2020 GMC Sierra 2500HD

What owners should know

Covers 2020–2026 · 6.6L Duramax L5P diesel and 6.6L V8 gas · Updated 2026-10-01

Researched from owner forums and NHTSA complaints and written by Know Your Truck. These are patterns in what owners report, not a guarantee about any particular truck.

Common failures & how to fix them

Parts and video buttons search for your 2020 GMC Sierra 2500HD. Always confirm a part fits using your VIN. Brakes, steering, fuel and airbag work affects your safety, so if you're not sure, have a qualified mechanic do it.

• 10-speed transmission valve body failure

  Dealer (recall)

  Signs: Sudden hard downshifts, limp mode, or rear wheel lock-up on diesels.

  Fix: Covered by GM recalls on 2020–2022 diesels. Other repairs are usually under warranty on newer trucks. Ask a dealer for all open recalls and bulletins.

  May be covered free by recall 24V797000 / 26V083000. Check the VIN at nhtsa.gov/recalls.

• Trailer brake controller warnings

  Easy DIY

  Signs: 'Check trailer wiring' or 'Trailer brakes disconnected' messages that cut the trailer brakes.

  Fix: Clean and inspect the 7-pin trailer connector and the trailer's wiring first. If it continues, have a dealer check for bulletins and module updates.

  Shop: 7 pin trailer connector▶ How-to videos

• Power tailgate opens unexpectedly

  Dealer (recall)

  Signs: The tailgate unlatches by itself, often after water gets in.

  Fix: Covered by GM recalls on 2020–2024 trucks with power-unlatching tailgates.

  May be covered free by recall 24V060000 / 24V894000. Check the VIN at nhtsa.gov/recalls.

• Steering gear shaft can break (2024)

  Dealer (recall)

  Signs: Loose steering or a clunk. In rare cases loss of steering.

  Fix: Covered by a GM recall on some 2024 trucks.

  May be covered free by recall 23V549000. Check the VIN at nhtsa.gov/recalls.

Recalls

A recall doesn't mean a truck still has the problem. Enter the truck's VIN at nhtsa.gov/recalls or ask a dealer to see whether the repair was done.

• Power Train:Automatic Transmission:Control Module:Software

  Feb 2026 · #26V083000

  General Motors, LLC is recalling certain 2020 Chevrolet Silverado 2500, 3500, GMC Sierra 2500, 3500, and 2020-2022 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles that may have been repaired incorrectly under recall 24V797. The transmission control valve may fail and cause the rear wheels to lock up.

  Risk and fix

  Risk: Rear wheel lock up increases the risk of a crash.

  Fix: Dealers will inspect the vehicles and update the transmission control software, free of charge. Owner notification letters were mailed March 6, 2026. Owners may contact GMC customer service at 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252516560. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on February 12, 2026.

• Power Train:Automatic Transmission:Control Module:Software

  Oct 2024 · #24V797000

  General Motors, LLC (GM) is recalling certain 2020-2022 Chevrolet Silverado 1500, 2500, 3500, GMC Sierra 1500, 2500, 3500, 2021 Cadillac Escalade, Escalade ESV, Chevrolet Tahoe, Suburban, GMC Yukon, and Yukon XL vehicles equipped with diesel engines. The transmission control valve may fail and cause the rear wheels to lock-up.

  Risk and fix

  Risk: Rear wheel lock-up can increase the risk of a crash.

  Fix: Dealers will install new transmission control module software, free of charge. GM will provide a special coverage program to cover the repair of transmissions that are identified by the remedy software as containing a defective control valve. Owner notification letters were mailed December 12, 2024. Owners may contact GM customer service at 1-888-988-7267, Cadillac customer service at 1-800-458-8006, GMC customer service at GMC 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N242454440.

• Latches/Locks/Linkages:Tailgate:Latch

  Feb 2024 · #24V060000

  General Motors, LLC (GM) is recalling certain 2020-2024 Chevrolet Silverado 2500, 3500, GMC Sierra 2500 and 3500 vehicles equipped with power-unlatching tailgates. The tailgate's electronic gate-release switch may short circuit due to water intrusion, which can result in the tailgate inadvertently unlatching while the vehicle is in park.

  Risk and fix

  Risk: An unlatched tailgate may open while driving and result in a loss of unsecured cargo, creating a road hazard and increasing the risk of a crash.

  Fix: Owners are advised to check that the tailgate is closed and latched before driving. Dealers will replace the exterior touchpad switch assemblies, free of charge. Owner notification letters were mailed May 17, 2024. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is N232426400.

• Tires:Temporary/Emergency Spare Tire

  Jul 2021 · #21V578000

  General Motors, LLC. (GM) is recalling certain 2020-2021 Chevrolet Silverado 2500 and GMC Sierra 2500 vehicles equipped with a 17" spare tire (RPO ZHQ or ZXT) and either the 20" accessory road tire (RPO REM) or the 18" accessory road tire (RPO Q2V). Operating the spare tire with other 20" or 18" tires can prevent the Anti-Lock Braking System (ABS) from engaging.

  Risk and fix

  Risk: An ABS system that cannot control the rear wheels independently increases the risk of a crash.

  Fix: Dealers will provide the appropriate spare tire and apply a new spare tire information label, free of charge. Owner notification letters were mailed on October 18, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020; GMC customer service at 1-800-462-8782. GM's number for this recall is N212329780.

• Seat Belts

  Dec 2020 · #20V792000

  General Motors, LLC (GM) is recalling certain 2019-2021 Chevrolet Silverado 1500 and GMC Sierra 1500, 2021 Chevrolet Suburban and Tahoe and GMC Yukon XL and 2020-2021 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 vehicles. The seat belt brackets may not be secured to the seat frame in the front-row center seating position.

