2022 Ford Maverick
Recalls and owner complaints reported to NHTSA
Price & value
We don't guess at prices. Get a real value for the exact truck from Kelley Blue Book, then see how the asking price compares.
Is it a good deal?
- Look up the truck on Kelley Blue Book. Choose its cab, trim, options, miles, condition and your ZIP code, and note the private party value (or the fair purchase price if you're buying from a dealer).
- Enter that value and the asking price below.
Enter both numbers to see the deal rating.
The rating only compares the two numbers you enter: within 5% of the value is a good deal, 5–15% under is a great deal, and more than 15% under is a buy-it-now price. Know Your Truck isn't affiliated with Kelley Blue Book. Rust, accident history, lifts and mods, and service records all change what a truck is worth, so always get a pre-purchase inspection.
Owner's manual
Get the free official owner's manual from Ford's owner manual library. Choose 2022 Maverick. It covers maintenance schedules, fluids, towing limits and warning lights. Older years may not be listed online.
Recalls
A recall doesn't mean a truck still has the problem. Enter the truck's VIN at nhtsa.gov/recalls or ask a dealer to see whether the repair was done.
Suspension:Front:Control Arm:Lower Ball Joint
May 2026 · #26V340000NHTSA warning: do not drive until this recall is fixed.
Ford Motor Company (Ford) is recalling certain 2021-2026 Bronco Sport and 2022-2026 Maverick vehicles.
Read more: details, risk and fix
Ford Motor Company (Ford) is recalling certain 2021-2026 Bronco Sport and 2022-2026 Maverick vehicles. The front lower control arm ball joints may have been incorrectly installed or incorrectly repaired at the vehicle assembly plant, allowing the control arm to disconnect from the front wheel knuckle.
Risk: A detached control arm can cause a loss of vehicle control, increasing the risk of a crash.
Fix: Owners are advised not to drive their vehicles until the remedy is completed. Dealers will inspect and repair the front lower control arm ball joints as necessary, free of charge.Owner notification letters were mailed September 2, 2026. Owners may contact Ford customer service at [phone removed]. Ford's number for this recall is 26S36. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on May 29, 2026.
Electrical System: Integrated Trailer Brake Control
Feb 2026 · #26V104000Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles.
Read more: details, risk and fix
Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
Risk: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.
Fix: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at [phone removed]. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.
Equipment:Electrical:Engine Block Heater
Oct 2025 · #25V685000Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles.
Read more: details, risk and fix
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
Risk: An electrical short circuit can increase the risk of a fire.
Fix: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at [phone removed]. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
Back Over Prevention:Software
Jun 2025 · #25V442000Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles.
Read more: details, risk and fix
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
Risk: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Fix: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at [phone removed]. Ford's number for this recall is 25S72.
Engine
May 2025 · #25V345000Ford Motor Company (Ford) is recalling certain 2020-2023 Escape, 2021-2023 Corsair, and 2022-2023 Maverick vehicles equipped with 2.5L HEV or PHEV engines that were repaired incorrectly under recall 23V380.
Read more: details, risk and fix
Ford Motor Company (Ford) is recalling certain 2020-2023 Escape, 2021-2023 Corsair, and 2022-2023 Maverick vehicles equipped with 2.5L HEV or PHEV engines that were repaired incorrectly under recall 23V380. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.
Risk: An engine compartment fire increases the risk of injury.
Fix: Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will update the powertrain control module software, free of charge. Owner notification letters were mailed June 27, 2025. Owners may contact Ford customer service at [phone removed]. Ford's number for this recall is 25S54.
Power Train:Automatic Transmission:Control Module (tcm/Pcm/Tecm)
Mar 2025 · #25V158000Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles previously repaired incorrectly under recall number 24V-267.
Read more: details, risk and fix
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles previously repaired incorrectly under recall number 24V-267. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.
Risk: An undetected low battery charge can result in a loss of electrical accessories such as hazard lights, or cause a loss of drive power, increasing the risk of a crash.
Fix: Dealers will recalibrate the body control module and power train control module, free of charge. Owner notification letters were mailed April 23, 2025. Owners may contact Ford customer service at [phone removed]. Ford's number for this recall is 25S26.
Electrical System: Instrument Cluster/Panel
Feb 2025 · #25V123000Ford Motor Company (Ford) is recalling certain 2022-2023 Maverick Hybrid vehicles previously repaired incorrectly under recall number 24V-140.
Read more: details, risk and fix
Ford Motor Company (Ford) is recalling certain 2022-2023 Maverick Hybrid vehicles previously repaired incorrectly under recall number 24V-140. The instrument panel cluster may not properly illuminate warning lights or gauges. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 101, "Control and Displays," and 102, "Transmission shift position sequence, starter interlock, and transmission braking effect" as well as FMVSS numbers 105, 108, and 208.
Risk: An instrument panel that does not illuminate critical safety information, such as the speedometer or warning lights, can increase the risk of a crash.
Fix: Dealers will update the instrument panel cluster software, free of charge. Owner notification letters were mailed April 9, 2025. Owners may contact Ford customer service at [phone removed]. Ford's number for this recall is 25C06.
Service Brakes, Hydraulic:Antilock/Traction Control/Electronic Limited Slip:Control Unit/Module
Feb 2025 · #25V124000Ford Motor Company (Ford) is recalling certain 2022 Maverick vehicles previously repaired incorrectly under recall number 24V-730.
Read more: details, risk and fix
Ford Motor Company (Ford) is recalling certain 2022 Maverick vehicles previously repaired incorrectly under recall number 24V-730. Under certain circumstances, the Antilock Brake System (ABS) module may cause the brake lights to illuminate without the driver applying the brakes. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Risk: Unintended illumination of the brake lights may confuse other drivers, increasing the risk of a crash.
Fix: Dealers will update the software in the ABS module, free of charge. Owner notification letters were mailed April 14, 2025. Owners may contact Ford customer service at [phone removed]. Ford's number for this recall is 25C07.
Power Train:Automatic Transmission:Control Module (tcm/Pcm/Tecm)
Feb 2025 · #25V127000Ford Motor Company (Ford) is recalling certain 2022 Maverick vehicles previously repaired incorrectly under recall number 24V-590.
Read more: details, risk and fix
Ford Motor Company (Ford) is recalling certain 2022 Maverick vehicles previously repaired incorrectly under recall number 24V-590. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.
Risk: An undetected low battery charge can result in a loss of electrical accessories such as hazard lights, or cause a loss of drive power, increasing the risk of a crash.
Fix: Dealers will update the power train control module software, free of charge. Owner notification letters were mailed April 11, 2025. Owners may contact Ford customer service at [phone removed]. Ford's number for this recall is 25S13.
Electrical System: Integrated Trailer Brake Control
Feb 2025 · #25V132000Ford Motor Company (Ford) is recalling certain 2021-2022 F-150, 2022 Maverick, Expedition, Lincoln Navigator, F-250, F-350, F-450, and F-550 vehicles previously repaired incorrectly under recall number 22V-193.
Read more: details, risk and fix
Ford Motor Company (Ford) is recalling certain 2021-2022 F-150, 2022 Maverick, Expedition, Lincoln Navigator, F-250, F-350, F-450, and F-550 vehicles previously repaired incorrectly under recall number 22V-193. Due to a software error, a towed trailer equipped with an electric or electric-over hydraulic brake system may not brake.
Risk: Loss of trailer brake functionality can extend the distance required to stop, increasing the risk of a crash.
Fix: Dealers will update the integrated trailer brake control module software, free of charge. Owner notification letters were mailed April 11, 2025. Owners may contact Ford customer service at [phone removed]. Ford's number for this recall is 25S18.
Power Train:Automatic Transmission:Control Module (tcm/Pcm/Tecm)
Feb 2025 · #25V133000Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick, 2022 Escape, and 2021-2022 Lincoln Corsair vehicles previously repaired incorrectly under recall number 24V-330.
Read more: details, risk and fix
Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick, 2022 Escape, and 2021-2022 Lincoln Corsair vehicles previously repaired incorrectly under recall number 24V-330. The Hybrid Powertrain Control Module (HPCM) software may cause the vehicle to shift into neutral unexpectedly, causing a loss of drive power.
Risk: A loss of drive power increases the risk of a crash.
Fix: Dealers will update the HPCM software, free of charge. Owner notification letters were mailed April 11, 2025. Owners may contact Ford customer service at [phone removed]. Ford's number for this recall is 25S16.
Exterior Lighting:Turn Signal
Feb 2025 · #25V094000Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick vehicles previously repaired incorrectly under recall number 23V-848.
Read more: details, risk and fix
Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick vehicles previously repaired incorrectly under recall number 23V-848. In the event that one of the rear turn signals stops working, the vehicle will not adjust the turn signal flash rate frequency to warn the driver that a turn signal has failed. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Risk: A nonfunctioning exterior turn signal cannot notify other drivers that the vehicle is turning, increasing the risk of a crash.
Fix: Dealers will update the body control module software, free of charge. Owner notification letters were mailed March 27, 2025. Owners may contact Ford customer service at [phone removed]. Ford's number for this recall is 25C04.
Exterior Lighting:Tail Lights
Feb 2025 · #25V095000Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick vehicles previously repaired incorrectly under recall number 24V-293.
Read more: details, risk and fix
Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick vehicles previously repaired incorrectly under recall number 24V-293. The body control module (BCM) may inadvertently deactivate one or both rear tail lights.
Risk: Rear tail lights that fail to illuminate can reduce the vehicle's visibility to other drivers, increasing the risk of a crash.
Fix: Dealers will update the body control module software, free of charge. Owner notification letters were mailed March 28, 2025. Owners may contact Ford customer service at [phone removed]. Ford's number for this recall is 25S07.
Electrical System:12v/24v/48v Battery
Jan 2025 · #25V019000Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco Sport and 2022-2023 Maverick vehicles.
Read more: details, risk and fix
Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco Sport and 2022-2023 Maverick vehicles. The 12-volt battery may experience degradation and suddenly fail.
Risk: Battery failure can result in a loss of electrical accessories, including the hazard lights, or cause a loss of drive power, increasing the risk of a crash.
