2018 Chevrolet Silverado 2500HD

What owners should know

Covers 2015–2019 · 6.6L Duramax diesel (LML 2015–2016, L5P 2017–2019) and 6.0L V8 gas · Updated 2026-10-01

Researched from owner forums and NHTSA complaints and written by Know Your Truck. These are patterns in what owners report, not a guarantee about any particular truck.

Common failures & how to fix them

Parts and video buttons search for your 2018 Chevrolet Silverado 2500HD. Always confirm a part fits using your VIN. Brakes, steering, fuel and airbag work affects your safety, so if you're not sure, have a qualified mechanic do it.

• 2015–2016 Duramax fuel pump (CP4) failure

  Best left to a shop

  Signs: Sudden stalling or no-start, low fuel pressure codes such as P0087.

  Fix: Prevention: change the fuel filter on schedule and buy fuel from busy stations. Some owners replace the CP4 with a different pump design as prevention. A failed pump usually means a full fuel system replacement at a diesel shop.

  Shop: Duramax fuel filterShop: Duramax CP3 conversion kit▶ How-to videos

• Loose brake pedal (2015–2016)

  Dealer (recall)

  Signs: The brake pedal feels loose or doesn't work right.

  Fix: Covered by GM recalls for the brake pedal pivot nut.

  May be covered free by recall 16V069000 / 18V578000. Check the VIN at nhtsa.gov/recalls.

• Block heater cord fire risk (2017–2019 diesels)

  Dealer (recall)

  Signs: A burnt or melted block heater cord or plug.

  Fix: Covered by GM recalls. Don't use the block heater until it's checked.

  May be covered free by recall 19V328000 / 21V496000. Check the VIN at nhtsa.gov/recalls.

• 'Service trailer brake system' warning

  Easy DIY

  Signs: Trailer brake warnings that cut the trailer brakes while towing.

  Fix: Start with the simple things: clean and inspect the 7-pin trailer connector and the trailer's wiring. If it continues, have a dealer check the trailer brake module.

  Shop: 7 pin trailer connector▶ How-to videos

• L5P cracked intercooler pipe

  Easy DIY

  Signs: A loud pop, then low power and limp mode.

  Fix: Replace the plastic charge pipe. Many owners upgrade to a metal pipe.

  Shop: L5P Duramax intercooler pipe▶ How-to videos

Recalls

A recall doesn't mean a truck still has the problem. Enter the truck's VIN at nhtsa.gov/recalls or ask a dealer to see whether the repair was done.

• Air Bags:Side/Window:Curtain:Inflator

  Oct 2024 · #24V756000

  General Motors, LLC (GM) is recalling certain 2018 Chevrolet Silverado 1500, GMC Sierra 1500, 2018-2019 Chevrolet Silverado 2500, 3500, and GMC Sierra 2500, 3500 Crew Cab trucks. The left or right-side roof-rail air bag (RRAB) inflator end cap may detach from the inflator or the inflator sidewall may rupture.

  Risk and fix

  Risk: A separated inflator end cap or inflator rupture can allow compressed gas to escape, resulting in the end cap or other components being propelled into the vehicle, increasing the risk of injury or crash.

  Fix: Dealers will replace the left and right side RRAB modules, free of charge. Owner notification letters were mailed November 8, 2024. Owners may contact Chevrolet customer service at 1-800-222-1020, and GMC Customer Service at 888-988-7267. GM's number for this recall is N242474500.

• Fuel System, Diesel:Storage:Tank Assembly

  Feb 2023 · #23V047000

  General Motors, LLC (GM) is recalling certain 2017-2019 Chevrolet Silverado 2500, 3500, and GMC Sierra 2500, 3500 vehicles equipped with a dual fuel tank option. The rear fuel tank may collapse and prevent the fuel pump from transferring fuel to the front tank, resulting in an engine stall.

  Risk and fix

  Risk: An engine stall increases the risk of a crash.

  Fix: Dealers will inspect the fuel tank and fuel pump module, replacing them as necessary. Dealers will also add a vent hose to the rear tank assembly. Repairs will be performed free of charge. An interim owner notification letter informing owners of the safety risk was mailed on March 15, 2023. Owner notification letters were mailed June 21, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is N222368030.

• Equipment:Electrical:Engine Block Heater

  Jul 2021 · #21V496000

  General Motors, LLC (GM) is recalling certain 2017-2019 Chevrolet Silverado 2500, 3500 and 2017-2019 GMC Sierra 2500 and 3500 vehicles equipped with a Duramax diesel 6.6 liter engine and an optional engine-block heater cord. An electrical short-circuit may occur in the engine-block heater cable or in the terminals that connect the heater cable to the block heater.

  Risk and fix

  Risk: An electrical short-circuit can increase the risk of a fire.

  Fix: Dealers will replace engine block heaters and heater cords. Vehicles that have this feature disabled as a remedy to the safety condition will be contacted and offered replacement block heaters and heater cords under a separate customer satisfaction program, free of charge. GM will provide free replacement block heaters and cords under a separate customer satisfaction campaign. For vehicles previously included in recall 19V-328, the heater cord will be replaced and rerouted, free of charge. Interim owner notifications were mailed on August 13, 2021. Owner notification letters are expected to be mailed on April 4, 2022. Customers may call GMC customer service at 1-800-462-8782. GM's number for this recall is 212329840.

