2023 Chevrolet Silverado 2500HD

What owners should know

Covers 2020–2026 · 6.6L Duramax L5P diesel and 6.6L V8 gas · Updated 2026-10-01

Researched from owner forums and NHTSA complaints and written by Know Your Truck. These are patterns in what owners report, not a guarantee about any particular truck.

Common failures & how to fix them

Parts and video buttons search for your 2023 Chevrolet Silverado 2500HD. Always confirm a part fits using your VIN. Brakes, steering, fuel and airbag work affects your safety, so if you're not sure, have a qualified mechanic do it.

• 10-speed transmission valve body failure

  Dealer (recall)

  Signs: Sudden hard downshifts, limp mode, or rear wheel lock-up on diesels.

  Fix: Covered by GM recalls on 2020–2022 diesels. Other repairs are usually under warranty on newer trucks. Ask a dealer for all open recalls and bulletins.

  May be covered free by recall 24V797000 / 26V083000. Check the VIN at nhtsa.gov/recalls.

• Trailer brake controller warnings

  Easy DIY

  Signs: 'Check trailer wiring' or 'Trailer brakes disconnected' messages that cut the trailer brakes.

  Fix: Clean and inspect the 7-pin trailer connector and the trailer's wiring first. If it continues, have a dealer check for bulletins and module updates.

  Shop: 7 pin trailer connector▶ How-to videos

• Power tailgate opens unexpectedly

  Dealer (recall)

  Signs: The tailgate unlatches by itself, often after water gets in.

  Fix: Covered by GM recalls on 2020–2024 trucks with power-unlatching tailgates.

  May be covered free by recall 24V060000 / 24V894000. Check the VIN at nhtsa.gov/recalls.

• Steering gear shaft can break (2024)

  Dealer (recall)

  Signs: Loose steering or a clunk. In rare cases loss of steering.

  Fix: Covered by a GM recall on some 2024 trucks.

  May be covered free by recall 23V549000. Check the VIN at nhtsa.gov/recalls.

Recalls

A recall doesn't mean a truck still has the problem. Enter the truck's VIN at nhtsa.gov/recalls or ask a dealer to see whether the repair was done.

• Latches/Locks/Linkages:Tailgate:Latch

  Feb 2024 · #24V060000

  General Motors, LLC (GM) is recalling certain 2020-2024 Chevrolet Silverado 2500, 3500, GMC Sierra 2500 and 3500 vehicles equipped with power-unlatching tailgates. The tailgate's electronic gate-release switch may short circuit due to water intrusion, which can result in the tailgate inadvertently unlatching while the vehicle is in park.

  Risk and fix

  Risk: An unlatched tailgate may open while driving and result in a loss of unsecured cargo, creating a road hazard and increasing the risk of a crash.

  Fix: Owners are advised to check that the tailgate is closed and latched before driving. Dealers will replace the exterior touchpad switch assemblies, free of charge. Owner notification letters were mailed May 17, 2024. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is N232426400.

Owner complaints by area

Reports owners filed with NHTSA. They aren't verified, and one complaint can mention more than one area. Tap an area to read the most recent ones.

• Power Train17

  1 involved a fire

  • Filed Jul 2026

    The contact owns a 2023 Chevrolet Silverado 2500. The contact stated that while driving at various speeds, the transmission was slipping. No warning light was illuminated. The vehicle was taken to the dealer, where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was repaired; however, the failure recurred days later. The vehicle was taken back to the dealer, where it was lifted and inspected, and the contact was informed that no failure was found. The contact stated that the failure persisted. The vehicle was not repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 105,000.

  • Filed Jul 2026

    The contact owns a 2023 Chevrolet Silverado 2500. The contact stated that while driving at various speeds, the transmission was slipping. Additionally, the contact stated that while driving 60-70 MPH, the vehicle stalled. No warning light was illuminated. The contact pulled over to the side of the road. Upon inspection, the contact became aware of a coolant leak underneath the vehicle. The vehicle was towed to the dealer, where it was diagnosed that the turbo coolant inlet had fractured. The part was replaced. Additionally, the dealer determined that the transmission was in working order upon inspection; however, the failure persisted. The vehicle was not repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 83,000.