Fix: Dealers will inspect and if necessary, replace the 12-volt battery, free of charge. Owner notification letters were mailed May 2, 2025. Owners may contact Ford customer service at [phone removed]. Ford's number for this recall is 25S02. Vehicles in this recall were previously repaired under 24V-267 and will need to have the new remedy completed.
Back Over Prevention:Software
Sep 2024 · #24V684000Ford Motor Company (Ford) is recalling certain 2022-2024 Ford Maverick vehicles equipped with Connected Touch Radios (CTR).
Read more: details, risk and fix
Ford Motor Company (Ford) is recalling certain 2022-2024 Ford Maverick vehicles equipped with Connected Touch Radios (CTR). The rearview camera image may freeze when the vehicle is in reverse.
Risk: An inoperative rearview camera display can reduce the driver's rear visibility, increasing the risk of a crash.
Fix: Dealers will update the Connected Touch Radio (CTR) software, free of charge. Owner notification letters were mailed on March 21, 2025. Owners may contact Ford customer service at [phone removed]. Ford's number for this recall is 24S59.
Electrical System:Body Control Module/Bcm
Aug 2024 · #24V590000Ford Motor Company (Ford) is recalling certain 2022 Maverick vehicles previously repaired under recall number 24V-267.
Read more: details, risk and fix
Ford Motor Company (Ford) is recalling certain 2022 Maverick vehicles previously repaired under recall number 24V-267. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.
Risk: An undetected low battery charge can result in a loss of electrical accessories such as hazard lights, or cause a loss of drive power, increasing the risk of a crash.
Fix: Dealers will recalibrate the body control module and power train control module, free of charge. Owner notification letters were mailed August 26, 2024. Owners may contact Ford customer service at [phone removed]. Ford's number for this recall is 24S50.
Power Train:Automatic Transmission:Control Module (tcm/Pcm/Tecm)
May 2024 · #24V330000Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick, 2020-2022 Escape, and 2021-2022 Lincoln Corsair vehicles.
Read more: details, risk and fix
Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick, 2020-2022 Escape, and 2021-2022 Lincoln Corsair vehicles. The Hybrid Powertrain Control Module (HPCM) software may cause the vehicle to shift into neutral unexpectedly, causing a loss of drive power.
Risk: A loss of drive power increases the risk of a crash.
Fix: Dealers will update the HPCM software, free of charge. Owner notification letters were mailed May 22, 2024. Owners may contact Ford customer service at [phone removed]. Ford's number for this recall is 24S33.
Exterior Lighting:Tail Lights
Apr 2024 · #24V293000Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick vehicles.
Read more: details, risk and fix
Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick vehicles. The Body Control Module (BCM) may inadvertently deactivate one or both rear tail lights.
Risk: Rear tail lights that fail to illuminate can reduce the vehicle's visibility to other drivers, increasing the risk of a crash.
Fix: Dealers will update the BCM software, free of charge. Owner notification letters were mailed May 10, 2024. Owners may contact Ford customer service at [phone removed]. Ford's number for this recall is 24S24.
Electrical System:Body Control Module/Bcm
Apr 2024 · #24V267000Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles.
Read more: details, risk and fix
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.
Risk: An undetected low battery charge can result in a loss of electrical accessories such as hazard lights, or cause a loss of drive power, increasing the risk of a crash.
Fix: Dealers will recalibrate the body control module and power train control module, free of charge. Owner notification letters were mailed on June 4, 2024. Owners may contact Ford customer service at [phone removed]. Ford's number for this recall is 24S24.
Electrical System: Instrument Cluster/Panel
Feb 2024 · #24V140000Ford Motor Company (Ford) is recalling certain 2022-2023 Maverick Hybrid vehicles.
Read more: details, risk and fix
Ford Motor Company (Ford) is recalling certain 2022-2023 Maverick Hybrid vehicles. The Instrument Panel Cluster may not properly illuminate warning lights or gauges. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 101, "Control and Displays," and 102, "Transmission shift position sequence, starter interlock, and transmission braking effect" as well as FMVSS numbers 105, 108, and 208.
Risk: An instrument panel that does not illuminate critical safety information, such as the speedometer or warning lights, can increase the risk of a crash.
Fix: Dealers will update the instrument panel cluster software, free of charge. Owner notification letters were mailed March 26, 2024. Owners may contact Ford customer service at [phone removed]. Ford's number for this recall is 24C01.
Exterior Lighting:Turn Signal:Bulbs
Dec 2023 · #23V848000Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick vehicles.
Read more: details, risk and fix
Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick vehicles. In the event that one of the rear turn signals stops working, the vehicle will not adjust the turn signal flash rate frequency to warn the driver that a turn signal is not working correctly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Risk: A nonfunctioning exterior turn signal will not notify other drivers that the vehicle is turning, increasing the risk of a crash.
Fix: Dealers will update the body control module software, free of charge. Owner notification letters were mailed January 16, 2024. Owners may contact Ford customer service at [phone removed]. Ford's number for this recall is 23C41.
Engine
May 2023 · #23V380000Ford Motor Company (Ford) is recalling certain 2020-2023 Escape, 2022-2023 Maverick, and 2021-2023 Corsair vehicles equipped with 2.5L HEV or PHEV engines.
Read more: details, risk and fix
Ford Motor Company (Ford) is recalling certain 2020-2023 Escape, 2022-2023 Maverick, and 2021-2023 Corsair vehicles equipped with 2.5L HEV or PHEV engines. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.
Risk: An engine compartment fire increases the risk of injury.
Fix: Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will replace the engine long-block in 2023 Escape and Corsair vehicles. For the other vehicles, dealers will update the powertrain control module software. If a connecting rod bearing failure is detected, dealers will replace the engine long-block. All inspections and repairs will be performed free of charge. Owner notification letters were mailed on June 14, 2024. Owners may contact Ford customer service at [phone removed]. Ford's number for this recall is 23S27. This recall expands and replaces recall number 22V-484. Vehicles previously repaired under 22V-484 will need to have the new remedy completed.
Exterior Lighting:Brake Lights
Sep 2022 · #22V730000Ford Motor Company (Ford) is recalling certain 2022 Maverick vehicles.
Read more: details, risk and fix
Ford Motor Company (Ford) is recalling certain 2022 Maverick vehicles. Under certain circumstances, the Antilock Brake System (ABS) module may cause the brake lights to illuminate without the driver applying the brakes. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Risk: Unintended illumination of the brake lights may confuse other drivers, increasing the risk of a crash.
Fix: Dealers will update the software in the ABS module, free of charge. Owner notification letters were mailed November 9, 2022. Owners may contact Ford customer service at [phone removed]. Ford's number for this recall is 22C24.
Air Bags:Side/Window:Curtain
Aug 2022 · #22V594000Ford Motor Company (Ford) is recalling certain 2022 Maverick vehicles.
Read more: details, risk and fix
Ford Motor Company (Ford) is recalling certain 2022 Maverick vehicles. The side-curtain air bags may not deploy properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 226, "Ejection Mitigation."
Risk: Improper deployment of an air bag increases the risk of injury in a crash.
Fix: Dealers will replace the left and right side-curtain air bag modules with a new design, free of charge. Owner notification letters were mailed January 30, 2023. Owners may contact Ford customer service at [phone removed]. Ford's number for this recall is 22C20.
Engine And Engine Cooling
Jul 2022 · #22V484000Ford Motor Company (Ford) is recalling certain 2020-2022 Escape, 2021-2022 Lincoln Corsair, and 2022 Maverick vehicles equipped with 2.5L HEV or PHEV engines.
Read more: details, risk and fix
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape, 2021-2022 Lincoln Corsair, and 2022 Maverick vehicles equipped with 2.5L HEV or PHEV engines. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.
Risk: An engine compartment fire increases the risk of injury.
Fix: Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will modify the under engine shield and active grille shutter, free of charge. Owner notification letters were mailed August 19, 2022. Owners may contact Ford customer service at [phone removed]. Ford's number for this recall is 22S47.
Electrical System: Integrated Trailer Brake Control
Mar 2022 · #22V193000Ford Motor Company (Ford) is recalling certain 2021-2022 F-150, 2022 Maverick, Expedition, Lincoln Navigator, F-250, F-350, F-450, and F-550 vehicles.
Read more: details, risk and fix
Ford Motor Company (Ford) is recalling certain 2021-2022 F-150, 2022 Maverick, Expedition, Lincoln Navigator, F-250, F-350, F-450, and F-550 vehicles. Due to a software error, a towed trailer equipped with an electric or electric-over hydraulic brake system may not brake.
Risk: Loss of trailer brake functionality could result in extended stopping distance, increasing the risk of a crash.
Fix: Dealers will update the integrated trailer brake control module software, free of charge. Owner notification letters were mailed April 22, 2022. Owners may contact Ford customer service at [phone removed]. Ford's number for this recall is 22S17.
Seat Belts:Rear/Other:Anchorage
Dec 2021 · #21V979000Ford Motor Company (Ford) is recalling certain 2021-2022 Mustang Mach-E and 2022 Maverick vehicles.
Read more: details, risk and fix
Ford Motor Company (Ford) is recalling certain 2021-2022 Mustang Mach-E and 2022 Maverick vehicles. The rear seat belt buckles may not be properly attached to the rear floor assembly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 208, "Occupant Crash Protection," and 210, "Seat Belt Assembly Anchorages."
Risk: Improperly attached seat belts may not adequately restrain an occupant in a crash, increasing the risk of injury.
Fix: Dealers will repair the rear seat belt buckle attachments, free of charge. Owner notification letters were mailed January 28, 2022. Owners may contact Ford customer service at [phone removed]. Ford's number for this recall is 21C36.
Fuel System, Gasoline:Storage
Dec 2021 · #21V976000Ford Motor Company (Ford) is recalling certain 2022 Maverick vehicles.
Read more: details, risk and fix
Ford Motor Company (Ford) is recalling certain 2022 Maverick vehicles. The fuel tank may have been damaged by drill holes during the installation of the spray-in bed-liner. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 301, "Fuel System Integrity."
Risk: A damaged fuel tank may result in a fuel leak, increasing the risk of a fire.