• Engine

  Apr 2019 · #19V328000

  General Motors LLC (GM) is recalling certain 2019 Chevrolet Silverado 4500, 5500 and 6500 vehicles and 2017-2019 Chevrolet Silverado 2500 and 3500 vehicles and GMC Sierra 2500 and 3500 vehicles equipped with Duramax 6.6 liter diesel engines and an optional engine-block heater. The engine block heater cord or the terminals that connect the heater cord to the block heater may short circuit and fail.

  Risk and fix

  Risk: A short-circuit may damage the engine components and increase the risk of fire.

  Fix: GM will contact owners, dealers will replace the engine block heater, free of charge. Additionally, in Chevrolet Silverado 2500 and 3500 vehicles, dealers will install a new rerouted heater cord. The recall began December 11, 2019. Owners may contact GM customer service at 1-586-596-1733. GM's number for this recall is N182206310.

• Seat Belts:Front:Retractor

  Sep 2017 · #17V567000

  General Motors (GM) is recalling certain 2017-2018 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 trucks. The front seat belt retractor assemblies were built with the incorrect torsion bar. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 209, "Seat Belt Assemblies."

  Risk and fix

  Risk: The seat belt retractors may not perform as intended during a crash, increasing the risk of injury.

  Fix: GM will notify owners, and dealers will replace both front seat belt retractor assemblies, free of charge. The recall began March 24, 2021. Owners may contact GMC customer service at 1-888-988-7267 or Chevrolet customer service at 1-800-222-1020. GM's numbers for this recall are 17368, 17375, and 17376.

Owner complaints by area

Reports owners filed with NHTSA. They aren't verified, and one complaint can mention more than one area. Tap an area to read the most recent ones.

• Electrical System13

  1 involved a fire

  • Filed Feb 2026

    Rear defroster seemed to short circuit and over heated causing my back window to break. There was no warning, no light that alerted me to this going on. I had it inspected by a local Chevy dealership and they have indeed confirmed that it short circuited and caused the damage to my rear window. They also removed the fuse to prevent anything further from happening and told me it could have completely caught on fire.

  • Filed Dec 2025

    Odometer Fraud. The contact purchased a 2018 Chevrolet Silverado 2500. The contact discovered a mileage discrepancy after the purchase. The vehicle was a private sale. At the time of purchase, the vehicle mileage was 92,985. While attempting to register the vehicle, it was discovered that the title mileage was approximately 215,000.

  • Filed Oct 2025

    Odometer Fraud. The contact purchased a 2018 Chevrolet Silverado 2500. The contact stated that while having a State Emissions Test performed on the vehicle, it was discovered that there was a mileage discrepancy. The vehicle was a private sale. At the time of purchase, the mileage was 75,200; however, it was discovered that on January 17,2024, the mileage was 265,005.

  • Filed Dec 2024

    Dash Warning: Check Engine Light, "Engine Power is Reduced!" and Traction Control. Code Reader Results: P2138 (APP) Accelerator Pedal Position Sensors - Not Plausible. Replaced with NEW OEM Part(s) - APP, Electrical Throttle Body and M15 Fuse - which did NOT fix issues and now due to safety concerns (further damage to vehicle and personal preservation) will be towing to dealership for diagnosis. Believe to be a known WIRING issues most likely due to WATER exposure/ SHORT in Connectors. - See IP, ECM/PCM and possible false activation to the APP circuit. This should be a RECALL due to the severity of mechanical issues of the malfunctioning system.

  • Filed Nov 2024

    while driving i smelled burning electrical somewhere in the cab. looking in the rearview mirror i saw smoke ciming from the corner of the sliding rear window. i pulled over and opened my rear door and heard a crack type noise. the smoke stopped and the drivers side rear window was shattered. upon researching the issue i found a recall was done in canada and not in the usa .

  • Showing the 5 most recent of 13.
• Engine12

  1 involved a fire

  • Filed Jun 2026

    2018 Chevy Silverado 2500Diesel Duramax (63,000 miles & Garage kept) While pulling 37' camper on flat terrain, Push Rod bent and broke in half - violently shaking and missing; Engine was ruined. Engine light did not appear until after it started shaking. Luckily this happened before crossing over steep mountain where we would not have been able to get off road or control vehicle and camper behind us. Truck was towed to Chevy dealership; had to wait until 10 days to learn extent of damage. Repair cost was going to be $26,000 and though our truck's trade in value was $37000 before this event, we were offered just $12000 for trade in. Though we had been led to believe that a Chevy Duramax was highly regarded for durability and longevity, we decided to purchase a RAM Truck. NO MORE CHEVYS for us! Contacted Chevy Customer Assistance but because we traded, they would not offer any financial assistance because we took the dealership's offer and traded the next day. We just couldn't stand a $26000 hit on an 8 year old vehicle and had to absorb that amount with our trade in.

