2012 GMC Sierra 2500HD

What owners should know

Covers 2011–2014 · 6.6L Duramax LML diesel and 6.0L V8 gas · Updated 2026-10-01

Researched from owner forums and NHTSA complaints and written by Know Your Truck. These are patterns in what owners report, not a guarantee about any particular truck.

Common failures & how to fix them

Parts and video buttons search for your 2012 GMC Sierra 2500HD. Always confirm a part fits using your VIN. Brakes, steering, fuel and airbag work affects your safety, so if you're not sure, have a qualified mechanic do it.

• Duramax LML fuel pump (CP4) failure

  Best left to a shop

  Signs: Sudden stalling or no-start, low fuel pressure codes such as P0087.

  Fix: Prevention: change the fuel filter on schedule and buy fuel from busy stations. Some owners replace the CP4 with a different pump design as prevention. A failed pump usually means a full fuel system replacement at a diesel shop.

  Shop: Duramax fuel filterShop: Duramax CP3 conversion kit▶ How-to videos

• DEF heater and NOx sensor problems

  Moderate DIY

  Signs: 'Poor DEF quality' or reduced power messages, check engine light.

  Fix: Scan for codes. Common fixes are a NOx sensor or the DEF heater and tank assembly.

  Shop: Duramax NOx sensorShop: Duramax DEF heater▶ How-to videos

• Worn idler arm and pitman arm

  Moderate DIY

  Signs: Loose, wandering steering, clunks, play in the steering wheel.

  Fix: Replace the idler arm and pitman arm, and check tie rods. Many owners add an idler arm support brace. Get an alignment afterward.

  Shop: idler armShop: pitman armShop: idler arm support kit▶ How-to videos

• Cracked dashboard

  Easy DIY

  Signs: Cracks across the dash top, especially near the passenger airbag.

  Fix: Cover it with a molded dash cover or replace the dash pad. Make sure a cover doesn't block the airbag.

  Shop: dash cover▶ How-to videos

Recalls

A recall doesn't mean a truck still has the problem. Enter the truck's VIN at nhtsa.gov/recalls or ask a dealer to see whether the repair was done.

• Air Bags:Frontal:Passenger Side:Inflator Module

  Feb 2021 · #21V051000

  General Motors, LLC (GM) is recalling certain 2012 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

  Risk and fix

  Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

  Fix: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 22, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on May 11, 2021. Owners may contact Cadillac customer service at 1-800-458-8006; Chevrolet customer service at 1-800-222-1020; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328770.

• Air Bags:Frontal:Passenger Side:Inflator Module

  Feb 2021 · #21V054000

  General Motors, LLC (GM) is recalling certain 2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of AL, CA, FL, GA, HI, LA, MS, SC, TX, PR, AS, GU, the MP, and VI or "Zone A." Additionally GM is recalling certain 2011-2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, Yukon XL and 2011-2013 Cadillac Escalade EXT, Chevrolet Avalanche, Silverado 1500, and GMC Sierra 1500 vehicles originally sold, or ever registered, in the states of AZ, AR, DE, DC, IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV or "Zone B." Additionally, GM is recalling certain 2010-2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, and Yukon XL and 2010-2013 Cadillac Escalade EXT, Chevrolet Avalanche, Silverado 1500, and GMC Sierra 1500 vehicles originally sold, or ever registered, in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY or "Zone C." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

  Risk and fix

  Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

  Fix: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 25, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed to 40 VIN owners on May 11, 2021. A second owner notification letter was mailed to all other owners on January 24, 2022. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328800.

• Equipment

  Apr 2018 · #18V267000

  General Motors LLC (GM) is recalling certain 2009-2014 Chevrolet Silverado HD and GMC Sierra HD, 2009 GMC Topkick 5000, 6000, 7000 and 8000 Series and Isuzu F Series, and 2009-2018 Chevrolet Express, and GMC Savana vehicles, equipped with certain Plastic-Handle Fire Extinguishers or Push Button 'Pindicator' Fire Extinguishers. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

  Risk and fix

  Risk: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

  Fix: GM will notify owners, instructing them to contact Kidde to get a replacement fire extinguisher, free of charge. The recall began June 11, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Isuzu customer service at 1-866-441-9638. GM's number for this recall is 18146.

Owner complaints by area

Reports owners filed with NHTSA. They aren't verified, and one complaint can mention more than one area. Tap an area to read the most recent ones.

• Air Bags12

  2 involved a crash

  • Filed Nov 2024

    The contact owns a 2012 GMC Sierra 2500. The contact received notification of NHTSA Campaign Number: 21V051000 (Air Bags); however, the part to do the recall repair was not yet available. The local dealer and an unknown dealer were contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect. .

  • Filed Sep 2021

    I received notice of a defective front airbag in February, 2021. As of now (about 7 months later) no action by GM to repair.

  • Filed Jul 2021

    NONE

  • Filed Jun 2021

    2012 GMC SIERRA. CONSUMER WRITES IN REGARDS TO PASSENGER SIDE AIRBAG SAFETY RECALL. THE CONSUMER STATED THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME COMPLETING THE RECALL REPAIR.

  • Filed Jan 2019

    DASH IS CRACKED NEAR PASSENGER SIDE AIR BAG, IF DEPLOYMENT WERE TO HAPPEN SHRAPNEL WILL FLY THROUGHOUT THE CAB. IVE SEEN THE SAME ISSUE ON NUMEROUS OTHER VEHICLES OF THE SAME GENERATION.

  • Showing the 5 most recent of 12.
• Electrical System11

  1 involved a crash · 1 involved a fire

  • Filed Sep 2023

    Driving on the expressway around 60 mph when the truck went into limp mode slowing me down to 40 and then would not shift gears Tcm went out gm told me that there is a big problem

  • Filed Aug 2023

    Failed TRANSMISSION CONTROL MODULE (24256861). While driving in the early morning hours (darkness) taking my child to school, I was navigating through a busy intersection when the vehicle surged and then made a loud metal on metal sound, feeling as if someone had struck me from behind. At that point the power train became inoperable, stranding us and coming very close to being first, struck from behind and then from cross traffic. The vehicle was/has been inspected by a GM technician at Starling Chevrolet, St Cloud, FL and the TCM was found to have failed (trouble code U0101, lost communication with TCM). It has been at the dealership for going on four months awaiting the production of a replacement part(TCM). There was no prior indication that the TCM was about to fail. Upon failure, all lights on the vehicle display flashed and the indicator for the vehicle drive position was lost (P, R, N, D), no longer visible.