Fix: Dealers will inspect and replace the fuel tank as necessary, free of charge. Interim owner notification letters were mailed on January 28, 2022. Owner notification letters were mailed on March 15, 2022. Owners may contact Ford customer service at [phone removed]. Ford's number for this recall is 21C35.
Owner complaints by area
Reports owners filed with NHTSA. They aren't verified, and one complaint can mention more than one area. Tap an area to read the most recent ones.
- Electrical System2002 involved a crash · 2 involved a fire
- Filed Sep 2026 · Also filed under Power Train
The contact owns a 2022 Ford Maverick. The contact stated that while driving 40 MPH, the engine light turned on and off and then several unknown warning lights illuminated and the vehicle abruptly decelerated. The driver pulled over, and the vehicle was restarted. The vehicle was then driven 20 MPH. The vehicle was taken to the local dealer, and it was determined the failure was caused by the calipers and a software update. The dealer informed the contact that the VIN was not under recall. The manufacturer was contacted. The failure mileage was approximately 122,000.
- Filed Sep 2026
the factory installed lead acid battery is not sufficient to support the electrical hybrid system. my vehicle died and went into deep sleep mode after 1 week of ownership ( i am the original owner). I was stranded in another state and had to call Ford roadside assistance to come jump start the battery. after approximately 4 months of consistent deep sleep mode issues ( i had since carried a jump box with me to avoid being stranded after first incident) i brought veicle to the Ford dealership and their fix was to replace the factory installed battery, which was reading low voltage, with the same new motorcraft battery. the issues continued after new battery install and after several attempts with different Ford dealerships for a permanent fix, i referenced recall 25s02, i was told my vehicles vin did not fall within the recall even though my vehicle exhibited the same problem. the recall 25s02 called for the dealer to replace the factory lead acid battery with an AGM battery and perform a battery relearn. i was unable to get any Ford dealer to perform the recall on my vehicle and was forced to purchase an AGM battery and install same myself and perform a battery relearn. since installing said AGM battery I have not any deep sleep issues with the vehicle or any incidents where the vehicle needed to be jump started. I feel that my vehicle should have fallen under this recall as it exhibited the same problems as mentioned above and fixing it myself with the recalls solution (replacing lead acid with AGM battery) has fixed said issue.
- Filed Sep 2026
While driving, the dashboard very quickly flashed the words "Charging System Service Soon" so fast I almost couldn't read it. Normally messages remain on the screen until I acknowledge them, but this was not the case. This happened at least 3 times within 30 minutes. When I got home, I parked and turned off the car. When I needed to turn the car back on shortly after, the vehicle would not turn on. I was able to get it jump started and immediately drove it to the Ford Service Center. The tech notes indicated: "Found SSM for concern. Required some module updates. During update, the PCM bricked due to low power. Through nearly 7 hours of testing, found the soldered connection of the main battery cable from battery to battery junction box is no longer connected and has caused a short circuit through the whole harness. There was a recall that expired in 2024 that was for this exact concern. (22B39) Recommendation is to replace full wiring harness and verify all modules are programmed properly. Pending customer approval.”" This is a safety concern in the sense that the disconnected battery cable could have led to the vehicle losing power while driving. Losing the ability to control the vehicle in this manner is a serious danger to me and other drivers, and I am grateful I was not driving when it lost power due to the disconnection.
- Filed Aug 2026 · Also filed under Unknown or Other, Engine
The Ford Maverick is subject to rodent invasions which caused an engine fire. We had to file a State Farm Insurance Claim ($4016.36 of repairs done to repair the engine including electrical, emission system, cowl, fuel system, and insulation.) This was completed XXX. We have been faithfully spraying the engine with Rodent Repellent, using Natural Repeller packs, and rat snap traps. We have regularly checked the engine to see if they have come back. Yesterday, XXX, low and behold there was evidence of rat/mice droppings, insulation, food, nesting, etc. We again have spent time and money to clean the engine and use the above-mentioned products to try to protect the engine. After moving the truck, again on XXX, there was new evidence. We treated again. This is causing us stress. This should be a recall and Ford made to remedy. Sincerely, [XXX] and [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
- Filed Aug 2026
On 7-2-26, my 2022 Ford Maverick Hybrid was brought to College Station Ford to receive the remedy for mandatory Safety Recall 24S59 (NHTSA Campaign 24V684000) regarding the frozen Rear View Camera display image. Prior to this service, the vehicle’s electrical, starting, and hybrid systems functioned flawlessly without error.Immediately following the completion of the recall service, which required a software flash of the Connected Touch Radio/Audio Control Module (ACM), the vehicle suffered a catastrophic module network failure resulting in a permanent no-start condition. The vehicle's Powertrain Control Module (PCM) and Body Control Module (BCM) have glitched into a permanent High-Voltage System Isolation Lockout loop.Independent professional laboratory load-testing has certified that the vehicle's low-voltage 12V auxiliary battery is healthy, fully charged, and completely functional. However, the vehicle can currently only be turned on by attaching an external 12V jump-pack directly to the battery system. This external voltage spike manually overrides the corrupted software communication loop, forcing the vehicle's electrical relays to close.The dealership has refused to remedy this botched recall programming, claiming the physical hybrid high-voltage lines have suddenly failed. Because a low-voltage 12V jump-pack cannot power or repair broken high-voltage traction lines, the vehicle is suffering from a software-induced safety lockout directly caused by the failed execution of Recall 24S59.This presents an active, extreme safety hazard. A hybrid powertrain suffering from un-remedied module communication failures and high-voltage isolation fault lockouts risks a sudden, unexpected, and catastrophic loss of motive power while operating at highway speeds on public roads.I am filing this report because the manufacturer's official recall remedy has introduced a dangerous, debilitating safety flaw to the vehicle's primary powertrain loop.
- Showing the 5 most recent of 200.
- Power Train179
- Filed Sep 2026 · Also filed under Electrical System
The contact owns a 2022 Ford Maverick. The contact stated that while driving 40 MPH, the engine light turned on and off and then several unknown warning lights illuminated and the vehicle abruptly decelerated. The driver pulled over, and the vehicle was restarted. The vehicle was then driven 20 MPH. The vehicle was taken to the local dealer, and it was determined the failure was caused by the calipers and a software update. The dealer informed the contact that the VIN was not under recall. The manufacturer was contacted. The failure mileage was approximately 122,000.
- Filed Sep 2026 · Also filed under Wheels, Engine
Engine long block assembly needed replacement. TPMS continues to fail. Axles make vehicle shake when going freeway speeds.
- Filed Sep 2026
I have already had the cv axles replaced under the extended customer satisfaction program in January 2026, but today while doing a cross country move, the outer boot on the drivers side showed significant grease loss, and the inner boot on the passenger side tore off with a very severe clunk, noise, and shake while braking and accelerating. Thankfully the cv axle did not separate, but a failure could have resulted in a loss of control. This will be going to the dealership tomorrow. No warning lights, messages, or symptoms that I could observe before the 1000 mile trip across yesterday and today.
- Filed Sep 2026
My 2022 Ford Maverick Hybrid has twice suddenly entered limp mode and experienced a substantial loss of power. The first incident occurred on or about XXX. After leaving my subdivision, I turned onto [XXX], which has a posted speed limit of 55 mph. The vehicle immediately lost power and entered limp mode, and the engine and wrench warning lights appeared. The weather was clear and sunny. I was able to drive several miles at substantially reduced power and return home. On XXX, at 83,600 miles, Louisburg Ford retrieved DTC P1061, determined that Ford TSB 25-2454 applied, and reprogrammed the required modules. The second incident occurred on 9/13/2026. My husband and I were returning home after traveling through [XXX], [XXX], and [XXX]. We were driving northbound on I-35 near mile marker 182 at the [XXX] exit, just south of [XXX]. It was completely dark and storming, with rain and lightning, when the vehicle again entered limp mode and lost power in highway traffic. We were fortunate to have cellular service and a gas station nearby. Otherwise, we could have been stranded in dangerous conditions. On XXX, at 106,338 miles, the same dealer retrieved the same P1061 code and again applied TSB 25-2454 by reprogramming the PCM. The same loss-of-power condition, code, and Ford-prescribed repair recurred within approximately 11 months and 22,738 miles. The dealer advised that there is no guarantee it will not happen again. I am concerned that this sudden loss of acceleration or motive power could recur at highway speed and cause a crash. I request that NHTSA investigate this recurring condition and whether TSB [XXX] provides an adequate remedy. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
- Filed Sep 2026
While driving on the streets the powertrain module gave out. It started to jerk around 30 mph and then just would not go.
- Showing the 5 most recent of 179.
- Engine1631 involved a crash · 3 involved a fire
- Filed Sep 2026 · Also filed under Power Train, Wheels
Engine long block assembly needed replacement. TPMS continues to fail. Axles make vehicle shake when going freeway speeds.
- Filed Aug 2026 · Also filed under Forward Collision Avoidance
Engine failure with fire. Fully engulfed within seconds. Police and fire on site. AAA insurance No prior issues with vehicle
- Filed Aug 2026 · Also filed under Power Train
What component or system failed, and is it available for inspection? The right frame engine mount, differential/rear mount, and upper engine mount were all torn or broken. Both front CV axle shafts also needed replacement. Repaired 8/17/2026 by Miami County Auto, Louisburg, KS (invoice #13092). No, I don't have the parts anymore. How was your safety or the safety of others put at risk? The vehicle developed a wobble/vibration under acceleration that was reported as "getting worse" — pronounced enough to visibly shake objects in the cabin. The shop noted the engine mounts were torn/broken, allowing excess engine movement, which increases risk of further mount or drivetrain component failure and loss of vehicle control, especially at highway speeds or during hard acceleration. Has the problem been reproduced or confirmed by a dealer or independent shop? Yes — confirmed and repaired by an independent shop (Miami County Auto) on 8/17/2026 at 104,205–104,211 miles. Not taken to a Ford dealer. Has the vehicle been inspected by the manufacturer, police, insurance, or others? No — only inspected and repaired by the independent repair shop noted above. Were there warning symptoms before failure, and when did they first appear? Yes — a wobble/vibration under acceleration that subsided when off the throttle, and progressively worsened over time before the repair. Originally I thought it was a recently repaired tire that was unbalanced. Took it to Ford dealership to rebalance. They said there was no wobble (there was) and took it the independent shop.