  • Filed Dec 2022

    The contact owns a 2018 Chevrolet Silverado 2500. The contact stated that while driving at various speeds, the vehicle lost motive power and stalled without warning. The contact took the vehicle to the dealer however, the mechanic was unable to determine the cause of the failure. The dealer replaced the negative battery cable; however, the failure persisted. The manufacturer was notified of the failure and a case was filed. The vehicle was not repaired. The failure mileage was approximately 36,000.

  • Filed Feb 2020

    TL* THE CONTACT OWNS A 2018 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHILE DRIVING AT UNDISCLOSED SPEEDS OR WHILE AT IDLE, THERE WAS AN ABNORMAL SOUND COMING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO MANKATO MOTORS LOCATED AT 1815 MADISON AVE, MANKATO, MN 56001, WHO INFORMED THAT CONTACT THAT THE SOUND WAS NORMAL WHILE THE VEHICLE WAS IN OPERATION. THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 23,277.

  • Filed Feb 2020

    THE CHECK ENGINE LIGHT COMES ON AT 27600 MILES WHILE DRIVING AND THIS NOT 1ST TIME THIS HAS HAPPEND .ONCE THE ENGINE LIGHT IS ON THE TRUCK THEN LOSES POWER DETUNNING THE VEHICLE CAUSING THE VEHICLES POWER TO NOT BE AS STRONG AS IF ENGINE IS IN LIMP MODE.AT 24000 MILE TRUCK WENT INTO SHOP FOR SAME ISSUE AND GM REPLACE ALL INJECTORS HOPING THIS WOULD BE THE FIX ..PRIOR TO 24000 MILES AT 23600 MILE 1 INJECTOR WAS REPLACE .I HAVE NOW PLACED 3600 MILES DRIVEN BEFORE LIGHT DECIDED TO COME BACK ON WITH ALL INJECTORS REPLACED AND NOW CODES P1089 ,AND NOW MY TRUCK IS SHOW NUMBER OF CODES INCLUDING B1011 , B1325 AND U0164 BOTH THIS TRUCK WITH JUST SHY 21000 MILE AND START TO WONDER WHY LAST CUSTOMER MAY HAVE TRADED HIS SELF

  • Filed Feb 2020

    TL* THE CONTACT OWNS A 2018 CHEVROLET SILVERADO HD. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 19V328000 (ENGINE) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT CALLED AUTONATION CHEVROLET SPOKANE VALLEY 8500 E SPRAGUE AVE, SPOKANE VALLEY, WA 99212 509) 720-8905, BUT WAS NOT REPAIRED. THE CONTACT HAD NOT EXPERIENCE A FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. PARTS DISTRIBUTION DISCONNECT.

  • Showing the 5 most recent of 12.
• Fuel/Propulsion System9

  1 involved a fire

  • Filed May 2026

    The truck kept going into limp mode and when taken to the dealership it was found to have metal in the fuel. According to the report from the dealership they stated that this indicated the injection pump had come apart internally and sent metal throughout the system. It has since been repaired at a high cost to myself. The generation of truck made before mine had a recall for the same thing and I feel that they have not fixed the problem or it wouldn't have happened to my truck. Seems like a manufacturing defect. When in limp mode the truck does not operate at the speed limit required for highway driving. There was no indication prior to the failure.

  • Filed Jun 2025

    2 low pressure fuel pumps have failed. truck stalls in traffic. currently in show with extremely large bill for repair.

  • Filed May 2025

    Driving down the road in heavy traffic and had complete engine failure due to loss of fuel. Diagnosed as fuel control module. I have seen where GM recalls have been made for similar issues. This put me in danger of collision. Truck is at the dealer and will cost $957.00

  • Filed Dec 2024

    Dash Warning: Check Engine Light, "Engine Power is Reduced!" and Traction Control. Code Reader Results: P2138 (APP) Accelerator Pedal Position Sensors - Not Plausible. Replaced with NEW OEM Part(s) - APP, Electrical Throttle Body and M15 Fuse - which did NOT fix issues and now due to safety concerns (further damage to vehicle and personal preservation) will be towing to dealership for diagnosis. Believe to be a known WIRING issues most likely due to WATER exposure/ SHORT in Connectors. - See IP, ECM/PCM and possible false activation to the APP circuit. This should be a RECALL due to the severity of mechanical issues of the malfunctioning system.

  • Filed Nov 2024

    Vehicle stalled then would not start

  • Showing the 5 most recent of 9.
• Air Bags6

  2 involved a crash

  • Filed Jul 2026

    Vehicle displays airbag deployment codes, airbag sound was heard, airbag agent smell is present yet no airbags were deployed in the vehicle. Yes it is available for inspection on request, it will be inspected by insurance adjusters in the next week.

  • Filed Jun 2026

    Frontal driver airbag deployed spontaneously while vehicle was stopped at a stop sign. No collision or impact occurred. Deployment produced excessive smoke and heat. Minor burn to hand resulted from deployment.

  • Filed Aug 2024

    The contact owns a 2018 Chevrolet Silverado 2500. The contact stated that while the vehicle was turned off and parked in the driveway, the contact heard a loud explosion. Upon inspection, it was discovered that the rear passenger’s side side-curtain air bag erroneously deployed. The cause of the failure was not yet determined. The contact stated that during the failure, shrapnel and shards of metal pierced the roof and caused multiple holes in the roof of the vehicle. The local dealer was notified of the failure. The manufacturer was not yet contacted. The failure mileage was 72,500.