  • Filed Jun 2026

    Was driving east on i40 between Hinton and calumet when my truck through a check engine light and service parking break. I pulled over it smelt like burning wires I cleared the codes with a code reader and turn the truck on the accessory when smoke filled the cab I got out and the truck was in flames.

  • Filed Mar 2026

    When putting vehicle in park, I get a message on dash that says "shift to park" when the vehicle is already in park. The vehicle electrical components does not turn off. Sometimes if I wiggle/hit or stick my hand under the steering wheel adjustment lever I can get it to turn off. Becoming more troublesome. Through research I see it is a common issue among GM/Chevy vehicles.

  • Filed Feb 2026

    Will pulling camper, truck lurched with hard shift at around 35mph and caused a sudden slow down in traffic. Truck then went into limp mode with engine light illuminated. Pulled over to turn vehicle off and restart. Attempted to gain speed again and similar lurch with hard shift at around 35-40mph. Vehicle again in reduced power mode. Was able to ease truck to dealer where code reader showed P0700 and P0747. This was similar to issue found in recall for model years 2020-2022 with GM 10L1000 transmissions. There has been a technical service bulletin issue by GM regarding models years 21-25 but no recall. Dealer has ordered parts for TSB but repair not performed yet.

  • Showing the 5 most recent of 17.
• Electrical System16

  2 involved a fire

  • Filed Sep 2026

    The stereo screen face failed, with warning signs in foreign languages. An inspection was completed and it was confirmed that the module behind the screen attempted to update and burned out. When this system update failed it continued to run power resulting in a dead battery. luckily there was another vehicle around to jump start the vehicle but if someone is out of cell service or doesn't have a jump box serious issues can arise. There are many cases of this happening online with other GMC products. A dealership has confirmed the module burned out. A claim has been filled with GM customer service but no investigations have occurred. Nothing came up until after the battery died and the screen failed after the vehicle was jumped.

  • Filed Jun 2026

    Was driving east on i40 between Hinton and calumet when my truck through a check engine light and service parking break. I pulled over it smelt like burning wires I cleared the codes with a code reader and turn the truck on the accessory when smoke filled the cab I got out and the truck was in flames.

  • Filed May 2026

    Truck will not release the key consistently upon shutting down the truck. The interlock will not allow it to turn fully off and pull out despite being placed in park.

  • Filed Apr 2026

    The entire infotainment system has gone black. Nothing shows on the screen. This is a safety issue as it does not show blind spot monitoring, heads up display, lane change warnings, allow hands free calling, gps, and much more. None of the safety features are available with a trailer hookup as well. We have taken it to a certified Chevrolet dealer who has said the truck was the 6th one that they have placed an order for in just over a week. The infotainment system is currently on back order which makes operating the vehicle concerning with its proper safety features.

  • Filed Apr 2026

    Switch fails in shifter assembly that is supposed to sense the vehicle is in park. Does not allow the key to be removed. Dealership explained that complete failure may cause the vehicle to actually get stuck in drive. Very common problem that typically occurs just outside of bumper to bumper warranty. Related to a cheap microswitch but requires $1000 full replacement of the shifter assembly.

  • Showing the 5 most recent of 16.
• Unknown or Other8

  • Filed Sep 2026

    I recently discovered that Tasca Buick GMC Palm Harbor (located at [XXX]) submitted official paperwork stating they completed a safety recall. However, this work was never performed. My truck was never brought to this dealership, and I have never been to this facility on the date listed in their report Filing a completion record for a safety recall without performing the actual repair is a severe safety hazard and constitutes fraudulent reporting to a federal agency.Desired Resolution:I request that NHTSA investigate Tasca Buick GMC Palm Harbor for fraudulent warranty and recall record filings. I also request that the recall status for my vehicle be reset to "Incomplete" in the national database so I can take it to a trustworthy dealer to get the actual safety repair performed NHTSA Campaign 24V-060 / GM Recall N232426400 (Power-Unlatching Tailgate Switch Replacement) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

