2005 Ram 2500

What owners should know

Covers 2003–2009 · 5.9L and 6.7L Cummins diesel, 5.7L Hemi V8 gas · Updated 2026-10-01

Researched from owner forums and NHTSA complaints and written by Know Your Truck. These are patterns in what owners report, not a guarantee about any particular truck.

Common failures & how to fix them

Parts and video buttons search for your 2005 Ram 2500. Always confirm a part fits using your VIN. Brakes, steering, fuel and airbag work affects your safety, so if you're not sure, have a qualified mechanic do it.

• Left tie rod can break

  Dealer (recall)

  Signs: Loose or wandering steering, clunks, or play in the steering linkage.

  Fix: Covered by Chrysler recalls on 2003–2012 4x4 trucks. Many owners also upgrade to a heavy-duty tie rod and drag link.

  May be covered free by recall 13V528000 / 13V529000. Check the VIN at nhtsa.gov/recalls.

  Shop: heavy duty tie rod drag link▶ How-to videos

• Front-end shake (death wobble)

  Moderate DIY

  Signs: Violent shaking of the steering wheel and front end after hitting a bump, usually at 45+ mph. Slowing down hard is often the only way to stop it.

  Fix: Find and replace the worn parts, most often the track bar or its bushings, then check ball joints, tie rod ends, the drag link and alignment. A new steering stabilizer alone usually only hides the problem.

  Shop: track barShop: steering stabilizer▶ How-to videos

• 5.9L Cummins weak lift pump

  Moderate DIY

  Signs: Hard starts, low power under load, low fuel pressure.

  Fix: Test fuel pressure and replace the lift pump. Many owners upgrade to an aftermarket lift pump.

  Shop: 5.9 Cummins lift pump▶ How-to videos

• 5.9L Cummins injector wear

  Hard DIY

  Signs: Hard starts, smoke, rough idle, knocking.

  Fix: Have injectors tested and replaced as a set. Use the correct injector type for the year, because early and late versions are different.

  Shop: 5.9 Cummins injectors▶ How-to videos

• 6.7L Cummins turbo actuator / EGR problems (2007–2009)

  Best left to a shop

  Signs: Low power, boost control codes, frequent exhaust cleaning cycles.

  Fix: Diagnose with a scan tool. Common fixes are a turbo actuator, EGR valve cleaning or replacement, and DPF cleaning.

  Shop: 6.7 Cummins turbo actuator▶ How-to videos

• 5.7L Hemi exhaust ticking

  Hard DIY

  Signs: Ticking that's loudest on a cold start and fades as the engine warms up.

  Fix: Usually broken exhaust manifold bolts. Replace the bolts and gasket.

  Shop: 5.7 Hemi exhaust manifold bolts▶ How-to videos

Recalls

A recall doesn't mean a truck still has the problem. Enter the truck's VIN at nhtsa.gov/recalls or ask a dealer to see whether the repair was done.

• Air Bags:Frontal:Passenger Side:Inflator Module

  May 2016 · #16V352000

  NHTSA warning: do not drive until this recall is fixed.

  Chrysler (FCA US LLC) expanded the affected population to include 73,712 2005-2009 RAM 2500 trucks produced at the St. Louis North Assembly Plant. With this change, Chrysler is recalling certain model year 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2010 RAM 3500 Cab Chassis, 2008-2010 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2012 Jeep Wrangler, 2008-2012 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2012 Chrysler 300, 2006-2012 Dodge Charger, 2005-2011 Dodge Dakota, and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AL, CA, FL, GA, HI, LA, MS, SC, TX, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Chrysler is also recalling 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2009 RAM 3500 Cab Chassis, 2008-2009 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2009 Jeep Wrangler, 2008-2009 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2009 Chrysler 300, 2006-2009 Dodge Charger, 2005-2009 Dodge Dakota and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AZ, AR, DE, Washington D.C., IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV, or "Zone B." Lastly, unless included in "Zone A" or "Zone B" above, Chrysler is recalling certain 2005-2008 RAM 2500, 2006-2008 RAM 3500, 2007-2008 RAM 3500 Cab Chassis, 2008 RAM 4500 and 5500 Cab Chassis, 2004-2008 Dodge Durango, 2007-2008 Chrysler Aspen, 2007-2008 Jeep Wrangler, 2008 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2008 Chrysler 300, 2006-2008 Dodge Charger, 2005-2008 Dodge Dakota, and 2006-2008 Mitsubishi Raider vehicles originally sold, or registered, in AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY.

  Risk and fix

  Risk: These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. These inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling. An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

  Fix: Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify the Chrysler, Dodge, Jeep and RAM owners. Mitsubishi owners will be notified by their company. Dealers will replace the passenger frontal air bag inflator, free of charge. The recall began on March 27, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S43. Note: This recall supersedes recall 14V-7700.

• Air Bags:Frontal:Driver Side:Inflator Module

  May 2015 · #15V313000

  NHTSA warning: do not drive until this recall is fixed.

  Chrysler (FCA US LLC) is recalling certain model year 2005-2009 Dodge Ram 2500, 2004-2008 Dodge Ram 1500 and Durango, 2006-2009 Dodge Ram 3500, 2008-2010 Dodge Ram 4500 and 5500, 2007-2008 Chrysler Aspen, 2005-2010 Chrysler 300, 300C, 300S, and SRT8, 2006-2010 Dodge Charger, 2005-2008 Magnum, 2005-2011 Dodge Dakota, and 2006-2009 Mitsubishi Raider vehicles. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture.

  Risk and fix

  Risk: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.

  Fix: Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify the affected Chrysler and Dodge owners and Mitsubishi will notify the affected Raider owners. Dealers will replace the driver's frontal air bag inflator, free of charge. The recall began for Chrylser on June 8, 2015. The recall for Mitsubishi started on June 24, 2015. Chrysler and Dodge owners may contact Chrysler customer service at 1-800-853-1403. Mitsubishi owners may call 1-888-648-7820. Chrysler's number for this recall is R25. Note: This recall supersedes recall 14V817 in its entirety. Vehicles that have had their driver side frontal air bag replaced previously need to have their air bag replaced under this recall as well.

• Air Bags

  Dec 2014 · #14V770000

  Chrysler Group LLC (Chrysler) is recalling certain model year 2004-2005 Dodge Ram 1500, 2500, and 3500, 2004-2005 Dodge Durango, 2005 Dodge Dakota, 2005 Dodge Magnum and 2005 Chrysler 300, 300C and 300 SRT8 vehicles originally sold, or ever registered, in geographic locations associated with high absolute humidity. Specifically, vehicles sold, or ever registered, in Alabama, Florida, Georgia, Hawaii, Louisiana, Mississippi, Texas, Puerto Rico, U.S. Virgin Islands, Saipan, Guam, and American Samoa are addressed by this recall. Upon deployment of the passenger side frontal air bag, excessive internal pressure may cause the inflator to rupture.

  Risk and fix

  Risk: In the event of a crash necessitating deployment of the passenger’s frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.

  Fix: Chrysler will notify owners, and dealers will replace the front passenger air bag inflator, free of charge. For vehicles that were sold, or are currently registered, in Florida, Puerto Rico, Hawaii, and the U.S. Virgin Islands, owners were notified and the recall began on December 5, 2014. For all other vehicles, Chrysler notified owners and the recall began on February 3, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P40 Expanded. Note: This recall has been superseded by recall 16V-352. This recall superseded the passenger air bag portion of recall 14V-354.

• Steering:Linkages:Tie Rod Assembly

  Nov 2013 · #13V528000

  Chrysler Group LLC (Chrysler) is recalling certain model year 2003-2008 Dodge RAM 2500 4x4 and 3500 4x4, model year 2007-2008 Dodge RAM 3500 4x2 Cab Chassis and model year 2006-2008 Dodge RAM 1500 Mega Cab 4x4 trucks manufactured February 12, 2002, through February 13, 2008. The left tie rod assembly may break.

  Risk and fix

  Risk: A failure of the tie rod assembly may result in a loss of steering control, increasing the risk of a crash.

  Fix: Chrysler notified owners and launched its recall campaign in January 2014. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N62.

• Steering:Linkages:Tie Rod Assembly

  Jul 2011 · #11V350000

  CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008-2011 DODGE RAM 2500/3500 4X4, MANUFACTURED FROM FEBRUARY 14, 2008, THROUGH MARCH 28, 2011; MODEL YEAR 2008-2011 DODGE RAM 3500 CAB CHASSIS 4X2, MANUFACTURED FROM FEBRUARY 14, 2008, THROUGH MARCH 28, 2011; AND MODEL YEAR 2008 DODGE RAM 1500 MEGA CAB 4X4, MANUFACTURED FROM FEBRUARY 14, 2008, THROUGH AUGUST 15, 2008, BECAUSE THE LEFT TIE ROD BALL STUD MAY FRACTURE. THIS CONDITION TENDS TO OCCUR DURING LOW SPEED PARKING LOT TYPE MANEUVERS WHEN THE CUSTOMER IS MAKING A TIGHT TURN. ADDITIONALLY, MODEL YEAR 2003-2008 DODGE RAM 2500/3500 VEHICLES MAY HAVE RECEIVED THE AFFECTED TIE ROD ASSEMBLY AS A REPLACEMENT PART DURING NORMAL SERVICE.

  Risk and fix

  Risk: THIS CONDITION COULD RESULT IN THE POTENTIAL LOSS OF DIRECTIONAL STABILITY IN THE LEFT HAND FRONT WHEEL, INCREASING THE RISK OF A CRASH.

  Fix: DEALERS WILL INSPECT THE TIE ROD ENDS FOR RELATIVE ORIENTATION AND REPLACE THE LEFT OUTER TIE ROD AS REQUIRED AND PERFORM A FRONT END TOE ALIGNMENT AS NEEDED. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 3, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

• Steering:Gear Box:Shaft Pitman

  May 2010 · #10E013000

  FABTECH IS RECALLING CERTAIN AFTERMARKET REPLACEMENT PITMAN ARMS, P/NOS. FTS93001 AND FT44039, INSTALLED FOR USE ON CERTAIN 2003 THROUGH 2008 DODGE 2500 4WD, 3500 4WD, AND 1500 4WD MEGA CAB VEHICLES. THE PITMAN ARM CAN FRACTURE AND BREAK AWAY FROM THE STEERING BOX CAUSING TOTAL LOSS OF STEERING CONTROL.

  Risk and fix

  Risk: STEERING LOSS COULD RESULT IN A VEHICLE CRASH POSSIBLY RESULTING IN PROPERTY DAMAGE, INJURY OR DEATH.

  Fix: FABTECH WILL NOTIFY OWNERS AND AUTHORIZED INSTALLERS WILL INSPECT FOR DEFECTIVE PITMAN ARM AND REPLACE IF NECESSARY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 24, 2010. OWNERS MAY CONTACT FABTECH AT 1-877-432-2832.

• Visibility:Glass, Side/Rear

  Dec 2007 · #07E104000

  CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."

  Risk and fix

  Risk: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.

  Fix: SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER'S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.

• Suspension

  Feb 2007 · #07E009000

  CERTAIN LKI ENTERPRISES, INC., BRAND NAME SUPERLIFT SUSPENSION, PITMAN ARMS SOLD AS REPLACEMENT EQUIPMENT FOR 2003-2007 DODGE RAM 2500 AND 3500 4X4 LIGHT TRUCKS. DUE TO INADEQUATE HEAT TREATMENT DURING PRODUCTION, THE AFFECTED PITMAN ARMS MAY DEVELOP CRACKS IN THE UPPER SPLINED ATTACHMENT ATTACHMENT TO THE STEERING OUTPUT SHAFT. MOVEMENT BETWEEN THE PITMAN ARM AND THE OUTPUT SHAFT MAY DEFORM SPLINES, RESULTING IN PREMATURE WEAR AND FATIGUE FAILURE OF THE AFFECTED PITMAN ARM.

  Risk and fix

  Risk: PITMAN ARM WEAR OR FAILURE MAY LEAD TO LOSS OF VEHICLE CONTROL, POSSIBLY RESULTING IN A VEHICLE CRASH.

  Fix: LKI WILL NOTIFY OWNERS AND REPLACE THE PITMAN ARM, IF NECESSARY. THE RECALL BEGAN ON MARCH 12, 2007. OWNERS MAY CONTACT LKI AT 1-800-551-4955.

• Power Train:Automatic Transmission:Lever And Linkage:Column Shift

  Oct 2005 · #05V462000

  ON CERTAIN PICKUP TRUCKS EQUIPPED WITH DIESEL ENGINES AND AUTOMATIC TRANSMISSIONS, IN AN ATTEMPT TO EXIT THE VEHICLE QUICKLY WITHOUT SHUTTING OFF THE ENGINE AND REMOVING THE KEY, THE DRIVER MAY INADVERTENTLY LEAVE THE AUTOMATIC TRANSMISSION SHIFT CONTROL IN INDICATED REVERSE.

  Risk and fix

  Risk: THIS ERROR IS AN UNINTENDED ACTION THAT MAY RESULT IN A LACK OF TRANSMISSION PARK PAWL ENGAGEMENT AND POSSIBLY DELAYED REARWARD MOVEMENT OF THE VEHICLE.

  Fix: DEALERS WILL PERFORM A SOFTWARE MODIFICATION TO EQUIP THESE VEHICLES WITH AN OUT-OF-PARK ALARM. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Owner complaints by area

Reports owners filed with NHTSA. They aren't verified, and one complaint can mention more than one area. Tap an area to read the most recent ones.

• Steering153

  11 involved a crash

  • Filed Feb 2026

    The contact owns a 2005 Dodge Ram 2500. The contact stated that while driving at an undisclosed speed, the steering wheel wobbled, and the air bag warning light illuminated. The vehicle was taken to the dealer; however, the contact was informed that parts were not available to repair the vehicle. The contact stated that the vehicle remained with the dealer for 45 days; however, the vehicle was not repaired. An alternate dealer was contacted. The contact was informed that the parts were ordered to repair the vehicle and would be notified when the parts were delivered. The dealer had not notified the contact if the parts were delivered. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact received notifications of NHTSA Campaign Numbers: 13V528000 (Steering), 16V352000 (Air Bags), and 15V313000 (Air Bags); however, the vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to contact other local dealers for possible assistance. The failure mileage was approximately 88,000.

  • Filed Feb 2024

    STEERING WENT OUT AND TRUCK ROLLED. VERIFIED PER MECHANIC FAILURE ON RECALLED PART/S

  • Filed Sep 2023

    The contact owns a 2005 Dodge Ram 2500. The contact stated that on several occasions while driving approximately 70 MPH, the vehicle drove over a bump in the roadway and the steering wheel started to shake violently. Additionally, the contact stated that while the brake pedal was depressed, the vehicle started to shake violently. The contact decelerated to slower speeds to stop the vehicle from shaking. No warning lights was illuminated. As a result, the contact stated that the last failure caused the vehicle to shake off the roadway. The contact was able to drive the vehicle to safety. The vehicle was not diagnosed or repaired. Neither the dealer nor the manufacturer was notified of the failure. The failure mileage was approximately 138,000.