  • Filed Oct 2022

    The contact's wife owns a 2018 Chevrolet Silverado 2500. The contact stated that while his wife was driving at 45 MPH, she crashed into another vehicle in an intersection. The air bags did not deploy upon impact. The contact was taken to the hospital by ambulance and was treated for pain on both sides of his ribs. The contact's wife did not sustain any injuries. The whereabouts of the other driver were unknown. A police report was filed. The vehicle was towed to an independent mechanic where it remained in their possession. The dealer nor the manufacturer had yet to be notified of the failure. The vehicle had yet to be respired. The failure mileage was approximately 44,000. The VIN was not available. The consumer stated the vehicle was totaled.

  • Filed Mar 2020

    THERE IS NO PASSENGER SEAT BELT WARNING AUDIO OR VISUAL. THE DEALER SAID THAT THIS VEHICLE DOESN'T HAVE A SENSOR TO TELL IF SOMEONE IS IN THE SEAT OR NOT. BUT THEY "ASSURED" ME THAT THE PASSENGER AIR BAGS STILL WOULD WORK. EVEN THOUGH IT HAS BEEN SHOWN THAT AIR BAGS BY THEM SELVES ARE NOT AS EFFECTIVE. I READ THAT CHEVROLET OFFERED TO INSTALL AN ON OFF SWITCH FOR THE AIR BAGS, THE WRONG THING TO DO IN MY OPINION. THE SEAT BELT WARNING SYSTEM SHOULD BE A REQUIREMENT NOT AN OPTION.

  • Showing the 5 most recent of 6.
• Power Train6

  • Filed Jun 2026

    2018 Chevy Silverado 2500Diesel Duramax (63,000 miles & Garage kept) While pulling 37' camper on flat terrain, Push Rod bent and broke in half - violently shaking and missing; Engine was ruined. Engine light did not appear until after it started shaking. Luckily this happened before crossing over steep mountain where we would not have been able to get off road or control vehicle and camper behind us. Truck was towed to Chevy dealership; had to wait until 10 days to learn extent of damage. Repair cost was going to be $26,000 and though our truck's trade in value was $37000 before this event, we were offered just $12000 for trade in. Though we had been led to believe that a Chevy Duramax was highly regarded for durability and longevity, we decided to purchase a RAM Truck. NO MORE CHEVYS for us! Contacted Chevy Customer Assistance but because we traded, they would not offer any financial assistance because we took the dealership's offer and traded the next day. We just couldn't stand a $26000 hit on an 8 year old vehicle and had to absorb that amount with our trade in.

  • Filed May 2025

    70,000 mile complete transmission failure despite being serviced on-time, as per the guidance. Failure happened while driving and it became dangerous to try to maintain highway speed. Quoted $8390 to replace by the local Chevy dealership and quoted 4-6 weeks delivery for backordered parts. This is an unacceptable situation that GM and other manufacturers have artificially manufactured. They design everything to the bare minimum to save fractions of a cent per part, and then they intentionally make the parts unavailable and then the dealership pushes you to trade the broken vehicle in at a massive loss just so you can get back on the road in a newer, more expensive vehicle. This sort of behavior is causing immense financial harm to American families.

  • Filed Oct 2024

    While hauling a trailer I received a warning tone and looked down to read the message, "reduced engine power", and the service engine light appeared all at the same time. The engine shutoff at the same time I received the warnings and didn't allow me to safely pull off the road.. I lost power steering, power braking, and controlling the vehicle and trailer while coasting to the sholder was difficult. Fortunately it was early in the morning and I was only traveling 35 mph on a straight road, and no other vehicles were on the road. If I was on an interstate traveling 55+ mph or on a curvy road it would have caused an accident or worse. I was very fortunate. This was the first time I experienced this problem and hadn't received prior warning messages or lights. The truck would not restart and the truck and trailer were towed to the dealership. The diagnosis was a failed "Fuel Pump Control Module." After waiting several weeks the replacement Fuel Pump Control Module did solved the problem. I kept the failed Fuel Pump Control Module and is available for inspection. Please investigate thoroughly! I was extremely fortunate the part failed when it did and I was able to walk away unharmed.

  • Filed Jun 2020

    VIBRATIONS AT 65-85 MPH. TRUCK SHAKES SO BAD IT'S UNSAFE TO DRIVE. *TR

  • Filed Feb 2020

    THE CHECK ENGINE LIGHT COMES ON AT 27600 MILES WHILE DRIVING AND THIS NOT 1ST TIME THIS HAS HAPPEND .ONCE THE ENGINE LIGHT IS ON THE TRUCK THEN LOSES POWER DETUNNING THE VEHICLE CAUSING THE VEHICLES POWER TO NOT BE AS STRONG AS IF ENGINE IS IN LIMP MODE.AT 24000 MILE TRUCK WENT INTO SHOP FOR SAME ISSUE AND GM REPLACE ALL INJECTORS HOPING THIS WOULD BE THE FIX ..PRIOR TO 24000 MILES AT 23600 MILE 1 INJECTOR WAS REPLACE .I HAVE NOW PLACED 3600 MILES DRIVEN BEFORE LIGHT DECIDED TO COME BACK ON WITH ALL INJECTORS REPLACED AND NOW CODES P1089 ,AND NOW MY TRUCK IS SHOW NUMBER OF CODES INCLUDING B1011 , B1325 AND U0164 BOTH THIS TRUCK WITH JUST SHY 21000 MILE AND START TO WONDER WHY LAST CUSTOMER MAY HAVE TRADED HIS SELF

