2024 Chevrolet Silverado 3500HD

What owners should know

Covers 2020–2026 · 6.6L Duramax L5P diesel and 6.6L V8 gas · Updated 2026-10-01

Researched from owner forums and NHTSA complaints and written by Know Your Truck. These are patterns in what owners report, not a guarantee about any particular truck.

Common failures & how to fix them

Parts and video buttons search for your 2024 Chevrolet Silverado 3500HD. Always confirm a part fits using your VIN. Brakes, steering, fuel and airbag work affects your safety, so if you're not sure, have a qualified mechanic do it.

• 10-speed transmission valve body failure

  Dealer (recall)

  Signs: Sudden hard downshifts, limp mode, or rear wheel lock-up on diesels.

  Fix: Covered by GM recalls on 2020–2022 diesels. Other repairs are usually under warranty on newer trucks. Ask a dealer for all open recalls and bulletins.

  May be covered free by recall 24V797000 / 26V083000. Check the VIN at nhtsa.gov/recalls.

• Trailer brake controller warnings

  Easy DIY

  Signs: 'Check trailer wiring' or 'Trailer brakes disconnected' messages that cut the trailer brakes.

  Fix: Clean and inspect the 7-pin trailer connector and the trailer's wiring first. If it continues, have a dealer check for bulletins and module updates.

  Shop: 7 pin trailer connector▶ How-to videos

• Power tailgate opens unexpectedly

  Dealer (recall)

  Signs: The tailgate unlatches by itself, often after water gets in.

  Fix: Covered by GM recalls on 2020–2024 trucks with power-unlatching tailgates.

  May be covered free by recall 24V060000 / 24V894000. Check the VIN at nhtsa.gov/recalls.

• Steering gear shaft can break (2024)

  Dealer (recall)

  Signs: Loose steering or a clunk. In rare cases loss of steering.

  Fix: Covered by a GM recall on some 2024 trucks.

  May be covered free by recall 23V549000. Check the VIN at nhtsa.gov/recalls.

Recalls

A recall doesn't mean a truck still has the problem. Enter the truck's VIN at nhtsa.gov/recalls or ask a dealer to see whether the repair was done.

• Latches/Locks/Linkages:Tailgate:Latch

  Nov 2024 · #24V894000

  General Motors, LLC (GM) is recalling certain 2024 Chevrolet Silverado HD 2500, 3500, and GMC Sierra HD 2500, 3500 vehicles equipped with power-unlatching tailgates. The tailgate's electronic gate-release switch may short circuit due to water intrusion, which can result in the tailgate inadvertently unlatching while the vehicle is in Park.

  Risk and fix

  Risk: An unlatched tailgate may open and result in a loss of unsecured cargo, creating a road hazard and increasing the risk of a crash.

  Fix: Owners are advised to check that the tailgate is closed and latched before driving. Dealers will replace the exterior touchpad switch assemblies, free of charge. Owner notification letters were mailed December 17, 2024. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is N242469160. This recall is an expansion of NHTSA Recall 24V-060.

• Latches/Locks/Linkages:Tailgate:Latch

  Feb 2024 · #24V060000

  General Motors, LLC (GM) is recalling certain 2020-2024 Chevrolet Silverado 2500, 3500, GMC Sierra 2500 and 3500 vehicles equipped with power-unlatching tailgates. The tailgate's electronic gate-release switch may short circuit due to water intrusion, which can result in the tailgate inadvertently unlatching while the vehicle is in park.

  Risk and fix

  Risk: An unlatched tailgate may open while driving and result in a loss of unsecured cargo, creating a road hazard and increasing the risk of a crash.

  Fix: Owners are advised to check that the tailgate is closed and latched before driving. Dealers will replace the exterior touchpad switch assemblies, free of charge. Owner notification letters were mailed May 17, 2024. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is N232426400.

• Steering

  Aug 2023 · #23V549000

  General Motors, LLC (GM) is recalling certain 2024 Chevrolet Silverado 2500, 3500, and GMC Sierra 2500, 3500 vehicles. The steering gear shaft may fracture and disconnect from the steering arm.