  • Filed Aug 2026

    I am filing this complaint regarding my 2023 Chevrolet Silverado 2500HD, which has approximately 20,000 miles and has been babied since new. The truck is maintained meticulously and the undercarriage is washed weekly. The brake failures I have experienced are completely unacceptable for a truck with this mileage and maintenance history. Both the FRONT and REAR brake friction material has completely DELAMINATED from the brake components. This is not normal brake wear. The material has separated from the underlying metal, which I believe is a serious material/manufacturing-quality issue. The dealer is now reporting that the rear emergency/parking brake shoes are also defective and require replacement. These components are inside the rear rotor and are not visible during a normal inspection. I strongly dispute any suggestion that this is simply corrosion or abuse. This truck is babied, maintained properly, and the undercarriage is washed every week specifically to prevent buildup and corrosion. At only 20,000 miles, having the front brakes, rear brakes, AND parking-brake shoes fail is completely unacceptable. The brake failures are also part of a disturbing pattern of component failures on this truck. The A/C compressor failed, leaving me without reliable air conditioning and resulting in a SIX-WEEK wait for replacement during the middle of summer. Additionally, only FIVE DAYS after I purchased the truck brand new, it required replacement of the Engine Control Module. This is a 2023 truck with only 20,000 miles. I expect normal wear items to wear normally—not to physically delaminate and fail. I am requesting that NHTSA investigate whether there is a systemic safety or manufacturing defect involving the brake materials/components used on these trucks. A brake component physically separating from its backing material is a serious safety concern and should not be dismissed as routine maintenance. GM needs to be held accountable for the quality and safety of this

  • Filed Mar 2026

    My key refuses to come out of the ignition caused by a parking sensor is what Chevy told me. I feel it is a safety hazard because I have to leave my truck idling and take the risk of the truck not registering it’s in park and moving on its.

  • Filed Jan 2026

    I am unable to get the keys out of the ignition when shutting off the truck.

  • Filed Jul 2025

    I was on a two lane driving down the road and getting up to speed. I was still about 45 miles per hour on my way up to 55 mph my vehicle started de rating very fast as I’m driving and then my engine shut off. I had no control over my steering as I made a turn to get off the two-lane road because there was no shoulder. I had to turn the steering wheel really hard and was not able to control the vehicle at all because the engine shut down completely. Everything shut down. I was sticking out in the road. I have no clue yet. What caused it I had to get it towed to a dealership. I just thank God I wasn’t on an interstate but still I was on a two lane and had just topped over a small hill where nobody could see me when they topped the little hill. It could’ve been a very dangerous situation.

  • Showing the 5 most recent of 8.
• Engine7

  • Filed May 2026

    Truck will not release the key consistently upon shutting down the truck. The interlock will not allow it to turn fully off and pull out despite being placed in park.

  • Filed Mar 2026

    GM should be ashamed of themselves not covering the shift to park issue that they have created. This is a known issue and should be recalled. It is impacting thousands of consumers.

  • Filed Jul 2025

    I was on a two lane driving down the road and getting up to speed. I was still about 45 miles per hour on my way up to 55 mph my vehicle started de rating very fast as I’m driving and then my engine shut off. I had no control over my steering as I made a turn to get off the two-lane road because there was no shoulder. I had to turn the steering wheel really hard and was not able to control the vehicle at all because the engine shut down completely. Everything shut down. I was sticking out in the road. I have no clue yet. What caused it I had to get it towed to a dealership. I just thank God I wasn’t on an interstate but still I was on a two lane and had just topped over a small hill where nobody could see me when they topped the little hill. It could’ve been a very dangerous situation.