  • Showing the 5 most recent of 6.
• Unknown or Other6

  1 involved a fire

  • Filed Dec 2024

    Reductant heater fault

  • Filed Nov 2024

    while driving i smelled burning electrical somewhere in the cab. looking in the rearview mirror i saw smoke ciming from the corner of the sliding rear window. i pulled over and opened my rear door and heard a crack type noise. the smoke stopped and the drivers side rear window was shattered. upon researching the issue i found a recall was done in canada and not in the usa .

  • Filed Jul 2024

    For the last year the vehicle has been in the shop at the dealer for a rancid chemical smell in the cab of the truck that causes a burning to the eyes and lungs. It gets worse when it's hot outside. The smell is there even when the vehicle is not running. The dealer cannot find the source of the smell and has turned the vehicle back over to us with no solution. It feels unsafe and is extremely uncomfortable to drive in with burning eyes and breathing issues.

  • Filed Jun 2020

    VIBRATIONS AT 65-85 MPH. TRUCK SHAKES SO BAD IT'S UNSAFE TO DRIVE. *TR

  • Filed Feb 2019

    MON OCT 8TH, 5PM, MY CHEVY SILVERADO 2500HD DIESEL TRUCK CAUGHT FIRE DRIVING DOWN A CITY ROAD(APPROXIMATELY 30MPH), WITH ME, MY 12YO DAUGHTER AND HER FRIEND IN IT. THE ENGINE DIED, AND I LOST POWER STEERING AND BRAKES. AFTER WRESTLING THE TRUCK TO THE SIDE FO THE ROAD, A PASSERBY DROVE BACKWARDS IN TRAFFIC TO ALERT ME THAT THE TRUCK WAS BURNING. IF NOT FOR HIM, WE MIGHT NOT HAVE GOTTEN OUT IN TIME. FLAMING FUEL WAS DRIPPING DOWN FROM IN THE CHASSIS, DRIVER SIDE, IN FRONT OF REAR WHEEL, APPROXIMATELY WHERE THE FUELING RECEPTACLE WAS. THE POOL OF BURNING FUEL ON THE GROUND COULD NOT BE EXTINGUISHED. A PASSERBY EMPTIED A 15LB FIRE EXTINGUISHER ONTO THE AREA, AND WAS NOT ABLE TO STOP THE FLAMING LEAKING FUEL. BY NOW, IT WAS LEAKING WITH THE INTENSITY OF A SMALL SHOWER HEAD. THE ENTIRE TRUCK BURNED TO THE GROUND RAPIDLY. THE TRUCK WAS TWO WEEKS OLD, WITH LESS THAN 1000 MILES. IT WAS UNMODIFIED. GM, CHEVROLET, AND WESELOH CHEVROLET WERE UTTERLY UNCONCERNED, AND UNMOVED BY THIS DISASTER. THEY TREATED THE INCIDENT AS IF I HAD WRONGLY COMPLAINED THAT THE FLOOR MATS DIDN'T FIT CORRECTLY. YOU CAN FIND A DETAILED DESCRIPTION OF WHAT HAPPENED HERE: HTTPS://BIT.LY/2XFBYEB

  • Showing the 5 most recent of 6.
• Exterior Lighting4

  • Filed Aug 2025

    tail light assembly falls out of the truck body due to faulty bolt connections that fail ( crumble and break off) due to heat from parking in the sun

  • Filed Dec 2023

    Dashboard lights and audio system shut off randomly for one second while driving, and then turned back on. when shutting the truck off, all power was lost for one second

  • Filed Feb 2020

    BRIGHTNESS LEVEL FOR THE CENTER CONSOLE DISPLAY (RADIO, CLIMATE CONTROLS) CANNOT BE DIMMED. WHEN ADJUSTING THE VOLUME, CHANGING AIRFLOW, TUNING RADIO ETC, A BANNER IS DISPLAYED ALONG THE TOP OF THE SCREEN THAT IS SO BRIGHT IT IS ALMOST BLINDING AT NIGHT. IT SIGNIFICANTLY IMPAIRS NIGHT VISION. THERE NEEDS TO BE A DIMMING OPTION. THE BANNER IS THE SAME BRIGHTNESS REGARDLESS OF SPEED OR TIME OF DAY. CHEVY 2500 SILVERADO WT.