  • Filed Mar 2016

    TL* THE CONTACT OWNS A 2012 GMC SIERRA 1500. THE CONTACT STATED THAT THE DASHBOARD NEAR THE PASSENGER SIDE AIR BAG WAS FRACTURED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE DASHBOARD NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 22,000.

  • Filed Feb 2016

    TL* THE CONTACT OWNS A 2012 GMC SIERRA 2500. WHEN USING THE SNOW PLOW, THE HEADLIGHTS DIMMED AND THE HEAT DECREASED AS IF IT WERE TURNED OFF. THE CONTACT MENTIONED THAT THE VOLTS DECREASED WHEN USING THE PLOW, WHICH MAY HAVE CAUSED THE FAILURE. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THE CAUSE OF THE FAILURE COULD NOT BE DIAGNOSED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND SENT AN INVESTIGATOR TO DIAGNOSE THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 18,500.

  • Filed Dec 2015

    TL* THE CONTACT OWNS A 2012 GMC SIERRA. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED A LOSS OF POWER WHICH RESULTED IN A FRONT END COLLISION WITH A GUARDRAIL. WHEN THE FAILURE OCCURRED, ALL THE WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS ABLE TO BE OPERATED AFTER THE CRASH. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC TO BE DIAGNOSED OR REPAIRED. A POLICE REPORT WAS FILED. THERE WERE NO INJURIES. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 75,000.

  • Showing the 5 most recent of 11.
• Unknown or Other10

  • Filed Feb 2025

    I'm following up on tracking number 11642264 that was submitted on Feb 12th for my 2012 GMC Sierra 2500 HD ignition lock issue that fits the profile for a current recall . I haven't heard anything and am checking on the current status. Thank you. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

  • Filed Feb 2025

    My 2012 GMC Sierra falls under recall number 14V827000 Ignition lock activator by year, make and model, but not by the VIN number. I called the GMC 800 number and they indicated that the NHTSA issues the recalls not the manufacturer. I then called the NHTSA and they indicated that the manufacturer issues the recalls. I just need to have VIN number [XXX] added to recall number 14V827000. Thank you. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

  • Filed Jan 2019

    DASH IS CRACKED NEAR PASSENGER SIDE AIR BAG, IF DEPLOYMENT WERE TO HAPPEN SHRAPNEL WILL FLY THROUGHOUT THE CAB. IVE SEEN THE SAME ISSUE ON NUMEROUS OTHER VEHICLES OF THE SAME GENERATION.

  • Filed Nov 2017

    TWO REAR TIRES HAVE BELT SEPARATION. TIRES ARE 2 YEARS OLD.

  • Filed Dec 2016

    CRACK IN DASHBOARD PASSENGER SIDE NEAR CORNER OF AIRBAG AND DRIVERS SIDE. CRACKED WHILE DRIVING. *TR

  • Showing the 5 most recent of 10.
• Structure10

  2 involved a fire

  • Filed Jan 2017

    MULTIPLE CRACKS IN DASHBOARD WHICH COULD POTENTIALLY FLY OFF DURING AIRBAG DEPLOYMENT

  • Filed Jan 2017

    1 DAY GOT IN TRUCK AND NOTICED THE DASH WAS CRACKED ON DRIVER SIDE BEHIND THE GAUGE CLUSTER AND AS I LOOKED I NOTICED IT WAS ALSO CRACKED AT THE 2 UPPER CORNERS OF THE PASSENGER AIR BAG. THE TRUCK ONLY HAS 25000 MILE ON IT. GM WILL NOT PAY TO HAVE IT FIXED AND I'M WORRIED THAT IT CAN AFFECT THE SAFETY OF THE AIR BAGS

  • Filed Dec 2016

    CRACK IN DASHBOARD PASSENGER SIDE NEAR CORNER OF AIRBAG AND DRIVERS SIDE. CRACKED WHILE DRIVING. *TR

  • Filed Jan 2016

    TL* THE CONTACT OWNS A 2012 GMC SIERRA. THE CONTACT STATED THAT THE DASHBOARD NEAR THE PASSENGER SIDE AIR BAG WAS FRACTURED. THE CONTACT TOOK THE VEHICLE TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE DASHBOARD NEEDED TO BE REPLACED. THE CONTACT INFORMED THE MANUFACTURER OF THE FAILURE. THE MANUFACTURER STATED THAT THE DASHBOARD WOULD BE ABLE TO BE REPLACED AT A DISCOUNTED PRICE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 67,000. UPDATED 09/28/16*LJ *TR

  • Filed Sep 2015

    TL* THE CONTACT OWNS A 2012 GMC SIERRA. THE CONTACT STATED THAT THE PASSENGER SIDE DASHBOARD WAS CRACKED ABOVE THE AIR BAG HOUSING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE DASHBOARD NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 57,000.

  • Showing the 5 most recent of 10.
• Engine8

  2 involved a fire

  • Filed Aug 2023

    Truck is a diesel. Fuel pump blew up and died in the middle of the street. Now I'm being told the Fuel system needs completely re done and will cost me 10g. I also found a lawsuit for this issue as well.

  • Filed Oct 2020

    WHILE TRAVELING ON THE INTERSTATE AT SPEED AND PASSING SLOWER TRAFFIC; ENGINE POWER FELL OFF, CHANGE FUEL FILTER NOW, ENGINE DERATE, AND CHECK ENGINE LITE, OCCURED. I HAD TO MANEUVER WITH NO POWER THROUGH THE TRAFFIC TO GET OUT OF THE TRAVEL LANES. I WAS THEN STRANDED ON THE INTERSTATE AS THE TRUCK WOULD NOT START. I WAS ABLE TO GET A MECHANIC TO COME AND CHANGE THE FUEL FILTER ON THE SIDE OF THE HIGHWAY, BUT THE TRUCK WOULD NOT START. THE TRUCK WAS EVENTUALLY TOWED TO A SHOP WHERE IT WAS DIAGNOSED WITH A CATASTROPHIC FAILURE OF THE FUEL PUMP (DIESEL MOTOR DRIVEN PUMP).

