2019 Ford F-350 Super Duty

What owners should know

Covers 2017–2019 · 6.7L Power Stroke diesel and 6.2L V8 gas · Updated 2026-10-01

Researched from owner forums and NHTSA complaints and written by Know Your Truck. These are patterns in what owners report, not a guarantee about any particular truck.

Common failures & how to fix them

Parts and video buttons search for your 2019 Ford F-350 Super Duty. Always confirm a part fits using your VIN. Brakes, steering, fuel and airbag work affects your safety, so if you're not sure, have a qualified mechanic do it.

• Front-end shake (death wobble)

  Moderate DIY

  Signs: Violent shaking of the steering wheel and front end after hitting a bump, usually at 45+ mph. Slowing down hard is often the only way to stop it.

  Fix: Find and replace the worn parts, most often the track bar or its bushings, then check ball joints, tie rod ends, the drag link and alignment. A new steering stabilizer alone usually only hides the problem.

  Shop: track barShop: steering stabilizer▶ How-to videos

• High-pressure fuel pump (CP4) failure

  Easy DIY

  Signs: Sudden stalling or no-start, low fuel pressure codes, metal in the fuel filter. Often there's little warning.

  Fix: Prevention is the fix you can do: change both fuel filters on schedule, drain the water separator, and buy fuel from busy stations. Some owners add a kit that keeps pump debris away from the injectors. A failed pump usually means a full fuel system replacement at a diesel shop.

  Shop: fuel filter kitShop: CP4 disaster prevention kit▶ How-to videos

• 6.7L cracked intercooler pipe

  Easy DIY

  Signs: A loud pop, sudden loss of power, boost or limp-mode codes.

  Fix: Replace the plastic cold-side intercooler pipe. Many owners upgrade to a metal pipe.

  Shop: 6.7 Powerstroke cold side intercooler pipe▶ How-to videos

• Tailgate opens by itself

  Dealer (recall)

  Signs: The tailgate drops open while driving or parked, often after rain or a car wash.

  Fix: Covered by a Ford recall for the electric release switch.

  May be covered free by recall 19V864000. Check the VIN at nhtsa.gov/recalls.

• Driveshaft failure risk

  Dealer (recall)

  Signs: Vibration from under the truck. A failure can cause loss of drive power.

  Fix: Covered by Ford recalls on certain 2017–2018 4x4s and on gas trucks with aluminum driveshafts.

  May be covered free by recall 22V880000 / 22V087000. Check the VIN at nhtsa.gov/recalls.

Recalls

A recall doesn't mean a truck still has the problem. Enter the truck's VIN at nhtsa.gov/recalls or ask a dealer to see whether the repair was done.

• Back Over Prevention: Sensing System: Camera

  Sep 2025 · #25V572000

  Ford Motor Company (Ford) is recalling certain 2015-2019 Lincoln MKC, Mustang, F-350 SD, F-250 SD, F-450 SD, 2015-2017 Lincoln Navigator, Expedition, 2015-2018 Edge, Transit Connect, 2016-2019 F-550 SD, Transit, 2017-2019 Econoline, and 2019 Ranger vehicles. The rearview camera may display a distorted, inverted, or blank image when the vehicle is in reverse.

  Risk and fix

  Risk: A rearview camera that displays an inverted, distorted, or blank image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.

  Fix: Dealers will inspect and replace the rearview camera as necessary, free of charge. Owner notification letters were mailed January 13, 2026. Ford owners will receive letters in phases, beginning January 2026 and June 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S89. This recall expands previous NHTSA recall number 25V270. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 8, 2025.

• Equipment:Other:Owners/Service/Other Manual

  Jun 2023 · #23V420000

  Ford Motor Company (Ford) is recalling certain 2018-2023 Expedition and Lincoln Navigator vehicles equipped with third-row seating; and 2019-2023 F-Super Duty F-250, F-350, F-450, and F-550 SuperCab vehicles. The owner's manual does not include instructions for adjusting or removing certain head restraints. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 202, "Head Restraints."

  Risk and fix

  Risk: Without instructions, the head restraints may be improperly adjusted, increasing the risk of injury in the event of a crash.

  Fix: Ford will mail the Owner's Manual addendums that describe how to adjust and remove the head restraints for the center seating positions, free of charge. Owner notification letters were mailed July 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C20.

• Back Over Prevention: Sensing System: Camera

  Aug 2022 · #22V644000

  Ford Motor Company (Ford) is recalling certain 2017-2020 F-Super Duty F-250, F-350, F-450, and 2017-2020 Lincoln Continental vehicles equipped with the 360-degree camera system. Degradation of the camera's anit-reflective lens coating can lead to a foggy or cloudy rearview camera image.

  Risk and fix

  Risk: Lack of a clear rearview camera image can reduce the driver's visibility of what is behind the vehicle, increasing the risk of a crash.

  Fix: Dealers will replace the rearview camera, free of charge. Owner notification letters were mailed July 14, 2023. Owners may contact Ford customer service at 1-800-1-866-436-7332. Ford's number for this recall is 22S51.

• Back Over Prevention: Sensing System: Camera

  Apr 2022 · #22V252000

  Ford Motor Company (Ford) is recalling certain 2019 F-150, Super Duty F-250, F-350, F-450, and F-550 vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or distorted image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

  Risk and fix

  Risk: A rearview camera that displays a blank or distorted image can reduce the drivers view of what is behind the vehicle, increasing the risk of a crash.

  Fix: Dealers will replace the rearview camera, free of charge. Owner notification letters were mailed June 2, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C19.

• Structure:Frame And Members:Underbody Shields

  Feb 2022 · #22V087000

  Ford Motor Company (Ford) is recalling certain 2017-2022 F-250 and F-350 Super Duty vehicles equipped with gasoline engines and aluminum driveshafts. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.

  Risk and fix

  Risk: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.

  Fix: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed on April 7, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S09.

• Tires

  Mar 2021 · #21V155000

  Ford Motor Company (Ford) is recalling certain 2018 F-150, 2018-2020 F-250, F-350, and 2019 Escape vehicles equipped with Continental tires. On the affected vehicles, it is possible that one or more tires were cured for too long during tire production.

  Risk and fix

  Risk: Over cured tires may develop a break in the sidewall, resulting in sudden air loss or belt edge separation which could lead to tread/belt loss. Either condition can cause a loss of vehicle control, increasing the risk of a crash.

  Fix: Ford will notify owners, and dealers will inspect the tires, and replace them as necessary, free of charge. The recall began on March 27, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S10.

• Steering

  Dec 2020 · #20E090000

  Icon Vehicle Dynamics, LLC (Icon) is recalling all 05-UP FSD 2.5 Centerline Stabilizer Kits with part number 65050. The kits were sold as an accessory for certain 2005-2021 Ford F-250 4X4 and F-350 4X4 pickup trucks. The foam ring inside the stabilizer "through shaft" may block the piston ports, possibly causing the steering to lock up.

  Risk and fix

  Risk: If the steering locks, it can increase the risk of a crash.

  Fix: Icon will notify owners, and dealers will install a new shock assembly with a revised foam ring and steel support disc, free of charge. The recall began December 21, 2020. Owners may contact Icon customer service at 1-951-689-4266.

• Power Train:Axle Assembly

  Sep 2020 · #20V576000

  Ford Motor Company (Ford) is recalling certain 2019 F-250 and F-350, single rear wheel and dual rear wheel, 4X4 vehicles. The front axles may contain a wheel end yoke that was not properly welded to the axle tube end.

  Risk and fix

  Risk: An improperly welded axle may affect vehicle control, increasing the risk of a crash.

  Fix: Ford will notify owners and dealers will inspect the front axle wheel yoke weld location. If the weld is found to be inaccurately located, the axle assembly will be replaced free of charge. The recall began October 16, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S56.

• Structure:Body:Roof And Pillars

  Dec 2019 · #19V880000

  Ford Motor Company (Ford) is recalling certain 2017-2019 F-Super Duty F-250, F-350, F-450, and F-550 SuperCrew Cab vehicles with carpet flooring. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.

  Risk and fix

  Risk: A vehicle fire could result if materials ignite inside the vehicle.

  Fix: Ford will notify owners, and dealers will apply heat resistant tape to the carpet and its insulation, and modify the B-Pillar insulation as necessary, free of charge. The recall is expected to begin January 20, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S52.

• Latches/Locks/Linkages:Tailgate:Latch

  Dec 2019 · #19V864000

  Ford Motor Company (Ford) is recalling certain 2017-2019 Super Duty F-250, F-350, and F-450 trucks equipped with an electric tailgate latch release switch mounted in the tailgate handle. Water may enter the electrical wiring system and cause a short circuit, activating the switch and releasing the tailgate latches.

  Risk and fix

  Risk: Unintended tailgate opening may allow unrestrained cargo to fall out of the truck bed and become a road hazard, increasing the risk of a crash.

  Fix: Ford will notify owners, and dealers will modify the tailgate/frame wiring harnesses by adding jumper pigtails to isolate the tailgate release control circuits and will install a new tailgate handle release switch, free of charge. The recall is expected to begin January 20, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S48.

