2020 Chevrolet Silverado 2500HD

What owners should know

Covers 2020–2026 · 6.6L Duramax L5P diesel and 6.6L V8 gas · Updated 2026-10-01

Researched from owner forums and NHTSA complaints and written by Know Your Truck. These are patterns in what owners report, not a guarantee about any particular truck.

Common failures & how to fix them

Parts and video buttons search for your 2020 Chevrolet Silverado 2500HD. Always confirm a part fits using your VIN. Brakes, steering, fuel and airbag work affects your safety, so if you're not sure, have a qualified mechanic do it.

• 10-speed transmission valve body failure

  Dealer (recall)

  Signs: Sudden hard downshifts, limp mode, or rear wheel lock-up on diesels.

  Fix: Covered by GM recalls on 2020–2022 diesels. Other repairs are usually under warranty on newer trucks. Ask a dealer for all open recalls and bulletins.

  May be covered free by recall 24V797000 / 26V083000. Check the VIN at nhtsa.gov/recalls.

• Trailer brake controller warnings

  Easy DIY

  Signs: 'Check trailer wiring' or 'Trailer brakes disconnected' messages that cut the trailer brakes.

  Fix: Clean and inspect the 7-pin trailer connector and the trailer's wiring first. If it continues, have a dealer check for bulletins and module updates.

  Shop: 7 pin trailer connector▶ How-to videos

• Power tailgate opens unexpectedly

  Dealer (recall)

  Signs: The tailgate unlatches by itself, often after water gets in.

  Fix: Covered by GM recalls on 2020–2024 trucks with power-unlatching tailgates.

  May be covered free by recall 24V060000 / 24V894000. Check the VIN at nhtsa.gov/recalls.

• Steering gear shaft can break (2024)

  Dealer (recall)

  Signs: Loose steering or a clunk. In rare cases loss of steering.

  Fix: Covered by a GM recall on some 2024 trucks.

  May be covered free by recall 23V549000. Check the VIN at nhtsa.gov/recalls.

Recalls

A recall doesn't mean a truck still has the problem. Enter the truck's VIN at nhtsa.gov/recalls or ask a dealer to see whether the repair was done.

• Power Train:Automatic Transmission:Control Module:Software

  Feb 2026 · #26V083000

  General Motors, LLC is recalling certain 2020 Chevrolet Silverado 2500, 3500, GMC Sierra 2500, 3500, and 2020-2022 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles that may have been repaired incorrectly under recall 24V797. The transmission control valve may fail and cause the rear wheels to lock up.

  Risk and fix

  Risk: Rear wheel lock up increases the risk of a crash.

  Fix: Dealers will inspect the vehicles and update the transmission control software, free of charge. Owner notification letters were mailed March 6, 2026. Owners may contact GMC customer service at 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252516560. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on February 12, 2026.

• Power Train:Automatic Transmission:Control Module:Software

  Oct 2024 · #24V797000

  General Motors, LLC (GM) is recalling certain 2020-2022 Chevrolet Silverado 1500, 2500, 3500, GMC Sierra 1500, 2500, 3500, 2021 Cadillac Escalade, Escalade ESV, Chevrolet Tahoe, Suburban, GMC Yukon, and Yukon XL vehicles equipped with diesel engines. The transmission control valve may fail and cause the rear wheels to lock-up.

  Risk and fix

  Risk: Rear wheel lock-up can increase the risk of a crash.

  Fix: Dealers will install new transmission control module software, free of charge. GM will provide a special coverage program to cover the repair of transmissions that are identified by the remedy software as containing a defective control valve. Owner notification letters were mailed December 12, 2024. Owners may contact GM customer service at 1-888-988-7267, Cadillac customer service at 1-800-458-8006, GMC customer service at GMC 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N242454440.

• Latches/Locks/Linkages:Tailgate:Latch

  Feb 2024 · #24V060000

  General Motors, LLC (GM) is recalling certain 2020-2024 Chevrolet Silverado 2500, 3500, GMC Sierra 2500 and 3500 vehicles equipped with power-unlatching tailgates. The tailgate's electronic gate-release switch may short circuit due to water intrusion, which can result in the tailgate inadvertently unlatching while the vehicle is in park.

  Risk and fix

  Risk: An unlatched tailgate may open while driving and result in a loss of unsecured cargo, creating a road hazard and increasing the risk of a crash.

  Fix: Owners are advised to check that the tailgate is closed and latched before driving. Dealers will replace the exterior touchpad switch assemblies, free of charge. Owner notification letters were mailed May 17, 2024. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is N232426400.

• Tires:Temporary/Emergency Spare Tire

  Jul 2021 · #21V578000

  General Motors, LLC. (GM) is recalling certain 2020-2021 Chevrolet Silverado 2500 and GMC Sierra 2500 vehicles equipped with a 17" spare tire (RPO ZHQ or ZXT) and either the 20" accessory road tire (RPO REM) or the 18" accessory road tire (RPO Q2V). Operating the spare tire with other 20" or 18" tires can prevent the Anti-Lock Braking System (ABS) from engaging.

  Risk and fix

  Risk: An ABS system that cannot control the rear wheels independently increases the risk of a crash.

  Fix: Dealers will provide the appropriate spare tire and apply a new spare tire information label, free of charge. Owner notification letters were mailed on October 18, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020; GMC customer service at 1-800-462-8782. GM's number for this recall is N212329780.

• Seat Belts

  Dec 2020 · #20V792000

  General Motors, LLC (GM) is recalling certain 2019-2021 Chevrolet Silverado 1500 and GMC Sierra 1500, 2021 Chevrolet Suburban and Tahoe and GMC Yukon XL and 2020-2021 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 vehicles. The seat belt brackets may not be secured to the seat frame in the front-row center seating position.

  Risk and fix

  Risk: If a seat-belt bracket is not secured, the seat belt may not properly restrain an occupant in the front-row center seat position, increasing the risk of injury in a crash.

  Fix: GM will notify owners, and dealers will inspect left-side and right-side front-row center seat-belt bracket attachments and reassemble it correctly as necessary, free of charge. The recall began January 26, 2021. Owners may contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N202314670.

• Power Train:Driveline:Driveshaft

  Oct 2020 · #20V650000

  General Motors LLC (GM) is recalling certain 2019-2020 Chevrolet Silverado 1500 and GMC Sierra 1500 and 2020 Chevrolet Silverado 2500 trucks. One of the driveshaft joints may not have been properly welded, causing the driveshaft to separate while the vehicle is moving.