  • Filed Sep 2017

    EMISSIONS FAILURE. NOX SENSOR, DEF SYSTEM. DRIVING, DISPLAY STATES, POOR DEF QUALITY. TOOK IN FOR REPAIR, STILL DEF QUALITY. TRUCK HAS SLOWED TO 55MPH, WILL SLOW TO 4 MPH IN 39 MILES. THEY ARE TROWING PARTS AT IT AT MY EXPENSE. CAN'T PROPERLY DIAGNOSE. THIS PROBLEM IS FROM 2010- CURRENT MODELS OF THESE DIESELS.

  • Filed Feb 2015

    THE FUEL INJECTION PUMP CP4 HAD A CATASTROPHIC FAILURE AS I WAS DRIVING ON A HEAVILY TRAVELED FOUR LANE HIGHWAY, US RT.20. I LOST POWER STEERING AND BRAKES. I FELT FORTUNATE THAT I WAS NOT TOWING A 16,000 LB. FIFTH WHEEL CAMPER DOWN A MOUNTAIN ROAD.I SAY THIS BECAUSE IT WAS EXTREMELY DIFFICULT TO MAINTAIN CONTROL OVER THE TRUCK STEERING IT AND BRINGING IT TO A CONTROLLED STOP. I HAVE READ ABOUT THESE PUMPS FAILING ON NUMEROUS DIESEL FORD AND GM TRUCKS. I ALSO FEEL IF A WOMAN OR SMALL PERSON HAD THIS HAPPEN TO THEM THE OUTCOME COULD END IN LOSS OF CONTROL RESULTING IN INJURIES EVEN DEATHS. THE ONLY ONE THAT KNOWS THE ACTUAL NUMBER OF PUMPS THAT HAVE FAILED IS THE MANUFACTURERS, WHO WILL NOT SHARE THAT INFORMATION WILLINGLY. *JS

  • Filed Dec 2014

    ENGINE WILL INCREASE IDLE FROM 700 TO 900 AT ANY TIME. ONE CAN BE SITTING AT A TRAFFIC LIGHT AND IT MIGHT INCREASE OR DECREASE. I PULL A 5TH WHEEL (35 FEET) AND IT IS VERY DIFFICULT TO STOP WITH THE ENGINE TRYING TO KEEP GOING. ALSO IT IS VERY SCARY TO STOP ON SLIPPERY ROADS. THIS DID NOT START UNTIL THE VEHICLE HAD APPROX. 35,000 MILES ON IT. THE DEALER TELLS ME IT IS NORMAL, BUT I HAVE TALKED TO OWNERS OF THE GM DIESEL FROM MODEL YEAR 2008 THROUGH 2015 AND NONE OF THEM HAVE THIS CONDITION. *TR

  • Showing the 5 most recent of 8.
• Power Train6

  • Filed Sep 2023

    Driving on the expressway around 60 mph when the truck went into limp mode slowing me down to 40 and then would not shift gears Tcm went out gm told me that there is a big problem

  • Filed Aug 2023

    Failed TRANSMISSION CONTROL MODULE (24256861). While driving in the early morning hours (darkness) taking my child to school, I was navigating through a busy intersection when the vehicle surged and then made a loud metal on metal sound, feeling as if someone had struck me from behind. At that point the power train became inoperable, stranding us and coming very close to being first, struck from behind and then from cross traffic. The vehicle was/has been inspected by a GM technician at Starling Chevrolet, St Cloud, FL and the TCM was found to have failed (trouble code U0101, lost communication with TCM). It has been at the dealership for going on four months awaiting the production of a replacement part(TCM). There was no prior indication that the TCM was about to fail. Upon failure, all lights on the vehicle display flashed and the indicator for the vehicle drive position was lost (P, R, N, D), no longer visible.

  • Filed May 2023

    Transmission Control Module Failed

  • Filed Nov 2017

    TL* THE CONTACT OWNS A 2012 GMC SIERRA 2500. WHILE DRIVING APPROXIMATELY 45 MPH, THE VEHICLE JERKED, STALLED, AND LOST POWER. THE TRANSMISSION WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO COURTESY BUICK GMC LAFAYETTE (4750 JOHNSTON ST, LAFAYETTE, LA 70506 (337) 504-7342) WHERE IT WAS DIAGNOSED THAT THE TORQUE CONVERTER BLEW APART AND THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND CONFIRMED THAT NO WARRANTY OR RECALL WAS ASSOCIATED WITH THE VIN. THE APPROXIMATE FAILURE MILEAGE WAS 127,000.

  • Filed Apr 2016

    WHILE DRIVING AT NORMAL HIGHWAY SPEED, TRUCK SHUT OFF EXCEPT FOR THE LIGHTS. LOST POWERS STEERING, BRAKES ETC. ONCE I GOT THE TRUCK PULLED OVER AND STOPPED, ATTEMPTED TO RESTART. WAS UNABLE TO DO SO UNTIL THE 4TH ATTEMPT DURING A 5 MINUTES TIME SPAN. ONCE STARTED, APPEARED TO BE RUNNING FINE EXCEPT FOR THE MIL ON THE DASHBOARD WHICH WAS LIT.

  • Showing the 5 most recent of 6.
• Fuel/Propulsion System5

  • Filed Aug 2023

    Truck is a diesel. Fuel pump blew up and died in the middle of the street. Now I'm being told the Fuel system needs completely re done and will cost me 10g. I also found a lawsuit for this issue as well.

  • Filed Oct 2020

    WHILE TRAVELING ON THE INTERSTATE AT SPEED AND PASSING SLOWER TRAFFIC; ENGINE POWER FELL OFF, CHANGE FUEL FILTER NOW, ENGINE DERATE, AND CHECK ENGINE LITE, OCCURED. I HAD TO MANEUVER WITH NO POWER THROUGH THE TRAFFIC TO GET OUT OF THE TRAVEL LANES. I WAS THEN STRANDED ON THE INTERSTATE AS THE TRUCK WOULD NOT START. I WAS ABLE TO GET A MECHANIC TO COME AND CHANGE THE FUEL FILTER ON THE SIDE OF THE HIGHWAY, BUT THE TRUCK WOULD NOT START. THE TRUCK WAS EVENTUALLY TOWED TO A SHOP WHERE IT WAS DIAGNOSED WITH A CATASTROPHIC FAILURE OF THE FUEL PUMP (DIESEL MOTOR DRIVEN PUMP).

  • Filed Sep 2020

    FUEL FILTER HOUSING CONTAINS A PRIMER PUMP. NEEDED FOR A DIESEL. SEALS WITHIN THAT PUMP FAILED ALLOWING AIR INTO THE SYSTEM. VEHICLE IS 8 YEARS OLD AND ONLY HAS 67K MILES ON IT. THIS CAUSED THE MOTOR TO QUIT WHILE IN MOTION. IN YELLOWSTONE PARK.