- Filed Aug 2026 · Also filed under Electrical System, Unknown or Other
The Ford Maverick is subject to rodent invasions which caused an engine fire. We had to file a State Farm Insurance Claim ($4016.36 of repairs done to repair the engine including electrical, emission system, cowl, fuel system, and insulation.) This was completed XXX. We have been faithfully spraying the engine with Rodent Repellent, using Natural Repeller packs, and rat snap traps. We have regularly checked the engine to see if they have come back. Yesterday, XXX, low and behold there was evidence of rat/mice droppings, insulation, food, nesting, etc. We again have spent time and money to clean the engine and use the above-mentioned products to try to protect the engine. After moving the truck, again on XXX, there was new evidence. We treated again. This is causing us stress. This should be a recall and Ford made to remedy. Sincerely, [XXX] and [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
- Filed Jun 2026 · Also filed under Steering, Electrical System
While driving at normal speeds. Car completely stopped working. Dashboard flashed to get to safe area. I could not shift the car neutral. Steering became stiff. The lights and infotainment was still on but the car had no power to accelerate. Had this been on the highway I would have been in a collision since my car went to the right very quick. Once car was stopped could not shift to neutral.
- Showing the 5 most recent of 163.
- Service Brakes1094 involved a crash
- Filed Sep 2026 · Also filed under Hydraulic
The contact’s husband who owns a 2022 Ford Maverick. The contact stated that while her husband was reversing to complete a 3-point turn, the brakes failed to respond while the brake pedal was depressed, causing the vehicle to drive into a ditch and then crashed into a large boulder alongside the driveway. The contact stated that the pre-crash alert illuminated prior to the crash. The rear passenger's side bumper was damaged, and wires were hanging down. The vehicle was towed to a dealer, where the contact was informed that no brake failure was found. The contact stated that the insurance company had inspected the vehicle. The driver had emotional distress and might have sustained a bruise. The failure mileage was approximately 46,100.
- Filed May 2026
NHTSA #26V104: I purchased this vehicle to rent it out on Turo (a vehicle sharing platform). It was de-listed from Turo on March 18 due to NHTSA #26V104 recall being unresolved. I have been unable to rent my vehicle since then and Ford has not provided a remedy to this recall. I would like to log a complaint that this software fix remedy has taken too long.
- Filed May 2026
brake issue when coming to a stop, sometimes the brakes (mainly front) feel like they go free for a rotation. this is a random problem, and the dealer didn't find an issue.
- Filed Feb 2026 · Also filed under Electrical System, Exterior Lighting
I have a 2022 Ford Maverick XL Hybrid and the system that failed is the rear lighting system, specifically the tail lamps, brake lamps, and rear turn signals. This appears to be related to the Body Control Module (BCM) software, which was the subject of Ford Recall 24S27 affecting many 2022–2024 Ford Mavericks. The failure began on my vehicle with the left rear tail lamp assembly (running light, brake light, and turn signal), and within approximately two minutes the right rear tail lamp assembly also stopped functioning. Since that time, the entire rear lighting system has been inoperative while driving. This issue creates an extremely serious safety hazard. While driving, my vehicle has no functioning rear running lights, brake lights, or turn signals. This means other drivers cannot see when I am braking, signaling a turn, or even driving at night. This significantly increases the risk of rear-end collisions or other traffic accidents, especially in low visibility conditions. I was unaware of the issue until visually noticing it when unlocking the vehicle, and there were no dashboard alerts to warn me prior to that either. Loveland Ford in Loveland, Colorado inspected the vehicle and confirmed that the rear lighting system is not functioning. However, instead of addressing the known Recall 24S27 Body Control Module software issue, they stated that LED bulbs were installed where halogen bulbs should be and issued an $816 estimate to replace the bulbs. I have never performed any aftermarket modifications, and the vehicle has only been serviced by Ford dealerships. The vehicle has been inspected by Loveland Ford, an authorized Ford dealership. Ford customer service confirmed that Recall 24S27 exists for this exact issue in many 2022–2024 Ford Mavericks but stated there is no record of my VIN receiving the recall remedy, which could mean the recall was never accomplished. No warning lamps, dashboard messages, or other alerts appeared prior to the failure.
- Filed Dec 2025 · Also filed under Electrical System, Vehicle Speed Control
My 2022 hybrid Maverick suddenly lost power as I was driving at 45 MPH. There was no warning lights; the entire dashboard went black. I lost all power including lights, speedometer, and power steering. Additionally, and more concerning, I lost all brake functionality so I could not stop the vehicle, even pressing the brake very hard. The parking brake switch also did not work due to the power loss. The brake pedal would not budge until suddenly after the vehicle completely lost all momentum. In the process blew through a stop sign and I could've easily been killed, or worse, killed other people as I had no control of the vehicle as it coasted. Thankfully nobody and nothing else was harmed as I was the only one on the road, it was just traumatic. The vehicle was towed to the dealer and preliminarily inspected. They decided they want to address a technical safety bulletin for a "no start condition", though the conditions did not match this situation exactly. But they also stated the hybrid/powertrain warranties did not apply, so I rejected the repair due to high cost. It is uncertain if the repair they want to do would fix the issue. It is currently available for inspection upon request, though Ford may try to buy it back soon. It has not been inspected by police or insurance. The only light I can think of was a month before I saw a brief "Charging System Service Soon" warning, but it was only on momentarily (did not persist). I am unsure if this is related.
- Showing the 5 most recent of 109.
- Unknown or Other681 involved a crash · 1 involved a fire
- Filed Aug 2026 · Also filed under Electrical System, Engine
The Ford Maverick is subject to rodent invasions which caused an engine fire. We had to file a State Farm Insurance Claim ($4016.36 of repairs done to repair the engine including electrical, emission system, cowl, fuel system, and insulation.) This was completed XXX. We have been faithfully spraying the engine with Rodent Repellent, using Natural Repeller packs, and rat snap traps. We have regularly checked the engine to see if they have come back. Yesterday, XXX, low and behold there was evidence of rat/mice droppings, insulation, food, nesting, etc. We again have spent time and money to clean the engine and use the above-mentioned products to try to protect the engine. After moving the truck, again on XXX, there was new evidence. We treated again. This is causing us stress. This should be a recall and Ford made to remedy. Sincerely, [XXX] and [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
- Filed Jul 2026
Driving on highway, approximately 65mph when all of a sudden the "door ajar" symbol on instrument panel lit / sound dinged, and the passenger who had their elbow on the door screamed. The passenger side door unlocked and "opened" as in it unlatched. It did not open all the way for her to fall out, but it was no longer fully closed. This is a 2022 vehicle. This happened for the first time in 2026 after 34k miles. There is an active recall for the same make / model but for some reason my VIN is not included. I'm pretty sure it should be after this experience.
- Filed May 2026
The chrome tips on the window switch fell off and jammed itself in the switch, in the on position for the passenger window. These exact parts are already on recall for different Ford models but it is the same part number being used.
- Filed Jan 2026
This is a complaint of Sheridan Ford in Wilmington DE specifically refusing to complete the recall without my paying out of pocket. Manufacturer Recall Number24S59 NHTSA Recall Number24V684 was left incomplete because they demanded I pay for a "diagnostic" fee on a known safety issue - this dealership is taking advantage of a saftey recall that is required to force customers to pay
- Filed Jan 2026 · Also filed under Electrical System
I received the 2022 Hybrid Ford Maverck XLT on March 2023, and had first 12V battery replacement on August 2023 as it was dysfunctional leading to car stalling. On 01/11/2026, the truck suddenly got stalled during drive due to the dysfunction (8.0V) again of the 12V battery, which triggered several error codes. The 12V battery was replaced again on 01/12/2026. I drove the truck home and found later that system alert with "Electrical Power Saver Active". The truck stalled again on 01/13/2026 at traffic light near school zone. The police had the truck towed to Tire Express per SOP. The truck was then diagnosed at local Ford dealer as: "multiple accessory / entertainment modules have software level that may be contributing to 12V battery drain / degredation". Obviously, this is the truck defect can may pose catastrophic risk to driver and surrounding drivers. I searched Google and found more 2022 Maverick with such serious issue! My total cost of repair and towing from this defect is 1145.11. Thank God that my family was safe during the sudden stalling while driving. I know there is no such recall but Ford should be responsible for the recall to avoid future risks and paying off my cost. Please consider this as a recall! Thank you!!!
- Showing the 5 most recent of 68.
- Forward Collision Avoidance283 involved a crash · 1 involved a fire
- Filed Aug 2026 · Also filed under Engine
Engine failure with fire. Fully engulfed within seconds. Police and fire on site. AAA insurance No prior issues with vehicle
- Filed Jun 2026 · Also filed under Steering, Electrical System
Due to go to dealership to inspect steering wheel
- Filed Aug 2025 · Also filed under Power Train, Engine
I was at a stoplight, when the light turned green I went to press the gas and the whole car lost power and died. The car stalled and would not turn over again. The vehicle had power but would not start the engine. All the alerts were flashing on the dash and the car would not go into neutral, so I was stuck in the middle of the roadway. I followed the procedures to activate the manual override and place the car into neutral and the vehicle would still not move. The electrical brake would not allow the vehicle to move. We tried repeatedly to put the car into neutral to move out of an active roadway and would be able to push the vehicle about an inch before the electrical break would kick in again. The vehicle would not start regardless of what was attempted. We even disconnected the battery in hopes of either getting the vehicle into neutral (which did not work either) or restarting whatever was wrong with the electrical system and be able to start the truck. Nothing worked and the vehicle had to be hoisted by pulley onto a flat bed tow truck. Then required to be "shaken" off of the truck when it arrived at the Ford dealership.
- Filed Jul 2025
When in adaptive cruise control the vehicle must of not seen the lines properly and started to steer towards the ditch. Then when trying to steer back onto the road the truck keep trying to steer into the ditch. The truck was fighting the drivers input even though the truck should deactivate the adaptive cruise control when manually taking over. The truck end up in the ditch and ran over a mailbox. The truck was inspected by Ford but they claimed nothing is wrong with it. It says in the manual that adaptive cruise control sometimes doesn't detect lines properly but when taking control the vehicle shouldn't continue to steer into a ditch. The Ford dealership were not able to get the same results because how can they when this problem doesn't happen all the time? The vehicle should not be fighting the driver instead it should of canceled the adaptive cruise control. It's very dangerous and I think needs to be looked into.