  Risk and fix

  Risk: A steering arm that disconnects may result in a total loss of steering control, increasing the risk of a crash.

  Fix: Dealers will inspect and replace the steering gear, if necessary, free of charge. Owner notification letters were mailed September 22, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is N232414720.

Owner complaints by area

Reports owners filed with NHTSA. They aren't verified, and one complaint can mention more than one area. Tap an area to read the most recent ones.

• Electrical System19

  • Filed Aug 2026

    The infotainment/control module in my 2024 Silverado 3500HD failed unexpectedly while I was traveling cross-country. The module is available for inspection upon request. Prior to the failure, I did not receive any warning lamps or messages. When the system failed, I lost access to multiple camera systems integrated into the vehicle, including backup and visibility-assistance cameras used to aid lane changes, parking, maneuvering, and identifying obstacles around the truck. Due to the size and height of this vehicle, these cameras provide important visibility of areas that are difficult to observe directly, including pedestrians, cyclists, and children who may be below the driver's line of sight. The loss of these camera systems reduced situational awareness and increased the risk of a collision while backing, changing lanes, or operating the vehicle in crowded areas. The failure also disabled navigation, hands-free functions, audio, WiFi connectivity, and access to vehicle settings controlled through the infotainment system. The vehicle was inspected by a Chevrolet dealer in Cape Cod, Massachusetts. The dealer attempted a software reflash to correct the issue; however, the procedure rendered the unit completely inoperable. The dealer confirmed that the module required replacement and quoted an estimated repair cost of approximately $1,500. The required replacement part was unavailable, and despite contacting numerous Chevrolet dealerships, I was unable to obtain a repair during my trip. As a result, I was required to continue operating the vehicle while towing a large trailer for an extended period without the camera systems and related functionality. I have also become aware of GM Service Bulletin PIC6630B, which indicates that GM has identified this failure mode and that it is not an isolated occurrence. Given that a single module failure can disable multiple safety features, I request that it be evaluated by an independent authority accordingly.

  • Filed Jun 2026

    I was driving down the XXX Expressway Sunday, XXX, with my children in my vehicle. This is a very heavily traveled highway in [XXX] with heavy traffic. My 2024 Chevy Silverado 3500 Diesel HD Truck with 25,500 miles suddenly started throwing multiple codes, lost power, and steering. Fortunately I was able to "roll into" the emergency lane while muscling the steering in that direction and engaged the emergency brake. My other son was following shortly behind me in his vehicle and pulled over to assist us about 30 mins after my truck was sitting stalled in the HWY. He parked his truck behind mine, put on his hazards, and we were transferring gear from my truck to his truck. At this point my 2024 Chevy HD Silverado Diesel started rolling back on it's own and nearly crushed my son's friend. The parking break was on and it suddenly released on it's own. It took 3 grown men to stop it from crushing my son's friend. The force was so strong that when he lifted his hand to try to stop the truck from rolling, it broke the right rear tail light. He could have been crushed between our two trucks from this situation. I have never been notified by GM of any recalls, however, the truck had to be towed to Ferman Cheverlotte service on Adamo Dr, Tampa Fl and is currently sitting on their lot. I was told by the service tech Michael Stevens that the vehicle had several open recalls that they would address but did not offer any information about what could be wrong. After searching online, I found that GM IS aware of this issue and sent several service bulletins about this exact problem. I had contacted the Ferman service center the week before to bring the truck in because the AC was out and made an appointment for service on Tuesday. The day after I made the appointment my batteries died and had to be replaced by AAA.It is disturbing to know GM and FERMAN Service centers are aware of this safety issue on these HD trucks and never informed me, the consumer. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

  • Filed Mar 2026

    Trailer brakes and lights come and go. I start with having everything then loose brakes and lights when I’m driving. This is apparently a known issue that they have a fix for but I have never received anything about a recall.