  • Filed Feb 2019

    WHEN IN DRIVE ENTERING AN INCLINE THE ENGINE WILL LURCH TO A HIGHER GEAR. ALSO WHEN DRIVING THE LIGHT IN THE FRONT PANEL WILL GO DARK. CAN NOT READ SPEED, TACK, GAS LEVEL ALL BLACK. ( FOR 30 SEC, 45 SEC THEN FOR AN HOUR AND A HALF) ALSO THE AIR-CONDITIONING WILL TURN ON AUTOMATICALLY WITHOUT ME TURNING IT ON AND NO INDICATOR IT IS ON. THEN LATER THE AIR-CONDITIONING INDICATOR LIGHT WILL TURN ON . STILL WITHOUT ME TURNING ON THE AIR-CONDITIONING. AT ALL TIMES TRUCK WAS IN MOTION ON STREET OR HIGHWAY.

• Equipment3

  • Filed Apr 2022

    The contact owns a 2018 Chevrolet Silverado 2500. The contact received notification of NHTSA Campaign Number: 21V496000 (Equipment) however, the part to do the recall repair was not yet available. The dealer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. Parts distribution disconnect.

  • Filed Mar 2022

    The contact owns a 2018 Chevrolet Silverado 2500. The contact received a notification for NHTSA Campaign Number: 21V496000 (Equipment) however, the part to do the recall repair was unavailable. The dealer had been notified of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the repair. The contact had not experienced a failure. VIN tool confirms parts not available.

  • Filed Jan 2022

    The contact owns a 2018 Chevrolet Silverado 2500. The contact received notification of NHTSA Campaign Number: 21V496000 (Equipment) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that he was informed that due to the vehicle being located in Florida where the vehicle was not prone to cold weather, he would not be receiving the repairs as a priority. The contact had not experienced a failure. VIN tool confirms parts not available.

• Steering2

  • Filed Sep 2026

    Description of Safety Defect: I purchased this 2018 Chevrolet Silverado 2500HD from Carvana. Within 14 days of vehicle delivery, an authorized, in-network warranty repair facility (Monro) diagnosed a critical safety defect in the steering linkage, identifying failed outer tie rod ends and a failed pitman arm. Carvana’s warranty administrator, SilverRock (Claim C102648992), acknowledged the structural steering failure by approving the pitman arm and idler arm replacement but explicitly denied the required tie rod ends, claiming "no failure." The vehicle has since been released back to me with the failed tie rod ends still installed. On this heavy-duty truck, the steering linkage has now deteriorated to a catastrophic failure point. With the truck parked on the ground, there is severe, excessive manual play allowing the front wheel to be physically shaken left-to-right by hand. The vehicle cannot be aligned, is structurally compromised, and is completely unsafe to operate on public roads due to the imminent risk of a total loss of steering control. Carvana and SilverRock delivered an unsafe vehicle that failed its structural inspection points, and subsequently refused to complete the safety-critical repair required under their mandatory 100-day limited warranty window, forcing a dangerous, heavy-duty vehicle back onto public roads.

  • Filed Mar 2025

    I’m have 1-2” dead space in steering. It is hard to stay in lane on highway as when a road dip takes extra movement keep straight. I was told this is normal but had dealer change steering box. Replacement helped a lot but truck is starting to get the 1-2” of play once again. Seems like similar issue to 2016 model year.

• Suspension2

  • Filed Sep 2026

    Description of Safety Defect: I purchased this 2018 Chevrolet Silverado 2500HD from Carvana. Within 14 days of vehicle delivery, an authorized, in-network warranty repair facility (Monro) diagnosed a critical safety defect in the steering linkage, identifying failed outer tie rod ends and a failed pitman arm. Carvana’s warranty administrator, SilverRock (Claim C102648992), acknowledged the structural steering failure by approving the pitman arm and idler arm replacement but explicitly denied the required tie rod ends, claiming "no failure." The vehicle has since been released back to me with the failed tie rod ends still installed. On this heavy-duty truck, the steering linkage has now deteriorated to a catastrophic failure point. With the truck parked on the ground, there is severe, excessive manual play allowing the front wheel to be physically shaken left-to-right by hand. The vehicle cannot be aligned, is structurally compromised, and is completely unsafe to operate on public roads due to the imminent risk of a total loss of steering control. Carvana and SilverRock delivered an unsafe vehicle that failed its structural inspection points, and subsequently refused to complete the safety-critical repair required under their mandatory 100-day limited warranty window, forcing a dangerous, heavy-duty vehicle back onto public roads.

  • Filed Jun 2020

    VIBRATIONS AT 65-85 MPH. TRUCK SHAKES SO BAD IT'S UNSAFE TO DRIVE. *TR

• Tires2

  • Filed Nov 2021

    While driving my vehicle I began to notice a severe shake. Upon pulling over I found the driver rear tire tread had separated and bulged to were the inner part of tread bulged about 12 inches long and approximately 2-3 inches higher than the rest of the tread. It happened a second time to the passenger rear tire in the same manner a little over 1000 miles later. Approximately 21,000 miles. Both times the vehicle shook violently. Each instance I had to purchase a new tire out of my pocket. Lt 265/60r20

  • Filed Jul 2021

    Goodyear Wrangler SR-A (LT265/60R-20) Experienced sudden and hard steering wheel shake at 35mph. Belt separated in tires causing bulging on the outside half of the tread on Driver Side Rear Tire. Cupping apparent prior to separation on all 4 tires. Tires were properly inflated and were still maintaining proper PSI after belt separation.