  • Filed Jul 2025

    Component/System: The Allison 10‑speed (10L1000) transmission valve body catastrophically failed on [XXX], while driving Sunday afternoon down Galveston Seawall Blvd. The truck abruptly dropped from 45 mph into limp mode in heavy traffic, forcing me to pull into the bike lane to avoid being rear‑ended. The vehicle remains at Classic Chevrolet (Galveston, TX) awaiting the OEM valve body—which is on national backorder—and the complete transmission assembly is likewise unavailable. The failed valve body and transmission are available for inspection upon request. Safety Risk: Unexpected limp mode and gear lock‑up in heavy traffic create an immediate risk of rear‑end collisions or side impacts as surrounding drivers have no warning of sudden deceleration or loss of drive. Reproduction/Confirmation: Classic Chevrolet diagnosed and confirmed the failed valve body on May 12, 2025. Their service advisor and my assigned GM Case Agent (#[XXX]) have both acknowledged the defect but report no parts available for repair. Inspections: The vehicle has been inspected by Classic Chevrolet under warranty. GM Customer Care has reviewed my service orders and correspondence. No police or insurance inspections occurred, as no collision ensued—however, the roadside inspection at Classic Chevrolet confirmed the mechanical failure. Warnings/Symptoms: There were no prior warning lamps, messages, or symptoms before the failure. The valve body failure occurred without any advance indication. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

  • Filed Nov 2024

    The contact owns a 2023 Chevrolet Silverado 2500. The contact stated that upon starting the vehicle, the check engine warning light illuminated. The contact restarted the vehicle, but the light failed to turn off. While driving 45 MPH hauling a trailer, the vehicle failed to operate as needed and the transmission was making an abnormal clunking sound. The vehicle then went into SAFE Mode and failed to exceed 35 MPH. The contact stated that the failure was related to NHTSA Campaign Number: 24V797000 (Power Train). The vehicle was taken to the local dealer, where it was diagnosed and determined that the valve body needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and opened a claim for the contact. The failure mileage was approximately 29,000.

  • Showing the 5 most recent of 7.
• Latches/Locks/Linkages4

  • Filed May 2026

    The contact owns a 2023 Chevrolet Silverado 2500. The contact stated that while driving or while parked, the tailgate unintendedly opened on several occasions. The contact related the failure to the tailgate exterior touchpad switch. The dealer and the manufacturer were contacted and informed the contact that the VIN was not included in NHTSA Campaign Number: 24V060000(LATCHES/LOCKS/LINKAGES). The vehicle was not diagnosed or repaired. The failure mileage was approximately 47,000.

  • Filed Apr 2024

    The contact owns a 2023 Chevrolet Silverado 2500. The contact received notification of NHTSA Campaign Number: 24V060000 (Latches/Locks/Linkages) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the tailgate had started detaching from the vehicle. The dealer was contacted, and the vehicle was diagnosed, and it was determined that the tailgate needed to be replaced. The vehicle had not been repaired due to parts not being available for repair. The manufacturer was made aware of the issue. The failure mileage was 7,800. VIN tool confirms parts not available.

  • Filed Apr 2024

    The contact owns a 2023 Chevrolet Silverado 2500. The contact received notification of NHTSA Campaign Number: 24V060000 (Latches/Locks/Linkages) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

  • Filed Feb 2024

    The contact owns a 2023 Chevrolet Silverado 2500. The contact stated that while driving at an undisclosed speed, the tailgate step bar continuously extended and retracted. The tailgate-ajar warning light was illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the step actuator due to water damage. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 41,000.