• Exterior Lighting:Headlights

  Nov 2019 · #19V808000

  Ford Motor Company (Ford) is recalling certain 2018-2019 F-250, F-350 and F-450 Super Duty trucks. The Daytime Running Lights (DRL) may not dim when the headlight switch is moved into the "On" position. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."

  Risk and fix

  Risk: DRL that cannot dim may reduce the visibility of other drivers, increasing the risk of a crash.

  Fix: Ford has notified owners, and dealers will reprogram the Body Control Module (BCM) software, free of charge. The recall began November 25, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C10.

• Power Train:Axle Assembly:Axle Shaft

  Sep 2019 · #19V688000

  Ford Motor Company (Ford) is recalling certain 2019 F-250 and F-350 vehicles equipped with electronically locking rear differentials. The passenger side rear axle shaft may fail prematurely due to a material issue.

  Risk and fix

  Risk: A broken passenger side rear axle could result in a loss of drive power and the inability to hold the vehicle still when in Park. If the parking brake is not applied, unintended vehicle movement can occur, increasing the risk of a crash.

  Fix: Ford will notify owners, and dealers will inspect the passenger side rear axle shaft, replacing it as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S31.

• Seats:Front Assembly:Recliner

  Aug 2019 · #19V633000

  Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."

  Risk and fix

  Risk: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.

  Fix: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.

• Engine

  Apr 2019 · #19V278000

  Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.

  Risk and fix

  Risk: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.

  Fix: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.

• Engine

  Dec 2018 · #18V894000

  Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater. Water and contaminants may get into the block heater cable's splice connector causing corrosion and damage.

  Risk and fix

  Risk: When the heater is plugged in, prolonged corrosion could cause a resistive short, increasing the risk of overheated or melted wiring which can increase the risk of a fire.

  Fix: Ford will notify owners, and dealers will disable the block heater cable, free of charge. Once parts are available, Dealers will replace the engine block heater cable, free of charge. The recall began June 3, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S45.

• Power Train:Automatic Transmission

  Nov 2018 · #18V802000

  Ford Motor Company (Ford) is recalling certain 2019 Ford F-250 Super Duty, F-350 Super Duty and F-450 Super Duty vehicles. An incorrect transmission case casting may cause the park pawl assembly to not be secured, possibly resulting in unintended vehicle movement.

  Risk and fix

  Risk: Unintended vehicle movement can increase the risk of a crash.

  Fix: Ford will notify owners and dealers will inspect the transmission case, replacing the transmission as necessary, free of charge. The recall began December 7, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S36.

Owner complaints by area

Reports owners filed with NHTSA. They aren't verified, and one complaint can mention more than one area. Tap an area to read the most recent ones.

• Steering266

  2 involved a crash

  • Filed Apr 2026

    A steering control module in my steering wheel failed which makes the lane keeping warning not operate correctly and the steering wheel not straight it's set at an angle to the right so when you're driving down the road you have to have it constantly turn to the right a little bit in order to go straight down the road in order to fix it you have to replace the entire steering wheel which is about 3,400 or so.

  • Filed Jun 2025

    The contact owns a 2019 Ford F-350. The contact stated that on three occasions while driving approximately 60 MPH, the front end of the vehicle started to wobble violently. The contact stated that when the brake pedal was depressed and the vehicle decelerated below 30 MPH, the wobbling ceased. The contact stated that there were no warning lights illuminated. The contact’s wife observed an unknown recall that might be associated with the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 37,000.

  • Filed Jun 2025

    The contact owns a 2019 Ford F-350. The contact stated that while driving on the highway at 75 MPH, the vehicle started shaking violently. There was no warning light illuminated. The contact pulled over to inspect the vehicle; however, the contact found no fault with the vehicle. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. The contact was informed that the VIN was not under recall. The manufacturer was notified of the failure. The approximate failure mileage was 66,500.

  • Filed May 2025

    I was driving at freeway speeds on the interstate when I hit a divot in the pavement. My truck started shaking violently and I could barely control the steering and/or hold onto the steering wheel. When I applied the brakes, the issue worsened. I was finally able to find a spot to pull off. The shaking stopped and I was able to re-enter the freeway. This issue has occurred on three separate occasions. The first incident occurred on or about March 31, 2025, as described above. The second and third incident occurred yesterday, May 11th, mirroring the conditions of March 31st.

  • Filed Jan 2025

    The contact owns a 2019 Ford F-350. The contact stated the adaptive steering fault light was illuminated and then the adaptive steering failed to operate as designed. The contact stated that while depressing the accelerator pedal, the vehicle failed to accelerate, and was ambling forward instead. The vehicle was taken to the dealer who diagnosed and determined that the failure was related to recall CXH03332865/R323W4 for the adaptive steering failure; however, the vehicle was not included. The vehicle had not been repaired. The manufacturer was made aware of the failure and confirmed that the VIN was not included in a recall related to the failure. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 40,000.

  • Showing the 5 most recent of 266.
• Suspension227

  3 involved a crash

  • Filed Jun 2025

    The contact owns a 2019 Ford F-350. The contact stated that on three occasions while driving approximately 60 MPH, the front end of the vehicle started to wobble violently. The contact stated that when the brake pedal was depressed and the vehicle decelerated below 30 MPH, the wobbling ceased. The contact stated that there were no warning lights illuminated. The contact’s wife observed an unknown recall that might be associated with the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 37,000.

  • Filed Jun 2025

    The contact owns a 2019 Ford F-350. The contact stated that while driving on the highway at 75 MPH, the vehicle started shaking violently. There was no warning light illuminated. The contact pulled over to inspect the vehicle; however, the contact found no fault with the vehicle. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. The contact was informed that the VIN was not under recall. The manufacturer was notified of the failure. The approximate failure mileage was 66,500.

  • Filed Sep 2024

    Front steering/suspension system Severe wobble causes driver to stop in middle of Freeway, possible accidents or death in an accident. Not confirmed by dealer at this time. Hundreds have reported here, and the same occured. Not at this time. No warnings prior to all of the failures. So far 12 failures Yes, 12 failures.

  • Filed Sep 2024

    DEATH WOBBLE, front suspension and steering Danger of a rear end collision at freeway speeds, or loss of control hitting other vehicles or items on the side of the road, result possible death to passengers, other vehicle people or bystanders. NO NO NONE I am a former Mechanic and this is LIFE THREATENING.

  • Filed Aug 2024

    My truck has only 13000 miles on it. We were going on vacation pulling our camper. I was doing about 63 MPH when we hit a bump in the interstate and the truck started VIOLENTLY shaking out of control. They cal it the death wobble. After doing some research it seams to be a very common problem that ford will not fully address. They put a bandage over a serious issue. They put me, my family and others in very serious danger. It took everything I had to keep us from going in the ditch. A vehicle with only 13000 miles on it should not experience something like this.

  • Showing the 5 most recent of 227.
• Unknown or Other42

  3 involved a crash · 2 involved a fire

  • Filed Jun 2025

    Rear backup camera foggy, can barely see the lines. I understand there is a possible recall but my vehicle doesn't show it

  • Filed Jan 2025

    [XXX] my 2019 ford f350 extended cab 4x4 6.7 diesel engine caught fire while i was driving on [XXX] i was pulling a small gooseneck horse trailer with 2 live horses inside. I was traveling at 60mph. no modifications to the truck, everything stock. a car pulled along side me pointing to the front of the truck yelling your on fire. immediately got off on an exit ramp, the truck engine died and i lost all power . i tried to put it in park nothing happened. the truck and trailer started to roll backwards off an embankment. i got the emergency brake on. my wife and i exited the truck the whole front end was on fire 50 ft + flames . we got the horses out and away .according to parkhills mo. fire dept truck burned to the ground in less than 15 minutes. they stated it was a fuel fed fire. all the fire crew and responding police officers stated it was a common occurrence for that model ford to catch fire . this truck had 19,967 miles no modifications. no warnings ,no fuel smells .nothing to indicate any problems. truck went from running perfect to burned up in less than 15 minutes. total loss of the truck along with all my personal belongings. we were lucky ourselves and our horses escaped. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

  • Filed Apr 2024

    The rear cab glass completely shattered due to the defrost heating element shorting out because it had broken and falling off of middle sliding window, started to melt carpeting behind the seat and immediately burst the entire rear glass.

  • Filed Nov 2023

    We started to have issues with our back up camera sporadically working, images appearing fuzzy and now the camera has gone completely blank - blue screen. We use this pickup truck to plow in the winter and the camera is important for that. Not having a working back up camera is a safety hazard under normal conditions as well. The issue is that Ford has a recall on "certain" 2019 F-350 trucks with back up camera issues WHICH ARE THE EXACT SAME ISSUES that are happening with our back up camera. This can not be a coincidence. I have called the Ford recall line and spoke to a representative who told me he would document my issue and forward the call information on to his manager. He told me to report it to the NHTSA as well. This is absolutely the same issue and we are not happy that they won't do right by us and take care of this issue.

