM DEALER

  • Filed Nov 2019

    I STARTED MY TRUCK AND STARTED DOWN MY DRIVEWAY. THE STEERING WHEEL WAS VERY HARD TO TURN SO I ATTEMPTED TO STOP AND THE POWER BRAKES WERE OUT AS WELL AND ONLY HAD MANUAL BRAKES SO I HAD TO PULL THE STEERING WHEEL HARD TO TURN AND PRESS THE BRAKES VERY HARD TO STOP THE TRUCK. I STOPPED THE TRUCK, TURNED IT OFF THEN BACK ON AND THE STEERING WHEEL WITH A WHINE AND THE BRAKES WORKED BUT NOT FULLY. IT FELT LIKE THE ABS WAS ATTEMPTING TO KICK IN WHEN PRESSING THE BRAKE PEDAL. I TOOK THE TRUCK TO THE DEALERSHIP AND THEY SAID THE POWER STEERING PUMP WENT OUT AND NEEDS REPLACED. THE TRUCK HAS 29, 618 MILES.

  • Filed Jun 2017

    THE VEHICLE WAS PARKED ON AN INCLINE, WITH THE FRONT OF THE TRUCK POINTING UP THE SLOPE. THE TRANSMISSION WAS SHIFTED FROM DRIVE TO NEUTRAL, THE PARKING BRAKE WAS APPLIED, AND THEN THE TRANSMISSION WAS SHIFTED FROM NEUTRAL TO PARK. THE VEHICLE WAS LEFT UNATTENDED, AND SHORTLY AFTER THAT, IT ROLLED 10-15 FEET BACKWARDS, WITH THE TRANSMISSION IN PARK, AND THE PARKING BRAKE FULLY APPLIED. IT WAS FOUND STOPPED ON LEVEL GROUND. UPON REALIZING WHAT HAPPENED, I REPEATED THE PARKING PROCESS USING THE SAME SHIFT SEQUENCE, D-N-P, WITH THE SAME RESULTS. ADDITIONALLY, I TRIED PARKING THE TRUCK POINTING DOWN A SLOPE. IN THIS SITUATION, THE TRUCK ROLLED FORWARD, AND HAD TO BE STOPPED USING THE BRAKE PEDAL. I IMMEDIATELY TOOK THE TRUCK TO THE DEALER WHO I BOUGHT IT FROM. THEY COULD NOT REPLICATE THE PROBLEM AND TOOK NO ACTION TO INVESTIGATE OR REPAIR THE TRANSMISSION.

  • Filed Jan 2017

    VEHICLE BOUNCES VERY DANGEROUSLY CAUSING VEHICLE TO SWERVE INTO OTHER LANE. POT HOLES SHAKE VEHICLE INTO OTHER LANES. BRAKES DO NOT HOLD WELL DURING SHAKING. MYSELF INSIDE SHAKE VERY HEAVILY AS WELL FEELING LIKE A BOBBLE HEAD. STEERING BECOMES VERY DIFFICULT WHILE SHAKING. IT IS SO BAD SPEAKING IS DIFFICULT DURING THE SHAKE. THIS HAPPENS AT ANY SPEED ABOVE 55MPH. THIS OCCURS MOST ON HIGHWAYS BUT ALSO ON CITY STREETS.

• Tires5

  • Filed May 2019

    TL* THE CONTACT OWNS 2016 FORD F-350 EQUIPPED WITH WILD TRAIL TIRES (NA), TIRE LINE: COMMERCIAL LT, TIRE SIZE: 275/70/R18, AND THE DOT NUMBER: KAFK D25A. THE CONTACT STATED THAT THE TIRE WAS PRODUCED WITH THE WRONG PLY RANGE 7 INSTEAD OF 10. THE CONTACT FELT THAT THE TRACTION DID NOT MET SPECIFICATIONS, GIVEN THE RATING WAS TRACTION A. THE VEHICLE WAS HARD TO STOP IF IT MUST BRAKE AT SPEEDS OF 30 MPH OR HIGHER. THE TREAD WEAR WAS WORN DOWN QUICKLY EVEN THOUGH IT WAS RATED A. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. IT WAS UNKNOWN IF THE MANUFACTURER WAS CONTACTED. THE TIRE FAILURE MILEAGE WAS 64,000 AND THE VEHICLE FAILURE MILEAGE WAS UNKNOWN.