  • Filed Apr 2023

    Steering is not as good as it should be. Has 83,000 miles and steering seems very loose, seems to wander from left to right, and hard to control, on Highway or city streets.

  • Filed Sep 2020

    TRUCK EXPERIENCES THE "DEATH WOBBLE". IT HAS HAD THE FRONT END REDONE TWICE, STILL HAS THE PROBLEM. WHEN I'M DRIVING ABOVE 50MPH, AND HIT A BUMP, SOMETIMES THE FRONT END AND STEERING WHEEL BEGIN TO VIOLENTLY SHAKE AND WOBBLE. WHEN IT OCCURS, IT IS EXTREMELY DANGEROUS, AND VERY DIFFICULT TO STOP. IT HAPPENED 4 TIMES ON A SINGLE TRIP.

  • Showing the 5 most recent of 153.
• Suspension77

  3 involved a crash

  • Filed Dec 2019

    SWAY AND BODY ROLL

  • Filed Oct 2019

    TL* THE CONTACT OWNS A 2005 DODGE RAM 2500. WHILE DRIVING 60 MPH OVER A BUMP IN THE ROAD, THE VEHICLE VIOLENTLY VIBRATED. THE FAILURES CEASED ONCE THE VEHICLE WAS STOPPED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE FAILURE OCCURRED BECAUSE THE VEHICLE DROVE OVER A POTHOLE. THE FAILURE MILEAGE WAS 250,000.

  • Filed Sep 2019

    TL* THE CONTACT OWNS A 2005 DODGE RAM 2500. WHILE DRIVING 65 MPH, THE VEHICLE BEGAN TO VIBRATE UNCONTROLLABLY. THE CONTACT EXITED THE HIGHWAY AND THE VEHICLE BEGAN TO RESUME NORMAL OPERATION. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT DROVE TO AN INDEPENDENT MECHANIC AND WAS INFORMED THAT THE UPPER AND LOWER BUSHING KITS NEEDED TO BE REPLACED. THE CONTACT WAS ALSO INFORMED THAT THE TIE ROD NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER AND DEALER WERE NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

  • Filed Jul 2019

    TL* THE CONTACT OWNED A 2005 DODGE RAM 2500. WHILE EXITING THE FREEWAY AT 65 MPH, THE CONTACT ATTEMPTED TO MAKE A LEFT TURN AND THE VEHICLE SHOOK VIOLENTLY. THE CONTACT VEERED THE VEHICLE TO THE SHOULDER OF THE ROAD WHERE IT CAME TO A COMPLETE STOP. THE VEHICLE RESUMED NORMAL OPERATION AND WAS TAKEN TO ORANGE COAST CHRYSLER JEEP DODGE RAM FIAT (2929 HARBOR BLVD, COSTA MESA, CA 92626, (714) 549-8023) WHERE IT WAS DIAGNOSED THAT THE FRONT END LINKAGES NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 195,000.

  • Filed Mar 2019

    DODGE DEATH WOBBLE HAS HAPPENED NUMEROUS TIMES THE LAST TIME IT BROKE THE TIE ROD END AND THREW ME OFF THE ROAD

  • Showing the 5 most recent of 77.
• Air Bags76

  12 involved a crash

  • Filed Jun 2026

    The dealer has told me for years that the air bad can not be found...there out of stock

  • Filed Feb 2026

    The contact owns a 2005 Dodge Ram 2500. The contact stated that while driving at an undisclosed speed, the steering wheel wobbled, and the air bag warning light illuminated. The vehicle was taken to the dealer; however, the contact was informed that parts were not available to repair the vehicle. The contact stated that the vehicle remained with the dealer for 45 days; however, the vehicle was not repaired. An alternate dealer was contacted. The contact was informed that the parts were ordered to repair the vehicle and would be notified when the parts were delivered. The dealer had not notified the contact if the parts were delivered. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact received notifications of NHTSA Campaign Numbers: 13V528000 (Steering), 16V352000 (Air Bags), and 15V313000 (Air Bags); however, the vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to contact other local dealers for possible assistance. The failure mileage was approximately 88,000.

  • Filed Jul 2019

    TAKARA INFLATORS APRIL 28TH 2019 WE TOOK OUR TRUCK TO THE DODGE DEALERSHIP TO HAVE THE RECALLS FIXED AS THEY REQUESTED. MAINLY THE AIRBAGS AND THEY DID A 28 POINT INSPECTION. JULY 1ST 2019 SOMEONE PULLED OUT IN FRONT OF MY HUSBAND AND THEY WERE INVOLVED IN A BAD ACCIDENT. THE AIRBAGS NEVER WENT OFF. MY HUSBAND HIT THE STEERING WHEEL SO HARD THERE'S A BRUISE AND MARK ON HIS CHEST AND THE SHAPE OF THE STEERING WHEEL. IT ALSO MESSED UP THE STEERING COLUMN AND THE GEAR SELECTOR. THE TRUCK IS TOTALED THE FRAME IS BENT THE SUSPENSIONS RIPPED OFF BUT WE CAN'T FIGURE OUT WHY THE AIRBAGS DIDN'T GO OFF. INSURANCE IS BEING A PAIN. DODGE SAID THEY'D SEND OUT AN INVESTIGATOR SO FAR NO ONE SHOWED UP. SOMETHING SHOULD BE DONE ABOUT THIS.

  • Filed Feb 2019

    DID NOT RECIEVE INFORMATION ABOUT A AIRBAG SAFETY RECALL. I LOST CONTROL DRIVING ON ICE WENT OFF THE ROAD INTO A DITCH AT 55MPH AND HIT A TREE WITH THE FRONT PASSENGER SIDE OF THE VEHICLE. NEITHER AIR BAGS DEPLOYED. THE DRIVER SIDE WAS REPLACED IN 2015. THE PASSENGER SIDE WAS RECALLED AND II WAS NEVER NOTIFIED. THE VEHICLE WAS TOTALED.

  • Filed Aug 2018

    TL* TAKATA RECALL. THE CONTACT OWNS A 2005 DODGE RAM 2500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V352000 (AIR BAGS); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER (LARRY H MILLER CHRYSLER JEEP AVONDALE, 10055 W PAPAGO FWY, AVONDALE, AZ 85323, (480) 865-3981) WAS CONTACTED AND CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND WAS NOT ABLE TO CONFIRM WHEN THE PARTS WERE TO BECOME AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

  • Showing the 5 most recent of 76.
• Power Train63

  17 involved a crash

  • Filed Feb 2022

    The contact owns a 2005 Dodge Ram 2500. The contact stated that after starting the vehicle, the gear shifter was shifted to the selected gear, but the vehicle would not move. Additionally, the vehicle made an abnormal sound. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 55,000.

  • Filed Feb 2021

    ENGINES NEEDING CAM SHAFTS LIFTERS TIMING CHAINS THEY OVER HEAT ELECTRIC FANS NOT WORKING BATTERIES EXPLODE TRANSMISSIONS STOP SHIFTING BAD VALVE BODIES BAD ELECTRICAL PARTS THESE TRUCKS ARE DRIVEN AROUND ONE LOCATION AT 35 MPH OR LESS 24-7 AND PARKED FOR LONG TIMES AT IDLE. NO CITY OR HWY DRIVING 4 DIFFERENT TRUCKS AT DEALERSHIPS SINCE 9/16/2020 STILL NOT REPAIRED

  • Filed Sep 2020

    THE TRUCK WITH ATTACHED TRAILER WAS PARKED ON AN INCLINED DRIVEWAY. THE TRUCK WAS PLACED IN PARK AND THE KEY WAS REMOVED FROM THE IGNITION. I PROCEEDED TO LOAD A COMPACT TRACTOR APPROXIMATELY 2500 LBS. THE TRUCK STARTED TO ROLL DOWN THE HILL AND CRASHED THRU A FENCE DOING EXTENSIVE DAMAGE TO THE TRUCK. I DID NOT TRY TO START THE TRUCK AND WAITED FOR MECHANIC TO ASSESS ANY MECHANICAL DAMAGE. THE MECHANIC CAME TO MY PLACE AND WHEN HE GOT IN THE TRUCK THE TRANSMISSION INDICATED THAT IT WAS STILL IN PARK. DODGE TOLD ME THAT THERE WAS NO RECALL ON THIS TYPE VEHICLE WITH THE TRANSMISSION NOT HOLDING. THE REPRESENTATIVE TOLD ME THAT THERE HAD BEEN SIMILAR PROBLEMS WITH GAS POWERED ENGINES BUT NOT THE DIESEL. I WOULD LIKE TO KNOW IF THIS CAN BE EVALUATED FOR RECALL. NO ONE GOT HURT IN THIS INSTANCE BUT CAUSED EXTENSIVE DAMAGE TO THE TRUCK MECHANICALLY AND COSMETICALLY.

  • Filed Dec 2018

    MAY 2018, PUT TRUCK IN PARK AND LEFT IT RUNNING TO GO IN TO GET SOMETHING. WE WERE IN AN RV PARK AT THE TIME. A MINUTE OR SO LATER, IT WENT IN REVERSE AND BACKED INTO A TRAILER CAUSING DAMAGE TO BOTH. GEARSHIFT SHOWEDIT WAS STILL IN 'P'. ALARM HAS SINCE BEEN PUT IN UNDER RECALL E17 AFTER WE REQUESTED IT. (HAD ASKED WHEN AIR BAGS WERE CHANGED OUT IN DECEMBER 2017, IF ANY OTHER RECALLS, AND WERE TOLD NO). A DODGE REP CAME ON JUNE 12, 2018 AND LOOKED AT THE TRUCK. AS OF 12/10/2018, WE HAVE NOT BEEN NOTIFIED OF RESULTS.

  • Filed Jan 2018

    TL* THE CONTACT OWNS A 2005 DODGE RAM 2500. ON SEVERAL OCCASIONS, WHILE THE GEAR SHIFTER WAS IN OPEN POSITION, THE TRANSMISSION SHIFTED OUT OF PARK INTO REVERSE. THE CONTACT HAD NOT DEPRESSED THE BRAKE PEDAL DURING THE INCIDENT. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 17V821000 (POWER TRAIN). THE MANUFACTURER WAS NOT NOTIFIED. THERE WERE NO RECALLS ASSOCIATED WITH THE VIN. THE APPROXIMATE FAILURE MILEAGE WAS 103,000.

  • Showing the 5 most recent of 63.
• Electrical System34

  4 involved a fire

  • Filed Jun 2021

    The room fcm power distribution module corrodes and causes electrical problems. Headlights can go out while driving, taillights, break lights etc. There is many complaints on the web about this issue and dodge has not fixed the problem. I was driving at night and my headlights went completely out. Luckily I was able to avoid any accident and come to a controlled stop. If I had been on a curve I would have lost sight of the road. This is a well known issue among dodge trucks. This is a safety recall as it can cause an accident and death.

  • Filed May 2018

    ALL LIGHTS (HEADLIGHTS, TAILLIGHTS, ETC.) COME ON WHILE VEHICLE TURNED OFF AND TURN OFF WHILE VEHICLE IS RUNNING. ALSO, WINDSHIELD WIPERS AND WASHERS RUN ALL THE TIME AND CAN NOT BE TURNED OFF. DRAINS BATTERY WHILE NOT RUNNING, THEN WILL NOT START. FACTORY TRAINED MECHANIC SAYS IT IS A "BAD TIPM" (TOTALLY INTEGRATED POWER MODULE), AND THE DEALERSHIP CAN NOT ORDER A NEW TIPM AS DODGE DOES NOT MAKE THESE ANYMORE (VEHICLE IS 12 YEARS OLD). MY VEHICLE IS PRACTICALLY USELESS AND NOW VALUELESS, AS I CAN NOT GET NEEDED PARTS TO REPAIR. MY EXPERIENCE HAS BEEN THAT AFTERMARKET PARTS (INCLUDING FAN CLUTCH FOR THIS VEHICLE) DOES NOT WORK WELL AND END UP NEEDING REPLACEMENT ALMOST AS SOON AS REPAIRS ARE DONE. THIS REALLY SUCKS THAT AN AMERICAN AUTO MANUFACTURER CAN FAIL TO MAKE PARTS AVAILABLE FOR 12 YEAR OLD VEHICLES. I GUESS THEY NEED TO SELL A NEW ONE THAT BAD! NOT ANOTHER DODGE, FOR SURE

  • Filed Aug 2017

    TL* THE CONTACT OWNS A 2005 DODGE RAM 2500. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED PER NHTSA CAMPAIGN NUMBERS: 15V313000 (AIR BAGS) AND 05V462000 (POWER TRAIN). WHILE EXITING THE VEHICLE, THE HORN BEGAN TO SOUND AND THE WARNING INDICATORS BEGAN TO FLICKER INDEPENDENTLY. THE FAILURE WAS PERSISTENT. THE VEHICLE WAS TAKEN TO A LOCAL DEALER (B&B CHRYSLER DODGE JEEP RAM 125 GRANDVIEW AVENUE, HONESDALE, PA 18431), BUT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. THE CONTACT ALSO STATED THAT THE FAILURE WAS NOT PRESENT PRIOR TO THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THE FAILURE WAS BEING INVESTIGATED. THE FAILURE MILEAGE WAS APPROXIMATELY 375,321.

  • Filed Jun 2016

    TRUCK QUIT AFTER IT WAS CRANKED UP. GAGES PEGGED OUT. TAKEN TO DEALER AND NARROWED DOWN TO THE ENGINE WIRING HARNESS FROM THE FIRE WALL TO THE ENGINE IS SHORTED OUT CAUSING THE PCM TO SHORT OUT AS WELL. WIRING HARNESS IS DISCONTINUED AND TRUCK HAS BEEN SITTING AT DEALER FOR OVER A WEEK. WE HAVE TRIED TO LOCATE ONE PERSONALLY TO NO AVAIL. IS THIS SOMETHING THAT YOU CAN ASSIST US WITH. WE LOVE OUR 2500 DIESEL AND WOULD LIKE TO HAVE IT REPAIRED AS OPPOSED TO BUYING ANOTHER TRUCK.

  • Filed Apr 2016

    REAR DOOR WIRING HARNESS: WIRES BREAK INSIDE OF RUBBER HOUSING CAUSING TOTAL WINDOW AND DOOR LOCK FAILURE. THE EXPOSED WIRES COULD ARC AGAINST EACH OTHER AND THE METAL RESULTING IN A FIRE. IF CHILD LOCKS ARE ENGAGED OR IF THE DOOR IS LOCKED YOU ARE UNABLE TO UNLOCK THE DOOR FROM THE OUTSIDE. THIS IS A SAFETY ISSUE BECAUSE IT COULD RESULT IN THE REAR PASSENGERS BECOMING TRAPPED IN THE VEHICLE IN AN EMERGENCY CAUSING INJURY OR DEATH.