  Risk and fix

  Risk: If the driveshaft separates, there may be a loss of propulsion, increasing the risk of crash.

  Fix: GM will notify owners, and dealers will replace the driveshaft, free of charge. The recall is expected to begin December 2020. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-888-988-7267. GM's number for this recall is N202314870.

• Air Bags:Side/Window:Curtain:Inflator

  Jul 2020 · #20V446000

  General Motors, LLC. (GM) is recalling certain 2020 Buick Enclave, Cadillac XT5 and XT6, Chevrolet Blazer, Silverado 1500, 2500 and 3500 and Traverse and GMC Acadia and Sierra 1500, 2500 and 3500 vehicles. The diffuser component of the Roof-Rail Air Bag (RRAB) inflator may not have been properly crimped to the inflator and could separate from the inflator during air bag deployment.

  Risk and fix

  Risk: If the diffuser separates from the inflator during deployment, RRAB performance may be degraded, increasing the risk of injury in a crash.

  Fix: GM will notify owners, and dealers will replace the suspect RRAB modules, free of charge. The recall began September 3, 2020. Owners may contact Chevrolet customer service at 1-800-630-2438, Cadillac customer service at 1-800-333-4223, or Buick customer service at 1-800-521-7300. GM's number for this recall is N202305380.

• Structure:Body:Hood

  Jun 2020 · #20V324000

  General Motors LLC (GM) is recalling certain 2020 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 vehicles previously recalled under 20V-142. Some of the vehicles in 20V-324 were not part of Recall 20V-142 but received defect parts during another service (typically during collision repair). The hood-latch striker wires on replacement hoods installed for Safety Recall 20V-142 may not have been heat-treated properly, possibly causing them to fracture.

  Risk and fix

  Risk: If a striker wire fractures, the hood may open unexpectedly while driving, increasing the risk of a crash.

  Fix: GM will notify owners, and dealers will replace the hood assembly, free of charge. For hoods sold over the counter, dealers will contact customers with instructions for hood replacement. The recall began July 7, 2020. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-888-988-7267. GM's number for this recall is N202306490.

• Latches/Locks/Linkages:Hood:Latch

  Mar 2020 · #20V142000

  General Motors LLC (GM) is recalling certain 2020 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 vehicles. The hood-latch striker wires may not have been heat-treated properly, possibly causing them to fracture.

  Risk and fix

  Risk: If a striker wire fractures, the hood may open unexpectedly while driving, increasing the risk of a crash.

  Fix: GM will notify owners, and dealers will replace the hood assembly, free of charge. The recall began April 13, 2020. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-888-988-7267. GM's number for this recall is N192284960.

• Seat Belts:Pretensioner

  Nov 2019 · #19V814000

  General Motors LLC (GM) is recalling certain 2019-2020 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2020 Silverado 2500, Silverado 3500, Sierra 2500, and Sierra 3500 vehicles equipped with carpet floor covering. When the front seat belt pretensioners deploy, hot gas may vent through an opening in the pretensioner bracket, possibly igniting the carpet.

  Risk and fix

  Risk: A vehicle fire could result if materials ignite inside the vehicle.

  Fix: GM will notify owners, and dealers will close off the opening in the pretensioner bracket, free of charge. The recall began December 13, 2019. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-888-988-7267. GM's number for this recall is N192270600.

Owner complaints by area

Reports owners filed with NHTSA. They aren't verified, and one complaint can mention more than one area. Tap an area to read the most recent ones.

• Power Train33

  1 involved a crash · 1 involved a fire

  • Filed Sep 2026

    While driving on the highway our transmission cooling line completely separated at rubber hose to metal line crimp. This cause transmission fluid to burst out all over the vehicle including the windshield and trailer. Vehicle immediately stopped pulling and we barely were able to get to the side of the road. This also caused a catastrophic transmission failure costing approximately 10,000 to repair. GM covered some of the transmission cost but still left us with 5000 bill for a transmission line defect on a vehicle under 100,000 miles. This created a unsafe condition with the trans fluid on the windshield and immediate loss of drive. All maintenance was performed per manufacturers specifications and no warning signs/lights/leaks provided prior to the failure. I do have pictures of the failed transmission cooling line.

  • Filed Sep 2026

    The contact owns a 2020 Chevrolet Silverado 2500. The contact stated that the transmission shuddered and hesitated while driving 55 MPH or at higher speed. The vehicle was taken to the dealer; however, the dealer was no longer in business. While driving at various speeds, the lifters were squeaking. The vehicle was taken to a dealer and was diagnosed with lifters failure. The contact decided not to repair the vehicle. The manufacturer was informed of the failure. The failure mileage was approximately 170,000.

  • Filed Sep 2026

    2 of the 4 Balance weights from Front Axle Propeller Shaft have become detached from their welds. Found on chassis during routine maintenance and visual inspection. Truck was just outside window of recall N202314870, Contacted GM Customer care to confirm no recall work was preformed and vehicle is outside of window of the referenced recall. Vehicle scheduled for evaluation/repair by GM Dealer 9/14/26 approx. 84000miles

  • Filed Aug 2026

    The contact owns a 2020 Chevrolet Silverado 2500. The contact stated that while driving at an undisclosed speed, the transmission was slipping and shifting hard. The contact associated the failure with NHTSA Campaign Number: 26V083000 (Power Train); however, the VIN was not included. The dealer was notified of the failure, but the vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 120,000.

  • Filed Apr 2026

    my 2020 Chevrolet Silverado has locked up a couple times on 4/2/26 i immediately drove to the robins chevy dealership, the service writer and i discussed the recall of the transmission, the next day i was sent a estimate of 6800.00 dollars to replace the valve body of the transmission, i asked why am i responsible for the replacement cost due to a known recall of the transmission valve body? i was instructed to call gm directly which i did and no action was taken, i was told to speak to the dealership manager. i need help with this matter.

  • Showing the 5 most recent of 33.
• Service Brakes19

  1 involved a crash

  • Filed Sep 2026

    The contact owns a 2020 Chevrolet Silverado 2500. The contact stated that the transmission shuddered and hesitated while driving 55 MPH or at higher speed. The vehicle was taken to the dealer; however, the dealer was no longer in business. While driving at various speeds, the lifters were squeaking. The vehicle was taken to a dealer and was diagnosed with lifters failure. The contact decided not to repair the vehicle. The manufacturer was informed of the failure. The failure mileage was approximately 170,000.