  • Filed Jan 2026

    Email Subject I am reporting a serious safety-related defect involving sudden and complete vehicle shutdown while driving in a 2024 Chevrolet Silverado EV RST. Component/System Involved: The failure appears related to the 12-volt electrical system and associated vehicle control electronics. When the vehicle detects the 12V battery as dead or critically low, it immediately disables propulsion and control systems. The exact failed component is UNKNOWN. The vehicle is available for inspection upon request. Incident Description: This failure has occurred twice under similar conditions (ambient temperature approximately 25°F). On November 28, 2024 and again on January 2, 2026, after driving approximately two blocks at low residential speeds, the vehicle abruptly and completely shut down while in motion. In both incidents, the shutdown was immediate, without warning, and accompanied by a loud thud and an extremely abrupt stop. Safety Risk: In both incidents, the vehicle became completely immobilized in the roadway. I was unable to steer to the side of the road, restart the vehicle, or shift it into gear to move it out of traffic. This created a significant risk of collision. A similar failure at highway speeds could result in a severe or fatal crash. Warnings or Prior Symptoms: No warning lamps, messages, alerts, or other symptoms appeared prior to either shutdown. Problem Confirmation or Reproduction: The issue has occurred twice under cold-weather conditions. Inspections: After the first incident, the 12V battery was inspected and no issues were found. Following the second incident, the vehicle is currently being inspected at a Chevrolet dealership. No police or insurance inspections were performed. This behavior suggests the vehicle lacks a fail-safe or degraded-operation mode for 12V system failure and instead performs an immediate shutdown while in motion, which may represent a serious safety defect warranting investigation.

  • Filed Aug 2025

    The contact owns a 2024 Chevrolet Silverado 3500. The contact stated that while driving 30 MPH and attempting to depress the brake pedal, the message “Trailer Brakes Disabled” was displayed. A dealer was contacted. The vehicle was taken to the dealer, and the contact was informed the contact the vehicle was operating as designed, and that neither the vehicle nor the trailer would be diagnosed. The vehicle was not repaired. The manufacturer was notified of the failure and opened a case. The approximate failure mileage was 12,000.

  • Showing the 5 most recent of 19.
• Power Train15

  1 involved a crash

  • Filed Sep 2026

    The Engine Cooler has a know defect that GM has put out service bulletins for. The engine cooler is cracking, mixing oil and antifreeze that is creating a sludge that runs thru the entire system. GM wants techs to attempt to clean/flush the engine before they approve a new engine to be ordered under warranty. GM is aware of the problem and there should be a recall out on the problem according to the service manager I spoke with at the dealership my truck is at currently. I was told the expected time frame is up to 3 months for the work to be completed, with no loaner available that is equivalent to the vehicle that went to the shop. The recall is necessary because if the engine has a major failure while driving it could cause an accident, if the vehicle is hauling a heavy trailer that could be detrimental because the truck can haul up to 40,000 GCWR.

  • Filed Jul 2026

    moved the truck on to the lawn and put it in park turned truck off. got out of the truck and went into the garage and 5 min later came out and saw the truck started to roll and went 50 ft and hit a tree.

  • Filed Jul 2026

    Transmission has shifting issues (hard shifts) . Vehicle is available for inspection upon request. Safety could be an issue if the transmission fails while driving that could cause harm to the vehicle driver and put others at risk. Vehicle is scheduled for inspection however the dealer is very backlogged.

  • Filed Mar 2026

    REAR WHEEL LOCKUP: While driving down the highway pulling a loaded trailer the rear wheels locked up, GM has an open recall on 2020-2022 models but denies its an issue with the 2024 model, my dealership pushed a “software update” but that does not fix the faulty transmission valve body issue, it just overrides the safety features that were designed to protect the transmission. I have a video of it occurring while slowing down for a stop sign when it did it the second time to me.

  • Filed Mar 2026

    The engine oil cooler failed causing engine oil to leak into the coolant system on my 2024 Chevy Silverado 3500HD. This requires a full replacement of the coolant system. In addition, excessive sludge buildup inside the motor is caused. This is a known issue with GM for 2024 Diesel vehicles. GM has released a service bulletin but is fighting my local dealership on the required repairs.