  • Filed Aug 2018

    DRIVING EAST BOUND ON I70 COMING INTO DENVER. TRUCK SHUT OFF WITH NO WARNING AT 80MPH ON STEEP DOWNHILL GRADE CAUSING LOSS OF ALL POWER FACILITIES IN THE TRUCK. NO BRAKES, NO POWER STEERING. I ENDANGERED THE LIVES OF EVERY SINGLE PERSON ON THE ROAD THANKS TO THIS FAILED FUEL PUMP. FURTHER INVESTIGATION SHOWS BOSCH (THE PUMP MANUFACTURER) HAD INSTRUCTED GM TO USE A LIFT PUMP ON THIS ITEM AND THEY HAVE DISREGARDED THAT RECOMMENDATION LEAVING PEOPLE IN DANGER OF SERIOUS INJURY OR DEATH. THIS ITEM NEEDS A RECALL AND GM IS REFUSING TO DO SO BECAUSE THIS OCCURRENCE RENDERS THE TRUCK IN NEED OF 13K+ I'M REPAIRS. SHAME ON GM AND SHAME ON NHTSA FOR NOT DOING THEIR JOB.

  • Filed Dec 2017

    TL* THE CONTACT OWNS A 2012 GMC SIERRA 2500. WHILE DRIVING APPROXIMATELY 35 MPH, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE FOLLOWING DAY, WHILE DRIVING APPROXIMATELY 35 MPH, THE "SERVICE EXHAUST FLUID SYSTEM", "SEE OWNERS MANUAL NOW", AND "97 MILES BEFORE 65 MPH NAX SPEED" MESSAGES APPEARED. THE CONTACT DROVE THE VEHICLE TO THE DEALER (TRICE HUGHS GM IN PRINCETON, KENTUCKY) WHERE IT WAS DIAGNOSED THAT THE IN TANK FUEL SENSOR, THREE GLOW PLUGS, AND THE NOX SENSOR HAD SHORTED AND NEEDED REPLACEMENT. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 39,000.

• Service Brakes4

  2 involved a crash

  • Filed Sep 2015

    I PURCHASED A 2012 GMC SIERRA DENALI FROM STAHL MOTORS IN MONTEREY, CA IN FEBRUARY OF 2015. THEY ARE NOT WILLING TO PAY FOR THE DAMAGES TO MY TRUCK EVEN THOUGH THEY SOLD ME A COMPLETELY DANGEROUS VEHICLE, WHICH I WILL EXPLAIN. MY TRUCK DIDN'T FEEL RIGHT AS I WAS DRIVING SO I DECIDED TO TAKE IT TO A SHOP TO GET LOOKED AT. THERE IS A LONG LIST OF THINGS THAT IS WRONG WITH THE VEHICLE, BUT I WILL MENTION JUST THE MAIN ONES. THE TRUCK WAS SOLD TO ME WITHOUT THE REAR BRAKES HOOKED UP. THE BRAKE LINES FOR THE REAR CALIPERS WERE CAPPED OFF BY THE REAR DIFFERENTIAL. WHEN THE MECHANIC SHOP DISCOVERED THAT, THEY ALSO DISCOVERED THE MASTER CYLINDER WAS COMPLETELY DRY, WHICH CAUSED DAMAGE TO MY FRONT BRAKES. THERE WAS NO CROSS MEMBER UNDERNEATH THE VEHICLE FROM FRAME TO FRAME. IT WAS TORCHED OUT, THEREFOR LEAVING ZERO SUPPORT FOR THE FRAME OF THE TRUCK AS WELL AS THE FRONT DIFFERENTIAL. WHICH NEEDED TO BE REBUILT CAUSED FROM EXCESSIVE MOVEMENT LEFT TO RIGHT. FRONT DIFFERENTIAL NEEDED TO BE REBUILT CAUSED FROM THE DAMAGE OF NO CROSS MEMBER IN PLACE. BALL JOINTS WERE ALSO AFFECTED (ABOUT TO POP OUT OF CONTROL ARMS) DUE TO WRONG PARTS INSTALLED IN FRONT SUSPENSION OF VEHICLE.

  • Filed Feb 2015

    THE FUEL INJECTION PUMP CP4 HAD A CATASTROPHIC FAILURE AS I WAS DRIVING ON A HEAVILY TRAVELED FOUR LANE HIGHWAY, US RT.20. I LOST POWER STEERING AND BRAKES. I FELT FORTUNATE THAT I WAS NOT TOWING A 16,000 LB. FIFTH WHEEL CAMPER DOWN A MOUNTAIN ROAD.I SAY THIS BECAUSE IT WAS EXTREMELY DIFFICULT TO MAINTAIN CONTROL OVER THE TRUCK STEERING IT AND BRINGING IT TO A CONTROLLED STOP. I HAVE READ ABOUT THESE PUMPS FAILING ON NUMEROUS DIESEL FORD AND GM TRUCKS. I ALSO FEEL IF A WOMAN OR SMALL PERSON HAD THIS HAPPEN TO THEM THE OUTCOME COULD END IN LOSS OF CONTROL RESULTING IN INJURIES EVEN DEATHS. THE ONLY ONE THAT KNOWS THE ACTUAL NUMBER OF PUMPS THAT HAVE FAILED IS THE MANUFACTURERS, WHO WILL NOT SHARE THAT INFORMATION WILLINGLY. *JS

  • Filed Jul 2014

    PULLING INTO A PARKING SPOT IN A PARKING GARAGE GOING NO MORE THAN 3 MILES PER HOUR, OR HOWEVER FAST THIS VEHICLE CAN GO WHILE FOOT IS RESTING ON BRAKE, GETTING READY TO FULLY BRAKE. AS I PRESSED DOWN ON BRAKE TO STOP, THE VEHICLE CONTINUED AS IF THE ANTI-LOCK BRAKE SYSTEM SLIPPED, CAUSING THE TRUCK TO DRIVE FORWARD CRASHING THROUGH THE SHEETROCK WALL AND FINALLY STOPPING AFTER HITTING THE GLASS WINDOWS. TWO WEEKS LATER, AFTER ALL COSMETIC REPAIRS WERE DONE, THE VEHICLE DID THE SAME THING IN ANOTHER PARKING LOT, BUT LUCKILY BROKE BEFORE HITTING THE CURB AND LIGHT POST. I DID FEEL UNDER MY FOOT ON THE BRAKE PEDDLE, AS I PRESSED DOWN TO STOP, A SLIP OF SOME SORT WHICH AT THE SAME TIME CAUSED THE VEHICLE TO PUSH FORWARD RIGHT BEFORE STOPPING. THIS IS DEFINITELY A MALFUNCTION OF SOME SORT WITH THE ANTI-LOCK BRAKE SYSTEM. *TR