  Risk and fix

  Risk: If a seat-belt bracket is not secured, the seat belt may not properly restrain an occupant in the front-row center seat position, increasing the risk of injury in a crash.

  Fix: GM will notify owners, and dealers will inspect left-side and right-side front-row center seat-belt bracket attachments and reassemble it correctly as necessary, free of charge. The recall began January 26, 2021. Owners may contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N202314670.

• Air Bags:Side/Window:Curtain:Inflator

  Jul 2020 · #20V446000

  General Motors, LLC. (GM) is recalling certain 2020 Buick Enclave, Cadillac XT5 and XT6, Chevrolet Blazer, Silverado 1500, 2500 and 3500 and Traverse and GMC Acadia and Sierra 1500, 2500 and 3500 vehicles. The diffuser component of the Roof-Rail Air Bag (RRAB) inflator may not have been properly crimped to the inflator and could separate from the inflator during air bag deployment.

  Risk and fix

  Risk: If the diffuser separates from the inflator during deployment, RRAB performance may be degraded, increasing the risk of injury in a crash.

  Fix: GM will notify owners, and dealers will replace the suspect RRAB modules, free of charge. The recall began September 3, 2020. Owners may contact Chevrolet customer service at 1-800-630-2438, Cadillac customer service at 1-800-333-4223, or Buick customer service at 1-800-521-7300. GM's number for this recall is N202305380.

• Structure:Body:Hood

  Jun 2020 · #20V324000

  General Motors LLC (GM) is recalling certain 2020 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 vehicles previously recalled under 20V-142. Some of the vehicles in 20V-324 were not part of Recall 20V-142 but received defect parts during another service (typically during collision repair). The hood-latch striker wires on replacement hoods installed for Safety Recall 20V-142 may not have been heat-treated properly, possibly causing them to fracture.

  Risk and fix

  Risk: If a striker wire fractures, the hood may open unexpectedly while driving, increasing the risk of a crash.

  Fix: GM will notify owners, and dealers will replace the hood assembly, free of charge. For hoods sold over the counter, dealers will contact customers with instructions for hood replacement. The recall began July 7, 2020. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-888-988-7267. GM's number for this recall is N202306490.

• Latches/Locks/Linkages:Hood:Latch

  Mar 2020 · #20V142000

  General Motors LLC (GM) is recalling certain 2020 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 vehicles. The hood-latch striker wires may not have been heat-treated properly, possibly causing them to fracture.

  Risk and fix

  Risk: If a striker wire fractures, the hood may open unexpectedly while driving, increasing the risk of a crash.

  Fix: GM will notify owners, and dealers will replace the hood assembly, free of charge. The recall began April 13, 2020. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-888-988-7267. GM's number for this recall is N192284960.

• Seat Belts:Pretensioner

  Nov 2019 · #19V814000

  General Motors LLC (GM) is recalling certain 2019-2020 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2020 Silverado 2500, Silverado 3500, Sierra 2500, and Sierra 3500 vehicles equipped with carpet floor covering. When the front seat belt pretensioners deploy, hot gas may vent through an opening in the pretensioner bracket, possibly igniting the carpet.

  Risk and fix

  Risk: A vehicle fire could result if materials ignite inside the vehicle.

  Fix: GM will notify owners, and dealers will close off the opening in the pretensioner bracket, free of charge. The recall began December 13, 2019. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-888-988-7267. GM's number for this recall is N192270600.

Owner complaints by area

Reports owners filed with NHTSA. They aren't verified, and one complaint can mention more than one area. Tap an area to read the most recent ones.

• Power Train24

  • Filed Sep 2026

    A dealer "fixed" the P20EE code on this date, then the code came back a week later. Same dealer said they don't have qualified diesel technician, took vehicle to a 2nd dealer 9/22/2025, unable to determine cause of code. On 6/18/2026 same P20EE code came on again, took to dealer, dealer able to perform repairs on 7/30/2026 after ordering the correct parts. No on 9/23/2026 P20EE code is back.

  • Filed Sep 2026

    While driving vehicle flashed engine power reduction signal and then the emergency brake automatic feature came on abruptly. Fortunately, I had been able to slow down after the reduced power, but if I wouldn't have quickly reacted to that, I think the emergency brake system would have caused a safety issue. Now. The vehicle is incapacitated. There were two recalls that describe this exact situation on the same year and model of truck, but my VIN number did not fall. Under that recall. The recall was for the sensor and then the second recall was because the first recall didn't correctly fix it. But the details of the faulty sensor are exactly what happened to my truck. So it sounds to me like they had more problems than just the recall that they acknowledged but they have not expanded it. My quest is to have them expand the recall to all of the vehicles that had the same problem.

  • Filed Mar 2026

    While driving down a highway doing between 45 and 55 mph the transmission suddenly and completely faulted causing the truck to come to a complete stop. Just enough power to get to the shoulder luckily. The transmission had basically completely blown out, fluid everywhere. The insurance company did not find any comprehensive damage. The entire transmission needs to be replaced. There were no indicators showing any problems, no alerts, no warning whatsoever. Mechanics said there was a lot of metal coming out of the transmission. The truck is currently in a mechanic shop awaiting the new transmission, so at this time it is available for inspection. The safety issue here is that it happened on a busy highway, and the vehicle was no longer drivable so it needed to be towed causing more time spent on the side of the road.