  • Filed Aug 2017

    PURCHASED NEW FEDERAL 35-12.5R20 COURAGIA MT TIRE, WHEELS TPMS MOUNTED AND BALANCED INSTALLED ON 2016 F-350 WITH 19340 MILES AT FIRST WE HAD A LOT OF TROUBLE WITH THE TPMS THE DEALER SAID THAT THEY SOMETIMES DON'T WORK AND TO JUST IGNORE THE LIGHT. I KNEW THAT WAS WRONG AND KEPT CHECKING TIRE PRESSURE AT 65 PSI TIRES ROAD ROUGH AND PULLED TO THE RIGHT I TOOK IT TO MY LOCAL SHOP AND THEY CHECKED ALIGNMENT AND SAID IT WAS PERFECT. ALSO SAID A TIRE MUST BE OUT OF ROUND CAUSING THE ROUGH RIDE. DEALER FOR TIRE IS 1,500 MILES AWAY CONTINUED DRIVING VEHICLE AND ON A TRIP IT GOT SO BAD THAT I REMOVED THE TIRE FROM THE TRUCK AND CAME HOME ON THE SPARE AFTER INSPECTING TIRE YOU CAN CLEARLY SEE BROKEN BELT SITUATION TWO OF THE OTHER TIRES ARE SHOWING SAME SIGNS OF PROBLEM CALLED DEALER AND HOT MAJOR RUNAROUND AFTER TWO WEEKS GOT A PERSONS CELL PHONE NUMBER SHE IS TRYING TO HELP. IT SAYS HER COMPANY WON'T ALLOW CERTAIN THINGS SO I PAID 160 TO SHIP TIRES TO UTAH. 2,000 MILES AWAY TO SEE IF THEY WILL GIVE ME ANY CREDIT TOWARDS NEW TIRES CALLS AND EMAILS TO FEDERAL TIRE COMPANY GO UNANSWERED ANTHEM TIRE WILL NOT GIVE ME THE NAME OF THEIR DISTRIBUTOR I FEEL LIKE THEY ARE GOING TO MAKE IT SO DIFFICULT THAT PEOPLE WILL JUST GIVE UP, THEY'RE SHOULD BE WARRANTY INFO GIVEN WITH EACH NEW TIRE

  • Filed Aug 2017

    PURCHASED NEW FEDERAL 35-12.5R20 COURAGIA MT TIRE, WHEELS TPMS MOUNTED AND BALANCED INSTALLED ON 2016 F-350 WITH 19340 MILES AT FIRST WE HAD A LOT OF TROUBLE WITH THE TPMS THE DEALER SAID THAT THEY SOMETIMES DON'T WORK AND TO JUST IGNORE THE LIGHT. I KNEW THAT WAS WRONG AND KEPT CHECKING TIRE PRESSURE AT 65 PSI TIRES ROAD ROUGH AND PULLED TO THE RIGHT I TOOK IT TO MY LOCAL SHOP AND THEY CHECKED ALIGNMENT AND SAID IT WAS PERFECT. ALSO SAID A TIRE MUST BE OUT OF ROUND CAUSING THE ROUGH RIDE. DEALER FOR TIRE IS 1,500 MILES AWAY CONTINUED DRIVING VEHICLE AND ON A TRIP IT GOT SO BAD THAT I REMOVED THE TIRE FROM THE TRUCK AND CAME HOME ON THE SPARE AFTER INSPECTING TIRE YOU CAN CLEARLY SEE BROKEN BELT SITUATION TWO OF THE OTHER TIRES ARE SHOWING SAME SIGNS OF PROBLEM CALLED DEALER AND HOT MAJOR RUNAROUND AFTER TWO WEEKS GOT A PERSONS CELL PHONE NUMBER SHE IS TRYING TO HELP. IT SAYS HER COMPANY WON'T ALLOW CERTAIN THINGS SO I PAID 160 TO SHIP TIRES TO UTAH. 2,000 MILES AWAY TO SEE IF THEY WILL GIVE ME ANY CREDIT TOWARDS NEW TIRES CALLS AND EMAILS TO FEDERAL TIRE COMPANY GO UNANSWERED ANTHEM TIRE WILL NOT GIVE ME THE NAME OF THEIR DISTRIBUTOR I FEEL LIKE THEY ARE GOING TO MAKE IT SO DIFFICULT THAT PEOPLE WILL JUST GIVE UP, THEY'RE SHOULD BE WARRANTY INFO GIVEN WITH EACH NEW TIRE