  • Filed Sep 2026

    The contact owns a 2020 Chevrolet Silverado 2500. The contact stated that while driving 20 MPH and depressing the brake pedal, the vehicle was making a squealing noise. The failure was a recurring failure. The contact associated the failure with Technical Service Bulletin: 20-NA-020. The dealer was contacted and replaced the brake pads to fix the vehicle; however, the failure persisted. The manufacturer was contacted by phone and was made aware of the failure. The failure mileage was approximately 12,000.

  • Filed Mar 2026

    My dash has been displaying intermittently “Service electric trailer brakes”. I have recently purchased a 30’ travel trailer. After driving a couple hundred miles with trailer in tow. The code started appearing even with the trailer not connected. I have contacted GM and they have indicated no recall on electric brake controller.

  • Filed Apr 2024

    Rear wheels locked up while driving/accelerating. Happened 5 times, 4 times while towing a camper once without towing. Luckily no harm or damage came to anyone. Traded in at dealership due to safety concerns after no diagnostics found anything “wrong”. It is already listed for sale, but I don’t think It’s been addressed or fixed.

  • Filed Jan 2024

    The contact owns a 2020 Chevrolet Silverado 2500. The contact stated while driving at an undisclosed speed, the steering wheel briefly became tight before returning to normal functionality. After the failure, the temperature gauge indicated that the engine was overheating. The contact also stated that the brake pedal required excessive force to slow and bring the vehicle to a complete stop. No warning lights were illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the water pump. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was 74,000.

  • Showing the 5 most recent of 19.
• Electrical System17

  2 involved a fire

  • Filed Sep 2026

    My vehicle was taken to Legacy Chevrolet of Waxahachie where a routine recall notice was addressed. During the process they technician broke my battery terminal. Upon my discovery the dealership claimed the broken terminal must have just broke on its own during the time it was at their dealership in spite of the ECM module update requiring the technician to specifically remove the battery cable from that specific terminal. Legacy has refused to address this issue and charged me for the new batteries as well as for the tow that was required. The damage was caused by their technician and all of the costs incurred should have been absorbed by the dealership.

  • Filed Aug 2026

    The contact owns a 2020 Chevrolet Silverado 2500. The contact stated that while driving at undisclosed speeds and towing a trailer, the message "Trailer Brake Disconnected" was displayed with an audible chime. The vehicle was inspected by the dealer, but no fault was found with the vehicle. Upon investigation, the contact discovered Service Update Program: N232414840; and associated the failure with the service update. The dealer and the manufacturer confirmed that the vehicle was not included in the program. The vehicle was not repaired. The failure mileage was approximately 126,000.

  • Filed Jun 2026

    I got to my destination and got out of the truck and like a hour later I came back to my truck to get in and my truck was full of smoke and stunk and my center console and center dash melted and gone . Nothing would work . That’s all I know

  • Filed Mar 2026

    This vehicle does not recognize that the gear is on park. Due to the issue, it has left me stranded twice. The first time it was at a very remote area up in the mountains. I was stuck for hours due to battery dying. The second time being a very dangerous situation Because it was a very dangerous area late at night.

  • Filed Feb 2026

    On approximately January 24, 2026 my 2020 Chevrolet Silverado 2500HD equipped with the 6.6 Duramax Diesel displayed an error code (P20B9). This error code was found to be related to the diesel exhaust fluid system specifically relating to "Reductant Heater A Control Circuit/Open." On January 27, 2026, the vehicle was diagnosed at Chevrolet dealership and the following was reported "Diesel Emissions Fluid Tank Remove and Replace - P20B9 SET FOR REDUCTANT HEATER CIRCUIT...COMMANDED ON AND ZERO AMPS..CIRCUITFAILURE... DISCONNECT PUMP MODULE AND BURNED/OVERHEATED TERMINALS..PUMP MODULE AND HARNESS PART OF TANK ASSEMBLY... LABOR TIME ADDED TO PERFORM MALFUNCTION/TAMPER TEST TO CLEAR EMISSIONS MESSAGE...." I found the "burned/overheated terminals" comment to be alarming. I looked into this matter further and found a GM Service Bulletin (21-NA-006) from October 2022. This bulletin identified this issue which contained an image showing burned/overheated terminals. The identified cause within the bulletin states "This condition may be caused by a poor connection at the Emission Reduction Fluid Tank electrical connector." I believe this should upgraded to a safety recall due the the potential of this terminal connection catching fire which could be detrimental for the operator, passengers, property, and the public.

  • Showing the 5 most recent of 17.
• Tires10

  • Filed Aug 2026

    Tire size 275 65 R20 entire tread came completely off the tire & caused damage to my fender & fender well. This tire had approximately 29,830 miles on it. It was 1 of the original tires from the factory on this truck.

  • Filed Sep 2025

    As I was driving I got a really bad vibration once I pulled over to check it out I discovered the tire was separating . The tires had about 10,000 miles on them. I have another tire that just recently did the same thing I will also be reporting

  • Filed Sep 2025

    While driving home I noticed a vibration in the steering wheel. Once I got home I looked over the tires because I had one start to come apart a month ago so I was worried another one was doing the same thing, and I was correct. The tire has roughly 12k miles on it

  • Filed Aug 2024

    I was traveling at 45 mph. Rear Passenger tire tread separated from tire, broke off and damaged wheel well, front & rear mud flaps, rear corner of bumper and cracked taillight. Tire have under 37,000 miles on them.

  • Filed Jul 2023

    LT275/65R20 July 2022 Driving home low tire signal came on, had bubble in tire, tires only had 22,000 miles. This is first of three complaints on these tires. Other two problems happened this past June. Two more tires with bubbles all tires under 30,000 miles.

  • Showing the 5 most recent of 10.
• Engine10

  1 involved a fire

  • Filed May 2026

    2020 3.0 diesel duramax sucked in the antifreeze and caused a hydrolock. The dealer says that it is not covered under warranty since the engine was over 100k miles. They did offer a new engine for $30K which I declined. The truck was always well taken care of and only received the best in all products

  • Filed Feb 2026

    The contact owns a 2020 Chevrolet Silverado 2500. The contact stated that while driving approximately 45 MPH, the check engine warning light illuminated. The vehicle was taken to the residence. The vehicle was then taken to a dealer, and DTC: P133X (Cylinder X Glow Plug Failure) was retrieved. The contact was informed that the Glow Plug needed to be replaced and reprogrammed. The vehicle was repaired, but the failure reoccurred with a different Glow Plug five months later. The vehicle was taken to a dealer to be diagnosed, and it was determinedthat Glow Plug #3 had failed, and DTC: P0673, P0607, and P133A were retrieved. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 50,616.