- Filed Jan 2025 · Also filed under Steering, Service Brakes
After performing a panic stop where the Pre-Collision activation message and chime activated, nothing happened until a few miles down the road. At that time, The "Service AdvanceTrac," "Pre-Collision Assist Not Available" and "Hill Start Assist" warning messages scrolled on the cluster with a chime to go with them. Additionally, the amber tell tale warning lights for the ABS system, electric park brake system, stability control system and pre-collision assist were illuminated. The lights turned themselves off one by one approximately five 5-6 miles after that, then all came back on with the same three warning messages about 2-3 miles after they had gone off. All remained illuminated even at the start of the next key cycle but promptly went away before leaving the parking lot. It should be noted that while the warning lights were on, the vehicle did not have electronic power steering assist though no warnings or lights told of this failure. I could just tell from the increased effort in low speed, parking lot maneuvers.
- Showing the 5 most recent of 28.
- Vehicle Speed Control271 involved a crash
- Filed Jan 2026 · Also filed under Power Train
As I was traveling on freeway at 65 mph cruise control disengaged. After I was notified to service engine soon and check engine light came on. Throttle was unresponsive forcing me to cross 4 lanes of the 5 freeway. Pulled over and shut off vehicle checked fluids. Nothing out of spec.restarted vehicle and would not get out of limp mode.
- Filed Dec 2025 · Also filed under Electrical System, Service Brakes
My 2022 hybrid Maverick suddenly lost power as I was driving at 45 MPH. There was no warning lights; the entire dashboard went black. I lost all power including lights, speedometer, and power steering. Additionally, and more concerning, I lost all brake functionality so I could not stop the vehicle, even pressing the brake very hard. The parking brake switch also did not work due to the power loss. The brake pedal would not budge until suddenly after the vehicle completely lost all momentum. In the process blew through a stop sign and I could've easily been killed, or worse, killed other people as I had no control of the vehicle as it coasted. Thankfully nobody and nothing else was harmed as I was the only one on the road, it was just traumatic. The vehicle was towed to the dealer and preliminarily inspected. They decided they want to address a technical safety bulletin for a "no start condition", though the conditions did not match this situation exactly. But they also stated the hybrid/powertrain warranties did not apply, so I rejected the repair due to high cost. It is uncertain if the repair they want to do would fix the issue. It is currently available for inspection upon request, though Ford may try to buy it back soon. It has not been inspected by police or insurance. The only light I can think of was a month before I saw a brief "Charging System Service Soon" warning, but it was only on momentarily (did not persist). I am unsure if this is related.
- Filed Oct 2025 · Also filed under Steering, Electrical System
While driving in local traffic, my vehicle completely shut down. All power was lost. The engine shut off, shift control was disabled and the power steering did not work. Several warning lights were displayed including a "shift to neutral" warning, which was disabled. I was unable to restart the vehicle. After sitting for 10 minutes, the vehicle was started and resumed normal operations. This has happened on more than one occasion. The local dealership has kept the vehicle and cannot duplicate the failure or determine the cause. I am concerned that this could happen on the highway and cause myself or other travelers to be injured.
- Filed Feb 2025 · Also filed under Power Train
The contact owns a 2022 Ford Maverick. The contact stated while driving approximately 65 MPH, the vehicle lost motive power. The vehicle failed to accelerate as designed. The powertrain message was displayed. Additionally, the WRENCH symbol was displayed. The vehicle was taken to the local dealer, but the dealer was unable to duplicate the failure. The vehicle was not diagnosed or repaired. The Ford Pass App alerted the contact of the failure. The vehicle was taken to another local dealer, Loudon Motors Ford LLC (address removed); where it was diagnosed that the throttle assembly had caused the failure. The vehicle was repaired, but the failure recurred. The manufacturer was contacted and referred the contact to the local dealer for assistance. The failure mileage was approximately 20,000.
- Filed Jan 2025
This car shifts to drive to neutral without any intervention on the freeway.
- Showing the 5 most recent of 27.
- Fuel/Propulsion System241 involved a fire
- Filed Aug 2026 · Also filed under Power Train
While driving my 2022 Ford Maverick on a public road, the vehicle suddenly lost acceleration and would not respond normally when I pressed the accelerator. I was left in the roadway and could not safely continue driving, creating a risk of being struck by other traffic. The vehicle was later inspected by a Ford dealership and diagnosed with a major internal transmission failure at approximately 62,000 miles. The Ford dealership recommended a rebuilt/replacement transmission. The vehicle remains available for inspection. I did not have advance warning that the transmission was about to fail.
- Filed May 2026
Fuel leaking from pressurized tank, strong fuel smell. Photo attached shows pattern of fuel leak.
- Filed Mar 2026 · Also filed under Electrical System, Engine
Just picked up vehicle after having a new battery installed. Was getting pop up on dashboard every few seconds that electrical saving mode was active. Then all of a sudden the truck shut off while driving about 45 mph on a busy road. Dash said switch to neutral to start vehicle which i tried but nothing happened. Truck coasted to a stop and would not start or even shift into neutral to push it off of the road. The dashboard was flashing pretty much every warning possible including stop safety, shift system failure, parking brake , battery saver active etc. The truck continued to not start or shift. Tow truck was called and it was towed home.
- Filed Dec 2025
Fuel tank failure at 18,000 miles and less than 3 years of ownership. I noticed that the vehicle had a strong gasoline smell when I was around it. When looking under the truck, I could see that there was a fuel leak coming from the fill pipe inlet into the fuel tank itself. Took the vehicle under warranty to the ford dealer, and was told that the hose clamp was loose connecting the fill pipe into the fuel tank itself. Was sent on my way with the vehicle, and noticed a smell of gasoline and fuel not even two months later. Took it back to the dealer and was told that they were unable to replicate it. Once the weather got cold again, took the vehicle back after noticing a much larger leak and smelling fuel, and am now being told by ford that the fuel tank does in fact need to be replaced as the tank is leaking from the fill pipe inlet. I am no longer under warranty and was quoted $1100 for this repair. Not only do I find this to be a safety concern as leaking gasoline is extremely dangerous and flammable (plus there are vapors in the air in my garage) but felt that my dealership did not do their due diligence to resolve this issue properly, and now I am on the hook for an $1100 repair that should’ve been taken care of when the vehicle was under warranty. No warning lamps were lit alerting me to this problem, I noticed it by smelling gasoline in my garage near the vehicle.
- Filed Jun 2025 · Also filed under Electrical System, Engine
1)After sitting for 2 days the battery was drained or dead. The truck would not start. I jumped the truck and it started up. Every time I park the truck i get a warning that the battery is low and I should drive it to recharge the battery. I drive the truck but it will not recharge. 2) The check engine light comes on. I went to the auto parts and scanned for diagnostics. The scan came back as a fuel tank pressure sensor failure. 3) When I drive the truck it smells as if something is burning. 4) The fuel gage is not showing accurate reading. 5)The fuel door wont open unless I have the truck turned on and then it takes several minutes. 6) After driving on the freeway I came to a stop on the off rap before entering a main street and the truck died.
- Showing the 5 most recent of 24.
- Air Bags244 involved a crash
- Filed Jul 2025 · Also filed under Electrical System, Service Brakes
My 2022 Ford Maverick hybrid is known to have an issue with water leaking into the cabin from the cowl. This water is leaking onto the floorboards and there is some mold growing behind the electrical box. WHICH IS NOT GOOD AND IS SAFTEY AND HASZARD TO OUR HEALH TO BREATH THIS IN THIS NEED TO BE SENT OUT AS A RECALL AND FIX FOR FREE OR BUY BACK THE vehicle
- Filed Feb 2025 · Also filed under Electrical System, Service Brakes
while i was driving the truck lost power and i could not turn on my 4 way flashers when i was on the side of the road. when i called ford and asked if i would replace the battery if i would get compensation they told me no even though there is a recall
- Filed Nov 2024 · Also filed under Seat Belts
The component that failed on this vehicle was the restraint control module (RCM). It was replaced by the dealer and is not available for inspection. The safety of the driver I believe was at risk due to the vehicle occupant sensor not showing an occupant and only showing a question mark on the dash display. This was also causing an airbag and seat belt indicator light. The problem has been reproduced by a dealer. The problem first showed a rear seat occupant issue and then started showing for the left front seat. Showing an air bag and seat belt indicator.
- Filed Oct 2024 · Also filed under Structure
I was involved in an accident. During the accident none of the airbags deployed. The impact was so hard that it lifted the truck up off the ground and spinned us around 90 degrees. This resulted in the individuals seated on the passenger side of the truck to be thrown into the door fairly hard, with one passenger hitting her head on the window even with the seatbelt on. The point of impact was the drivers side back tire and bumper area.
- Filed Jun 2024 · Also filed under Seat Belts
On Thursday (June 13, 2024) my truck displayed a fault that states Rear Belt Monitor Fault Service Required, at the same time my air bag light came on. I proceeded to work and found a lot of people have had this issue with their Ford Mavericks but have all said it is actually their drivers seatbelt with the issue. My husband thought he would test it to see and while driving he took his seatbelt off, the airbag light and fault went away but also even driving at highway speeds it never told us the seatbelt was off. When he plugged the seatbelt back in my truck indicated that seatbelt 3 was actually plugged in and the fault and airbag light came back on.
- Showing the 5 most recent of 24.