  • Showing the 5 most recent of 15.
• Service Brakes12

  • Filed Apr 2026

    Leaking break fluid on my feet with sponge breaks dealer absolutely no help

  • Filed Mar 2026

    Trailer brakes and lights come and go. I start with having everything then loose brakes and lights when I’m driving. This is apparently a known issue that they have a fix for but I have never received anything about a recall.

  • Filed Oct 2025

    When pulling my trailer with my 2024 chevy 3500, I get the following alert displayed on my screen periodically: Trailer Brakes Disabled Service Required. The trailer brakes stop working on my 16000lb trailer and I need to pull off the road and shut off the truck, and then restart it to get my brakes working again. The dealer replaced the brake controller in the truck, but I still get the message. I towed this trailer across country 2 times in my 2020 chevy without a problem. I have hydrastar brakes on my 2022 keystone Montana. GM said it's a problem with the trailer. Hydrastar said they have had numerous reports from 2024 GM truck owners. I am bringing it back to the GM dealer Monday for an oil change but I was informed they have no further information to guide them Please assist.

  • Filed Jun 2025

    When driving my truck and towing a trailer which has elec. over hyd. brakes and trying to stop. My truck will disable my brakes on my trailer, which may weigh 3+ times the weight of my truck. GM had a recall on the truck brake module which fixed my problem. Then l took my truck back for an oil change a few months later and they said that there is a open recall on the brake module (NEWER UPDATE) which once again caused my brake issues again with the newer recall. l have opened up a complaint with GM and they say take it to a GM dealer. The dealer checks the truck out and says there is no problem with the truck. They tell me that l need to install a module on my trailer ,which l did early on with the problem. l did own a 2017 chevy and pulled that trailer with NO issues. The trailer dealer hooked the trailer to a 2018 GMC and a 2016 Dodge pick-up. And had NO problem with the trailer brakes and put a NYS inspection sticker on my trailer LAST MONTH. We !! the trailer dealer and myself have spoken to the company ( brake module) that GM says that l need. This trailer brake module which the trailer dealer installed in Feb 2024 still did not fix my problem. The brake module company told me GM has His words a HORNETS NEST problem with this issue. Someone is going to loose there brakes and KILL somebody or a family Thank You for any HELP [XXX] Please contact with any feedback or info INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

  • Filed Mar 2025

    The brakes on this vehicle are very spongy, they have to be pushed all the way to the floor to get the vehicle to stop. When pulling a trailer you are on pins and needles wondering if you can get the truck to stop. The trailer brakes are doing most of the stopping. I have owned many trucks and the brakes on this 2024 Chevy Silverado 3500 are the worst that I have ever experienced. This is a Safety hazard with serious implications. I have talked to many other people with the same truck and they also claim that the brake system is faulty and/or sub standard. I have taken my truck back to the dealer and they claim that the brakes are working normal (test driving around their service lot). This is a serious problem that needs to be investigated by your orginazation. Thank you in advance for any insight on this serious brake issue.

  • Showing the 5 most recent of 12.
• Unknown or Other6

  • Filed Mar 2026

    No Owners Manual came with my Truck. I was made aware of Safety Recall 25V815 (Manufacturer Recall N252532020) which addressed 2025-2026 cars and trucks. Currently my 2024 is not included. I can confirm my dealer did not receive any owners manuals for most cars and trucks in 2024. I notified Chevrolet Customer Service and they did not assist. They Dealer was unable to assist and would not reimburse me for the Owners Manual I purchased. I am requesting reimbursement for the purchase of an Owners Manual.