  • Filed Nov 2025

    The contact owns a 2020 Chevrolet Silverado 2500. The contact stated that while driving at an undisclosed speed, the rear wheels locked up momentarily. The check engine warning light was illuminated. The vehicle was previously taken to the local dealer to be repaired under NHTSA Campaign Number: 24V797000 (Power Train). The vehicle was repaired, but the failure recurred. The manufacturer was contacted, who confirmed that the recall repair was a one-time free repair, and no further assistance was provided. The failure mileage was approximately 188,000.

  • Filed Sep 2025

    I am writing to express my serious concern and frustration regarding the unresolved recall on my 2020 Chevrolet Silverado 2500 (VIN: [XXX] ). Despite multiple visits to multiple dealerships, I was repeatedly told that the necessary parts to complete the recall repair were on back order and instructed to “wait for parts.” No interim solution or assistance was ever offered. As a result of this delay, my vehicle broke down without warning, leaving me stranded on the side of the road. This created a hazardous situation and significant disruption to my day. To make matters worse, I had to pay out of pocket to have the truck towed to a repair shop in an effort to get it operational—an expense I should never have incurred given the known recall and repeated attempts to have the issue corrected by Chevrolet. I have been a loyal Chevrolet owner and have always trusted the brand for its quality and dependability. However, this delay and lack of proactive support is causing significant inconvenience and eroding that trust. This situation is unacceptable for several reasons: 1.Safety Risk and Recall Obligation: Chevrolet acknowledged the defect by issuing a recall, yet I have been forced to operate a vehicle that does not meet your own safety standards for months. 2.Repeated Service Attempts with No Resolution: I followed the proper process and visited an authorized dealer multiple times, only to be turned away each time with no solution beyond “wait for parts.” 3.Breakdown and Financial Loss: The vehicle failure and subsequent towing expense are a direct consequence of Chevrolet’s inability to provide timely parts or alternative accommodations. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

  • Filed Apr 2025

    I was driving on Interstate 75 in Ohio when the engine suddenly overheated and completely locked up we were pulling my travel trailer camper at the time which we ended up getting off of an overpass and blocking traffic for several hours until we got the vehicles moved Chevrolet did eventually replace the motor and the entire cooling system with what they claim is a new motor in October of 2024, and within the last couple of days I have noticed a smell coming from the engine compartment that was reminiscent about the smell when it locked up I'm afraid they stuck another motor in my truck that has the same exact issues and once it goes out of warranty I'm going to be stuck with another broke down truck

  • Showing the 5 most recent of 10.
• Unknown or Other10

  • Filed Feb 2026

    THREE WEEKS I NOTICED THE HEADLINER ABOVE THE REAR WINDOW WAS WET. THE REAR WINDOW HAS SOME CRACKS ON THE TOP PLASTIC MOLDING THAT HOLDS THE WINDOW TO THE CAB OF THE TRUCK. THIS MOLDING IS IN BETWEEN THE HEADLINER AND THE REAR GLASS.

  • Filed Jan 2026

    The engine block heater in my truck keeps tripping the circuit breaker. Dealership says it that 'it appears that the block heater cord is shorted recommend replacing cord' estimate $500. I understand that Chevy has recalled some trucks from this year for this very problem however it and they don't include my truck. This is a fire safety hazard!!! The company admits it is a safety issue. Why isn't my truck on the list? Here is the article I found on it. 2020 silverado engine block heater cord recall +5 General Motors has issued recalls affecting 2019–2020 Chevrolet Silverado 1500 and various heavy-duty models (4500HD-6500HD) due to a fire risk from the engine block heater cord . The cord can short circuit, potentially causing a fire in the engine compartment. Owners are advised to park trucks outdoors and away from structures until the free dealer repair is completed. Key Details Regarding 2020 Silverado Recalls: Affected Vehicles: Specific 2019-2020 Chevrolet Silverado 1500, GMC Sierra 1500, and 2019-2023 4500HD, 5500HD, and 6500HD trucks. The Issue: The engine block heater cord or its terminals can short-circuit, causing a fire risk. Symptoms: Potential for smoke, a burning smell, poor heater performance, or tripped circuit breakers. Action Required: Dealers will inspect and potentially disable or replace the block heater cord. Safety Recommendation: Do not plug in the engine block heater until the recall repair has been performed. It is recommended to check the NHTSA recall website with your VIN for the most up-to-date information on your specific vehicle. GM recalls 40,000 pickups over fire risk - FOX 5 San Diego Apr 24, 2023 — This is an archived article and the information in the article may be outdated. Please look at the time stamp on the story to see when it was last updated. (WJW... [XXX] Part 573 Safety Recall Report 21V-496 - nhtsa Mar 4, 2022 — Description of Defect : ... In vehicles equipped with the Duramax dies INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

  • Filed Dec 2025

    I am filing a safety and health complaint regarding a known rear window water intrusion defect on my 2020 Chevrolet Silverado 2500 with approximately 56,000 miles. Despite the severity of the issue, the dealership has refused to provide a permanent repair. This defect is widely documented and has resulted in a recall in Canada, yet no recall exists in the United States—despite significantly more of these vehicles being sold here. The inconsistency in recall coverage is deeply concerning. My vehicle experiences substantial water intrusion that has saturated the rear headliner, rear seat area, and carpeting. This creates a serious health concern, particularly for rear-seat passengers, including children. Prolonged moisture intrusion creates a high likelihood of mold growth beneath interior components, which General Motors has failed to address. There is also a serious safety risk. The rear sliding window heater module is mounted directly to the rear window. It is well known that when this module is exposed to moisture from the leak, it can cause the rear window to shatter or explode. The dealership has acknowledged this risk. A rear window shattering while occupants are in the vehicle could result in serious injury. When covered under bumper-to-bumper warranty, the dealership’s only solution is a “reseal” of the rear window. This is not a permanent repair, and many owners report repeated failures after resealing. This issue is easily verified through widespread consumer complaints. These trucks are expensive vehicles, and owners should not be forced to accept temporary fixes for a defect that presents clear health and safety risks. I respectfully request that NHTSA investigate this issue and take appropriate action.

  • Filed Sep 2025

    The rear camera goes out when backing up. This causes a safety hazard due to not being able to see.