  • Filed Oct 2023

    Panoramic sunroof suddenly cracks. Contacted Ford dealership and they told me to go through my insurance. I read up on forums on this issue and it is happening to Ford owners with sunroofs.

  • Showing the 5 most recent of 42.
• Wheels40

  1 involved a crash

  • Filed Aug 2024

    The contact owns a 2019 Ford F-350. The contact stated that while the vehicle was parked, it was discovered that the air pressure in all four tires were consistently decreasing; the contact also noticed corrosion around the rims and valve stems on each wheel. The low tire pressure warning light was illuminated. The vehicle was driven to a dealer but not diagnosed; however, the contact was informed that the dealer would replace the current tires with new tires to monitor the failure. The vehicle was repaired; however, the failure reoccurred. The contact was constantly adding air to the tires before driving the vehicle. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 25,000.

  • Filed Aug 2024

    In June 2024, I experienced serious sustained steering wheel oscillation to the point of having to stop the vehicle while traveling over 70 mph to regain control before proceeding on my way. I scheduled an appointment with my dealer (Woody Anderson Ford, Huntsville, AL) after July 4th weekend and was assigned an appointment date of August 9, 2024 at 10:00am. In May 2024, after traveling about 47 mph over a semi-diagonal railroad tracks on level pavement, the steering became violent but was recoverable after reducing speed to under 20 mph. This was the second instance. In March 2024, after transitioning across a section of highway in town at about +/- 45 mph, which the highway had appeared to have been poorly repaired my steering began to oscillate but I was able to recover with no concern. This was the first instance.

  • Filed Aug 2023

    Steering suspension has been failing over and over for months. Several severe incidents while driving 70+ mph down the road. Complete loss of control of the vehicle, uncontrollable death wobbles. One incident put me in a ditch, while the others were near collisions. First incident - was no longer able to drive above 30mph without sever death wobble. After “repairs”, recreated the issue at 75 mph and I’m unable to drive safely above 35 mph. Ford has confirmed many parts needing replacement but will not take ownership in replacing them. First incident -$5,300. Second incident - nearly $2500. There were no warning lamps, messages, or any notification of failure prior to incident. The entire front end of these vehicles need to be recalled. There is a class action lawsuit for a reason. I’m unable to sell my truck, or drive it do to costly RECURRING repairs. I’m fearful for my life in my Ford.

  • Filed May 2023

    Driving down i70 in Colorado and hit a section where there is concrete. One of the cracks in the concrete caused the steering wheel to vibrate uncontrollably until the speed dropped below 50 mph. During the incident braking made the vibration worse and it felt as though the front of the truck was bouncing at a rapid rate. Steering in any direction was nearly impossible. I have a service scheduled to look at this in a few weeks but until then I fear driving as it was a complete loss of control. This happened a few more times on the journey home and seems to be tied to bumps in the road when traveling over 55 mph. This incident happened without warning and did not cause any warning lights to appear. This truck has less than 15k miles on it so I was surprised it would behave this way.

  • Filed Apr 2023

    I’ve experienced 3 nearly identical incidents: after driving over bumps in the road or uneven pavement, my F350 went into an uncontrolled wobble, violently shaking, causing total loss of steering control. In each case, the uncontrolled wobble only stopped after I slowed the vehicle to under 15 mph. Because these incidents occurred on major freeways with fast moving traffic, a significant danger was posed to me and my passengers and other drivers. After searching online resources, I read several similar instances of this happening to other F350/250 owners, aka “the death wobble.”

  • Showing the 5 most recent of 40.
• Structure23

  2 involved a crash

  • Filed Feb 2025

    The contact owns a 2019 Ford F-350. The contact stated while the vehicle was in the automatic car wash, water entered the vehicle from the front windshield. The water leaked into the fuse box and short-circuited the fuse box. The vehicle was towed to the dealer where it was determined that the seal around the windshield needed to be resealed and the fuse box replaced. The vehicle was repaired. The contact stated that on a separate occasion while driving 70 MPH, the vehicle abruptly came to a complete stop. No warning lights were illuminated. The vehicle was towed to the dealer, who diagnosed and determined that the transmission had failed. The vehicle was repaired, but the failure reoccurred 2 additional times. The dealer diagnosed that the clutch plate failed and gear 1 and gear 2 were heat-welded together. The vehicle was not repaired and remained at the dealer. The manufacturer was notified of the failure. The failure mileage was approximately 30,000.

  • Filed Dec 2024

    Interior cabin Air Conditioning Unit leaks water inside the cab area. Water leaks below the passenger dash area, creating mold to the carpet and flooring. Water damage caused to the inside of the vehicle on multiple areas around the passenger front side inside the cabin.

  • Filed Jul 2024

    The contact owns a 2019 Ford F-350. The contact stated that the roof seam cover had lifted and detached. Additionally, the contact stated that while raining or washing the vehicle, there was water entering the headlight enclosures and the headlights became inoperable. While the vehicle was in park(P), the interior lights turned on without driver input, and turned off while shifted into reverse(R). There was no notification from Ford Pass. There were no warning lights illuminated. The vehicle was taken to the local dealer, who informed the contact that there were no open recalls but diagnosed the vehicle and determined that the headlight assembly needed to be replaced. The vehicle was repaired, but the failure recurred. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 10,000.

  • Filed Dec 2023

    It had a tailgate recall, when recall first came out, they wouldn't look at it. It hadn't caused any damage, or wasn't bad enough. Then they didn't have the parts. Now when they have the parts, they will not fix it because it has to many miles on it. Well DUH! It is a work truck. Causing major insurance claims. and I can't get it fixed?

  • Filed Jul 2022

    On or around June 4, 2022 I was driving my truck and had my enclosed trailer attached. I went to put my trailer up in storage and noticed my tailgate had opened on its own. This has caused damage to my tailgate and is a major safety concern that the tailgate is opening on its own.

  • Showing the 5 most recent of 23.
• Back Over Prevention20

  • Filed Mar 2026

    My rearview camera is showing a distorted image and then goes blank while in reverse creating a safety issue while backing up. The camera is doing everything listed in the following recall campaigns: 20C19/22V252 20C19/24V188 20C19/20V575 but Ford says my truck does not qualify for the recall because my VIN is not listed in the recall.

  • Filed Jul 2025

    The contact owns a 2019 Ford F-350. The contact stated that while reversing, the rearview camera failed to display a rearview image. The contact stated that the vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 25V442000 (Back Over Prevention), but the VIN was not included. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 40,000.

  • Filed Jul 2025

    The contact owns a 2019 Ford F-350. The contact stated that while reversing, the rearview camera failed to display a rearview image. The contact stated that the vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 25V442000 (Back Over Prevention), but the VIN was not included. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 40,000.

  • Filed Jun 2023

    The contact owns a 2019 Ford F-350. The contact received notification of NHTSA Campaign Number: 22V644000 (Back Over Prevention) however, the part to do the recall repair was not yet available. The local dealer was contacted. Recently, the contact stated that a blank image would appear on the screen while the vehicle was in reverse(R). The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was approximately 31,000. VIN tool confirms parts not available.

  • Filed May 2023

    The contact owns a 2019 Ford F-350. The contact received notification of NHTSA Campaign Number: 22V644000 (Back Over Prevention) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

  • Showing the 5 most recent of 20.
• Engine18

  2 involved a fire

  • Filed Aug 2026

    Wife was driving the truck(I was the passenger) while towing our dump trailer. After approx 100 miles into this trip the dash showed a "Reduced Engine Power Warning", and then shuddered. That was immediately followed by a "Service Engine Soon" warning on the dash, and the truck shut down as we were pulling to the shoulder. I smelled diesel fuel as we slowed to a stop. I got out and saw some smoke coming from under the hood. I looked under the truck and saw burning material falling from underneath, I shouted fire, and my wife exited while I retrieved our dog from the back seat. The cab was filling with smoke. Wife called [XXX] while I retrieved a few more small items from back seat. We stepped back and the truck was fully engulfed in flames in a few minutes. Fire crews were on scene after several more minutes, and by that time the truck was burnt to the ground. This truck was in excellent condition with no prior running issues or warnings of mechanical problems. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

  • Filed Apr 2026

    While sitting at a stop sign, the fuel supply line blue off the fuel filter under the hood. Straying diesel fuel all over. The white clip that hold the hose on had crumbled apart, It soaked the engine with fuel and we were lucky it did not start a fire. The fuel line was reattached and it then blew off again. I had to replace the entire fuel line at a cost of around $1000. Prior to the first event the filter had been on the truck and was being serviced every other oil change in line with the manufactured guidelines. When looking on line this is a major problem with the fuel line and under hood filters causing fires. This needs a repair before more people are hurt

  • Filed Jan 2026

    I have about 54000 miles on a 2019 ford super duty 350 with the Power stroke 6.7. Engine light went on and its at Willowbrook ford in Illinois. Emission problem with Particular Sensor code 22e02. The cost of repair is between 816 plus another 1259 if it is cracked. This is absolutely ridiculous. After researching this is a big Ford problem. So they sold some trucks without them and have eliminated them on their 22 models. I think Ford should be responsible for the cost.