  • Showing the 5 most recent of 34.
• Exterior Lighting17

  • Filed Jun 2021

    The room fcm power distribution module corrodes and causes electrical problems. Headlights can go out while driving, taillights, break lights etc. There is many complaints on the web about this issue and dodge has not fixed the problem. I was driving at night and my headlights went completely out. Luckily I was able to avoid any accident and come to a controlled stop. If I had been on a curve I would have lost sight of the road. This is a well known issue among dodge trucks. This is a safety recall as it can cause an accident and death.

  • Filed May 2018

    ALL LIGHTS (HEADLIGHTS, TAILLIGHTS, ETC.) COME ON WHILE VEHICLE TURNED OFF AND TURN OFF WHILE VEHICLE IS RUNNING. ALSO, WINDSHIELD WIPERS AND WASHERS RUN ALL THE TIME AND CAN NOT BE TURNED OFF. DRAINS BATTERY WHILE NOT RUNNING, THEN WILL NOT START. FACTORY TRAINED MECHANIC SAYS IT IS A "BAD TIPM" (TOTALLY INTEGRATED POWER MODULE), AND THE DEALERSHIP CAN NOT ORDER A NEW TIPM AS DODGE DOES NOT MAKE THESE ANYMORE (VEHICLE IS 12 YEARS OLD). MY VEHICLE IS PRACTICALLY USELESS AND NOW VALUELESS, AS I CAN NOT GET NEEDED PARTS TO REPAIR. MY EXPERIENCE HAS BEEN THAT AFTERMARKET PARTS (INCLUDING FAN CLUTCH FOR THIS VEHICLE) DOES NOT WORK WELL AND END UP NEEDING REPLACEMENT ALMOST AS SOON AS REPAIRS ARE DONE. THIS REALLY SUCKS THAT AN AMERICAN AUTO MANUFACTURER CAN FAIL TO MAKE PARTS AVAILABLE FOR 12 YEAR OLD VEHICLES. I GUESS THEY NEED TO SELL A NEW ONE THAT BAD! NOT ANOTHER DODGE, FOR SURE

  • Filed Jul 2016

    TL* THE CONTACT OWNS A 2005 DODGE RAM 2500. WHILE DRIVING APPROXIMATELY 25 MPH, THE HEADLIGHTS AND TAIL LIGHTS FAILED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FUSE BOX MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 80,000. ...UPDATED 09/14/16 *BF THE CONSUMER STATED THE FUSE BOX NECESSARYTO COMPLETE THE REPAIR WAS NO LONGER IN PRODUCTION. *JS

  • Filed Apr 2016

    TURN SIGNAL SIGNALLING WRONG DIRECTION WITHOUT WARNING OR NO SIGNALLING AT ALL. SEEMS TO HAPPEN ON DAYS WITH HEAVY DEW OR FOG... CAN AFFECT HAZARD LIGHTS AS WELL.

  • Filed May 2015

    TL* THE CONTACT OWNS A 2005 DODGE RAM 2500. WHILE DRIVING APPROXIMATELY 45 MPH AND SIGNALING A RIGHT TURN, THE TURN SIGNAL FAILED TO ENGAGE WITHOUT WARNING. THE CONTACT ALSO STATED THAT WHILE SIGNALING TO MAKE A RIGHT TURN, THE LEFT TURN SIGNAL ACTIVATED WITHOUT WARNING. THE CONTACT PULLED THE VEHICLE OVER AND ALSO DISCOVERED THAT THE PASSENGER SIDE TAIL LIGHT HAD BLOWN OUT. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE WINDSHIELD WIPER STALK WAS FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 73,000.

  • Showing the 5 most recent of 17.
• Fuel System17

  2 involved a crash

  • Filed Jun 2016

    TL* THE CONTACT OWNS A 2005 DODGE RAM 2500. WHILE DRIVING APPROXIMATELY 45 MPH, SMOKE APPEARED FROM THE HOOD OF THE VEHICLE. UPON INSPECTION, THE CONTACT DISCOVERED THAT THE ENGINE WAS COVERED WITH FUEL. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL LINE INJECTOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 88,287. THE VIN WAS UNAVAILABLE. UPDATED 11/08/16*LJ

  • Filed Sep 2015

    S10 DIRECT REPLY- LETTER TO THE SECRETARY FROM CONSTITUENT REQUESTING ASSISTANCE WITH A POTENTIAL SAFETY ISSUE REGARDING CHRYSLER VEHICLE (S); FULL DOCUMENT NOT IMAGED. *SMD 2005 DODGE RAM 2500. THE CONSUMER STATED THE GAS TANK NEEDED TO BE REPLACED. THE CONSUMER STATED HE WAS NEVER ABLE TO PROPERLY PUT GAS IN THE VEHICLE FROM THE DAY, HE PURCHASED IT. THE CONSUMER STATED THE FIRST TIME HE ATTEMPTED TO PUT GAS IN THE VEHICLE, HE COULD ONLY ADD FOUR CENTS AT A TIME WITHOUT THE NOZZLE SHUTTING OFF AND THE GAS SPILLING OUT. THE GAS TANK WAS REPLACED WITH A USED ONE. HOWEVER, THE REPLACEMENT TANK FAILED. THE CONSUMER STATED INFERIOR PARTS WERE USED WHICH CAUSED THE GAS TANK TO LEAK. *JB

  • Filed Jul 2014

    WHILE ON THE OFF RAMP TO THE STOP AT THE BOTTOM DODGE RAM GAS PEDAL STUCK DOWN CAUSING THE TRUCK TO ACCELERATE CAUSING THE TRUCK TO LEAVE THE ROAD AT AROUND 85+ MPH THEN DROPPING OFF THE ROAD TO AN 400+ DROP. *TR

  • Filed Dec 2013

    SHORTLY AFTER SPEEDING UP A CAR IN FRONT OF ME HIT THEIR BRAKES. WHEN I ATTEMPTED TO SLOW DOWN IT SEEMED THAT THE ACCELERATOR PEDAL DID NOT RETURN TO NEUTRAL AND IT WAS VERY HARD TO STOP. AFTER TROUBLESHOOTING, I FOUND OUT THAT THE ACCELERATOR PEDAL WAS STICKING AND NOT RETURNING TO NEUTRAL AFTER BEING DEPRESSED. SOMETIMES IT WOULD SLOWLY RETURN TO NEUTRAL, OTHER TIMES IT WOULD STAY DEPRESSED. THERE IS NO EXTERNAL INTERFERENCE WITH THE PEDAL (I.E. FLOOR MAT), AND ONLY THE PEDAL LINKAGE IS AT FAULT. IF I PUSHED THE PEDAL A LARGE DISTANCE THEN IT WOULD NORMALLY SPRING BACK ALL THE TO NEUTRAL. WHEN I CHECKED CLOSELY, IT APPEARS THAT THE ACCELERATOR PEDAL POSITION SENSOR (APPS) IS WHAT IS CAUSING THE BINDING. THIS TRUCK IS THROTTLE-BY-WIRE SO NO MECHANICAL CABLE IS INVOLVED. THE APPS IN THIS MODEL TRUCK IS PART OF THE ACCELERATOR PEDAL MECHANISM AND THE HINGE POINT FOR THE PEDAL IS IN THE APPS. *TR

  • Filed Apr 2012

    DRIVING HOME FROM WORK I NOTICED A STRONG SMELL OF DIESEL FUEL IN THE CAB, LOOKING IN THE REARVIEW MIRROR I NOTICED THAT ALL THE CARS BEHIND ME HAD SLOWED DOWN TO A DISTANCE OF APPROX. 300 FEET AND WHITE SMOKE TRAILING BEHIND THE TRUCK. WHEN I HAD THE CHANCE I PULLED OVER IN A STORE PARKING LOT AND EXITED THE CAB TO SEE FUEL POURING OUT UNDER MY TRUCK AND WHITE SMOKE COMING OUT FROM THE LEFT FRONT WHEEL WELL. I HAD THE TRUCK TOWED TO CLOSEST DODGE DEALER WHERE THEY DISCOVERED THE NUMBER 4 INJECTOR LINE HAD RUPTURED AND COATED THE WHOLE ENGINE BAY. THEY ALSO INDICTED THAT I WAS LUCKY THAT THIS DID NOT CAUSE A FIRE OR POSSIBLY AN ACCIDENT FROM THE FUEL SPILLING ON THE ROADWAY. WHILE READING A CUMMINS FORUM ONLINE I HAVE DISCOVERED THIS TO BE A FAIRLY COMMON PROBLEM. *TR

  • Showing the 5 most recent of 17.
• Engine And Engine Cooling13

  1 involved a crash · 2 involved a fire

  • Filed May 2012

    EXCESSIVE VIBRATION SINCE PURCHASES TRUCK NEW IN 2005. REPLACED SERPENTINE BELT 5 TIMES AND TENSIONER PULLEY 2 TIMES, WHICH IS ABOUT EVERY 30K MILES. CHRYSLER AGREED TO PAY FOR THE LAST BELT AND PULLEY ACKNOWLEDGING SOMETHING WAS WRONG CAUSING THE ISSUE. THE ISSUE WAS NOT KNOWN UNTIL RECENTLY. THE VIBRATION OVER A LONG PERIOD OF TIME CAUSED SEVERAL BOLTS/MOUNTS TO WORK LOOSE AND ALLOWED PARTS TO SHIFT. THE COOLING FAN SHIFTED INTO THE RADIATOR BREAKING THE FAN BLADES AND BUSTING THE RADIATOR. THE RADIATOR, FAN ASSEMBLY AND FAN HAD TO BE CHANGED. DURING THESE REPAIRS THE VIBRATION SOURCE WAS FOUND. THE FLYWHEEL WAS BAD. CHANGED FLYWHEEL, CLUTCH AND THROW OUT BEARING. THE BEARING IN THE FLYWHEEL WAS BAD AND CAUSING SLACK WHICH CAUSED THE VIBRATION. THE EXCESSIVE VIBRATION ALSO CAUSED A 5" CRACK IN THE BELL HOUSING AND BROKE THE EXHAUST PIPE IN TWO. MUFFLER SHOP SAID THEY HAVE NEVER SEEN A BREAK IN THE EXHAUST LIKE THIS. CHRYSLER IS SAYING ALL OF THESE ITEMS ARE NORMAL WEAR AND TEAR, DISREGARDING THE FACT THAT EARLIER CHRYSLER AGREED TO REPLACE A SERPENTINE BELT AND TENSIONER PULLEY. UJOINTS IN THE SAME VEHICLE HAVE BEEN CHANGED MULTIPLE TIMES. VERY POOR HEADLIGHTS. SO BAD IT IS A SAFETY ISSUE NOT ALLOWING THE DRIVER TO ADEQUATELY SEE IN FRONT OF THE VEHICLE WHILE DRIVING DURING THE NIGHT. *TR

  • Filed Mar 2012

    TL* THE CONTACT OWNS A 2005 DODGE RAM 2500. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, HE STARTED TO HEAR A TICKING NOISE COMING FROM THE MOTOR. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE EXHAUST MANIFOLD OVERHEATED AND TWISTED, CAUSING THE BOLTS TO FRACTURE. AS A RESULT BOTH MANIFOLDS NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 79,000.

  • Filed Sep 2009

    2005 DODGE 2500 DIESEL TRUCK. REPLACED SERPENTINE BELT 4 TIMES DUE TO FRAYING. THE LAST TIME IT WAS CHANGED THE DEALERSHIP TOLD ME A PULLEY HAD A NICK ON IT AND NEEDED REPLACED. I PAID TO REPLACE THE SERPENTINE BELT AND PULLEY. I HAVE 120,000 MILES ON THE VEHICLE AND THE 4TH BELT IS NEEDING CHANGED DUE TO FRAYING. THE EDGE TOWARDS THE FAN IS THE ONE THAT GETS FRAYED. I EMAILED DODGE A WEEK AGO AND HAVE NOT RECEIVED A RESPONSE. I FEEL THIS IS A DEFECT. *TR

  • Filed Jun 2009

    TL*THE CONTACT OWNS A 2005 DODGE RAM 2500. WHILE DRIVING AT AN UNKNOWN SPEED, THE TRANSMISSION WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. IMMEDIATELY, SMOKE AND VAPORS APPEARED FROM THE ENGINE COMPARTMENT. THE CONTACT USED A 10-POUND FIRE EXTINGUISHER, BUT WAS NOT SUCCESSFUL IN EXTINGUISHING THE FLAMES. THE FIRE DEPARTMENT WAS CALLED TO EXTINGUISH THE FIRE. BOTH A POLICE AND FIRE REPORT WERE FILED. THE VEHICLE WAS DESTROYED. THE FAILURE AND CURRENT MILEAGES WERE LESS THAN 28,400.

  • Filed Jun 2009

    MY 2005 DODGE RAM 2500 IGNITED AND BLEW UP WHILE UNDER 7 YEAR 70K WARRANTY AND CHRYSLER DENIES ANY RESPONSIBILITY. *TR

  • Showing the 5 most recent of 13.
• Visibility/Wiper11

  • Filed Dec 2020

    THE HEATER IN THE TRUCK WILL NOT THROW OUT HEAT IN VENTS ON TOP OF DASH AND ONLY PUT HEAT OUT ON DRIVERS SIDE IN OTHER VENTS FOR FLOOR OR PANEL. SO THERE IS NO HEAT COMING OUT OF DEFROSTER VENTS. WILL NOT DEFROST FRONT WINDSHIELD. CANNOT SEE OUT OF WINDSHIELD CANNOT SAFELY DRIVE VEHICLE. THIS IS A WIDE SPREAD PROBLEM WITH THESE TRUCKS.

  • Filed Dec 2018

    VEHICLES WIPERS DON'T WORK CORRECTLY. THEY GO ON AND OFF RANDOMLY. I HAVE WITNESSED THEM TURNING ON WHILE THE VEHICLE WAS PARKED AND TURNED COMPLETELY OFF WITH NO KEY IN THE IGNITION. WHILE DRIVING THE WIPERS WON'T GO ON WHEN I NEED THEM MOST.