  • Filed Jan 2026

    Email Subject I am reporting a serious safety-related defect involving sudden and complete vehicle shutdown while driving in a 2024 Chevrolet Silverado EV RST. Component/System Involved: The failure appears related to the 12-volt electrical system and associated vehicle control electronics. When the vehicle detects the 12V battery as dead or critically low, it immediately disables propulsion and control systems. The exact failed component is UNKNOWN. The vehicle is available for inspection upon request. Incident Description: This failure has occurred twice under similar conditions (ambient temperature approximately 25°F). On November 28, 2024 and again on January 2, 2026, after driving approximately two blocks at low residential speeds, the vehicle abruptly and completely shut down while in motion. In both incidents, the shutdown was immediate, without warning, and accompanied by a loud thud and an extremely abrupt stop. Safety Risk: In both incidents, the vehicle became completely immobilized in the roadway. I was unable to steer to the side of the road, restart the vehicle, or shift it into gear to move it out of traffic. This created a significant risk of collision. A similar failure at highway speeds could result in a severe or fatal crash. Warnings or Prior Symptoms: No warning lamps, messages, alerts, or other symptoms appeared prior to either shutdown. Problem Confirmation or Reproduction: The issue has occurred twice under cold-weather conditions. Inspections: After the first incident, the 12V battery was inspected and no issues were found. Following the second incident, the vehicle is currently being inspected at a Chevrolet dealership. No police or insurance inspections were performed. This behavior suggests the vehicle lacks a fail-safe or degraded-operation mode for 12V system failure and instead performs an immediate shutdown while in motion, which may represent a serious safety defect warranting investigation.

  • Filed Oct 2025

    When pulling my trailer with my 2024 chevy 3500, I get the following alert displayed on my screen periodically: Trailer Brakes Disabled Service Required. The trailer brakes stop working on my 16000lb trailer and I need to pull off the road and shut off the truck, and then restart it to get my brakes working again. The dealer replaced the brake controller in the truck, but I still get the message. I towed this trailer across country 2 times in my 2020 chevy without a problem. I have hydrastar brakes on my 2022 keystone Montana. GM said it's a problem with the trailer. Hydrastar said they have had numerous reports from 2024 GM truck owners. I am bringing it back to the GM dealer Monday for an oil change but I was informed they have no further information to guide them Please assist.

  • Filed Aug 2024

    Consistent error messages when trailering that lead to vehicle having a failure of trailer brakes

  • Filed Jan 2024

    I believe my def heater has stopped working and my full def tank is now frozen. I’m now stranded in the middle of South Dakota in -29 degree weather. My truck will not drive. Or idle for the heater to keep me warm because the def is required for engine to run.

  • Showing the 5 most recent of 6.
• Engine3

  • Filed Sep 2026

    The Engine Cooler has a know defect that GM has put out service bulletins for. The engine cooler is cracking, mixing oil and antifreeze that is creating a sludge that runs thru the entire system. GM wants techs to attempt to clean/flush the engine before they approve a new engine to be ordered under warranty. GM is aware of the problem and there should be a recall out on the problem according to the service manager I spoke with at the dealership my truck is at currently. I was told the expected time frame is up to 3 months for the work to be completed, with no loaner available that is equivalent to the vehicle that went to the shop. The recall is necessary because if the engine has a major failure while driving it could cause an accident, if the vehicle is hauling a heavy trailer that could be detrimental because the truck can haul up to 40,000 GCWR.

  • Filed Mar 2026

    The engine oil cooler failed causing engine oil to leak into the coolant system on my 2024 Chevy Silverado 3500HD. This requires a full replacement of the coolant system. In addition, excessive sludge buildup inside the motor is caused. This is a known issue with GM for 2024 Diesel vehicles. GM has released a service bulletin but is fighting my local dealership on the required repairs.

  • Filed Oct 2025

    At approximately 35,126 miles the oil cooler cracked and flooded my engine cooling system with over 2.5 gallons of oil causing catastrophic engine failure.