  • Filed Jun 2025

    We received a recall on this truck 2/2025 showing that there was a transmission control valve defect that was causing excessive wear on the gears. We took it into Sands Chevrolet and they did a repair under warranty. Within a few weeks, the truck again lost power, would not go over 30 MPH and caused a safety issue as it happened while on the highway. We immediately took the truck back to Sands who informed us of the recall and that the transmission needed to be repaired because of the excessive wear under the recall. Sands Chevrolet told us it would be 2 months before they could repair it. However, there was another local shop that could so we took it there and had it repaired within days. The dealership told us to submit our invoice and credit card statement showing that we paid the $5575 out of pocket that we were told we would be reimbursed for. Now, Chevy is denying that there was even a recall on the vehicle.... but I have the letter from GM showing the recall and the local Sands dealership is the one that told us to go get it fixed. I have the scan of the safety recall, but it is not letting me upload it here. It is GM Recall # N242454440

  • Showing the 5 most recent of 10.
• Steering9

  • Filed Oct 2025

    Intermittent steering catches

  • Filed Jan 2024

    The contact owns a 2020 Chevrolet Silverado 2500. The contact stated while driving at an undisclosed speed, the steering wheel briefly became tight before returning to normal functionality. After the failure, the temperature gauge indicated that the engine was overheating. The contact also stated that the brake pedal required excessive force to slow and bring the vehicle to a complete stop. No warning lights were illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the water pump. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was 74,000.

  • Filed Sep 2022

    The truck pulls to the right, pulling it off the road. It has 50k miles now and the dealer has aligned it 6 times and it’s showing within specifications, but continues to pull to the right. The dealer can’t find the cause of the problem and GM has no answer but for me to start paying to change parts which may or may not fix it.

  • Filed Jul 2021

    The contact owns a 2020 Chevrolet Silverado 2500. The contact stated while driving 38 mph, he noticed the steering wheel was loose. The contact started to hear an abnormal sound coming from the vehicle. The contact stated while driving over a small bump in the roadway, the vehicle inadvertently steered to the right. The contact took the vehicle to the local dealer however, the mechanic was unable to duplicate the failure. The contact took the vehicle to an independent mechanic, where it was diagnosed with needing the pitman arm and idler arm to be replaced. The contact called the local dealer and made them aware of the repair that was needed on the vehicle. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 20,000.

  • Filed Jan 2021

    AT HIGHWAY SPEEDS OF 55-80MPH THE VEHICLE HAS A CONSTANT VIBRATION IN THE STEERING WHEEL. THIS HAS BEEN A PROBLEM SINCE PURCHASED BRAND NEW IN JULY '20. AT 1,350 MILES, IN AUGUST '20, I HAD THE TIRES ROTATED AND BALANCED, NOTHING CHANGED. AT 5,700 MILES, IN JANUARY '21, I HAD THE TIRES ROTATED AND BALANCED AGAIN, NOTHING CHANGED. I FOUND THAT GM HAS A TSB OUT BUT IT IS NOT A RECALL TO FIX THE ISSUE OR REPLACE THE BAD TIRES. SEE GM TSB #19-NA-240.

  • Showing the 5 most recent of 9.
• Fuel/Propulsion System8

  • Filed Feb 2026

    On approximately January 24, 2026 my 2020 Chevrolet Silverado 2500HD equipped with the 6.6 Duramax Diesel displayed an error code (P20B9). This error code was found to be related to the diesel exhaust fluid system specifically relating to "Reductant Heater A Control Circuit/Open." On January 27, 2026, the vehicle was diagnosed at Chevrolet dealership and the following was reported "Diesel Emissions Fluid Tank Remove and Replace - P20B9 SET FOR REDUCTANT HEATER CIRCUIT...COMMANDED ON AND ZERO AMPS..CIRCUITFAILURE... DISCONNECT PUMP MODULE AND BURNED/OVERHEATED TERMINALS..PUMP MODULE AND HARNESS PART OF TANK ASSEMBLY... LABOR TIME ADDED TO PERFORM MALFUNCTION/TAMPER TEST TO CLEAR EMISSIONS MESSAGE...." I found the "burned/overheated terminals" comment to be alarming. I looked into this matter further and found a GM Service Bulletin (21-NA-006) from October 2022. This bulletin identified this issue which contained an image showing burned/overheated terminals. The identified cause within the bulletin states "This condition may be caused by a poor connection at the Emission Reduction Fluid Tank electrical connector." I believe this should upgraded to a safety recall due the the potential of this terminal connection catching fire which could be detrimental for the operator, passengers, property, and the public.

  • Filed Mar 2022

    My 2020 Silverado HD truck requires a replacement wiring harness and DEF tank and is basically inoperable. This is a known issue for GM and spans multiple model years.GM continued to produce throughout multiple model years knowing that owners may be stranded and unable to use these vehicles because of the defective parts. Hardships for owners would include loss of income and exposure to various dangerous conditions. The DEF tank has a heater system that can get exposed to the DEF fluid because of a poor design and poor manufacturing standards resulting in short circuit. GM will replace the wiring harness and combination tank/heater assembly under warranty. The parts are supposedly on NATIONAL BACK ORDER, yet GM continues to manufacture and ship new 2022 models with the required parts needed for repairs. GM will not provide alternate transportation. Supposedly in excess of ten thousand trucks are affected. Warm climate owners and warm temperatures may affect this issue positively. GM has no policy for a timely response to this issue. Trucks will become unsafe to operate when the electronic controls limit the truck speed to 5 mph or less. An operator may become stranded and exposed to dangerous highway conditions if stranded with this issue.

  • Filed Mar 2022

    The DEF heater/tank shorted out. The DEF system has thrown a code 3 times in the little over a year I’ve owned the truck. This final time I was told that the tank needs to be replaced. The truck has now been in the shop for 2 months and there is still no ship date on the replacement tank. The tanks are on a national back order. From what I understand there are about 9,000 people waiting for this DEF tank countrywide. I now have a $60k work truck that I am paying for but cannot use with no reasonable end in sight.

  • Filed Mar 2022

    Service DEF message in truck that will soon result in reduced speed. Local and purchasing dealers both stated a new DEF tank is needed. A tank is not available and is on back order.

  • Filed Mar 2022

    DEF tank heater short causes wiring harness to melt and fault on diesel trucks, enabling limp mode. Limp mode is dangerous when hauling trailers over long distances. Faulty part is on 6 month backorder. No reparations from GM.