• Service Brakes3

  • Filed Aug 2026

    I am filing this complaint regarding my 2023 Chevrolet Silverado 2500HD, which has approximately 20,000 miles and has been babied since new. The truck is maintained meticulously and the undercarriage is washed weekly. The brake failures I have experienced are completely unacceptable for a truck with this mileage and maintenance history. Both the FRONT and REAR brake friction material has completely DELAMINATED from the brake components. This is not normal brake wear. The material has separated from the underlying metal, which I believe is a serious material/manufacturing-quality issue. The dealer is now reporting that the rear emergency/parking brake shoes are also defective and require replacement. These components are inside the rear rotor and are not visible during a normal inspection. I strongly dispute any suggestion that this is simply corrosion or abuse. This truck is babied, maintained properly, and the undercarriage is washed every week specifically to prevent buildup and corrosion. At only 20,000 miles, having the front brakes, rear brakes, AND parking-brake shoes fail is completely unacceptable. The brake failures are also part of a disturbing pattern of component failures on this truck. The A/C compressor failed, leaving me without reliable air conditioning and resulting in a SIX-WEEK wait for replacement during the middle of summer. Additionally, only FIVE DAYS after I purchased the truck brand new, it required replacement of the Engine Control Module. This is a 2023 truck with only 20,000 miles. I expect normal wear items to wear normally—not to physically delaminate and fail. I am requesting that NHTSA investigate whether there is a systemic safety or manufacturing defect involving the brake materials/components used on these trucks. A brake component physically separating from its backing material is a serious safety concern and should not be dismissed as routine maintenance. GM needs to be held accountable for the quality and safety of this

  • Filed Sep 2024

    THE VEHCILE ONLY HAS 1779 MILES. THE AC UNIT OPERATED FOR SHORT PERIOD TIME. THE OUTSIDE TEMPERTURE WAS 95 DEGREE FAHRENHEIT ALL THE CONTROLS WERE NOT INOPERATE. THE A/C COMPRESSOR PUMP WAS NOT FUNCTIONING. THE ONLY ITEMS WORKING WAS THE FAN MOTOR BLOWING HOT AIR. I RESTATED THE VEHICLE AND STILL NO COLD AIR OUTPUT. THE DEALERSHIP SAID THEY COULD NOT FIND ANY PROBLEMS WITH A/C UNIT. THE UNIT OPERATED NORMALY AND THE TEMPERTUER IS 35 DEGREES OUTPUT. THE SECOND PROBLEM THE DASH PANEL EMERGENCY LIGHT CABLE WAS NEVER INSTALLED. THE DEALER HAD TO ORDER THE PART.

  • Filed Jun 2024

    Vehicle was towing Horse Trailer. Gave an indication message to check trailer break wiring. I did so and all was working fine. I loaded my horses and pulled out onto the road. Traveling 10 mph the truck completely shut off, no brakes, No warning, I helplessly rolled to a stop. The truck then turned on electrically, but did not start the engine completely by itself. Two minutes later, the truck turned itself off electrically. The motor was never running. I had it towed to a dealership in which it took them five days to repair. The truck has 17,000 miles on it. If I would’ve been traveling on the expressway or going any faster, I could’ve killed people.. I personally have PTSD from ever driving this truck hooked to a trailer again. There should have been some kind of warning system. I should have never lost my brakes. I purchased this truck as a towing vehicle from my Horse Trailer And now I am terrified to use it!

• Exterior Lighting3

  • Filed Sep 2024

    The vehicle mileage is 1,886. The vehicle steering command left or right turns had beautiful chime sound. The dealership could not find the signal chime commands. They claim that this vehicle doesn't have chime when turning right or left. This high-end truck has a lot features that dealership don't know about. This vehicle mileage is very good on the highway 22.4 miles per gallon.

  • Filed Sep 2024

    THE VEHCILE ONLY HAS 1779 MILES. THE AC UNIT OPERATED FOR SHORT PERIOD TIME. THE OUTSIDE TEMPERTURE WAS 95 DEGREE FAHRENHEIT ALL THE CONTROLS WERE NOT INOPERATE. THE A/C COMPRESSOR PUMP WAS NOT FUNCTIONING. THE ONLY ITEMS WORKING WAS THE FAN MOTOR BLOWING HOT AIR. I RESTATED THE VEHICLE AND STILL NO COLD AIR OUTPUT. THE DEALERSHIP SAID THEY COULD NOT FIND ANY PROBLEMS WITH A/C UNIT. THE UNIT OPERATED NORMALY AND THE TEMPERTUER IS 35 DEGREES OUTPUT. THE SECOND PROBLEM THE DASH PANEL EMERGENCY LIGHT CABLE WAS NEVER INSTALLED. THE DEALER HAD TO ORDER THE PART.