  • Filed Aug 2017

    PURCHASED NEW FEDERAL 35-12.5R20 COURAGIA MT TIRE, WHEELS TPMS MOUNTED AND BALANCED INSTALLED ON 2016 F-350 WITH 19340 MILES AT FIRST WE HAD A LOT OF TROUBLE WITH THE TPMS THE DEALER SAID THAT THEY SOMETIMES DON'T WORK AND TO JUST IGNORE THE LIGHT. I KNEW THAT WAS WRONG AND KEPT CHECKING TIRE PRESSURE AT 65 PSI TIRES ROAD ROUGH AND PULLED TO THE RIGHT I TOOK IT TO MY LOCAL SHOP AND THEY CHECKED ALIGNMENT AND SAID IT WAS PERFECT. ALSO SAID A TIRE MUST BE OUT OF ROUND CAUSING THE ROUGH RIDE. DEALER FOR TIRE IS 1,500 MILES AWAY CONTINUED DRIVING VEHICLE AND ON A TRIP IT GOT SO BAD THAT I REMOVED THE TIRE FROM THE TRUCK AND CAME HOME ON THE SPARE AFTER INSPECTING TIRE YOU CAN CLEARLY SEE BROKEN BELT SITUATION TWO OF THE OTHER TIRES ARE SHOWING SAME SIGNS OF PROBLEM CALLED DEALER AND HOT MAJOR RUNAROUND AFTER TWO WEEKS GOT A PERSONS CELL PHONE NUMBER SHE IS TRYING TO HELP. IT SAYS HER COMPANY WON'T ALLOW CERTAIN THINGS SO I PAID 160 TO SHIP TIRES TO UTAH. 2,000 MILES AWAY TO SEE IF THEY WILL GIVE ME ANY CREDIT TOWARDS NEW TIRES CALLS AND EMAILS TO FEDERAL TIRE COMPANY GO UNANSWERED ANTHEM TIRE WILL NOT GIVE ME THE NAME OF THEIR DISTRIBUTOR I FEEL LIKE THEY ARE GOING TO MAKE IT SO DIFFICULT THAT PEOPLE WILL JUST GIVE UP, THEY'RE SHOULD BE WARRANTY INFO GIVEN WITH EACH NEW TIRE

  • Filed Dec 2016

    TL* THE CONTACT OWNS A 2016 FORD F-350 SUPER DUTY EQUIPPED WITH BF GOODRICH RUGGED TRAIL T/A TIRES, SIZE: LT245/75R17 (NA). WHILE DRIVING 40 MPH, THE REAR DRIVER SIDE TIRE BLEW OUT. THE TIRES WERE NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 16V246000 (TIRES), BUT WAS REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE TIRE FAILURE MILEAGE WAS UNKNOWN. THE VEHICLE FAILURE MILEAGE WAS APPROXIMATELY 15,000.

• Back Over Prevention4

  • Filed May 2026

    The contact owns a 2016 Ford F-350. The contact stated while reversing, the rear view camera independently blanked on and off. The contact received a recall notification, NHTSA Campaign Number: 25V572000 (Back Over Prevention). The vehicle was taken to the dealer and the recall repair was completed. The failure reoccurred. The dealer was made aware of the failure. The contact was informed that the repair was not covered under the recall. In addition, the contact stated that the failure was peristent. The manufacturer was not made aware of the failure. The failure mileage was approximately 216,000.