  • Filed Sep 2025

    The contact owns a 2019 Ford F-350. The contact stated that while driving at an undisclosed speed, the check engine warning light was illuminated. The contact stated that after the vehicle was parked and turned off, there was fuel leaking from the engine compartment. The contact became aware that the fuel line was inoperable, causing fuel to leak onto the engine and the exhaust system. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 44,000.

  • Filed May 2025

    The contact owns a 2019 Ford F-350. The contact stated while driving at an undisclosed speed, there was an abnormal burning odor and white smoke coming from under the hood. There was no warning light illuminated. The contact diagnosed the vehicle with an upper oil pan leak. The vehicle was taken to a local dealer, where it was diagnosed with the same failure and remained at the dealer for further repairs. The manufacturer was made aware of the failure. The failure mileage was approximately 57,000.

  • Showing the 5 most recent of 18.
• Electrical System16

  2 involved a crash

  • Filed Aug 2025

    My back up camera is not working.

  • Filed Feb 2025

    The contact owns a 2019 Ford F-350. The contact stated while the vehicle was in the automatic car wash, water entered the vehicle from the front windshield. The water leaked into the fuse box and short-circuited the fuse box. The vehicle was towed to the dealer where it was determined that the seal around the windshield needed to be resealed and the fuse box replaced. The vehicle was repaired. The contact stated that on a separate occasion while driving 70 MPH, the vehicle abruptly came to a complete stop. No warning lights were illuminated. The vehicle was towed to the dealer, who diagnosed and determined that the transmission had failed. The vehicle was repaired, but the failure reoccurred 2 additional times. The dealer diagnosed that the clutch plate failed and gear 1 and gear 2 were heat-welded together. The vehicle was not repaired and remained at the dealer. The manufacturer was notified of the failure. The failure mileage was approximately 30,000.

  • Filed Dec 2024

    Due to a recall, the Vehicle computer was reprogrammed by local dealer, Griffith Ford, in San Marcos, Texas. After the reprogramming, the engine and transmission starting to rev differently and could not shift gears smoothly as previous to the reprogramming. The transmission and engine does not synchronize correctly. The transmission tries to do more than 6 speeds when the transmission is a 6 speed transmission. Turbo is also not as smooth as previously. Possibly the new program used to reprogram the computer is either for newer vehicles with different engines and/or transmissions.

  • Filed Jun 2024

    When you drive this truck for extended periods of time the entire instrument cluster shuts off loosing blinkers lights and any indication of speed, among that if you're towing a trailer the trailer lights shut off, ford has tried fixing it under warranty to no avail, now the truck is out of warranty and the issue is getting worse and they're not sure what's wrong. I also have videos of this issue

  • Filed Nov 2023

    The back up camera will display a blue screen when truck is in reverse. This is a full size truck and I am unable to see behind me when trying to backup. There have been recalls on this issue with ford but apparently my truck is not one of them.

  • Showing the 5 most recent of 16.
• Fuel/Propulsion System14

  3 involved a fire

  • Filed Aug 2026

    Wife was driving the truck(I was the passenger) while towing our dump trailer. After approx 100 miles into this trip the dash showed a "Reduced Engine Power Warning", and then shuddered. That was immediately followed by a "Service Engine Soon" warning on the dash, and the truck shut down as we were pulling to the shoulder. I smelled diesel fuel as we slowed to a stop. I got out and saw some smoke coming from under the hood. I looked under the truck and saw burning material falling from underneath, I shouted fire, and my wife exited while I retrieved our dog from the back seat. The cab was filling with smoke. Wife called [XXX] while I retrieved a few more small items from back seat. We stepped back and the truck was fully engulfed in flames in a few minutes. Fire crews were on scene after several more minutes, and by that time the truck was burnt to the ground. This truck was in excellent condition with no prior running issues or warnings of mechanical problems. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

  • Filed Jun 2026

    This model has the same Bosh CP4 high pressure fuel pump as the recalled models 2020-2022 and in fact being older the catastrophic failure risk is higher due to additional mileage. If this part fails the engine shuts off with loss of steering and braking even when pulling 15-20K pounds. The safety concern for this year is the same or greater then newer models.

  • Filed Apr 2026

    While sitting at a stop sign, the fuel supply line blue off the fuel filter under the hood. Straying diesel fuel all over. The white clip that hold the hose on had crumbled apart, It soaked the engine with fuel and we were lucky it did not start a fire. The fuel line was reattached and it then blew off again. I had to replace the entire fuel line at a cost of around $1000. Prior to the first event the filter had been on the truck and was being serviced every other oil change in line with the manufactured guidelines. When looking on line this is a major problem with the fuel line and under hood filters causing fires. This needs a repair before more people are hurt

  • Filed Feb 2026

    Failed component was the upper fuel filter/ fuel filter connecting lines located on top of the 6.7 power stroke engine broke and poured diesel all over the engine and into the valley causing the engine and engine bay to catch on fire while driving down the road. Safety was the fact that our entire truck burnt down and there was extreme risk of loss of life and ended up total loss of property. There have been multiple cases of power strokes from 2011-2026 equipped with the 6.7L power stroke diesel engine having this exact same problem due to the poor placement and inadequate materials to be used in high pressure fuel lines and filters. The vehicle was inspected by insurance and they did determine that was the cause of the fire. There were no warnings, we started smelling something and then smoke began coming through the vents. Pulled over and by then the engine bay was on fire and even the fire extinguisher could not put the diesel out and the entire truck was engulfed in flames in a matter of minutes. Ford needs to fix this issue with the placement of their upper fuel filters and should be held accountable to their customers who have suffered loss for this.

  • Filed Mar 2025

    The fuel filter housing cracked and started pouring diesel out the top and back of the engine. No warning lights going to dealer for replacement. This can be very dangerous for vehicle occupants and another motorist.

  • Showing the 5 most recent of 14.
• Power Train13

  1 involved a fire

  • Filed Sep 2026

    My 2019 Ford F350 fully power stroke deisel super duty started making a terrible grinding and grinding noise when I let off the accelerator. There’s specifically fluid leaking from rear axle in the center where the drive shaft meets the heavy duty Dana M300 axle. And all over the inside rear passenger tire. There’s a burnt gear oil smell coming from the truck as a result and the truck can’t be driven .

  • Filed Aug 2026

    Wife was driving the truck(I was the passenger) while towing our dump trailer. After approx 100 miles into this trip the dash showed a "Reduced Engine Power Warning", and then shuddered. That was immediately followed by a "Service Engine Soon" warning on the dash, and the truck shut down as we were pulling to the shoulder. I smelled diesel fuel as we slowed to a stop. I got out and saw some smoke coming from under the hood. I looked under the truck and saw burning material falling from underneath, I shouted fire, and my wife exited while I retrieved our dog from the back seat. The cab was filling with smoke. Wife called [XXX] while I retrieved a few more small items from back seat. We stepped back and the truck was fully engulfed in flames in a few minutes. Fire crews were on scene after several more minutes, and by that time the truck was burnt to the ground. This truck was in excellent condition with no prior running issues or warnings of mechanical problems. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

  • Filed Aug 2026

    The contact owns a 2019 Ford F-350 SD. The contact stated that while driving at an undisclosed speed, the contact became aware that the transmission was slipping. No warning lights were illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed with torque converter failure. The contact was informed that the transmission needed to be replaced. The vehicle was in the process of being repaired. The contact referenced an unknown recall; however, the VIN was not associated with a recall associated with the failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 130,000.

  • Filed Aug 2026

    The contact owns a 2019 Ford F-350 SD. The contact stated that while the vehicle was parked, her husband attempted to turn the key in the ignition, but the vehicle failed to operate as intended. The messages "Service Advanced Trac", "Oil Change Required", and "Hill Start Assist" were displayed. The ABS and check engine warning lights were illuminated. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 71,000.

  • Filed Feb 2025

    The contact owns a 2019 Ford F-350. The contact stated while the vehicle was in the automatic car wash, water entered the vehicle from the front windshield. The water leaked into the fuse box and short-circuited the fuse box. The vehicle was towed to the dealer where it was determined that the seal around the windshield needed to be resealed and the fuse box replaced. The vehicle was repaired. The contact stated that on a separate occasion while driving 70 MPH, the vehicle abruptly came to a complete stop. No warning lights were illuminated. The vehicle was towed to the dealer, who diagnosed and determined that the transmission had failed. The vehicle was repaired, but the failure reoccurred 2 additional times. The dealer diagnosed that the clutch plate failed and gear 1 and gear 2 were heat-welded together. The vehicle was not repaired and remained at the dealer. The manufacturer was notified of the failure. The failure mileage was approximately 30,000.