  • Filed Feb 2026

    A couple times I heard loud clanking coming from rear brakes. One time in particular I was trying to stop and it felt line someone had ran into my truck but must have been the rear wheel locking up

  • Filed Oct 2025

    Torque converter in my transmission we out, causing my gears to grind and lose power. Slight rumbling sound under the front passenger seat, First dealer (Palmen Motors, Kenosha WI) told me there was nothing wrong with the vehicle and no transmission error codes exist. Second dealer (Parks GMC, Greenville SC) indicated that i need a complete new transmission. Part is on backorder for the last 4 weeks and I am without my vehicle. No ETA for new part or any information on why it failed prematurely.

  • Showing the 5 most recent of 24.
• Unknown or Other16

  • Filed May 2025

    Cracks in the rear sliding window plastic upper rail glass guide causing Rear window leaking water and causing mold from water leaking. GMC has a service bulletin number 18-NA-383 knowing of this issue and not telling customers purchasing the GMC vehicle. The service bulletin was released in 2019 before purchasing the truck and they still didn't inform the customers. My child rides in the back in a car seat and now has been breathing in this mold and mildew for how long. I have had my vehicle in with Titus will Gmc in olympia multiple times for service and inspection of various recalls and still didn't inform me of this issue.

  • Filed May 2025

    Tailgate unlatches unexpectedly. Has happened while parked and while driving. Almost caused accident to others.

  • Filed Mar 2025

    I have a notice of a recall for the transmission control module and I took it to a GMC dealership and they are refusing to fix it. The transmission will not shift so I am unable to drive it

  • Filed Mar 2025

    ODI # 11646185 My truck on [XXX] leaked transmission coolant from the jumper line leak( which this part is recalled but not for my VIN #) $400.61 dollars and left me stranded in the middle of the highway and had to be towed. After the repair and checking the transmission was discovered it was ruined because of the leak. So now I have to have a new transmission installed at Jennings in Beardstown IL to the cost of $7363.39. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

  • Filed Mar 2025

    My truck had been sitting idling for about 20 minutes on a job site on flat level ground. I turn around for whatever reason and my truck is driving forward with on one in it but my dog. The truck ran into an out rigger on my crane. I had 3 of my employees there that witnessed this happen. I got into my truck and the shifter was in drive. Somehow my dog was able to shift my truck into drive from park while it was sitting idle. I have 3 eye witnesses as well as pictures of the incident. I have pictures but was no able to upload them to they portal.

  • Showing the 5 most recent of 16.
• Electrical System13

  2 involved a fire

  • Filed Sep 2026

    When I try to start my truck it comes up as service trailer brake control module and it has caused my truck battery to drain so I cant even crank my truck up.

  • Filed Dec 2025

    The main tailgate will not go down or function properly and it says online there is a national recall for this, but does not come up when I search my vehicle. When I turn on my left turn signal the brights flash for no reason and this is a known major issue with the vehicles as well. The trucks computer is telling me low on coolant even though it is not that has already been fixed through a 3rd pARTY WARRANTY Parking brake was stuck on when I bought the vehicle and had been for a long time you could tell and I had to pay over $1100 to fix it at GM. The Ford collision system does not work properly and the cameras will come on at certain times when they're not supposed to be and not come on when they are supposed to be

  • Filed Nov 2025

    The rear defroster massively overheated. It started heavily smoking and eventually exploded the rear windows. Only warning sign was the smoke which we noticed quickly because the windows were up. Had the windows been down we might not have noticed before a fire started. I'm taking it to a dealership now. This module also triggers on from a remote start. Extremely dangerous!!!

  • Filed Oct 2025

    I have taken the vehicle to my local dealership six times. The tailgate started opening and the headlights were blinking on and off. This happened 3 months after I bought it. The dealership told me they changed the tailgate switch and they said there wasn’t anything wrong with my lights. Two weeks after the dealership said they changed the tailgate switch, the tailgate started opening and closing. The lights also stopped working driving down the road at night. This happened 3 different times at night. The tailgate opened when I was pulling a trailer and it caved in and I had to pay to have it repaired. The dealership said it wasn’t their problem. During this time the power steering fluid was leaking under my steering wheel and ruined my carpet. The dealership has yet to acknowledge that problem. I still have to put power steering fluid in the truck every week and my interior is ruined. The tailgate is still opening on its own. I had to start charging my batteries up every morning because they were dead. I got up one morning and the batteries were dead and the truck wouldn’t start. I had to buy a new $300 key. Took it back to the dealership for an appointment. The truck sat there for a week and I called for an update and they didn’t even remember the truck was there. It still sat there 4 days after that. They told me the truck needs new batteries and it wasn’t under warranty. I spent $1000 on 2 batteries. Tailgate is still going down. The lights are still going on and off. And then the lights and the locks will go on and off while the truck is parked and turned off. And now the new batteries are becoming weak and I am having to get the truck jumped off several times. I have had the truck at the dealership 6 times and they still haven’t fixed anything. When they have my truck I am losing money because I am a business owner and I use my truck for work. I lost all of my tools. I have lost time and money because the dealer has yet to help and do their job. I need help GM

  • Filed Mar 2025

    Vehicle was parked in a school parking lot. Rear Trailer Harness and modules in back short circuited causing an electrical fire that expanded to the driver’s taillight rear bumper, and bed of truck.