  • Filed Feb 2026

    The contact owns a 2016 Ford F-350. The contact received notification of NHTSA Campaign Number: 25V572000 (Back Over Prevention); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while in reverse, the back-over prevention camera intermittently displayed a distorted, blue, or black screen. While driving at various speeds, the camera erroneously displayed an image of the rear of the vehicle. The dealer was not contacted. The manufacturer was made aware of the failure. The failure mileage was 173,293.

  • Filed May 2025

    Rear camera intermittent or degraded operation.

  • Filed Aug 2021

    I am a handicapped 65 yr. old male. I purchased this vehicle in 2019 used from a FORD dealer. Marchese Ford, Lebanon, NY. Pretty much since I have owned this vehicle, The back up camera has been working intermittingly. Sometimes it will work but lately, It is just lines and distorted objects. Or, will not come on at all. As I cannot work, I can't afford the money to diagnose the problem. I do know that it is not the camera as my son tried the camera on his friends truck and it worked properly. Now I see a recall for over 600,00 vehicles and am hoping to include my truck as I need this camera to back up as I cannot turn completely to see me surroundings due to illness/injuries. Thank You [XXX] [XXX] PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

• Engine And Engine Cooling3

  • Filed Jun 2025

    The contact owns a 2016 Ford F-350. The contact stated while driving 60 MPH, there was an abnormal knocking sound coming from the engine compartment. The vehicle was taken to the local dealer where it was diagnosed and determined that the cylinder was not operating as needed, and there was engine damage. The vehicle was not repaired. The vehicle was previously taken to the local dealer, Summerville Ford (9700 Dorchester Rd, Summerville, SC 29485); where it was diagnosed and determined that there were metal shavings in the fuel system in the high-pressure fuel pump. The vehicle was repaired; however, the failure recurred. There was black smoke while driving and the check engine warning light was illuminated. The contact stated that the turbo charger, body mounts, and coolant pump were replaced; however, the failure persisted. The manufacturer was not yet contacted. The failure mileage was approximately 82,800.

  • Filed Aug 2024

    The contact owns a 2016 Ford F-350. The contact stated while driving 45–55 MPH, the vehicle lost motive power. The contact was able to pull over and restart the vehicle, which reset the vehicle. The vehicle then went into LIMP Mode. The contact stated that the RPM failed to exceed 2,500 RPM. The vehicle was idling. There were no warning lights illuminated. The vehicle was taken to an independent mechanic, who referred the contact to a Ford dealer for assistance. The vehicle was taken to another independent mechanic, who determined that the failure was due to the turbo. The vehicle was taken to the local dealer, where it was diagnosed that the turbo needed to be replaced. The vehicle was repaired, but the failure recurred. The manufacturer was contacted, and the contact was informed that the turbo charger was good for approximately three to four years; no assistance was provided. The contact was referred to the NHTSA hotline for assistance. The failure mileage was approximately 50,000.

  • Filed Dec 2021

    The contact owns a 2016 Ford F-350. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer. The dealer diagnosed that the Diesel Exhaust Fluid (DEF) reductant heater needed to be replaced. The dealer informed the contact that the VIN was not included in a recall. The vehicle was not repaired and remained at the dealer. The manufacturer was made aware of the failure and referred the contact to file a complaint with NHTSA. The failure mileage was approximately 52,500.

• Visibility/Wiper3

  • Filed Dec 2022

    The backup camera fails to function creating a danger to children that it was specifically suppose to address.

  • Filed Nov 2018

    STARED INTERMITTENTLY WITH THE WIPER/TURN SIGNAL MULTIFUNCTION SWITCH AND THE WIPERS WOULD NOT TURN OFF EVEN THOUGH THE SWITCH WAS IN THE OFF POSITION. AS SOON AS I WOULD START THE TRUCK IT WOULD COME ON. EVENTUALLY IT WOULD NOT EVER SHUT OFF AND WENT TO THE POINT OF TEARING UP THE WIPER BLADES. HAD TO REPLACE THE WHOLE SWITCH TO FIX THE PROBLEM.