  • Showing the 5 most recent of 13.
• Fuel System10

  2 involved a fire

  • Filed Jul 2026

    The contact called on behalf of a Federal Agency that owned a 2019 Ford F-350. The contact stated that while driving 55 MPH, the check engine warning light illuminated, and the message "Reduce Power Mode" was displayed. The driver pulled over to the side of the road, and the vehicle shut off. The driver became aware of smoke coming from underneath the hood of the vehicle. The driver opened the hood and became aware that the engine compartment was engulfed in flames. The driver attempted to extinguish the fire with fire extinguishers; however, the fire persisted, and the vehicle was completely burned. The fire was extinguished by the Fire Department. The contact believed that a Fire Department report was filed. A Police report was filed. No injuries were sustained. There was no property damage. The vehicle was towed to a tow yard and was deemed a total loss. The contact related the failure to NHTSA Action Number: PE24014 (Fuel System, Diesel, Fuel System, Other). The manufacturer was notified of the failure. The failure mileage was approximately 120,000.

  • Filed Jul 2026

    The contact called on behalf of a Federal Agency that owned a 2019 Ford F-350. The contact stated that while driving 55 MPH, the check engine warning light illuminated, and the message "Reduce Power Mode" was displayed. The driver pulled over to the side of the road, and the vehicle shut off. The driver became aware of smoke coming from underneath the hood of the vehicle. The driver opened the hood and became aware that the engine compartment was engulfed in flames. The driver attempted to extinguish the fire with fire extinguishers; however, the fire persisted, and the vehicle was completely burned. The fire was extinguished by the Fire Department. The contact believed that a Fire Department report was filed. A Police report was filed. No injuries were sustained. There was no property damage. The vehicle was towed to a tow yard and was deemed a total loss. The contact related the failure to NHTSA Action Number: PE24014 (Fuel System, Diesel, Fuel System, Other). The manufacturer was notified of the failure. The failure mileage was approximately 120,000.

  • Filed Sep 2025

    The contact owns a 2019 Ford F-350. The contact stated that while driving at an undisclosed speed, the check engine warning light was illuminated. The contact stated that after the vehicle was parked and turned off, there was fuel leaking from the engine compartment. The contact became aware that the fuel line was inoperable, causing fuel to leak onto the engine and the exhaust system. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 44,000.

  • Filed Jun 2025

    The contact owns a 2019 Ford F-350. The contact stated that the vehicle was taken to the dealer to be inspected; however, the dealer refused to inspect the vehicle. The contact related the issue to NHTSA Campaign Number: 24V957000 (Fuel System, Diesel); however, neither the VIN nor the model year vehicle was included in the recall. No warning lights were illuminated. The manufacturer was made aware of the issue and referred the contact the NHTSA Hotline for assistance. The vehicle was not inspected or repaired. The contact had not experienced a failure. VIN tool showed no open recall.

  • Filed Mar 2025

    The contact owns a 2019 Ford F-350. The contact stated that while driving at 70 MPH, the vehicle lost motive power. The low fuel pressure warning light was illuminated. The vehicle was started. The vehicle was driven to the shoulder of the roadway. The vehicle was taken to the dealer; however, the failure was not duplicated. The contact stated that the vehicle had been to the dealer several times for the failure. In addition, the low-pressure fuel pump was replaced in 2024; however, the failure reoccurred. In addition, the contact stated that the vehicle was taken to the dealer more than fourteen times regarding the failure. The contact stated that the failure occurred while the vehicle was driven above 50 MPH. The manufacturer was made aware of the failure, and a case was filed. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 154,000.

  • Showing the 5 most recent of 10.
• Service Brakes9

  • Filed Feb 2025

    Brake lights stay on won’t go off. Replaced brake module, fuse etc. Can put key in and turn to accessories and put gear selector in drive,neutral, reverse WITHOUT PUTTING FOOT ON BRAKE PEDAL… CANNOT FIGURE THIS PROBLEM OUT…

  • Filed Jun 2024

    When you drive this truck for extended periods of time the entire instrument cluster shuts off loosing blinkers lights and any indication of speed, among that if you're towing a trailer the trailer lights shut off, ford has tried fixing it under warranty to no avail, now the truck is out of warranty and the issue is getting worse and they're not sure what's wrong. I also have videos of this issue

  • Filed Apr 2023

    The trailer brake controller randomly says trailer disconnected and will not apply the trailer brakes, but you can manually operate the brakes from the controller and they work fine, I have replaced every thing on the trailer brakes,wires,7pin plug, and I keep getting the same fault randomly( trailer disconnected). Ford tells me the unit is fine, Well it is not, I have pulled the trailer with a chevy and a dodge and the brakes work as they should. It happens everything I use it and after doing a Google search, seems there many others with the same problem

  • Filed Oct 2022

    On 4 separate occasions while driving my truck under 60 mph, the truck started shaking violently. The steering froze and the complete chassis, frame and body shook and felt like it was falling apart. It only subsided when I decelerated below 30 mph.

  • Filed Oct 2022

    The contact owns a 2019 Ford F-350. The contact stated that while driving at an undisclosed speed and hauling a trailer, the brake pedal was depressed with the "Wiring Fault on Trailer" message displayed. The contact pressed a button on the steering wheel and cleared the message. The vehicle was taken to the dealer; however, the dealer was unable to duplicate the failure. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The manufacturer advised the contact to take the vehicle to the dealer for service. The failure mileage was approximately 6,000.

  • Showing the 5 most recent of 9.
• Visibility/Wiper8

  • Filed Sep 2025

    Rear window shattered when rear window defrost was activated.

  • Filed Aug 2025

    My back up camera is not working.

  • Filed Dec 2024

    The contact owns a 2019 Ford F-350. The contact stated while driving at an undisclosed speed, the contact noticed that the windshield wipers became inoperable. The contact stated that when the windshield wipers were engaged, the contact could not shut off the windshield wipers. The contact had to turn off the vehicle to stop the windshield wipers. The contact restarted the vehicle, and the failure persisted. The contact also stated that the exterior lights were inoperable. The contact stated that the exterior lights were turning off and on while driving. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The approximate failure mileage was 74,000.

  • Filed Nov 2023

    The back up camera will display a blue screen when truck is in reverse. This is a full size truck and I am unable to see behind me when trying to backup. There have been recalls on this issue with ford but apparently my truck is not one of them.

  • Filed Feb 2023

    There is currently a recall for the rear camera on this truck that Ford has yet to repair because they say they don't have the replacement parts. This truck has the 360 view package. There are cameras all around this truck and they all are getting cloudy to the point it's hard to see from any of them, not just the rear view camera. Ford is refusing to replace the other cameras under any kind of warranty/recall. I think that it's a matter of safety to replace all the cameras because they are all either unusable or nearly unusable. I use all the camreas alot because this is a big truck and there are alot of blind spots.

  • Showing the 5 most recent of 8.
• Latches/Locks/Linkages8

  • Filed Feb 2025

    The contact owns a 2019 Ford F-350. The contact stated that the driver's side front door latch failed to lock and securely close the door. The contact stated that the failure only occurred during cold weather. The failure had occurred 4 times. The vehicle was taken to the dealer to be diagnosed; however, the cause of the failure was not yet determined. The vehicle was not repaired. The contact was informed that there was an undisclosed Customer Satisfaction Program for the door latch freezing and the door lock actuator failing to operate as designed; however, the contact was not provided the CSP number. The manufacturer was made aware of the failure and opened a case. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 82,000.

  • Filed Jan 2025

    The contact owns a 2019 Ford F-350. The contact stated while driving or while the vehicle was parked, the doors would freeze in cold weather and failed to latch securely. The vehicle was not taken to a dealer or independent mechanic to be diagnosed or repaired. The manufacturer was notified of the failure but offered no assistance. The contact was referred to the NHTSA Hotline for assistance. The contact related the failure to Customer Satisfaction Program: 19N06 (Door Latch Freezing Concerns). The failure mileage was 91,620.

  • Filed Mar 2022

    The contact owns a 2019 Ford F-350. The vehicle had previously been serviced under the Manufacturer Campaign Number: 19S48. The contact stated that while hauling a trailer, there was an abnormal sound coming from the vehicle, and the contact noticed that the tailgate had unexpectedly opened. The vehicle was taken to the dealer. The dealer took pictures of the vehicle and forwarded them to the manufacturer. The vehicle was not repaired. The manufacturer was made aware of the failure but declined the tailgate replacement since the damage happened after the recall was repaired. The failure mileage was approximately 42,000.

  • Filed Apr 2021

    THE TAILGATE WILL OPEN UP WHEN BACKUP UP IN TRUCK - THERE IS RECALL BUT THE RECALL DOES NOT FIX THE ISSUE. I HAVE THE RECALL WORK COMPLETED BY FORD DEALER BUT IT STILL OPENS UP WHEN BACKUP WITH TRAILER ATTACHED. THIS HAS HAPPEN 3 TIMES SINCE WARRANTY REPAIR. FORD DID NOT FOX THIS PROBLEM AND THEY WILL NOT ACKOWLEDGE IT.