  • Filed May 2018

    ALL LIGHTS (HEADLIGHTS, TAILLIGHTS, ETC.) COME ON WHILE VEHICLE TURNED OFF AND TURN OFF WHILE VEHICLE IS RUNNING. ALSO, WINDSHIELD WIPERS AND WASHERS RUN ALL THE TIME AND CAN NOT BE TURNED OFF. DRAINS BATTERY WHILE NOT RUNNING, THEN WILL NOT START. FACTORY TRAINED MECHANIC SAYS IT IS A "BAD TIPM" (TOTALLY INTEGRATED POWER MODULE), AND THE DEALERSHIP CAN NOT ORDER A NEW TIPM AS DODGE DOES NOT MAKE THESE ANYMORE (VEHICLE IS 12 YEARS OLD). MY VEHICLE IS PRACTICALLY USELESS AND NOW VALUELESS, AS I CAN NOT GET NEEDED PARTS TO REPAIR. MY EXPERIENCE HAS BEEN THAT AFTERMARKET PARTS (INCLUDING FAN CLUTCH FOR THIS VEHICLE) DOES NOT WORK WELL AND END UP NEEDING REPLACEMENT ALMOST AS SOON AS REPAIRS ARE DONE. THIS REALLY SUCKS THAT AN AMERICAN AUTO MANUFACTURER CAN FAIL TO MAKE PARTS AVAILABLE FOR 12 YEAR OLD VEHICLES. I GUESS THEY NEED TO SELL A NEW ONE THAT BAD! NOT ANOTHER DODGE, FOR SURE

  • Filed Mar 2018

    WIPERS WORK FINE IN HIGH OR LOW POSITION BUT ARE SPORADIC AND OR STOP COMPLETELY IN THE INTERMITTENT POSITION.

  • Filed May 2015

    TL* THE CONTACT OWNS A 2005 DODGE RAM 2500. WHILE DRIVING APPROXIMATELY 45 MPH AND SIGNALING A RIGHT TURN, THE TURN SIGNAL FAILED TO ENGAGE WITHOUT WARNING. THE CONTACT ALSO STATED THAT WHILE SIGNALING TO MAKE A RIGHT TURN, THE LEFT TURN SIGNAL ACTIVATED WITHOUT WARNING. THE CONTACT PULLED THE VEHICLE OVER AND ALSO DISCOVERED THAT THE PASSENGER SIDE TAIL LIGHT HAD BLOWN OUT. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE WINDSHIELD WIPER STALK WAS FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 73,000.

  • Showing the 5 most recent of 11.
• Structure10

  • Filed Oct 2024

    White paint job from the factory has totaly failed down to the bare metal in some places and has cracks all over the truck. I understand that their was a formula change in the paint for a couple years. My truck is one of them . The paint job is totaly failed. This a factory defect. Can you help me with this issue. This was my first new truck ever and have cared for it to the best ability. The cost of a paint job is scary. Thanks

  • Filed Apr 2019

    TL* THE CONTACT OWNS A 2005 DODGE RAM 2500. WHEN THE CONTACT PURCHASED THE VEHICLE, HE NOTICED A PIECE OF THE BODY FILLER FALL OUT FROM UNDER THE FRONT DRIVER'S DOOR. HE ALSO NOTICED THAT EIGHT INCHES FROM THE FRAME WAS CORRODED THROUGH. THE CONTACT CALLED GIBSON AUTO & RV SALES AT (864) 467-9080 (LOCATED AT 3103 N PLEASANTBURG DR, GREENVILLE, NC 29609), WHICH WAS WHERE THE VEHICLE WAS PURCHASED. THE CONTACT WAS INFORMED THAT THEY WOULD SEND A CHECK FOR THE REPAIR OF THE FRAME. THE VEHICLE WAS NOT TAKEN TO A DEALER AND WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 210,130.

  • Filed Apr 2018

    DRIVING ACCROSS THE KINGSTON RHINECLIFF BRIDGE AND HEARD CLUNKING AND SCRAPING FROM UNDER THE TRUCK BED. I PULLED OVER TO INSPECT THE UNDERCARRIAGE AND NOTICED THE GAS TANK STRAP HAD RUSTED AND FAILED LEAVING THE GAS TANK HANGING.

  • Filed Oct 2017

    BOTH REAR WHEEL WELLS ARE RUSTING OUT FROM INSIDE OUT. I KNOW THIS IS A OLD VEHICLE NOW BUT THIS SHOULD RUST FROM OUTSIDE IN. I TAKE VERY GOOD CARE OF TRUCK SO IT DOESN'T RUST AWAY ON ME, THIS IS VERY FRUSTRATING TO HAVE HAPPEN. RUST WILL EAT THRU SOON ENOUGH AND ROCKS WILL BE ABLE TO BE FLUNG OUT AT OTHER CARS.

  • Filed Aug 2016

    TL* THE CONTACT OWNS A 2005 DODGE RAM 2500. WHILE THE VEHICLE WAS PARKED, THE CONTACT NOTICED OIL LEAKING UNDERNEATH THE VEHICLE. UPON FURTHER INSPECTION, THE CONTACT NOTICED THAT THE OIL PAN WAS CORRODED AND CAUSED OIL TO LEAK. THE VEHICLE WAS TAKEN TO A DEALER WHO CONFIRMED THE CORROSION AND DIAGNOSED THAT THE OIL PAN NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 110,000.

  • Showing the 5 most recent of 10.
• Service Brakes9

  3 involved a crash

  • Filed May 2020

    BRAKE PEDAL MOVES SIDE TO SIDE WHEN APPLYING THE BRAKE. THE VEHICLE HAS POWER ADJUSTABLE BRAKE AND ACCELERATOR PEDALS. FIRST NOTICED SLIGHT MOVEMENT WHILE DRIVING AND IS NOW ABOUT HALF TO THREE QUARTERS OF AN INCH PLAY. *TR

  • Filed Mar 2017

    TL* THE CONTACT OWNS A 2005 DODGE RAM 2500. WHILE DRIVING APPROXIMATELY 80 MPH, THE VEHICLE VIBRATED ABNORMALLY. WITHIN SECONDS, A LOUD NOISE WAS HEARD UNDER THE VEHICLE. THE DRIVER WAS ABLE TO COAST ONTO THE ROAD SHOULDER AND FOUND UNKNOWN PARTS HAD SEPARATED FROM THE VEHICLE WHILE DRIVING. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE TRANSFER CASE, CONSTANT VELOCITY JOINT, UNIVERSAL JOINT, FUEL LINES, AND BRAKES LINES FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 270,000.

  • Filed Apr 2015

    TL* THE CONTACT OWNED A 2005 DODGE RAM 2500. WHILE DRIVING APPROXIMATELY 75 MPH AND WHILE APPLYING THE BRAKES TO SLOW DOWN, THE VEHICLE SUDDENLY ACCELERATED. THE DRIVER LOST CONTROL OF THE VEHICLE AND CRASHED INTO A CONSTRUCTION SITE. THE DRIVER SUFFERED A NECK INJURY AND THE FRONT PASSENGER SUFFERED A FRACTURED STERNUM AND INJURIES TO THE RIGHT FOOT AND LEFT LUNG. MEDICAL ASSISTANCE WAS REQUIRED AND A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 137,000.

  • Filed Feb 2014

    TL* THE CONTACT OWNS A 2005 DODGE RAM 2500 DIESEL TRUCK. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 50 MPH, HE APPLIED THE BRAKES FOR A TRAFFIC STOP AND THE VEHICLE ACCELERATED. IN ADDITION, THE ENGINE RMPS INCREASED TO 2000. THE BRAKE PEDAL WAS ENGAGED WITH BOTH FEET IN ORDER TO STOP THE VEHICLE. THE FAILURE RECURRED WHENEVER THE VEHICLE WAS OPERATION. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER BUT HAD NOT BEEN REPAIRED OR DIAGNOSED. THE APPROXIMATE FAILURE MILEAGE WAS 116,000.

  • Filed Oct 2011

    THE ABS CONTROL UNIT ON MY 2005 DODGE RAM 2500 BROKE. I WAS ALERTED TO THIS BY A BRAKE LIGHT AND AN ABS LIGHT ON THE DASHBOARD. AFTER SHUTTING OFF THE ENGINE, THE MODULE MOTOR CONTINUES TO RUN. THE FOLLOWING PART NUMBERS ARE LISTED ON THE UNIT: P52121408AD TJZBK2824K0241. *TR

  • Showing the 5 most recent of 9.
• Diesel8

  • Filed Jun 2016

    TL* THE CONTACT OWNS A 2005 DODGE RAM 2500. WHILE DRIVING APPROXIMATELY 45 MPH, SMOKE APPEARED FROM THE HOOD OF THE VEHICLE. UPON INSPECTION, THE CONTACT DISCOVERED THAT THE ENGINE WAS COVERED WITH FUEL. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL LINE INJECTOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 88,287. THE VIN WAS UNAVAILABLE. UPDATED 11/08/16*LJ

  • Filed Dec 2013

    SHORTLY AFTER SPEEDING UP A CAR IN FRONT OF ME HIT THEIR BRAKES. WHEN I ATTEMPTED TO SLOW DOWN IT SEEMED THAT THE ACCELERATOR PEDAL DID NOT RETURN TO NEUTRAL AND IT WAS VERY HARD TO STOP. AFTER TROUBLESHOOTING, I FOUND OUT THAT THE ACCELERATOR PEDAL WAS STICKING AND NOT RETURNING TO NEUTRAL AFTER BEING DEPRESSED. SOMETIMES IT WOULD SLOWLY RETURN TO NEUTRAL, OTHER TIMES IT WOULD STAY DEPRESSED. THERE IS NO EXTERNAL INTERFERENCE WITH THE PEDAL (I.E. FLOOR MAT), AND ONLY THE PEDAL LINKAGE IS AT FAULT. IF I PUSHED THE PEDAL A LARGE DISTANCE THEN IT WOULD NORMALLY SPRING BACK ALL THE TO NEUTRAL. WHEN I CHECKED CLOSELY, IT APPEARS THAT THE ACCELERATOR PEDAL POSITION SENSOR (APPS) IS WHAT IS CAUSING THE BINDING. THIS TRUCK IS THROTTLE-BY-WIRE SO NO MECHANICAL CABLE IS INVOLVED. THE APPS IN THIS MODEL TRUCK IS PART OF THE ACCELERATOR PEDAL MECHANISM AND THE HINGE POINT FOR THE PEDAL IS IN THE APPS. *TR

  • Filed Apr 2012

    DRIVING HOME FROM WORK I NOTICED A STRONG SMELL OF DIESEL FUEL IN THE CAB, LOOKING IN THE REARVIEW MIRROR I NOTICED THAT ALL THE CARS BEHIND ME HAD SLOWED DOWN TO A DISTANCE OF APPROX. 300 FEET AND WHITE SMOKE TRAILING BEHIND THE TRUCK. WHEN I HAD THE CHANCE I PULLED OVER IN A STORE PARKING LOT AND EXITED THE CAB TO SEE FUEL POURING OUT UNDER MY TRUCK AND WHITE SMOKE COMING OUT FROM THE LEFT FRONT WHEEL WELL. I HAD THE TRUCK TOWED TO CLOSEST DODGE DEALER WHERE THEY DISCOVERED THE NUMBER 4 INJECTOR LINE HAD RUPTURED AND COATED THE WHOLE ENGINE BAY. THEY ALSO INDICTED THAT I WAS LUCKY THAT THIS DID NOT CAUSE A FIRE OR POSSIBLY AN ACCIDENT FROM THE FUEL SPILLING ON THE ROADWAY. WHILE READING A CUMMINS FORUM ONLINE I HAVE DISCOVERED THIS TO BE A FAIRLY COMMON PROBLEM. *TR

  • Filed Nov 2010

    2005 DODGE 2500 DIESEL. STARTING AT APROX. 27,000 MILES, THE TRUCK BEGAN TO IDLE ROUGHLY AND WAS INCREASINGLY HARDER TO START. AT ABOUT 30K MILES, THE TRUCK WAS TAKEN TO THE DEALERSHIP FOR REPAIR. AFTER ABOUT A WEEK, THE DEALERSHIP INFORMED US THAT THE FUEL WAS NOT DIESEL IN THE TRUCK, AND THEY DID NOT KNOW WHAT IT WAS. IN FACT IT WAS DIESEL FROM OUR VERY OWN TANK, AND OUR FUEL SALESMAN TOLD THEM IT WAS ULSD, WITH A MOUNTAIN DEW APPEARANCE FOR HIGHWAY. THE DEALER REMOVED THE FUEL FROM THE TRUCK AND REPLACED IT WITH THEIR OWN, ONLY TO THEN TELL US WE RUINED THE ENTIRE FUEL SYSTEM, WHICH WOULD NEED TO BE REPLACED AT A COST OF @ $14,000. THEN THEY ADDED THAT WE HAD VOIDED THE VEHICLE WARRANTY FROM CONTAMINATION. WE TOOK THE TRUCK DIRECTLY TO CUMMINS, WHO DIAGNOSED 2 FAULTY INJECTORS AND REPLACED THEM AT A COST OF @$1700. THE TRUCK RAN FINE FOR 3 YEARS, THEN SAME TROUBLE AGAIN, TOOK IT BACK TO DODGE AT OUR MECHANICS REQUEST, AND GOT THE SAME TOTAL REPLACEMENT SCENARIO. WENT BACK TO CUMMINS YESTERDAY, WHERE THEY SERVICE TECH TOLD ME 1. DODGE BUYS THE ENGINES FROM CUMMINS JUST ABOVE COST, AND CARRIES THE ENTIRE WARRANTY, 2. DODGE LOCKED CUMMINS OUT OF THE ENGINES THROUGH PROGRAMMING AND DIFFERENT PLUG CONNECTOR 3. HE HAD MANY PEOPLE WITH THE SAME EXPERIENCE AS WE DID, TURNING THE PROBLEM BACK ON THE OWNER AND REFUSING SERVICE. HE SAID IN FACT HE DID NOT KNOW OF DODGE HONORING ENGINE WARRANTEES AT ALL, AND IT WAS A SORE ISSUE FOR CUMMINS REPUTATION. CUMMINS SENT US TO A THIRD PARTY, WERE THE TRUCK IS NOW. WHILE TALKING TO DODGE CORPORATE THE FIRST TIME AROUND, THEY TOLD ME THEY COUNT ON THEIR DEALERS TO BE THE "EYES AND EARS" OF THE COMPANY AND LEAVE IT TO THEM TO DECIDE WARRANTIES. IT IS NOT RIGHT TO VOID OVER A FAULTY COMPONENT, ONE WHICH THE DEALER COULD NOT EVEN DIAGNOSE. IF I TOOK IT TO A REGULAR MECHANIC FOR A SPARK PLUG AND THEY TOLD ME I NEEDED A NEW ENGINE, THAT WOULD SHOW EXTREME NEGLIGENCE. *TR