- Structure211 involved a crash
- Filed Jul 2026
The driver's side (left front) door failed at the check-arm attachment point inside the door assembly: the spot welds securing the check-arm reinforcement bracket to the inner door structure cracked and separated. The vehicle is a commercial fleet 2022 Ford Maverick XL SuperCrew with approx. 82,000 miles. The vehicle and failed component are available for inspection upon request. First symptoms were difficulty opening and closing the door with popping/cracking noises. No warning lamps or messages occurred; the failure is concealed inside the door. This is a safety risk because the check arm attachment supports the door's structure. The same weld separation on related vehicles has been documented by NHTSA (investigation PE23-013) to cause doors that fail to latch, fail to stay closed, or open while driving, risking occupant ejection and injury. The failure was confirmed 7/17/2026 by Grapevine Collision Center (Grapevine, TX) after a Ford dealership stated there is no recall or warranty coverage for the Maverick and referred me there. The shop diagnosed broken check-arm welds and quoted $2,602.46 for a door shell replacement, noting it has seen this identical failure on Ford Escapes and Lincoln Corsairs. Not inspected by Ford, police, or insurance. This is the same failure mode NHTSA investigated on 2020-2021 Escapes (PE23-013), which Ford addressed via Customer Satisfaction Program 23B56 covering 2020-2023 Escapes. The Maverick shares the same C2 platform and door design but is excluded, leaving owners to pay out of pocket for a defect Ford repairs free on sibling vehicles.
- Filed Mar 2026
Driver side door limiter welds broke loose. Ford said they had to replace the entire door and it was not covered by warranty. The dealer said that this happened to a bunch of Ford Escapes, but they did not have a recall for the Maverick yet.
- Filed Jan 2026
When it rains water gets into the passenger-side footwell and beneath the carpeting during rain events.
- Filed Nov 2025
Door check has failed in the frame. The spot welds have broken in similar fashion to the Ford Customer Satisfaction Program 23B56 on the Escapes. There are popping noises, creaking, alignment issues, and prevents the window from rolling down.
- Filed Aug 2025
My 2022 Ford Maverick developed a water intrusion defect caused by improperly sealed body panels under the hood cowl. This defect allowed water to enter the cabin, pooling in the passenger-side floor pan and creating a persistent, extremely strong interior odor. A chemical treatment temporarily masked the smell, but it returned and worsens over time. The vehicle cannot be reasonably operated without rolling down the windows due to the odor, raising health and safety concerns. The defect was difficult to replicate, but eventually the servicing dealer confirmed that the leak occurs when the vehicle is parked or driven at a downward incline with the rear elevated. Repairs were completed at Greenway Ford (Orlando, FL) between August 14–21, 2025. The final invoice was $2,040.55. Ford only provided partial goodwill coverage, leaving me responsible for $918.25 + tax, and refused to cover replacement of the contaminated carpet and padding. I also incurred $312.94 in rental costs because the vehicle could not be safely used. This is not an isolated issue — multiple Maverick owners have reported the same cowl sealing defect on online owner forums. Water intrusion creates ongoing health risks (odor/mold exposure) and may also affect safety-critical electrical components or interior visibility. I request that NHTSA investigate this systemic defect in 2022 Ford Mavericks and evaluate whether a recall or service campaign is warranted.
- Showing the 5 most recent of 21.
- Steering202 involved a crash
- Filed Jun 2026 · Also filed under Electrical System, Forward Collision Avoidance
Due to go to dealership to inspect steering wheel
- Filed Jun 2026 · Also filed under Electrical System, Engine
While driving at normal speeds. Car completely stopped working. Dashboard flashed to get to safe area. I could not shift the car neutral. Steering became stiff. The lights and infotainment was still on but the car had no power to accelerate. Had this been on the highway I would have been in a collision since my car went to the right very quick. Once car was stopped could not shift to neutral.
- Filed May 2026 · Also filed under Suspension
Front end of vehicle suddenly started to shake violently when accelerating. Issue was reproduced any time when accelerating. No warning was indicated by the vehicle. Car was undrivable above 50 mph. Vehicle had 25K miles. Dealer reproduced issue. Diagnosed it as a catastrophic failure of both CV joints and front bearing(s). Dealer would not release vehicle as it was undrivable due to extreme safety issue. Parts arrived after a week and both CV joints & front bearing(s) were replaced. Online reporting for this vehicle shows this is a repeated issue which the manufacturer has a customer satisfaction bulletin but no recall.
- Filed May 2026 · Also filed under Electrical System
I was trying to turn and the wheel kept kicking back the other direction. About a week prior to this as I was driving down the road all of a sudden the wheel threw me across a median and into incoming traffic almost causing multiple accidents. I have a video of it but it won’t allow me to upload it. [XXX] However this link should play it. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
- Filed Apr 2026 · Also filed under Electrical System
When the battery voltage suddenly drops the vehicle loses its power steering making slow speed turns extremely difficult. This poses a serious risk of the inability to control the direction of the vehicle and this makes a crash extremely probable.
- Showing the 5 most recent of 20.
- Suspension20
- Filed May 2026 · Also filed under Steering
Front end of vehicle suddenly started to shake violently when accelerating. Issue was reproduced any time when accelerating. No warning was indicated by the vehicle. Car was undrivable above 50 mph. Vehicle had 25K miles. Dealer reproduced issue. Diagnosed it as a catastrophic failure of both CV joints and front bearing(s). Dealer would not release vehicle as it was undrivable due to extreme safety issue. Parts arrived after a week and both CV joints & front bearing(s) were replaced. Online reporting for this vehicle shows this is a repeated issue which the manufacturer has a customer satisfaction bulletin but no recall.
- Filed May 2026 · Also filed under Power Train, Electrical System
When we brought it in for first oil change at the dealership ; when we got it back it had a broken axle which they tried to say we just needed new tires , after contacting service manager and he and I go for a ride in it they kept it for several weeks and put over 300 miles on it and got ford engineering involved to determine the cause was broken axle. It has been replaced again since then supposedly by a recall but it feels like it is broken again ! Ford took some shortcuts and used inferior parts, infrastructure etc , we had tremendous problems with the battery to which they said their shouldn’t be any reason for this be happening loss of power loss of electrical display and distribution finally I just had to replace the battery on my own because they refused to accept responsibility 4-6 months later a recall for the batteries was issued. The axles on the truck are not sufficient and they are not taking care of it properly! I would also like to report that they cut so many corners on the Maverick that the tailgate just drops no shock absorber nothing just slams on the bumper very dangerous! & They also chose to leave many open” holes” where mud rocks , leaves etc get into the front quarter panels from the hood area at the corner of windshield . So this wet material gets trapped in there n I’m sure will eventually affect the structural integrity of the panel - maybe rust through! Same thing happens with the tailgate fills with debris from bed , rear wheel wells also have a whole. I just wish ford would go back to how Henry Ford ran the company ! Help NHTSA
- Filed Jan 2026 · Also filed under Power Train, Lane Departure
Clunking in the front end around 20,000 miles. Brought to multiple dealers and they all said no problem found yet clearly hear clunking both sides front going over bumps or steering back and forth quickly. Finally I just replaced them and noise gone. Second thing is headliner is completely ruined from moisture intrusion and can visibly be seen but dealer states no leaks present yet my headliner is water stained looking like those wet tiles in a school. Third is my transmission. It is very erratic when shifting and sometimes flares when downshifting. Dealers state no problems exist. Operates as designed, yet I have driven other mavericks and they do not have the same issues as myself. I have changed the fluid with genuine ford ulv transmission fluid from dealer at about 50k miles. I change my oil every 3k, changed my differentials and transfer case all with genuine fluid. I am an AAS Automotive Technology graduate and currently ASE certified and have worked in multiple dealerships replacing transmissions, engines, almost anything since I have started. I need to gather my records as I have kept receipts and records as I do all my own maintenance and repairs. I have replaced the downstream oxygen sensor twice. Yesterday morning I got a frozen throttle body and limp mode and if I did not have my scan tool I would have been stranded as it would not let me drive due to the stuck closed codes. All codes since I owned the vehicle with 3 miles on it are stored in my ford app and on my scan tool with vin. I have tried calling ford, email, different dealerships and they deny me or want me to pay out of pocket when I have warranty.
- Filed Oct 2025 · Also filed under Power Train
CV axle is going bad and the car would shake really bad when on the highway and felt unsafe to drive going 65 MPH was scary with a rattle and car could nat stay in lane
- Filed Aug 2025 · Also filed under Steering
The contact owns a 2022 Ford Maverick. The contact stated while driving approximately 50-70 MPH, the vehicle shook violently while depressing the accelerator pedal. There was no warning light illuminated. The vehicle was taken to a dealer and the front CV axles were replaced under warranty. However, three months after the CV axle repair, the failure recurred. The vehicle was taken back to the dealer and the contact was informed that the CV axles were on backorder. The manufacturer was later notified of the failure and the contact was informed that parts were available; however, the part was no longer covered under warranty. The contact was provided an estimate to cover half the cost of the repair. The contact was referred to the NHTSA Hotline to report the failure. The vehicle was not repaired. The failure mileage was approximately 38,000.
- Showing the 5 most recent of 20.
- Exterior Lighting16
- Filed Feb 2026 · Also filed under Electrical System, Service Brakes
I have a 2022 Ford Maverick XL Hybrid and the system that failed is the rear lighting system, specifically the tail lamps, brake lamps, and rear turn signals. This appears to be related to the Body Control Module (BCM) software, which was the subject of Ford Recall 24S27 affecting many 2022–2024 Ford Mavericks. The failure began on my vehicle with the left rear tail lamp assembly (running light, brake light, and turn signal), and within approximately two minutes the right rear tail lamp assembly also stopped functioning. Since that time, the entire rear lighting system has been inoperative while driving. This issue creates an extremely serious safety hazard. While driving, my vehicle has no functioning rear running lights, brake lights, or turn signals. This means other drivers cannot see when I am braking, signaling a turn, or even driving at night. This significantly increases the risk of rear-end collisions or other traffic accidents, especially in low visibility conditions. I was unaware of the issue until visually noticing it when unlocking the vehicle, and there were no dashboard alerts to warn me prior to that either. Loveland Ford in Loveland, Colorado inspected the vehicle and confirmed that the rear lighting system is not functioning. However, instead of addressing the known Recall 24S27 Body Control Module software issue, they stated that LED bulbs were installed where halogen bulbs should be and issued an $816 estimate to replace the bulbs. I have never performed any aftermarket modifications, and the vehicle has only been serviced by Ford dealerships. The vehicle has been inspected by Loveland Ford, an authorized Ford dealership. Ford customer service confirmed that Recall 24S27 exists for this exact issue in many 2022–2024 Ford Mavericks but stated there is no record of my VIN receiving the recall remedy, which could mean the recall was never accomplished. No warning lamps, dashboard messages, or other alerts appeared prior to the failure.