• Seat Belts2

  • Filed Mar 2020

    THERE IS NO PASSENGER SEAT BELT WARNING AUDIO OR VISUAL. THE DEALER SAID THAT THIS VEHICLE DOESN'T HAVE A SENSOR TO TELL IF SOMEONE IS IN THE SEAT OR NOT. BUT THEY "ASSURED" ME THAT THE PASSENGER AIR BAGS STILL WOULD WORK. EVEN THOUGH IT HAS BEEN SHOWN THAT AIR BAGS BY THEM SELVES ARE NOT AS EFFECTIVE. I READ THAT CHEVROLET OFFERED TO INSTALL AN ON OFF SWITCH FOR THE AIR BAGS, THE WRONG THING TO DO IN MY OPINION. THE SEAT BELT WARNING SYSTEM SHOULD BE A REQUIREMENT NOT AN OPTION.

  • Filed Jun 2019

    WHEN EVER THE VEHICLE IS IN MOTION. PASSENGER SEAT DOES NOT HAVE THE REMINDER OR WARNING SYSTEM TO ALERT THE OCCUPANT TO BUCKLE UP SHOULD THEY FORGET. MY DEALER STATES THE PASSENGER AIR BAG SYSTEM IS ACTIVE FULL TIME HOWEVER IT IS ONLY MARGINALLY EFFECTIVE SHOULD THE PASSENGER FAIL TO SECURE THEIR SEAT BELT. ADDITIONALLY, THERE IS NO DASH INDICATOR SHOWING THE PASSENGER SEAT BELT BUCLKE/NO-BUCKLE STATUS AS SHOWN ON PAGE 86 OF THE 2018 SILVERADO OWNERS MANUAL WHICH DISCUSSES THE PASSENGER SENSING SYSTEM AND AIRBAG STATUS INDICATOR WHICH IS NOT PRESENT IN THIS LINE OF VEHICLES. PAGE 145 OF THE 2018 SILVERADO OWNERS MANUAL STATES THERE "MAY" BE A REMINDER LIGHT NEAR THE AIRBAG STATUS INDICATOR WHICH IS NOT INSTALLED ON THIS LINE OF VEHICLES. VIEWING SIMILAR VEHICLES, THIS CONDITION IS PRESENT IN A MINIMUM OF MODEL YEARS 2017 THROUGH 2020 CHEVROLET AND GMC 2500/3500 HD CREW CAB VEHICLES. CONTACTED GENERAL MOTORS CUSTOMER SERVICE ON 4/10/2018 & 4/24/2018 FILED GM CASE [XXX]. GM REP CALLED BACK 4/30/2018 AND THEIR SOLUTION WAS TO HAVE MY DEALERSHIP INSTALL AN AIRBAG ON/OFF SWITCH TO DISABLE THE AIRBAG. NOT A SUITABLE RESOLUTION TO THIS SAFETY ISSUE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TT

• Wheels1

  • Filed Sep 2026

    Description of Safety Defect: I purchased this 2018 Chevrolet Silverado 2500HD from Carvana. Within 14 days of vehicle delivery, an authorized, in-network warranty repair facility (Monro) diagnosed a critical safety defect in the steering linkage, identifying failed outer tie rod ends and a failed pitman arm. Carvana’s warranty administrator, SilverRock (Claim C102648992), acknowledged the structural steering failure by approving the pitman arm and idler arm replacement but explicitly denied the required tie rod ends, claiming "no failure." The vehicle has since been released back to me with the failed tie rod ends still installed. On this heavy-duty truck, the steering linkage has now deteriorated to a catastrophic failure point. With the truck parked on the ground, there is severe, excessive manual play allowing the front wheel to be physically shaken left-to-right by hand. The vehicle cannot be aligned, is structurally compromised, and is completely unsafe to operate on public roads due to the imminent risk of a total loss of steering control. Carvana and SilverRock delivered an unsafe vehicle that failed its structural inspection points, and subsequently refused to complete the safety-critical repair required under their mandatory 100-day limited warranty window, forcing a dangerous, heavy-duty vehicle back onto public roads.

• Vehicle Speed Control1

  • Filed Dec 2024

    Dash Warning: Check Engine Light, "Engine Power is Reduced!" and Traction Control. Code Reader Results: P2138 (APP) Accelerator Pedal Position Sensors - Not Plausible. Replaced with NEW OEM Part(s) - APP, Electrical Throttle Body and M15 Fuse - which did NOT fix issues and now due to safety concerns (further damage to vehicle and personal preservation) will be towing to dealership for diagnosis. Believe to be a known WIRING issues most likely due to WATER exposure/ SHORT in Connectors. - See IP, ECM/PCM and possible false activation to the APP circuit. This should be a RECALL due to the severity of mechanical issues of the malfunctioning system.

• Visibility1

  • Filed Oct 2024

    The contact owns a 2018 GMC Sierra 2500. The contact stated that while the vehicle was parked with the engine idling for approximately ten minutes, the rear crew cab window suddenly shattered. During the failure, the rear window defroster was activated. The cause of the failure was not yet determined, and the vehicle was not repaired. The local dealer and manufacturer were notified of the failure. The failure mileage was 30,000.