  • Filed Feb 2021

    THE TAILGATE ON MY FORD F350 WAS REPAIRED LAST YEAR FROM THE RECALL PERTAINING TO THE TAILGATE OPENING ON ITS OWN. THE TAILGATE OPENED ON ITS OWN AGAIN TODAY. 02/26/2021. THE FIRST TIME IT HAPPENED I WAS TURNING RIGHT FROM A MAIN CITY STREET ONTO A SIDE STREET GOING ABOUT 10 MPH. TODAY I WAS GOING ABOUT 5 MPH AND TURNED LEFT INTO A PARKING LOT.

  • Showing the 5 most recent of 8.
• Diesel6

  1 involved a fire

  • Filed Jul 2026

    The contact called on behalf of a Federal Agency that owned a 2019 Ford F-350. The contact stated that while driving 55 MPH, the check engine warning light illuminated, and the message "Reduce Power Mode" was displayed. The driver pulled over to the side of the road, and the vehicle shut off. The driver became aware of smoke coming from underneath the hood of the vehicle. The driver opened the hood and became aware that the engine compartment was engulfed in flames. The driver attempted to extinguish the fire with fire extinguishers; however, the fire persisted, and the vehicle was completely burned. The fire was extinguished by the Fire Department. The contact believed that a Fire Department report was filed. A Police report was filed. No injuries were sustained. There was no property damage. The vehicle was towed to a tow yard and was deemed a total loss. The contact related the failure to NHTSA Action Number: PE24014 (Fuel System, Diesel, Fuel System, Other). The manufacturer was notified of the failure. The failure mileage was approximately 120,000.

  • Filed Jun 2025

    The contact owns a 2019 Ford F-350. The contact stated that the vehicle was taken to the dealer to be inspected; however, the dealer refused to inspect the vehicle. The contact related the issue to NHTSA Campaign Number: 24V957000 (Fuel System, Diesel); however, neither the VIN nor the model year vehicle was included in the recall. No warning lights were illuminated. The manufacturer was made aware of the issue and referred the contact the NHTSA Hotline for assistance. The vehicle was not inspected or repaired. The contact had not experienced a failure. VIN tool showed no open recall.

  • Filed Mar 2025

    The contact owns a 2019 Ford F-350. The contact stated that while driving at 70 MPH, the vehicle lost motive power. The low fuel pressure warning light was illuminated. The vehicle was started. The vehicle was driven to the shoulder of the roadway. The vehicle was taken to the dealer; however, the failure was not duplicated. The contact stated that the vehicle had been to the dealer several times for the failure. In addition, the low-pressure fuel pump was replaced in 2024; however, the failure reoccurred. In addition, the contact stated that the vehicle was taken to the dealer more than fourteen times regarding the failure. The contact stated that the failure occurred while the vehicle was driven above 50 MPH. The manufacturer was made aware of the failure, and a case was filed. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 154,000.

  • Filed Feb 2025

    The contact owns a 2019 Ford F-350. The contact stated while routine maintenance was being completed on the vehicle by a certified mechanic, the contact was informed that there were metal shavings inside the fuel pump. The mechanic informed the contact that the fuel pump needed to be replaced. The vehicle had not been repaired. The contact searched online and became aware of NHTSA Campaign Number: 24V957000 (Fuel System, Diesel) and related the failure to the recall. The manufacturer was made aware of the failure and confirmed that the VIN was not included in the recall. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 65,788.

  • Filed Sep 2024

    The contact owns a 2019 Ford F-350. The contact stated while driving approximately 45 MPH, the vehicle lost motive power without warning. The contact coasted to the roadside and replaced the fuel filters. The vehicle started but remained idling without the proper RPM. The contact was able to get the vehicle to drive at slower speeds only. The vehicle was taken to the dealer to be diagnosed. The contact was informed that the fuel return line was malfunctioning due to the high-pressure fuel pump failure. The contact was informed that the fuel pump needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure and opened a case. The approximate failure mileage was 58,000.

  • Showing the 5 most recent of 6.
• Exterior Lighting6

  1 involved a crash

  • Filed Feb 2025

    Brake lights stay on won’t go off. Replaced brake module, fuse etc. Can put key in and turn to accessories and put gear selector in drive,neutral, reverse WITHOUT PUTTING FOOT ON BRAKE PEDAL… CANNOT FIGURE THIS PROBLEM OUT…

  • Filed Dec 2024

    The contact owns a 2019 Ford F-350. The contact stated while driving at an undisclosed speed, the contact noticed that the windshield wipers became inoperable. The contact stated that when the windshield wipers were engaged, the contact could not shut off the windshield wipers. The contact had to turn off the vehicle to stop the windshield wipers. The contact restarted the vehicle, and the failure persisted. The contact also stated that the exterior lights were inoperable. The contact stated that the exterior lights were turning off and on while driving. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The approximate failure mileage was 74,000.

  • Filed Jul 2024

    The contact owns a 2019 Ford F-350. The contact stated that the roof seam cover had lifted and detached. Additionally, the contact stated that while raining or washing the vehicle, there was water entering the headlight enclosures and the headlights became inoperable. While the vehicle was in park(P), the interior lights turned on without driver input, and turned off while shifted into reverse(R). There was no notification from Ford Pass. There were no warning lights illuminated. The vehicle was taken to the local dealer, who informed the contact that there were no open recalls but diagnosed the vehicle and determined that the headlight assembly needed to be replaced. The vehicle was repaired, but the failure recurred. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 10,000.

  • Filed Nov 2020

    A FORD TRUCK TAILGATE RECALL HAS SATISFIED FEDERAL SAFETY REGULATORS WHO OPENED AN INVESTIGATION IN OCTOBER 2018 FOLLOWING COMPLAINTS ABOUT ELECTRIC TAILGATES THAT SUDDENLY OPENED.*DT THE INVESTIGATION OPENED BY THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) INCLUDED ELECTRIC TAILGATE PROBLEMS IN 2017-2019 FORD F-250, F-350 AND F-450 SUPER DUTY TRUCKS." THIS RECALL HAS NOT FIXED THIS ISSUE AND THE TAILGATE CONTINUES TO OPEN AND IS A SAFETY ISSUE. WE HAVE ATTEMPTED TO WORK WITH FORD MOTOR COMPANY LEGAL DIVISION FOR COMPENSATION AND A SOLUTION TO THIS BUT THEY WILL NOT COOPERATE. UNTIL NHTSA RECOGNIZE THE RECALL IS A FAILURE, OWNERS WILL CONTINUE TO BE A SAFETY PROBLEM ON OUR HIGHWAYS. WHEN DID THIS HAPPEN? MULTIPLE TIMES! IT HAS BEEN TO 5 DEALERSHIPS TRYING TO RESOLVE THIS RECALL! THE DATE LISTED BELOW IS THE DATE WE PURCHASED OUR TRUCK. UPDATE: VEHICLE HAS BEEN REPAIRED BY A FORD DEALER.*JB

  • Filed Jun 2020

    I?M DRIVING MY 2019 FORD PICKUP AT NIGHT. THE TRUCK IS EQUIPPED WITH AUTO HIGH-BEAMS AND THEY ARE ENABLED IN THE SETTINGS. IT IS NIGHT AND I DON?T WANT MY HIGH-BEAMS ON SO I TOGGLE THEM OFF BY FLIPPING THE TURN INDICATOR HANDLE. A CAR IS APPROACHING FORM THE OPPOSITE DIRECTION ON THE OTHER SIDE OF THE ROAD. AS THE CAR APPROACHES AND PASSES BY ? WHAT SHOULD MY HIGH-BEAMS DO, STAY OFF OR TURN ON? SENSE I TURNED THEM OFF, I WOULD THINK THEY SHOULD SAY OFF BUT THEY DON?T, THEY COME ON. THIS CAN BE FURTHER EXACERBATED IN FOG. WE ALL KNOW THAT DRIVING WITH HIGH-BEAMS IN FOG IS DANGEROUS ? THE DRIVER COULD BE BLINDED BY THE LIGHT REFLECTION OFF THE FOG. THE SAME SCENARIO ABOVE BUT NOW DRIVING IN FOG WITH THE HIGH-BEAMS OFF ? A CAR IS APPROACHING FORM THE OPPOSITE DIRECTION ON THE OTHER SIDE OF THE ROAD AND AFTER PASSING BY AND THE AUTO HIGH-BEAMS TURNS ON AND I BLINDED BY THE REFLECTION - I SWERVE OFF THE ROAD AND HIT A PEDESTRIAN (THAT LAST PART DID NOT HAPPEN, BUT IT COULD). WHO WOULD BE LIABLE IN THIS CASE? MY FORD DEALER SAYS THAT THERE IS NOTHING WRONG WITH MY AUTO HIGH-BEAMS AND THAT IS THE WAY THEY ARE DESIGNED TO OPERATE. I THINK THIS IS A DANGEROUS CONDITION AND MUST BE ADDRESS AND RESOLVED. MY TRUCK HAS BEEN TO THE DEALER TWICE TO FIX THIS ISSUE AND THEY HAVE BEEN UNABLE TO RESOLVE THE ISSUE. THE LAST TIME THE TRUCK WAS IN THE SHOP (2 WEEKS) FORD ADMITTED THAT THERE WAS SOMETHING WRONG AND THAT OTHER OWNERS ARE ALSO EXPERIENCING THIS ISSUE TOO BUT THEY DON?T KNOW HOW TO FIX IT. I WAS TOLD TO TAKE MY TRUCK HOME AND I WOULD BE NOTIFIED WHEN FORD HAD A SOLUTION. THAT WAS OVER 2 WEEKS AGO (JUNE 5TH). DEALER FOR REPAIR IS WILSON MOTORS IN CORVALLIS OR. *TR