- Filed Feb 2026
The rear brake lights intermittently do not work, but at the same time the middle third light brake light works fine. also the turn signals work fine. People will rear end me if they don’t see my brake lights. I am a retired, master mechanic, and my son is also a mechanic. We have both looked into this problem and it possibly could be either a module or the turn signal switch. I had no warning of this problem coming on other than someone telling me my rear brake lights stopped working when they were following me. This is a very dangerous situation.
- Filed Oct 2025 · Also filed under Electrical System, Engine
My car shuts off Battery drains, burning smell Rear camera gives out Clicking noises
- Filed Sep 2025
When opening driver side door the interior lights do not turn on! This is a hazardous situation at night entering the truck and turning on the ignition.
- Filed Nov 2024 · Also filed under Electrical System
Truck stay in 12v battery deep sleep. None of my cabin lights work, ambient lighting, remote start, nor does my ford pass app work because of this issue. Its been on going since about a month after purchase. So that is two plus years of this constant issue
- Showing the 5 most recent of 16.
- Back Over Prevention142 involved a crash
- Filed Mar 2025 · Also filed under Electrical System
The contact owns a 2022 Ford Maverick. The contact received notifications of NHTSA Campaign Numbers: 24V684000 (Back Over Prevention) and 25V019000 (Electrical System); however, the parts to do the recall repairs were not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available for NHTSA Campaign Number: 25V019000 (Electrical System); and Parts distribution disconnect for NHTSA Campaign Number: 24V684000 (Back Over Prevention).
- Filed Mar 2025 · Also filed under Lane Departure
While reversing into my driveway towards my garage, the rear parking aid did not show the truck with the radar bars on the reverse camera on the infotainment screen. The rear parking aid was on and was beeping, but did not show the radar on the screen. I restarted the vehicle and put the car in reverse and the radar began showing in the top right corner. I will attach pictures to this report.
- Filed Feb 2025 · Also filed under Electrical System
The contact owns a 2022 Ford Maverick. The contact received notifications of NHTSA Campaign Numbers: 24V684000 (BACK OVER PREVENTION) and 25V019000 (ELECTRICAL SYSTEM); however, the parts to do the recall repairs were not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
- Filed Feb 2025 · Also filed under Electrical System
The contact owns a 2022 Ford Maverick. The contact received notifications of NHTSA Campaign Numbers: 24V684000 (Back Over Prevention) and 25V019000 (Electrical System); however, the parts to do the recall repair were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
- Filed Feb 2025 · Also filed under Electrical System
The contact owns a 2022 Ford Maverick. The contact stated that while attempting to park the vehicle, the rearview camera became inoperable. The contact stated that the image displayed on the screen was frozen. The contact received notifications of NHTSA Campaign Numbers: 24V684000 (Back Over Prevention) and 25V019000 (Electrical System); however, the parts to do the recall repairs were unavailable. The dealer was contacted. The vehicle was not diagnosed or repaired. The dealer informed the contact that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The approximate failure mileage was 52, 000. VIN tool confirms parts not available.
- Showing the 5 most recent of 14.
- Lane Departure6
- Filed Jan 2026 · Also filed under Suspension, Power Train
Clunking in the front end around 20,000 miles. Brought to multiple dealers and they all said no problem found yet clearly hear clunking both sides front going over bumps or steering back and forth quickly. Finally I just replaced them and noise gone. Second thing is headliner is completely ruined from moisture intrusion and can visibly be seen but dealer states no leaks present yet my headliner is water stained looking like those wet tiles in a school. Third is my transmission. It is very erratic when shifting and sometimes flares when downshifting. Dealers state no problems exist. Operates as designed, yet I have driven other mavericks and they do not have the same issues as myself. I have changed the fluid with genuine ford ulv transmission fluid from dealer at about 50k miles. I change my oil every 3k, changed my differentials and transfer case all with genuine fluid. I am an AAS Automotive Technology graduate and currently ASE certified and have worked in multiple dealerships replacing transmissions, engines, almost anything since I have started. I need to gather my records as I have kept receipts and records as I do all my own maintenance and repairs. I have replaced the downstream oxygen sensor twice. Yesterday morning I got a frozen throttle body and limp mode and if I did not have my scan tool I would have been stranded as it would not let me drive due to the stuck closed codes. All codes since I owned the vehicle with 3 miles on it are stored in my ford app and on my scan tool with vin. I have tried calling ford, email, different dealerships and they deny me or want me to pay out of pocket when I have warranty.
- Filed Mar 2025 · Also filed under Back Over Prevention
While reversing into my driveway towards my garage, the rear parking aid did not show the truck with the radar bars on the reverse camera on the infotainment screen. The rear parking aid was on and was beeping, but did not show the radar on the screen. I restarted the vehicle and put the car in reverse and the radar began showing in the top right corner. I will attach pictures to this report.
- Filed Mar 2023
On Monday 2/27/2023 I was driving northbound on the Taconic Parkway in New York going with my cruise control and co-pilot360 adaptive lane control engaged. I think I dozed off for about 20 seconds and during this time my co-pilot disarmed and my Maverick drove off the highway. Fortunately I regained control before I hit a sign or trees. I damaged a front rim, but it was a very close call. I am a very good driver normally, but this feature should be investigated. I understand that it is not "autopilot". I have the dash-camera video here: https://youtu.be/z6hpNyx3snc a. Co-pilot shuts off at .020 b. Truck leaves road at .036
- Filed Sep 2022 · Also filed under Service Brakes, Forward Collision Avoidance
When driving at slow speeds the brakes seem to have a “dead space”. The brakes slowly engage, don’t engage at all (hence dead space) then abruptly stop the vehicle. There is also a loud clunk associated with it. On one occasion the brakes would not engage at all causing me to nearly hit the vehicle in front of me. I had to pump the brake in order to stop abruptly, creating a dangerous situation. I took it to one ford dealer who claimed they couldn’t replicate the issue. The following week I took it to another in which they were able to replicate it however advised the can’t seem to find anything wrong with the system to be able to fix it.
- Filed Jul 2022 · Also filed under Electrical System, Forward Collision Avoidance
Vehicle would not start due to electrical connection, check engine light on, all driver assist features disabled.
- Showing the 5 most recent of 6.
- Seat Belts61 involved a crash
- Filed Sep 2025
I am getting a “rear seat belt monitor fault” warning on my dash accompanied by an air bag warning light. It is also not allowing the auto start stop function to work as the vehicle states it cannot verify the driver seat belt is fastened. I have read in online forums that this is not an isolated issue.
- Filed Nov 2024 · Also filed under Air Bags
The component that failed on this vehicle was the restraint control module (RCM). It was replaced by the dealer and is not available for inspection. The safety of the driver I believe was at risk due to the vehicle occupant sensor not showing an occupant and only showing a question mark on the dash display. This was also causing an airbag and seat belt indicator light. The problem has been reproduced by a dealer. The problem first showed a rear seat occupant issue and then started showing for the left front seat. Showing an air bag and seat belt indicator.
- Filed Jun 2024 · Also filed under Air Bags
On Thursday (June 13, 2024) my truck displayed a fault that states Rear Belt Monitor Fault Service Required, at the same time my air bag light came on. I proceeded to work and found a lot of people have had this issue with their Ford Mavericks but have all said it is actually their drivers seatbelt with the issue. My husband thought he would test it to see and while driving he took his seatbelt off, the airbag light and fault went away but also even driving at highway speeds it never told us the seatbelt was off. When he plugged the seatbelt back in my truck indicated that seatbelt 3 was actually plugged in and the fault and airbag light came back on.
- Filed Feb 2024 · Also filed under Seats
What component or system failed or malfunctioned? It’s not exactly failed or malfunctioned as much as it is just a flawed design. However, the problem is that the drivers seatbelt keeps getting wrapped up in the lever to recline the seat. This results in the handle getting pulled off of the seat constantly, the seat unexpectedly reclining when the driver pulls on the seatbelt too hard, or the seatbelt simply getting bunched up in the handle causing it to just become stuck and non functional. Is it available for inspection upon request? It is available for inspection anytime. How was your safety or the safety of others put at risk? When the drivers seat suddenly reclines or the seatbelt fails to engage due to being caught up in another component of the vehicle that’s a problem. Has the problem been reproduced or confirmed by a dealer or independent service center? No although I can duplicate that issue. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No.
- Filed Jul 2023
The contact owns a 2022 Ford Maverick. The contact stated that after she parked the vehicle, her daughter unlatched the rear passenger's seat belt; however, the shoulder strap that she had placed behind her was twisted and inadvertently retracted. The seat belt then seized while tightly wrapped around the contact's daughter's waist, causing her breathing difficulty. The contact had to cut the rear passenger's seat belt with a scissor to release her daughter. The contact's daughter sustained bruising on her stomach and waist; however, medical attention was not received. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was 34,115.
- Showing the 5 most recent of 6.
- Wheels5
- Filed Sep 2026 · Also filed under Power Train, Engine
Engine long block assembly needed replacement. TPMS continues to fail. Axles make vehicle shake when going freeway speeds.
- Filed Dec 2025
The contact owns a 2022 Ford Maverick. The contact stated that while her son was driving approximately 60-65 MPH on the Interstate, the passenger’s side front wheel detached. There were no warning lights illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 40,000.
- Filed Aug 2025 · Also filed under Power Train
Both right and left cv axle joints had a rough spot in the bearing. Both had to be replaced in November 2023. Now (August 2025), the same issue is happening again. Current mileage as of 8/24/25 is 35,844. Calling dealer to schedule repair first thing Monday morning.
- Filed Jun 2025 · Also filed under Power Train
This issue has been going on for a few months now and is getting worse. When accelerating, usually around the 50 - 60 MPH range, the vehicle begins to shake pretty violently. We had tires balanced and the front end aligned. No change. Mechanic feels like it an axle or CV boot issue.