  • Showing the 5 most recent of 13.
• Service Brakes12

  • Filed Dec 2025

    The main tailgate will not go down or function properly and it says online there is a national recall for this, but does not come up when I search my vehicle. When I turn on my left turn signal the brights flash for no reason and this is a known major issue with the vehicles as well. The trucks computer is telling me low on coolant even though it is not that has already been fixed through a 3rd pARTY WARRANTY Parking brake was stuck on when I bought the vehicle and had been for a long time you could tell and I had to pay over $1100 to fix it at GM. The Ford collision system does not work properly and the cameras will come on at certain times when they're not supposed to be and not come on when they are supposed to be

  • Filed Dec 2024

    Tires locking up while driving. NOT SAFE TO DRIVE

  • Filed Sep 2024

    I HAVE A 5TH WHEEL WITH SOLAR AND MY BRAKE CONTROLER STOPS WORKING PERIODICALLY. I HAVE A CASE# WITH GM 9-13676268071. I ALSO HJAVE AN EXTENDED WARRANTY WITH GM AND IT'S NOT COVERED DUE TO MY VIN# NOT BEING ON A BULLENTIN# 23-NA-149. GM ALSO HAS A CUSTOMER SATISFACTION PROGREAM # N232414840 AND STILL WON'T COVER IT. THIS IS A MAJOR SAFETY ITEM AND CONCERN FOR ME.

  • Filed Aug 2024

    The contact owns a 2020 GMC Sierra 2500. The contact stated that while driving 65 MPH, the message "Check Service Brakes Now" was displayed. The vehicle was taken to an independent mechanic, where it was diagnosed with electric parking brake malfunction. The mechanic informed the contact that the electric parking brake had been engaged unintendedly, causing the rear driver's side brake calipers to seize. The vehicle was repaired; however, the failure recurred on the rear passenger's side while driving. The vehicle was taken to the dealer, where it was diagnosed with electric parking brake circuitry failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 62,000.

  • Filed Mar 2024

    My vehicle inadvertently locks the rear tires at highway speeds and then releases and drives. In some instances it may brake several times causing the tires to burn rubber for a short distance causing rear traffic to either swerve to avoid rear ending me and in a couple instances causes the rear following traffic to abruptly change lanes to avoid rear ending me

  • Showing the 5 most recent of 12.
• Engine10

  1 involved a fire

  • Filed Dec 2025

    Catastrophic engine failure after taking it in for the April 2025 recall. Complete engine replacement needed

  • Filed Sep 2025

    The catalytic converter failed at 93,000 miles, and 64 months. GM says it is out of warranty.

  • Filed Jan 2025

    The contact owns a 2020 GMC Sierra 2500. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed, and the transmission jerked. The contact stated that the transmission was skipping gear while shifting. The check engine warning light turned on and off. The contact received notification of NHTSA Campaign Number: 24V797000 (Power Train); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was approximately 114,000. VIN tool confirms parts not available.

  • Filed Aug 2023

    Low coolant light keeps coming on and dealership checks and confirms coolant is not low. The end result is the sensor In the resivor is bad and requires the entire tank to be replaced rather than just the sensor

  • Filed Mar 2023

    Check engine came on Sunday morning the code that through was P0 526 u062F. After calling the dealer and setting maintenance to be done one day later, the truck broke down while driving on the side of the road. The dealer is saying that the belt came off and the tensioner locked up doing damage to the fan clutch and connector. The case, because the code that ran is saying that the belt wasn’t going the speed that it was supposed to because the tensioner failed. The vehicle only has 55,000 miles on it.

  • Showing the 5 most recent of 10.
• Steering6

  • Filed Dec 2025

    Bad vibration and bad wobble in steering wheel and front end components. This is the 3rd or 4th time my truck has been back to the dealer because of the same issue!

  • Filed Oct 2025

    I have taken the vehicle to my local dealership six times. The tailgate started opening and the headlights were blinking on and off. This happened 3 months after I bought it. The dealership told me they changed the tailgate switch and they said there wasn’t anything wrong with my lights. Two weeks after the dealership said they changed the tailgate switch, the tailgate started opening and closing. The lights also stopped working driving down the road at night. This happened 3 different times at night. The tailgate opened when I was pulling a trailer and it caved in and I had to pay to have it repaired. The dealership said it wasn’t their problem. During this time the power steering fluid was leaking under my steering wheel and ruined my carpet. The dealership has yet to acknowledge that problem. I still have to put power steering fluid in the truck every week and my interior is ruined. The tailgate is still opening on its own. I had to start charging my batteries up every morning because they were dead. I got up one morning and the batteries were dead and the truck wouldn’t start. I had to buy a new $300 key. Took it back to the dealership for an appointment. The truck sat there for a week and I called for an update and they didn’t even remember the truck was there. It still sat there 4 days after that. They told me the truck needs new batteries and it wasn’t under warranty. I spent $1000 on 2 batteries. Tailgate is still going down. The lights are still going on and off. And then the lights and the locks will go on and off while the truck is parked and turned off. And now the new batteries are becoming weak and I am having to get the truck jumped off several times. I have had the truck at the dealership 6 times and they still haven’t fixed anything. When they have my truck I am losing money because I am a business owner and I use my truck for work. I lost all of my tools. I have lost time and money because the dealer has yet to help and do their job. I need help GM

  • Filed Mar 2025

    The contact owns a 2020 GMC Sierra 2500. The contact stated that while driving at various speeds, the steering wheel was pulling to the left unintentionally. Additionally, the contact stated that there was significant play in the steering wheel. The contact stated that while driving 35-40 MPH and driving through a puddle of water, the vehicle veered violently at a 60-degree angle into the left lane while the contact was firmly grabbing the steering wheel, nearly causing a crash. The vehicle was taken to the dealer and was diagnosed with upper steering shaft failure. The contact was informed that the upper steering shaft needed to be replaced. The part was replaced. Additionally, the vehicle was taken to a Tire Shop, where the tires were replaced and alignment was performed. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 31,800.