  • Filed Oct 2009

    RE: POSSIBLE DANGEROUS LEAKING FUEL TUBE DODGE CORPORATION DODGE CUSTOMER ASSISTANCE CENTER P. O. BOX 21-8004 AUBURN HILLS, MI 48321-8004 TEL: 800-992-1997 13 OCTOBER 2009 DEAR DODGE CORPORATION, I AM FORWARDING A COPY OF THIS LETTER TO THE NHTSA, AAA, CONSUMER REPORTS AND CPPB. ON OCTOBER 10TH WHILE RETURNING HOME FROM PASADENA I DETECTED A STRONG SCENT OF DIESEL IN THE CAB OF MY TRUCK. IT WAS ESPECIALLY STRONG AS I SLOWED AFTER TRAVELING SEVERAL HOURS ON THE SOUTHERN CALIFORNIA FREEWAY SYSTEM. WHEN I ARRIVED HOME I INVESTIGATED AND DISCOVERED THAT THE INJECTOR TUBE TO THE #4 CYLINDER WAS SPRAYING A FINE MIST OF FUEL INTO AND AROUND THE ENGINE COMPARTMENT AND ONTO THE FIREWALL AS WELL AS BEING SOAKED INTO THE HOOD INSULATION. I KNOW THAT THE DIESEL FUEL IS FAR LESS VOLATILE THAN GASOLINE. I ALSO KNOW THAT ATOMIZING IT IN A CONFINED COMPARTMENT THAT HAS HIGH TEMPERATURES AS WELL AS A CHANCE FOR SPARK OR A SHORTED WIRE, SUCH AS THE CONFINES OF THE ENGINE COMPARTMENT, ARE AN EXCELLENT LOCATION FOR A VEHICLE FIRE. DIESEL FUEL IS DIFFICULT TO IGNITE BUT ONCE IT IS BURNING IT IS DIFFICULT TO EXTINGUISH. YOU AND YOUR EXPERT ENGINEERS ARE AWARE OF THIS. I FOUND THAT THE BLUE PLASTIC RETAINING CLAMP THAT HOLDS THE INJECTOR TUBE IN PLACE AND PREVENTS VIBRATION FROM DAMAGING THE CONNECTIONS OR THE TUBE ITSELF WAS LOOSE. THE PLASTIC CLAMP/RETAINER WAS SECURELY HELD IN PLACE BY THE SCREW THAT PASSED THROUGH THE DEVICE BUT THE WHOLE CLAMP WOULD FREELY MOVE AROUND THE TUBE AND THE TUBE WOULD BE ABLE TO MOVE BACK AND FORTH INSIDE THE CLAMP. THIS SORT OF DEFEATS IT'S PURPOSE. I FOUND THAT THE PRESSED FITTING ON THE TUBE NEAR WHERE IT ATTACHED TO THE INJECTOR WAS WHERE THE MISTING/LEAK WAS. MY INTERNET RESEARCH HAS FOUND THAT THIS ANOMALY IN THE FUEL DELIVERY SYSTEM THOUGH NOT COMMON IS NOT UNCOMMON. I BELIEVE THAT IT IS MORE APT TO OCCUR IN THE 2006 MODELS BUT THIS IS ONLY MY OPINION FROM LIMITED INTERNET RESEARCH. *TR

  • Showing the 5 most recent of 8.
• Wheels7

  1 involved a crash

  • Filed Mar 2019

    DODGE DEATH WOBBLE HAS HAPPENED NUMEROUS TIMES THE LAST TIME IT BROKE THE TIE ROD END AND THREW ME OFF THE ROAD

  • Filed Sep 2016

    2005 RAM 2500 4X4. KMC XD ROCKSTAR RIMS (20*10"), 37*12.5*20 NITTO TERRA GRAPPLER TIRES. I'VE HAD THE XD RIMS FOR 2 1/2 YEARS, NO PROBLEMS, ALL HIWAY MILES, NO OFF-ROADING. SITTING IN DRIVEWAY FOR 3 DAYS, I NOTICED A FLAT TIRE, AFTER AIRING UP TO 50 PSI AS DESCRIBED ON DOOR JAM, I SPRAYED DOWN WITH SOAPY WATER LOOKING FOR LEAK, HUGE BUBBLE OCCURRED ON THE BASE OF THE RIM, CLEANED THE AREA AND FOUND A 3/4" CRACK LEAKING AIR. KMC WILL EVALUATE THE RIM FOR WARRANTY. I'VE SINCE READ MANY STORIES OF THE SAME WHEEL HAVING CRACKS.

  • Filed Nov 2014

    I HAD TAKEN MY TRUCK TO GET IT SERVICED BECAUSE THE STEERING FELT OFF AND WHEN I WOULD GO TO STOP IT SOUNDED LIKE METAL SHAKING. WHEN I GOT TO THE DEALERSHIP THEY SAID THE LEFT TIE ROD WAS CRACKED AND THE STEERING LINKAGE WAS JUST HANGING THERE ABOUT TO FALL OFF. THERE HAD BEEN A RECALL ON IT BEFORE I HAD PURCHASED THE TRUCK SO I CALLED CHRYSLER GROUP AND THEY INFORMED ME THAT IT WAS DEEMED THAT THE TRUCK DIDN'T HAVE THE "SPECIFIC RECALLED" PART. SO I HAD TO PAY OUT OF POCKET AROUND $3,000 TO FIX A PROBLEM THAT THERE WAS A RECALL ON. THE EXACT SAME PROBLEM LISTED IN THE RECALL, "BECAUSE THE LEFT TIE ROD BALL STUD MAY FRACTURE." IS EXACTLY WHAT HAPPENED TO MINE. I WAS TOLD BY CHRYSLER GROUP THAT SINCE MY TRUCK HAD BEEN CHECKED FOR THE SPECIFIC PART BY THE PREVIOUS OWNER AND IT WASN'T PART OF THE RECALL THEY WOULDN'T COVER IT. THEY DID SAY TO KEEP ALL MY RECIEPTS IN CASE THERE IS A FUTURE RECALL ON THAT SPECIFIC PART. *TR

  • Filed Jan 2012

    DEALER HAD MY TRUCK TWICE SINCE THE RECALL. HE TOLD ME THAT THERE WAS A TIE-ROD ASSEMBLY, STEERING LINKAGE AND FRONT END NEEDED. I ONLY HAVE 49,000 MILES ON IT AND THERE'S A RECALL FOR THESE DEFECTS WITH CHRYSLER ID 11V350000 - THEY OLD ME THAT IT WOULD COST ME $3,000 THE FIRST TIME AND THEN I CAME BACK TO GET PARTS AND NOW THEY ARE TELLING ME THEY WILL GIVE ME A BREAK ON PARTS - THIS IS FRAUD IF THERE'S A RECALL PLUS THEY SHOULD HAVE FIXED IT THE FIRST TIME FOR FREE - IT WAS TOTALLY UNDER WARRANTY AT BOTH TIMES. *TR

  • Filed Nov 2011

    MY DODGE RAM 2500 TRUCK HAS A VIOLENT DEATH WOBBLE ISSUE. AT FREEWAY SPEEDS WHEN HITTING AN UNEVEN BUMP IN THE PAVEMENT THE TRUCK GOES INTO A SUSTAINING DEATH WOBBLE TYPE MOTION IN THE FRONT END. IT IS EXTREMELY SCARY, AND QUITE DANGEROUS. THE TRUCK IS COMPLETELY OUT OF CONTROL AND MUST BE SLOWED TO APPROXIMATELY 30 MPH FOR THE WOBBLE TO STOP. I'VE TAKEN MY TRUCK TO THE DODGE DEALER SEVERAL TIMES AND THEY CANNOT FIND THE PROBLEM. I'VE REPLACED EVERYTHING, THE AXLE, STEERING DAMPENER 3 TIMES, BALL JOINTS, ALIGNMENT ADJUSTMENTS, NEW TIRES. THE PROBLEM GOES AWAY FOR A SHORT TIME BUT THEN ALWAYS RETURNS. I'M AFRAID TO DRIVE MY TRUCK ON THE FREEWAY AND MY KIDS ARE AFRAID TO DRIVE IN MY TRUCK PERIOD. WHEN IT HAPPENS IT'S VERY WILD AND SCARY. ALL THE TRAFFIC AROUND ME SLOWS DOWN AND SWERVES TO GET AWAY FROM MY TRUCK. IT'S NOT ONLY DANGEROUS AND SCARY, BUT EMBARRASSING TOO. I DON'T KNOW WHAT TO DO. I'VE TRIED EVERYTHING AND NOTHING IS WORKING. DODGE IS PRETTY MUCH USELESS. THEY TURNED THEIR BACK ON ME SINCE ALL THE COMPONENTS CHECK OUT FINE. THEY SAID THERE'S NOTHING THAT THEY CAN DO. I NEED A RESOLUTION FOR THIS PROBLEM. *TR

  • Showing the 5 most recent of 7.
• Gasoline7

  2 involved a crash

  • Filed Sep 2015

    S10 DIRECT REPLY- LETTER TO THE SECRETARY FROM CONSTITUENT REQUESTING ASSISTANCE WITH A POTENTIAL SAFETY ISSUE REGARDING CHRYSLER VEHICLE (S); FULL DOCUMENT NOT IMAGED. *SMD 2005 DODGE RAM 2500. THE CONSUMER STATED THE GAS TANK NEEDED TO BE REPLACED. THE CONSUMER STATED HE WAS NEVER ABLE TO PROPERLY PUT GAS IN THE VEHICLE FROM THE DAY, HE PURCHASED IT. THE CONSUMER STATED THE FIRST TIME HE ATTEMPTED TO PUT GAS IN THE VEHICLE, HE COULD ONLY ADD FOUR CENTS AT A TIME WITHOUT THE NOZZLE SHUTTING OFF AND THE GAS SPILLING OUT. THE GAS TANK WAS REPLACED WITH A USED ONE. HOWEVER, THE REPLACEMENT TANK FAILED. THE CONSUMER STATED INFERIOR PARTS WERE USED WHICH CAUSED THE GAS TANK TO LEAK. *JB

  • Filed Jul 2014

    WHILE ON THE OFF RAMP TO THE STOP AT THE BOTTOM DODGE RAM GAS PEDAL STUCK DOWN CAUSING THE TRUCK TO ACCELERATE CAUSING THE TRUCK TO LEAVE THE ROAD AT AROUND 85+ MPH THEN DROPPING OFF THE ROAD TO AN 400+ DROP. *TR

  • Filed Mar 2012

    JUST PULLED ON TO EXIT RAMP LOST POWER AND STARTED MISSING, BY THE TIME REACHED STOP SIGN AT BOTTOM PULLED OVER SHUT OFF ENGINE AND RESTARTED. BARELY REGAINED SPEED TO 40 MPH TO LIMP TO JOB SITE RAN INJECTOR CLEANED LIMPED 25 MILES INTO TOWN TO MECHANIC HE REPLACED LEFT BACK WIRING HARNESS SAID FAULTY DESIGN OF PLUGS GOIING TO INJECTORS. *TR

  • Filed Jan 2012

    WHILE DRIVING ON MY WAY HOME FROM THE GROCERY STORE I GOT A REAL STRONG DIESEL SMELL COMING INTO THE CABIN, I WAS HALF A BLOCK AWAY SO I KEPT DRIVING GOT INTO MY DRIVEWAY AND POPPED THE HOOD TO FIND INJECTOR LINE #4 LEAKING LIKE CRAZY TURNED THE TRUCK OFF AND THE NEXT DAY I WENT TO THE DEALER AND BOUGHT TWO NEW INJECTOR LINE, REPLACED THE BAD ONE AND KEPT ONE FOR SPARE, ANOTHER 8 MONTHS LATER THE SAME LINE WENT OUT AGAIN, SO I REPLACED IT WITH THE SPARE I HAD IN THE TRUCK I WENT BACK TO THE DEALER AND BOUGHT ANOTHER TWO, MY 3RD ONE WENT OUT A WEEK BEFORE HALLOWEEN WHILE SHOPPING FOR MY 2 YEAR OLD SONS COSTUME I WAS ON THE FREEWAY GOING BACK HOME WITH MY WIFE, MY SON, AND MY DAD I GOT THE SAME SMELL INTO THE CABIN AND THIS TIME I GOT SOME SMOKE INTO THE CABIN ALSO I FREAKED OUT AND GOT OFF THE FREEWAY AND PUT MY WIFE, SON AND DAD INTO A TAXI AND SENT THEM HOME AND I REPLACED A 3RD INJECTOR LINE, THIS HAS TO STOP BEFORE SOMEBODY GETS HURT, DODGE HAS TO STEP UP AND DO SOMETHING ABOUT IT OR I HAVE A FEELING THEY WILL PAY ALOT OF MOBEY IF SOMETHING BAD HAPPENS. *TR

  • Filed Nov 2005

    I WAS IN A SINGLE CAR ACCIDENT ON NOVEMBER 14, 2005 IN A 2005 DODGE RAM PICKUP TRUCK . I HIT A DEER AND THEN HIT A TREE GOING 45-50 MPH. MY AIR BAG DID NOT DEPLOY AND THE FUEL SWITCH DID NOT TURN OFF. I DO NOT UNDERSTAND WHY THE AIRBAG DID NOT DEPLOY AS IT SHOULD HAVE. *NM

  • Showing the 5 most recent of 7.
• Engine6

  1 involved a fire

  • Filed Feb 2021

    ENGINES NEEDING CAM SHAFTS LIFTERS TIMING CHAINS THEY OVER HEAT ELECTRIC FANS NOT WORKING BATTERIES EXPLODE TRANSMISSIONS STOP SHIFTING BAD VALVE BODIES BAD ELECTRICAL PARTS THESE TRUCKS ARE DRIVEN AROUND ONE LOCATION AT 35 MPH OR LESS 24-7 AND PARKED FOR LONG TIMES AT IDLE. NO CITY OR HWY DRIVING 4 DIFFERENT TRUCKS AT DEALERSHIPS SINCE 9/16/2020 STILL NOT REPAIRED

  • Filed Apr 2020

    TRUCK BURST INTO FLAMES JUST SITTING IN THE DRIVEWAY. TRUCK HAD BEEN PARKED AND NOT STARTED IN 5 DAYS.

  • Filed Jan 2020

    TL* THE CONTACT OWNS A 2005 DODGE RAM 2500. WHILE DRIVING AT A NORMAL RATE OF SPEED, VARIOUS FUEL INJECTORS BURNED THE PISTONS WITHOUT WARNING AND DAMAGED THE MOTOR. THE CONTACT TOOK THE VEHICLE TO KEN GARFF WEST VALLEY CHRYSLER JEEP DODGE RAM FIAT (4175 W 3500 S, WEST VALLEY CITY, UT 84120) AND DOUG SMITH CHRYSLER DODGE JEEP RAM (523 W MAIN ST, AMERICAN FORK, UT 84003) WHERE THE INJECTORS AND ENGINE WERE REPLACED ON VARIOUS OCCASIONS UNDER WARRANTY. THE FAILURE RECURRED AND THE ENTIRE ENGINE BLEW UP. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC AND PAID $15,000 TO HAVE THE MOTOR REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 60,000.