• Fuel/Propulsion System3

  • Filed Sep 2026

    The Engine Cooler has a know defect that GM has put out service bulletins for. The engine cooler is cracking, mixing oil and antifreeze that is creating a sludge that runs thru the entire system. GM wants techs to attempt to clean/flush the engine before they approve a new engine to be ordered under warranty. GM is aware of the problem and there should be a recall out on the problem according to the service manager I spoke with at the dealership my truck is at currently. I was told the expected time frame is up to 3 months for the work to be completed, with no loaner available that is equivalent to the vehicle that went to the shop. The recall is necessary because if the engine has a major failure while driving it could cause an accident, if the vehicle is hauling a heavy trailer that could be detrimental because the truck can haul up to 40,000 GCWR.

  • Filed Jan 2026

    Email Subject I am reporting a serious safety-related defect involving sudden and complete vehicle shutdown while driving in a 2024 Chevrolet Silverado EV RST. Component/System Involved: The failure appears related to the 12-volt electrical system and associated vehicle control electronics. When the vehicle detects the 12V battery as dead or critically low, it immediately disables propulsion and control systems. The exact failed component is UNKNOWN. The vehicle is available for inspection upon request. Incident Description: This failure has occurred twice under similar conditions (ambient temperature approximately 25°F). On November 28, 2024 and again on January 2, 2026, after driving approximately two blocks at low residential speeds, the vehicle abruptly and completely shut down while in motion. In both incidents, the shutdown was immediate, without warning, and accompanied by a loud thud and an extremely abrupt stop. Safety Risk: In both incidents, the vehicle became completely immobilized in the roadway. I was unable to steer to the side of the road, restart the vehicle, or shift it into gear to move it out of traffic. This created a significant risk of collision. A similar failure at highway speeds could result in a severe or fatal crash. Warnings or Prior Symptoms: No warning lamps, messages, alerts, or other symptoms appeared prior to either shutdown. Problem Confirmation or Reproduction: The issue has occurred twice under cold-weather conditions. Inspections: After the first incident, the 12V battery was inspected and no issues were found. Following the second incident, the vehicle is currently being inspected at a Chevrolet dealership. No police or insurance inspections were performed. This behavior suggests the vehicle lacks a fail-safe or degraded-operation mode for 12V system failure and instead performs an immediate shutdown while in motion, which may represent a serious safety defect warranting investigation.

  • Filed Jan 2024

    I believe my def heater has stopped working and my full def tank is now frozen. I’m now stranded in the middle of South Dakota in -29 degree weather. My truck will not drive. Or idle for the heater to keep me warm because the def is required for engine to run.

• Structure3

  1 involved a crash

  • Filed Dec 2024

    The contact owns a 2024 Chevrolet Silverado 3500. The contact stated while driving at approximately 60 MPH, the front driver's side and passenger's side wheels shuddered when the vehicle drove over a pothole or an object in the roadway. No warning light was illuminated. The contact researched and was made aware of Technical Service Bulletin Number: PIT6154A; however, the vehicle was not included. The vehicle was taken back to the residence. A dealer was contacted however, the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 13,000.

  • Filed Oct 2024

    The tailgate spontaneously unlatches without operator input while driving or parked. The dealer thinks it is caused by moisture in the latch gate switch. The tailgate has spontaneously unlatched on several occasions while pulling a trailer without the driver/operator being aware this has occurred. Then when making a turn the tailgate wedges into the trailer jack and makes the tailgate inoperable. The bodyshop quote to repair the tailgate is: 2,275.92 Dinsdale Chevrolet dealer says there is not a recall and has declined to pay for repairs. Contact was made with GM Customer Service, "Reggie" on 10/23/2024 at 11:46, 866.636.2273 He noted, as there has not been a recall, they are not responsible for the issue. Respectfully, [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

  • Filed Mar 2024

    The vehicle was involved in a single vehicle roll over crash. The sheet metal of the roof pealed down and away from the frame of the vehicle. The windshield separated from the metal at the top portion of the windshield. The metal then began to separate from underneath the weld along the sides of the roof. The metal was then rolled inward into the passenger compartment of the vehicle. The metal pinned the front passenger seat back down and to the right against the passenger side B-pillar. Both A-pillars did not sustain any structural damage as the result of the crash.