  • Filed Jun 2021

    While driving my 2020 GMC 2500 Denali with the Duramax Diesel engine, the power assist for the steering and brakes failed without any warning. This made the truck nearly impossible to steer and stop. Luckily, I was able to avoid a collision and get the truck stopped in a safe location. The truck is currently being towed to Rivard GMC in Tampa, Fl. Doing an internet search, I found this problem has happened to others as well. Please ask GM to rectify this extremely dangerous defect.

  • Filed Jan 2021

    THE VEHICLE PULLS TO THE RIGHT OR LEFT INTO ONCOMING TRAFFIC WITHIN 800 FEET OR SOONER DEPENDING ON SPEED. THIS OCCURS ON CITY STREETS OR INTERSTATE. GM AND GM APPROVED DEALERSHIPS SAY THIS IS DONE TO GM SPECIFICATIONS. THE FIRST 7000 MILES, IT DIDN'T PULL. AFTER GM SHOP ALIGNED, AND 3 MONTHS LATER, IT IS UNSAFE TO OPERATE.

  • Showing the 5 most recent of 6.
• Forward Collision Avoidance5

  • Filed Sep 2026

    While driving vehicle flashed engine power reduction signal and then the emergency brake automatic feature came on abruptly. Fortunately, I had been able to slow down after the reduced power, but if I wouldn't have quickly reacted to that, I think the emergency brake system would have caused a safety issue. Now. The vehicle is incapacitated. There were two recalls that describe this exact situation on the same year and model of truck, but my VIN number did not fall. Under that recall. The recall was for the sensor and then the second recall was because the first recall didn't correctly fix it. But the details of the faulty sensor are exactly what happened to my truck. So it sounds to me like they had more problems than just the recall that they acknowledged but they have not expanded it. My quest is to have them expand the recall to all of the vehicles that had the same problem.

  • Filed Dec 2025

    The main tailgate will not go down or function properly and it says online there is a national recall for this, but does not come up when I search my vehicle. When I turn on my left turn signal the brights flash for no reason and this is a known major issue with the vehicles as well. The trucks computer is telling me low on coolant even though it is not that has already been fixed through a 3rd pARTY WARRANTY Parking brake was stuck on when I bought the vehicle and had been for a long time you could tell and I had to pay over $1100 to fix it at GM. The Ford collision system does not work properly and the cameras will come on at certain times when they're not supposed to be and not come on when they are supposed to be

  • Filed Jun 2024

    The contact owns a 2020 GMC Sierra 2500. The contact stated while driving 60 MPH, the vehicle independently slowed and dramatically decelerated. The vehicle returned to normal functionality, but the failure became a regular occurrence. The contact stated that when the failure occurred, the gear shifter position indicator light flashed, and once the vehicle returned to normal functionality, the light remained solid. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the Forward Collision Avoidance warning sensor. The vehicle was repaired, but the failure reoccurred. The manufacturer was not notified of the failure. The failure mileage was 102,000.

  • Filed Mar 2024

    My vehicle inadvertently locks the rear tires at highway speeds and then releases and drives. In some instances it may brake several times causing the tires to burn rubber for a short distance causing rear traffic to either swerve to avoid rear ending me and in a couple instances causes the rear following traffic to abruptly change lanes to avoid rear ending me

  • Filed Dec 2021

    Was driving truck down driveway at about 5km per hour and the parking brake automatically engage bringing the vehicle to a sudden and unexpected hard stop. Brought to dealership, then said they cannot duplicate the problem and therefore there is no action to be taken.

• Structure5

  2 involved a fire

  • Filed Nov 2025

    The rear defroster massively overheated. It started heavily smoking and eventually exploded the rear windows. Only warning sign was the smoke which we noticed quickly because the windows were up. Had the windows been down we might not have noticed before a fire started. I'm taking it to a dealership now. This module also triggers on from a remote start. Extremely dangerous!!!

  • Filed Mar 2025

    Vehicle was parked in a school parking lot. Rear Trailer Harness and modules in back short circuited causing an electrical fire that expanded to the driver’s taillight rear bumper, and bed of truck.

  • Filed Feb 2025

    While towing my dump trailer early in the morning for about 20 minutes I noticed sudden hard up shifting and down shifting in some gears on flat surface roads. I then proceeded to approach an incline hill about a 5% grade and then, what I've recently learned, my transmission locked up and released for a split second. The roads were slick so it didn't seem too harsh, I continued with no incident for another 40 miles and then it happened again while pulling up a 7% grade in a left hand sharp turn at 40 mph. The truck fish tailed and jack knifed my trailer on the left rear side of my truck and the front left side of the trailer. I was on a one lane road and had to continue until I reached my detitanation, I slowed and maintained a speed of 45 in order to prevent it from happening again but it did it 5 more times before reaching my destination. I'm currently scheduled to have the transmission checked on 02/27/2025 at Peterson's Chevrolet Nampa Idaho. In the meantime, I have no means of using any of my trailers.

  • Filed Jun 2024

    The contact owns a 2020 GMC Sierra 2500. The contact stated that when the vehicle was parked, the contact's husband noticed that rainwater had entered the rear interior of the vehicle. The contact stated that the rainwater had entered through the rear sliding window. In addition, the contact stated that the aluminum casing around the rear window had fractured. The contact stated that due to the failure, the interior of the vehicle had a moldy odor. The vehicle was taken to the dealer where it was diagnosed with a fractured window frame. The contact was informed that the rear window and frame needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The contact was informed that the repair would not be covered under warranty. The failure mileage was approximately 69,000.