  • Showing the 5 most recent of 6.
• Vehicle Speed Control5

  • Filed Jul 2023

    We are trying to make it out of the mountains of Colorado and back home to Missouri. We have the most horrific shaking on our truck. I am scared to death. This "death wobble" is TERRIBLE! I want someone to know now in case we die! We have a horse trailer loaded down with 4 horses and 2 dogs. There should be a recall for this!!!! Signed [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

  • Filed Apr 2023

    08 Apr 2023 vehicle hit a pot hole and we almost went into ditch when it began to wobble uncontrollably. We were traveling on the hwy and almost caused an accident to the vehicles behind us. Very frightening. 16 Apr 2023, hit a small pot hole vehicle began to wobble uncontrollably, took us again almost into the ditch. It occurred four more times trying to get home from airport. We scared traveling in this vehicle now because of these incidents. We are filing an official complaint on Ford.

  • Filed May 2021

    ON TWO OCCASIONS THE TRUCK HAS GOTTEN THE SHAKES AND IT'S HARD TO CONTROL ON THE ROAD. STEERING WHEEL VIBRATES BAD TOO. WAS GOING ABOUT 50 MPH EACH TIME. ONCE DOWN THE HIGHWAY IN A CONSTRUCTION AREA AND THE OTHER TIME DOWN A COUNTY ROAD. I BELIEVE IT HAS A 'DEATH WOBBLE'

  • Filed Oct 2019

    1ST INCIDENT-DRIVING ON THE HIGHWAY THE TRUCK STARTED VIOLENTLY SHAKING AFTER HITTING A SMALL RISE GOING OVER AN OVERPASS. EXTREMELY BLESSED THAT I WAS IN AN EXPRESS LANE (TOLLED) AND NO ONE WAS AROUND ME. 16FT TRAILER WAS HOOKED UP AND IT TOOK EVERY BIT OF STRENGTH I HAD TO KEEP THE TRUCK IN THE 2 LANES AND NOT THE WALL. THANKFUL NO OTHER VEHICLES WERE AROUND ME. 2ND INCIDENT- AGAIN DRIVING ON THE HIGHWAY THE NEXT DAY; A VERY SMALL BUMP IN THE ROAD CAUSED THE VIOLENT SHAKING. I WAS NOT TOWING, BUT I DID HAVE VEHICLES AROUND ME THIS TIME THAT THANKFULLY WERE PAYING ATTENTION AS I WAS IN AND OUT OF THE FAST AND MIDDLE LANE. THE EXPERIENCE IS INDESCRIBABLE AND FRIGHTENING.

  • Filed Apr 2019

    WHILE PARKING, FOOT ON BRAKE, ENGINE INCREASED RPM TO VERY HIGH LEVEL. 2019 TRUCK WITH 41 MILES, VEHICLE WAS STATIONARY.

• Air Bags4

  2 involved a crash

  • Filed Oct 2024

    Drivers airbag cover is cracked/splitting, seems to be following the release seam of airbag. I am worried that it will continue, or the airbag will malfunction. Took truck to local FORD dealer and was told that this issue was not covered under my warranty nor restraint system warranty. No warnings, no messages prior.

  • Filed Sep 2022

    The air bag light came on

  • Filed Nov 2020

    TL* THE CONTACT OWNS A 2019 FORD F-350. THE CONTACT STATED THAT WHILE MAKING A TURN INTO A PARKING LOT, ANOTHER VEHICLE THAT WAS SPEEDING AT 45 MPH, CRASHED INTO THE PASSENGER SIDE. THE CONTACT MENTIONED THE IMPACT WAS FORCEFUL AND THAT THE OTHER VEHICLE HAD ALL ITS AIR BAGS DEPLOY. NONE OF THE SIDE AIR BAGS DEPLOYED. BOTH VEHICLES WERE TOWED FROM THE CRASH SCENE. THE CONTACT AND THE OTHER DRIVER WERE TRANSPORTED BY AMBULANCE TO THE HOSPITAL. THE CONTACT HAD PAINS ON THE LEFT SIDE OF HIS NECK AND ON HIS LOWER BACK. THE CONTACT'S SHOULDER HIT THE SIDE WINDOW AND WAS ALSO SORE. A POLICE REPORT WAS FILED. THE ENTIRE CAB OF THE TRUCK WAS PUSHED TO THE DRIVER'S SIDE WITH THE SUPPORTS SNAPPING THE PASSENGER SIDE DOOR AND THE CAB CORNER WERE SMASHED IN. THE INSURANCE COMPANY WAS STILL DETERMINING IF THE VEHICLE WOULD BE TOTALED. THE MANUFACTURER TOLD THE CONTACT TO CALL THE LOCAL DEALER TO SEE WHY THE AIRBAGS DID NOT DEPLOY. THE DEALER (PLACE MOTOR INC 193 THOMPSON RD, WEBSTER, MA 01570 (508) 943-8012) SENT THE CONTACT TO THE AUTO BODY SHOP WITH THE INSURANCE COMPANY. THE FAILURE MILEAGE WAS 58,000.

  • Filed Jul 2019

    TL* THE CONTACT OWNED A 2019 FORD F-350 SD. THE CONTACT STATED THAT WHILE DRIVING AT 55 MPH, THE CONTACT FELL ASLEEP BEHIND THE WHEEL CAUSING THE VEHICLE TO HIT A CURB, WENT OVER A HILL AND INTO THE GROUND, CAUSING THE VEHICLE TO ROLL OVER 2 TIMES. NO AIRS BAGS DEPLOYED. THE PASSENGER SUSTAINED A FRACTURED RIGHT FOOT, BRUISED SHOULDERS AND PELVIC BONE. THE CONTACT SUSTAINED MINOR INJURIES TO HIS CHEST. THERE WAS A POLICE REPORT FILED. THE PASSENGER WAS TAKEN TO ST. JAMES MEDICAL CENTER WHERE SHE WAS TRANSFERRED TO MANKATO CLINIC WICKERSHAM HEALTH CAMPUS CLINIC HEALTH SYSTEM WHERE THEY ARE CURRENTLY UNDER MEDICAL CARE. THE VEHICLE WAS TOWED BY THE POLICE TO A LOT WHERE THE DAMAGES WERE UNKNOWN. THE FAILURE MILEAGE WAS 5,000. *BF CONSUMER STATED BLACK BOX ONLY RECORDS 3 INCIDENTS AND STARTS AGAIN.*JB

• Other3

  1 involved a fire

  • Filed Jul 2026

    The contact called on behalf of a Federal Agency that owned a 2019 Ford F-350. The contact stated that while driving 55 MPH, the check engine warning light illuminated, and the message "Reduce Power Mode" was displayed. The driver pulled over to the side of the road, and the vehicle shut off. The driver became aware of smoke coming from underneath the hood of the vehicle. The driver opened the hood and became aware that the engine compartment was engulfed in flames. The driver attempted to extinguish the fire with fire extinguishers; however, the fire persisted, and the vehicle was completely burned. The fire was extinguished by the Fire Department. The contact believed that a Fire Department report was filed. A Police report was filed. No injuries were sustained. There was no property damage. The vehicle was towed to a tow yard and was deemed a total loss. The contact related the failure to NHTSA Action Number: PE24014 (Fuel System, Diesel, Fuel System, Other). The manufacturer was notified of the failure. The failure mileage was approximately 120,000.

  • Filed Mar 2025

    The fuel filter housing cracked and started pouring diesel out the top and back of the engine. No warning lights going to dealer for replacement. This can be very dangerous for vehicle occupants and another motorist.

  • Filed Jul 2024

    The contact owns a 2019 Ford F-350. The contact stated while driving at an undisclosed speed, the reduced engine power and check engine warning lights illuminated. The vehicle lost motive power. In addition, the contact noticed white smoke and diesel odor entering the interior of the vehicle. The contact parked the vehicle and noticed diesel fluid pouring out onto the ground. The vehicle was towed to an independent mechanic where it was diagnosed with a cracked fuel filter. The contact was informed that the fuel filter needed to be replaced. The vehicle was repaired. The contact stated that the vehicle was previously serviced by an independent mechanic and the fuel filter was replaced several days before the failure reoccurred. The contact stated that the new fuel filter had only 600 miles before the failure occurred. The manufacturer was not made aware of the failure. The failure mileage was approximately 48,000.