  • Filed Sep 2015

    TL* THE CONTACT OWNS A 2005 DODGE RAM 2500. THE CONTACT STATED THAT THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE CONTACT ALSO STATED THAT THE HEADLIGHTS, WINDSHIELD WIPERS, INSTRUMENT PANEL LIGHTS, AND GAUGES FAILED TO OPERATE. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS TESTING. THE MECHANIC STATED THAT THE ENGINE CLUSTER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO DEALER WHERE IT WAS DIAGNOSED THAT THE TIPM MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 36,000.

  • Filed Jul 2015

    AFTER CHANGING THE OIL I NOTICED A QUARTER SIZE RUST BUBBLE ON THE SIDE OF THE OIL PAN ABOUT 1/2" FROM THE BOTTOM. I TOOK A RAG AND WIPED IT OFF IN AN ATTEMPT TO SPRAY SOME PAINT ON IT BUT AS SOON AS I WIPED IT THE NEW OIL STARTED RUNNING OUT AT A SLOW DRIP. I ULTIMATELY ENDED UP REPLACING THE OIL PAN. AFTER I HAD THE PAN OF IT LOOKED LIKE THE PAN HAD BEEN PAINTED WITH RUST ON THE OUTSIDE. THE INSIDE OF THE PAN WAS FINE BUT I HAD 10 OR 15 RUST SPOTS THAT WERE BUBBLING UNDER THE PAINT.

  • Showing the 5 most recent of 6.
• Vehicle Speed Control6

  4 involved a crash · 1 involved a fire

  • Filed Apr 2015

    TL* THE CONTACT OWNED A 2005 DODGE RAM 2500. WHILE DRIVING APPROXIMATELY 75 MPH AND WHILE APPLYING THE BRAKES TO SLOW DOWN, THE VEHICLE SUDDENLY ACCELERATED. THE DRIVER LOST CONTROL OF THE VEHICLE AND CRASHED INTO A CONSTRUCTION SITE. THE DRIVER SUFFERED A NECK INJURY AND THE FRONT PASSENGER SUFFERED A FRACTURED STERNUM AND INJURIES TO THE RIGHT FOOT AND LEFT LUNG. MEDICAL ASSISTANCE WAS REQUIRED AND A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 137,000.

  • Filed Jul 2014

    WHILE ON THE OFF RAMP TO THE STOP AT THE BOTTOM DODGE RAM GAS PEDAL STUCK DOWN CAUSING THE TRUCK TO ACCELERATE CAUSING THE TRUCK TO LEAVE THE ROAD AT AROUND 85+ MPH THEN DROPPING OFF THE ROAD TO AN 400+ DROP. *TR

  • Filed May 2014

    DRIVING ON THE HIGHWAY AT 60 MPH SUDDENLY MY FRONT TIRES STARTED BOUNCING UP AND DOWN IN OPPOSED [XXX]. SCARED THE LIFE OUT OF MY WIFE AND ME ! I RECEIVE D IN THE MAIL A NOTICE OF A RECALL ON MY TIEROD BALL JOINTS AND WENT TO COOK CHRYSLER DEALERSHIP ON RT 40 ABERDEEN MD. THEY SAID THEY CANNOT GET THE PARTS ! THEY HAVE A WHOLE LIST OF PEOPLE WHO HAVE THE SAME PROBLEM !! WHATS GOING ON ? ITS A RECALL . I WOULD LIKE AN ANSWER, BUT MORE, I WANT PARTS ! I WILL BE CONTACTING THE ATTORNEY GENERAL. SINCERELY, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) *JS *TR

  • Filed Dec 2013

    SHORTLY AFTER SPEEDING UP A CAR IN FRONT OF ME HIT THEIR BRAKES. WHEN I ATTEMPTED TO SLOW DOWN IT SEEMED THAT THE ACCELERATOR PEDAL DID NOT RETURN TO NEUTRAL AND IT WAS VERY HARD TO STOP. AFTER TROUBLESHOOTING, I FOUND OUT THAT THE ACCELERATOR PEDAL WAS STICKING AND NOT RETURNING TO NEUTRAL AFTER BEING DEPRESSED. SOMETIMES IT WOULD SLOWLY RETURN TO NEUTRAL, OTHER TIMES IT WOULD STAY DEPRESSED. THERE IS NO EXTERNAL INTERFERENCE WITH THE PEDAL (I.E. FLOOR MAT), AND ONLY THE PEDAL LINKAGE IS AT FAULT. IF I PUSHED THE PEDAL A LARGE DISTANCE THEN IT WOULD NORMALLY SPRING BACK ALL THE TO NEUTRAL. WHEN I CHECKED CLOSELY, IT APPEARS THAT THE ACCELERATOR PEDAL POSITION SENSOR (APPS) IS WHAT IS CAUSING THE BINDING. THIS TRUCK IS THROTTLE-BY-WIRE SO NO MECHANICAL CABLE IS INVOLVED. THE APPS IN THIS MODEL TRUCK IS PART OF THE ACCELERATOR PEDAL MECHANISM AND THE HINGE POINT FOR THE PEDAL IS IN THE APPS. *TR

  • Filed Dec 2011

    TL* THE CONTACT OWNS A 2005 DODGE RAM 2500 DIESEL. THE CONTACT WAS DRIVING APPROXIMATELY 5 MPH WHEN THE VEHICLE ACCELERATED TO 30 MPH WITHOUT WARNING. THE CONTACT FORCEFULLY APPLIED THE BRAKES AND SHIFTED INTO PARK BUT THE VEHICLE DID NOT RESPOND AND CONTINUED TO ACCELERATE. SUDDENLY, THE VEHICLE JUMPED OVER AND CRASHED INTO A DITCH, FLIPPED AND CAUGHT ON FIRE. THE CONTACT SUSTAINED INJURIES TO THE LOWER BACK, SHOULDERS AND HEAD. THE CONTACT WAS TRANSPORTED TO THE HOSPITAL VIA AMBULANCE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND AN INVESTIGATOR WAS SENT BY THE MANUFACTURER TO INSPECT THE FAILURE. THE INVESTIGATOR WAS UNABLE TO DIAGNOSE THE FAILURE DUE TO THE SEVERITY OF THE FIRE. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000. THE VIN WAS UNAVAILABLE.

  • Showing the 5 most recent of 6.
• Visibility6

  • Filed Aug 2011

    MY SAFETY ISSUE IS THE FACT THAT I CANNOT CONTROL THE AIRFLOW TO THE WINDSHIELD FOR SAFE VISIBILITY, THE INABILITY TO PREVENT OR CLEAR FOGGING. SNOW-ICE ETC. FROM MY WINDSHIELD AND SIDE WINDOWS. DUE TO FAILURE OF TRANSFER DOORS FROM POOR ENGINEERING IN THE HEATING AND AC SYSTEM. A VERY EXPENSIVE REPAIR ESPECIALLY FOR SOME ONE ON A FIXED INCOME. THIS FAILURE SEEMS TO BE A COMMON FAULT ON 2002-2007 DODGES AT JUST OVER 40000 MILES. *KB

  • Filed Apr 2011

    WINDSHIELD WIPERS DO NOT WORK PROPERLY!!!!!!!!!!!!!!!!!!!!! TURN ON BY THEMSELVES, STAY ON CONSTANT WHEN IN DELAY, DON'T COME ON AT ALL, OR HAVE NO DELAY AT ALL BUT AM ABLE TO TURN ON IN LOW OR HIGH POSITIONS HAVE CHANGED RELAYS, MULTI FUNCTION SWITCH, WIPER MOTOR, FCM NOTHING HAS WORKED AND I CAN NOT GET HELP FROM DEALERSHIP BOUGHT THE VEHICLE USED. *TR

  • Filed Dec 2010

    WINDSHIELD WIPERS WORK ERRATICALLY IF AT ALL. THE INTERMITTENT WIPER FUNCTION TIMING IS OFF, IT WILL WIPE TWICE, WAIT A MINUTE, WIPE ONCE, WAIT A MINUTE OR TWO, WIPE FOUR OR FIVE TIME BACK AND FORTH, NO MATTER WHAT THE SPEED SETTING. THE WIPERS WILL ALSO GET STUCK UP OR IN THE MIDDLE AND FLAT OUT NOT WORK AT ALL SOMETIMES. THIS IS ALL WHEN IT IS RAINING OR TRYING TO USE WINDSHIELD WIPER FLUID TO CLEAN THE WINDSHIELD. *TR

  • Filed Sep 2010

    TL*THE CONTACT OWNS A 2005 DODGE RAM 2500. WHILE DRIVING APPROXIMATELY 40 MPH THE DRIVER ATTEMPTED TO ENGAGE THE LEFT TURN SIGNAL BUT THE RIGHT TURN SIGNAL CAME ON. THE VEHICLE WAS TAKEN TO HIS RESIDENCE AND PARKED. WHILE THE VEHICLE WAS PARKED HE WAS ABLE TO DUPLICATE THE FAILURE. THE TURN SIGNALS WILL EITHER NOT COME ON OR THE OPPOSITE TURN SIGNAL WOULD ILLUMINATE. THE VEHICLE WAS NOT TAKEN TO BE EXAMINED FOR THE CAUSE OF FAILURE AND HAS NOT BEEN REPAIRED. HE ALSO STATED THAT WHEN THE WINDSHIELD WIPER WAS SET ON INTERMITTENT IT WOULD SWIPE MULTIPLE TIMES. THE FAILURE AND CURRENT MILEAGES WERE 44,000. THE VIN WAS UNAVAILABLE.

  • Filed Jun 2010

    DEFROST WINDSHIELD, NO AIR. *TR

  • Showing the 5 most recent of 6.
• Unknown or Other5

  • Filed Mar 2020

    DASH IS CRACKING IN MULTIPLE AREA. SEEMS TO BE GETTING PROGRESSIVELY WORSE. DEFROST VENTS ARE FALLING APART AND BECOMING LODGED IN THE VENTS. WORRIED ABOUT THESE PIECES BREAKING AND BECOMING SHARPS PROJECTILES IN THE EVENING OF A COLLISION. NOT SAFE.

  • Filed Jul 2019

    SPARE TIRE CARRIER. THE CABLE THAT HOIST THE SPARE TIRE UNDER THE BED OF THE TRUCK BROKE AT THE END OF THE CABLE CAUSING THE TIRE TO FALL TO THE GROUND. THIS HAPPENED WHILE I WAS DRIVING AT 55 MPH WHILE TOWING A FIFTH WHEEL CAMPER. THE CAMPER RAN OVER THE TIRE CAUSING DAMAGE TO MY FIFTH WHEEL. BOTH AXLES ARE NOW BENT ON THE CAMPER, BENT A RIM, DESTROYED A TIRE, TORE A JACK STABILIZER OFF OF THE CAMPER. THE TIRE JUST MISSED MY WIFE WHO WAS DRIVING BEHIND ME. WE WERE TRAVELING ON A PAVED ROAD. THANK GOD THAT NOBODY WAS INJURED OR KILLED FROM THIS FREE ROLLING TIRE. I CALLED DODGE ABOUT THE PROBLEM, AT FIRST I WAS TOLD THAT IT WAS A MAINTENANCE PROBLEM, I INFORMED THEM THAT THE OWNERS MANUAL DOES NOT MENTION ANYTHING ABOUT MAINTENANCE FOR THE SPARE TIRE CARRIER. I WAS THEN TOLD THAT THE VEHICLE WAS TOO OLD. THIS IS A 2005 MODEL THAT I BOUGHT BRAND NEW, I AM THE ONLY OWNER OF THE VEHICLE. THE TRUCK IS IN ALMOST PERFECT SHAPE. I HAVE ONLY USED THE SPARE TIRE ONCE, THAT WAS ABOUT 7 YEARS AGO. THIS IS ALSO THE ONLY TIME THAT THE TIRE HAS BEEN LOWERED.

  • Filed Jun 2015

    MY KEYS WERE ABLE TO BE PULLED OUT OF IGNITION SWITCH WITH JUST OVER 40000 MILES ON VEHICLE WHILE VEHICLE WAS BEING DROVE. NOW THE VEHICLE WAS 8 YEARS OLD WHEN I BOUGHT FROM SOMEONE BUT ONLY 40000 MILES WERE ON IT. AS TIME WENT ON LITTLE THINGS STARTED HAPPENING, LIGHTS ON DASH WOULD COME ON THEN SHUT OFF. AIR WOULD STAY ON EVEN AFTER SHUTTING VEHICLE OFF. THEN THAT WOULD DRAIN BATTERY. THE SWITCH WOULD BECOME MORE LOOSE OVER TIME. KEYS WOULDN'T EVEN STAY IN IGNITION, THEY WOULD JUST FALL OUT WHILE I WAS DRIVING.

  • Filed Jul 2013

    TRAVELING ON US93 OUT OF KINGMAN, AZ. HIT A PATCH OF ROUGH FREEWAY AND TRUCK WENT INTO AN UNCONTROLLABLY DEATH WOBBLE. I WAS PULLING A 12 FOOT HAULMARK MOTORCYCLE TRAILER WHEN THIS OCCURRED. IT WAS A MIRACLE WE DIDN'T CRASH. GOT IT SLOWED DOWN AND OFF THE ROAD EVERYTHING APPEARED O.K. PROCEEDED CAUTIOUSLY AND NOW IT WAS PULLING HARD TO THE RIGHT LIKE SOMETHING WAS OUT OF LINE. AFTER DRIVING FOR APPX 25 MILES, WHATEVER WAS CAUSING IT TO PULL TO RIGHT CORRECTED ITSELF. OVER THE NEXT 1500 MILES THIS HAS OCCURRED ON THREE MORE OCCASIONS ONCE WITH TRAILER AND TWICE WITHOUT TRAILER. HAVE NEW SHOCKS AND TIRES ORDERED. HAVE AND APPT WITH DODGE TO HAVE IT CHECKED OUT BUT HAVE LITTLE FAITH IN THEM. *TR

  • Filed Jan 2010

    DRIVING ON THE HWY 5 DOING 70 MPH LONG STRAIGHT AWAY HIT A BUMP AND IT FELT LIKE ALL MY TIRES POPPED AT ONCE. VERY VIOLENT SHAKING THROUGH OUT THE WHOLE TRUCK! HAD TO PULL OVER TO GET IT TO STOP SHAKING BEFORE I LOST CONTROL AND CRASHED INTO ANOTHER CAR! HAVE SPENT $2000 TRYING TO FIX THIS PROBLEM! A DODGE 2500 2005. *TR

• Seat Belts5

  2 involved a crash

  • Filed Jul 2019

    TAKARA INFLATORS APRIL 28TH 2019 WE TOOK OUR TRUCK TO THE DODGE DEALERSHIP TO HAVE THE RECALLS FIXED AS THEY REQUESTED. MAINLY THE AIRBAGS AND THEY DID A 28 POINT INSPECTION. JULY 1ST 2019 SOMEONE PULLED OUT IN FRONT OF MY HUSBAND AND THEY WERE INVOLVED IN A BAD ACCIDENT. THE AIRBAGS NEVER WENT OFF. MY HUSBAND HIT THE STEERING WHEEL SO HARD THERE'S A BRUISE AND MARK ON HIS CHEST AND THE SHAPE OF THE STEERING WHEEL. IT ALSO MESSED UP THE STEERING COLUMN AND THE GEAR SELECTOR. THE TRUCK IS TOTALED THE FRAME IS BENT THE SUSPENSIONS RIPPED OFF BUT WE CAN'T FIGURE OUT WHY THE AIRBAGS DIDN'T GO OFF. INSURANCE IS BEING A PAIN. DODGE SAID THEY'D SEND OUT AN INVESTIGATOR SO FAR NO ONE SHOWED UP. SOMETHING SHOULD BE DONE ABOUT THIS.