  • Filed Mar 2024

    Tailgate fell down when I had a trailer hooked up. I was parked, then backed up the trailer. Tailgate came down on the jack and scratched the tailgate. There is a recall on some trucks but mine says no recall. Sounds like same issue.

• Vehicle Speed Control4

  • Filed Sep 2026

    While driving vehicle flashed engine power reduction signal and then the emergency brake automatic feature came on abruptly. Fortunately, I had been able to slow down after the reduced power, but if I wouldn't have quickly reacted to that, I think the emergency brake system would have caused a safety issue. Now. The vehicle is incapacitated. There were two recalls that describe this exact situation on the same year and model of truck, but my VIN number did not fall. Under that recall. The recall was for the sensor and then the second recall was because the first recall didn't correctly fix it. But the details of the faulty sensor are exactly what happened to my truck. So it sounds to me like they had more problems than just the recall that they acknowledged but they have not expanded it. My quest is to have them expand the recall to all of the vehicles that had the same problem.

  • Filed Jan 2023

    There is an issue that is causing the batteries to die. This in return causes the Vehicle to go into Limp home mode with no warning. The "issue" was supposed to be resolved by the Dealer in March 2022. The resolution was that one battery was bad. The vehicle is equipped with two batteries. Each of which is sufficient to run the vehicle. A single battery failure should not have caused the truck to have a power limitation. Furthermore the issue was not resolved and General Motors and the Local dealership refuse to continue to work on the issue. This is even after filling complaints with BBB. As of November 2022 the issue has cause both batteries to go bad. The dealer has refused to work on the vehicle and it has been out of service for more than 30 days. Secondary issue. The dealer has refused to work on the vehicle but computer is locked by GM so that only GM equipment can see full scope of codes. This means I can not have third parties work on the vehicle. This is can get the vehicle stuck in areas where there is not GM facilities and GM will not provide any assistance as it is not under warranty. This has also prevented me from finding the actual resolution to the problem.

  • Filed Mar 2022

    DEF system failed. Wire harness burned out. Tank failure. Truck went into limp mode. I personally know 3 others with the same issue.

  • Filed Dec 2021

    While driving Truck was setting Cruise Control at approx 100km/hr. The cruise would set but at approx 70km/hr. Tried to set multiple time throughout the trip but no change. Recorded video and sent to dealer. They brought truck in to check it out, but said that since they can't duplicate the problem they cannot diagnose it. This has happened multiple times and have recorded video each time. Again dealer said they can't do anything unless they see it themselves.

• Engine And Engine Cooling2

  • Filed Jun 2026

    The contact owns a 2020 GMC Sierra 2500. The contact stated that the check engine warning light was illuminated, and the message "Reduced Power" was displayed. The vehicle was taken to the dealer, where the turbo actuator and wastegate position sensor A-circuit were replaced; however, the failure persisted. The vehicle was taken back to the dealer, and the contact was advised that another diagnostic test was needed. The contact declined to pay for the diagnostic test. The vehicle was taken to a retired GM mechanic, who diagnosed the vehicle with turbo charger failure. The vehicle was not repaired due to the cost. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 100,000.

  • Filed Apr 2025

    The contact owns a 2020 GMC Sierra 2500. The contact stated that the vehicle was under NHTSA Campaign Number: 24V797000 (Power Train) and the vehicle was repaired. The contact stated that after the recall repair, the transmission started shifting hard. The vehicle was taken to the dealer, and the contact was informed that the transmission module would reprogram and adjust independently. The contact stated that a week later, while driving approximately 45 MPH, the vehicle started to run rough, and the message engine power reduced was displayed. The transmission fault, parking brake system alert, service parking brake, and the check engine warning light illuminated. The vehicle was towed to the dealer, who diagnosed the vehicle and determined that the fuel injector was open, causing high resistance in the connector for cylinder #4. The transmission could not be diagnosed until the injector was repaired. The manufacturer was informed of the failure and opened a case. The failure mileage was 125,000.

• Exterior Lighting2

  • Filed Oct 2025

    I have taken the vehicle to my local dealership six times. The tailgate started opening and the headlights were blinking on and off. This happened 3 months after I bought it. The dealership told me they changed the tailgate switch and they said there wasn’t anything wrong with my lights. Two weeks after the dealership said they changed the tailgate switch, the tailgate started opening and closing. The lights also stopped working driving down the road at night. This happened 3 different times at night. The tailgate opened when I was pulling a trailer and it caved in and I had to pay to have it repaired. The dealership said it wasn’t their problem. During this time the power steering fluid was leaking under my steering wheel and ruined my carpet. The dealership has yet to acknowledge that problem. I still have to put power steering fluid in the truck every week and my interior is ruined. The tailgate is still opening on its own. I had to start charging my batteries up every morning because they were dead. I got up one morning and the batteries were dead and the truck wouldn’t start. I had to buy a new $300 key. Took it back to the dealership for an appointment. The truck sat there for a week and I called for an update and they didn’t even remember the truck was there. It still sat there 4 days after that. They told me the truck needs new batteries and it wasn’t under warranty. I spent $1000 on 2 batteries. Tailgate is still going down. The lights are still going on and off. And then the lights and the locks will go on and off while the truck is parked and turned off. And now the new batteries are becoming weak and I am having to get the truck jumped off several times. I have had the truck at the dealership 6 times and they still haven’t fixed anything. When they have my truck I am losing money because I am a business owner and I use my truck for work. I lost all of my tools. I have lost time and money because the dealer has yet to help and do their job. I need help GM