• Lane Departure2

  • Filed Aug 2026

    The infotainment/control module in my 2024 Silverado 3500HD failed unexpectedly while I was traveling cross-country. The module is available for inspection upon request. Prior to the failure, I did not receive any warning lamps or messages. When the system failed, I lost access to multiple camera systems integrated into the vehicle, including backup and visibility-assistance cameras used to aid lane changes, parking, maneuvering, and identifying obstacles around the truck. Due to the size and height of this vehicle, these cameras provide important visibility of areas that are difficult to observe directly, including pedestrians, cyclists, and children who may be below the driver's line of sight. The loss of these camera systems reduced situational awareness and increased the risk of a collision while backing, changing lanes, or operating the vehicle in crowded areas. The failure also disabled navigation, hands-free functions, audio, WiFi connectivity, and access to vehicle settings controlled through the infotainment system. The vehicle was inspected by a Chevrolet dealer in Cape Cod, Massachusetts. The dealer attempted a software reflash to correct the issue; however, the procedure rendered the unit completely inoperable. The dealer confirmed that the module required replacement and quoted an estimated repair cost of approximately $1,500. The required replacement part was unavailable, and despite contacting numerous Chevrolet dealerships, I was unable to obtain a repair during my trip. As a result, I was required to continue operating the vehicle while towing a large trailer for an extended period without the camera systems and related functionality. I have also become aware of GM Service Bulletin PIC6630B, which indicates that GM has identified this failure mode and that it is not an isolated occurrence. Given that a single module failure can disable multiple safety features, I request that it be evaluated by an independent authority accordingly.

  • Filed Aug 2023

    The truck intermittently disconnects and reconnects from the trailer. Trailer brakes don't work briefly when this happens. At night when truck and trailer lights are on the truck detects trailer is disconnected, this happens every few minutes. Note: I've seen a bulletin about solar panels on the trailer, I do not have solar panels on the trailer. Also, blind spot mirror indicators at night are almost constantly on. When the trailer and truck lights go off, the blind spot indicators work as intended.

• Exterior Lighting2

  • Filed Mar 2026

    Trailer brakes and lights come and go. I start with having everything then loose brakes and lights when I’m driving. This is apparently a known issue that they have a fix for but I have never received anything about a recall.

  • Filed Mar 2024

    There is an electrical / turn signal and trailering issue. Not towing- the right turn signal gives a rapid flash when the automatic headlights are activated or in off position. The rapid flash goes away when manual headlights are used both running lights and on. Although the light still works with a rapid blink, there is a dash error message and it’s impossible to know while driving if the error is real or not. This issue is intermittent when auto headlights are selected. Towing- bigger safety issue. The trailer lights only work properly when headlights are in auto mode and daylight. When it gets dark, the headlights turn on and error messages happen and trailer lights go out. There are also error messages when manual running lights or manual lights are activated. Thus it appears there is no way to tow an RV safely at night. This did not occur on my 2021 Chevy 3500. These issues are wide spread but GM is doing nothing about it. Please help me, the other owners, and the public from these dangerous vehicles.

• Suspension2

  • Filed Jul 2025

    I keep getting a chunking noise coming from the rear of vehicle. Twice I have taking in to the dealer and I was told this condition may be caused by movement between the anchor plate and axle assembly. They have re-torqueing the joints of the leaf springs assembly. it coming loose. It has happened after 4,000 miles. This tells me that it can come loose while I am driving! GM has a service document ID: 5501065. It has been happening since 2020!

  • Filed Aug 2024

    Vibration occurs when driving at highway speed. Vibration can be felt in the steering wheel, drivers seat, and passenger seat. I believe this is related to my vechicles front hub bearing extensions. there was a TSB for this issue on presious model trucks and the same part is used on 2024 models.