  • Showing the 5 most recent of 8.
• Structure6

  • Filed Feb 2025

    Rear spoiler is leaking water into the cab causing the headliner and rear seat to get wet when raining outside

  • Filed Dec 2024

    Rear window leaking. There is mold inside vehicle.

  • Filed Jun 2024

    Water leaking in around rear window causing moldy smell, puddled water on rear floor, saturated carpet. Believe to be health hazard because my eyes & nose burn when I’m in the vehicle. Have not had any inspection of this problem because the warranty had run out before I discovered. This is a known problem to GM on numerous trucks as I learned after researching. Truck has very low mileage, less than 15000. Very disappointed.

  • Filed Feb 2024

    Rear window frame is leaking during rain or heavy dew. Causing saturated headliner, seats and carpet. Mold could develop and become a health factor. My 2 kids always ride in the back seat. This is a known issue for GM and are not taking action to correct this problem. Vehicle started leaking with 25,000 miles.

  • Filed Nov 2023

    Back window leaked. It was a heavy mist all night, not even heavy rain yet, and when we opened the passenger back door in the morning around 7:30 am, we found a pool of water on the back seat and water running down the seat. When I checked the forums, there is an abundance of complaints about the back windows leaking in Chevy trucks for many years now.

  • Showing the 5 most recent of 6.
• Engine And Engine Cooling4

  • Filed Feb 2026

    The contact owns a 2020 Chevrolet Silverado 2500. The contact stated that while driving at 50 MPH, the vehicle went into LIMP Mode. The check engine warning light illuminated, and the messages "Service Emission System”, “See Owner's Manual", and "65 MPH Max Speed" were displayed on the instrument panel. The vehicle was taken to the dealer, where it was diagnosed, and determined that the diesel exhaust fluid gas tank connector terminal had overheated, and the gas tank and the wiring harness needed to be replaced. The vehicle was not repaired due to the cost. The vehicle remained at the dealer. The contact associated the failure to the Global Warranty Management: N212342980. The manufacturer was not notified of the failure. The failure mileage was 173,794.

  • Filed Feb 2025

    The contact owns a 2020 Chevrolet Silverado. The contact stated that while attempting to remote start the vehicle, the vehicle failed to start. The contact was able to manually start the vehicle however, the message "Service Emissions System - Speed Limited to 65 MPH" was displayed. The contact stated while driving approximately 25 MPH, the "Check Engine” and “Speed Limit 65 MPH" messages were displayed. The contact heard an abnormal sound like air coming from the rear of the vehicle. The contact stated there was thick black smoke coming from the exhaust pipe. The contact returned to the residence. The contact had not taken the vehicle to the dealer or independent mechanic. The vehicle was not diagnosed. The contact had used a handheld scanner and became aware that the Reductant Heater circuits 1, 2, and 3 had short-circuited. The contact checked and observed that the wiring harness located under the vehicle near the fuel tank and the Diesel Exhaust Fluid (DEF) tank had melted. The vehicle was not repaired. The contact had researched online and related the failure to Technical Service Bulletin Number: N202300791 - Service Update Diesel Exhaust Fluid System (Fuel System, Diesel). The manufacturer was informed of the failure. The failure mileage was approximately 131,000.

  • Filed Jan 2025

    The contact owns a 2020 Chevrolet Silverado 2500. The contact stated that while operating the vehicle, the check engine warning light remained illuminated. The contact stated that the failure was intermittent. The vehicle was taken to the local dealer who replaced the fuel module and fuel tank. The failure eventually reoccurred, and the fuel rail sensor was replaced; however, the failure recurred intermittently. The manufacturer was notified of the failure. The failure mileage was 135,000.

  • Filed Jan 2024

    The contact owns a 2020 Chevrolet Silverado 2500. The contact stated while driving at an undisclosed speed, the steering wheel briefly became tight before returning to normal functionality. After the failure, the temperature gauge indicated that the engine was overheating. The contact also stated that the brake pedal required excessive force to slow and bring the vehicle to a complete stop. No warning lights were illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the water pump. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was 74,000.

• Vehicle Speed Control4

  • Filed Sep 2025

    I am writing to express my serious concern and frustration regarding the unresolved recall on my 2020 Chevrolet Silverado 2500 (VIN: [XXX] ). Despite multiple visits to multiple dealerships, I was repeatedly told that the necessary parts to complete the recall repair were on back order and instructed to “wait for parts.” No interim solution or assistance was ever offered. As a result of this delay, my vehicle broke down without warning, leaving me stranded on the side of the road. This created a hazardous situation and significant disruption to my day. To make matters worse, I had to pay out of pocket to have the truck towed to a repair shop in an effort to get it operational—an expense I should never have incurred given the known recall and repeated attempts to have the issue corrected by Chevrolet. I have been a loyal Chevrolet owner and have always trusted the brand for its quality and dependability. However, this delay and lack of proactive support is causing significant inconvenience and eroding that trust. This situation is unacceptable for several reasons: 1.Safety Risk and Recall Obligation: Chevrolet acknowledged the defect by issuing a recall, yet I have been forced to operate a vehicle that does not meet your own safety standards for months. 2.Repeated Service Attempts with No Resolution: I followed the proper process and visited an authorized dealer multiple times, only to be turned away each time with no solution beyond “wait for parts.” 3.Breakdown and Financial Loss: The vehicle failure and subsequent towing expense are a direct consequence of Chevrolet’s inability to provide timely parts or alternative accommodations. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

  • Filed Jan 2025

    In 2024, I noticed that my truck was experiencing rough shifts. It felt as if the back wheels were jerking over uneven ground, even though the vehicle was on a flat surface. In November 2024, my sister sent me an article about General Motors' massive recall due to rear wheel lock-up, which increased the risk of crashes. I contacted GM and learned that my truck was part of the recall. I reported the issues my truck was exhibiting, and GM instructed me to reach out to my dealer about the problem. However, I was informed that they did not have the parts to fix the issue and had no idea when they would receive them. I asked GM if they would provide me with a rental vehicle, but they declined, stating that if they offered a rental to me, they would have to provide one for others as well, which was not feasible due to the large number of affected vehicles. I explained that my truck is my daily driver for work, and I frequently transport my grandchildren in it. Driving the truck was hazardous given the issues it was already exhibiting. I was told to contact my dealer, and since my truck was under warranty, they should provide me with a rental. When I requested to speak with a manager, I was informed that they would only reiterate the same information. I then contacted my dealer, Sapaugh GM Country, located at 1435 McNutt St., Herculaneum, MO. I was informed that they do not have the parts. but they did a minor tweak which has caused more damage to my powertrain and engine.