  • Filed Oct 2020

    AS I WAS DRIVING HOME MY CHECK ENGINE LIGHT CAME ON AND ALL OF MY LIGHTS WENT OUT. I HAD NO TAIL LIGHTS AND THE RADIO STARTED SAYING NO SIGNAL DETECTED. THE DASH SCREEN WAS SAYING SERVICE KEYLESS ENTRY SYSTEM. AND I HAD NO RUNNING LIGHTS BUT MY HEADLIGHTS. PRETTY SCARY THINKING NO ONE COULD SEE ME AS THEY WERE DRIVING BEHIND ME AT A HIGH RATE OF SPEED. MY TRUCK ONLY HAS 200 MILES ON IT SO THIS IS REALLY SCARY TO BE HAVING ISSUES SO EARLY IN THE OWNERSHIP OF THIS TRUCK. I'VE ALWAYS HAD FORDS BUT THIS TRUCK CAUGHT MY EYE AND I STEPPED OUT OF MY COMFORT ZONE AND NOW WISHING I WOULD HAVE STAYED IN IN.

• Wheels2

  • Filed Dec 2024

    Tires locking up while driving. NOT SAFE TO DRIVE

  • Filed Jan 2021

    THE VEHICLE PULLS TO THE RIGHT OR LEFT INTO ONCOMING TRAFFIC WITHIN 800 FEET OR SOONER DEPENDING ON SPEED. THIS OCCURS ON CITY STREETS OR INTERSTATE. GM AND GM APPROVED DEALERSHIPS SAY THIS IS DONE TO GM SPECIFICATIONS. THE FIRST 7000 MILES, IT DIDN'T PULL. AFTER GM SHOP ALIGNED, AND 3 MONTHS LATER, IT IS UNSAFE TO OPERATE.

• Tires2

  • Filed Dec 2023

    I was travelling south bound on the highway at 70 mph when out of no where the left rear tire failed. The tread peeled back like an alligator skin and tore apart the side of my truck and caused me to fishtail all over the highway. I was able to avoid colliding with other vehicles on the road and miraculously made it to the shoulder of the highway. The tire is a Goodyear Wrangler TrailRunner AT in a size LT275/65/R20. I still have the remaining parts of the tire. My vehicle is still under manufacturer warranty, but the GMC dealer turned me away and told me I had to deal with Goodyear directly. I reached out to Goodyear to file a claim for the tire failure and damages related to it. They have been ignoring me for over a week, so I have filed a claim with my insurance company to handle the damages. I'm currently waiting to get my truck into the shop for repairs. There were no indications of any issues with the tire. I had them rotated as recommended by the manufacturer and kept the tire pressure at the recommended levels through the dealer when my vehicle was serviced. The TPMS light came on as soon as the tire failed and lost pressure showing the vehicle tire pressure monitoring system was working properly when the tire failed.

  • Filed Aug 2022

    The contact owns a 2020 GMC Sierra 2500 equipped with Goodyear Tires, Tire Line: Wrangler Trail Runner, Tire Size: LT275/65/R20, DOT Number: PJ0TJB1V 2319. The contact stated that within a three-day period while hauling a camper on a road trip, all four tires experienced a failure. The contact indicated that the first failure occurred while driving approximately 60 MPH; the rear driver’s side tire experienced a blowout. During the failure, the driver’s side rear quarter panel was severely damaged. The contact stated that later on while driving at an undisclosed speed, the rear passenger’s side tire experienced a similar blowout causing damage to the passenger’s side rear quarter panel. Additionally, on another occasion while driving approximately 50 MPH on the same road trip, the front passenger’s side tire experienced tread separation. While at the service center the mechanic discovered that the front driver’s side tire had also experienced partial tread separation. The cause of the failure was not determined. The manufacturer and local dealer were notified of the failure. The failure mileage was 25,400.

• Visibility/Wiper1

  1 involved a fire

  • Filed Nov 2025

    The rear defroster massively overheated. It started heavily smoking and eventually exploded the rear windows. Only warning sign was the smoke which we noticed quickly because the windows were up. Had the windows been down we might not have noticed before a fire started. I'm taking it to a dealership now. This module also triggers on from a remote start. Extremely dangerous!!!

• Fuel System1

  • Filed Apr 2025

    The contact owns a 2020 GMC Sierra 2500. The contact stated that the vehicle was under NHTSA Campaign Number: 24V797000 (Power Train) and the vehicle was repaired. The contact stated that after the recall repair, the transmission started shifting hard. The vehicle was taken to the dealer, and the contact was informed that the transmission module would reprogram and adjust independently. The contact stated that a week later, while driving approximately 45 MPH, the vehicle started to run rough, and the message engine power reduced was displayed. The transmission fault, parking brake system alert, service parking brake, and the check engine warning light illuminated. The vehicle was towed to the dealer, who diagnosed the vehicle and determined that the fuel injector was open, causing high resistance in the connector for cylinder #4. The transmission could not be diagnosed until the injector was repaired. The manufacturer was informed of the failure and opened a case. The failure mileage was 125,000.

• Diesel1

  • Filed Apr 2025

    The contact owns a 2020 GMC Sierra 2500. The contact stated that the vehicle was under NHTSA Campaign Number: 24V797000 (Power Train) and the vehicle was repaired. The contact stated that after the recall repair, the transmission started shifting hard. The vehicle was taken to the dealer, and the contact was informed that the transmission module would reprogram and adjust independently. The contact stated that a week later, while driving approximately 45 MPH, the vehicle started to run rough, and the message engine power reduced was displayed. The transmission fault, parking brake system alert, service parking brake, and the check engine warning light illuminated. The vehicle was towed to the dealer, who diagnosed the vehicle and determined that the fuel injector was open, causing high resistance in the connector for cylinder #4. The transmission could not be diagnosed until the injector was repaired. The manufacturer was informed of the failure and opened a case. The failure mileage was 125,000.