  • Filed Apr 2018

    WHILE DRIVING, MY SEAT BELTS LOCK UP AND WILL NOT ALLOW ANY MOVEMENT - HOLDING THE OCCUPANT TIGHTLY TO THE BACK OF THE SEAT, INDUCING TREMENDOUS ANXIETY. WITH EACH MOVEMENT OF THE OCCUPANT, THE SEATBELT TIGHTENS. SEATBELT MUST BE UNBUCKLED TO RELEAVE PRESSURE.

  • Filed Jan 2014

    MY HUSBAND WAS DRIVING A 2005 DODGE RAM 2500 WHEN THE FRONT LEFT TIRE BLEW. FOR A FEW SECONDS HE WAS ABLE TO KEEP CONTROL OF THE TRUCK BUT THEN IT MADE A SUDDEN JERK TO THE LEFT AND PULLED HIM OFF THE ROAD, HE FOUGHT IT FOR A FEW MORE SECONDS UNTIL IT DID THE SUDDEN JERK THING AGAIN TO THE LEFT AND HE SLAMMED INTO 2 OAK TREES WHERE THE SEAT BELT FAILED AND HE WAS EJECTED FROM THE TRUCK. AFTER IMPACT AND ME RUNNING TO THE TRUCK I NOTICED HE HAD BEEN EJECTED, BEGAN LOOKING FOR HIM THEN THE AIR BAG WENT OFF. THERE WERE SEVERAL THINGS WRONG WITH THIS WHOLE THING AND I AM JUST NOW GETTING A RECALL NOTICE ON THE LEFT TIE ROD BALL STUD.WHAT ABOUT THE SEAT BELT AND AIR BAG DELAY? IF THIS IS WHAT CAUSE THE SUDDEN JERKING TO THE LEFT NOW ALL MY QUESTIONS HAVE BEEN ANSWERED. JUST WISH IT WOULD HAVE BEEN RELEASED SOONER MAYBE I WOULDN'T BE A WIDOW AT THE AGE OF 41! *TR

  • Filed Nov 2006

    DT*: THE CONTACT STATED THE PASSENGER SEAT BELT WOULD NOT ALLOW THE PASSENGER TO LEAN FORWARD. THE VEHICLE WAS TAKEN TO THE SERVICE DEALER, WHO WAS NOT ABLE TO FIND THE CAUSE OF THE PROBLEM. THE CONSUMER STATED THE SEAT BELT HAS BEEN REPAIRED. UPDATED 01/10/07. *JB

  • Filed Dec 2005

    DT: THE CONTACT STATED WHILE TRYING TO INSTALL A CHILD SEAT HE FOUND THE REAR SEAT BELTS WOULD NOT LOCK SECURELY. ALSO, THERE WAS SLACKNESS IN THE SEAT BELTS THAT ALLOWED THE CHILD SEAT TO MOVE. THE DEALERSHIP WAS UNABLE TO DETERMINE WHAT CAUSED THE PROBLEM. *AK

• Latches/Locks/Linkages5

  • Filed Jun 2014

    THE LOCK ON MY DRIVER DOOR IS STUCK IN THE LOCKED POSITION AND WILL NOT UNLOCK WITH THE KEY FOB, OUTER MANUAL LOCK, OR INTERIOR POWER LOCK. CANNOT EVEN PULL UP THE LOCK, CAN ONLY OPEN DOOR BY PULLING INTERIOR DOOR HANDLE. RESEARCHED AND THIS IS A PRETTY COMMON PROBLEM ACROSS ALL DODGE MODELS AROUND MY YEAR MODEL. *TR

  • Filed Feb 2012

    DRIVER DOOR LOCK IS STUCK DOWN IN LOCK POSITION. POWER DOOR LOCKS AND KEY WILL NOT OPEN DOOR. DOOR WILL OPEN FROM INSIDE DOOR LATCH. HAVE BEEN MANY COMPLAINTS ON THIS ISSUE ON THE FORUMS. *TR

  • Filed Feb 2012

    DRIVER DOOR POWER LOCK ACTUATOR FAILED, RESULTING IN DISABLING THE OUTSIDE DOOR HANDLE AND THE ONLY KEY CYLINDER ON THE VEHICLE. AS A RESULT, THE KEYS WERE LOCKED IN THE TRUCK WITH THE MOTOR RUNNING, AND THERE WAS NO WAY TO ENTER THE VEHICLE WITH A SPARE KEY SINCE THERE IS NO LOCK CYLINDER ON THE PASSENGER SIDE DOOR ON THIS TRUCK. NOTE THAT LOCKING THE KEYS IN THE TRUCK WITH THE MOTOR RUNNING WHEN EXPERIENCING THIS FAILURE IS VIRTUALLY INEVITABLE WITH THIS TRUCK, SINCE IT AUTOMATICALLY LOCKS THE DOORS WHEN YOU REACH 10 MPH AND THE OTHER THREE DOORS STAY LOCKED WHEN YOU EXIT FROM THE DRIVER DOOR. I HAD TO CALL AAA TO OPEN THE TRUCK SINCE THERE WAS NO WAY TO GET IN EVEN WITH A SPARE KEY, SINCE THIS FAILURE DISABLES THE ONLY DOOR LOCK ON THE TRUCK. I BELIEVE THIS IS A SAFETY CONCERN SINCE BEING LOCKED OUT OF YOUR RUNNING VEHICLE IN THE WINTER COULD BE A SAFETY HAZARD, ESPECIALLY IF YOU ARE OUT OF CELLPHONE RANGE OR YOUR CELLPHONE IS LOCKED IN THE VEHICLE, AS MINE WAS. *TR

  • Filed Sep 2007

    TL*THE CONTACT OWNS A 2005 DODGE RAM 2500. THE CONTACT STATED THAT THE PASSENGER SIDE DOOR WOULD NOT UNLOCK WHEN USING THE KEY. THE DEALER REPAIRED THE VEHICLE, HOWEVER, THE CONTACT WAS UNSURE OF WHAT THEY REPAIRED. THE CURRENT MILEAGE WAS 18,500 AND FAILURE MILEAGE WAS 18,400.

  • Filed Jun 2006

    I HAVE BEEN LOCKED OUT OF MY 2005 DODGE 2500 TRUCK WITH THE ENGINE RUNNING. THE LOCK ASSEMBLY ON THE TRUCK BECAME NON-OPERATIONAL WITH THE KEY AND DOOR HANDLE. EVEN WITH A SPARE KEY, IT WAS USELESS. I HAD TO CALL MY WIFE TO BRING ME THE EXTRA FOB ( ELECTRONIC DOOR OPENER) TO GET IN THE TRUCK. A CONTRIBUTING FACT WAS THAT THERE WAS NOT A LOCK ON THE PASSENGER HANDLE. MY QUESTION IS WHAT WOULD HAPPEN IF THE VEHICLE WAS A STANDARD MODEL WITHOUT A FOB? THE DEALERSHIP SAID THAT THEY HAVE SEEN THIS HAPPEN SEVERAL TIMES. BY THE WAY, MY DEALER WAS VERY HELPFUL. BUT WHAT ABOUT OTHER INSTANCES OF THIS OCCURRING. *NM

• Hydraulic5

  2 involved a crash

  • Filed Oct 2011

    THE ABS CONTROL UNIT ON MY 2005 DODGE RAM 2500 BROKE. I WAS ALERTED TO THIS BY A BRAKE LIGHT AND AN ABS LIGHT ON THE DASHBOARD. AFTER SHUTTING OFF THE ENGINE, THE MODULE MOTOR CONTINUES TO RUN. THE FOLLOWING PART NUMBERS ARE LISTED ON THE UNIT: P52121408AD TJZBK2824K0241. *TR

  • Filed Feb 2010

    TL*THE CONTACT OWNS A 2005 DODGE RAM 2500. THE CONTACT WAS DRIVING APPROXIMATELY 5 MPH INTO THE DRIVEWAY. THERE WAS PRESSURE APPLIED TO BRAKE PEDAL, FOLLOWED BY A NO POWER RESPONSE WHEN SUDDENLY, THE VEHICLE CRASHED INTO THE RESIDENCE GARAGE. THERE WERE NO PERSONAL INJURIES. THE FAILURES OCCURRED ON TWELVE SEPARATE OCCASIONS WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER ON TWELVE TIMES FOR THE IDENTICAL FAILURES. THE TECHNICIAN WAS ABLE TO LOCATE THE PROBLEM AND A REMEDY. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 1,000.

  • Filed Sep 2007

    TL*THE CONTACT OWNS A 2005 DODGE RAM 2500. WHILE PULLING INTO THE DRIVEWAY AT 5 MPH, THE STEERING WHEEL LOCKED. THE CONTACT APPLIED THE BRAKES AND THE VEHICLE STRUCK THE CONCRETE WALL OF HIS GARAGE. THE VEHICLE WAS TOWED TO THE MECHANIC AND HE STATED THAT THE BRAKES FAILED. THE MECHANIC ALSO STATED THAT THE POWER STEERING SHAFT WAS DAMAGED AND THE BELT WAS WRAPPED AROUND THE FAN. THE CURRENT AND FAILURE MILEAGES WERE 36,693.

  • Filed Sep 2007

    TL*THE CONTACT OWNS A 2005 DODGE RAM 2500 REGCAB 4X4 SWB. WHILE DRIVING 70 MPH, THE CONTACT HEARD A HUMMING NOISE FOLLOWED BY A LOUD EXPLOSION. HE LOOKED IN THE REARVIEW MIRROR AND NOTICED METAL PIECES OF THE TRANSFER CASE COMING FROM UNDER THE VEHICLE. THE CONTACT ATTEMPTED TO APPLY THE BRAKES, HOWEVER, THEY FAILED TO ENGAGE. THE CONTACT COASTED THE VEHICLE INTO THE GRASS AND IT CAME TO A STOP. THE DEALER WAS UNABLE TO DIAGNOSE THE CAUSE OF FAILURE. . THE CURRENT AND FAILURE MILEAGES WERE 58,000. RECEIVED 12/12/07. 4200 UPDATED 12/12/07. *JB

  • Filed Nov 2005

    I PURCHASED A 2005 DODGE RAM 2500 3 MONTHS AGO AND ONLY HAVE 10,000 MILES ON THE TRUCK. ON FRIDAY, NOVEMBER 11, 2005, I RETURNED HOME AND NOTICED THAT MY BRAKE LIGHTS REMAINED AFTER I EXITED THE TRUCK. I TRIED TURNING THE LIGHTS ON AND OFF, AND THEY REMAINED ON. I DECIDED TO DRIVE TO THE MAXWELL CHRYSLER DEALER A FEW BLOCKS AWAY AS I WAS AFRAID MY BATTERY WOULD GO DEAD. AS I WAS PROCEEDING DOWN MY STREET, I NOTICED THE BRAKE INDICATOR LIGHT CAME ON. I WENT TO BRAKE, AND THERE WAS NO BRAKE PEDAL! IT HAD FALLEN OFF. I MADE IT TO THE DEALERSHIP USING MY EMERGENCY BRAKE. THEY SAID THE "CLASP" THAT HOLDS THE PEDAL HAD FALLEN OFF. IT WAS NOT ON THE FLOOR, SO I DON'T KNOW IF IT WAS BROKEN, MISSING, ETC. THEY REPLACED THE CLASP. I WAS HORRIFIED TO THINK THAT I WAS SUPPOSED TO HAVE BEEN ON INTERSTATE I-35 TOWING MY HORSES. PLEASE LOOK INTO THIS ASAP. I WOULD LIKE TO KNOW IF THIS IS AN ISOLATED INCIDENT, OR WHETHER THIS COULD BE A POSSIBLE DEFECT. *JB

• Equipment4

  • Filed Sep 2012

    TL* THE CONTACT OWNS A 2005 DODGE RAM 2500 DIESEL. THE CONTACT STATED THAT THE AIR CONDITIONER FAILED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE A/C SCHRADER VALVE HAD BECOME STICKY AND WAS DEFECTIVE. THE VEHICLE WAS NOT REPAIRED HOWEVER, YEARS LATER THE FAILURE RECURRED. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHO THEN ADVISED THAT THE EVAPORATOR VALVE WAS LEAKING AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 76,498 AND THE CURRENT MILEAGE WAS 76,498. UPDATED 01/09/13*LJ UPDATED 1/11/2013 *JS

  • Filed Aug 2012

    EVERY ONCE IN AWHILE MY 2005 DODGE RAM 2500 FRONT END WILL SHAKE VIOLENTLY AND JUST ABOUT CAUSE ME TO CRASH WHILE DRIVING A VARIOUS SPEEDS. I'VE TAKEN IT BACK TO THE DEALERSHIP AND THEY HAVE REPLACED THE STEERING DAMPENER SEVERAL TIMES YET IT STILL HAS THE PROBLEM. I STARTED RESEARCHING IT ON THE INTERNET AND THERE IS A LOT OF PEOPLE COMPLAINING ABOUT THE SAME EXACT THING. IT IS DESCRIBED AS THE SHAKE OF DEATH OR DEATH WOBBLE. THERE IS NO FACTORY RECALL FOR THIS PROBLEM BUT ARE OPTIONS FOR REPLACING FRONT END PARTS FOR ABOUT $500-800 DOLLARS. SOMEONE SHOULD LOOK INTO THIS AS PEOPLE MAY HAVE DIED BECAUSE OF IT. ESPECIALLY IF IT HAPPENS AT A HIGH RATE OF SPEED. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

  • Filed Apr 2010

    DRAW-TITE GOOSENECK HITCH FOR 2005 DODGE RAM 2500 PICK-UP. THE FRAME MOUNTED U-BOLTS CONNECTING THE HITCH TO THE FRAME SHEARED OFF UNDER LIGHT TO MEDIUM LOAD. *TR