- Filed Jan 2025 · Also filed under Suspension
Vehicle shakes and vibrates at speeds 55 to 65 or under rapid acceleration. Took it into Ford dealership and charged with a wheel alignment. Didn’t change the situation. Noticed on Facebook Maverick group about cv axles wearing. Told this was the issue. Ford does not have replacements and still waiting since October 2024 for repairs to be made. Still not repaired and not sure if what to do if I’m still driving the vehicle.
- Visibility/Wiper4
- Filed Sep 2025
Never in all my years of driving have I or anyone i know experienced a vehicle with such a sensitive windshield that cracks with even minimal impact. I've owned this Ford maverick for under 3 years with 3 chip repairs and 2 replacements. This is unfair to consumers as often we are not aware of this issue until it is too late to change undo the purchases on these vehicles and have to drive faulty vehicles. It's surprising that there's no recall already assessed for something that causes customers to have higher insurance premiums, constant damage that affects visibility and causes some to drive with these defects to avoid extra costs and wasted money. I am hopeful you can assist us consumers in having Ford rectifying these issues at no cost to us as their choice to use defective windshield glass has cost all of us. This issue is widely known by owners and discussed on social media forums in abundance. Dealers are aware of this issue and offer nothing but an attempt to purchase other vehicles. Minimal research on the internet provides an abundance of evidence. I thank you for your time and assistance in advance for this issue.
- Filed Oct 2024 · Also filed under Electrical System, Exterior Lighting
My license plate light has stopped working. It was replaced and still isn’t working. This reduces visibility and increases risk of a crash. This is in addition to the legal requirement to have an operating license plate light.
- Filed Mar 2024
My vehicle was parked in a secure parking garage at work. I came out from work and noticed a hairline crack in the windshield. I took it to Safelite seeking to have it repaired and was told the entire windshield needed replaced and the windshield was “thin” and “dangerous”
- Filed Jun 2022
I am concerned about the ability of the windshield to protect drivers from road hazards. It appears that almost every stone that is propelled by other vehicles cause a star chip on the windshield and then proceeds to crack. I am afraid this will weaken the windshield and a larger projectile may not be stopped. I was informed that this vehicle has a special windshield to reduce noise. With cost cost of recalibrating the safety systems, no one can afford to replace the windshield evert 10000 miles.
- Hydraulic31 involved a crash
- Filed Sep 2026 · Also filed under Service Brakes
The contact’s husband who owns a 2022 Ford Maverick. The contact stated that while her husband was reversing to complete a 3-point turn, the brakes failed to respond while the brake pedal was depressed, causing the vehicle to drive into a ditch and then crashed into a large boulder alongside the driveway. The contact stated that the pre-crash alert illuminated prior to the crash. The rear passenger's side bumper was damaged, and wires were hanging down. The vehicle was towed to a dealer, where the contact was informed that no brake failure was found. The contact stated that the insurance company had inspected the vehicle. The driver had emotional distress and might have sustained a bruise. The failure mileage was approximately 46,100.
- Filed Jun 2024 · Also filed under Service Brakes
The contact owns a 2022 Ford Maverick. The contact stated while driving 35 MPH, the accelerator pedal was depressed; however, the vehicle failed to accelerate as needed. The contact stated that the message “Engine Power Reduced” was displayed. Additionally, the contact stated that the “BRAKE” warning light illuminated; however, due to the failure the computer system generated the failure code in error. The vehicle was taken to the dealer where it was diagnosed as a fractured well in the braking system. The contact was informed that the braking system needed to be replaced. The vehicle was not repaired. The contact was informed that the parts needed to be ordered to perform the repair. The manufacturer was made aware of the failure. The failure mileage was approximately 56,000. The VIN was unavailable.
- Filed May 2023 · Also filed under Service Brakes, Exterior Lighting, Air Bags
The contact owns a 2022 Ford Maverick. The contact received notification of NHTSA Campaign Number: NHTSA Campaign Number: 22V594000 (Air Bags) and 22V730000 (Exterior Lighting, Service Brakes, Hydraulic) however, the parts to do the recall repairs were not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
- Seats31 involved a crash · 1 involved a fire
- Filed Sep 2024 · Also filed under Electrical System
Front passenger seat, seat heating element malfunctioned - created a small fire and smoke produced. Dealership diagnosed as 'a couple of hot spots that burned through the cover.' It is available for inspection. Fire hazard caused burn on passenger, smoke inhalation. Smoke/fire started while driving at 55mph, resulted in sudden breaking and pulling off the road. Yes, the dealer found hot spots that caused the burning - but take no responsibility for the issue as that car has 56000 miles. No, it has only been inspected by Ford dealership. No warning lamps, no symptoms until physical burning sensation prior to the smoke/fire.
- Filed Feb 2024 · Also filed under Seat Belts
What component or system failed or malfunctioned? It’s not exactly failed or malfunctioned as much as it is just a flawed design. However, the problem is that the drivers seatbelt keeps getting wrapped up in the lever to recline the seat. This results in the handle getting pulled off of the seat constantly, the seat unexpectedly reclining when the driver pulls on the seatbelt too hard, or the seatbelt simply getting bunched up in the handle causing it to just become stuck and non functional. Is it available for inspection upon request? It is available for inspection anytime. How was your safety or the safety of others put at risk? When the drivers seat suddenly reclines or the seatbelt fails to engage due to being caught up in another component of the vehicle that’s a problem. Has the problem been reproduced or confirmed by a dealer or independent service center? No although I can duplicate that issue. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No.
- Filed Mar 2023
I was rear-ended while stopped at a red-light by an inattentive driver. The resulting impact cause the power driver's seat to drop to the end if it's track and the backrest to drop down onto the rear bench. If there was a passenger behind me at the time of the accident, they would have been crushed by the seat with the headrest potentially crushing their chest, while their legs would have been crushed due to the seat suddenly sliding so far back. Motors in seat still function, but cannot move seat. When attempting to lower the backrest a clicking noise can be heard.
- Engine And Engine Cooling3
- Filed Aug 2024 · Also filed under Exterior Lighting, Electrical System
See attached document for complaint
- Filed Mar 2023 · Also filed under Air Bags, Engine
The contact owns a 2022 Ford Maverick. The contact stated that the check engine warning light was illuminated. The contact stated that while driving, the vehicle was running rough. The contact received notification of NHTSA Campaign Number: 22V594000 (Air Bags) however, the part to do the recall repair was not yet available. The vehicle was taken to the local dealer and was diagnosed with engine and exhaust failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was approximately 8,000. Parts distribution disconnect.
- Filed Aug 2022 · Also filed under Structure, Electrical System
The contact owns a 2022 Ford Maverick. The contact stated while driving approximately 35 MPH, the check engine warning light illuminated. The contact stated that the vehicle decelerated as if the transmission was slipping. The contact pulled into his residence driveway when he noticed smoke coming from under the hood. The contact opened the hood and a large amount of gray smoke coming from the engine compartment. The contact used a garden hose to put out the smoke. The contact stated that he never saw a flame; however, he smelled the odor of burnt plastic. The contact stated the vehicle then failed to start-up. The contact had the vehicle towed to a local dealer where it was diagnosed and determined that the 300 AMP fuse was burnt and needed to be replaced. The vehicle had not been repaired. The manufacturer had been informed of the failure. The contact stated that he received a letter from the manufacturer for NHTSA Campaign Number: 22V484000 (Engine and Engine Cooling, Structure). The failure mileage was approximately 4,700.
- Tires2
- Filed Aug 2024
I ordered my truck with all terain tires, they installed Falken wildpeak A/T AT3W 235 65R 17 tires.When me vehicle sits for a while (especially when its cold out) .I get a vibration for the first few miles down the road then it goes away. I have taken it to the dealer they are blameing the issue on the Falken tires,they said these tires develop a flat spot after sitting for a while. So they didnt think it was going to hurt my vehicle so they where not going to replace them.Seeing how I paid extra for all terrain tires and they installed these tires I don't think that was the correct action on there part.
- Filed May 2024
while highway driving on a 350 mile trip on several different paved surfaces including interstate highway the weather conditions were dry to torrential rain and light rain. The tires in question were hydro planing at speeds over 45 miles per hour on wet pavement and the truck was unstable unless speed was reduced. The tires were OEM on this truck and the trip occurred from 17,900 miles to 18,250 miles. There is approx 6/32 of tread remains on the tires. The tires were replaced upon return with a more suitable all season tire. The tires in question are continental pro contact tx, 225/65 r 17, 102H. They are designated all season and stamped M&S as well. These are unsafe for the reason listed above.
- Firerelated1
- Filed Mar 2024 · Also filed under Exterior Lighting, Engine
See attached document for complaint
- Fuel System1
- Filed Jan 2024 · Also filed under Gasoline
The contact owns a 2022 Ford Maverick. The contact stated that the vehicle would not properly accelerate from a stationary position and the check engine warning light remained illuminated. The vehicle was taken to the local dealer who diagnosed that the EVP Emissions Control System and the purge valve were faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure. The failure mileage was 43,000.
- Gasoline1
- Filed Jan 2024 · Also filed under Fuel System
The contact owns a 2022 Ford Maverick. The contact stated that the vehicle would not properly accelerate from a stationary position and the check engine warning light remained illuminated. The vehicle was taken to the local dealer who diagnosed that the EVP Emissions Control System and the purge valve were faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure. The failure mileage was 43,000.
- Latches/Locks/Linkages1
- Filed Jan 2023
I was working on my vehicle, when I close the hood. Upon closing, I heard something, I go to open, and the hood latch is stuck closed, not sure if that's a safety concern, but it was for me, as I could not access any important components of my vehicle, took it to the dealer, but still something of concern on a new vehicle.
Safety ratings
NHTSA 5-Star Safety Ratings from government crash tests. Ratings differ by cab style and 2WD/4WD, so check the row that matches the truck. Source: nhtsa.gov/ratings.
| Version | Overall | Front | Side | Rollover |
|---|---|---|---|---|
| Ford Maverick 4WD | 4/5 stars | 5/5 stars | 5/5 stars | 4/5 stars |
| Ford Maverick FWD | 4/5 stars | 5/5 stars | 5/5 stars | 4/5 stars |
| Ford Maverick HEV FWD | 4/5 stars | 5/5 stars | 5/5 stars | 4/5 stars |