• Back Over Prevention1

  1 involved a fire

  • Filed Mar 2025

    Vehicle was parked in a school parking lot. Rear Trailer Harness and modules in back short circuited causing an electrical fire that expanded to the driver’s taillight rear bumper, and bed of truck.

• Parking Brake1

  • Filed Aug 2024

    The contact owns a 2020 GMC Sierra 2500. The contact stated that while driving 65 MPH, the message "Check Service Brakes Now" was displayed. The vehicle was taken to an independent mechanic, where it was diagnosed with electric parking brake malfunction. The mechanic informed the contact that the electric parking brake had been engaged unintendedly, causing the rear driver's side brake calipers to seize. The vehicle was repaired; however, the failure recurred on the rear passenger's side while driving. The vehicle was taken to the dealer, where it was diagnosed with electric parking brake circuitry failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 62,000.

• Fuel/Propulsion System1

  • Filed Mar 2022

    DEF tank system failure. Vehicle is under warranty, 18 months old, (purchased 08/20) with 20,000 miles. 6 WEEKS AGO I took to dealer who informed me that there are no DEF tanks available and don't know when they will be available. This is a hazard: if I am on a trip and the system shuts off I could be stranded anywhere with the reduced speed that the DEF system creates. If this system is designed to shut off (with warning) there should be ample supplies at all GMC dealers for repair. If there aren't ample supplies the system should NOT shut the truck down. THIS IS A SAFETY HAZARD THAT IS PREVENTABLE!

• Air Bags1

  1 involved a crash

  • Filed Apr 2021

    TL* THE CONTACT OWNS A 2020 GMC SIERRA 2500. THE CONTACT STATED THAT UPON DRIVING OVER A HILL AT 45 MPH, A VEHICLE WAS STOPPED IN THE MIDDLE OF THE ROAD. IN AN EFFORT TO AVOID HITTING THE VEHICLE, THE CONTACT DROVE THE VEHICLE OFF THE ROAD AND INTO A CONCRETE CULVERT AT THE END OF THE RAVINE. THE AIR BAGS DID NOT DEPLOY UPON IMPACT. THE AUTHORITIES WERE CALLED TO THE SCENE AND THE CONTACT WAS RUSHED TO A LOCAL HOSPITAL VIA AMBULANCE. THE CONTACT WAS DIAGNOSED WITH FRACTURED VERTEBRAE THAT MAY REQUIRE POSSIBLE SURGERY. A POLICE REPORT WAS FILED AT THE SCENE. DUE TO THE ACCIDENT, THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THE VEHICLE WAS REPAIRED. THE DEALER NOR THE MANUFACTURER HAVE YET TO BE NOTIFIED OF THE FAILURE. THE VEHICLE WAS REPAIRED AND SOLD. THE FAILURE MILEAGE WAS APPROXIMATELY 15,500.

• Suspension1

  • Filed Jan 2021

    THE VEHICLE PULLS TO THE RIGHT OR LEFT INTO ONCOMING TRAFFIC WITHIN 800 FEET OR SOONER DEPENDING ON SPEED. THIS OCCURS ON CITY STREETS OR INTERSTATE. GM AND GM APPROVED DEALERSHIPS SAY THIS IS DONE TO GM SPECIFICATIONS. THE FIRST 7000 MILES, IT DIDN'T PULL. AFTER GM SHOP ALIGNED, AND 3 MONTHS LATER, IT IS UNSAFE TO OPERATE.

• Electronic Stability Control (esc)1

  • Filed Sep 2020

    2020 GMC SIERRA DENALI DURAMAX 3000 MILES TRIED TURNING ON TRUCK THIS MORNING TO GO TO WORK AND WOULD NOT EVEN CRANK IT IS A PUSH START OPTION HAVE NO CLUE ON HOW IM GOING TO TAKE IT TO THE DEALERSHIP IF I CANT GET IT OF PARK INTO NEUTRAL FOR A TOW TRUCK AT LEAST ! TRUCK DOES NOT CRANK IT THROWS ME A TON OF MESSAGES STABILITY TRAK DSC ABS POWER REDUCED 4WD CHECK TRAILER LIGHTS. BUNCH OF MESSAGES I TOOK VIDEO OF IT AND SO TRUCK DOESN'T EVEN TRY TO START. I TOOK A VIDEO OR THE PROBLEM

• Traction Control System1

  • Filed Nov 2019

    TL* THE CONTACT OWNS A 2020 GMC SIERRA 2500. WHILE DRIVING 5 MPH, THE BRAKES ENGAGED AUTOMATICALLY AND THE TRACTION CONTROL WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN SEVERAL TIMES TO CARL BLACK CHEVROLET BUICK GMC (LOCATED AT 1110 ROBERTS BOULEVARD NORTHWEST, KENNESAW, GA 30144, (888) 457-2417). THE DEALER DIAGNOSED THAT THE SPEED SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE CONTINUED. THE DEALER DIAGNOSED THE VEHICLE AGAIN AND STATED THAT THE WHEEL HUBS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE DEALER DIAGNOSED THE VEHICLE A THIRD TIME AND STATED THAT AN UNKNOWN STEERING ANGLE SENSOR NEEDED TO BE UPDATED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE CONTINUED. THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS 571.

Safety ratings

NHTSA 5-Star Safety Ratings from government crash tests. Ratings can differ by cab style and 2WD/4WD.

NHTSA hasn't published star ratings for this truck. Many heavy-duty pickups aren't included in NHTSA's crash-test program, so this doesn't mean the truck is unsafe.