  • Filed Mar 2012

    JUST PURCHASES NEW 2012 GMC SIERRA 3500 , 400 MILES , HAVE HAD ALIGNMENT / STEERING PROBLEMS WITH A DRIFT TO LEFT AND A WONDERING STEERING WHEEL, ALSO BRAKE AND ABS LIGHTS ON, WENT TO DEALER THEY LOOKED AT IT FOR 2 HRS, AND SAID IT NEEDED A PART ORDERED AND THERE WAS A TSB ON IT, THE TECH SAID IT WOULD BE SAFE TO DRIVE BUT I WOULD NOT HAVE ABS BRAKES, ALSO HE WOULD CHECK ALIGNMENT AGAIN AT TIME WHEN PART CAME IN 4 DAYS EST, BRAKE AND ABS LIGHT REMAINED ON, VEHICLE DROVE FINE THE NEXT DAY UNTIL A ACCIDENT, WENT AROUND CURVEAT 55 MPH, APPLIED BRAKES TO SLOW, BRAKES WENT TO FLOOR UN ABLE TO SLOW AT ALL WENT OFF THE ROAD LOST CONTROL AND CRASHED INTO TREES, BOTH AIRBAGS DEPLOYED , WENT TO EMERGENCY ROOM WITH ARM INJURY AND RIB INJURIES, BRAND NEW TRUCK VERY SCARRY I WILL NEVER BUY A GM PODUCT AGAIN. *TR

• Vehicle Speed Control3

  • Filed Aug 2023

    Failed TRANSMISSION CONTROL MODULE (24256861). While driving in the early morning hours (darkness) taking my child to school, I was navigating through a busy intersection when the vehicle surged and then made a loud metal on metal sound, feeling as if someone had struck me from behind. At that point the power train became inoperable, stranding us and coming very close to being first, struck from behind and then from cross traffic. The vehicle was/has been inspected by a GM technician at Starling Chevrolet, St Cloud, FL and the TCM was found to have failed (trouble code U0101, lost communication with TCM). It has been at the dealership for going on four months awaiting the production of a replacement part(TCM). There was no prior indication that the TCM was about to fail. Upon failure, all lights on the vehicle display flashed and the indicator for the vehicle drive position was lost (P, R, N, D), no longer visible.

  • Filed Jun 2013

    TL* THE CONTACT OWNS A 2012 GMC SIERRA K-1500. THE CONTACT STATED THAT WHILE DRIVING 75 MPH, THE VEHICLE BEGAN TO DECELERATE AS THE WARNING LIGHTS IN THE INSTRUMENT PANEL ILLUMINATED. THE VEHICLE WOULD NOT ACCELERATE BEYOND 35 MPH. THE FAILURE WAS RESOLVED MOMENTARILY AFTER THE VEHICLE WAS RESTARTED BUT SOON RECURRED. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THEY WHERE UNABLE TO DUPLICATE THE FAILURE. THE FAILURE WAS NOT REPORTED TO THE MANUFACTURER. THE FAILURE MILEAGE WAS 7,000. THE CURRENT MILEAGE WAS 20,000. KMJ

  • Filed Oct 2012

    TL* THE CONTACT OWNS A 2012 GMC SIERRA. THE CONTACT STATED THAT WHILE DRIVING UPHILL AND ATTEMPTING TO DECELERATE. THE VEHICLE ACCELERATED ABNORMALLY. IN ORDER TO STOP THE VEHICLE, THE CONTACT ABRUPTLY APPLIED THE BRAKES AS THE ENGINE EXHIBITED A LOUD THUMP. THE CONTACT TOOK THE VEHICLE TO THE DEALER BUT THEY WERE UNABLE TO DUPLICATE THE FAILURE. THE FAILURE AND THE CURRENT MILEAGES WERE 5,545. UPDATED 13/13/12 *CN

• Suspension3

  1 involved a crash

  • Filed Jan 2019

    WELL I KEEP DRIVING MY TRUCK. AND MY AIRBAG LIGHT IS ON. SO THERE FOR IF I GET HIT THEY NOT GOING TO COME OUT AND PROTECT ME. AND I'M HAVING BAD ISSUES WITH MY BALL JOINTS. ON MY 2012 GMC 2500 HD. I'VE PUT 2 SETS ON THEM. AND I'VE ONLY HAD IT A YEAR. YOU GOTTA DO SOMETHING ABOUT THAT.

  • Filed Sep 2015

    I PURCHASED A 2012 GMC SIERRA DENALI FROM STAHL MOTORS IN MONTEREY, CA IN FEBRUARY OF 2015. THEY ARE NOT WILLING TO PAY FOR THE DAMAGES TO MY TRUCK EVEN THOUGH THEY SOLD ME A COMPLETELY DANGEROUS VEHICLE, WHICH I WILL EXPLAIN. MY TRUCK DIDN'T FEEL RIGHT AS I WAS DRIVING SO I DECIDED TO TAKE IT TO A SHOP TO GET LOOKED AT. THERE IS A LONG LIST OF THINGS THAT IS WRONG WITH THE VEHICLE, BUT I WILL MENTION JUST THE MAIN ONES. THE TRUCK WAS SOLD TO ME WITHOUT THE REAR BRAKES HOOKED UP. THE BRAKE LINES FOR THE REAR CALIPERS WERE CAPPED OFF BY THE REAR DIFFERENTIAL. WHEN THE MECHANIC SHOP DISCOVERED THAT, THEY ALSO DISCOVERED THE MASTER CYLINDER WAS COMPLETELY DRY, WHICH CAUSED DAMAGE TO MY FRONT BRAKES. THERE WAS NO CROSS MEMBER UNDERNEATH THE VEHICLE FROM FRAME TO FRAME. IT WAS TORCHED OUT, THEREFOR LEAVING ZERO SUPPORT FOR THE FRAME OF THE TRUCK AS WELL AS THE FRONT DIFFERENTIAL. WHICH NEEDED TO BE REBUILT CAUSED FROM EXCESSIVE MOVEMENT LEFT TO RIGHT. FRONT DIFFERENTIAL NEEDED TO BE REBUILT CAUSED FROM THE DAMAGE OF NO CROSS MEMBER IN PLACE. BALL JOINTS WERE ALSO AFFECTED (ABOUT TO POP OUT OF CONTROL ARMS) DUE TO WRONG PARTS INSTALLED IN FRONT SUSPENSION OF VEHICLE.