  • Filed Nov 2024

    The contact owns a 2020 Chevrolet Silverado 2500. The contact stated while driving 50 MPH, the accelerator pedal was depressed; however, the vehicle failed to respond. No warnings lights were illuminated. The contact pulled over to the side of the roadway, turned off and restarted the vehicle; however, while attempting to shift into drive the vehicle hesitated and failed to respond as needed. The contact stated that the failure persisted. The vehicle was taken to a dealer where it was diagnosed and determined that the transmission had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but offered no assistance. The failure mileage was unknown.

  • Filed Mar 2022

    DEF tank heater short causes wiring harness to melt and fault on diesel trucks, enabling limp mode. Limp mode is dangerous when hauling trailers over long distances. Faulty part is on 6 month backorder. No reparations from GM.

• Hydraulic3

  • Filed Sep 2026

    The contact owns a 2020 Chevrolet Silverado 2500. The contact stated that the transmission shuddered and hesitated while driving 55 MPH or at higher speed. The vehicle was taken to the dealer; however, the dealer was no longer in business. While driving at various speeds, the lifters were squeaking. The vehicle was taken to a dealer and was diagnosed with lifters failure. The contact decided not to repair the vehicle. The manufacturer was informed of the failure. The failure mileage was approximately 170,000.

  • Filed Jan 2024

    The contact owns a 2020 Chevrolet Silverado 2500. The contact stated while driving at an undisclosed speed, the steering wheel briefly became tight before returning to normal functionality. After the failure, the temperature gauge indicated that the engine was overheating. The contact also stated that the brake pedal required excessive force to slow and bring the vehicle to a complete stop. No warning lights were illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the water pump. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was 74,000.

  • Filed May 2023

    The contact owns a 2020 Chevrolet Silverado 2500. The contact stated that the electronic parking brake warning light was illuminated. The vehicle was taken to the dealer, where it was diagnosed that the brake shoes within the rear drum needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and a case was opened. The failure mileage was approximately 48,000.

• Fuel System3

  1 involved a fire

  • Filed Feb 2025

    The contact owns a 2020 Chevrolet Silverado. The contact stated that while attempting to remote start the vehicle, the vehicle failed to start. The contact was able to manually start the vehicle however, the message "Service Emissions System - Speed Limited to 65 MPH" was displayed. The contact stated while driving approximately 25 MPH, the "Check Engine” and “Speed Limit 65 MPH" messages were displayed. The contact heard an abnormal sound like air coming from the rear of the vehicle. The contact stated there was thick black smoke coming from the exhaust pipe. The contact returned to the residence. The contact had not taken the vehicle to the dealer or independent mechanic. The vehicle was not diagnosed. The contact had used a handheld scanner and became aware that the Reductant Heater circuits 1, 2, and 3 had short-circuited. The contact checked and observed that the wiring harness located under the vehicle near the fuel tank and the Diesel Exhaust Fluid (DEF) tank had melted. The vehicle was not repaired. The contact had researched online and related the failure to Technical Service Bulletin Number: N202300791 - Service Update Diesel Exhaust Fluid System (Fuel System, Diesel). The manufacturer was informed of the failure. The failure mileage was approximately 131,000.

  • Filed Nov 2023

    The contact owns a 2020 Chevrolet Silverado 2500. The contact stated that on several occasions while driving at various speeds, the vehicle started to lose motive power and then stalled. The contact stated that on most occasions, the vehicle was restarted after one attempt. The vehicle was taken to three different dealers on several occasions however, the failure could not be duplicated. The vehicle was then towed to a dealer where it was diagnosed that the Fuel Pump Driver Module needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 15,000.

  • Filed Feb 2022

    The contact owns a 2020 Chevrolet Silverado 2500 HD. The contact stated that while driving at 50 MPH, a warning alarm engaged and advised that there was an emission system issue and the vehicle needed to be serviced within 160 miles. The transmission warning light illuminated. The contact stated that she parked at some point to run an errand and upon restarting the vehicle, a death issue system alarm engaged indicating that the vehicle needed to be repaired within 90 miles. The vehicle was taken to the local dealer where the failure was diagnosed as a dead issue and one of the pins on the wiring harness had burnt and was starting to melt. The local dealer informed the contact that the death tank and wiring harness needed to be replaced; however, the parts for the repair were not available the vehicle was not drivable. The vehicle was not repaired. The manufacturer was notified of the failure and advised the contact the parts for the repair were not available. The vehicle was not repaired. The failure mileage was approximately 20,000.

• Latches/Locks/Linkages2

  • Filed Aug 2026

    The contact owns a 2020 Chevrolet Silverado 2500. The contact stated that while driving at an undisclosed speed, the tailgate independently opened. The contact associated the failure with NHTSA Campaign Number: 24V060000 (Latches/Locks/Linkages); however, the VIN was not included in the recall. The dealer was contacted, but the vehicle was not diagnosed or repaired because the VIN was not included in the recall. The manufacturer was not notified of the failure. The failure mileage was approximately 118,000.

  • Filed Mar 2026

    The contact owns a 2020 Chevrolet Silverado 2500. The contact stated that while driving at an undisclosed speed, the tailgate opened unexpectedly and was crushed by an attached trailer. The vehicle was taken to a dealer, where it was diagnosed and associated with NHTSA Campaign Number: 24V060000 (Latches/Locks/Linkages); however, the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 99,600.

• Exterior Lighting2

  • Filed Mar 2026

    This vehicle does not recognize that the gear is on park. Due to the issue, it has left me stranded twice. The first time it was at a very remote area up in the mountains. I was stuck for hours due to battery dying. The second time being a very dangerous situation Because it was a very dangerous area late at night.

  • Filed Dec 2020

    I WAS DRIVING IN A SNOW STORM AND THE HEADLIGHTS PACKED IN VERY THICKLY WITH HEAVY WET SLUSHY SNOW AND NO LIGHT WENT THROUGH AND I COULD NOT SEE THE ROAD. THE HEADLIGHT LENS AND THE SURROUNDING TRIM FORM A V-SHAPED TROUGH AROUND THE LIGHT THAT DOESN'T ALLOW THE SNOW TO SLIDE OFF FROM WIND AND BUMPS. THE SHAPE ACTUALLY ENCOURAGED SNOW TO ACCUMULATE AND COVER THE ENTIRE LENS AND THE LED LIGHTS RUN SO COOL THEY DON'T CAUSE ANY SNOW TO MELT. I HAD TO PULL OFF THE ROAD AND CLEAN THE HEADLIGHTS MANUALLY TWICE DURING A 26 MILE TRIP.