  • Filed Mar 2017

    HEATED REAR WINDOW GLASS SHATTERED. SMALL PIECES OF GLASS ALL OVER INTERIOR. VEHICLE WAS STATIONARY, NOT RUNNING, JUST SITTING IN DRIVEWAY AT THE TIME IT SHATTERED. GLASS WAS NOT IMPACTED BY ANYTHING.

• Structure2

  • Filed Aug 2025

    The junk cab mounts deteriorate so fast the cab settles and crushes the wiring harness causing many electrical issues. There are many forums that talk about bad cab mounts and what components to use to repair them, but in my opinion this is a Ford issue.

  • Filed Apr 2020

    BEFORE PURCHASING THE TRUCK IT WAS NEVER DISCLOSED TO ME IT WAS IN ACCIDENT OR A TREE OR SOMETHING FELL ON IT THE ROOF/ BACK WINDOW WAS LEAKING I TOLD THEM (DEALERSHIP), WHEN IT RAINS OR WHEN IT SNOWED THE WATER LEAKED INSIDE THE TRUCK, I WAS BACKING UP TO PUT SMALL TRAILER ON IT AND IT BUMPED THE BACK WINDOW AND IT SHATTERED, CALLED SAFELITE IN ONTARIO TO FIX WINDOW, FOUND OUT THE BACK WINDOW WAS FULL OF BUNDLE, THEY WOULDN'T FIX IT CAUSE IT HAD SO MUCH BUNDLE IN IT, SAFELITE STATED THAT THE TRUCK WAS IN WRECK AND IT WAS REPAINTED AND WHOEVER HAD IT BEFORE I PURCHASED IT FIXED IT AND SOLD IT, I CALLED A FEW OTHER PLACES AND THEY WON'T FIX IT EITHER CAUSE THAT SAME REASON, I WOULD HAVE TO TAKE IT TO A BODY SHOP. I TALK TO THE DEALERSHIP WHERE I GOT IT FROM AND THEY TOLD ME THERE WAS NOTHING THEY COULD DO ABOUT IT. WHEN PURCHASED THE TRUCK ON THE DRIVER SIDE IN THE DOOR THERE WASN'T A STICKER THERE THAT IS SUPPOSED TO BE THERE, IT'S NO STICKERS IN NONE OF THE DOORS IT'S BEEN IN THE SHOP EVERY OTHER WEEK AND SOMETHING HAS TO BE FIXED. SINCE TRUCK WAS PURCHASED IT'S BEEN IN THE SHOP SEVERAL TIMES, IT SEEMS LIKE SINCE BEGINNING OF NOVEMBER 2019. I HAVE SPENT MORE MONEY INTO GETTING THE TRUCK FIXED THAN DRIVING IT. I FEEL LIKE I'M BEING TREATED UNFAIR AND TAKING ADVANTAGE OF FOR WHAT THEY SOLD ME THIS TRUCK FOR AND IT HAS ALL THESE PROBLEMS. I PURCHASED THIS TRUCK FOR WORK (OWN BUSINESS) AND CAN'T GET THE JOB DONE AND PAY PAYMENTS ON TIME IF I DON'T HAVE A PROPER TRUCK TO GET THE WORK DONE.

• Gasoline2

  • Filed Dec 2024

    The contact owns a 2016 Ford F-350. The contact stated that while driving at 55 MPH, the vehicle inadvertently lost motive power. The contact was able to pull to the shoulder of the roadway, where the vehicle failed to restart. The oil and check engine warning lights were illuminated. The vehicle was towed to the dealer who diagnosed a failure with the fuel pump. The contact was informed that the entire fuel system needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure but did not assist. The failure mileage was 88,000.