  • Filed Mar 2012

    JUST PURCHASES NEW 2012 GMC SIERRA 3500 , 400 MILES , HAVE HAD ALIGNMENT / STEERING PROBLEMS WITH A DRIFT TO LEFT AND A WONDERING STEERING WHEEL, ALSO BRAKE AND ABS LIGHTS ON, WENT TO DEALER THEY LOOKED AT IT FOR 2 HRS, AND SAID IT NEEDED A PART ORDERED AND THERE WAS A TSB ON IT, THE TECH SAID IT WOULD BE SAFE TO DRIVE BUT I WOULD NOT HAVE ABS BRAKES, ALSO HE WOULD CHECK ALIGNMENT AGAIN AT TIME WHEN PART CAME IN 4 DAYS EST, BRAKE AND ABS LIGHT REMAINED ON, VEHICLE DROVE FINE THE NEXT DAY UNTIL A ACCIDENT, WENT AROUND CURVEAT 55 MPH, APPLIED BRAKES TO SLOW, BRAKES WENT TO FLOOR UN ABLE TO SLOW AT ALL WENT OFF THE ROAD LOST CONTROL AND CRASHED INTO TREES, BOTH AIRBAGS DEPLOYED , WENT TO EMERGENCY ROOM WITH ARM INJURY AND RIB INJURIES, BRAND NEW TRUCK VERY SCARRY I WILL NEVER BUY A GM PODUCT AGAIN. *TR

• Steering3

  1 involved a crash

  • Filed Feb 2015

    THE FUEL INJECTION PUMP CP4 HAD A CATASTROPHIC FAILURE AS I WAS DRIVING ON A HEAVILY TRAVELED FOUR LANE HIGHWAY, US RT.20. I LOST POWER STEERING AND BRAKES. I FELT FORTUNATE THAT I WAS NOT TOWING A 16,000 LB. FIFTH WHEEL CAMPER DOWN A MOUNTAIN ROAD.I SAY THIS BECAUSE IT WAS EXTREMELY DIFFICULT TO MAINTAIN CONTROL OVER THE TRUCK STEERING IT AND BRINGING IT TO A CONTROLLED STOP. I HAVE READ ABOUT THESE PUMPS FAILING ON NUMEROUS DIESEL FORD AND GM TRUCKS. I ALSO FEEL IF A WOMAN OR SMALL PERSON HAD THIS HAPPEN TO THEM THE OUTCOME COULD END IN LOSS OF CONTROL RESULTING IN INJURIES EVEN DEATHS. THE ONLY ONE THAT KNOWS THE ACTUAL NUMBER OF PUMPS THAT HAVE FAILED IS THE MANUFACTURERS, WHO WILL NOT SHARE THAT INFORMATION WILLINGLY. *JS

  • Filed Jul 2014

    TL* THE CONTACT OWNS A 2012 GMC SIERRA 1500. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE RIGHT AND LEFT TURN SIGNAL AND SAFETY BELT CHIME STOPPED WORKING. ALSO, THE RADIO MALFUNCTIONED AND THE VEHICLE VEERED TO THE RIGHT. THE MANUFACTURER WAS NOT CONTACTED AND THE VEHICLE WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 60,000 AND THE CURRENT MILEAGE WAS 65,274. UPDATED 10/2/14*CN THE CONSUMER STATED THAT THE INTERIOR LIGHTS ALSO WENT OUT. THE VEHICLE WAS REPAIRED UNDER RECALL. UPDATED 3/9/15 *JS

  • Filed Mar 2012

    JUST PURCHASES NEW 2012 GMC SIERRA 3500 , 400 MILES , HAVE HAD ALIGNMENT / STEERING PROBLEMS WITH A DRIFT TO LEFT AND A WONDERING STEERING WHEEL, ALSO BRAKE AND ABS LIGHTS ON, WENT TO DEALER THEY LOOKED AT IT FOR 2 HRS, AND SAID IT NEEDED A PART ORDERED AND THERE WAS A TSB ON IT, THE TECH SAID IT WOULD BE SAFE TO DRIVE BUT I WOULD NOT HAVE ABS BRAKES, ALSO HE WOULD CHECK ALIGNMENT AGAIN AT TIME WHEN PART CAME IN 4 DAYS EST, BRAKE AND ABS LIGHT REMAINED ON, VEHICLE DROVE FINE THE NEXT DAY UNTIL A ACCIDENT, WENT AROUND CURVEAT 55 MPH, APPLIED BRAKES TO SLOW, BRAKES WENT TO FLOOR UN ABLE TO SLOW AT ALL WENT OFF THE ROAD LOST CONTROL AND CRASHED INTO TREES, BOTH AIRBAGS DEPLOYED , WENT TO EMERGENCY ROOM WITH ARM INJURY AND RIB INJURIES, BRAND NEW TRUCK VERY SCARRY I WILL NEVER BUY A GM PODUCT AGAIN. *TR

• Tires2

  • Filed Aug 2026

    The contact owns a 2012 GMC Sierra 2500 equipped with Armstrong Tires, Tire Line: Tru Trac HT, Tire Size: 245/75/17, DOT Number: 1E6DAE022625. The contact stated that the vehicle was taken to an independent mechanic for a routine tire rotation but was informed there were massive bubbles on the tires, and on one tire, there was a bulge the size of an apple on the sidewall of the tire. The contact replaced the tires. The local dealer was not contacted. The manufacturer was contacted and declined to accept the mileage claim and requested photos of the tires. The tire failure mileage was approximately 27,000. The vehicle failure mileage was approximately 146,500.