• Steering2

  • Filed Apr 2024

    I was towing my 36 ft 5th wheel home from my storage place when the engine stopped. I had no brakes or power steering. I was coming up to a stop sign when this occurred so fortunately I was only moving about 15 mph. I was able to stop the truck and trailer by using the 5th wheel braking system without any damage to vehicle or other property. Once I regained my composure I tried to start the truck. All the dash lights were on but it would not start. The digital display kept showing Service ECM & Service StabiliTrak. I had the truck towed to the dealer where it is right now. They have been unable to replicate the issue and have no suggested fix at this time. I had no prior warning messages or symptoms of the problem. All of this happened Sunday April 5, 2024. The truck is a 2024 and I bought it new, picked it up November 30, 2023. Current mileage is 3,523. If I would have been towing on the Interstate at 60-65 mph around a curve this could have been catastrophic.

  • Filed Jan 2024

    With just under 900 miles the Steering wheel is turned to the left. There is a knocking noise when turning corners which the truck is now at the dealership for the 2nd time since I bout it.

• Forward Collision Avoidance1

  • Filed Aug 2026

    The infotainment/control module in my 2024 Silverado 3500HD failed unexpectedly while I was traveling cross-country. The module is available for inspection upon request. Prior to the failure, I did not receive any warning lamps or messages. When the system failed, I lost access to multiple camera systems integrated into the vehicle, including backup and visibility-assistance cameras used to aid lane changes, parking, maneuvering, and identifying obstacles around the truck. Due to the size and height of this vehicle, these cameras provide important visibility of areas that are difficult to observe directly, including pedestrians, cyclists, and children who may be below the driver's line of sight. The loss of these camera systems reduced situational awareness and increased the risk of a collision while backing, changing lanes, or operating the vehicle in crowded areas. The failure also disabled navigation, hands-free functions, audio, WiFi connectivity, and access to vehicle settings controlled through the infotainment system. The vehicle was inspected by a Chevrolet dealer in Cape Cod, Massachusetts. The dealer attempted a software reflash to correct the issue; however, the procedure rendered the unit completely inoperable. The dealer confirmed that the module required replacement and quoted an estimated repair cost of approximately $1,500. The required replacement part was unavailable, and despite contacting numerous Chevrolet dealerships, I was unable to obtain a repair during my trip. As a result, I was required to continue operating the vehicle while towing a large trailer for an extended period without the camera systems and related functionality. I have also become aware of GM Service Bulletin PIC6630B, which indicates that GM has identified this failure mode and that it is not an isolated occurrence. Given that a single module failure can disable multiple safety features, I request that it be evaluated by an independent authority accordingly.

• Fuel System1

  • Filed Aug 2025

    The contact owns a 2024 Chevrolet Silverado 3500. The contact stated that while driving at various speeds, the vehicle hesitated, and the transmission failed to properly shift. The vehicle was taken to the local dealer, who discovered metal shavings inside the fuel filter and diagnosed that the High-Pressure Fuel Pump was faulty and needed to be replaced. The high-pressure fuel pump was replaced, and the vehicle was repaired. Later, while hauling a trailer on the highway, the vehicle unexpectedly stalled. The vehicle was towed to the dealer, who diagnosed that the fuel pump control module had failed and needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 19,000.

• Diesel1

  • Filed Aug 2025

    The contact owns a 2024 Chevrolet Silverado 3500. The contact stated that while driving at various speeds, the vehicle hesitated, and the transmission failed to properly shift. The vehicle was taken to the local dealer, who discovered metal shavings inside the fuel filter and diagnosed that the High-Pressure Fuel Pump was faulty and needed to be replaced. The high-pressure fuel pump was replaced, and the vehicle was repaired. Later, while hauling a trailer on the highway, the vehicle unexpectedly stalled. The vehicle was towed to the dealer, who diagnosed that the fuel pump control module had failed and needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 19,000.

• Visibility/Wiper1

  • Filed Apr 2024

    Wiper totally quits working when using it. May start again and may not. So far dealer has not fully solved problem

Safety ratings

NHTSA 5-Star Safety Ratings from government crash tests. Ratings can differ by cab style and 2WD/4WD.

NHTSA hasn't published star ratings for this truck. Many heavy-duty pickups aren't included in NHTSA's crash-test program, so this doesn't mean the truck is unsafe.