  • Filed Dec 2009

    FRONT LEFT TIRE WORE VERY UNEVENLY W/ 85K MILES. TRUCK VIBRATES AND BOUNCES. REPLACED ALL TIRES. TRUCK STILL VIBRATES WITH NEW TIRES AND SEEMS TO HAVE A SELF PERPETUATED BOUNCE - MOST OFTEN OCCURS AT 45 TO 65 MPH, UNDER LIGHT ACCELERATION, WHILE MAKING A LONG SWOOPING RIGHT CURVE - BUT HAPPENS ELSEWHERE LESS FREQUENTLY. CERTIFIED DODGE SHOP FOLLOWED TSB AND REPLACED ORIGINAL TIE ROD (NO LONGER AVAILABLE BY ITSELF) WITH MULTIPLE ARM DAMPER / TIE/ PITMAN ARM PARTS # 68039930-AA, 52106909-AE, 52122362-AE, 52122370-AB. TRUCK STILL VIBRATES AND BOUNCES - VERY UNSETTLING! YOU DEFINITELY FEEL LIKE YOU DON'T HAVE COMPLETE CONTROL OF THE TRUCK WHILE IT'S BOUNCING. ADD ICE OR SNOW AND ????ALSO NEW DAMPER PARTS NOW SQUEAK WHEN BODY LEANS - LIKE WHEN I TAKE A HARD RIGHT AT LOW SPEEDS IN A PARKING LOT. RETURNED TO SHOP. THEY SUGGESTED I CHANGE DIFFERENTIAL FLUID (NEVER DONE TO DATE), SO WE DID. MADE VIBRATIONS A LITTLE LESS NOTICEABLE, (STEERING WHEEL AND SHIFT LEVER DON'T DANCE AS MUCH) BUT DID NOT FIX THE PROBLEM. SHOP SAID DODGE IS WORKING ON SOME OTHER KIND OF FIX (TSB) THAT MAY PERTAIN TO MY PROBLEM, BUT THEY DON'T KNOW YET BECAUSE IT HASN'T BEEN RELEASED. SOMETHING ABOUT A SLEEVE THAT GOES OVER SOME EXISTING PART. I CONTACTED DODGE DIRECTLY TO SEE IF I COULD FIND OUT MORE INFORMATION ABOUT WHAT THE PROBLEM AND WHAT THEY ARE WORKING ON TO FIX IT. THEY WOULDN'T TELL ME ANYTHING EXCEPT TO MAYBE TRY ANOTHER AUTHORIZED DODGE SHOP IF I WASN'T HAPPY WITH THE WORK THEY DID. THIS IS '!@#$%'.! YOU KNOW DODGE KNOWS SOMETHING. DIDN'T WE LEARN ANYTHING FROM THE FORD PINTO? ATLEAST TELL PEOPLE THAT YOU ARE WORKING ON SOMETHING SO WE DON'T WASTE OUR HARD EARNED MONEY ON POINTLESS REPAIRS THAT WON'T FIX THE PROBLEM. MY TRUCK IS A 05' DODGE 2500 CREW CAB 5 SPD MANUAL. PROBLEM STARTED AROUND 80K MILES - TRUCK NOW HAS 97K MILES. *TR

• Fuel/Propulsion System3

  • Filed Jul 2018

    WHILE DRIVING DOWN HIGHWAY GASOLINE STARTED SPEWING UNDER PRESSURE FROM TOP OF FUEL PUMP, PULLED INTO PARKING LOT AWAY FROM OTHER VEHICLES AND WAITED FIVE TO TEN MINUTES BEFORE GASOLINE STOPPED SPRAYING OUT. I HAD TO HAVE IT TOWED HOME WHERE I COULD CHECK TO FIND OUT IF IT WAS ONLY A RUBBER HOSE AS I EXPECTED OR SOMETHING ELSE. I FOUND OUT IT WAS A FITTING AT TOP OF THE FUEL PUMP WHICH LOOKS LIKE METAL CONNECTOR WHERE THE GASOLINE WAS SPRAYING OUT OF A PIN HOLE, I LOST ABOUT 5 GALLONS OF GAS IN 14 MILES OF HIGHWAY DRIVING.

  • Filed Mar 2017

    TL* THE CONTACT OWNS A 2005 DODGE RAM 2500. WHILE DRIVING APPROXIMATELY 80 MPH, THE VEHICLE VIBRATED ABNORMALLY. WITHIN SECONDS, A LOUD NOISE WAS HEARD UNDER THE VEHICLE. THE DRIVER WAS ABLE TO COAST ONTO THE ROAD SHOULDER AND FOUND UNKNOWN PARTS HAD SEPARATED FROM THE VEHICLE WHILE DRIVING. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE TRANSFER CASE, CONSTANT VELOCITY JOINT, UNIVERSAL JOINT, FUEL LINES, AND BRAKES LINES FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 270,000.

  • Filed Aug 2015

    TURN SIGNAL WHEN SWITCHED ACTIVATES THE OPPOSITE TURNING LIGHT. REAR TAIL TIGHT HOUSINGS ARE NOT WATER TIGHT AND BLOWS BULBS AFTER RAINING. WINDSHIELD WIPERS ACT ON THEIR OWN WHEN ITS RAINING AND NOW DOME AND CONSOLE LIGHTS DONT WORK. NO BLOWN FUSES. THE THIRD FUEL PUMP LINE IS ALSO DEFECTIVE. WILL EVENTUALLY BREAK FROM VIBRATION. NEW ONES HAVE BETTER VIBRATION HOUSING AND DEALERSHIP HAD STOCK. (125 OF THESE AND NONE OTHER BECAUSE EVERYONE WAS HAVING THE SAME ONE BREAK). KEY FALLS OUT OF IGNITION AND REAR PASSENGER SIDE DOOR DOES NOT LOCK OR UNLOCK WHEN BUTTON IS PUSHED. AIR BAGS WERE RECENTLY RECALLED BUT THEY DON'T HAVE ENOUGH PART TO GET IT FIXED. I MUST WAIT. VERY UNSAFE VEHICLE TO BE AN OWNER OF.

• Electronic Stability Control (esc)2

  • Filed Nov 2014

    I HAD TAKEN MY TRUCK TO GET IT SERVICED BECAUSE THE STEERING FELT OFF AND WHEN I WOULD GO TO STOP IT SOUNDED LIKE METAL SHAKING. WHEN I GOT TO THE DEALERSHIP THEY SAID THE LEFT TIE ROD WAS CRACKED AND THE STEERING LINKAGE WAS JUST HANGING THERE ABOUT TO FALL OFF. THERE HAD BEEN A RECALL ON IT BEFORE I HAD PURCHASED THE TRUCK SO I CALLED CHRYSLER GROUP AND THEY INFORMED ME THAT IT WAS DEEMED THAT THE TRUCK DIDN'T HAVE THE "SPECIFIC RECALLED" PART. SO I HAD TO PAY OUT OF POCKET AROUND $3,000 TO FIX A PROBLEM THAT THERE WAS A RECALL ON. THE EXACT SAME PROBLEM LISTED IN THE RECALL, "BECAUSE THE LEFT TIE ROD BALL STUD MAY FRACTURE." IS EXACTLY WHAT HAPPENED TO MINE. I WAS TOLD BY CHRYSLER GROUP THAT SINCE MY TRUCK HAD BEEN CHECKED FOR THE SPECIFIC PART BY THE PREVIOUS OWNER AND IT WASN'T PART OF THE RECALL THEY WOULDN'T COVER IT. THEY DID SAY TO KEEP ALL MY RECIEPTS IN CASE THERE IS A FUTURE RECALL ON THAT SPECIFIC PART. *TR

  • Filed Oct 2014

    ON PA 81 HIT A BUMP IN THE ROAD AT 65 MPH. THOUGHT I HAD A FLAT TIRE BUT WAS NOT THE CASE. AFTER LOOKING ON THE WEB "YOU TUBE" AND ASKING PEOPLE I FOUND THAT I HAD A DEATH WOBBLE. THIS WAS VERY SCARY AND THE KIDS IN THE BACK THOUGH WE WERE GOING TO CRASH AS DID I. THIS DEATH WOBBLE SHOULD BE LOOKED AT AND FIXED BEFORE SOMEONE GETS INTO A CRASH. *TR

• Other2

  • Filed Jun 2010

    WHILE DRIVING HOME FROM WORK FRIDAY THE #4 FUEL TUBE THAT COMES FROM THE FUEL BAR AND GOES INTO THE INJECTORS STARTED LEAKING CAUSING DIESEL TO LEAK OVER MY ENTIRE MOTOR AND UNDERCARRIAGE OF VEHICLE. I DROVE THE VEHICLE ABOUT 20 MILES AS I DID NOT KNOW THERE WAS A LEAK. I COULD SEE SMOKE COMING FROM WHAT I THOUGHT WAS MY EXHAUST BEHIND THE TRUCK BUT THEN NOTICED MY FUEL GAGE STARTED GOING DOWN QUICKLY AND WHEN I MADE IT HOME SMOKE STARTED COMING FROM UNDER HOOD. AN EXTREME AMOUNT OF SMOKE. ABOUT 10 GALLONS OF DIESEL WAS LEAKED OUT. THIS COULD HAVE IGNITED AND / OR EXPLODED CAUSING SERIOUS INJURY OR DEATH TO MYSELF AND SURROUNDING VEHICLES / HOMES. I WAS ABLE TO FIND THE LEAK AND PURCHASED REPLACEMENT PART FROM MY LOCAL DODGE DEALERSHIP. THE PARTS DEPARTMENT TOLD ME THE #4 TUBE, WHICH IS THE ONE I REPLACED, WAS VERY COMMON TO LEAK. IF THIS IS VERY COMMON...SOMETHING SHOULD BE DONE. IF ONE TUBE IS COMMON TO LEAK ALL OTHERS ARE QUESTIONABLE AS WELL. THE PART COST ME $52.60 PLUS LABOR TO CHANGE. *TR

  • Filed Dec 2005

    THE CONSUMER EXPERIENCED SUDDEN ACCELERATION IN HIS 2005 DODGE RAM 2500 QUAD CAB. *NM THE CONSUMER ALSO STATED THE VEHICLE WAS BECOMING DIFFICULT TO START, SO HE REPLACED THE FUEL FILTER. THE CONSUMER DROPPED THE VEHICLE OFF AT THE DEALER. THE DEALER INFORMED THE CONSUMER, THEY COULD NOT GET THE VEHICLE STARTED, BECAUSE THE FUEL WAS CONTAMINATED WITH A FLUID THAT WAS REAL DARK. THE CONSUMER HAD THE VEHICLE TOWED TO ANOTHER SHOP WHERE HE WAS THEN TOLD THERE WAS A LOT OF RUST IN BOTH MANIFOLDS AND THE HEAD, BUT THE FUEL LOOKED FINE. THE MECHANIC RECOMMENDED THE INJECTORS BE REPLACED. SINCE THE REPLACEMENT OF THE INJECTORS THE VEHICLE IS NOW DRIVABLE. *JB

• Seats2

  • Filed Sep 2009

    TL*THE CONTACT OWNS A 2005 DODGE RAM 2500 DIESEL. THE CONTACT STATED THAT THE DRIVER SIDE FRONT SEAT MOVED FORWARD DURING DECELERATION. INSTABILITY WHILE DRIVING INCREASED THE RISK OF A VEHICLE CRASH. AS OF CURRENT DATE THE VEHICLE HAS NOT BEEN REPAIRED. HE TOOK THE VEHICLE TO THE DEALER AND A TECHNICIAN STATED THAT HE NEEDED TO REPLACE THE SEAT TRACKER AT APPROXIMATELY $500.00. THE COMPONENT HAS NOT BEEN REPLACED. THE FAILURE MILEAGE WAS 50,000 AND THE CURRENT MILEAGE WAS 60,000.

  • Filed Oct 2006

    THE DRIVER SEAT MECHANISM FAILED DURING MILD ACCELERATION, CAUSING THE DRIVER TO BE THROWN BACKWARDS. THE SEAT TILT MECHANISM HAS A PLASTIC AND METAL GEARBOX THAT BROKE CAUSING THE SEAT TO SWING FORWARD UNDER BRAKING AND BACKWARD UNDER ACCELERATION. THIS CAUSES CONTROL PROBLEMS AS THE MOVEMENT IS ABOUT 1 FOOT. THE DEALER WAS PRESSURED TO REPLACE THE FAILED PART AND CLAIMS THIS IS THE FIRST TIME IT HAS EVER OCCURRED. THE TRUCK WAS 15 MONTHS OLD AT THE TIME OF FAILURE WITH 56,000 MILES ON THE ODOMETER. THE PART HAS NOT BEEN IMPROVED, SO I AM LOOKING AT REPLACING THIS MECHANISM EVERY 15 MONTHS! THIS SEAT TILT MECHANISM ON THE POWER SEAT IS NOT DESIGNED PROPERLY. *NM

• Child Seat1

  • Filed Jun 2022

    The contact owns a Britax car seat, Model Name: Advocate ClickTight, Manufacture Date: August 26, 2016, installed in a 2005 Dodge Ram 2500. The contact stated that a crack on the right side of the headrest had formed without incident. The manufacturer had yet to be notified of the failure. The car seat had yet to be repaired or replaced. The purchase date of was August 2017.

• Trailer Hitches1

  • Filed Apr 2010

    DRAW-TITE GOOSENECK HITCH FOR 2005 DODGE RAM 2500 PICK-UP. THE FRAME MOUNTED U-BOLTS CONNECTING THE HITCH TO THE FRAME SHEARED OFF UNDER LIGHT TO MEDIUM LOAD. *TR

• Tires1

  • Filed Apr 2009

    TL*THE CONTACT OWNS A 2005 DODGE RAM 2500. THE CONTACT PURCHASED FOUR NEW NITTO TERRA GRAPPLER AT (NA) TIRES, SIZE 285/70R17 FOR HIS VEHICLE, BUT STATED THAT THEY FLEX TOO MUCH. WHENEVER HE TURNS THE VEHICLE, HE FEELS AS IF THE TIRES ARE FALLING OFF. WHEN CHANGING LANES, THE VEHICLE IS DIFFICULT TO CONTROL AND BEGINS TO SWERVE. THE MANUFACTURER ADVISED HIM TO FILE A WARRANTY CLAIM WITH ONE OF THE DEALERS. THE MANUFACTURER THEN CALLED THE DEALER BACK AND STATED THAT THERE WAS NOTHING WRONG WITH THE TIRES; THEREFORE, THEY WOULD NOT PROVIDE COMPENSATION. THE DOT NUMBER WAS UNKNOWN. THE FAILURE MILEAGE WAS 56,000.

Safety ratings

NHTSA 5-Star Safety Ratings from government crash tests. Ratings can differ by cab style and 2WD/4WD.

NHTSA hasn't published star ratings for this truck. Many heavy-duty pickups aren't included in NHTSA's crash-test program, so this doesn't mean the truck is unsafe.