  • Filed Jul 2015

    TL* THE CONTACT OWNS A 2012 GMC SIERRA 2500 EQUIPPED WITH PATHFINDER LT24575R16 TIRES, SIZE: 265/70R17 (NA). WHILE DRIVING 70 MPH, THE REAR END OF THE VEHICLE BEGAN TO VIBRATE AND THE REAR DRIVER SIDE TIRE BLEW OUT AND DAMAGED THE WHEEL PANEL. THE CONTACT REPLACED THE TIRE WITH THE SPARE TIRE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE REAR DRIVER SIDE TIRE TREAD SEPARATED. THE TIRE WAS NOT REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE TIRE AND VEHICLE FAILURE MILEAGE WAS 45,391. UPDATED 09/21/15*LJ UPDATED 12/4/2017*CN

• Electronic Stability Control (esc)2

  1 involved a crash

  • Filed Jul 2014

    PULLING INTO A PARKING SPOT IN A PARKING GARAGE GOING NO MORE THAN 3 MILES PER HOUR, OR HOWEVER FAST THIS VEHICLE CAN GO WHILE FOOT IS RESTING ON BRAKE, GETTING READY TO FULLY BRAKE. AS I PRESSED DOWN ON BRAKE TO STOP, THE VEHICLE CONTINUED AS IF THE ANTI-LOCK BRAKE SYSTEM SLIPPED, CAUSING THE TRUCK TO DRIVE FORWARD CRASHING THROUGH THE SHEETROCK WALL AND FINALLY STOPPING AFTER HITTING THE GLASS WINDOWS. TWO WEEKS LATER, AFTER ALL COSMETIC REPAIRS WERE DONE, THE VEHICLE DID THE SAME THING IN ANOTHER PARKING LOT, BUT LUCKILY BROKE BEFORE HITTING THE CURB AND LIGHT POST. I DID FEEL UNDER MY FOOT ON THE BRAKE PEDDLE, AS I PRESSED DOWN TO STOP, A SLIP OF SOME SORT WHICH AT THE SAME TIME CAUSED THE VEHICLE TO PUSH FORWARD RIGHT BEFORE STOPPING. THIS IS DEFINITELY A MALFUNCTION OF SOME SORT WITH THE ANTI-LOCK BRAKE SYSTEM. *TR

  • Filed Jan 2013

    APPARENTLY GM USES PEANUT OIL TO LUBRICATE WIRING SO THEY CAN MORE EASILY INSULATE, ETC (ACCORGING TO THE GM DEALER). THIS ATTRACTS RATS AND MICE WHICH CHEW UP THE WIRING - POTENTIALLY IMPACTING SENSORS AND OTHER ITEMS CONTROLLING CRUISE, STABILITY/TRACTION CONTROL, AND ANY NUMBER OF ELECTRICAL SYSTEMS THAT THE DRIVER MAY BE RELYING UPON FOR SAFETY. I ACTUALLY HAD MAP SENSOR WIRES CHEWED UP THAT DISABLED MY STABILITY/TRACTION SYSTEMS AND INHIBITED ENGINE PERFORMANCE. LUCKILY FOR ME IT HAPPENED IN MY DRIVEWAY RATHER THAN ON THE HIGHWAY. DEALER CLAIMS IT IS NOT WARRANTY ITEM EVEN THOUGH CAUSED BY A PROCESS THAT GM ELECTS TO USE IN BUILDING THE VEHICLE. THIS COULD IMPACT ANY/EVERY VEHICLE THAT GM BUILDS WITH USE OF PEANUT OIL (MAY INDEED BE ALL OF THEIR MODELS). *TR

• Wheels2

  1 involved a fire

  • Filed Mar 2014

    WHILE THE VEHICLE WAS BEING DRIVEN, IT JUST WENT DEAD, NO ENGINE, NO ELECTRIC, NO NOTHING. THE VEHICLE WAS LEFT IN PLACE AND AT SOME POINT, CAUGHT FIRE AND BURNED. A TOTAL LOSS. TO DATE, THE INSURANCE COMPANY HAS NOT PAID ME FOR MY LOSS BUT RATHER HAS GONE TO GREAT LENGTHS TO INVESTIGATE ME PERSONALLY, LOOKING FOR ANY REASON TO NOT PAY. SO, I'VE BEEN MAKING TWO VEHICLE PAYMENTS FOR THE LAST 8 MONTHS. AS A RESULT, I AM STRUGGLING FINANCIALLY. *TR

  • Filed Sep 2013

    I PURCHASED A NEW GMC SIERRA HD2500 SLE IN JUNE, IT CAME WITH 20" ALLOY WHEELS AND GOODYEAR WRANGLER SRA TIRES (LT265-60R20), LOAD RANGE E. WITHIN 3 DAYS, I HAD A SIDEWALL PUNCTURE ON ONE TIRE WHILE DRIVING ON OUR RANCH. THE TIRE HAD TO BE REPLACED. NOW, JUST YESTERDAY, SEP. 15, I HAD ANOTHER SIDEWALL PUNCTURE WHILE DRIVING ON THE RANCH. I JUST LEFT THE LOCAL DISCOUNT TIRE, WHERE THEY ARE WAITING FOR A NEW TIRE TO ARRIVE SO THEY CAN REPLACE THE OLD TIRE. I'VE BEEN LIVING ON THIS RANCH FOR 47 YEARS NOW, AND HAVE OWNED AT LEAST 10 TRUCKS AND 2 SUBURBANS OVER THE YEARS. THERE IS A 3.5 MILE LOOP ROAD THAT RUNS AROUND THE RANCH, AND I DRIVE IT REGULARLY. THESE TWO FLATS ARE THE ONLY TWO I'VE EVER EXPERIENCED IN DRIVING THIS LOOP ROAD, WHICH IS A COMBINATION OF CALICHE AND LIMESTONE. THE ROAD IS NOT GREAT, BUT IT'S NOT TERRIBLE EITHER; AND I FIND IT VERY ODD TO HAVE TWO FAILURES WITHIN 4 MONTHS. (TOTAL MILEAGE ON THE TRUCK IS NOW 9250.) I'M THINKING IT'S ENTIRELY POSSIBLE THAT THESE WRANGLERS HAVE A WEAKER THAN NORMAL SIDEWALL; THE WORKER AT DISCOUNT TIRE TOLD ME THAT MY "NORMAL" TRUCK TIRE, A GOODRICH DUELER AT, DID IN FACT HAVE AN ADDITIONAL SIDEWALL LAYER COMPARED TO THE GOODYEAR. IN ANY RESPECT, I'M CALLING THIS TO YOUR ATTENTION IN CASE THERE ACTUALLY IS SOME MANUFACTURING DEFECT THAT I SHOULD KNOW ABOUT. I WOULD APPRECIATE HEARING YOUR THOUGHTS ON THIS ISSUE. *TR