• Lane Departure3

  • Filed Apr 2026

    A steering control module in my steering wheel failed which makes the lane keeping warning not operate correctly and the steering wheel not straight it's set at an angle to the right so when you're driving down the road you have to have it constantly turn to the right a little bit in order to go straight down the road in order to fix it you have to replace the entire steering wheel which is about 3,400 or so.

  • Filed Apr 2023

    Safety Recall Notice 22S51 / NHTSA Recall 22V644 We were notified on September 2022 of this recall after noticing our rear camera was defective. As of April 23, 2023, the manufacturer has failed to remedy this safety recall. Ford is saying the remedy (rear view camera parts) are not available. I am asking that the NHTSA engage with Ford to expedite resolution of this recall.

  • Filed Feb 2023

    There is currently a recall for the rear camera on this truck that Ford has yet to repair because they say they don't have the replacement parts. This truck has the 360 view package. There are cameras all around this truck and they all are getting cloudy to the point it's hard to see from any of them, not just the rear view camera. Ford is refusing to replace the other cameras under any kind of warranty/recall. I think that it's a matter of safety to replace all the cameras because they are all either unusable or nearly unusable. I use all the camreas alot because this is a big truck and there are alot of blind spots.

• Electronic Stability Control (esc)3

  • Filed Oct 2020

    VEHICLE STARTED SHAKING VIOLENTLY WHEN I WAS DRIVING ON THE HIGHWAY WITH 60 MPH, I LOST CONTROL. LUCKILY THERE WAS NO CAR NEXT TO MINE BUT IF THERE WAS I WOULD HAVE CRASHED. I CAN NOT TRUST THIS TRUCK ANY LONGER. I AM TERRIFIED TO DRIVE.

  • Filed Jul 2020

    WHILE TRAVELING OVER BUMPS EXCESSIVE VIBRATION IN STEERING AND IN CAB. EVEN AFTER STEERING DAMPENER WAS FIXED.

  • Filed Dec 2019

    THERE IS AN ISSUE WITH FORD TRUCKS THAT IS COMMONLY REFERRED TO AS THE DEATH WOBBLE. MY TRUCK HAS LESS THAN 30,000 MILES AND HAS BEEN IN THREE TIMES FOR THIS ISSUE. ONCE FORD CORRECTED THE ISSUE AND IT CAME BACK. WHEN IT CAME BACK WAS TOLD THERE ARE UPDATED PARTS HAVE BEEN WAITING FOR WELL OVER A MONTH WITH NO FEEDBACK FROM FORD. REACHED OUT YET AGAIN TO THEM AND WAS TOLD THAT I WOULD BE ESCALATED. MY CONCERN IS THAT THIS SAFETY ISSUE SHOULD HAVE ACTIVE MANAGEMENT AND COMMUNICATION FROM FORD AND IT DOES NOT. PEOPLE ARE TOLD THEY HAVE TO WAIT WITH NO UPDATE. NOW IT APPEARS I HAVE BEEN ESCALATED (WE SHALL SEE) BUT I AM CONCERNED FOR OTHERS THAT MAY NOT BE AWARE OF WHAT TO DO IN ORDER TO GET THIS ADDRESSED. CAN YOU REACH OUT TO FORD AND SEE HOW/WHAT THEIR PLAN IS TO COMMUNICATE AND SUPPORT IMPACTED PARTIES? ISSUE OCCURS WHEN DRIVING ANYTHING OVER 45 MPH AND TO RESOLVE YOU MUST SLOW TO BELOW 25 MPH. THINK OF THIS OCCURRING WHEN ON HIGHWAY AND HAVING LIMITED CONTROL OF A 1 TON TRUCK. ISSUE OCCURS AT RANDOM TIMES SO THERE IS NO WAY TO AVOID IT. OCCURRED MANY TIMES FIRST TIME WAS BACK IN EARLY 2019

• Engine And Engine Cooling2

  1 involved a fire

  • Filed Jul 2026

    The contact called on behalf of a Federal Agency that owned a 2019 Ford F-350. The contact stated that while driving 55 MPH, the check engine warning light illuminated, and the message "Reduce Power Mode" was displayed. The driver pulled over to the side of the road, and the vehicle shut off. The driver became aware of smoke coming from underneath the hood of the vehicle. The driver opened the hood and became aware that the engine compartment was engulfed in flames. The driver attempted to extinguish the fire with fire extinguishers; however, the fire persisted, and the vehicle was completely burned. The fire was extinguished by the Fire Department. The contact believed that a Fire Department report was filed. A Police report was filed. No injuries were sustained. There was no property damage. The vehicle was towed to a tow yard and was deemed a total loss. The contact related the failure to NHTSA Action Number: PE24014 (Fuel System, Diesel, Fuel System, Other). The manufacturer was notified of the failure. The failure mileage was approximately 120,000.

  • Filed Jun 2024

    The contact owns a 2019 Ford F-350. The contact stated while driving approximately 35 MPH, there was an abnormal clanking sound coming from the engine compartment. The vehicle was towed to the local dealer who diagnosed that the engine and turbocharger had failed and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 87,000.

• Tires2

  • Filed Aug 2024

    The contact owns a 2019 Ford F-350. The contact stated that while the vehicle was parked, it was discovered that the air pressure in all four tires were consistently decreasing; the contact also noticed corrosion around the rims and valve stems on each wheel. The low tire pressure warning light was illuminated. The vehicle was driven to a dealer but not diagnosed; however, the contact was informed that the dealer would replace the current tires with new tires to monitor the failure. The vehicle was repaired; however, the failure reoccurred. The contact was constantly adding air to the tires before driving the vehicle. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 25,000.

  • Filed Jul 2021

    The tires have 40000 miles on them. They are the factory tires and the tread came off as I was driving and done damage to the truck not sure of exact amount will be getting estimates tomorrow . It was the driver side front I have pictures of tire and damage and also of the other 3 tires and still have the tire that failed

• Gasoline1

  • Filed Sep 2025

    The contact owns a 2019 Ford F-350. The contact stated that while driving at an undisclosed speed, the check engine warning light was illuminated. The contact stated that after the vehicle was parked and turned off, there was fuel leaking from the engine compartment. The contact became aware that the fuel line was inoperable, causing fuel to leak onto the engine and the exhaust system. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 44,000.

• Firerelated1

  1 involved a fire

  • Filed Nov 2024

    The contact owned a 2019 Ford F-350 hauling a small trailer with 2 horses. The contact stated that while driving at approximately 60 mph, another driver waved him down and informed him there was a fire from the front of the vehicle. The contact merged to the side of the road, parked, and exited immediately. The contact attempted to open the hood but was unsuccessful in doing so as the hood had become too hot to touch from the fire brewing inside. The contacts stated that he and his wife who was the front passenger occupant were able to unload their horses from the trailer just in time, as the entire truck engulfed in flames all within ten minutes. The origin of the fire was undetermined. No injuries were sustained. The location of the fire was the front of the vehicle. The fire department arrived to extinguish the fire. A fire department report was filed. A police department report was filed. The vehicle was destroyed. The remains of the vehicle were towed to a local towing company's lot. The local dealer was contacted. The manufacturer was not notified of the failure. The approximate failure mileage was 19,000.

• Tether1

  • Filed Jan 2024

    The contact owns a 2019 Ford F-350. The contact stated while attaching a Graco Safety First with the latch system, the contact became aware that the vehicle was not equipped with the lower latch for the latch system. The contact had taken the vehicle to a local dealer and was advised that the latching system was not part of the vehicle design and was not offered on any similar model vehicles. The contact stated that the issue was a safety-related failure by the manufacturer. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was 26,987

• Lower Anchor (on Car Seat or Vehicle)1

  • Filed Jan 2024

    The contact owns a 2019 Ford F-350. The contact stated while attaching a Graco Safety First with the latch system, the contact became aware that the vehicle was not equipped with the lower latch for the latch system. The contact had taken the vehicle to a local dealer and was advised that the latching system was not part of the vehicle design and was not offered on any similar model vehicles. The contact stated that the issue was a safety-related failure by the manufacturer. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was 26,987

• Hydraulic1

  • Filed Oct 2022

    The contact owns a 2019 Ford F-350. The contact stated that while driving at an undisclosed speed and hauling a trailer, the brake pedal was depressed with the "Wiring Fault on Trailer" message displayed. The contact pressed a button on the steering wheel and cleared the message. The vehicle was taken to the dealer; however, the dealer was unable to duplicate the failure. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The manufacturer advised the contact to take the vehicle to the dealer for service. The failure mileage was approximately 6,000.

• Seat Belts1

  • Filed Jan 2022

    Seat belt locks and will not allow movement while driving causing the driver to be pinned against the seat under normal driving conditions.

• Visibility1

  • Filed Jul 2020

    SUNROOF EXPLODED WHILE ON HIGHWAY IN MOTION

Safety ratings

NHTSA 5-Star Safety Ratings from government crash tests. Ratings can differ by cab style and 2WD/4WD.

NHTSA hasn't published star ratings for this truck. Many heavy-duty pickups aren't included in NHTSA's crash-test program, so this doesn't mean the truck is unsafe.