• Engine And Engine Cooling1

  • Filed May 2023

    The contact's son owns a 2018 Chevrolet Silverado 2500. The contact stated that while driving at an undisclosed speed, the check engine and “Service Vehicle" messages was displayed. The vehicle was taken to a local dealer, where it was diagnosed that the diesel exhaust fluid (DEF) and catalytic converter needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 109,000. The VIN was not available.

• Service Brakes1

  • Filed Mar 2021

    TL* THE CONTACT OWNS A 2018 CHEVROLET SILVERADO 2500. THE CONTACT STATED THAT WHILE AT A COMPLETE STOP WITH THE BRAKE PEDAL ENGAGED, THE CONTACT FELT THAT THE BRAKES WAS DISENGAGING, CAUSING THE VEHICLE TO START MOVING FORWARD. THE CONTACT DEPRESSED THE BRAKE PEDAL WITH EXTRA FORCE TO KEEP THE VEHICLE FROM MOVING FORWARD. THE CONTACT STATED THAT THE BRAKE FAILURE WAS EXPERIENCED ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO RK CHEVROLET (2651 VIRGINIA BEACH BLVD, VIRGINIA BEACH, VA 23452, (757) 261-1661 TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE BRAKE MASTER CYLINDER WAS CONTAMINATED WITH POWER STEERING. THE VEHICLE WAS NOT REPAIRED. THE CONTACT ALSO WANTED IT NOTED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 19V645000 (SERVICE BRAKES, HYDRAULIC) NOR 20V603000 (SERVICE BRAKES, HYDRAULIC). THE MANUFACTURER WAS CONTACTED AND INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS 84,200.

• Hydraulic1

  • Filed Mar 2021

    TL* THE CONTACT OWNS A 2018 CHEVROLET SILVERADO 2500. THE CONTACT STATED THAT WHILE AT A COMPLETE STOP WITH THE BRAKE PEDAL ENGAGED, THE CONTACT FELT THAT THE BRAKES WAS DISENGAGING, CAUSING THE VEHICLE TO START MOVING FORWARD. THE CONTACT DEPRESSED THE BRAKE PEDAL WITH EXTRA FORCE TO KEEP THE VEHICLE FROM MOVING FORWARD. THE CONTACT STATED THAT THE BRAKE FAILURE WAS EXPERIENCED ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO RK CHEVROLET (2651 VIRGINIA BEACH BLVD, VIRGINIA BEACH, VA 23452, (757) 261-1661 TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE BRAKE MASTER CYLINDER WAS CONTAMINATED WITH POWER STEERING. THE VEHICLE WAS NOT REPAIRED. THE CONTACT ALSO WANTED IT NOTED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 19V645000 (SERVICE BRAKES, HYDRAULIC) NOR 20V603000 (SERVICE BRAKES, HYDRAULIC). THE MANUFACTURER WAS CONTACTED AND INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS 84,200.

• Seats1

  • Filed Jun 2019

    WHEN EVER THE VEHICLE IS IN MOTION. PASSENGER SEAT DOES NOT HAVE THE REMINDER OR WARNING SYSTEM TO ALERT THE OCCUPANT TO BUCKLE UP SHOULD THEY FORGET. MY DEALER STATES THE PASSENGER AIR BAG SYSTEM IS ACTIVE FULL TIME HOWEVER IT IS ONLY MARGINALLY EFFECTIVE SHOULD THE PASSENGER FAIL TO SECURE THEIR SEAT BELT. ADDITIONALLY, THERE IS NO DASH INDICATOR SHOWING THE PASSENGER SEAT BELT BUCLKE/NO-BUCKLE STATUS AS SHOWN ON PAGE 86 OF THE 2018 SILVERADO OWNERS MANUAL WHICH DISCUSSES THE PASSENGER SENSING SYSTEM AND AIRBAG STATUS INDICATOR WHICH IS NOT PRESENT IN THIS LINE OF VEHICLES. PAGE 145 OF THE 2018 SILVERADO OWNERS MANUAL STATES THERE "MAY" BE A REMINDER LIGHT NEAR THE AIRBAG STATUS INDICATOR WHICH IS NOT INSTALLED ON THIS LINE OF VEHICLES. VIEWING SIMILAR VEHICLES, THIS CONDITION IS PRESENT IN A MINIMUM OF MODEL YEARS 2017 THROUGH 2020 CHEVROLET AND GMC 2500/3500 HD CREW CAB VEHICLES. CONTACTED GENERAL MOTORS CUSTOMER SERVICE ON 4/10/2018 & 4/24/2018 FILED GM CASE [XXX]. GM REP CALLED BACK 4/30/2018 AND THEIR SOLUTION WAS TO HAVE MY DEALERSHIP INSTALL AN AIRBAG ON/OFF SWITCH TO DISABLE THE AIRBAG. NOT A SUITABLE RESOLUTION TO THIS SAFETY ISSUE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TT

Safety ratings

NHTSA 5-Star Safety Ratings from government crash tests. Ratings can differ by cab style and 2WD/4WD.