• Visibility1

  • Filed May 2014

    PASSANGER FRONT DOOR HANDLE FAILURE. LOUD NOISE WAS HEARD UPON CLOSING OF THE DOOR. DOOR HANDLE PULL CLEAR FROM THE DOOR. WINDOW CANNOT BE ROLLED DOWN AND INTERNAL DOOR HANDLE IS INOPERABLE. *JS

• Latches/Locks/Linkages1

  • Filed May 2014

    PASSANGER FRONT DOOR HANDLE FAILURE. LOUD NOISE WAS HEARD UPON CLOSING OF THE DOOR. DOOR HANDLE PULL CLEAR FROM THE DOOR. WINDOW CANNOT BE ROLLED DOWN AND INTERNAL DOOR HANDLE IS INOPERABLE. *JS

• Exterior Lighting1

  1 involved a fire

  • Filed Oct 2012

    VEHICLE WAS TAKEN TO GMC DEALER FOR HEADLIGHT DEFECT AND WE WERE INFORMED THAT THEY WOULD HAVE TO ORDER PARTS. DROVE TRUCK BACK TO SITE AND WHILE TRUCK WAS RUNNING BUT STATIONARY SMOKE WAS OBSERVED COMING FROM THE ENGINE COMPARTMENT. WHEN THE HOOD WAS RAISED THE ENTIRE TRUCK BECAME ENGULFED AND COMPLETELY BURNED. *TR

• Visibility/Wiper1

  • Filed Aug 2012

    PURCHASE A NEW 2012 GMC SIERRA SLE ON 07/26/12. AS I LEAVE FOR WORK IN THE EARLY HOURS, IT REQUIRES THAT I USE THE DEFOG/DEFROST. ON THE MORNING OF THE 28TH I SELECTED THE DEFOG/DEFROST AND ONLY THE DRIVER'S SIDE CLEARED. THINKING IT MAY BE ISOLATED, I RECEIVED THE SAME RESULT ON THE 29TH. I CALLED THE SELLING DEALER ABOUT ANOTHER MATTER AND MENTIONED THIS PROBLEM. ON AUGUST 9TH THE TRUCK WAS TAKEN FOR SERVICE AND TO ADDRESS THIS ISSUE. WAS TOLD THAT IT IS OPERATING AS NORMAL AND THE DEALER TESTED TWO OTHER NEW TRUCKS. STILL NOT HAPPY WITH THE ANSWER, I CALLED GMC. THEY SETUP SERVICE AT ANOTHER DEALERSHIP FOR THE 16TH. AGAIN, NO PROBLEMS COULD BE FOUND PER THEIR TESTING, BUT WERE GOING TO CHANGE THE DUCT AS THE AIR FLOW WAS MUCH GREATER TO THE DRIVER'S SIDE. WHEN THE DUCT CAME IN, THEY OPTED NOT TO CHANGE IT, AS IT REQUIRES TO STRIP THE DASH TO THE WINDSHIELD. ALL THIS TIME GMC WAS UPDATED OF THE PROGRESS. THE SYSTEM DOESN'T CLEAR THE PASSENGER SIDE OF THE WINDSHIELD AND PASSENGER DOOR WINDOW. GMC STAND IS, THAT ENGINEERING DESIGN THE SYSTEM THIS WAY TO CLEAR THE DRIVER'S SIDE QUICKER DURING POOR WEATHER, AS LIKE SNOW AND ICE. MY STAND IS THAT THIS IS NOT A PROPER ANSWER FOR A VEHICLE MAKER TO STATE. THIS ISSUE MAKES THE VEHICLE UNSAFE TO OPERATE AND I DO NOT LIVE WITHIN AN AREA SEEING THIS TYPE OF WEATHER OFTEN. I HAVE READ MANY INTERNET ARTICLES RELATED TO THIS. OTHER OWNERS TRUCKS OPERATE PROPERLY CLEARING BOTH SIDES OR HAVE HAD THEM PROPERLY REPAIRED IF THEY HAVE HAD THE SAME ISSUE. I NEED TO HAVE MY VEHICLE REPAIRED SO THAT IT CAN BE OPERATED SAFELY. GMC WILL NOT ADMIT THAT THIS IS A PROBLEM REQUIRING REPAIRS. *TR

• Hydraulic1

  1 involved a crash

  • Filed Mar 2012

    JUST PURCHASES NEW 2012 GMC SIERRA 3500 , 400 MILES , HAVE HAD ALIGNMENT / STEERING PROBLEMS WITH A DRIFT TO LEFT AND A WONDERING STEERING WHEEL, ALSO BRAKE AND ABS LIGHTS ON, WENT TO DEALER THEY LOOKED AT IT FOR 2 HRS, AND SAID IT NEEDED A PART ORDERED AND THERE WAS A TSB ON IT, THE TECH SAID IT WOULD BE SAFE TO DRIVE BUT I WOULD NOT HAVE ABS BRAKES, ALSO HE WOULD CHECK ALIGNMENT AGAIN AT TIME WHEN PART CAME IN 4 DAYS EST, BRAKE AND ABS LIGHT REMAINED ON, VEHICLE DROVE FINE THE NEXT DAY UNTIL A ACCIDENT, WENT AROUND CURVEAT 55 MPH, APPLIED BRAKES TO SLOW, BRAKES WENT TO FLOOR UN ABLE TO SLOW AT ALL WENT OFF THE ROAD LOST CONTROL AND CRASHED INTO TREES, BOTH AIRBAGS DEPLOYED , WENT TO EMERGENCY ROOM WITH ARM INJURY AND RIB INJURIES, BRAND NEW TRUCK VERY SCARRY I WILL NEVER BUY A GM PODUCT AGAIN. *TR

• Engine And Engine Cooling1

  • Filed Mar 2012

    TL* THE CONTACT OWNS A 2012 GMC SIERRA. THE CONTACT STATED THAT WHENEVER THE VEHICLE WAS IDLING THE CONTACT NOTICED THAT THE VEHICLE WOULD VIBRATE WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS INFORMED THAT THE FAILURE COULD NOT BE REPAIRED. THE CURRENT AND THE FAILURE MILEAGES WERE 1,200. ..UPDATED 04/16/12 *BF UPDATED 05/07/12

Safety ratings

NHTSA 5-Star Safety Ratings from government crash tests. Ratings can differ by cab style and 2WD/4WD.