  • Filed Feb 2024

    1.THE INSTRUMENT PANEL EMERGENCY LIGHTS ARE NOT OPERATING . THE MANUFACTOR FAIL TO DO FINAL INSPECTION. THE EMERGENCY HARNESS WAS NOT INSTALL. THE INSTRUMENT LIGHTS WERE NOT OPERATING. 2. THE TRUCK AUTOMATIC STEPS LIGHTS DON'T COME ALL THE TIME. THE PASSENGERS ARE UNABLE SEE DURING DARKNESS. THEY LOSS THERE FOOTING AND FELL ON THE ASPHALT. THE AUTOMATIC STEPS ARE COLOR BLACK ARE TO SEE DURING THE NIGHT. THE STEPS SHOULD BE COLOR FLUORESCENT WHITE. THE VEHICLE MILEAGE IS ONLY 1224 MILES.

• Fuel/Propulsion System2

  • Filed Mar 2026

    The high pressure fuel pump “grenaded” while driving on the interstate. Caused an immediate shutdown and barely got off the main lane to the shoulder in extremely heavy traffic putting me, my wife and others in imminent danger. The components were inspected by the dealer mechanic and insurance adjuster and they said that is what happened and that there was no reason for it to have happened. A warning of reduced power appeared about 3 seconds before the truck completely shutdown.

  • Filed Mar 2026

    On February 3, 2026, my vehicle was taken to Rick Hendrick Chevrolet of Buford for diagnosis of a fuel system failure. The dealership charged a 235 diagnostic fee and concluded that the failure was caused by fuel contamination from an outside source. Based on this determination, my warranty claim with General Motors was denied and my case (#89096714) was closed. After this determination, the vehicle was transported to an independent diesel repair shop for further inspection. During the initial inspection, the technician removed the intake cover and discovered a large crack in the fuel injector pump. The pump had catastrophically failed and internally disintegrated, sending metal fragments throughout the fuel system. This clearly indicates the contamination originated from an internal mechanical failure of the fuel injector pump, not from outside fuel contamination. The independent technician confirmed that the injector pump failure caused metal debris to spread throughout the fuel system. Additionally, there was a visible leak at the front of the engine, which should have prompted further inspection in that area during the dealership’s diagnosis. It appears the dealership’s conclusion was based primarily on fuel sampling, without performing a full mechanical inspection of the injection pump and related components.

• Structure2

  • Filed Sep 2025

    The hood latch broke off mid drive on the freeway and my hood came up and then slammed down, came up again and went flying across the freeway.

  • Filed Feb 2024

    The contact owns a 2023 Chevrolet Silverado 2500. The contact stated that while driving at an undisclosed speed, the tailgate step bar continuously extended and retracted. The tailgate-ajar warning light was illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the step actuator due to water damage. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 41,000.

• Engine And Engine Cooling1

  • Filed Jul 2026

    The contact owns a 2023 Chevrolet Silverado 2500. The contact stated that while driving at various speeds, the transmission was slipping. Additionally, the contact stated that while driving 60-70 MPH, the vehicle stalled. No warning light was illuminated. The contact pulled over to the side of the road. Upon inspection, the contact became aware of a coolant leak underneath the vehicle. The vehicle was towed to the dealer, where it was diagnosed that the turbo coolant inlet had fractured. The part was replaced. Additionally, the dealer determined that the transmission was in working order upon inspection; however, the failure persisted. The vehicle was not repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 83,000.

• Wheels1

  1 involved a fire

  • Filed Jun 2026

    Was driving east on i40 between Hinton and calumet when my truck through a check engine light and service parking break. I pulled over it smelt like burning wires I cleared the codes with a code reader and turn the truck on the accessory when smoke filled the cab I got out and the truck was in flames.