• Diesel2

  1 involved a fire

  • Filed Feb 2025

    The contact owns a 2020 Chevrolet Silverado. The contact stated that while attempting to remote start the vehicle, the vehicle failed to start. The contact was able to manually start the vehicle however, the message "Service Emissions System - Speed Limited to 65 MPH" was displayed. The contact stated while driving approximately 25 MPH, the "Check Engine” and “Speed Limit 65 MPH" messages were displayed. The contact heard an abnormal sound like air coming from the rear of the vehicle. The contact stated there was thick black smoke coming from the exhaust pipe. The contact returned to the residence. The contact had not taken the vehicle to the dealer or independent mechanic. The vehicle was not diagnosed. The contact had used a handheld scanner and became aware that the Reductant Heater circuits 1, 2, and 3 had short-circuited. The contact checked and observed that the wiring harness located under the vehicle near the fuel tank and the Diesel Exhaust Fluid (DEF) tank had melted. The vehicle was not repaired. The contact had researched online and related the failure to Technical Service Bulletin Number: N202300791 - Service Update Diesel Exhaust Fluid System (Fuel System, Diesel). The manufacturer was informed of the failure. The failure mileage was approximately 131,000.

  • Filed Feb 2022

    The contact owns a 2020 Chevrolet Silverado 2500 HD. The contact stated that while driving at 50 MPH, a warning alarm engaged and advised that there was an emission system issue and the vehicle needed to be serviced within 160 miles. The transmission warning light illuminated. The contact stated that she parked at some point to run an errand and upon restarting the vehicle, a death issue system alarm engaged indicating that the vehicle needed to be repaired within 90 miles. The vehicle was taken to the local dealer where the failure was diagnosed as a dead issue and one of the pins on the wiring harness had burnt and was starting to melt. The local dealer informed the contact that the death tank and wiring harness needed to be replaced; however, the parts for the repair were not available the vehicle was not drivable. The vehicle was not repaired. The manufacturer was notified of the failure and advised the contact the parts for the repair were not available. The vehicle was not repaired. The failure mileage was approximately 20,000.

• Forward Collision Avoidance1

  • Filed Mar 2026

    This vehicle does not recognize that the gear is on park. Due to the issue, it has left me stranded twice. The first time it was at a very remote area up in the mountains. I was stuck for hours due to battery dying. The second time being a very dangerous situation Because it was a very dangerous area late at night.

• Suspension1

  • Filed Sep 2025

    I just financing this car and dealer write on dmv price of $57,057 with 63,631 miles that the tell me that was a pre contract on 9/13/24 then they then the bring the truck on 9/15/2025 with 64156 miles at the price of 61,777 on the contract i dont know what to do

• Visibility/Wiper1

  • Filed Feb 2024

    Rear window frame is leaking during rain or heavy dew. Causing saturated headliner, seats and carpet. Mold could develop and become a health factor. My 2 kids always ride in the back seat. This is a known issue for GM and are not taking action to correct this problem. Vehicle started leaking with 25,000 miles.

• Seats1

  • Filed Jan 2024

    This manual seat does not have an adjustment for up and down. Short people can not adjust to see over the hood when driving. Their solution is to sit on a cushion. This makes the seatbelt fit wrong and you slide around on the seat. This is a safety hazard with no solution. The “kits” you buy then make the seat a risk to disconnect from the truck.

• Gasoline1

  • Filed Nov 2023

    The contact owns a 2020 Chevrolet Silverado 2500. The contact stated that on several occasions while driving at various speeds, the vehicle started to lose motive power and then stalled. The contact stated that on most occasions, the vehicle was restarted after one attempt. The vehicle was taken to three different dealers on several occasions however, the failure could not be duplicated. The vehicle was then towed to a dealer where it was diagnosed that the Fuel Pump Driver Module needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 15,000.

• Wheels1

  • Filed Jul 2023

    Numerous times since first taking possession of new vehicle trucks electronic emergency braking system has activated while driving all on its own without warning. several times while on slower side roads and several times while at Interstate speeds, twice coming very close to a head on collision and once coming close to being rear ended while towing a car on a trailer by a semitrailer. The last time there was a message on the drivers information center that stated "service parking brake" The truck has been out of service use to several dealers to diagnose the problem to no avail. I've explained to the dealers its like having a blown tire, you can't predict when it will happen. Its a very dangerous situation. Second the goodyear wrangler tires tend to slide on curves in wet weather. This happens whenever the road is wet and you are on a curve. Both these defects have been reported to the manufacturer as well as servicing dealers. Very dangerous truck.

• Back Over Prevention1

  • Filed Apr 2021

    TL* THE CONTACT OWNS A 2020 CHEVROLET SILVERADO 2500. THE CONTACT STATED THAT THE REAR BACK UP CAMERA FAILED TO OPERATE AS NEEDED WHILE DRIVING OVER A BUMP. THERE WAS NO WARNING LIGHT ILLUMINATED. THE CONTACT SPOKE WITH RESSLER CHEVROLET (8474 HUFFINE LN, BOZEMAN, MT 59718) WHERE HE WAS INFORMED THAT THERE WAS NO FIX FOR THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND A CASE WAS FILED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN.

• Air Bags1

  1 involved a crash

  • Filed Nov 2020

    FOLLOWING A VEHICLE WITH 4-5 CAR LENGTHS BETWEEN, THE VEHICLE IN FRONT OF US DID A PANIC STOP IN HEAVY TRAFFIC. WHEN TRYING TO STOP OUR NEW TRUCK AL IT DID WAS SKID WITHOUT ANY NOTICEABLE ABS ACTIONS. WE WERE TRAVELING APPROXIMATELY 65MPH AT THE TIME OF THE PANIC STOP. TRUCK ONLY HAD 4000 MILES ON IT AT THE TIME OF THE ACCIDENT. ROADS WERE DRY.

Safety ratings

NHTSA 5-Star Safety Ratings from government crash tests. Ratings can differ by cab style and 2WD/4WD.

NHTSA hasn't published star ratings for this truck. Many heavy-duty pickups aren't included in NHTSA's crash-test program, so this doesn't mean the truck is unsafe.