  • Filed Dec 2020

    TL* THE CONTACT OWNS A 2016 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE FUEL MODE WARNING LIGHT ILLUMINATED, WHICH CAUSED THE VEHICLE TO STALL FOR APPROXIMATELY ONE MINUTE BEFORE RESUMING NORMAL OPERATION. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO TINDOL FORD (1901 E. FRANKLIN BLVD, GASTONIA, NC 28054, (704) 867-8341) WHERE IT WAS DIAGNOSED AND IT WAS DETERMINED THAT THE FUEL RAIL SYSTEM FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 209,700. THE VIN WAS NOT AVAILABLE.

• Other2

  • Filed Nov 2024

    I keep on hand a set of fuel filters and other filters for my personal vehicle. The set I just installed (fuel filters), the upper one, made of plastic, exploded while purging the air out of the diesel system. Diesel went all over the motor, the exhaust, the turbo, and all over my garage. While looking into this more, I found more people in the listings showing the same thing to happen to them. I had to go out and spend another $103 to fix this problem, so I could get my vehicle up and running again. Now, imagine if this engine was hot, the exhaust hot, the turbo hot. This would have ignited the fuel and possibly caused a wreck and or loss of life. I use my vehicle to tow a 5.5 ton trailer, so the motor can run warm some days. This could have been extremely dangerous to myself and others around me. I have contacted Amazon about this seller, but when Amazon allows anyone to sell anything on there, there is opportunity for people to sell fake garbage. I have kept the filter that exploded, along with the packaging. Comparing the old with the one that exploded, I can now tell the fakes from the originals. [XXX] # In the uploads, the white writing on the canister is the fake one. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

  • Filed Dec 2023

    The contact owns a 2016 Ford F-350. The contact stated while driving approximately 70 MPH, the "Engine Power Reduced" message was displayed and the vehicle downshifted while running very rough before the vehicle stalled. The contact coasted to the side of the road and had the vehicle towed to the dealer. The dealer diagnosed the vehicle and determined that the high-pressure fuel pump had failed and caused metal fragments to enter the fuel system. The contact was informed that the high-pressure fuel system needed to be replaced. The vehicle had not been repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The approximate failure mileage was 112,000.

• Electronic Stability Control (esc)2

  • Filed Aug 2020

    THE ENTIRE VEHICLE SHAKES WHEN DRIVING OVER A CERTAIN SPEED LIMIT (30+). AFTER RESEARCHING, THIS IS KNOWN TO THE PUBLIC AS "DEATH WOBBLE".

  • Filed Aug 2019

    MY 2016 F 350 HAS THE DEATH WOBBLE TOOK IT TO DEALERSHIP THEY REPAIRED THE ALIGNMENT STABILIZER ARM AND LET ME GO AND GOT ON THE INTERSTATE10 HEADED TO HOUSTON GOT SPEED UP 75 MPH AND HIT BUMP AND ALMOST LOST CONTROL OF THE TRUCK,18 WHEELER ALMOST RUN ME OVER; IT SCARED SO BAD I HAVE A PACEMAKER I THOUGHT I WAS HAVING A HEART ATTACK!!

• Traction Control System1

  • Filed Jul 2024

    The contact owns a 2016 Ford F-350. The contact stated while driving at speeds of 51 MPH or exceeding that speed, the vehicle experienced the "Death Wobble". The failure also occurred while driving over rough road surfaces. The contact stated that during the failure, the “Traction Control Loss” warning light was illuminated. The dealer was made aware of the failure. The dealer confirmed that the VIN was not included in a recall. The contact was referred to the manufacturer who confirmed that the VIN was not included in a recall. The manufacturer had referred the contact to the NHTSA Hotline to file a safety complaint. The failure mileage was 120,000.

Safety ratings

NHTSA 5-Star Safety Ratings from government crash tests. Ratings can differ by cab style and 2WD/4WD.

NHTSA hasn't published star ratings for this truck. Many heavy-duty pickups aren't included in NHTSA's crash-test program, so this doesn't mean the truck is unsafe.