• Lane Departure1

  • Filed Apr 2026

    The entire infotainment system has gone black. Nothing shows on the screen. This is a safety issue as it does not show blind spot monitoring, heads up display, lane change warnings, allow hands free calling, gps, and much more. None of the safety features are available with a trailer hookup as well. We have taken it to a certified Chevrolet dealer who has said the truck was the 6th one that they have placed an order for in just over a week. The infotainment system is currently on back order which makes operating the vehicle concerning with its proper safety features.

• Vehicle Speed Control1

  • Filed Jul 2025

    Component/System: The Allison 10‑speed (10L1000) transmission valve body catastrophically failed on [XXX], while driving Sunday afternoon down Galveston Seawall Blvd. The truck abruptly dropped from 45 mph into limp mode in heavy traffic, forcing me to pull into the bike lane to avoid being rear‑ended. The vehicle remains at Classic Chevrolet (Galveston, TX) awaiting the OEM valve body—which is on national backorder—and the complete transmission assembly is likewise unavailable. The failed valve body and transmission are available for inspection upon request. Safety Risk: Unexpected limp mode and gear lock‑up in heavy traffic create an immediate risk of rear‑end collisions or side impacts as surrounding drivers have no warning of sudden deceleration or loss of drive. Reproduction/Confirmation: Classic Chevrolet diagnosed and confirmed the failed valve body on May 12, 2025. Their service advisor and my assigned GM Case Agent (#[XXX]) have both acknowledged the defect but report no parts available for repair. Inspections: The vehicle has been inspected by Classic Chevrolet under warranty. GM Customer Care has reviewed my service orders and correspondence. No police or insurance inspections occurred, as no collision ensued—however, the roadside inspection at Classic Chevrolet confirmed the mechanical failure. Warnings/Symptoms: There were no prior warning lamps, messages, or symptoms before the failure. The valve body failure occurred without any advance indication. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• Steering1

  • Filed Jan 2025

    The car pulls to the left while driving. The steering wheel turned to the left when I stopped. I have taken it to the dealer three times but the problem is not resolved.

• Seat Belts1

  • Filed Jan 2025

    The seat beat has been un-latching while driving. It is random when it occurs. No warnings come before this happens. Does not always need to be that I move for it to unlatch. I have been sitting still while driving and it has come undone. The seat belt has been cleaned out. No signs of defect or other damage. Available to be inspected..should be repaired free of charge as this is a life threatening issue.

• Visibility/Wiper1

  • Filed Nov 2024

    This is not a failure, just a poor design for cold temperatures. The windshield wipers are set low on the windshield, below where the defroster can reach. When it is cold/snowing outside, (which it does a lot in the Alaskan interior), the wipers remove the melted water from the windshield and push it down to where the wipers sit in the off position. This causes a major buildup of ice very quickly and the wipers freeze to the glass and collect ice. Then, when the driver attempts to clear more melting snow, the ice that is frozen to the wipers just creates major streaking and poor visibility.

• Suspension1

  • Filed Feb 2024

    1.THE INSTRUMENT PANEL EMERGENCY LIGHTS ARE NOT OPERATING . THE MANUFACTOR FAIL TO DO FINAL INSPECTION. THE EMERGENCY HARNESS WAS NOT INSTALL. THE INSTRUMENT LIGHTS WERE NOT OPERATING. 2. THE TRUCK AUTOMATIC STEPS LIGHTS DON'T COME ALL THE TIME. THE PASSENGERS ARE UNABLE SEE DURING DARKNESS. THEY LOSS THERE FOOTING AND FELL ON THE ASPHALT. THE AUTOMATIC STEPS ARE COLOR BLACK ARE TO SEE DURING THE NIGHT. THE STEPS SHOULD BE COLOR FLUORESCENT WHITE. THE VEHICLE MILEAGE IS ONLY 1224 MILES.

Safety ratings

NHTSA 5-Star Safety Ratings from government crash tests. Ratings can differ by cab style and 2WD/4WD.

NHTSA hasn't published star ratings for this truck. Many heavy-duty pickups aren't included in NHTSA's crash-test program, so this doesn't mean the truck is unsafe.